L 25 and 26 final
-
Upload
shrikant-jahagirdar -
Category
Technology
-
view
322 -
download
1
description
Transcript of L 25 and 26 final
![Page 1: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/1.jpg)
L-25Cyclones
Air Pollution and Control
(Elective-I)
![Page 2: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/2.jpg)
Cyclones• Settling chambers discussed in previous
lecture are not effective in removing smallparticles.
• Therefore, one needs a device that canexert more force than gravity force on theparticles so that they can be removed fromthe gas stream.
• Cyclones use centrifugalcentrifugal forcesforces forremoving the fine particles. They are alsoknown as centrifugal or inertial separators.
2Prof S S Jahagirdar, NKOCET
![Page 3: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/3.jpg)
CycloneCyclone
3Prof S S Jahagirdar, NKOCET
![Page 4: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/4.jpg)
Vortex core
Main Vortex
4Prof S S Jahagirdar, NKOCET
![Page 5: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/5.jpg)
CYCLONE
VortexFinder
Cylinder
Cone
Inlet
Outlet
DustDischarger
Cyclonebody
5Prof S S Jahagirdar, NKOCET
![Page 6: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/6.jpg)
6Prof S S Jahagirdar, NKOCET
![Page 7: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/7.jpg)
7Prof S S Jahagirdar, NKOCET
![Page 8: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/8.jpg)
• The cyclone consists of a vertically placedcylinder which has an inverted coneattached to its base.
• The particulate laden gas stream enterstangentially at the inlet point to thecylinder.
• The velocity of this inlet gas stream isthen transformed into a confined vortex,from which centrifugal forces tend todrive the suspended particles to the wallsof the cyclone.
8Prof S S Jahagirdar, NKOCET
![Page 9: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/9.jpg)
• The vortex turns upward after reaching at the bottom of the cylinder in a narrower inner spiral.
• The clean gas is removed from a central cylindrical opening at the top, while the dust particles are collected at the bottom in a storage hopper by gravity.
9Prof S S Jahagirdar, NKOCET
![Page 10: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/10.jpg)
How particles separated from gas?• A high rate of spin
Spinning gas
Centrifugal force flingfling the dust particles to the walls of cylinder and cone
The particle then slide down the wall and into the storage hopper
The cleaned gas gradually spiral downward …
The downward cleaned gas gradually reversed its downward and forms a smaller ascending spiral
A vortex finder tube extending downward into the cylinder aids in directing the inner vortex out of the device
![Page 11: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/11.jpg)
Cyclone DimensionsD= Body diameterH= Height of inletW= width of inletLc= Length of coneLb= Length of bodyS= Length of vortex finderDe= Diameter of exitDd= Diameter of dust outlet
11Prof S S Jahagirdar, NKOCET
![Page 12: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/12.jpg)
Effective turns
12Prof S S Jahagirdar, NKOCET
![Page 13: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/13.jpg)
Vi = Gas Velocity at inlet (m/s or ft/s)
Equation Equation for dfor dpp
13Prof S S Jahagirdar, NKOCET
![Page 14: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/14.jpg)
dp is the size of the smallest particle that will be collected if it starts at the inside edge of the inlet duct.
Thus, in theory, all particles of size dp or larger should be collected with 100% efficiency.
14Prof S S Jahagirdar, NKOCET
![Page 15: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/15.jpg)
Equation for Cut Size diameter
15Prof S S Jahagirdar, NKOCET
![Page 16: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/16.jpg)
Standard Cyclone
16Prof S S Jahagirdar, NKOCET
![Page 17: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/17.jpg)
Standard Cyclone
17Prof S S Jahagirdar, NKOCET
![Page 18: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/18.jpg)
18Prof S S Jahagirdar, NKOCET
![Page 19: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/19.jpg)
•Lapple then developed a general curve for standard conventional cyclones to predict the collection efficiency for any particle size.• If the size distribution of particles is known, the overall collection efficiency of a cyclone can be predicted by using above graph. •Theodore and DePaola (1980) have fitted an algebraic equation to above graph, which makes Lapple’s approach more precise and more convenient for application to computers.
Equation of Cyclone
19Prof S S Jahagirdar, NKOCET
![Page 20: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/20.jpg)
20Prof S S Jahagirdar, NKOCET
![Page 21: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/21.jpg)
Equation for efficiency
X 100
in %
21Prof S S Jahagirdar, NKOCET
![Page 22: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/22.jpg)
22Prof S S Jahagirdar, NKOCET
![Page 23: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/23.jpg)
Advantagesi) low initial cost,
ii) simple in construction and operation,
iii) low pressure drop,
iv) low maintenance requirements,
v) continuous disposal of solid particulate matter, and
vi) use of any material in their construction that can withstand the temperature and pressure requirements. Prof S S Jahagirdar, NKOCET 23
![Page 24: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/24.jpg)
Disadvantagesi) low collection efficiency for
particles below 5 – 10 µ in diameter,
ii) severe abrasion problems can occur during the striking of particles on the walls of the cyclone, and
iii) a decrease in efficiency at low particulate concentration.
Prof S S Jahagirdar, NKOCET 24
![Page 25: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/25.jpg)
Operational problems• i) Erosion: Heavy, hard, sharp edged
particles, in a high concentration, movingat a high velocity in the cyclone,continuously scrap against the wall andcan erode the metallic surface.
25Prof S S Jahagirdar, NKOCET
![Page 26: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/26.jpg)
• ii) Corrosion: If the cyclone is operating below the condensation point, and if reactive gases are present in the gas stream, then corrosion problems can occur. Thus the product should be kept above the dew point or a stainless steel alloy should be used.
• iii) Build – up: A dust cake builds up on the cyclone walls, especially around the vortex finder, at the ends of any internal vanes, and especially if the dust is hygroscopic. It can be a severe problem.
26Prof S S Jahagirdar, NKOCET
![Page 27: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/27.jpg)
Applications of cyclonesi) For the control of gas borne particulate matter in industrial operations such as cement manufacture, food and beverage, mineral processing and textile industries. ii) To separate dust in the disintegration operations, such as rock crushing, ore handling and sand conditioning in industries. iii) To recover catalyst dusts in the petroleum industry. iv) To reduce the fly ash emissions.
27Prof S S Jahagirdar, NKOCET
![Page 28: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/28.jpg)
• Applications• Power Plant
• Textile industry (Cotton, Polyester)
• Stone Crusher
• Mineral Industry
• Rubber Industry
• Material Handling
• Fly Ash
• Lead Industry
• Cement Industry
• Steel Industry28
Prof S S Jahagirdar, NKOCET
![Page 29: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/29.jpg)
Objective QuestionsQ1. In cyclone particulate separation takes place
because of ________________ force.
Q2. Cyclone separator has ___________ inlet.
Q3. In case of cyclone equation for effective turns is given by _______________.
Q4. Cut size diameter in case of cyclone can be computed by using equation _______________.
Q5. In case of a standard cyclone length of conical part is given by ________________. (similar questions on dimensions of cyclone)
29Prof S S Jahagirdar, NKOCET
![Page 30: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/30.jpg)
Theory Questions
Q1. Discuss with neat sketch working principle of cyclone. Also list its advantages and disadvantages.
Q2. write short notes on:-
1. Standard cyclone
2. Operational problems in cyclone.
30Prof S S Jahagirdar, NKOCET
![Page 31: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/31.jpg)
Prof S S Jahagirdar, NKOCET 31
![Page 32: L 25 and 26 final](https://reader033.fdocuments.us/reader033/viewer/2022051412/54be4a1c4a795910468b4614/html5/thumbnails/32.jpg)
Prof S S Jahagirdar, NKOCET 32