Lab procedure cast partial
-
Upload
rajah-muthiah-dental-college-and-health-sciences -
Category
Health & Medicine
-
view
37 -
download
1
Transcript of Lab procedure cast partial
![Page 1: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/1.jpg)
Lab procedures in Cast Partial Dentures
PresenterBejoy ZachariahI MDS
Department of Prosthodontics and Crown & Bridge
23-01-2015 1
![Page 2: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/2.jpg)
23-01-2015 2
Contents • Introduction• Impressions with work authorization forms• Requisites for casts• Surveying the master casts• Block and Relief Arbirary block out Parallel block out Shaped block out• Duplication• Investment materials Gypsum bonded Phosphate bonded Silica bonded • Waxing and Spruing Maxillary Mandibular• Investing Vaccum mix Hand investing
![Page 3: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/3.jpg)
23-01-2015 3
• Wax elimination and heating• Casting• Cutting off Sprue, Finishing and Polishing• Corrected cast technique• Artificial teeth setting• Processing • Advancements • Conclusion• References
![Page 4: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/4.jpg)
23-01-2015 4
Why lab procedure is important?
Introduction
“ G o o d t e c h n i q u e p a y s o ff .”
T h e s e w o r d s a r e n o t m e r e l y a m o tt o t o h a n g o n t h e w a l l i n t h e l a b o r a t o r y b u t w o r d s o f w i s d o m
![Page 5: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/5.jpg)
23-01-2015 5
Possible errors in RPD
Everyone who participates in any step of the fabrication of a removable partial denture must share in the success or failure of the restoration.
Some seemingly innocuous deviations can be accumulative and cause serious problems, so
everyone should review the procedures that they use on a regular
basis.
Rudd and Rudd. A review of 243 errors possible during the fabrication of a removablepartial denture: Part I J Prosthet Dent 2001;86:251-61
![Page 6: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/6.jpg)
23-01-2015 6
![Page 7: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/7.jpg)
23-01-2015 7
Impressions with work authorization forms
Bomberg TJ, Hatch RA, Hoffman W. impression material thickness in stock and custom tray. J Prosthet Dent. 1985;54(August).
![Page 8: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/8.jpg)
23-01-2015 8
(1) The signature and license number of the dentist (2) The date the authorization was signed(3) The name and address of the patient(4) A description of the service or material ordered.
![Page 9: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/9.jpg)
23-01-2015 9
Requisites for casts
voids or nodules
hard dense
denture support.
3 to 4 mm deep peripheral roll
Vertical side walls
15 mm thick
•Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 10: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/10.jpg)
23-01-2015 10
Surveying the master casts
Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 11: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/11.jpg)
23-01-2015 11Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 12: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/12.jpg)
23-01-2015 12
Design should mimic the design on diagnostic cast
![Page 13: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/13.jpg)
23-01-2015 13
![Page 14: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/14.jpg)
23-01-2015 14
Block out and Relief
![Page 15: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/15.jpg)
23-01-2015 15
Arbitrary block out
Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 16: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/16.jpg)
23-01-2015 16
Parallel block out
Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 17: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/17.jpg)
23-01-2015 17
Shaped block out
Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 18: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/18.jpg)
23-01-2015 18
Relief
Dental laboratory procedures vol 3;Rudd KD 2nd edition.
Not used in complete denture bases, bead retention, open retention
![Page 19: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/19.jpg)
23-01-2015 19Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4 th edition.
![Page 20: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/20.jpg)
23-01-2015 20
Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 21: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/21.jpg)
23-01-2015 21Dental laboratory procedures vol 3;Rudd KD 2nd edition.
Duplicating procedure
![Page 22: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/22.jpg)
23-01-2015 22
Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4 th edition.
Agar : complex polysacharide extracted from sea weed Primarily consists of 15% colloidal suspension of agar in water Borates- 0.2-0.5% Potassium sulphate- 1-2% Wax- 1% Thixotrophic material 0.5% Water- around 84%
![Page 23: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/23.jpg)
23-01-2015 23
![Page 24: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/24.jpg)
23-01-2015 24
![Page 25: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/25.jpg)
23-01-2015 25
![Page 26: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/26.jpg)
23-01-2015 26
Investment Materials
Gypsum bondedPhosphate bonded
Silica bonded
Robert G. Craig & John M. Powers : Restorative dental materials (Tenth edition)
![Page 27: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/27.jpg)
23-01-2015 27
Gypsum bonded
• mixed with water• composed of a mixture of silica (SiO2) and calcium sulphate
hemihydrates (gypsum product)• Three types of gypsum bonded investments can be identified
as follows: -Type 1 thermal expansion type; for casting inlays and
crowns. -Type 2 hygroscopic expansion type; for casting inlays and
crowns. -Type 3 casting complete and partial dentures.
Robert G. Craig & John M. Powers : Restorative dental materials (Tenth edition)
![Page 28: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/28.jpg)
23-01-2015 28
Phosphate bonded
• powder contains silica, magnesium oxide and ammonium phosphate
• Can be mixed with water or colloidal silica• Two types of phosphate-bonded investment can be identified
as follows: -Type 1- for inlays, crowns and other fixed restorations. -Type 2- for partial dentures and other casts. removable restorations
Robert G. Craig & John M. Powers : Restorative dental materials (Tenth edition)
![Page 29: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/29.jpg)
23-01-2015 29
Silica bonded
• consist of powdered quartz or cristobalite which is bonded together with silica gel.
• On heating, the silica gel turns into silica so that the completed mould is a tightly packed mass of silica particles.
Robert G. Craig & John M. Powers : Restorative dental materials (Tenth edition)
![Page 30: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/30.jpg)
23-01-2015 30
Robert G. Craig & John M. Powers : Restorative dental materials (Tenth edition)
![Page 31: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/31.jpg)
23-01-2015 31
Investment cast
![Page 32: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/32.jpg)
23-01-2015 32
![Page 33: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/33.jpg)
23-01-2015 33
![Page 34: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/34.jpg)
23-01-2015 34Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 35: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/35.jpg)
23-01-2015 35Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 36: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/36.jpg)
23-01-2015 36Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 37: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/37.jpg)
23-01-2015 37
Design transfer
![Page 38: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/38.jpg)
23-01-2015 38
Waxing the frame work- Maxilla
![Page 39: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/39.jpg)
23-01-2015 39Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 40: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/40.jpg)
23-01-2015 40Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 41: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/41.jpg)
23-01-2015 41Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 42: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/42.jpg)
23-01-2015 42
![Page 43: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/43.jpg)
23-01-2015 43
![Page 44: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/44.jpg)
23-01-2015 44
Waxing the frame work- Mandible
Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 45: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/45.jpg)
23-01-2015 45
![Page 46: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/46.jpg)
23-01-2015 46
Spruing
![Page 47: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/47.jpg)
23-01-2015 47
![Page 48: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/48.jpg)
23-01-2015 48Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 49: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/49.jpg)
23-01-2015 49Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 50: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/50.jpg)
23-01-2015 50
![Page 51: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/51.jpg)
23-01-2015 51Dental laboratory procedures vol 3;Rudd KD 2nd edition.
Hamda et all. Investigation of the effect of three sprue design on the porosity and the completeness of titanium cast removable partial denture frameworks. J Prosthet Dent. 1999;82(1):15–21
![Page 52: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/52.jpg)
23-01-2015 52
Hamdi et all. Button versus buttonless castings for removable partial denture framework. J Prosthet Dent. 1994;72(4):433–44.
![Page 53: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/53.jpg)
23-01-2015 53Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 54: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/54.jpg)
23-01-2015
• Mechanical mixing under vacuum removes air bubbles created during mixing and evacuates any potentially harmful gases produced by the chemical reaction of the high-heat investments.
InvestingVacuum Mixing
54
![Page 55: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/55.jpg)
23-01-2015
• For gypsum bonded investments, temperature can be either 4680 for the hygroscopic technique or 6500C for the thermal expansion technique.
• With phosphate bonded investments,
the maximum temperature setting may
range from 7000C to 8700C, depending
upon the alloy selected..
Wax elimination and heating
Monika nemet. Laboratory fabrication procedures of a metal partial denture framework. acta stomatol crot 2003;37:95-98. 55
![Page 56: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/56.jpg)
23-01-2015
• It is also advisable to begin the burn out procedure while the mold is still wet.
• This process is facilitated by placing the ring with the sprue hole down over a slot in a ceramic tray in the burnout furnace.
Shah SA. Influence of time of placement of investments for burnout and the type of rings being used on the casting accuracy. J Indian Prosthodont Soc.2014 Mar;14(1):67-71.
56
![Page 57: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/57.jpg)
23-01-2015
Casting
•Monika nemet. Laboratory fabrication procedures of a metal partial denture framework. acta stomatol crot 2003;37:95-98. 57
![Page 58: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/58.jpg)
23-01-2015 58
![Page 59: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/59.jpg)
23-01-2015 59
co-cr alloy is a commonly used investment material for casting of partial dentures.this metal doesnot have adequate ductility
for adjustment purposes but are light in weight, strong and corrosion resistant. superheating the alloy before casting can
increase the ductility of the alloy.
superheating the alloy can cause the metal to react with the mold and a close adhering green scale is formed. this green
scale is very hard to be removed and requires a lot of machining.
Allan FC, Asgar K, Alligato RDE, Cobalt FDE, Con EC. Reaction of Cobalt-Chromium Casting Alloy with Investment. J Dent Res. 1966;45(5):1516–28.
![Page 60: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/60.jpg)
23-01-2015 60
Sand blasting
![Page 61: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/61.jpg)
23-01-2015 61
Pickling
![Page 62: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/62.jpg)
23-01-2015 62
Cutting off Casting Sprues and Finishing and Polishing
![Page 63: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/63.jpg)
23-01-2015 63Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 64: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/64.jpg)
23-01-2015 64Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 65: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/65.jpg)
23-01-2015 65Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 66: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/66.jpg)
23-01-2015 66Dental laboratory procedures vol 3;Rudd KD 2nd edition.
![Page 67: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/67.jpg)
23-01-2015 67
![Page 68: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/68.jpg)
23-01-2015 68
Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4 th edition.
The unit pictured in is theTi-Lectro Polisher (CMP Industries). The polishing occurs in a bath of 85% orthophosphoric acid, which is heated t o 49 ° C to 60 °C.
The anode is attached to the cast and the cast is immersed in the solution. Each square inch of metal surface area requires 2 amperes of current for 6 minutes. The average setting is 6 amperes f o r 6 mins.
![Page 69: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/69.jpg)
23-01-2015
• A functional impression is generally made by adding an impression base to the removable partial denture framework.
• Functional impressions may be made by a variety of impression materials.
Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th edition
Joanne N. Walton The corrected cast impression: An alternative technique. Quintessence Int 1993;24:779-781.69
Corrected cast impressions
![Page 70: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/70.jpg)
23-01-2015
Techniques for pouring corrected cast impressions are boxing with a
• 1)Plaster pumice mix and wax, • 2)Beading and boxing with wax, • 3)Beading with wax and the two stage pour.
Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th editionJoanne N. Walton The corrected cast impression: An alternative technique. Quintessence Int 1993;24:779-781.
70
![Page 71: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/71.jpg)
23-01-2015
• 1. A rubber base corrected cast impression is received in the laboratory.
• 2. Outline the master cast for removal of the ridge areas •Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th edition
71
![Page 72: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/72.jpg)
23-01-2015
• 3. Remove the residual ridge areas from the master cast
• cut retention areas into the cast
Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th edition 72
![Page 73: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/73.jpg)
23-01-2015
• 4. Place the framework with its impression on the master cast and lute it
Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th edition73
![Page 74: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/74.jpg)
23-01-2015
• 5. Soak- the cast and framework in clear slurry water, and place it into plaster/pumice mixture.
•Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th edition74
![Page 75: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/75.jpg)
23-01-2015
• 6. After the plaster/pumice mixture has set, shape it to the outline of the cast.
• 7. Use a strip of boxing wax to complete the boxing of the impression and is seal with a wax spatula
•Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th edition
75
![Page 76: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/76.jpg)
23-01-2015
8. Soak the boxed impression in clear slurry water for 5 minutes in preparation for pouring
9. Pour the boxed impression in improved stone
•Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th edition
76
![Page 77: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/77.jpg)
23-01-2015
•Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4th edition
77
![Page 78: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/78.jpg)
23-01-2015 78
Artificial teeth setting
![Page 79: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/79.jpg)
23-01-2015 79
![Page 80: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/80.jpg)
23-01-2015 80
Determining occlusal schemes
1. Class III removable partial denturea. The occlusal morphology of the artificial teeth is selected to
match that of the opposing teeth or surfaces.b. If the existing occlusion is physiologically healthy, the patient is
restored to the existing occlusal scheme, which may be group function or mutually protected.
c. A group function articulation is recommended if the patient’s natural canine is missing or periodontally compromised.
d. A balanced articulation is recommended if the restoration is to oppose a complete denture. Some clinicians believe that balanced articulation is not desirable or clinically obtainable and select a monoplane or lingualized occlusion.
Ivanhoe JR, Plummer KD. Removable partial denture occlusion. Dent Clin N Am. 2004;48:667–83
![Page 81: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/81.jpg)
23-01-2015 81
2. Class II removable partial denture The recommendations given for class III are appropriate,
with the following exceptions:a. Group function articulation should be avoided when there
are no remaining premolars. A canine-protected articulation reduces the destructive lateral forces that are generated on the distal extension during function.
b. Except when opposing a complete denture, a balanced articulation should be avoided to prevent nonworking contacts on natural teeth.
Ivanhoe JR, Plummer KD. Removable partial denture occlusion. Dent Clin N Am. 2004;48:667–83
![Page 82: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/82.jpg)
23-01-2015 82
3. Class I removable partial dentureThe recommendations given for classes II and III
are appropriate with the following exception:a. Balanced articulation is recommended for
patients for whom canine-protected articulation is not possible to provide bilateral occlusal contacts for increased denture stability.
Ivanhoe JR, Plummer KD. Removable partial denture occlusion. Dent Clin N Am. 2004;48:667–83
![Page 83: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/83.jpg)
23-01-2015 83
4. Class IV removable partial denturea. During excursive movements the anterior artificial
teeth should either disocclude or have passive occlusal contact.
b. A balanced articulation is recommended if the restoration is to oppose a complete denture. Some clinicians believe that balanced articulation is not desirable or clinically obtainable and select a monoplane or lingualized articulation with no anterior tooth contact in function
Ivanhoe JR, Plummer KD. Removable partial denture occlusion. Dent Clin N Am. 2004;48:667–83
![Page 84: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/84.jpg)
23-01-2015 84
Processing
After the teeth arrangement has been completed the flasking, processing, deflasking and finishing steps are followed.
![Page 85: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/85.jpg)
23-01-2015 85
Advancements In Cast Partial Denture Fabrication
3 D computer models
Valplast RPD
Milling of RPD
![Page 86: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/86.jpg)
23-01-2015 86
References 1. Nasser KSGA. Cast partial denture : Laboratory step by step. J Indian Prosthodont Soc. 2006;6(4):170–4. 2. Knezoviê-zlatariê D. Laboratory Fabrication Procedures of a Metal Partial Denture Framework. Acta
Stomatol Croat. 2003;37:95–8. 3. Bomberg TJ, Hatch RA, Hoffman W. impression material thickness in stock and custom tray. J Prosthet
Dent. 1985;54(August). 4. Howard S, Rudd KD, Dc U, Morrow RM, Powell JM. Comparision of effects of tap water and slurry water on
gypsum casts. J Prosth Dent. 1970;24(5):563–9. 5. Hasaballa M. THE FEASIBILITY OF INDIRECT CASTING OF MAXILLARY REMOVABLE PARTIAL DENTURE. Saudi
Dent J. 1993;5(3):114–20. 6. Hamda et all. Investigation of the effect of three sprue design on the porosity and the completeness of
titanium cast removable partial denture frameworks. J Prosthet Dent. 1999;82(1):15–21. 7. Brudvik JS, Lee S, Croshaw SN, Reimers DL. Laser Welding of Removable Partial Denture Frameworks. Int J
Prosthodont. 2008;21(4):285–92. 8. Allan FC, Asgar K, Alligato RDE, Cobalt FDE, Con EC. Reaction of Cobalt-Chromium Casting Alloy with
Investment. J Dent Res. 1966;45(5):1516–28. 9. Hamdi et all. Button versus buttonless castings for removable partial denture framework. J Prosthet Dent.
1994;72(4):433–44. 10. Walton JN. The corrected cast impression : An alternative technique Prosthodontics. Quintessence Int
(Berl). 1993;24(11):779–81. 11. Ivanhoe JR, Plummer KD. Removable partial denture occlusion. Dent Clin N Am. 2004;48:667–83. 12. Williams RJ, Bibb R, Rafik T. A technique for fabricating patterns for removable partial denture
frameworks using digitized casts and electronic surveying. J Prosthet Dent. 2004;91(1):85–8.
![Page 87: Lab procedure cast partial](https://reader038.fdocuments.us/reader038/viewer/2022102905/55d05689bb61ebb97b8b4785/html5/thumbnails/87.jpg)
23-01-2015 87
13. Textbook of clinical removable partial prosthodontics by Stewart, Rudd, Kuebker 2nd edition.
14. Stewart’s clinical removable partial prosthodontics. Rodney D. phoenix.4 th edition.
15. Dental laboratory procedures vol 3;Rudd KD 2nd edition.
16. Mc Cracken’s removable partial prosthodontics, ninth edition
17. Joanne N. Walton The corrected cast impression: An alternative technique. Quintessence Int 1993;24:779-781.
18. Knapp J.G Technique for recording the cast surveyer. J. Prosthet Dent 1979; 41:352-354.
19. Yilmaz. G Optical surveying of casts for removable partial dentures J. Prosthet Dent.1975; 34:292-296
20. Richard E Coy. Survey and design of diagnostic casts for removable partial dentures J. Prosthet Dent.1974; 32:103
21. Sergio Reinaldo De Fiori. Transferring the path of insertion from the diagnostic cast to multiple master casts. J. Prosthet Dent.1983; 50:733.
22. Arthur M La Vere. A simplified procedure for survey and design of diagnostic casts. J. Prosthet Dent.1977; 37:680.
23. Robert G. Craig & John M. Powers : Restorative dental materials (Tenth edition)
24. Kenneth J. Anusavice : Philips’ science of dental materials (eleventh edition)