MAHARASHTRA POLLUTION CONTROL BOARD · 1 Chairman 2 Member 3 Member 4 Member 5 Member 6 Sp. Invitee...
Transcript of MAHARASHTRA POLLUTION CONTROL BOARD · 1 Chairman 2 Member 3 Member 4 Member 5 Member 6 Sp. Invitee...
1 Chairman
2 Member
3Member
4 Member
5 Member
6 Sp. Invitee
Shri V. M. Motghare, Joint Director (APC)
MAHARASHTRA POLLUTION CONTROL BOARD
Minutes of 9th Consent Committee Meeting of 2017-2018 held on 06.02.2018 at 11:30 a.m. at 3rd Floor, Kalpataru Point, Chamber of Hon'ble Member
Secretary, Mumbai - 22.
……….
The following members of the Consent Committee were present:
Dr. P. Anbalagan, IAS, Member Secretary
Maharashtra Pollution Control Board, Mumbai
Shri. R. G. Pethe
Retired WPAE, MPC Board
Shri Shri P. K. Mirashe, Assistant Secretary
(Technical)
Maharashtra Pollution Control Board, Mumbai
Chairman of the committee welcomed the members of the committee and allowed proceeding of the meeting to start. The minutes of the 8th Consent
Committee meeting of 2017-18 held on 18.12.2017 & 20.12.2017 Circulated under Board’s letter No. MPCB/AS (T)/TB/B- 4875 dated 02.01.2018 were
confirmed.
Maharashtra Pollution Control Board, Mumbai
Shri Y.B. Sontakke , Joint Director (WPC)
Maharashtra Pollution Control Board, Mumbai
Shri A. R. Supate, Principal Scientific Officer,
Maharashtra Pollution Control Board, Mumbai
Shri N. N. Gurav, Reginal Officer (HQ), Sp. Invitee was absent, leave of absence was granted to him.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 1
Sr.
No.UAN No. Name of Industry & Address
Decision on
grant of
consent
Consent
granted uptoSection Remarks/ Discussion (1)
Operate
1
MPCB-
CONSENT-
0000031386
DEEPAK NITRITE LIMITED
(PLOT NO. K-9 & K-10,MIDC
TALOJA,DISTRICT-RAIGAD
Approved
Consent to
Operate
28.02.2019 AS(T)
The committee noted PP has obtained Environmental
Clearance from MoEF & CC vide No. F.No. J-
11011/367/2016-IA-II(I) dated 03/01/2018 for modernization
with change in product mix of existing manufacturing
factory in which 10 nos. of products with total quantity 1440
MT/M is permitted and resubmitted for change in products
including amendment in by product., Hence it was decided
to grant consent to operate, by imposing following
conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of EC conditions and O & M of
pollution control systems. By product change needs
amendment in EC.
After submission of requisite consent fee, if any.
2
MPCB-
CONSENT-
0000031393
Deepak Nitrite Ltd., Plot Nos - 1-
7,26-31,MIDC,Dhatav, MIDC,
Roha, Roha-402116
Approved
Cosnent to
Operate
30.08.2018 AS(T)
The Committee noted that the industry has not carried out
production of products other than consented products. Also,
industry has obtained the Environmental Clearance from
Govt. of India on 02.01.2018 regarding modernization with
change in product mix of existing manufacturing factory and
existing capacity is around 822 MT/M is reduced to 740
MT/M with specific condition of fresh water requirement is
restricted up to 420 CMD., hence it was decided to grant
amendment for change in products as per EC dtd.
02.01.2018 with overriding effect on existing consent which
us valid up to 30.08.2018 by imposing following condition:
(i) PP shall obtain amendment in Environment Clearance
for By-products within three months period.
(ii) PP shall submit Bank Guarantee of Rs. 5 lakh towards
O & M of pollution control systems.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 2
3
MPCB-
CONSENT-
0000030665
Astoria Agro and Allied
Industries Pvt Ltd., 102-113,
234-243 Samsherpur
(Nandurbar Shahada Road)
Nandurbar Approved
Consent to
Renewal
31.07.2018 WPC
The committee noted that industry is CREP complied but
JVS analysis results are exceeding the consented
standard, hence it was decided to grant renewal of consent
for 2500 TCD Sugar unit, by imposing following conditions:
(i) Forfeit Bank Guarantee of Rs. 2.5 lakh out of Rs. 5 lakh
and top-up with Rs. 5 lakh as JVS are exceeding consented
standards, so as to make total Bank Guarantee of Rs. 7.5
lakh towards O & M of pollution control systems.
4
MPCB-
CONSENT-
0000033833
Enpro Industries Pvt. Ltd. Gat
No.215/3,216/2,218/1&2,219/1
&2,214/2 Alandi-Markal Road,
Tal- Khed, Dist -Pune
Not Approved
Consent to
Operate
______ APC
It was decided to issue SCN for refusal of consent to
operate on following non-compliances:
(i) Not submitted clarification towards increased in CI. From
Rs. 50.42 Crs. To 60.37 Crs.
(ii) Not provided scrubber to pickling section.
(iii) Started Construction work for expansion without
obtaining consent to establish and earlier
also industry has started picking activity without consent
and for that they have submitted Board resolution.
5
MPCB-
CONSENT-
0000033735
Melog Speciality Chemicals Pvt.
Ltd., N-5 Additional MIDC,
Anand Nagar Ambernath, Dist-
Thane
Approved
Consent to 1st
Consent to
Operate for
expansion with
amalgamation of
existing consent
30.09.2020 AS(T)
The committee noted that existing unit having valid consent
to operate which is valid up to 30/9/2020 for mfg. of
Speciality Chemicals. Industry has also obtained consent to
establish for expansion within existing premises on
08/9/2017 for mfg. of Speciality Chemicals. Unit has
obtained Environmental Clearance on 21/9/2016 which
includes existing consented
products & expansion products. hence it was decided to
grant 1st consent to operate for expansion with
amalgamation with existing consent with ZLD conditions, by
imposing following conditions:
(i) Industry shall achieve ZLD and submit Bank Guarantee
of Rs. 5 lakh towards compliance of same.
(ii) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
6
MPCB-
CONSENT-
0000032274
Vardhan Agro Processing Ltd.,
Gat No. 644/1 A/P- Trimali Tal.
Khatav Dist Satara
Consent to
1st Operate31.07.2018 WPC
It was decided to grant consent to 1st operate for Khandsari
Sugar -- 1000 MT/Day & Co-generation unit- 14 MW, by
imposing following conditions:
(i) Industry shall install CPU within 3 months and submit
Bank Guarantee of Rs. 5 lakh towards compliance of same.
(ii) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 3
7
MPCB-
CONSENT-
0000035008
Mosdorfer India Pvt. Ltd., Gat
No. 196/ 1 and 2, Village Gonde
Dhumala, Near Lear
Corporation,
Taluka Igatpuri, District - Nashik
Not Approved
Consent to
Establish
_____ APC
It was decided to keep the case in abeyance and put up in
next CC after obtaining clarification regarding location of
the industry, as the area is catchment area.
8
MPCB-
CONSENT-
0000033519
CIDCO's 70 MLD high Tech
STP on SBR Technology at
Sector 16 Kharghar, Navi
MUmbai
Approved
Consent to
Operate
31.03.2019 WPC
The committee noted that CIDICO has applied for consent
to Establish and Operate for 70.00 MLD sewage collection,
treatment, and disposal of sewage, STP located at Sec-16,
kharghar, and CIDCO has adopted SBR Technology for
treatment of sewage. Hence, it was decided to grant
consent to establish and operate for 70 MLD STP, by
imposing following conditions:
(i) PP shall achieve BOD -10 mg/l standard.
(ii) PP shall install online monitoring system within 3
months.
(iii) PP shall submit Bank Guarantee of Rs. 5 lakh towards
compliance of consent conditions.
9
MPCB-
CONSENT-
0000035460
Lupin Ltd., Plot No.6A & 6B
Sector-17 SEZ MIHAN Notified
area, Nagpur 441108 MIHAN
Nagpur Nagpur
Not Approved
amalgamation of
1st consent to
operate for
Expansion with
existing consent.
_____ AS(T)
It was decided to keep the case in abeyance and put up in
next CC after verification regarding pollution control
systems.
10
MPCB-
CONSENT-
0000035667
Ebco Pvt. Ltd., SURVEY
NO.53, HISSA NO.7/3 & 7/4,
GAURAI PADA, VASAI (E),
DIST - PALGHARNot Approved
Operate_____ APC
The committee noted that industry has applied for 1st
consent to operate for additional production capacity &
amendment in existing consent. Committee also noted that
Source of water consumption is Bore-well NOC from
CGWB is requried. Hence it was decided to issue SCN for
refusal of consent to 1st operate as industry has not
obtained NOC from CGWB for consumption of ground
water.
11
MPCB-
CONSENT-
0000036268
Kansai Nerolac Paints Ltd., Plot
No. W-188/189, Kopar
Khairane, Navi Mumbai - 400
013 Thane
Not Approved
1st Consent to
Operate for R&D
activity without
commercial
activity/productio
n of
experimental
Paint,
Intermediates,
Thinners and
Additives
_____ AS(T)
It was decided to keep the case in abeyance and get
clarification from SRO regarding this plant if this is only an
R & D activity or it is integrated with manufacturing plant.
And are they manufacturing any products and verification
and verification of EC applicability.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 4
12
MPCB-
CONSENT-
0000037797
VISWAAT CHEMICALS
LIMITED, Plot No. N-1
Additional Ambernath, MIDC,
Ambernath (East) Ambernath
Approved
Consent to
Operate
31.03.2020 AS(T)
The committee noted that this is existing unit having
consent to operate which is valid up to 31/3/2020 for mfg. of
Speciality, Textile and Leather Chemicals. Industry have
obtained Environmental Clearance on 28/1/2016 which
includes existing as well as expansion products. hence it
was decided to grant 1s consent to operate mfg. of
Speciality, Textile and Leather Chemicals with ZLD
conditions, by imposing following conditions:
(i) Industry shall achieve Zero Liquid Discharge (ZLD) and
submit Bank Guarantee of Rs. 5 lakh towards compliance
of same.
(ii) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
13
MPCB-
CONSENT-
0000038010
Godavari Pulp and Paper Mills
Pvt. Ltd., Gut No.405 Vill.
Lakhmapur, Tal. Dindori, Dist.
Nashik. Dindori
Not Approved
Amalgamation of
renewal of
existing consent
with consent to
first operate
_____ WPC
The committed noted that industry has applied for combine
consent to Operate for the production Kraft paper 6000
MT/M (Existing consent to operate for the production of
Kraft paper 4500 MT/M is valid upto 31.03.2018) and
consent to Operate for 1500 M/T from 4500 MT/M. It was
also noted that Industry is discharging boiler blowdown to
nearby area. Hence it was decided to issue SCN for refusal
of Amalgamation of renewal of existing consent with
consent to first operate, on following non-compliances:
(i) Industry is discharging boiler blowdown to nearby area.
(ii) Environment statement for current year not provided.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 5
Establish
1
MPCB-
CONSENT-
0000011852
Datar Genetics Limited, F-8, D-
Road, MIDC, Ambad,,F-8, D-
ROAD, MIDC, AMBAD,
NASHIK.
Not Approved
Combined
Consent & BMW
Authorization ,
Consent to
Establish
_____ PSO
It was decided to issue SCN for refusal of CCA Establish,
on following non-compliances:
(i) Water consumption is 41 CMD however effluent
generation is not submitted.
(ii) PP has not provided ETP & STP.
(iii) Online BMW authorisation application is not submitted.
Category and quantity of BMW is required as per New
Rule, 2016.
2
MPCB-
CONSENT-
0000024857
Aarti Industries Ltd., Plot No.- K-
17/18/19, M.I.D.C. Tarapur,
Boisar
Not Approved
Consent to
Establish
_____ AS(T)
The committee noted that Unit is located in MIDC Tarapur
where Hon’ble NGT passed an order on 09/9/2016 not to
consider the new establishments /expansions in the
application no. 64/2016 filed by Akhil Bhartiya Mangela
Samaj. Being aggrieved by this order M/s. JSW steel
coated products ltd.
located in MIDC Tarapaur filed W.P. 4777/2017 & Hon’ble
High court passed an order on
02/5/2017 & directed MPCB to grant NOC/consent in
accordance of the Water & Air Act, having
ZLD.
It was decided to issue SCN fore refusal of consent to
establish for enhance the production quantity of some of
the product and introduction of additional
products, on following non-compliances’:
(i) industry has failed to provide Zero Liquid Discharge
(ZLD) for the total project i.e. existing and expansion.
3
MPCB-
CONSENT-
0000025598
IRAA Clothing Pvt.Ltd., Plot
No.B-7/3 M.I.D.C.,Tarapur-
Boisar Palgher
Final Refusal of
consent to
Establish
_____ WPC
The committee noted that consent application is to add
capital investment proposed for upgradation of existing
ETP plant without increasing in garment activity or
consumption of water or fuel consumption, but in the
applied consent they have spilt the production quantity in
two parts I. readymade garment from 13,50,000 to
18,50,000 nos/year and garment washing 13,50,000 will
remain
same. Hence it was decided to issue final refusal of
consent for expansion activity.
Industry should apply for stitching activity separately.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 6
4
MPCB-
CONSENT-
0000025879
Sujan CooperStandard AVS
PVT. LTD., F-11,PHASE-3
CHAKAN MIDC KHED
Not Approved
Consent to
Establish
_____ APC
It was decided to issue SCN for refusal for consent to
establish expansion for Rubber Moulded Products, rubber
bounded products, on following non compliances:
(i) Industry has not submitted proper water budget for
proposed expansion.
(ii) Industry has not submitted details of ETP & STP
provided for proposed expansion.
(iii) Industry has not submitted clarification towards
diffidence in CI as per application & CA certificate
submitted.
(iv) Industry has not submitted B.G. of Rs.1,00,000/-
towards O & M of PCS as per the condition of earlier
consent granted.
(v) Industry has failed to reply to the query letter issued by
SRO.
5
MPCB-
CONSENT-
0000026657
PRECISION METALS, 253 AT -
ATAKARGAON, POST -
SAJGAON KHOPOLI, TAL -
KHALAPUR, DIST - RAIGAD
Not Approved
Conent to
Establish
_____ APC
It was decided to keep the case in abeyance and put up in
next CC after obtaining clarification from categorisation
committee.
6
MPCB-
CONSENT-
0000005406
Sai Fertilizers & Phosphates
Pvt. Ltd., N-45 Additional
Ambernath MIDC, Ambernath
Not Approved
Conent to
Establish for
Expansion
_____ AS(T)
The committee noted that Unit is located in Addl.
Ambernath MIDC Area where new
establishment/expansion is not permitted unless no
pollution potential or ZLD as per the Board circular dated
21/9/2015. Hon’ble NGT (WZ) passed an order on
01/5/2017 in Application No. 3/2017(WZ) in which granted
liberty to the MPCB to consider the proposals of industries
in terms of modified directions of CPCB dated 31/03/2016.
where is no additional load to CETP/ZLD.
It was decided to issue SCN for refusal of consent to
establish for expansion and stop work as industry has not
provided Zero Liquid Discharge (ZLD)
7
MPCB-
CONSENT-
0000026803
RAN CHEMICALS PVT LTD.,
45 Mouza Khapri PO- Kalambi
Kalmeshwar Nagpur
Approved
Consent to
Establish
Commissionin
g of the unit or
5 yrs
whichever is
earlier
AS(T)
It was decided to grant consent to establish for in existing
unit for mfg of Synthetic organic chemical with ZLD
conditions:
(i) Industry shall not take any effective steps prior to
obtaining Environment Clearance for expansion activity.
(ii) Industry shall provide Zero Liquid Discharge (ZLD)
before applying for 1st consent to operate for expansion.
(iii) Industry shall obtain NOC from CGWB/Irrigation
Department for utilization of ground water/ surface water.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 7
8
MPCB-
CONSENT-
0000029586
Cosma International India Pvt
Ltd., Plot No A 12 MIDC
Talegaon Maval
Approved
Consent to
Establish
Commissionin
g of the unit or
5 yrs
whichever is
earlier
APC
It was decided to grant consent to establish for for
expansion for production of Automobile press Parts &
Assembly Die Washing Activity from 918720 Nos/Month to
928720 Nos./Month i.e 10000 Nos/Month with increased in
capital investment from Rs. 474.53 Crs. to 590.36 crs. i.e by
Rs.115.83 crs., by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
9
MPCB-
CONSENT-
0000031248
OMINIACTIVE HEALTH
TECHNOLOGIES LIMITED,
PLOT NO-38,39 & 5 C IBT
PARK ,PHASE -II HINJEWADI
MULSHIApproved
Consent to
Establish
Commissionin
g of the unit or
5 yrs
whichever is
earlier
AS(T)
The committee noted the material balance submitted by the
unit on 06.11.2017,
accordingly, there is no chemical reaction involved because
this process is formulation process. hence it was decided to
grant consent to establish expansion for Lutein Beadlet
9000 Kg/M., by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
10
MPCB-
CONSENT-
0000030708
Kider India Pvt. Ltd., Gat No.
584/2 Gat No. 584/2, Koregaon
Bhima, Tal:- Shirur, Dist:- Pune
412216
Approved
Consent to
Establish
Commissionin
g of the unit or
5 yrs
whichever is
earlier
APC
It was decided to grant consent to establish for expansion
of existing storage Ware House by 12886.39 Sq. meter., by
imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
11
MPCB-
CONSENT-
0000031847
Warkem Biotech Pvt Ltd., Plot
No N36 Additional Ambernath
M.I.D.C. Ambernath, Dist-
ThaneApproved
Consent to
Establish for
Expansion
Commissionin
g of the unit or
5 yrs
whichever is
earlier
AS(T)
It was decided to grant consent to establish expansion for
mfg Protein Hydrolysate Powder, Bio Fertilizers & Organic
Fertilizers – 101 MT/M and Protein Sludge – 25 MT/M, with
ZLD conditions and by imposing following conditions:
(i) Industry shall not take any effective steps prior to
obtaining Environment Clearance and submit Bank
Guarantee of Rs. 5 lakh towards compliance of same and
consent conditions.
(ii) Industry shall achieve Zero Liquid Discharge (ZLD) by
installing MEE of 1.6 MT/hr capacity.
12
MPCB-
CONSENT-
0000032788
Aurangabad Distillery Ltd,
45,47,48,50 Rangoan Road ,
Walchandnagar Indapur Approved
Consent to
Establish for
Expansion
Commissionin
g of the unit or
5 yrs
whichever is
earlier
WPC
It was decided to grant consent to establish expansion for
recovery of salt (Potash) form spent effluent, by imposing
following conditions:
(i) Industry shall include activity of recovery of salt (Potash)
from the effluent in Environment Clearance and submit
Bank Guarantee of Rs. 5 lakh towards compliance of same
and consent conditions.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 8
13
MPCB-
CONSENT-
0000032916
A.R.SULPHONATES
PVT.LTD., N-41 Additional
MIDC, Anandnagar,Ambernath
(E)
Approved
Consent to
Establish for
Expansion
Commissionin
g of the unit or
5 yrs
whichever is
earlier
AS(T)
It was decided to grant consent to establish expansion for
mfg. of Linear Alkyl Benzene Sulphonic Acid-7680 MT/M &
Sulphuric Acid -1500 MT/M. subject submission of material,
by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
(ii) Industry shall not take any effective steps prior to
obtaining Environment Clearance and submit Bank
Guarantee of Rs. 5 lakh towards compliance of same.
(iii) Industry shall achieve Zero Liquid Discharge (ZLD)
14
MPCB-
CONSENT-
0000032719
Galaxy Surfactants Ltd., M-3 M-
3, MIDC Tarapur Palghar
Approved
Amendment in
existing consent
for installation of
ZLD
31.10.2021 AS(T)
The committee noted that existing unit having valid consent
to operate up to 31/10/2021 for mfg. of speciality chemicals.
Hence, it was decided to grant amendment in existing
consent with Zero Liquid Discharge (ZLD) by installation of
plant of capacity 15.6 CMD including MEE salts generated
@ 1.8 MT/M. and the disposal path of treated effluent as
NIL instead of disposal to CETP, by imposing following
conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
(ii) Industry shall install camera, flow meter & separate
energy meter and submit Bank Guarantee of Rs. 5 lakh
towards compliance of same.
15
MPCB-
CONSENT-
0000033447
Indian Oil Corporation Ltd.
(LPG Bottling Plant), S. No. 55
& 56 On SH 199, Dhanaj Khurd
Karanja Lad Approved
Consent to
Establish
(Expansion)
Commissionin
g of the unit or
5 yrs
whichever is
earlier
AS(T)
It was decided to grant consent to establish expansion for
increase in production quantity of L.P.G Bottling &
additional new activity i.e. Cylinder testing and Painting, by
imposing following conditions:
(i) Industry shall provide adequate ETP for Paint Booth
Effluent and Water Curtain as APC for Paint Booth and
submit Bank Guarantee of Rs. 5 lakh towards compliance
of same.
16
MPCB-
CONSENT-
0000035305
Just Textiles Ltd., Anand Nagar-
Additional Ambernath MIDC
Indl. Area Anand Nagar-
Additional Ambernath MIDC
Not Approved
Consent to
Establish
_____ WPC
It was decided to keep the case in abeyance and put up in
next CC after obtaining TAC committee with RO(HQ),
JD(WPC), AS(T) & PSO report regarding adequacy of
effluent treatment system provided by the unit and water
budget.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 9
17
MPCB-
CONSENT-
0000035732
KSPG Automotive India Private
Ltd., Gat No. 380 Gat No. 380,
Village Takwe Budruk , Taluka:
Vadgoan Maval , District Pune Approved
Consent to
Establish
Commissionin
g of the unit or
5 yrs
whichever is
earlier
APC
It was decided to grant consent to establish expansion for
increase in production Automotive Valves from 79000
Nos/Month to 2,47148 Nos/M 9 i.e. increased by 168148
Nos/Month) with proposed additional C.I. Rs. 237.17 Crs.,
by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
18
MPCB-
CONSENT-
0000037695
Britannia Industries Limited, B
28 Plot NoMIDC Ranjangaon
Industrial Area. Shirur Not Approved
Consent to
Consent to
Establish
_____ WPC
It was decided to issue SCN for refusal of consent to
establish, on following non-compliances:
(i) CETP does not have further capacity to accommodate
effluent.
(ii) CETP is not properly functioning.
(iii) Industry has not submitted Zero Liquid Discharge (ZLD)
proposal.
19
MPCB-
CONSENT-
0000037319
Dairy Power Ltd., Gat No. 555
Songaon, Post - Saikheda, Tal -
Niphad, Dist Nashik
Approved
Consent to
Establish
Expansion
Commissionin
g of the unit or
5 yrs
whichever is
earlier
WPC
It was decided to grant consent to establish expansion for
the production of Milk Powder, Butter, Pasteurized Milk,
Cream, Paneer, Shrikhand, Curd, Lassi, Ghee, Khoya, by
imposing following conditions:
(i) Industry shall achieve 30 mg/ltr BOD as disposal on 15
acres’ land.
(ii) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
(iii) Industry shall obtain NOC from CGWA/ irrigation
department for utilization of ground water/surface water.
20
MPCB-
CONSENT-
0000038112
VAISHNO DEV FOOD
PRODUCTS PVT LTD., S. NO.
35 VILLAGE BABHALGAON
POST - ITKAL TULJAPUR,
Babhalgaon, OsmanabadApproved
Consent to
Establish
Expansion
Commissionin
g of the unit or
5 yrs
whichever is
earlier
WPC
It was decided to grant consent to establish for expansion
of Proposed products viz, Raw Milk Processing- 60,000000
Lit/M, Market milk-1950000 Lit/M, Butter– 150 Ton/M, Ghee-
90 Ton/M, SMP/WMP/DW -300 Ton/M, curd-1035 Ton/M,
flavoured milk-75000- Ltr/M, Paneer-150 Ton/M, Cheese-
30Ton/M and Ice cream 60,000 Ltr/M, by imposing following
conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
(ii) Industry shall obtain NOC from CGWA/ irrigation
department for utilization of ground water/surface water.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 10
21
MPCB-
CONSENT-
0000038042
EMUGE - FRANKEN INDIA
PRIVATE LIMITED, Gat No.
91,92,93 and 128 At Post
Kondhanpur Haveli
Approved
Consent to
Establish
Expansion
Commissionin
g of the unit or
5 yrs
whichever is
earlier
APC
It was decided to grant consent to establish expansion for
production of Nitrided Cutting Tool: 60000 Nos/Year, Black
Oxidized Tap Holder Parts/Tool Holder parts: 20000
Nos/Year and Shot Blasted tap Holder parts/tool holder
parts: 2000 on existing selected production with increased
in capital investment from Rs. 38.26 Crs. to 53.15 crs. i.e by
Rs.14.89 crs., by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
(ii) Industry shall recycled/reused treated effluent in process
and disposed ETP sludge to CHWTSDF.
(iii) Water source to be verified.
22
MPCB-
CONSENT-
0000037184
Hindustan Petroleum
Corporation Limited ( LPG
Filling Plant) Plot No- G-6 MIDC
Malegaon Sinnar Approved
Consent to
Establish
Expansion
Commissionin
g of the unit or
5 yrs
whichever is
earlier
AS(T)
It was decided to grant consent to establish expansion for
additional production for Filling of LPG in to Cylinder -
10000 MT/M with additional C.I. 12.50 Cr., by imposing
following conditions:
(i) Industry shall provide ETP/ STP and APC for paint booth
(water contain), and lease detection system with alarm.
(ii) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
Renewal
1
MPCB-
CONSENT-
0000009401
Ballarpur Opencast Mine, 284
285 286 287 288 289 290 near
ballarpur town BallarpurApproved
Consent to
Renewal
30.06.2021 APC
It was decided to gran renewal of consent with expansion
for additional production capacity i.e Coal – 0.625 Million
Ton/Year (existing consented quantity 0.5 Ton/Year) and CI
of Rs. 25.00 Cr. By imposing following conditions:
(i) Bank Guarantee regim for mines.
Consent to be issued with conditions decided in CAC
meetings.
2
MPCB-
CONSENT-
0000015310
Asian paints Ltd., Plot No. 3/2
MIDC, Taloja, Tal- Panvel, Dist-
Raigad Approved
Consent to
Renewal
31.12.2020 AS(T)
It was decided to grant renewal of consent for mfg of paints,
enamels, varnished & thinner with increase in capital
investment, by imposing following conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
After obtaining requisite consent fee, If any.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 11
3
MPCB-
CONSENT-
0000021756
Anand Teknow Aids
Engineering India Ltd., A-18, 5
Star MIDC Indapur Loni Devkar
Indapur
Approved
Consent to
Renewal
28.02.2021 APC
It was decided to grant renewal of consent to operate with
increased capital investment from Rs. 8.10 Crs to 39.61
Crs., by imposing following conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
(ii) Industry shall submit Board Resolution for increase in
capital investment without obtaining prior permission from
the Board and submit Bank Guarantee of Rs. 2 lakh
towards compliance of same before issue of consent.
(iii) Industry shall submit permanent Bank Guarantee of Rs.
25 lakh towards not to do any violation in future.
After obtaining requisite consent fee, If any.
Consent shall be issued after obtaining Bank Guarantees.
4
MPCB-
CONSENT-
0000018902
Cosma International India Pvt.
Ltd., Plot No A-12, Talegaon
MIDC Village - Navlakh Umbre
Maval
Approved
Consent to
Renewal
28.02.2021 APC
It was decided to grant renewal of consent to operate with
increased in production quantity and capital investment, by
imposing following conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
(ii) Industry shall submit Board Resolution for increase
production without obtaining prior permission from the
Board and submit Bank Guarantee of Rs. 2 lakh towards
compliance of same.
(iii) Industry shall submit permanent Bank Guarantee of Rs.
25 lakh towards not to do any violation in future.
After obtaining requisite consent fee, If any.
Consent shall be issued after obtaining Bank Guarantees.
5
MPCB-
CONSENT-
0000024882
Ultra Engineers (Unit IV),
Sector No. 10, Plot No. 58
PCNTDA, Bhosari Haveli NotApproved
Consent to
Renewal
_____ APC
It was decided to issue SCN for refusal of consent to
renewal with expansion and stop work, on following non-
compliances:
(i) Industry has increase capital investment and production
capacity without obtaining C to E from Board.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 12
6
MPCB-
CONSENT-
0000024775
Jabil Circuit India Pvt. Ltd., B-
26,MIDC Ranjangaon,Pune
Ranjangaon MIDC Shirur
Approved
Consent to
Renewal
30.04.2019 APC
It was decided to grant of renewal of consent operate for
SET BOX: 40, 00,000 Nos/Annum and PCB Assembly
82,00,000 Nos/Year with CI of Rs. 396.25 Crs., by imposing
following condition:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
(ii) Industry shall submit Board Resolution for increase
capital investment without obtaining prior permission from
the Board and submit Bank Guarantee of Rs. 2 lakh
towards compliance of same.
(iii) Industry shall submit permeant Bank Guarantee of Rs.
25 lakh towards not to do violation in future.
Consent shall be issue after obtaining Bank Guarantees.
After obtaining requisite consent fee, If any.
7
MPCB-
CONSENT-
0000019494
METALYST FORGINGS LTD.,
Gat No. 251, Chakan -
Talegaon Road, Kharabwadi,
Chakan
Not Approved
Consent to
Renewal with
additional heat
treatment activity
_____ APC
It was decided to issue final refusal of consent and closure
direction, on following non-compliances:
(i) Industry has not provided adequate APC system.
(ii) Forfeit existing Bank Guarantee for non-compliances.
8
MPCB-
CONSENT-
0000025919
S. R. THORAT MILK
PRODUCTS PRIVATE
LIMITED, 21/3/1/2 RAJAPUR
ROAD SANGAMNER Not Approved
Consent to
Renewal
_____ WPC
It was decided to issue SCN for renewal of consent for dairy
unit, on following non-compliances:
(i) JVS are exceeding prescribed consented standards.
(ii) Industry is not achieving BOD 30 mg/l and not submitted
proposal for same.
(ii) Not submitted Bank Guarantee as per earlier consent
conditions.
9
MPCB-
CONSENT-
0000025721
Fairfield Atlas Ltd. (DTA), 157,
Devarwadi village, off. Vengurla
road, Tal.: Chandgad,
Dist.: Kolhapur Not Approved
Renewal of
consent to
Operate with
increase in C.I.
_____ APC
It was decided to issue SCN for renewal of consent on
following non-compliance:
(i) Permission for the treatment of Industrial Effluent (I.E.) &
Domestic Effluent (D.E.) on another location is not obtained
by the unit.
(ii) Hazardous Waste is not treated & disposed regularly.
(iii) APC devices & its control facility is not provided
(iv) Two separate C.A. certificates are submitted for the
single unit.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 13
10
MPCB-
CONSENT-
0000026331
SPM Autocomp Systems Pvt
Ltd., F-32 MIDC Ind. Area,
Ranjangaon, Shirur
Approved
Consent to
Renewal
30.06.2022 APC
It was decided to grant renewal of consent to operate for
manufacturing of Exhaust Manifold, Casting Machine
Component: 1500 MT/Month with increase in CI without
increase in production., by imposing following condition:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
(ii) SRO shall carry out Monthly sampling of ETP for 4
months and submit report.
After obtaining requisite consent fee, If any.
11
MPCB-
CONSENT-
0000023920
PHOENIX MECANO INDIA
PVT. LTD., GAT NO. 388,389
PIRANGUT INDUSTRIAL
ESTATE, BHARE MULSHIApproved
Consent to
Renewal
30.04.2019 APC
It was decided to grant renewal for mfg. of Aluminium die
casting, polyester FRP & powder
coating work, by imposing following conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
After obtaining requisite consent fee, If any.
12
MPCB-
CONSENT-
0000028246
Badve Engineering Ltd., Plot
no. C-11 MIDC Ranjangaon
Shirur, Dist- Pune
Renewal plus C
to O for
additional
products
30.11.2018 APC
It was decided to grant renewal of consent to operate with
amalgamation of 1st consent to operate for expansion for
manufacturing Plastic moulded parts-450 MT/M, engineer
press parts, automobile press parts -600MT/M & powder
coating activity -50,000 Sq.feet/M, by imposing following
conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
(ii) SRO shall carry out Monthly sampling of ETP for 4
month and submit report.
(iii) Industry shall submit Board Resolution for increase
production without obtaining prior permission from the
Board and submit Bank Guarantee of Rs. 2 lakh towards
compliance of same.
(iv) Industry shall submit permanent Bank Guarantee of Rs.
10 lakh towards not to do any violation in future.
After obtaining requisite consent fee, If any.
13
MPCB-
CONSENT-
0000028548
Bharat Petroleum Corporation
Ltd., Plot no 1074, Village-
Sanaswadi, Tal- Shirur, Dist-
PuneApproved
Consent to
Renewal
31.03.2022 AS(T)
It was decided to grant renewal of consent for with increase
in CI by 43.59 Cr. without change in
production quantity, by imposing following conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
After obtaining requisite consent fee, If any.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 14
14
MPCB-
CONSENT-
0000026306
UMASONS AUTO COMPO
PVT LTD., B - 34 MIDC,
WALUJ Gangapur
Approved
Consent to
Renewal
30.06.2019 APC
The committee noted the reply submitted by industry for
SCN.
Hence, it was decided to grant renewal of consent with
increased in capital investment and will not remove
parameter like CN, Cd, Cu, N, Pb, & Cl as
industry is electroplating activity and vide notification
No.GSR 266 (E) dtd. 30/3/2012 MoEFCC
included for electroplating activity, by imposing following
conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
After obtaining requisite consent fee, If any.
15
MPCB-
CONSENT-
0000029301
Prasad Sugar And Allied Agro
Products Ltd.,
912/1/1,912/1/2,913/1/1,913/1/2
,914 & 915 Sade-Vambori Road
Rahuri, Tal:-Rahuri,Dist:-
Ahmednagar.
Approved
Consent to
Renewal
31.07.2018 WPC
It was decided to grant renewal of consent for sugar unit, by
imposing following conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
After obtaining requisite consent fee, If any.
16
MPCB-
CONSENT-
0000029327
IVRCL TLT Private Ltd., Plot
No. A-34 MIDC Industrial Area,
Butibori Hingna
Not Approved
Consent to
Renewal
_____ APC
The committee noted that for manufacturing of Fabrication
of Transmission Line Tower Member, Telecom Tower
Member, Substation Structure/ Railway Structure/Re
structure (with Hot Dip Galvanizing). Unit is member of TLT
Galvanizing Association and till date not install ARP system
to recover acid from spent acid. Hence, it was decided to
issue SCN for refusal for renewal on following non-
compliances:
(i) industry has failed to sent Spent Acid to ARP and yet not
installed ARP.
17
MPCB-
CONSENT-
0000029650
Adamo The Village, Plot No.
63/A, Kasturba Road,
Matheran, Tal. Karjat, Dist.
Raigad. Plot No. 63/A, Kasturba
Road,
Matheran, Tal. Karjat, Dist.
Raigad.
Approved
Consent to
Renewal
31.05.2021 WPC
It was decided to grant renewal of consent for hotel activity
with lodging and Boarding for 38 Rooms without laundry &
swimming pool, by imposing following conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
After obtaining requisite consent fee, If any.
18
MPCB-
CONSENT-
0000028032
Adamo The Resort, Plot No. BP-
10, MG Road, Matheran, Tal.
Karjat, Dist. Raigad Plot No. BP-
10, MG Road,
Matheran, Tal. Karjat, Dist.
Raigad
Approved
Consent to
Renewal
31.05.2021 WPC
It was decided to grant renewal of consent for hotel activity
with lodging and Boarding for 32 Rooms without laundry &
swimming pool, by imposing following conditions:
(i) PP shall submit Bank Guarantee of Rs. 5 lakh towards O
& M of pollution control systems.
After obtaining requisite consent fee, If any.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 15
19
MPCB-
CONSENT-
0000028260
Polybond India Pvt. Ltd., Gat
No. 1087, Sanaswadi, Tal:-
Shirur, Dist:- Pune 412210
Not Approved
Consent to
Renewal
_____ APC
The committee noted that, STP operating partially and
provided bypass arrangement for collection tank, Not
maintained logbook for ETP & STP and has still not
provided scrubber to phosphating plant as per consent
condition no.10. Hence it was decided to issue SCN for
refusal for renewal of consent with stop work, on following
non-compliances:
(i) Industry has increase C.I. from Rs. 22.42 Crs Rs. 34.48
Crs. without obtaining C to E from Board.
(ii) Not provided scrubber to phosphating section as per
earlier consent conditions.
(iii) ETP is not in operation & kept idle condition. The traces
of overflow of effluent from collection
tank.
(iv) JVS results are exceeding prescribed consented
standards.
(v) STP operating partially and provided bypass
arrangement for collection tank.
(vi) Not submitted Bank Guarantee as per earlier consent
conditions.
20
MPCB-
CONSENT-
0000029744
Shri. Ganesh Sahakari Sakhar
Karkhana Ltd., Gut No.55
Ganeshnagar, Rahata
Approved
Consent to
Renewal
31.07.2018 WPC
It was decided to grant renewal of consent for 1750 TCD
sugar unit, by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
(ii) Industry shall install online monitoring system within 3
months and submit Bank Guarantee of Rs. 5 lakh towards
compliance of same.
After obtaining requisite consent fee, If any.
21
MPCB-
CONSENT-
0000030278
AB Mauri India Pvt., D-7/2A
Lote Parshuram- MIDC Khed
Approved
Amendment in
Renewal of
Consent
30.11.2019 WPC
It was decided to grant amendment for additional of two
products i.e. (a) DRY VINASSE(commercial yeast culture)
for animal ration and (b) Vinasse Enrich with molasses for
animal ration., by imposing following conditions:
(i) The industry shall include this activity in their
Environment Clearance within 3 months.
(ii) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
After obtaining requisite consent fee, If any.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 16
22
MPCB-
CONSENT-
0000029065
Shree kranti sugar And power
Ltd., (Unit of Parner Sugar) AT
POST DEVI BHOIRE TAL-
PARNER
DIST-A.NAGAR
Approved
Consent to
Renewal
31.07.2018 WPC
The committed noted, industry has 100 acres of own land is
available for disposal of treated effluent & presently treated
effluent is being discharge on own land. Industry has
provided online monitoring system and also submitted the
revocation order from CPCB dated 16.11.2017.
Hence, it was decided to grant renewal of consent for 1250
TCD sugar unit, by imposing following conditions:
(i) Forfeit Bank Guarantee of Rs. 2.5 lakh as JVS are
exceeding consented standards and top-up with double Rs.
5 lakh, hence to make total Bank Guarantee of Rs. 7.5 lakh
towards O & M of pollution control systems.
23
MPCB-
CONSENT-
0000028430
Polybond India Pvt. Ltd., Gat
No. 144 / 145, Gat No. 144 /
145, Village Dhanore, Tal:-
Khed, Dist:- Pune KhedNot Approved
Consent to
Renewal
_____ APC
It was decided to issue SCN for refusal of consent to
renewal, on following non-compliances:
(i) Industry has increased C.I. from Rs. 16.97 Crs to Rs.
34.97 Crs. without obtaining C to E from Board.
(ii) Not provided scrubber to phosphating section.
(iii) Not submitted B.G. of Rs.50,000/- as per the condition
of earlier consent granted.
24
MPCB-
CONSENT-
0000031158
Kokuyo Camlin Limited, Plot
No: D-2/1 MIDC Tarapur
Palghar Approved
Cosnent to
Renewal with
enhancement in
CI
31.07.2019 AS(T)
It was decided to grant renewal of consent for
manufacturing of Paint Manufacturing with increase in CI by
Rs. 4.22 Crs., by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
After obtaining requisite consent fee, If any.
25
MPCB-
CONSENT-
0000030556
Paramount Minerals &
Chemicals Ltd., Plot No C-6
Ambernath west Ambernath,
Dist-Thane
Approved
Consent to
Renewal
31.08.2022 AS(T)
It was decided to grant renewal of consent for dyes & dye
intermediates mfg. with increase in CI 20.76 and additional
4 new products Rapid wetting agent- 200 MT/M, Acrylic
Polymers (Binders)- 300 MT/M, Poly Vinyl Acetate- 50
MT/M, Ice Flakes- 100 MT/d. Ind., with ZLD conditions, by
imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
(ii) Industry shall achieve Zero Liquid Discharge ZLD by
distillation & MEE.
(iii) Industry shall install online monitoring system within 3
months and submit Bank Guarantee of Rs. 5 lakh towards
compliance of same.
After obtaining requisite consent fee, If any.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 17
26
MPCB-
CONSENT-
0000031105
Automobile Corporation of Goa
Limited, Plot No. F-2 Plot No. F-
2, MIDC Jejuri, Tal:- Purandar,
Dist:- Pune 412303 PurandarApproved
Consent to
Renewal
30.09.2022 APC
It was decided to grant plain renewal of consent for Sheet
Metal Surface Treatment (Motor Vehicle Parts) 865
MT/Month, by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
After obtaining requisite consent fee, If any.
27
MPCB-
CONSENT-
0000031797
Shri Saikrupa Sugar And Allied
Industries Ltd.,
234,334,335,336,337,21 & 20
Devdaithan Shrigonda Not Approved
Consent to
Renewal
_____ WPC
It was decided to issue SCN for refusal of renewal of
consent for 1250TCD sugar & 5.5 MW cogeneration unit,
on following non-compliances:
(i) Industry has not provided online monitoring system to
ETP and stack emission.
(ii) JVS analysis results are exceeding the consented
standards.
(iii) Not provided Wet Scrubber/ESP to stack as per CREP
Norms.
28
MPCB-
CONSENT-
0000031803
Advy Chemical Pvt. Ltd., Plot
No. A334/336/338, Road No.
26,Plot No. A- 337/339, Road
No. 25, Wagle Estate,
Thane,Thane,Thane
Combined
Consent & BMW
Authorization
Consent to
Renewal
31.08.2021 PSO
It was decided to grant combine consent and authorization
to R & D activity by imposing continues bank guarantee.
29
MPCB-
CONSENT-
0000030681
Taikisha Engineering India Pvt
Ltd., Gat No. 321/323, Pune
Nagar Road, Vill. Kondhapuri,
Tal. Shirur, Dist. Pune
Approved
Consent to
Renewal
31.08.2019 APC
It was decided to grant renewal of consent for JOB Work
with Material Laser Division: 6700 MT/Annum, Paint Shop
Equipment: 1100 MT/Annum & Painting of Paint Shop
Equipment: 550 MT/Annum, by imposing following
conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
(ii) Industry shall reuse 100% of treated effluent in to the
process.
After obtaining requisite consent fee, If any.
30
MPCB-
CONSENT-
0000033370
R.M.Chemicals Pvt. Ltd., Plot
No. E-119/120/126 Plot No. E-
119/120/126, MIDC Awdhan,
Dhule, Tal & Dist.Dhule.Not Approved
Consent to
Renewal with
expansion
_____ AS(T)
It was decided to issue SCN for refusal of consent to
renewal with expansion for manufacturing activities of
Detergent Cake & Powder, on following non-compliances:
(i) Industry has increased in CI and production without
obtaining consent to establish from Board.
(ii) Industry has also failed to submit H.W annual returns in
for IV including latest JVS report.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 18
31
MPCB-
CONSENT-
0000033721
Vadhivare Speciality Chemicals
Ltd., Gut No. 204, Wadivarhe,
Nashik Mumbai Highway,
Igatpuri, Nashik
Approved
Consent to
Renewal
30.11.2018 AS(T)
It was decided to issue plain renewal for Bulk drugs mfg.,
by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
After obtaining requisite consent fee, If any.
32
MPCB-
CONSENT-
0000034644
Hikal ltd., A-18 A-18 MIDC area
Mahad Mahad
Approved
Consent to
Renewal
30.11.2018 AS(T)
It was decided to grant renewal of consent for Pesticides
with increase in CI and without increase in production
quantity, by imposing following conditions:
(i) Industry shall extend existing Bank Guarantee of Rs. 7.5
lakh towards O & M of pollution control systems.
(ii) All the conditions of conditional direction issued by
Board on 25.09.2017
After obtaining requisite consent fee, If any.
33
MPCB-
CONSENT-
0000027649
Wockhardt Research Center, D-
4 Wockhardt Limited D4 MIDC
Chikalthana Aurangabad – 431
006
Not Approved
Consent to
Renewal
_____ AS(T)
It was decided issue SCN for renewal for renewal of
consent and CCA for BMW generation from R & D activity
with stop work for expansion, on following non-
compliances:
(i) Industry is manufacturing products which attracts
Environment Clearances.
34
MPCB-
CONSENT-
0000035330
CDET Explosive Industries
Private Limited,
270,271,272,273,309,321/
1,322/1,323,325,326,327,333,3
34,335,336,337,340,395 98 km,
Nagpur-Amravati Road (NH-6),
Talegaon (S.P.) AshtiApproved
Consent to
Renewal
31.12.2020 AS(T)
The committee noted that primary treatment facility for
effluent treatment followed by solar evaporation. Provided 6
Nos. of burning pits followed by bag filter with hood for
destroying waste products. provided STP for sewage
treatment. Applied for CGWB/A
permission for withdrawal of 327.4 m3/day.
Hence, it was decided to grant renewal of consent for
Detonators of all types, Delay Elements & Shock Tube, with
increase in CI by 5.84 Cr., by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
(ii) Industry shall provide solar evaporation pits above
ground.
After obtaining requisite consent fee, If any.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 19
35
MPCB-
CONSENT-
0000035536
HPCL, Hazarwadi LPG Plant,
Hazarwadi LPG PlantBhilwadi
Railway Staion-Post- Sangli,
Dist - Sangli - 416303,
Approved
Consent to
Renewal
31.12.2019 AS(T)
It was decided to grant renewal of consent for Filling of LPG
in to Cylinders – 13000 MT/Month, Painting of Old
Cylinders – 600 Nos./day using LPG – 13000 MT/Month as
a raw material, with increase in CI by 16.10 Cr., by
imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
(ii) Industry shall submit undertaking from plant head for
increase CI without prior permission from the Board and in
future they will not do such violation.
After obtaining requisite consent fee, If any.
36
MPCB-
CONSENT-
0000035287
CENTURY RAYON -
CHEMICAL PLANT (A division
of Century Textiles and
Industries Ltd.),
13,14,15,194,195A & 195B
Kalyan
Approved
Consent to
Renewal
31.12.2022 AS(T)
It was decided to grant renewal of consent for mfg. of
Caustic Soda, Chlorine and Hydrogen (By membrane Cell
technology) with increase in CI 40.96 Crs. Without change
in productions quantity, by imposing following conditions:
(i) Industry shall achieve Zero Liquid Discharge (ZLD)
within 6 months.
(ii) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
After obtaining requisite consent fee, If any.
37
MPCB-
CONSENT-
0000035472
Sudal Industries Limited, A-5
MIDC-Ambad Nashik
Approved
Consent to
Renewal
31.12.2018 APC
The committee noted that Industry has provided scrubber
as air pollution control system to Melting furnaces. ETP is
provided for the treatment of industrial effluent and treated
effluent is being partly recycled into the process and partly
utilized for gardening purpose. Hence, it was decided to
grant renewal of consent for manufacturing of Aluminium
casting and Extrusion, by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
After obtaining requisite consent fee, If any.
38
MPCB-
CONSENT-
0000036057
Amines & Plasticizers Limited,
Plot No. D-21/21A TTC
Industrial Area Turbhe
Approved
Consent to
Renewal
31.12.2022 AS(T)
The committee noted that industry has provided APC in the
form of scrubber and also online monitoring system for pH,
flow including Ambient VOC monitoring. Hence, it was
decided to grant renewal of consent with increase in CI by
Rs. 12.92 Crs. Without change in production quantity, by
imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems.
Consent to be issued after connectivity of online monitoring
system to Board server and after obtaining requisite
consent fee, If any.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 20
39
MPCB-
CONSENT-
0000035934
LOBA CHEMIE Private Limited,
Plot No. - D-22, M.I.D.C.,
Tarapur, Village-Salwad, Boisar
Approved
Consent to
Renewal
31.12.2022 AS(T)
The committee noted that existing unit having consent to
operate which is valid up to 31/12/2017 and applied for
renewal of consent without change in production. Unit
engaged in reprocessing & repacking of various chemicals.
Hence it was decided to grant renewal of consent with
increase in CI and without increase in production quantity,
by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control systems (Extending
existing BG of Rs. 2.0 Lakh and fresh BG of Rs. 3.0 Lakh)
40
MPCB-
CONSENT-
0000036792
Vaishno Devi Dairy Products
Ltd. (Formerly Known as
Shubhi Agro Industries Ltd.)
Gat No.
88/1B, Village
Nanur,Nandur,Pune
Not Approved
Consent to
Renewal
_____ WPC
It was decided to issue SCN for refusal of renewal of
consent and stop work for Dairy unit, on following non
compliances:
(i) Industry has not submitted Bank Guarantee as per
earlier consent.
(ii) Industry has installed additional boiler, changed fuel and
increased CI without prior permission
from the Board.
(ii) Industry has not submitted RoC certificate for change in
name.
41
MPCB-
CONSENT-
0000030667
SHRI VRIDHESHWAR
SAHAKARI SAKHAR
KARKHANA LTD., 106, 104/1,
105/1, 109/ZA
ADINATHNAGAR, KASAR
PIMPALGAON PATHARDI,
Dist. Ahmednagar
Not Approved
Consent to
Renewal
_____ WPC
It was decided to issue SCN for refusal of renewal of
consent and stop work for 2500 TCD Sugar unit, on
following non compliances:
(i) ETP is inadequate and not in operation.
(ii) As per directions of CPCB not installed online
monitoring system to ETP & Stack.
(iii) Not submitted bank Guarantee as per earlier consent.
(iv) Unit started crushing without valid consent and carried
out excess crushing.
42
MPCB-
CONSENT-
0000034808
Shri Kedareshwar Sahakari
Sakhar Karkhana Ltd.
Sumannagar, 352,357 At
Sumannagar, Post Bodhegaon
Shevgaon, Dist. Ahmednagar
Not Approved
Consent to
Renewal
_____ WPC
It was decided to issue SCN for refusal of renewal of
consent and stop work for 2500 TCD Sugar unit, on
following non compliances:
(i) ETP is inadequate and not in operation.
(ii) Not provided APC to 32TPH bagasse fired boiler,
provided only dust collector which is also not in operation
(iii) As per directions of CPCB not installed online
monitoring system to ETP & Stack.
(iv) Not submitted requisite consent fees from 2011-2016.
(v) Unit started crushing without valid consent and carried
out excess crushing.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 21
43
MPCB-
CONSENT-
0000025628
SEWERAGE TREATMENT
PLANTS - NMMC, BEALPUR,
NERUL, VASHI, SANPADA,
KOPARKHAIRANE,
GHANSOLI,AIROLI NAVI
MUMBAIApproved
Consent to
Renewal
31.05.2022 WPC
It was decided to grant Renewal of consent for 205 MLD
sewage (Eight STPs at- CBD Belapur sec-12, Nerul sec-50
, Sanpada sec-20, Vashi-sec-18, Koparkhairne sec-14,
Airoli, sec-18, Nerul- sec-2 with including STP at Ghansoli -
30 MLD) with SBR technology at 7 STP and another is
operated by lagoon technology, by imposing following
conditions:
(i) Corporation shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of STP's.
(ii) Corporation shall achieve BOD-30 mg/l standard for
disposal.
1
MPCB-
CONSENT-
0000035987
PRABHAT DAIRY LIMITED,
GUT NO 121/9 & 121/4 AT
RANJANKHOL POST
TILAKNAGAR RAHATA Approved
Consent to
Establish
(Expansion)
Commissionin
g of the unit or
5 yrs
whichever is
earlier
WPC
It was decided to grant consent to establish for expansion
for 03 Nos of total new Product (Fresh Cream – 18 MT/Day,
Liquid Milk Protein Concentrate – 24 MT/Day & Liquid
Concentrate Lactose – 40 MT/Day) & 01 Nos of
Enhancement in quantity of existing product (Pasteurisation
of Milk from 1 lakh Ltr/Day to 03 lakh Ltrs Per day, by
imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
2
MPCB-
CONSENT-
0000028800
Chhatrapati Sahakari Sakhar
Karkhana, Sonaji nagar,
Sawargaon, Tal. Majalgaon,
Dist. Beed
Approved
Renewal of
Consent to
Operate
31.07.2018 WPC
It was decided to grant renewal of consent to operate for
sugar unit, by imposing following conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards O & M of pollution control system.
(ii) Industry shall obtain revocation of closure direction from
CPCB for installation of online monitoring system.
3
MPCB-
CONSENT-
0000036841
Lastra Niraj Pvt Ltd., Plot No.F-
11, F-12, F-12/1, F-30, M.I.D.C.,
Ambad, Nashik.
Approved
Consent to
Establish
(Expansion)
Commissionin
g of the unit or
5 yrs
whichever is
earlier
APC
It was decided to grant consent to establish for expansion
for PS Positive plates - 3.7 M2/M, by imposing following
conditions:
(i) Industry shall submit Bank Guarantee of Rs. 5 lakh
towards compliance of consent conditions.
4
_____ Navi Mumbai Municipal
Corporation, Site S. no. 376-
379, Behind Lubrizol Company,
Turbhe, Navi Mumbai
Approved
Authorization31.12.2022 RO(HQ)
It was decided to grant MSW authorization for waste
processing facility for capacity 750 MT/D with aerobic
composting, RDF processing facility and earmarking the
area dedicated for landfill out of 145 acres of total land.
Table Item
Note: As per the Board's policy the industry may get total additional period based on fees paid up to 3 terms.
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 22
Operate, Establish Renewal Minutes of 9th CC meeting of 2017-18 dtd. 06.02.2018 23