SECTION: 2.30.050FM0450

0414Supersedes

1013

COMPARE THESE FEATURES • Non-clogging vortex impeller design. Bronze class C89833• Durable cast construction. Cast iron switch case, base,

motor and pump housing. No sheet metal parts to rust or corrode. All cast iron class 30 30,000# tensile strength

• Stainlesssteelscrews,bolts,floatrod,handle,guard,arm and seal assembly

• 20' UL listed 3-wire neoprene cord and plug. Extra cord lengths available in 25'-35'-50' lengths only.

• 3 phase models available• Motor-60Hz,3450RPM,oil-filled,hermeticallysealed,

automatic reset, thermal overload protected (1 Ph only) • Maximum temperature for sewage or dewatering

130°F (54°C), 120°F (49°C) for WD295. If over 130°F, consult factory.

• Shaft seal - stainless steel carbon & ceramic rotary• Corrosionresistantpowdercoatedepoxyfinish• Upper & lower ball bearings running in bath of oil• Square ring & gasket - neoprene• All models pass 2" spherical solids• Major width 12-7/8" • Height 19-5/16" (single seal)• Automaticunitsavailablewithfloatoperated,

submersible 2-pole mechanical switch. On point 15-3/4" - Off point 5-1/4"• Specify2"or3"NPTfemaleflangedverticaldischarge.• 100% computerized testing

MODELS 4292-4293-4294-4295DOUBLE SEAL PUMPS (nonautomatic only)• Gives motor extra protection from seal leaks

• Improved bearing lubrication

• Helps eliminate seal and bearing damage from dry runs

• Major width 12-7/8" Height 21-3/16"

Note: The sizing of effluent systems normally requiresvariable level float(s) controls and properly sizedbasins to achieve required pumping cycles or dosing timers with nonautomatic pumps.

© Copyright 2014 Zoeller Co. All rights reserved.

292 - 293 - 294 - 295 Single Seal Series4292 - 4293 - 4294 - 4295 Double Seal Series

(For Pump Prefix Identification see News & Views 0052)

HIGH HEAD“WASTE-MATE”

SUBMERSIBLE

SEWAGEOR DEWATERING PUMP

DoubleSealPump

Nonautomaticmodels forvariable levelsystems

Automatic unitsavailable insingle phase 292,293, 294 & 295series

WD295 controlledby variable levelfloatswitch

*See back page for UL & CSA listings

Tested to ULStandard UL778

R LU*

*R

Certified to CSAStandard C22.2 No.108

Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies.

MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961

(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624

visit our web site:www.zoeller.com

®

Your Peace of Mind is Our Top Priority ®

SK1415

SELECTION GUIDE1. Integralfloatoperatedmechanicalswitch,noexternalcontrolrequired.

2. For automatic use single piggyback variable level float switch ordoublepiggybackvariablelevelfloatswitch.RefertoFM0477.

3. See FM1228 for correct model of simplex control panel.

4. See FM0712 for correct model of duplex control panel.

Single Seal Auto Design Weight 86-89 lbs.

For information on additional Zoeller products refer to catalog on explosion-proof models, FM1702; Simplex controls, FM1596; Piggyback Variable Level Float Switches, FM0477; Electrical Alternator, FM0486; Mechanical Alternator, FM0495; Sump/Sewage Basins, FM0487; Alarm Systems, FM0732; Disconnect/Rail Systems, FM0787; and Junction Boxes FM1597.

CAUTIONAll installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).

© Copyright 2014 Zoeller Co. All rights reserved.

PUMP PERFORMANCE CURVEMODEL 292/4292/293/4293/294/4294/295/4295

0 80 160 240 320 400 480

2201401301201101009080706050403020100

2

4

6

8

10

12

14

16

18

20

80

65

60

55

50

45

40

35

30

25

20

15

10

5

LITERSGALLONS

FEET

MET

ERS

TOTA

L DY

NAM

IC H

EAD

FLOW PER MINUTE

150 160 170 180 190 200 210

560 640 720 800

7022

292/4292

293/4293

294/4294

295/4295

75

24

CAUTIONModel 293 should notbe subjected to lessthan 15' TDH.

009919A

Double Seal Design / Weight 92-95 lbs.

294/4294Gal. Liters196 742181 685165 625150 568136 515121 45894 35658 22013 49-- --

62 ft.(18.9m)

292/4292 293/4293

199 753

115

23

8959

154140

184168

435

87

337223

583530

696636

295/4295Gal.214 810

Liters

75 ft.(22.9m)

MODELFeet Meters Gal. Liters Gal. Liters

5 1.5 530140 -- --10 3.0 469124 -- --

4.6 409108 118 447156.1 34491 108 409207.6 28475 96 363259.1 21256 82 31030

12.2 3810 48 1824015.2 ---- -- --5018.3 ---- -- --6021.3 ---- -- --70

Shut-off Head: 42 ft.(12.8m) 50 ft.(15.2m)

2" NPTOR3" NPTAVAILABLE IN A FLANGE

19 5/16" [491 mm]

6" [152 mm]

4 1/8" 8 3/4"

6 1/2"

4 1/8" [105 mm]

6 11/32" [161 mm]

[165 mm]

[222 mm][105 mm]

SK863

6 [152 mm]

4 1/8 8 3/4

6 1/2

4 1/8 [105 mm]

21 3/16 [538 mm]

4 1/8 [105 mm]

2" NPTOR3" NPTAVAILABLE IN A FLANGE

[165 mm]

[222 mm][105 mm]

009919B

* No molded plug ** Single piggyback switch included (1) UL listed unit available with 20 amp plug (2) CSA approval with 20 amp plug

292 MODELS 4292 MODELS Standard all models - 20 ft. cord - ½ HP Control Selection Listings

Single Seal Double Seal Volts Ph Mode Amps Simplex Duplex cCSAus UL

M292 -- 115 1 Auto 15.0 1 -- Y Y(1)

N292 N4292 115 1 Non 15.0 2 or 3 2 or 4 Y Y(1)

D292 -- 230 1 Auto 7.5 1 -- Y N

E292 E4292 230 1 Non 7.5 2 or 3 4 Y N

* H292 -- 200 1 Auto 8.8 1 -- Y N

* I292 * I4292 200 1 Non 8.8 2 or 3 4 Y N

* F292 * F4292 230 3 Non 5.2 3 4 Y N

* J292 * J4292 200 3 Non 6.4 3 4 Y N

* G292 * G4292 460 3 Non 2.9 3 4 Y N

* BA292 * BA4292 575 3 Non 2.4 3 4 Y N

293 MODELS 4293 MODELS Standard all models - 20 ft. cord - 1 HP Control Selection Listings

Single Seal Double Seal Volts Ph Mode Amps Simplex Duplex cCSAus UL

D293 -- 230 1 Auto 10.2 1 -- Y Y

E293 E4293 230 1 Non 10.2 2 or 3 4 Y Y

* H293 -- 200 1 Auto 12.0 1 -- Y N

I293 I4293 200 1 Non 12.0 2 or 3 4 Y N

* F293 * F4293 230 3 Non 7.6 3 4 Y Y

* J293 * J4293 200 3 Non 8.2 3 4 Y Y

* G293 * G4293 460 3 Non 4.0 3 4 Y Y

* BA293 -- 575 3 Non 3.3 3 4 Y N

295 MODELS 4295 MODELS Standard all models - 20 ft. cord - 2 HP Control Selection Listings

Single Seal Double Seal Volts Ph Mode Amps Simplex Duplex cCSAus UL

D295 -- 230 1 Auto 17.1 1 -- Y(2) Y

E295 E4295 230 1 Non 17.1 2 or 3 4 Y (2) Y

WD295 -- 230 1 Auto 17.1 ** 4 Y N

* H295 -- 200 1 Auto 20.5 1 -- Y N

* I295 * I4295 200 1 Non 20.5 2 or 3 4 Y N

* F295 * F4295 230 3 Non 12.2 3 4 Y Y

* J295 * J4295 200 3 Non 14.3 3 4 Y Y

* G295 * G4295 460 3 Non 6.1 3 4 Y Y

* BA295 -- 575 3 Non 4.9 3 4 Y N

294 MODELS 4294 MODELS Standard all models -20 ft. cord -1½ HP Control Selection Listings

Single Seal Double Seal Volts Ph Mode Amps Simplex Duplex cCSAus UL

D294 -- 230 1 Auto 13.7 1 -- Y Y(1)

E294 E4294 230 1 Non 13.7 2 or 3 4 Y Y(1)

* H294 -- 200 1 Auto 17.8 1 -- Y N

* I294 * I4294 200 1 Non 17.8 2 or 3 4 Y N

* F294 * F4294 230 3 Non 9.5 3 4 Y Y

* J294 * J4294 200 3 Non 10.8 3 4 Y Y

* G294 * G4294 460 3 Non 4.8 3 4 Y Y

* BA294 -- 575 3 Non 3.8 3 4 Y N

© Copyright 2014 Zoeller Co. All rights reserved.

© Copyright 2014 Zoeller Co. All rights reserved.

MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961

(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624

Your Peace of Mind is Our Top Priority ®

® visit our web site:www.zoeller.com