Helicopter Performance, Limitations, and Load Calculations
description
Transcript of Helicopter Performance, Limitations, and Load Calculations
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter Performance, Limitations, and Load Calculations
UNIT 5
Slide 5-1
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Unit 5 - Objectives1. Describe general aspects of helicopter
design, flight controls, and terminology.2. Define “in-ground-effect” and “out-of-
ground-effect” as they relate to helicopter performance.
Slide 5-2
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Unit 5 - Objectives3. Describe air density altitude and the effects
on helicopter performance.4. Describe the process for completing a load
calculation form.
Slide 5-3
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter Design Rotor SystemsSingle-Rotor Helicopter - The most common design uses a single main rotor which imparts lift and thrust, and a smaller tail rotor, which compensates for torque induced by the powered turning of the main rotor.
Slide 5-4
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter Design Rotor SystemsDual-Rotor Helicopter – Some helicopters have dual main rotors, mounted in tandem or side-by-side. Torque compensation is achieved by turning the rotors in opposite directions.
Slide 5-5
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignHelicopter ControlsThere are four controls that are used in conjunction with each other when flying a helicopter.
- Collective pitch control- Throttle control- Anti-torque- Cyclic control
Slide 5-6
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter Design Helicopter ControlsCollective Control This changes the angle of the pitch (of angle of attack) of each main rotor blade simultaneously. The collective is controlled by the left hand.As the pitch of the blades is increased, lift is created causing the helicopter to rise from the ground, hover or climb, as long as sufficient power is available.
Slide 5-7
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignHelicopter ControlsThrottle ControlOn the turbine-powered helicopters, this power coordination is accomplished automatically through the fuel control and governor systems of the turbine engine.
Slide 5-8
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignHelicopter ControlsAnti-Torque ControlTwo anti-torque pedals are provided to counteract the torque effect of the main rotor. This is done by increasing or decreasing the thrust of the tail rotor.
Slide 5-9
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignHelicopter ControlsAnti-Torque ControlThe anti-torque pedals accomplish this by changing the pitch (angle of attack) or the tail rotor blades.
Slide 5-10
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignHelicopter ControlsAnti-Torque ControlHeading and directional control in hover and at low air speeds as forward air speed increases, the tail rotor becomes less necessary (slip streaming effect).
Slide 5-11
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignHelicopter ControlsCyclic ControlThe “cyclic” is controlled by the pilot’s right hand. Aircraft moves in the direction that pressure is applied
to the cyclic.If the pilot moves the cyclic forward, the lift in the rear half of the rotor disk is increased, and the aircraft moves forward.
Slide 5-12
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignLanding GearSkids – Skids are the most common type of landing gear used in light and medium-class helicopters.
Slide 5-13
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignLanding GearWheels – Wheels are primarily used on medium and heavy helicopters.
Slide 5-14
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceBasic Helicopter DesignLanding GearFloats – Floats can be used on land as well as water. There are two types; fixed or inflated. “Pop Outs” are inflated only as needed.
Slide 5-15
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceHelicopter LoadingCenter of Gravity Effects
Slide 5-16
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceHelicopter LoadingCenter of Gravity Effects
Slide 5-17
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter PerformanceHelicopter LoadingFloor LoadingCareful attention must be given to small, heavy parcels loaded into helicopters to determine that the maximum pounds-per-square-inch limitations are not exceeded.
Slide 5-18
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of Flight
Being familiar with terms commonly used in helicopter flight characteristics is important to persons involved with helicopter use.
Slide 5-19
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightGround EffectA condition of improved rotor system performance encountered when the helicopter is hovering near the ground.
Slide 5-20
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations Slide 5-21
Hover-In-Ground-Effect (HIGE) occurs when helicopter is hovering approximately less than one-half the rotor diameter distance from the ground.
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations Slide 5-22
HIGE the airflow is interrupted by the ground under the helicopter; this reduces downward velocity of the air and produces an outward airflow pattern.
S-271 Helicopter Crewmember
Hover-Out-Of-Ground-Effect (HOGE) occurs when the helicopter exceeds about one-half of the rotor diameter distance from the ground, and the cushion of air disintegrates.
Unit 5 Helicopter Performance, Limitations, and Load Calculations Slide 5-23
S-271 Helicopter Crewmember
HOGE no cushion of air and maximum performance of helicopter is required. Payload may have to be reduced.
Unit 5 Helicopter Performance, Limitations, and Load Calculations Slide 5-24
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightGround Effect – Hover-Out-Of-Ground-Effect (HOGE)It is important to understand the capabilities and limitations presented by ground effect when choosing a landing site
Slide 5-25
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightGround Effect – Translational LiftTranslational lift occurs when the helicopter approaches 15 to 18 MPH indicated airspeed and when hovering with a 15 MPH steady headwind.Can be felt as an aircraft transitions from a hover to forward flight.
Slide 5-26
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightAutorotationAutorotation is a non-powered flight condition in which the rotor system maintains flight RPM by reversed airflow. It provides the pilot a means of safely landing the helicopter after an engine failure or other mechanical emergency.
Slide 5-27
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightAutorotationHelicopters have a freewheeling unit in the transmission which automatically disengages the engine from the rotor system in the event of failure. This allows the main rotor to rotate freely.
Slide 5-28
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightAutorotationWhen the helicopter is powered by the engine, airflow is downward through the rotors. During an autorotation airflow is upward, “wind milling” the rotor blades as the helicopter descends.
Slide 5-29
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightHeight Velocity DiagramIn flight manuals for each helicopter types is a chart which provides necessary information to complete a safe autorotation.
Slide 5-30
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightMaximum PerformanceTakeoff Occurs when the helicopter HOGE before or after translational lift. The helicopter is totally power dependent and the margin for safety is significantly reduced.
Slide 5-31
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations Slide 5-32
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightMaximum Performance TakeoffWhen possible, avoid confined areas, or large obstructions that require the pilot to use maximum power for extended periods.
Slide 5-33
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightDensity AltitudeDensity altitude refers to a theoretical air density which exists under standard conditions of a given altitude.
By definition, density altitude is pressure altitude corrected for temperature and humidity.
Slide 5-34
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightDensity AltitudeCan have a profound effect on aircraft performance. Air, like other gases and liquids, is fluid. It flows and changes shape under pressure. Air is said to be “thin” at higher elevations.
Slide 5-35
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightDensity AltitudeThere are more air molecules per cubic foot at sea level feet than at 8,500 feet. As density altitudeincreases, air thinsout and aircraftperformancedecreases. Slide 5-36
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightDensity AltitudeThere are three factors that affect density altitude in varying degrees; atmospheric pressure, temperature, and to some degree, humidity.
Slide 5-37
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightDensity Altitude ChartExercise - Density Altitude Chart
Density altitude affects helicopter performance.
Slide 5-38
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
8400 ft.8400 ft.
Slide 5-39
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightDensity Altitude Effects PerformanceHigh elevation, high temperature, and high moisture content all contribute to high density altitude conditions and lessen performance. Performance is reduced because the thinner air at high density altitudes reduces blade efficiency.
Slide 5-40
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightAt sea level the cool, dense air provides optimum helicopter performance.
Slide 5-41
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Principles of FlightBut at higher altitude, or hotter conditions, the air is less dense and performance is significantly reduced.
Slide 5-42
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter Load CalculationsLoad Calculation FormOne of the most important documents you will need to become familiar with is the Load Calculation Form.For a helicopter to fly safely it is critical that you obtain an allowable payload from the Load Calculation form.
Slide 5-43
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter Load Calculations• The AMD-67 and FS-5700-17 load calculation
is required for all helicopter flights conducted on interagency fires and project work.
• Any 5 degree C change in outside air temperature or any 1,000 pressure altitude feet change, a new load calculation will need to be completed to ensure safe operations.
Slide 5-44
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter Load CalculationsMany accidents have happened that involved aircraft that were operating in conditions that were too high or too hot for the weight of the aircraft.
Slide 5-45
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
3
4
5 50 gals X 7 lbs/gal
6
7a
7b
8
9
10
11
12
13
14
15
PILOT(S) Bo Duke DATE
INTERAGENCY HELICOPTER LOAD CALCULATION
Electronic Version (12/03)
MODEL Bell 407
N# 123WH
DEPARTURE Helibase PA
MISSION Initial Attack TIME
4000
OAT 25
2 DESTINATION Helispot PA 6000 OAT 20
1
HOGE- J
FUEL WEIGHT 350
OPERATING WEIGHT (3 + 4 + 5) 3467
HELICOPTER EQUIPPED WEIGHT 2911
FLIGHT CREW WEIGHT 206
PERFORMANCE REFERENCE (List chart/supplement from Flight Manual) FMS 3 4-2 FMS 3 4-4 FMS 3 4-4
Non-Jettisonable Jettisonable HIGE HOGE
WEIGHT REDUCTION (Required for all Non-Jettisonable loads) 155 155 0
COMPUTED GROSS WEIGHT (From Flight Manual Performance Section) 5000 5000 5075
GROSS WEIGHT LIMITATION (From Flight Manual Limitations Section) 5000 5000 5500
ADJUSTED WEIGHT (7b minus 8) 4845 4845 5075
OPERATING WEIGHT (From Line 6) 3467 3467 3467
SELECTED WEIGHT (Lowest of 9 or 10) 4845 4845 5075
PASSENGERS/CARGO
ALLOWABLE PAYLOAD (11 minus 12) 1378 1378 1608
ACTUAL PAYLOAD (Total of all weights listed in Item 14) Line 15 must not exceed Line 13 for the intended mission (HIGE, HOGE or HOGE-J) 0
PILOT SIGNATURE HazMat Onboard
MANAGER SIGNATURE Yes No
Slide 5-46
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter Load Calculations
3
4
5 50 gals X 7 lbs/gal
6
7a
7b
8
9
10
11
12
13
14
15
PILOT SIGNATURE HazMat Onboard
MANAGER SIGNATURE Yes No
ACTUAL PAYLOAD (Total of all weights listed in Item 14) Line 15 must not exceed Line 13 for the intended mission (HIGE, HOGE or HOGE-J) 0
PASSENGERS/CARGO
ALLOWABLE PAYLOAD (11 minus 12) 1378 1378 1608
OPERATING WEIGHT (From Line 6) 3467 3467 3467
SELECTED WEIGHT (Lowest of 9 or 10) 4845 4845 5075
GROSS WEIGHT LIMITATION (From Flight Manual Limitations Section) 5000 5000 5500
ADJUSTED WEIGHT (7b minus 8) 4845 4845 5075
WEIGHT REDUCTION (Required for all Non-Jettisonable loads) 155 155 0
COMPUTED GROSS WEIGHT (From Flight Manual Performance Section) 5000 5000 5075
PERFORMANCE REFERENCE (List chart/supplement from Flight Manual) FMS 3 4-2 FMS 3 4-4 FMS 3 4-4
Non-Jettisonable Jettisonable HIGE HOGE HOGE- J
FUEL WEIGHT 350
OPERATING WEIGHT (3 + 4 + 5) 3467
HELICOPTER EQUIPPED WEIGHT 2911
FLIGHT CREW WEIGHT 206
OAT 25
2 DESTINATION Helispot PA 6000 OAT 20
1 DEPARTURE Helibase PA
MISSION Initial Attack TIME
4000
PILOT(S) Bo Duke DATE
INTERAGENCY HELICOPTER LOAD CALCULATION
Electronic Version (12/03)
MODEL Bell 407
N# 123WH • Aircraft model• N Number• Mission• Date/Time• Departure• Destination
Slide 5-47
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter Load Calculations
3
4
5 50 gals X 7 lbs/gal
6
7a
7b
8
9
10
11
12
13
14
15
PILOT SIGNATURE HazMat Onboard
MANAGER SIGNATURE Yes No
ACTUAL PAYLOAD (Total of all weights listed in Item 14) Line 15 must not exceed Line 13 for the intended mission (HIGE, HOGE or HOGE-J) 0
PASSENGERS/CARGO
ALLOWABLE PAYLOAD (11 minus 12) 1378 1378 1608
OPERATING WEIGHT (From Line 6) 3467 3467 3467
SELECTED WEIGHT (Lowest of 9 or 10) 4845 4845 5075
GROSS WEIGHT LIMITATION (From Flight Manual Limitations Section) 5000 5000 5500
ADJUSTED WEIGHT (7b minus 8) 4845 4845 5075
WEIGHT REDUCTION (Required for all Non-Jettisonable loads) 155 155 0
COMPUTED GROSS WEIGHT (From Flight Manual Performance Section) 5000 5000 5075
PERFORMANCE REFERENCE (List chart/supplement from Flight Manual) FMS 3 4-2 FMS 3 4-4 FMS 3 4-4
Non-Jettisonable Jettisonable HIGE HOGE HOGE- J
FUEL WEIGHT 350
OPERATING WEIGHT (3 + 4 + 5) 3467
HELICOPTER EQUIPPED WEIGHT 2911
FLIGHT CREW WEIGHT 206
OAT 25
2 DESTINATION Helispot PA 6000 OAT 20
1 DEPARTURE Helibase PA
MISSION Initial Attack TIME
4000
PILOT(S) Bo Duke DATE
INTERAGENCY HELICOPTER LOAD CALCULATION
Electronic Version (12/03)
MODEL Bell 407
N# 123WH • Helicopter equipped weight +
• Flight crew weight +• Fuel weight =• Operating weight
Slide 5-48
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter Load Calculations
3
4
5 50 gals X 7 lbs/gal
6
7a
7b
8
9
10
11
12
13
14
15
PILOT SIGNATURE HazMat Onboard
MANAGER SIGNATURE Yes No
ACTUAL PAYLOAD (Total of all weights listed in Item 14) Line 15 must not exceed Line 13 for the intended mission (HIGE, HOGE or HOGE-J) 0
PASSENGERS/CARGO
ALLOWABLE PAYLOAD (11 minus 12) 1378 1378 1608
OPERATING WEIGHT (From Line 6) 3467 3467 3467
SELECTED WEIGHT (Lowest of 9 or 10) 4845 4845 5075
GROSS WEIGHT LIMITATION (From Flight Manual Limitations Section) 5000 5000 5500
ADJUSTED WEIGHT (7b minus 8) 4845 4845 5075
WEIGHT REDUCTION (Required for all Non-Jettisonable loads) 155 155 0
COMPUTED GROSS WEIGHT (From Flight Manual Performance Section) 5000 5000 5075
PERFORMANCE REFERENCE (List chart/supplement from Flight Manual) FMS 3 4-2 FMS 3 4-4 FMS 3 4-4
Non-Jettisonable Jettisonable HIGE HOGE HOGE- J
FUEL WEIGHT 350
OPERATING WEIGHT (3 + 4 + 5) 3467
HELICOPTER EQUIPPED WEIGHT 2911
FLIGHT CREW WEIGHT 206
OAT 25
2 DESTINATION Helispot PA 6000 OAT 20
1 DEPARTURE Helibase PA
MISSION Initial Attack TIME
4000
PILOT(S) Bo Duke DATE
INTERAGENCY HELICOPTER LOAD CALCULATION
Electronic Version (12/03)
MODEL Bell 407
N# 123WH • Performance reference• Computed gross weight• Weight reduction• Adjusted weight• Gross weight limitation• Selected weight• Operating weight• Allowable payload
Slide 5-49
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Helicopter Load Calculations
3
4
5 50 gals X 7 lbs/gal
6
7a
7b
8
9
10
11
12
13
14
15
PILOT SIGNATURE HazMat Onboard
MANAGER SIGNATURE Yes No
ACTUAL PAYLOAD (Total of all weights listed in Item 14) Line 15 must not exceed Line 13 for the intended mission (HIGE, HOGE or HOGE-J) 0
PASSENGERS/CARGO
ALLOWABLE PAYLOAD (11 minus 12) 1378 1378 1608
OPERATING WEIGHT (From Line 6) 3467 3467 3467
SELECTED WEIGHT (Lowest of 9 or 10) 4845 4845 5075
GROSS WEIGHT LIMITATION (From Flight Manual Limitations Section) 5000 5000 5500
ADJUSTED WEIGHT (7b minus 8) 4845 4845 5075
WEIGHT REDUCTION (Required for all Non-Jettisonable loads) 155 155 0
COMPUTED GROSS WEIGHT (From Flight Manual Performance Section) 5000 5000 5075
PERFORMANCE REFERENCE (List chart/supplement from Flight Manual) FMS 3 4-2 FMS 3 4-4 FMS 3 4-4
Non-Jettisonable Jettisonable HIGE HOGE HOGE- J
FUEL WEIGHT 350
OPERATING WEIGHT (3 + 4 + 5) 3467
HELICOPTER EQUIPPED WEIGHT 2911
FLIGHT CREW WEIGHT 206
OAT 25
2 DESTINATION Helispot PA 6000 OAT 20
1 DEPARTURE Helibase PA
MISSION Initial Attack TIME
4000
PILOT(S) Bo Duke DATE
INTERAGENCY HELICOPTER LOAD CALCULATION
Electronic Version (12/03)
MODEL Bell 407
N# 123WH • Passengers and cargo• Actual payload• Pilot signature • Manager signature• HazMat
Slide 5-50
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Unit 5 - Objectives1. Describe general aspects of helicopter
design, flight controls, and terminology.2. Define “in-ground-effect” and “out-of-
ground-effect” as they relate to helicopter performance.
Slide 5-51
S-271 Helicopter Crewmember
Unit 5 Helicopter Performance, Limitations, and Load Calculations
Unit 5 - Objectives3. Describe air density altitude and the effects
on helicopter performance.4. Describe the process for completing a load
calculation form.
Slide 5-52