Intelligent Underground Mine Detection
-
Upload
steveabonyi -
Category
Documents
-
view
230 -
download
0
Transcript of Intelligent Underground Mine Detection
-
7/29/2019 Intelligent Underground Mine Detection
1/6
RES-SYS Research and Development LTD. Nagykert 98, Tata 2890 HungaryTel: +36 23 415 206, +36 23 417 780, +36 30 327 4222, +36 20 953 8305Fax: +36 23 417 780 Email: [email protected]
INTELIGENT UNDERGROUND MINE DETECTION (IUMD) ROBOT
The IUMD Robot System was developed on the base of a new robot technology(newest sensor and most advanced digital technology), which is able to construct aprecise map of the metallic parts located under the ground level, to store thecoordinates of their location and if required to make a paint mark on the ground at theplace of their location.
This robot system was developed mainly for military application. The system has thehighest effectiveness in procedures of mapping and destruction of projectiles andactive mines.
The IUMD Robot System recognizes projectiles and different mines, mapping theircoordinates with up to 1 cm accuracy. It uses a 2m long pneumatic lever holding themagnetic sensors vertically with a gyroscope. The data sent from the unit onto theremote control unit is already a picture of the detected metallic part. The identifiedobjects can be destroyed using the built-in back-sliding disrupter with the help of aninfrared camera. These maneuvers are done securely using the remote control froma distance of over 100m. The incoming data, both pictures of found metallic parts andvideo input can be stored onto the notebook built in the remote control.The screen on the remote control unit shows two parallel pictures: one of the GPScoordinates and the map the unit is located at, and one of the video input the unit
sends to the remote control.
The unit has front shields to avoid the fragmentation effect.
The system recognizes metallic parts in up to 2m depth below the ground level.The unit can be used during day and night it uses two infrared lights in the cameraand two 50W halogen lights on the front. It can be used in extreme conditions: from-10C up to +60C; it is dustproof it works even in desert conditions.
Steps of the mapping process:1. Digitalization of the traditional map with the available largest scale.
2. Loading of precise coordinates of the examination area into the distancecontrol and coordination system.
3. Setting of the detector and video recording units according to the terrainconditions.
4. Examination of the designated area.
Main parts of the IUMD Robot System:
infra laser scanning and warning system (optional)
radio controlled menu system
microwave video recording transfer system
high sensitive and high resolution magnetometer
form recognition DSP system
1
-
7/29/2019 Intelligent Underground Mine Detection
2/6
RES-SYS Research and Development LTD. Nagykert 98, Tata 2890 HungaryTel: +36 23 415 206, +36 23 417 780, +36 30 327 4222, +36 20 953 8305Fax: +36 23 417 780 Email: [email protected]
Properties of the IUMD Robot System:
quick and precise recognition of metallic parts
detection of the location of metallic parts with up to 1 cm accuracy
precise detection of the projectiles size and identification of mines
high level of reliability
high level of applied technology
Main parts of IUMD Robot System:
8 units of magnetic locator transducer
analog-digital converter
data collector unit
measuring and analyzing unit (computer)
Possibilities of installation :
on robot with distance control
on passenger car
Detection:
Signal patterns from vertical and horizontal targets aid in determining their orientation
Raising the locator eliminates unwanted signals
2
-
7/29/2019 Intelligent Underground Mine Detection
3/6
RES-SYS Research and Development LTD. Nagykert 98, Tata 2890 HungaryTel: +36 23 415 206, +36 23 417 780, +36 30 327 4222, +36 20 953 8305Fax: +36 23 417 780 Email: [email protected]
Sensitivity and resolutions:
Searching of projectile with calibre 175 mm in depth up to 5 feet
Searching of projectile with calibre 81 mm in depth up to 3 feet
Searching of projectile MK81 in depth up to 9 feet
Back view
3
-
7/29/2019 Intelligent Underground Mine Detection
4/6
RES-SYS Research and Development LTD. Nagykert 98, Tata 2890 HungaryTel: +36 23 415 206, +36 23 417 780, +36 30 327 4222, +36 20 953 8305Fax: +36 23 417 780 Email: [email protected]
Front view
4
-
7/29/2019 Intelligent Underground Mine Detection
5/6
RES-SYS Research and Development LTD. Nagykert 98, Tata 2890 HungaryTel: +36 23 415 206, +36 23 417 780, +36 30 327 4222, +36 20 953 8305Fax: +36 23 417 780 Email: [email protected]
Side view
Size of the unit:1,5m x 0,9 m x 0,6m with setback lever3,0m x 0,9m x 0,6m during action
Weight of the unit:160 kg.
Width of the caterpillar:0,2 m
Operating time:
4-6 hours
Power system:24V Li-Ion battery, 2 x 500W motor
Charging power:220V (built-in accumulator)
Charging time:2 hours fast charge (up to 85% charging rate)6 hours normal charge ( 100% charging rate)
5
-
7/29/2019 Intelligent Underground Mine Detection
6/6
RES-SYS Research and Development LTD. Nagykert 98, Tata 2890 HungaryTel: +36 23 415 206, +36 23 417 780, +36 30 327 4222, +36 20 953 8305Fax: +36 23 417 780 Email: [email protected]
remote control unit
6