KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles...
Transcript of KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles...
![Page 1: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/1.jpg)
KICK-OFF MEETING
JAN 31, 2018
![Page 2: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/2.jpg)
• Introductions and Roles• Objectives and Overview of Pipe Rig Study• Review of Coupon CCT Study Results• Detail Test Plan and Schedule• Open Discussion on Expectations and
Participants• Break to Visit Pilot Set-Up• Required Resources and Flint Staff Assistance• Wrap/ Comments/ Next Steps
![Page 3: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/3.jpg)
![Page 4: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/4.jpg)
• December 2015: Flint began boosting O-P to meet an EPA WQP of O-P > 3.1
• pH was required > 7
• Chlorine residual has continually improved in the system
• November 2017: We completed coupon studies for CCT
• December 2017: DEQ issued new WQP Requirements
![Page 5: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/5.jpg)
Parameter Target100 Percent
Range
pH (s.u.) 7.5 7.2 - 7.9
Orthophosphate
residual (mg/L)3.3 3.1 - 4.5
Parameter Target90 Percent
Range
100 Percent
Range
pH (s.u.) 7.5 7.3 - 7.8 7.2 - 7.9
Orthophosphate
residual (mg/L)3.6 3.3 - 4.0 3.2 - 4.5
Free chlorine
residual (mg/L)1.5 - 1.8 1.4 - 1.9 1.3 - 2.0
Note: All daily values must fall within 100% range, excluding 9 days of allowed non-compliance per 6 months
Distribution System (EWDM Sampling Stations)
Water Treatment Facility
![Page 6: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/6.jpg)
1) EPA Sequential Database
2) MDEQ Sentinel Database
3) MDEQ Residential Database
4) To better understand how Pb changed at specific locations over time, a subset was created from only those sites with Pb samples collected during all seasons
![Page 7: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/7.jpg)
![Page 8: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/8.jpg)
• The next phase was prescribed by EPA and DEQ to conduct pipe studies using harvested lead pipes from the system
• EPA has required pipe studies to:
– Establish the proper O-P Dose
– Determine impacts of blending GCDC Water into the GLWA Water
![Page 9: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/9.jpg)
• CCT strategy efficacy can be studied on actual pipe from distribution system. Orthophosphate dose comparison is possible. [1]
• Collection of stagnation samples is possible, depending on design. [2]
[1] Schock & Lytle, 2011[2] Cantor, Hill, & Giani, 2017
![Page 10: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/10.jpg)
Welter , G., Schock, M., Miller, S., Razza , R., & Giammar, D. (2015, November 17)
Civardi & GrayEisnor & Gagnon, 2003
Madison Water Utility, 2016
![Page 11: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/11.jpg)
• Assess lead concentration reduction in GLWA water from exhumed Flint LSLs with increased orthophosphate dose compared to current GLWA conditions.
• Study effect of pH increase (7.5) on lead concentration compared to current GLWA conditions.
• Recommend Final CCT for Flint and WQPs
![Page 12: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/12.jpg)
COMPLETED NOV. 2017
![Page 13: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/13.jpg)
2.0 mg/L PO4
2.5 mg/L PO4
3.0 mg/L PO4
3.5 mg/L PO4
4.0 mg/L PO4
5.0 mg/L PO4
Target pH: 7.2
2.0 mg/L PO4
2.5 mg/L PO4
3.0 mg/L PO4
3.5 mg/L PO4
4.0 mg/L PO4
5.0 mg/L PO4
Target pH: 7.5
2Replicates
2Replicates
![Page 14: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/14.jpg)
• Conducted under zero headspace to eliminate pH atmospheric drift
![Page 15: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/15.jpg)
• Lead Concentrations expressed in (µg/L-day)– The number of days between water changes
varies from 3-4 days (7 days if there is a holiday)
– µg/L-day charts express the normalized lead concentrations
![Page 16: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/16.jpg)
0
10
20
30
40
50
60
70
80
0 20 40 60 80 100
Le
ad
Co
nce
ntr
atio
n (
µg
/L-d
ay)
Days Since Start
2.0 mg/L PO4, [1] 2.0 mg/L PO4, [2] 2.5 mg/L PO4, [1] 2.5 mg/L PO4, [2]
3.0 mg/L PO4, [1] 3.0 mg/L PO4, [2] 3.5 mg/L PO4, [1] 3.5 mg/L PO4, [2]
4.0 mg/L PO4, [1] 4.0 mg/L PO4, [2] 5.0 mg/L PO4, [1] 5.0 mg/L PO4, [2]
Steady State
![Page 17: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/17.jpg)
0
10
20
30
40
50
60
70
80
0 20 40 60 80 100
Le
ad
Co
nce
ntr
atio
n (
µg
/L-d
ay)
Days Since Start
2.0 mg/L PO4, [1] 2.0 mg/L PO4, [2] 2.5 mg/L PO4, [1] 2.5 mg/L PO4, [2]
3.0 mg/L PO4, [1] 3.0 mg/L PO4, [2] 3.5 mg/L PO4, [1] 3.5 mg/L PO4, [2]
4.0 mg/L PO4, [1] 4.0 mg/L PO4, [2] 5.0 mg/L PO4, [1] 5.0 mg/L PO4, [2]
Steady State
![Page 18: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/18.jpg)
• Outliers were removed using the interquartile range (IQR) function
• Replicate coupon data were averaged if data was determined not to be outlying
![Page 19: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/19.jpg)
0
10
20
30
40
50
60
70
80
0 20 40 60 80 100
Le
ad
Co
nce
ntr
atio
n (
µg
/L-d
ay)
Days Since Start
2.0 mg/L PO4 2.5 mg/L PO4 3.0 mg/L PO4 3.5 mg/L PO4
4.0 mg/L PO4 5.0 mg/L PO4 Steady State
![Page 20: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/20.jpg)
0
10
20
30
40
50
60
70
80
0 20 40 60 80 100
Le
ad
Co
nce
ntr
atio
n (
µg
/L-d
ay)
Days Since Start
2.0 mg/L PO4 2.5 mg/L PO4 3.0 mg/L PO4 3.5 mg/L PO4
4.0 mg/L PO4 5.0 mg/L PO4 Steady State
![Page 21: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/21.jpg)
0
5
10
15
20
25
42 52 62 72 82
Le
ad
Co
nce
ntr
atio
n (
µg
/L-d
ay)
Days Since Start
2.0 mg/L PO4 2.5 mg/L PO4 3.0 mg/L PO4
3.5 mg/L PO4 4.0 mg/L PO4 5.0 mg/L PO4
0
5
10
15
20
25
42 52 62 72 82
Le
ad
Co
nce
ntr
atio
n (
µg
/L-d
ay)
Days Since Start
2.0 mg/L PO4 2.5 mg/L PO4 3.0 mg/L PO4
3.5 mg/L PO4 4.0 mg/L PO4 5.0 mg/L PO4
7.2 pH Target 7.5 pH Target
![Page 22: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/22.jpg)
• Trends appear similar between target pH groups
• t-test used to determine if pH made a significant impact on lead solubility
![Page 23: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/23.jpg)
• t-test assuming unequal variances
• Significance (α) value of 0.05
• Null hypothesis: lead concentrations are the same
• After two different t-tests, pH was determined to not to make a significant impact on lead concentrations
![Page 24: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/24.jpg)
Comparison Mean 1 Mean 2T
Statistic
t Critical
(two tail)
Lead is the
same
2.0A vs 2.0B 17.85 16.91 0.2308 2.021 SUPPORTED
2.5A vs 2.5B 17.52 16.81 0.1762 2.024 SUPPORTED
3.0A vs 3.0B 13.83 13.10 0.2196 2.021 SUPPORTED
3.5A vs 3.5B 11.31 12.29 0.3232 2.018 SUPPORTED
4.0A vs 4.0B 11.04 9.43 0.5715 2.022 SUPPORTED
5.0A vs 5.0B 9.75 8.95 0.4337 2.021 SUPPORTED
Summarized t-Test 1 Results for pH Comparison (All Data)
Comparison Mean 1 Mean 2T
Statistic
t Critical
(two tail)
Lead is the
same
2.0A vs 2.0B 11.565 12.239 -0.924 2.074 SUPPORTED
2.5A vs 2.5B 10.870 13.660 -3.550 2.086 REJECTED
3.0A vs 3.0B 10.412 9.554 1.400 2.086 SUPPORTED
3.5A vs 3.5B 8.531 9.398 -1.656 2.093 SUPPORTED
4.0A vs 4.0B 8.166 7.238 1.658 2.074 SUPPORTED
5.0A vs 5.0B 8.482 6.939 2.832 2.080 REJECTED
Summarized t-Test 2 Results for pH Comparison (After Steady-State)
![Page 25: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/25.jpg)
0
5
10
15
20
25
42 52 62 72 82
Le
ad
Co
nce
ntr
atio
n (
µg
/L-d
ay)
Days Since Start
2.0 mg/L PO4 2.5 mg/L PO4 3.0 mg/L PO4
3.5 mg/L PO4 4.0 mg/L PO4 5.0 mg/L PO4
![Page 26: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/26.jpg)
Comparison Mean 1 Mean 2 T Statistict Critical
(two tail)Lead is the same
2.0 vs 2.5 11.902 11.864 0.060 2.074 SUPPORTED
2.5 vs 3.0 11.864 10.097 3.074 2.080 REJECTED
3.0 vs 3.5 10.097 8.964 2.377 2.074 REJECTED
3.5 vs 4.0 1.200 1.806 2.521 2.080 REJECTED
4.0 vs 5.0 1.806 1.965 0.274 2.074 SUPPORTED
Summarized t-Test 3 Results
• Third t-test used to determine significant differences between consecutive doses
• Results determined no significant difference between 2.0 and 2.5 mg/L as PO4, or 4.0 and 5.0 mg/L as PO4.
![Page 27: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/27.jpg)
• Each point represents the average of one batch
• Bolded points represent the overall average lead concentration at each dose
0
2
4
6
8
10
12
14
16
0
2
4
6
8
10
12
14
16
0.00 1.00 2.00 3.00 4.00 5.00 6.00
Le
ad
Co
nce
ntr
atio
n (
µg
/L-d
ay)
Orthophosphate Dose (mg/L as PO4)
![Page 28: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/28.jpg)
• No significant difference in lead concentration at target pH values
• No significant difference in corrosion inhibitor performance below doses of 2.5 mg/L PO4, and above doses of 4.0 (3.5?) mg/L PO4
• Lead concentrations leveled off in the 3.5 to 4 range mg/L PO4.
![Page 29: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/29.jpg)
![Page 30: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/30.jpg)
• EPA constructed pipe rigs
• There are 4 rigs with 4 pipes each
• Pipes have been running since Spring 2016
• 4 pipes were harvested by EPA in Oct. 2017 and replaced
• We need to verify 4 replaced pipes are suitable to use—if so 16 pipes for use
• We have not received any pipe lead background data –starting fresh with data
![Page 31: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/31.jpg)
• GLWA water currently enters the Flint WTP prior to Flint adding chemicals
• The pipes currently receive Flint treated water
• Pipes current CCT entering -----
![Page 32: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/32.jpg)
Tap (WQP Adjusted Water Leaving)Tap (WQP Adjusted Water Leaving)
![Page 33: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/33.jpg)
Sample ID Pipe IDPipe
InstallationTotal Lead (µg/L)
A-1 2300 Vernon St. 10/2/2017 5.5
A-2 2614-02 Existing 2.7
A-3 2614-03 Existing 4.3
A-4 2614-01 Existing 2.2
B-1 742-4 Existing 9.7
B-2 742-2 Existing ND
B-3 2317 Vernon St. 10/2/2017 3.8
B-4 742-03 Existing 2.4
C-1 2417 Vernon St. 10/2/2017 3.1
C-2 2301 ID #3 Existing 4.3
C-3 2301 ID #2 Existing 3.5
C-4 2301 ID #4 Existing 2.4
D-1 2402 Vernon St. 10/2/2017 4.4
D-2 749 ID #1 Existing 3.9
D-3 749 ID #3 Existing 5.1
D-4 749 ID #4 Existing 3.8
![Page 34: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/34.jpg)
• Entering GLWA water will be routed to feed the pipes and the pipes will be switched from Flint water to straight GLWA
• GLWA CCT water quality entering Flint---
![Page 35: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/35.jpg)
CSII (GLWA Water Entering)CSII (GLWA Water Entering)
![Page 36: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/36.jpg)
• Phase 1– Test only GLWA water– Test different O-P levels to optimize lead and dose– Test above using pH as received– Some testing at set pH of 7.5
• Phase 2– Pick a few of O-P conditions and one pH– Blend in 5% GCDC—See impacts– Possibly Phase 1 refinement also
• Phase 3???– Nothing planned or scheduled-TBD
![Page 37: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/37.jpg)
Input Water pH Condition Target pHOrthophosphate Dose
(mg/L as PO4)Replicate Pipes
GLWA As Received 7.2-7.4
1.2 (as received) 2
2.5 2
3.0 2
3.5 2
4.0 2
5.0 2
GLWA Adjusted 7.5
1.2 (as received) 1
2.5 1
3.0 1
4.0 1
Number of Pipes 16
![Page 38: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/38.jpg)
Orthophosphate
Dose (mg/L as PO4)
Replicate
Pipes
1.2 (as received) 2
2.5 2
![Page 39: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/39.jpg)
Rig #Orthophosphate Dose
(mg/L as PO4)
Replicate
Pipes
23.0 2
3.5 2
34.0 2
5.0 2
![Page 40: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/40.jpg)
pHOrthophosphate Dose
(mg/L as PO4)Pipes
7.5
1.2 (as received) 1
2.5 1
3.0 1
4.0 1
![Page 41: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/41.jpg)
• 8 of 16 Pipes retained for Phase 1 refinements• Orthophosphate doses for blended conditions could be adjusted
based on Phase 1 findings
Input WaterpH
ConditionTarget pH
Orthophosphate Dose
(mg/L as PO4)Number of Pipes
95% GLWA
5% GCDC
(COUNTY)
TBD TBD
1.2 (as received) 2
2.5 2
3.0 2
4.0 2
Phase 1 Refinement TBD 8
![Page 42: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/42.jpg)
• Hopefully and assumed that pipes are at steady state. Initially recommended 12 month study for Phase 1 and 2
• Budget constraints cut testing to 9 months and then to 8 months which is current plan
• We all need to recognize we have no control over time required for pipes to equilibrate so in a sense schedule is arbitrary based on budget
![Page 43: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/43.jpg)
![Page 44: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/44.jpg)
![Page 45: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/45.jpg)
• Plumb GLWA water to rigs with hose to switch sources. Reduce pressure to TBD.Keep on Flint water now
• Wire rig-mounted outlets into timer to control pumps
• Assist in plumbing-in pH control system
![Page 46: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/46.jpg)
• Provide work desk/space
• Need Internet access
• Perhaps printing and copying occasionally
• Plant access
![Page 47: KICK-OFF MEETING JAN 31, 2018 - Michigan...KICK-OFF MEETING JAN 31, 2018 •Introductions and Roles ... •Lead concentrations leveled off in the 3.5 to 4 range mg/L PO 4. •EPA constructed](https://reader035.fdocuments.us/reader035/viewer/2022070713/5ed1c6c2b7ffc46a1872d19e/html5/thumbnails/47.jpg)
• Provide orthophosphate and caustic
• Provide Operator to assist with chemical make-up, sampling etc.
• Check and make up chemicals as needed on weekends