HCD-GNX88diagramas.diagramasde.com/audio/Sony_HCD-GNX88.pdf · 2012. 5. 1. · Sony Corporation...

HCD-GNX88E ModelSERVICE MANUAL

MiNi Hi-Fi COMPONENT SYSTEMSony CorporationAudio GroupPublished by Sony Engineering Corporation

9-879-461-012005B02-1

© 2005.02

SPECIFICATIONS

Ver.1.0 2005. 02

– Continued on next page –

• HCD-GNX88 is the Amplifier,CD player, tape deck and tunersection in MHC-GNX88.

Model Name Using Similar Mechanism NEW

CD CD Mechanism Type CDM74-F1BD84

Section Base Unit Name BU-F1BD84

Optical Pick-up Name KSM-215DCP/C2NP

TAPE Model Name Using Similar Mechanism NEW

Section Tape Transport Mechanism Type CMAT5Z2

The following are measured at AC 127 V, 60 HzDIN power output (rated) 180 + 180 watts

(6 ohms at 1 kHz, DIN)Continuous RMS power output (reference)

225 + 225 watts(6 ohms at 1 kHz, 10% THD)

InputsVIDEO/MD (AUDIO) IN (phono jacks):

voltage 250/450 mV,impedance 47 kiloohms

TV (AUDIO) IN (phono jack):voltage 250 mV,impedance 47 kiloohms

MIC (phone jack): sensitivity 1 mV,impedance 10 kiloohms

OutputsVIDEO OUT (phono jack): max. output level 1 Vp-p,

unbalanced, Sync negative,load impedance 75 ohms

PHONES (stereo mini jack): accepts headphones of 8 ohms or moreFRONT SPEAKER: Use only the supplied speaker

• SS-GNX88SURROUND SPEAKER: Use only the supplied speaker

• SS-RSX80SUBWOOFER OUT: Use only the supplied subwoofer

• SS-WGV88

Disc player sectionSystem Compact disc and digital audio systemLaser Semiconductor laser

(λ=780 nm)Emission duration: continuous

Laser Output Max. 44.6 µW**This output is the value measured at a distance of 200 mm from the objective lens surface on the Optical Pick-up Block with 7 mm aperture.

Frequency response 2 Hz – 20 kHz (±0.5 dB)Wave length 780 – 790 nmSignal-to-noise ratio More than 90 dBDynamic range More than 90 dB

OPTICAL CD DIGITAL OUT(Square optical connector jack, rear panel)Wave length 660 nmOutput Level –18 dBm

USER

xystus_stamp2

2

HCD-GNX88

Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

Flexible Circuit Board Repairing• Keep the temperature of soldering iron around 270˚C

during repairing.• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering

or unsoldering.

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardousradiation exposure.

This appliance is classified asa CLASS 1 LASER product.This label is located on the rearexterior.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITHMARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTSLIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESECOMPONENTS WITH SONY PARTS WHOSE PART NUMBERSAPPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTSPUBLISHED BY SONY.

Tape deck sectionRecording system 4-track 2-channel stereoFrequency response 50 – 13,000 Hz (±3 dB), using Sony

TYPE I tapeTuner sectionFM stereo, FM/AM superheterodyne tunerFM tuner sectionTuning range 87.5 – 108.0 MHzAntenna FM lead antennaAntenna terminals 75 ohm unbalancedIntermediate frequency 10.7 MHzAM tuner sectionTuning rangeLatin American models: 530 – 1,710 kHz

(with the interval set at 10 kHz)531 – 1,710 kHz(with the interval set at 9 kHz)

Antenna AM loop antennaAntenna terminals External antenna terminalIntermediate frequency 450 kHz

GeneralPower requirements 127 V AC, 60 HzPower consumption 350 wattsDimensions (w/h/d) (Approx.) 280 x 360 x 398.5 mmMass (Approx.) 12.8 kgSupplied accessories: Remote Commander (1)

Batteries (2)AM loop antenna (1)FM lead antenna (1)Front speaker pads (8)Surround speaker pads (8)Subwoofer pads (4)Video cord (1)

Design and specifications are subject to change without notice.

Unleaded solderBoards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed withthe lead free mark due to their particular size.)

: LEAD FREE MARK

Unleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40°C higher than

ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350°C.Caution: The printed pattern (copper foil) may peel away ifthe heated tip is applied for too long, so be careful!

• Strong viscosityUnleaded solder is more viscous (sticky, less prone to flow)than ordinary solder so use caution not to let solder bridgesoccur such as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.

3

HCD-GNX88

TABLE OF CONTENTS

1. SERVICING NOTES ................................................ 4

2. GENERALLocation of Controls ........................................................ 5

3. DISASSEMBLY3-1. Disassembly Flow ........................................................... 73-2. Side Panel, Top Case ....................................................... 83-3. Loading Panel Assy ......................................................... 83-4. Front Panel Assy .............................................................. 93-5. Tuner Pack ....................................................................... 93-6. Tape Mechanism Deck, Mic Board ................................. 103-7. Panel Board, CD-SW Board ............................................ 103-8. CD Mechanism Deck ...................................................... 113-9. CDG Board ...................................................................... 113-10. Back Panel ....................................................................... 123-11. Primary Board ................................................................. 123-12. Power AMP PC Board Assy, Main Board ....................... 133-13. Surround Board, PA Board .............................................. 133-14. Power Transformer (T1200) ............................................ 143-15. Driver Board, SW Board ................................................. 143-16. BD84 Board ..................................................................... 153-17. Sensor Board ................................................................... 153-18. Motor (TB) Board ........................................................... 163-19. Motor (LD) Board ........................................................... 16

4. TEST MODE .............................................................. 17

5. MECHANICAL ADJUSTMENTS ....................... 21

6. ELECTRICAL ADJUSTMENTSDeck section .................................................................... 21CD Section ...................................................................... 22

7. DIAGRAMS7-1. Circuit Board Location .................................................... 267-2. Block Diagram – CDG Section – ................................... 277-3. Block Diagram – Tape Section – .................................... 287-4. Block Diagram – Main Section – ................................... 297-5. Block Diagram – AMP Section – ................................... 307-6. Block Diagram – Display Section – ............................... 317-7. Printed Wiring Board – BD84 Board – .......................... 327-8. Schematic Diagram – BD84 Board – ............................. 337-9. Printed Wiring Board – CD Mechanism Board – ........... 347-10. Schematic Diagram – CD Mechanism Board – ............. 357-11. Printed Wiring Boards – Main Board – .......................... 367-12. Schematic Diagram – Main Board (1/3) – ..................... 377-13. Schematic Diagram – Main Board (2/3) – ..................... 387-14. Schematic Diagram – Main Board (3/3) – ..................... 397-15. Printed Wiring Boards – Panel Board – ......................... 407-16. Schematic Diagram – Panel Board – ............................... 417-17. Printed Wiring Board – CD-SW, Jog, Mic Boards – ...... 427-18. Schematic Diagram – CD-SW, Jog, Mic Board – .......... 437-19. Printed Wiring Board – PA Board – ............................... 447-20. Schematic Diagram – PA Board – .................................. 457-21. Printed Wiring Board – Surround Board – ..................... 467-22. Schematic Diagram –Surround Board – ......................... 477-23. Printed Wiring Board – CDG Boards – .......................... 487-24. Schematic Diagram – CDG Boards – ............................. 497-25. Printed Wiring Board – Trans, Primary Boards – .......... 507-26. Schematic Diagram – Trans, Primary Boards – ............. 517-27. IC Pin Function Description ............................................ 54

8. EXPLODED VIEWS8-1. Case (Top), Rear Panel Section ....................................... 608-2. Front Panel Section ......................................................... 618-3. Chassis Section ................................................................ 628-4. CD Mechanism Deck Section-1

(CDM74-F1BD84) .......................................................... 638-5. CD Mechanism Deck Section-2

(CDM74-F1BD84) .......................................................... 64

9. ELECTRICAL PARTS LIST ................................ 65

4

HCD-GNX88SECTION 1

SERVICING NOTES

NOTES ON HANDLING THE OPTICAL PICK-UP BLOCKOR BASE UNIT

The laser diode in the optical pick-up block may suffer electrostaticbreak-down because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECK

The laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission, observefrom more than 30 cm away from the objective lens.

LASER DIODE AND FOCUS SEARCH OPERATION CHECK

Carry out the “S curve check” in “CD section adjustment” and checkthat the S curve waveform is output several times.

• MODEL IDENTIFICATION– Back Panel –

MODEL PART No.

Mexican model 2-547-460-0[]

PART No.

5

HCD-GNX88SECTION 2GENERAL This section is extracted

from instruction manual.

LOCATING THE CONTROLS

Main unit

ALBUM +/– ql AMP MENU ed AUTO/MANUAL3)2 CD el CD SYNC qd Deck A ea Deck B ws DIRECTION qk DISC 1 ~ 3 7 Disc tray 9 DISPLAY rd Display rf

ECHO LEVEL wf ENTER wa EQ BAND qa EX-CHANGE/DISC SKIP 6

GROOVE ehILLUMINATION rs IR Receptor r;

MASTER VOLUME 8

MIC 1 (jack) wj MIC 2 (jack) wh MIC LEVEL wg MP3 BOOSTER q; MPX4)qk OPERATION DIAL wl PHONES (jack) wk Power illuminator wd REC PAUSE/START qh

SOUND FLASH e; SPEAKERS3)1 SURROUND1) rg

SURR SPEAKER MODE2) rgTAPE A/B ej

Tape lid ws ea TUNER/BAND ek TUNING +/– qjTV eg VIDEO/MD ef X-ROUND buttons3)3

WAVE/FADER/BALANCE/RANDOM/TWISTER

X-ROUND JOG3)4 X-ROUND OFF3)1

?/1 (power) ra

Z OPEN/CLOSE 5 n N (play) qs

. > (go backward/forward) qj

m M (rewind/fast forward) ql

X (pause) qf x (stop) qg

Z A (Eject A) esB Z (Eject B) w;

1)For MHC-GNX100/GNX66/GNX60

2)For MHC-GNX88/GNX80/GNX77/GNX70/GX9900

3)MHC-GNX100 only4)For MHC-GNX88/GNX77/

GNX66

List of button locations and reference pages

ALPHABETICAL ORDER

A – D

E – L

M – R

S – Z

SYMBOLS

Top Panel

Front Panel

4

6 57

1 2 3

wk wgwhwj wf

qjqkql

w;wz

wswd

rg

rd

ra

el

ej

eg

wle;

eaesed

ef

eh

ek

r;

rs

rf8

0qa

qsqd

qfqg

qh

9

6

HCD-GNX88This section is extractedfrom instruction manual.

Remote control

ALBUM + qf ALBUM – qh CD wfCLEAR qk CLOCK/TIMER SELECT 2CLOCK/TIMER SET 4DISC SKIP qd DISPLAY wh ENTER qs

EQ qj

FM MODE 6 FUNCTION 8 PLAY MODE 5REPEAT 6 SLEEP 1

TAPE wd TUNER/BAND 7 TUNER MEMORY wg TUNING MODE 5 VOLUME +/– qg

The + button has a tactile dot.*

?/1 (power) 3 x (stop) qa X (pause) ql N (play) w; –. (go backward) ws

>+ (go forward) wa

m (rewind) q; M (fast forward) 9

* Use the tactile dot as a reference when operating the system.

ALPHABETICAL ORDER

A – E

F – Z

SYMBOLS

7

5

q;

qg

qh

qj

qk

w;

ws

wd

wg

wh

qf

qd

qs

qa

9

8

6

4

31 2

ql

wa

wf

7

HCD-GNX88SECTION 3

DISASSEMBLY

• This set can be disassembled in the order shown below.

3-1. DISASSEMBLY FLOW

3-2.SIDE PANEL, TOP CASE(Page 8)

3-3.LOADING PANEL ASSY(Page 8)

3-4.FRONT PANEL ASSY(Page 9)

3-5.TUNER PACK(Page 9)

3-14.POWER TRANSFORMER (T1200) (Page 14)

3-12.POWER AMP PC BOARD ASSY, MAIN BOARD (Page 13)

3-8.CD MECHANISM DECK (Page 11)

3-7.PANEL BOARD, CD-SW BOARD (Page 10)

3-6.TAPE MECHANISM DECK, MIC BOARD (Page 10)

3-11.PRIMARY BOARD (Page 12)

3-13.SURROUND BOARD, PA BOARD(Page 13)

3-9.CDG BOARD (Page 11)

3-10.BACK PANEL(Page 12)

3-15.DRIVER BOARD,SW BOARD(Page 14)

3-18.MOTOR (TB) BOARD(Page 16)

3-19.MOTOR (LD) BOARD(Page 16)

3-17.SENSOR BOARD(Page 15)

3-16.BD84 BOARD(Page 15)

SET

8

HCD-GNX88

Note: Follow the disassembly procedure in the numerical order given.

3-2. SIDE PANEL, TOP CASE

3-3. LOADING PANEL ASSY

1 screw (case 3 TP2) (3X8)

2 two screws (case 3 TP2) (3X12)

3 two screws (+BVTP 3X10)

4

5 PANEL (SIDE-L)

6 screw (case 3 TP2) (3X8)

7 two screws (case 3 TP2) (3X12)


9

0 PANEL (SIDE-R)

qa two screws (+BVTP 3X10)

qs

qd CASE (TOP)

CD mechanismdeck (CDM74-F1BD84)1 Turn the pulley to the arrow direction.

Front side

Pulley

2 Pull out disc tray

3

4 loading panel assy

9

HCD-GNX88

3-4. FRONT PANEL ASSY

3-5. TUNER PACK



3 screw (+BVTP 3X10)

5 screw (+BVTP 3X6)


6 front panel assy

7 connector (CN100)

8 CNP508

9 CNP509

q; connector (CN503)

lug

qa connector (CN1102)

qs connector (tape mechanism deck)


2 CNP13 tuner pack

10

HCD-GNX88

3-6. TAPE MECHANISM DECK, MIC BOARD

3-7. PANEL BOARD, CD-SW BOARD

1 two screws (+BVTP2.6 (3CR))

3 cover (TCM)


4 screw (+BVTP2.6 (3CR))

5 tape mechanism deck


7 bracket (MIC)

9 MIC board

8 knob (MIC)

1 knob vol

2 knob (AMS)

3 three screws (+BVTP2.6 (3CR))




7 three screws (+BVTP2.6 (3CR))

8 connector (CNS902)

0 PANEL board

qa CD-SW board

9 claw

11

HCD-GNX88

3-8. CD MECHANISM DECK

MAIN board

1 CD mechanism deck

4 connector (CN701)

2 CNP505

3 CNP504

5 connector (CN560)

3-9. CDG BOARD



3 CDM cover

4 screw (+BVTP 3X10)5 screw (+BVTP 3X10)

6 CDG board

12

HCD-GNX88

3-11. PRIMARY BOARD

3-10. BACK PANEL

1 connector (CN1200)


3 four screws (+BVTP 3X10)

4 four screws (+BVTP 3X10)

6 connector (CN580)

5 back panel

1 connector (CN101)

2 connector (CN201)

3 screw (+BVTP 3X8)

4 PRIMARY board

13

HCD-GNX88

3-13. SURROUND BOARD, PA BOARD

3-12. POWER AMP PC BOARD ASSY, MAIN BOARD



8 connector (CN105)

3 screw (+BVTP 3X6)


5 screw (+BVTP 3X6)


7 power amp pc board assy


q; screw (+BVTP 3X10)

qa MAIN board

4 connector (CN607)


2 two screws (transistor)

3 SURROUND board


6 holder

7 three screws (+BVTP 3X10)

8 two screws (transistor)


qa screw (+BVTP 3X10)

0 heat sink

qs bracket

qd PA board

14

HCD-GNX88

3-15. DRIVER BOARD, SW BOARD

3-14. POWER TRANSFORMER (T1200)



3 two screws

4 two screws

5 power transfomer (T1200)TRANS board

3 connector (CN703)

4 DRIVER board

6 SW board

2 wire (flat type) (CN702)

1 two screws (+BTTP (M2.6))

5 screw (+BTTP (M2.6))

15

HCD-GNX88

3-17. SENSOR BOARD

3-16. BD84 BOARD

5 two coil springs (insulator)

9 two coil springs (insulator)

6 two insulators

0 two insulators

qs screw (+BVTP 2.6x 8)

7 two screws (BVTT M2.6)

3 screw (BVTT M2.6)

2 holder (213) ASSY

8 two stoppers (BU)

qd Remove the four solderings of motor.

qf CN101 (flat type)

qg CD board

qh optical pick-up (KSM-215DCP/C2NP)

1 floating screw (+PTPWH M2.6)


qa

2 tray

3 belt (table)

5 pulley (table)

8 screw (+BTTP (M2.6))

0 SENSOR board

7 gear (geneva)

9 connector (CN731)




16

HCD-GNX88

3-19. MOTOR (LD) BOARD

3-18. MOTOR (TB) BOARD

6 Remove the two solderings of motor.

8 MOTOR (TB) board

7 table motor assy (M741)


4

3 wire (flat type) 5 core (CN742)

1 stopper

2 stopper

4 Remove the two solderings of motor.

3 MOTOR (LD) board

1 belt (loading)

5 loading motor assy (M751)


17

HCD-GNX88

[MC TEST MODE]• This mode is used to check operations of the respective sections

of Amplifier, Tuner, and Tape.

Procedure:* To enter MC Test Mode

1. Press x button, [ENTER] button and [DISC 3] buttonsimultaneously.

2. The CD ring indicators TAPE A and TAPE B indicators flashon the fluorescent indicator tube. The function is changed toVIDEO.

* Check of Amplifier

1. Press [EQ BAND] button repeatedly until a message “GEQMAX” appears on the fluorescent indicator tube. GEQincreases to its maximum.

2. Press [EQ BAND] button repeatedly until a message “GEQMIN” appears on the fluorescent indicator tube. GEQ increasesto its minimum.

3. Press [EQ BAND] button repeatedly until a message “GEQFLAT” appears on the fluorescent indicator tube. GEQ set toflat.

4. When the [VOLUME] knob is turned clockwise even slightly,the sound volume increases to its maximum and a message“VOLUME MAX” appears.

5. When the [VOLUME] knob is turned counter-clockwise evenslightly, the sound volume decreases to its minimum and amessage “VOLUME MIN” appears.

* Tape function1. When a tape is inserted in Deck B and recording is started, the

function is changed to VIDEO automatically. When [CD SYNC]

button is pressed during recording in function, ALC (AutomaticLevel Control) is turned on.

2. During recording, turn Mm knob to counter clockwiserotation will change the function to TAPE B and rewind TapeB until the recording start position and playback of Tape B isstarted. If the [REC PAUSE/ START] button is pressed for apause and pressed again to resume recording during recordingtime, when tape deck B is rewind, tape deck B will be rewinduntil the position where the pause is applied.

* To release MC Test mode.

1. To release this mode, press ?/1 button.2. The cold reset is enforced at the same time.

[COLD RESET]• The cold reset clears all data including preset data stored in

the RAM to initial conditions. Execute this mode whenreturning the set to the customer.

Procedure: 1. Press x button, [ENTER] button, and ?/1 button

simultaneously.2. The fluorescent indicator tube becomes blank for a while, and

the set is reset.

[GC TEST MODE]• This mode is used to check the fluorescent indicator tube,

LEDs, keys, VOLUME jog, OPERATION DIAL jog, AMSjog, destination, software version and VACS level.

Procedure:1. Press x button, [ENTER] button and [DISC 2] button

simultaneously.2. All LEDs and segments in fluorescent indicator tube are lighted

up. All LEDs are lighted up in red color. If the system is turnedon, the I/O LED is lighted up in green color.

3. When you want to enter the software version display mode,press [DISC 1] button. The model and destination are displayed.

4. Each time [DISC 1] button is pressed, the display changes fromMC version, GC version, CD version, CDDM version, CDMAversion, CDMB version, BDA version, BDB version, STversion, TA version, TM version and TC version in this order,and returns to the MC version display.

5. When [DISC 3] button is pressed while the version numbersare being displayed except model and destination, the date ofthe software creation appear. When [DISC 3] button is pressedagain, the display returns to the software version display. When[DISC 1] button is pressed while the date of the softwarecreation is being displayed, the date of the software creationis displayed in the same order of software version display.

6. Press [DISC 2] button, the key check mode is activated.7. In the key check mode, the fluorescent indicator tube displays

“K 0 J0V0 X0”.Each time a button is pressed, “K” value increases. However,once a button has been pressed, it is no longer taken intoaccount.“J” value increases in the manner of 0,1, 2, 3 ... if [OPERATION

DIAL] knob is turned clockwise, or it decreases in the mannerof 0, 9, 8, 7 ... if [OPERATION DIAL] knob is turned counter-clockwise.“V” value increases in the manner of 0,1, 2, 3 ... if [VOLUME]

knob is turned clockwise, or it decreases in the manner of 0,9, 8, 7 ... if [VOLUME] knob is turned counter-clockwise.

“E” value increases in the manner of 0,1, 2, 3 ... if >.knob is turned clockwise, or it decreases in the manner of 0,

9, 8, 7 ... if >. knob is turned counter-clockwise.8. When [DISC 3] button is pressed after all LEDs and segments

in fluorescent indicator tube light up, the fluorescent indicatortube displays “VACS A+B APCC”. A is VACS level which istrigger by signal level, B is VACS level which is trigger bytemperature and CC is VACS level which is trigger byAPVACS (Abuse Protection VACS).The signal level, which will trigger VACS A is shown in thecenter area.

9. When [EX-CHANGE/DISC SKIP] button is pressed after allLEDs and segments in fluorescent indicator tube light up,alternate segments in fluorescent indicator tube would lightup. If you press [EX-CHANGE/DISC SKIP] button again, anotherhalf of alternate segments in fluorescent indicator tube wouldlight up. Pressing [EX-CHANGE/DISC SKIP] button againwould case all segments lights up.

10. To release this mode, press three buttons in the same manneras step 1, or disconnect the power cord.

SECTION 4TEST MODE

18

HCD-GNX88

[VACS ON/OFF]• This mode is used to switch ON and OFF the VACS (Variable

Attenuation Control System).

Procedure:1. Press ?/1 button to turn the set ON.

2. Press x button and [ILLUMINATION] button simultaneously.The message “VACS OFF” or “VACS ON” appears.

[TUNER STEP CHANGE]• The step interval of AM channels can be toggled between 9

kHz and 10 kHz.

Procedure:1. Press ?/1 button to turn the set ON.2. Press [TUNER/BAND] button to select the “AM”.

3. Press ?/1 button to turn the set OFF.

4. Press [ENTER] button and ?/1 button simultaneously. Thesystem will turn ON automatically. The message “AM 9kSTEP” or AM 10k STEP” appears and thus the channel stepis changed.

[CD SERVICE MODE]• This mode let you move the CD sled motor freely. Use this

mode when you want to clean the optical pick-up.

Procedure:1. Press ?/1 button to turn the set ON.2. Select CD function.

3. Press x , [ENTER] button, and Z OPEN/CLOSE buttonsimultaneously.

4. The CD service mode is activated. The message “SERVICEMODE” appears.

5. With the CD in stop status, turn Mm knob to clockwiserotation to move the optical pick-up to outside track, or turn

Mm knob to counterclockwise rotation to move toinside track. The message “SLED OUT” or “SLED IN”appears.

6. To turn on or off the laser, press [DIRECTION] button. Themessage “LASER ON” or “LASER OFF” appears on thefluorescent indicator tube.

7. To release this mode, press ?/1 button.

[AGING MODE]This mode can be used for operation check of CD section.

• If an error occurs, the aging operation would stops and thestatus is displayed.

• If there are no error occurs, the aging operation wouldcontinues repeatedly.

Procedure:1. Press ?/1 button to turn the set ON2. Select CD function.3. Load three discs on the disc tray.4. Press [PLAY MODE] button to select the “ALL DISCS” mode,

and press the [REPEAT] button to select “REPEAT OFF” mode. 5. Press x button, [ENTER] button, and [EX-CHANGE/DISC

SKIP] button simultaneously.6. Aging operation is started.

7. To release this mode, press ?/1 button or disconnect thepower cord to turn the power OFF.

Aging mode sequence:

Start (from disc 1)

Disc chucking

TOC reading

Play first track for 2 seconds

Play last track for 2 seconds

EX-CHANGE open/close

Open the disc tray

Disc skip

Close the disk tray

Change the next disc

19

HCD-GNX88

Display

M*$$%%&&##00

3) Display of no disc errors

D*: The number of mechanical error (“00” is latest one)

(Rotate >. knob in the direction of either to display next

error)$$: Error type

01: Focus error02: GFS error03: Setup error

%%: Not used&&:

00: No disc judgment without chucking retry.01: No disc judgment after chucking retry.

##: The state when judged as no disc01: Stop02: Setup03: TOC reading04: Access05: Playback06: Pause07: Manual search (Play)08: Manual search (Pause)

[CD REPEAT 5 LIMIT OFF MODE]• The number of repeat for CD playback is 5 times when the

repeat mode is “REPEAT ALL”. This mode enables CD torepeat playback for limitless times.


3. Press x button, [CD] button and [DISC 1] buttonsimultaneously to enter the CD repeat 5 limit off mode andthe fluorescent indicator tube displays “LIMIT OFF”.

4. To release this mode, operate the cold reset. (Refer to the “MCCOLD RESET”)

[CD SHIP MODE (WITH MEMORY CLEAR)]• This mode moves the optical pick-up to the position durable

to vibration and clears all data including preset data stored inthe RAM to initial conditions. Use this mode when returningthe set to the customer after repair.


3. Press x button, [CD] button and ?/1 button simultaneously.The set will power off automatically.

4. After the “STANDBY” blinking display finish, a message“LOCK” is displayed on the fluorescent indicator tube andthe CD ship mode is set.

Display

D*$$%%&&##00

• Display when an error occurred (CD Error Code Mode)Procedure:

1. Press x button, [ENTER] button and [DISC 1] buttonsimultaneously to enter the error code display mode.

2. The fluorescent indicator tube displays the number of totalerror.

3. Each time Mm knob is rotated, display change asbelow.

Display of total error

> + direction – . direction

Display of Mechanical errors

> + direction – . direction

Display of no disc errors

4. To clear the error record, operate the cold reset. (Refer to the“MC COLD RESET”)

5. To release this mode, press the ?/1 button or disconnectthe power plug to turn the power OFF.

1) Display of total error

EM**: The number of mechanical errors.ED**: The number of no disc errors after chucking the disc.

2) Display of mechanical errors

M*: The number of mechanical error (“00” is latest one)

(Rotate >. knob in the direction of either to display nexterror)$$: Not used%%: Loading related error (Second figure is not used)

D: Stop by the problem other than mechanical problem whileclosing.

E: Stop by the problem other than mechanical problem whileopening.

C: Stop by the problem other than mechanical problem whilechucking up.

F: Stop by the problem other than mechanical problem whilechucking down.

&&: Emerging error01: Stop while chucking up.02: Stop while chucking up.03: Time-out of EX-CHANGE open.05: Time-out of EX-CHANGE close.

##: Not used

Display

EM**ED**

20

HCD-GNX88

[CD TRAY LOCK MODE]• This mode let you lock the disc trays. When this mode is

activated, the disc tray will not open when Z OPEN/CLOSEbutton or [EX-CHANGE/DISC SKIP] button is pressed. Themessage “LOCKED” will be displayed in the will be displayedon the fluorescent indicator tube.


3. Press x button and Z OPEN/CLOSE buttonsimultaneously and hold down until “LOCKED” or“UNLOCKED” displayed on the fluorescent indicator tube(around 5 seconds).

[VIDEO/MD SWITCHING]• This mode let you switch from VIDEO to MD and vice-versa.

Procedure:1. Press ?/1 button to turn the set ON.2. Select VIDEO function.

3. Press [VIDEO/MD] button and ?/1 button simultaneously.The function will change to MD. Press the same buttons againto change from MD to VIDEO.

[REMOTE COMMANDER DISABLE MODE]• This mode let you disable the remote commander reception.

When this mode is activated, the set will not response if thebutton on the remote commander is pressed. The message“RemoteDisable” will be displayed on the fluorescent indicatortube. Use this mode during aging to avoid disturbance.

• Procedure:

1. Press x button, [GROOVE] button and [DISC 2] buttonsimultaneously.“RemoteDisable” displayed on the fluorescent indicatortube. To enable the remote commander reception, press thesame buttons again.“RemoteEnable” displayed on the fluorescent indicatortube.

[CD SHIP MODE (WITHOUT MEMORY CLEAR)]• This mode moves the optical pick-up to the position durable

to vibration. Use this mode when returning the set to thecustomer after repair.


3. Press [CD] button and ?/1 button simultaneously. The setwill power off automatically.

4. After the “STANDBY” blinking display finish, a message“LOCK” is displayed on the fluorescent indicator tube andthe CD ship mode is set.

[CD POWER MANAGE]• This mode let you switch on or off power supply to the BU

during TUNER function.• When CD POWER is set to OFF, the power supply to the BU

is cut off during TUNER function. It will increase the timetaken to access CD when function change from TUNER toCD but it will improve tuner reception.

• When CD POWER is set to ON, the power supply to the BUis not cut off during TUNER function. It will reduce the timetaken to access CD when function change from TUNER toCD but it will decrease tuner reception performance.


3. Press ?/1 button to turn the set OFF.

4. Press x button and ?/1 button simultaneously. The setwill power on automatically.

5. The message “CD POWER ON” or “CD POWER OFF” willbe displayed on the fluorescent indicator tube.

21

HCD-GNX88

SECTION 5MECHANICAL ADJUSTMENTS

SECTION 6ELECTRICAL ADJUSTMENTS

Precaution1. Clean the following parts with a denatured alcohol-moistened

swab:record/playback heads pinch rollerserase head rubber beltscapstan idlers

2. Demagnetize the record/playback head with a headdemagnetizer.

3. Do not use a magnetized screwdriver for the adjustments.4. After the adjustments, apply suitable locking compound to

the parts adjusted.5. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.

Torque Measurement

3.06 N • m to 6.96 N • m

FWD CQ-102C 31 to 71 g • cm

(0.43 – 0.98 oz • inch)

FWD0.19 N • m to 0.58 N • m

back tensionCQ-102C 2 to 6 g • cm

(0.02 – 0.08 oz • inch)

3.06 N • m to 6.96 N • m

REV CQ-102RC 31 to 71 g • cm

(0.43 – 0.98 oz • inch)

0.19 N • m to 0.58 N • mREVCQ-102RC 2 to 6 g • cmback tension

(0.02 – 0.08 oz • inch)

6.96 N • m to 14.02 N • m

FF/REW CQ-201B 71 to 143 g • cm

(0.98 – 1.99 oz • inch)

9.80 N • m

FWD tension CQ-403A 100 g or more

(3.53 oz or more)

9.80 N • m

REV tension CQ-403R 100 g or more

(3.53 oz or more)

Mode Torque meter Meter reading

0 dB=0.775 VDECK SECTION

1. Demagnetize the record/playback head with a headdemagnetizer.

2. Do not use a magnetized screwdriver for the adjustments.3. After the adjustments, apply suitable locking compound to the

parts adjust.4. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.5. The adjustments should be performed in the order given in

this service manual. (As a general rule, playback circuitadjustment should be completed before performing recordingcircuit adjustment.)

6. The adjustments should be performed for both L-CH and R-CH.

7. Switches and controls should be set as follows unless otherwisespecified.

• Test Tape

RECORD/PLAYBACK HEAD AZIMUTH ADJUST-MENT

DECK A DECK B

Note: Perform this adjustments for both decksProcedure:

1. Mode: Playback

Tape Signal Used forP-4-A100 10 kHz, –10 dB Azimuth Adjustment

set

MAIN boardCN510Pin 1 (L-CH)Pin 3 (R-CH)

MAIN boardCN510Pin 2 (GND)

+–

level meter

test tapeP-4-A100(10 kHz, –10 dB)

22

HCD-GNX88

2. Turn the adjustment screw and check output peaks. If the peaksdo not match for L-CH and R-CH, turn the adjustment screwso that outputs match within 1dB of peak.

3. Mode: Playback

4. After the adjustments, apply suitable locking compound tothe pats adjusted.

Adjustment Location: Playback Head (Deck A).Record/Playback/Erase Head (Deck B).

Screwposition

L-CHpeak

within1dB

Outputlevel

L-CHpeak

R-CHpeak

within1dB

Screwposition

R-CHpeak

MAINboardCN510set

test tapeP-4-A100(10 kHz, –10 dB)

pin 3

oscilloscope

L-CH

R-CH

V H

waveform of oscilloscope

in phase 45° 90° 135° 180°

good wrong

pin 2

pin 1

L

R

CD SECTION

Note:1. CD Block is basically designed to operate without adjustment.

Therefore, check each item in order given.2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.3. Use an oscilloscope with more than 10MΩ impedance.4. Clean the object lens by an applicator with neutral detergent

when the signal level is low than specified value with thefollowing checks.

S-curve CheckConnection:

Procedure:1. Connect an oscilloscope to test point TPO102 (FE1) and TP

117(VC) on the BD84 board.2. Turn the power on.3. Put the disc (YEDS-18) in and turned power switch on again

and actuate the focus search. (actuate the focus search whendisc table is moving in and out)

4. Check the oscilloscope waveform (S-curve) is symmetricalbetween A and B. And confirm peak to peak level within2.4 ± 1 Vp-p.

S-curve waveform

Note:• Try to measure several times to make sure than the ratio

of A : B or B : A is more than 10 : 7.• Take sweep time as long as possible and light up the

brightness to obtain best waveform.

Checking Location: BD84 board (SIDE B) (See page 24.)

+–

BD84 board

TPO102 (FE1)TP117 (VC)

oscilloscope

A

B

symmetry

within 2.4 ± 1 Vp-p

forward reverse

23

HCD-GNX88

RFAC Level CheckConnection:

Procedure:1. Connect an oscilloscope to test point TP124 (RFAC) and TP

117(VC) on the BD84 board.2. Turn the power on.3. Put the disc (YEDS-18) in to playback the number five track.4. Confirm that oscilloscope waveform is clear and check RFAC

signal level is correct or not.Note: A clear RFAC signal waveform means that the shape “◊” can be

clearly distinguished at the center of the waveform.

RFAC signal waveform


E-F Balance CheckConnection:

Procedure:1. Connect an oscilloscpe to test point TPO103 (TE1) and TP117

(VC) on the BD84 board.2. Turn the power on.3. Select the function “CD”.

4. Press three buttons of [ENTER], M , and[SURRUUND MODE] simultaneously to set the CD servicemode.

5. Put the disc (YEDS-18) in to playback the number five track. 6. Press the . button. The message “TRAVERSE” is

displayed. (The tracking servo and the sledding servo areturned OFF)

7. Check the level B of the oscilliscope's waveform and the A(DC voltage) of the center of the Traverse waveform.Confirm the following :A/B x 100 = less than ± 22%

Traverse Waveform

8. Press the . button. The message “TRAVERSE” isdisplayed. (The tracking servo and sledding servo are turnedON)Confirm the C (DC voltage) is almost equal to the A (DCvoltage) is step 5.

9. To exit from this mode, perform as follows.1) Move the optical pick-up to the most inside track.

2) Press three buttons of x , [CLEAR], and [DISPLAY]

simultaneously. (cold reset)Notes:

• Always move the optical pick-up to most inside trackwhen exiting from this mode. Otherwise, a disc will notbe unloaded.• Do not run the sled motor excessively, otherwise the gear

can be chipped.

Traverse Waveform


+–

BD84 board

TP124 (RFAC)TP117 (VC)

oscilloscope

VOLT/DIV: 200 mVTIME/DIV: 500 ns

level: 0.9 ± 0.4 Vp-p

+–

BD84 board

TPO103 (TE1)TP117 (VC)

oscilloscope

0V

B

level: 1.0 ± 0.5 Vp-p

Center of the waveform

A (DC voltage)

0V

Tracking servoSled servo

ON

C (DC voltage)

Tracking servoSled servo

OFF

24

HCD-GNX88

Checking Location:

– BD84 BOARD (SIDE B) –

TP117 (VC)

TP124 (RFAC)

JPO103 (TE1)

JPO102 (FE1)IC101

25

HCD-GNX88

SECTION 7DIAGRAMS

For schematic diagrams.Note:• All capacitors are in µF unless otherwise noted. (p: pF)

50 V or less are not indicated except for electrolytics andtantalums.

• All resistors are in Ω and 1/4 W or less unless otherwisespecified.

• % : indicates tolerance.• f : internal component.• 2 : nonflammable resistor.• 5 : fusible resistor.

• C : panel designation.• A : B+ Line.• B : B– Line.• H : adjustment for repair.• Voltages and waveforms are dc with respect to ground

under no-signal conditions.BD84 board no mark: CD PLAYOther board no mark: TUNER (FM/AM) ( ) : CD PLAY < > : TAPE PLAY [ ] : TAPE REC

* : Impossible to measure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Signal path.F : TUNER (FM/AM)E : TAPE PLAY (DECK A)d : TAPE PLAY (DECK B)G : RECORDJ : CD PLAYN : MIC INPUTc : CDGg : VIDEO

Note: The components identified by mark 0 or dotted linewith mark ! are critical for safety.Replace only with part number specified.

(The other layers' patterns are not indicated.)

• Indication of transistor.

Caution:Parts face side: Parts on the parts face side seen from(Side A) the parts face are indicated.Pattern face side: Parts on the pattern face side seen from(Side B) the pattern face are indicated.

C

B

These are omitted.

E

Q

B

These are omitted.

C E

Q

B

These are omitted.

C E

Q

Note on Printed Wiring Boards:Note:• X : parts extracted from the component side.• : Pattern from the side which enables seeing.

26

HCD-GNX88

7-1. CIRCUIT BOARD LOCATION

CD-SW board

TRANS board

PA board

SURROUND board

SWITCHING POWER

TUNER PACK

PRIMARY board

CDG board

MAIN board

MIC board

JOG board

PANEL board

MOTOR (LD) board

SW board

SENSOR board

BD84 board

DRIVER board

MOTOR (TB) board

HCD-GNX88

2727HCD-GNX88

7-2. BLOCK DIAGRAM – CDG SECTION –

MP3 STBMP3 REQ

XTCN

MP3 REQ

MP3 STB

MP3 CLKMP3 CLK

MP3 ACKMP3 ACK

MP3 DATA OUTMP3 DATAMP3 LP

MP3 LP

MP3 CSMP3 RST

MP3 CSMP3 RST

MP3 DATA IN

SCOR

SENSCD-CLK

XLAT

CD-DATA

XRST

XTCN

SCOR

SENSCLOCK

XLT

DATA

XRST

R-CH

CD-L

CD MUTE

AMAIN

SECTION(Page 29)

BDISPLAYSECTION(Page 31)

IC731(TABLE SENSOR)

IC701(LD)MOTOR DRIVER

42

97

RINFIN

OUT1OUT2

IC712TBL MOTOR DRIVER

42

97

RINFIN

OUT1OUT2

LMR

LMF

TM-R

TM-F

TBL_SENSE-1

E-2

E-3OPEN SW

Q731

M751(LOADING)

M741(TBL)

RE701

S751(LEVER SW)

ROTARYENCODER

E-3E-2E-1

INVERTER

M

M

D+3.3V

OPTICAL PICK-UPBLOCK

(KSM-215DCP/C2NP)

LDDRIVER

Q10

CD DIGITALOUT

OPTICAL

CD MUTEQ250,251

+3.3V

LD

GND

FOCUSCOIL

F+

F

T+

TTRACKING

COIL

IC251

X17116.9MHz

SL/SP MOTORDRIVER

12

6

11

13

14

VR

PD

15

16

17

18

4

26

23

2

20MUTE

CH2OUT-F

CH1FIN

OUTVREF

CH1RIN

CH2FIN

SFDR

OPIN+

CH2OUT-R

CH1OUT-R

CH1OUT-F

CH4OUT-R

CH4OUT-F

CH3OUT-F

CH3OUT-R

M

M

M101(SPINDLE)

M102(SLED)

S101(LIMIT)

VCC

VC

A

B

C

D

E

F

DETECTOR

A

B

E19

F20

LD36

PD37

TFDR11

FFDR13

CH3FIN 9

OPTICALOUT3

SSTP7

MPD6

95XTACN

100XRST

102DATA

104XLAT

105CLOCK

86AOUT2

81AOUT1

71DOUT

61PCMD1

62LRCKI

63LRCK

65PCMD

DIGITAL SIGNALIC301

PROCESSOR

SYSTEMIC401 (1/5)

CONTROL

IC210

21

40

SDO011

LRCKIA16

SFSY/LRCK1B19

SDI014

77 XTAO

78 XTAI

55VDD

VDD

VDDM

26

25 VC

27

C28

D29

107SENS

XTCN

XRST

DATA

XLT

CLOCK

SENS

113GFS

114C2PO

TRDR

NC

NC12

22 SRDRCH3RIN 10

CH2RIN FRDR14

XRST100

66BCK

60BCK1

BCKIA15

SBSY/BCK1B18

5

+3.3V

IC303

7

5 1

326

27

25

7

5

24

23

22

46

45

44

43

39

42

41

6

19

21

40

38

18

3

2

1

28

35

37

STANBY

36PO11/BUCK/AD1

8MIACK7MICK

6MIDIO

4MICS

5MILP

2RESET

41SRMSTB

115SCOR SCOR

REG

CD MUTE DRIVEQ540, 541

IC101RF AMP

IC1002DRAM

IC1001VIDEO D/A

IC1003+5V REG.

IC1006VIDEO BUFFER

25,2

7,29

,30

VA0-7

15-2

2

VD0-3

1442623

RASCAS

A0-7

DQ1-4

X100214.31818MHz

60

XO1

59

XI1

X100117.734475MHz

58

XO2

57

XI2

+B SWITCHQ1007,1008

NO402

CN402

IIC-CLK

IIC-DATA

IIC-CLK

IIC-DATA

3

4

CNVSSJ1001

TXD1

RTS1 ON BOARDPROGRAMCLK1

RXD1

CN VSS

RESET

RESET

VIDEOOUT

VMUTE

133 WE2822 CE

3

2

6

9

7

8

RASCASWECE

398 DATASBSO

5110 SFSYWFCK

299 CLCKEXCK

6MUTE

56PDOWN

1,2,

24,2

59-

12,1

4-17

9 854

Q1004SBSY

Q1005,10096

3 41 2

11 1013 12

IC1005

Q1010

VCC55SENTSC

54RESETQ1002,1006

Q1003

52DEN

37GDET

MUTE DATA

HALT_CLK

PAL/_NTSC

CDG-RST

CDG/_BDG

CDG-DET

CDG/-POWER

CDG/_BGC

CDG/-DET

44VDOUT

Q1001

34 33 31 32 9

MUT

E DA

TA

HALT

_CLK

VMUT

E

CDG-

RST

CDG/

_BDG

CDG-

DET

CDG-

POW

ER

CNVC

C

VMUT

E

CDG

RST

CDG/

BDG

CDG

DET

CD P

OWER

CNVC

C

VMUTE

CDG-POWER

1

423

PWR

VINSAVE

6VCC

VOUT

1 3VIN VOUT

: CD

: CDG

• SIGNAL PATH• R-CH is omitted due to same as L-CH.

: VIDEO

HCD-GNX88

2828HCD-GNX88

7-3. BLOCK DIAGRAM – TAPE SECTION –

ST-L E MAINSECTION(Page 29)

REC-OUT-LD

MAINSECTION(Page 29)

TC BLOCK

32

A TRIGDRIVE

: PLAYBACK (DECK B): PLAYBACK (DECK A)

R-CH

FM/AM TUNER UNIT

CN509

ANTENNA

ST-L

FM ANT

AM ANT

AM ANT

ST-R

TUNED

ST-DINST-DOUT

ST-CLKST-CE

FM 75 COAXIAL

CAP M+

BTRGM+

ATRGM+

AHALFBHALFAPLAYBPLAY

B SHUTA SHUT

REC(FWD)REC(REV)

CAPM-CONT

B-TRIG

A-TRIGTC-RELAY

A-HALFB-HALFA-PLAYB-PLAY

BSHUTASHUT

REC BIASPB-A/B

ALCREC-MUTETC-MUTE/IO-EXP DATA OUT

AM

EQ OUT1A

B

TUNED

MC DOUT(ST)MC DIN(ST)ST-CLKST-CE

34

28 27 26

2421

5659

586765

908951479448

95

91

83

50

49

5753

B TRIGDRIVE 55

CAP MOTORDRIVE 54

88

8684

8785

13 11 15 14

PB OUT1TAI1

REC IN1

AIN1

BIN1

A/B

ALC

ON/O

FF

REC

MUT

E ON

/OFF

MUT

E ON

/OFF

DECK A/B SELECTPB/REC EQUALIZER AMP

IC301

Q340, 343

Q342, 345

Q341,344

SYSTEM CONTROL(CD/TAPE MECHANISM CONTROL)

IC401(2/5)

REC-OUT1EQ

TC-PB-L

TESTCONNECTOR

CN510

R-CH

R-CH

R

L

CMAIN

SECTION(Page 29)

MUTEQ280

MUTE DRIVEQ542, 543

PBHEAD

DECK-A

DECK-B

BIAS OSCQ370

BIASTRAP

SWITCHDRIVE

Q377, 379

SWITCHDRIVE

Q382, 383

R-CH

R-CH

Q376

Q373, 374

Q381

L – CH

R – CH

R-CH

C174, L104

BIAS+9V

REC/PBHEAD

ERASEHEAD Q378,380

T301

L – CH

R – CH

: TUNER (FM/AM)

: RECORD


CN102

SW VOL IN

SW AD KEYSYSTEMCONTROL

SW ON LED

SW LED2

SW LED1

SW VOLAD-KEY

LED-SW-ON

LED CTRL2

LED CTRL1

2

1

3

45

HCD-GNX88

2929HCD-GNX88

7-4. BLOCK DIAGRAM – MAIN SECTION –

J101

C(Page 28)

(Page 28)

D(Page 28)

E

R-CH

VOLUMECONTROL

CPUINTERFACEINPUT

SELECTSWITCH

SURROUND ORDPL BUFFER

MID/BASS &TREBLE

R-CH

R-CH

COMMAND

TOUT1OUT1

VOLIN1

+

Q101

R-CH

R-CH

SPEANA

DBFB F/B

F-R

F-L

SW OUT

+

+

+

RV1100

MIC AMPIC1100 (2/2)

INPUT SELECT SWITCH,GRAPHIC EQUALIZER CONTROL,

ELECTRICAL VOLUMEIC101

SYSTEM CONTROLIC401(3/5)

SURROUNDVOL CONTROL

IC201

INA1

INEX1

INC1

SAOUT DATA

CLK

BB-A

1

BB-B

1

SWOUT

REC-OUT-L

R-CH

TC-PB-LTAPE SECTION

TAPE SECTION ST-L

(Page 27)ACD SECTION CD-L

VREF

DATA CLOCK

M16

530-

DATA

M16

530-

CLK

LINE

MUT

E

M61

529-

DATA

M61

529-

CLK

NC

NC

NC

NC

NCNC

NC

NC

NC

VREF

NC

NC

NCNC

NC

NC

NC

NC

R-CH

LINE-MUE

J1101(1/3)

J1101(2/3)

L

R

MD/VIDEOAUDIO

IN

L

R

TVAUDIO

IN

LPF

I/F

2

14 15

24

18

22 1621

6

35

INB1IND1

4

19

41

40

37

39

38

MIC 2MIC AMP

IC1100(1/2)

ECHO LEVEL

MIC LEVEL

17

8

MIC

RECB

1

7

MIC OUT

CAB

CAB

A+9V

34

2 33

32

+

2

13

9

6 7

DIGTALECHO

IC1101LPF2OUT

LPF1IN

13 12

6 5

10 9

15 24

14

79 80 81 8266

+

AMPSECTIONH

G

F

(Page 30)

AMPSECTION(Page 30)

DISPLAYSECTION

TAPESECTION

(Page 31)

11

431

25

35

30

29

87

23

2827

2622

3

MUTEQ180, 181VREF

VREF

Q544,545BUFFER

17 18

J1100(1/3)

J1100(2/3)

J1101(3/3)

J1100(3/3)

MIC 1

: TUNER (FM/AM)

: CD: TAPE PLAY: RECORD: MIC INPUT


HCD-GNX88

3030HCD-GNX88

7-5. BLOCK DIAGRAM – AMP SECTION –

IC600POWER AMP

IC800POWER AMP

IC550OVER CURRENT

PROTECTOR

: FM

MUTINGQ604, 606, 610

F-R

DBFB F/B

F-L

SW OUT

LINE-MUTE

78 70

STK-

MUT

E

52

THER

MAL

VAC

S

PROT

STK-

MUT

E

14

14

11

4

3

12

STK MUTE

FAN DET

FAN-CTL

FAN-ONFAN-K

OVER LOADDETECT

Q668, 618

+ +

+

+

MUTINGQ640, 641

MUTINGCONTROLQ634,682

F-RE

LAY

HP-D

ET

HP-M

UTE

FAN-

K

100

HD D

ETT

75

HP-M

UTE

77

LINE

/SUR

R-RL

Y

76

FR-R

ELAY

36

FAN

KICK

-OFF

OVER LOAD DETECT

Q800, 850

RELAY DRIVEQ644, 647

H/P

DET

F-RE

LAY

HP-MUTE

+-

-+

FRONT SPEAKER

SUB WOOFEROUT

L

R

PHONESJ1103

RY646

SYSTEM CONTROLLERIC401 (4/5)

TM600

+-

-+

SURR SPEAKER

L

R

TM601

MAINSECTION(Page 29)

HMAINSECTION(Page 29)

MFAN MOTOR

DRIVEQ580,581,584

DC FANM891

VL(AC)

TH629

TH630

THERMALDETECT

Q628, 630

THERMALDETECT

Q629

SW MUTEQ812

MUTEQ810

Q583

+

68

SW R

Y/IO

-EXP

CLK

RY862

TM101

RELAY DRIVEQ814, 815

G

DISPLAYSECTION(Page 31)

J

DISPLAYSECTION(Page 31)

I

6

4

OVERLOAD

DC DETVP

OCP

CT

OUT

D624

D812

D550

2

1

PROTECTSWITCH

Q666

Q648

PROTECTSWITCH

Q385

18 1110

914 8

-7

5

• SIGNAL PATH

HCD-GNX88

3131HCD-GNX88

7-6. BLOCK DIAGRAM – DISPLAY SECTION –

FL901FLUORESCENT

INDICATOR TUBE

9,10

, 12

– 22

,24

– 4

1, 4

3 –

478

– 1,

100

– 9

6,92

-85

P1 –

36

G1 –

13

G17-

24

64 –

66

93–9

5

BPF4

1

BPF, RECT

IC904

67

6816

2

15 69

71

48

80

ALL BAND

BPF3

BPF1

IN2

IN1

VKK

SELECTOR

G14-16G14-16

G1-13,G17-24

13

17

74 VOLUMEROTARYENCODER

S970VOLUME

97 BPM DET

76 AMSROTARYENCODER

S916

XAMP

SECTION(Page 30)

J

XAMPSECTION(Page 30)

I

XMAINSECTION(Page 29)

F CDSECTION(Page 27)

BSPEANA

BPM LOW

FAN CTL

P1 – 36

VF1VF2

D905-VG

(-32V)

X9014MHz

83 XIN

82 XOUT

57–

59,

72,7

8,79 LED DRIVE

Q908-913,915,916,918-920

D907, D914,915,916,918,D919,921,923,926

D906, 908 – 913D 917,D925,920,922,924

LED+9V

Q905

Q907

Q904

Q906

D902(R)

D927(G)

KEY2 |

KEY0

S1149-1160S910,911,918,920,924S901 – 904, 912,915,917

60IIC DATA

55LED VIDEO

49MD0

51MD2

52LED CD/DVD

53LED TUNER

54LED TAPE

56LED STOP,PAUSE

61IIC CLK77RESET

30 IIC-DATA29 IIC-CLK

IIC-DATA

IIC-CLK

71 GC-RESET

74 POWER-KEY

73 DISPLAY-KEY

S925

S900DISPLAY

72 STBY-LED/FAN CTL

4 SIRCS

RESET

X40216MHz

15 X-IN

13 X-OUT

X40132.768kHz

10 XC-IN

11 XC-OUT

32CD-POWER

SYSTEM CONTROL

IC401 (5/5)

69STBY-RY

12RESET

20AC-CUT

B+ SWITCHQ560, 561

B+ SWITCHQ504, 505

RECTD560

M +9V

MT +7V

A +9VTC +9V

D561 – 563

D660, 661

+9VREGULATOR

IC561+9V

REGULATOR

IC560

+3.3VREGULATOR

IC562+3.3V

LED+9V

BIAS+3.3V

LEVELDETECT

IC402

D505

SWITCHINGREGULATOR

LED DRIVEQ900,903,917

RECTD658

RECTD656

+VL

VL(AC)

F1261 VL

VL

VH

VH

VP

VF

VF

AC3

AC4NC

NCAC4

AC3

GNDF1271

F1241

F1251

F1281

R1292

–VL

+VH

–VH

– 33VREGULATOR

Q1264

POWER ON/OFFRELAY DRIVE

Q1200

– VG(-32V) D1292

RECT

VF1

VF2

RY1200

CN1202

AC IN

T1200POWER

TRANSFORMER

RESETSWITCH

Q501

REMOTE CONTROLRECEIVER

IC903

TO FLUORESCENTINDICATOR TUBE

FL901

EVER +4V

M+9V

D3.3V

DISPLAY CONTROLKEY CONTROL

IC902BUFFERQ901,902,914

70 BPF214

75 JOGROTARYENCODER

S1161OPERATION

DIAL

1 2

CNS901

MD0

MD2

TESTCONNECTOR

INT0

INT1

SIO

SOO

2

1

3

6

4

5

. - TUNING + >

HCD-GNX88

3232HCD-GNX88

7-7. PRINTED WIRING BOARD – BD84 BOARD – • See page 26 for Circuit Boards Location.

Ref. No. Location

IC101 E-9IC251 C-7IC301 C-9IC303 B-10

Q10 F-4

• SemiconductorLocation

TP117(VC)

JPO103(TE1)

JPO102(FE1)

TP124(RFAC)

B13

R412

R422

R406

R252

R251

R182

R181

R423

R151

R143

R142R141

R133

R132

R131

R114

R113

R112 R111

IC303

IC251

CN101

C252

C251

C194

C181

IC101

C162

C143

C142C141

C133

C132

C131

C124

C111

C122

C115

C114

C113

C112

C185

C186

R204

R203

C161 R161

C211

C317

R306

C212

IC301

C163

C320

C213

R421

C306

C307

C309

C310

C311

C313

R307

R163

R301

R303

R305

R351

R352

R353

R354

R401R402

R403R404

R405

R407 R4

08

R409

R410

R419

R411

CN20

1

S101(LIMIT)

M101SPINDLEMOTOR

M102SLED

MOTORM

M

13

4 5

116

17

32

64

49

33 48

AMAIN

BOARD(Page 36)

OPTICAL PICK-UPBLOCK

(KSM-215DCP)

C10

C260

C14

C15 C16

C18

C11

R253

R191

R172

R171

R162

C209 X1

71

R12

R11

R10Q10

E

C116

C184

C183

C303

C302

C305

C259

C258

C257

C255

C203

C196

C195

C201 C182

C171

C172

C210

C151

C134

C125

C123

R165

R13

C17

FB30

1

R201 R173

R205

C174

C318

C314

C308

C312

R313C315

R302

C316

11(11)1-864-566-

BD84 BOARD (SIDE A) BD84 BOARD (SIDE B)

11(11)1-864-566-

2 3 4 5 6 7 8 9 10 11

A

1

B

C

D

E

F

G

: Uses unleaded solder.

HCD-GNX88

3333HCD-GNX88

7-8. SCHEMATIC DIAGRAM – BD84 BOARD – • See page 52, 53 for IC Block Diagrams. • See page 52 for Waveforms. • See page 52 for IC Pin Function Description.

JPO004

JPO10

JPO102

JPO103

C307

C309

C308

R303

C310

C311

R306

C312 C313C314

C316 C315

R313

C320

C306

R351

C305

C302

R182

R181 C183

C184

C162

C174

R173

C161

R203

R151

C151

C143C142

R143R132 R133

C133

C132

C124 C122

C125

C131

R131 R121

C123C134

C141

R142

R141

C111C112C113C114

R112

R114

R111

R113

C115

C195

R191C163

R165

C210

R162R163

C196

IC101

C185

C181

C182

C201C209C203

R204 R423

R422R421

C213

R411R410R409R408R407R406R412

C211

C212

R205

CN201

R302

C318

R301 R305C317

R401

R402

R405R404

R419R403

C194

C17R12

R11

C16

R10

C18

C11 C10

C14

C15 CN101

R252

R251

R253 C258

C259

C257C252

C260 C255

M102

M101

IC301

C251

R13

R307

IC303

C171C172

R172

R171

IC251

Q10

S101

C116X171

R352 R354 R353

R161

C186

R201

FB301

TP117

TP124

C303

MDP

APC

FEI

TEI

0.1

0.1

474V

100k1/10W

0.1

0.1

0

0.1 0.1474V

0.0022 0.1

2201/10W

0

0.1

1001/10W

2204V

0.1

1001/10W

1001/10W

226.3V

226.3V

0.1

0.1

0

0.1

0

0

10010V

0.10.0015

3.3k1/10W 10k

1/10W180k

1/10W0.01

0.47

330p 0.1

0.1

100p

1M1/10W

15k1/10W

0.10.1

0.1

1k1/10W

4.7k1/10W

0.0033470p0.0033470p

15k 1/10W

15k 1/10W

1k 1/10W

1k 1/10W

0.1

0.1

00.1

0

0.1

47k1/10W

1001/10W

0.1

CXD3059AR

470p

0.1

0.1

10010V

0.0110010V

0UH 100 1/10W

1001/10W

1001/10W

22p

100 1/10W100 1/10W100 1/10W100 1/10W100 1/10W100 1/10W100 1/10W

220p

22p

0

31P

10k1/10W

0.01

100k1/10W

100k1/10W

0.01

1001/10W

1001/10W

100 1/10W100 1/10W

100 1/10W100 1/10W

0.1

2204V

100k1/10W

0

1

3.31/10W

0.001

10 10

0.1

0.1 16P

22k1/10W

10k1/10W

10k1/10W

0.1

0.1

0.10.1

22010V

0.1

TC94A34FG-002

0.0068

11/10W

10k1/10W

BH15FB1WG

22p27p

1M1/10W

4701/10W

BA5947FM-E2

2SA2119KLD DRIVER

(LIMIT)

10010V

16.9MHz

1001/10W

1001/10W

1001/10W

1001/10W

470p

0UH

(VC)

(RFAC)

0.1

EF

F

EDABC

MIACKMICK

MIDIOMILPMICS

SCOR

SENS

CLOC

K

DATA

XRST

XLTCLOCK

SENSSCOR

XRST

MP3REQ

DATA

MP3STB

XTACN

XTAC

N

MP3STBDCBA

MP3RST

XLT

MP3REQMIACK

MICKMIDIOMILPMICS

MP3RST

SBSO

EXCK

WFC

KSBSOEXCK

WFCK

MOTORSPINDLE

MOTORSLED

DRIVESL/SP MOTOR

RF AMP

PROCESSORDIGITAL SIGNAL

REG

(2/3)

MAINBOARD

(Page38)

HCD-GNX88

3434HCD-GNX88

7-9. PRINTED WIRING BOARD – CD MECHANISM BOARD – • See page 26 for Circuit Boards Location.

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11 12 13 14

(LEVER SW)CN751S751

IC731

CN731

CN741

CN74

2

C715

C731

C735

C736

R70

1

R711

R731

R721

R722

R723

R73

5

R73

2

R733

R73

4

D70

1

D71

1

Q731

C751

IC71

2

IC70

1

CN704

C737

R71

3

R712

C741

R70

2

JW702

JW703

JW704

JW705

JW706

JW707

JW70

8

JW711

CN70

3

CN702CN705

R751

C752

CN70

1

JW712

JW701

JW70

9

JW710

JW713

JW714

CN72

1

MAINBOARD

(Page 36)

Ref. No. Location

D701 D-6D711 D-7

IC701 F-6IC712 F-7IC731 E-11

Q731 C-9



HCD-GNX88

3535HCD-GNX88

7-10. SCHEMATIC DIAGRAM – CD MECHANISM BOARD –

(1/3)37

no mark : FM

R701

D701

R712R711

R721

C735 C736

R722

C737

R723

R733

R734R735

C741

CN731 CN741

CN742

CN702

CN703 CN751

CN704CN721C751

R751

C752

CN705 CN751

R732R731

M741

CN701

IC731

E-1E-2E-3

Q731

D711

R713

C731

C715

S751

R702

470

MTZJ-T-77-5.1A

4.7k 1k

4.7k

0.1 0.1

4.7k

0.1

4.7k

1k

12k100

0.01

3P 3P

5P

5P

4P 4P

2P2P0.01

4.7k

0.1

2P 2P

10k100

(TBL)

12P

RPI-576TABLE

SENSORDTC114ESA

TBL ADDRESSENS SWITCH

MTZJ-T-77-3.6B

22k

1050V

10016V

(LEVER SW)

100

VREF

OUT2

RNF

OUT1

VM VCC

FIN

GND

RIN

IC701BA6956AN

LD MOTORDRIVER

VREF

OUT2

RNF

OUT1

VM VCC

FIN

GND

RIN

BA6956AN

DRIVER

IC712

TBL MOTOR

RE701ROTARY

ENCODER

M751(LOADING)

• See page 52 for IC Block Diagrams.

HCD-GNX88

3636HCD-GNX88

1 12

2CN504

CN560

13

12

Q

CDGBOARD

(Page 48)

R

CDGBOARD

(Page 48)

Y3

R202

C205

C539

C405

Y1

22 42

121

22 42

121Y8

C538

C149

R373 R372

R375

R376

JR390

R356 R357

IC401

R563

Q561

IC101 IC201

R290

JR035

C210

R431

R432

R433

R434

R430

R401 R402

R403R404R405 R406R407R409R411

C410

C411C412R412

R413

R417

R418

R419

R420

R311

R421

R422

R423

R424

R339

R426

FB50

8

FB507

FB512

FB50

9

R429

Q389

R395

R397

R307

R396

R355

R302

JR030C4

30

C429

R540

R505

R438R435

R440

R441

R442

R443

R444R445

R446R4

48R4

47R4

49 R450

D501

R394

R529

R530

R427

R319

R428

R451

R452

C464

JR46

5

JR46

6

D341

JR46

7

JR468

Q341

Q540

R475

R476R4

77R4

78

R472

Q340Q342

IC402

Q501

D503

D504 R5

01

D502

R503

D505

R500

R400

R513

R510

C497

R592

R593

R492

R493

Q345

R343

R291R292

R293

R294

R295

R296

R297

R342

C341

JR00

4

JR00

3

R489

R490R491

R273

R389

Q374Q371

R304

Q372 Q373

R384

Q376

Q375

Q382

R383

R399

R381

R380

R382

C381

Q381

R371 R374

IC301

C380

Q541

C384

C386R392

C377

FB261

FB51

0

FB263

C264

FB260

R150

C534

C547

C546

R268

R270

R269

R265

R267

R264

R266

R263

R260

R261

R262

R203

C203

JR01

4

R204

C372

R205C206

R229

R228

C373

R305

R303

R312

R306

C364

R310

R308

R309

R387

R354

R352

R385

R351

R221

R560

R220

C376

Q379

C263

FB50

6

C537

C262

C260

C261

R253

R254

R257

R256

R255R252 R250R2

51

Q250

Q251

Q343

R532

R104

IC550

R495

C564

C565

D550

R483

R484R4

85

R486

R487

R586

C110

JR017

D402

JR02

0

R140

R154 R166

R157

R541

R116

R103

C581

C580

Q584

Q582

Q580 Q581

R575

R577

R579

R580

D581

R122

C122

R153

C121R121

C115

R562

R106Q1

01

R107

R281

Q281

R282

R285

Q280R286

R488

Q378

C382

R585

C385

Q380

C383

R369

D342

R379

R388

R344

R347

C340

Q377

D340

C378

R391

R378

JR02

1

JR016

R393

Q370

JR015

R102R101

R105

R131

R132

R130

C160

C567

Q560

R346

R341

R345

R349

R274

JR001

JR00

2

R538

R542

Q542

Q543

Q544Q545

R543

R544

R545

R546

R547

R548

R582

R184

R185 R1

86R187

R180

R181

R182R183

Q180Q181

R370

C551

D401

R469 R470

R390

R353

C419

R570

R571

JR007

R133

R463

JR261

JR00

5

Q344JR

009

R271

R301

R272

R348

C375

C314

R386

Q383JR

018

R377

C371

R425

JR031

C499

Q151

R155

R156

R151

R152

R340

R502

R573R574

JR03

4

FB262

D583JR359

FB150

R591

JR138

JR022

JR507

C525

C523

C522

C524

C521

C520JR03

2

Q583

R336

JR028

JR02

9

R588

R337

Q505

Q504

JR036

JR012

JR019JR

010

JW563

NO401

JW260

JW56

0

JW520

JW00

1

JW002

JW003JW

006

JW00

8

JW00

9

JW010

JW011JW012

JW01

3

JW01

5

JW01

6JW

017

JW01

8

JW019JW020

JW021JW022

JW023JW024JW025JW026

JW027JW028JW029JW030JW031

JW032JW033

JW034

JW035

JW036

JW03

7JW

038 JW

039

JW04

0JW

041

JW042JW043

JW04

4JW

045

JW04

6

JW04

7JW

048

JW04

9JW

050

JW05

1JW

052

JW05

3JW

054

JW05

5

JW05

6

JW05

7

JW05

8

JW05

9

JW06

0

JW06

2

JW06

3

JW06

4JW

065

JW06

6

JW06

7JW

068

JW072

JW07

3

JW07

4

JW07

5JW

076

JW077

JW078

JW079JW080

JW082

JW087

JW088

JW08

9

JW090

JW091JW092

JW093JW094

JW095JW096JW097

JW098JW099JW100

JW10

3JW

104

JW10

5

JW10

8

JW10

9

JW11

0

JW11

1

JW11

2

JW11

3

JW11

4JW

115

JW11

6JW

117

JW122

JW132

JW13

8JW

139

JW14

0

JW14

1JW

142

JW14

3JW

144

JW14

6

JW14

7

JW148

JW14

9

JW16

9JW

170

JW17

1

JW17

2JW

173

JW17

4

JW175

JW176

JW177JW178

JW179JW180

JW18

1

JW182JW183

JW18

5

JW186

JW188JW189JW190

JW191

JW19

3JW

194

JW19

5JW

196

JW19

7

JW19

9

JW20

2

JW204

JW20

9

JW21

0

JW21

4

JW216

JW217JW218

JW220JW221

JW222

JW223

JW22

7JW

228

JW22

9

JW23

0

JW23

1

JW23

2

JW23

3

JW23

5JW

236

JW23

7JW

238

JW24

0JW

239

JW24

1JW

243

JW24

4JW

245

JW24

6

JW24

7

JW24

8

JW250

JW25

4JW

255

JW258JW259JW262

JW263JW264JW265

JW268

JW269

JW270

JW271

JW272

JW273

JW27

4

JW27

6

JW279JW280

JW281

JW284

JW288

JW289

JW290

JW293

JW294

JW29

9JW

300

JW30

1

JW30

2JW30

6JW312

JW31

7

JW32

0JW

321

JW32

2JW

323

JW32

4

JW32

5

JW32

6

JW32

7JW

328

JW32

9

JW331

JW332JW333JW334JW335

JW338

JW339

JW340

JW341JW342

JW343

JW344JW345

JW34

6JW

347

JW34

8

JW349

JW35

0JW

351

JW35

2

JW35

3

JW35

4

JW355

JW35

6

JW35

7

JW35

8

JW35

9

JW36

0

JW361

JW362

JW364

JW366

JW367JW368

JW369

JW370

JW37

1

JW37

2 JW37

3

JW37

4

JW37

9

JW38

0

JW107

JW19

8

JW38

5

JW38

6

JW387

JW13

6

JW381

JW37

5

JW37

6

JW37

8JW

377

JW130

JW134JW133

JW13

7

JW131

JW38

9

JW292

JW391JW392

JW101

JW102

JW285

JW393JW394JW395

JW00

4

JW00

5

JW00

7

JW069JW070

JW071

JW12

1JW

120

JW11

8

JW11

9JW

397

JW398

JW39

9

JW40

0

JW365

JW257JW256

JW167

JW127

JW12

5

JW123

JW124

JW396

JW014

JW20

8

JW291

JW295

JW31

5

JW31

6

JW286

JW287

CLP01

CLP02

CLP03

CLP04

CLP05

CLP06

JW266

JW31

3

JW20

0

JW402

JW403

JW40

4

JW40

5

JW406

JW407

JW40

8

JW151JW152JW153

JW150


JW159

JW225

JW226

JW21

3

JW21

5JW

212

JW21

1

JW128

JW31

0

JW30

3JW

304

JW166

JW40

9JW

168

JW410

JW24

2

JW23

4

JW41

2

JW31

8

JW31

9

JW41

3

JW41

4

JW415

JW416

JWH001

JW417

JW192

JW411

JW084JW083

JW08

1

JW085JW086

JW419

JW39

0

JW27

5

JW252

JW10

6

JW267

JW251

JW561

JW129

JW203

JW206

JW580

JW224JW219

JW184

JW201

JW205

JW41

8

JW42

0

JW42

1

JW422

JW384JW383

JW382

JW337JW363

JW450JW

307

JW30

8

JW253

JW522

JW401

JW33

6

JW452

CN509

X402

X401

C568

C308

C355

C391

CN505

C310

C462

CN508

C501C503

C416

IC561

CN514

C542

IC210

D560

L371

C374

CN502

C351

C250

CN501

C100

C150

C103

C222

J101

C540

C202

C207

C311

C204

C230

CN506

C211

C231

C223

C309

C498

C541

C305

C353

C306

C359

C552

C220

C354

C356

C301

C251

C535

CN507

C104C1

05

C111

IC560

C566

C180

C560C561

C550

CN100

CN513

C102C114

C221

C155

C152

C280

C156

C157C158

CN102

CN102

CN58

0

Q585

C163C1

62

C116

C130

C112

CN10

5

CN510(FOR CHECK)

C113 C106

C107

C108

C281

L302

T301

C502

L370

C312

C131

TM101

C303

L372

C543

C544

C545

C181

D561 D562

D563

C379

C109

C562

EPT560

C563

C161

C304

C361

C307

CN402

C140

C159

IC562

CN503

C370

JW297

JW298

CLP07

NO503

JW160JW161JW162JW163JW164JW165

JW18

7JW

126

JW13

5

JW20

7

NO507NO402

C154

C153

C553

JW282

JW277

JW566

JW567

JW56

8

JW061

JW14

5

JW278

1

6

3

1

3

4

E

E

E

E

E

1

4

1

3

1

76

2

SUBWOOFEROUT

TVAUDIO IN

CD DIGITALOUT

(OPTICAL)

VIDEO/MDAUDIO IN

SYSTEMCONTROL

L

R

L

R

M891DC FAN

1 8

FSURROUND

BOARD(Page 46)

GSURROUND

BOARD(Page 46)

14

1 4

31 30

80 81

50

51 1

100

11 1210

1

1

3031

1110

21 20

40 13

8

113 18

1 3

JPA

BOARD(Page 44)

ITRANSBOARD

(Page 50)K

PABOARD

(Page 44)E

SURROUNDBOARD

(Page 46)

BDRIVERBOARD

(Page 34)

C

PRIMARYBOARD

(Page 50)

DMIC

BOARD(Page 42)

TUNER PACKA

BD84BOARD

(Page 32)

13 13

+ –

1

6

12

27

26

1

1

3

3

(FOR CHECK)(FOR CHECK)

HPANELBOARD

(Page 40)

TAPEMECHANISM

DECK

TAPE AHEAD

TAPE BHEAD

BOARDMAIN

11(11)1-864-934-

13

4 5

EE

E

E

EE

EE

E

E

EE

E

E

E

E

EEE

E

E

E EE

E

EE

EEE

E

E

E

E

E

E

E

E

E

E

R511R512

R437

R511

2 3 4 5 6 7 8 9 10 11 12 13 14

A

1

B

C

D

E

F

G

H

J

I

15

K

7-11. PRINTED WIRING BOARD – MAIN BOARD – • See page 26 for Circuit Boards Location.

Ref. No. Location

D340 E-3D341 E-3D342 E-3D401 D-6D402 D-6D501 C-5D502 C-5D503 C-5D504 C-5D505 C-6D550 I-12D551 I-12D560 I-8D561 G-9D562 G-10D563 G-10D581 H-13D583 H-13

IC101 D-10IC201 D-12IC210 B-14IC301 H-5IC401 C-4IC402 C-5IC550 I-12IC560 H-9IC561 H-9IC562 C-6

Q101 C-8Q151 C-8Q180 J-10Q181 J-10Q250 B-13Q251 B-13Q280 D-10Q281 D-11

• Semiconductor Location

Ref. No. Location

Q340 E-2Q341 E-3Q342 E-3Q343 E-2Q344 E-3Q345 E-3Q370 J-4Q371 I-4Q372 I-4Q373 I-4Q374 I-4Q375 I-4Q376 I-4Q377 I-5Q378 I-5Q379 I-5Q380 J-5Q381 I-5Q382 I-5Q383 I-5Q501 B-5Q504 C-6Q505 C-6Q540 E-5Q541 E-5Q542 E-5Q543 E-5Q544 F-5Q545 F-5Q560 C-7Q561 C-6Q580 H-13Q581 H-13Q582 H-13Q583 D-4Q584 H-13Q585 H-13


HCD-GNX88

3737HCD-GNX88

7-12. SCHEMATIC DIAGRAM – MAIN BOARD (1/3) – • See page 52 for Waveforms. • See page 57 for IC Pin Function Description.

R503 C503

C502C501

D502 D501

R501 D504

D505

R483R484R485R486R487R488R489R490

R492R491

R586

R585

R430

R429

R428

R427

R426

R425

R424

R423

R422

R421

R420

R419

R418

R417

R530 R529

C430

C429

R407

R405

R404

R403

R402

R401

R411 X4

01C4

10

R406

C412

R409R505

R413

R412

NO402

R431R432R433R434

R538

R438R439R440R441R442R443R444R445R446R447R448R449R450

R478

R477

R476

R475

R470JR

468R451

R452

R469

R574R573R571

R472

R570

JR465

JR466

JR467

D401

R591

R400R500

NO401

JW522

Q501

D503

D402

C498

C497

NO507

CN402

R291 R292

R293

R290

R297

R296

R295

R294

R344

R346

R348

R347

D340

D341

D342

C340

R342

C341

CN509

R272

R273

R274

R343

R349

R340

R345R341

C416

C419

C411

X402

IC401

IC402

R502

C405Q340

Q343

Q342

Q345

Q344

Q341

Q504

Q505

Q583

C462 C464

C499

JR507

R435R437

R592 R593

R493

R463

0 0.1

0.11050V

1SS355 1SS355

220 1SS355

1SS355

100100100100100100100100

4.7k 100

10k

10k

100

100

100

100

100

100

100

100

100

100

1k 100

220

10k

10k 10k

47p

47p

100

100

100

100

100

100

330k 32

.768

kHz

22p

100

0.1

10k4.7k

0

100k

4P

100100100100

10k

100100100100100100100100100100100100100

100

100

100

100

1000

100

100

100

10k10k10k

100

10k

0

0

0

1SS355

15k

10010k

3P

JW

DTC124EKARESET

SWITCH

1SS355

1SS355

1050V

0.1

12P

10P

4.7k 47k

47k

47k

47k

4.7k

47k

4.7k

680

680

680

2.2k

1SS355

1SS355

1SS355

0.0047

2.2k

0.0047

13P

22k

10k

47k

2.2k

3.3k

2.2k

3.3k3.3k

22006.3V

220p 22p

16MHz

M30622MEP-A02FPU0

BD4929G-TR

1k

0.12SB1132

A TRIG DRIVE

FA1A4MA TRIG DRIVE

2SB1132B TRIG DRIVE

FA1A4MB TRIG DRIVE

FA1A4MCAP MOTOR

DRIVE

2SB1132CAP MOTOR

DRIVE

DTA114EKAB+ SWITCH

DTC124EKAB+ SWITCH

DTA124EKABUFFER

10010V

0.01

0.1

0

100100

3.3k 4.7k

4.7k

10k

A-TRG

B-TRG

BUS1

EVER +4V

BUS2

BUS4BUS5

BUS6

M+9V

BUS7

BUS8

HP DET

BUS9

BUS3

M GNDGND

129

3233

3431

8990

51 53 54 55 56 57 58 59

31323334

129

12357

18192122232425262728

32

84858687

91

3029

3839404142434445464748

7980

81

82

75 76 77 78

83

70

38

3940414243444546

68/A

8

95

52

94

4950

88

2930

71 73 7472

53

54

55

51

90

89

47

4894

29 30 4 97

72

36

37

65/A5

66/A6

67/A7

35

3731

3334

MASTER CONTROL

BOARD

BOARDPRIMARY

DRIVER

(2/3)

MAINBOARD

(3/3)

MAINBOARD

(2/3) (3/3)

MAINBOARD

MAINBOARD

LEVEL DETECT

(Page39)

(Page39)

(Page38)

(Page38)

(Page35)

(Page51)

HCD-GNX88

3838HCD-GNX88

7-13. SCHEMATIC DIAGRAM – MAIN BOARD (2/3) –

C161

R156

C251

R257R250

C250

C534

R255

R251

R252 R256

FB50

6

FB50

7

FB51

0

FB512C535

FB50

8

C547

C546

R254R253

FB260

FB261

FB263

FB262R270

R271

R269

R268

R263

R262

R261

R260

C261

C260

C262

C263 R267

R266

R265

R264

JR261

J101

JW419

C210 C211

C568

C567

R563

R562

R560

JW102

JW101CN105

C202

R203

C204

C203 C206

R155C160

C159R151

C158

R152C1

57

C156

C155

C154

C152

C140

R140

C281C280

R281 R285

R282 R286

C104

C103

C150C100

C102

C105

C130R131

C121

R121

R106

R105C109

R102

C110

C108

C111

C107

C106

CN100

FB150

C230

C231

R228

C223

C222

C220

C221

R221

R220

CN513

CN514

C207

R130

R133

R132

C131

C115C116

FB50

9

C122

R122

R229

R101

JW260C264

R204 R205

C205

C149

R157

R150

R104

C112

C113

R103

R107

R116 C114

C162 C163

R153

R166

TM101

C521

C523

C524

C525

JR032

C538

JW560

C539

CN506

R532

Q280 Q281

IC101

IC201

Q560

Q561

IC562

Q101

Q151

Q250

Q251

IC210

R154

C153

R582

JW266

R510 R511 R512 R513

CN504CN505

C537C520 C522

1050V

10k

1050V

1k1k

1050V

0.1

10k

10k

33k 33k

0UH

0UH

0UH

0UH330010V

0UH

220p

220p

10k10k

0

0

0

01k

1k

1k

1k

0

0

0

0

220p

220p

220p

220p 100k

100k

100k

100k

0

4P

JW

0.1 10010V

10006.3V

0.1

2.2k

2.2k

2.7k

JW

JW4P

1050V

0

22010V

220p 220p

47k0.01

150V2.2k

0.033

10k0.

022

0.02

2

1050V

1050V

1050V

0.068

10k

1050V

1050V

10k 10k

33k 33k

1050V

1050V

1050V 100

10V

1050V

1050V

1050V

2.2k

220p

1k

10k

47k1

50V

10k

0.01

0.033

1050V

0.02

2

0.02

2

4P

0

0.1

0.1

6.8k

10010V

10010V

0.1

0.1

12k

100k

6P

8P

150V

2.2k

100k

1M

0.4750V

0.122010V

0UH

220p

1k

6.8k

2.2k

JW 0.47

1k 1k

0.1

0.1

200

100

1k 0.27

0.27

560

220

100

1035

V

0.27 0.27

560

100

2P

220p

220p

220p

220p

00.1

0.1

9PFFC-R

0

2SC3661MUTE

2SC3661MUTE

M61529FP-D60G

M61530-D60G

RT1P137PB+ SWITCH

DTC114EKAB+ SWITCH

TA78033LS

2SC1623SWITCH

2SC1623SWITCH

2SC3661MUTE

2SC3661MUTE

TOTX141F

1k

1050V

0

JW

1k 1k 1k 1k

13P31P

0.10.1 220p

BUS7BUS8

BUS9

BUS6

A+9V

CD M

UTE

TC M

UTE

LINE

MUT

E

GND

SPEA

NA

OVER

LOAD

DET

ECT

DC D

ETEC

T

TC R

TC L

REC

R

REC

L

DBFB

FB

UNRE

G

M+7

V

R IN

L IN

M GND

HP DET 1 2 3 1921 22 23 24 25 26 2728 5 7

32

77

78

68/A8

79 80

82

18

88

87

86

85

84

81

EXCK

SBSO

WFC

K

EXCK

SBSO

WFC

K

1931 32 33 34 35 28 37 OPTICAL OUT

BOARD

BOARD

BOARDSURROUND

BOARDSURROUND

BOARDSURROUND

MIC

BOARDMAIN

(3/3)

MAINBOARD

(1/3)

BOARDMAIN

(1/3)

(3/3)

MAINBOARD

INPUT SELECT SWITCH,GRAPHIC EQUALIZER CONTROL,

ELECTRICAL VOLUME

CONTROLSURROUND VOL

REGULATOR+3.3V

BOARDCDG

BD84

(Page39)

(Page39)

(Page37)

(Page37)

(Page47)

(Page47)

(Page47)

(Page43)

(Page33)(Page49)

HCD-GNX88

3939HCD-GNX88

7-14. SCHEMATIC DIAGRAM – MAIN BOARD (3/3)– • See page 52 for Waveforms.

JW382

D583

D581

JW580Q582

Q581

R577

Q580

R575C580

CN580C581

Q585R580R579

R305

C306

C311

R339

R304

C305

R303

R319

C314

R302

R301

C303

C304

C356

R355R354

C355

R353R369

C364 R352 C353

R351

C312

R309

R308

R310

R311

R312

R306

C308

C561

C560D560

CN510

CN503

CN508

C382

C310

L302100uH

C550

C551

D550

C552

EPT560

R548R547

R543 R546

C544

C545

R545R544

C542

C543

R541

C540

C541

R542

Q584

C562

C563 C564

C565

R182R183R185 R184

R186R187

C180C181

R393

R397R391

R392

R380

C383

C384

L371C380

C378L370

C373

R374

R371

C372

R370

T301C371

C370

R377

R378

C377

C379 R379

R386

R395

R394

L372100uH

R389 C361

C376

CN507

C375

R387

R385

R381

R382

R383

R384R396

R390

R399

C566

D563

D562

D561

R495CN102

CN501 CN502

R180R181

R307C307

NO503

R372

R373

R375

R376 R388

C386

C374

C385

C359

C309

C301

C351

C391

C553

IC550

R540

IC301

Q543Q541

C381

Q376

Q375

Q374

Q373

Q372

Q371

Q377

Q379 Q381

Q382

Q383

Q378

Q380Q370

C354

Q545

IC560

IC561

Q181 Q180

R356

R336

R337

R357

Q540 Q542Q544

CN560

MT

UDZ6.8B

UDZ6.2B

JW2SC1623

DTC114EKA

100k

2SC1623

1k0.1

3P0.1

2SD25254.7k4.7k

47k

2.250V

1050V

22k

2.2k

150V

10k

2.2k

0.0022

4.7k

3.3k

0.1

1050V

2.250V

47k2.2k

150V

10k2.2k

0.0022 4.7k 0.1

3.3k

1050V

4.7k

100

100

0

100

22k

47010V

0.01

0.01D3SBA20-4101

3P

3P

17P

1200p

1050V

10016V

0.1

1SS355

2.250V

GND PLATE

470k15k

68k 68k

150V

150V

470k15k

150V

150V

15k

150V

150V

470k

DTC114EKA

10016V

47010V

0.1

0.1

47k47k1k 1k

10k10k

4.750V

4.750V

2.2k

2.2k10k

10k

8.2k

330p

330p

27mH120p

120p27mH

0.001

4.7k

4.7k

0.001

3.3k

0.0047

0.01

47

10k

0.01

0.0068 10

33

47k

4.7k

22k 1050V

680p

8P

680p

2.2k

2.2k

2.2k

2.2k

2.2k

2.2k10k

10k

10k

470025V

10EDB40

10EDB40

10EDB40

1007P

13P 8P

10k10k

1M10

50V

6P

10k

4.7k

10k

4.7k 6.8k

0.022

4735V

0.022

4735V

4735V

0.012

0.012

10016V

100025V

RT8H015C-T112-1

68k

HA12237F

DTC114EKAMUTE DRIVE

DTC114EKAMUTE DRIVE

1200p

2SC3661SWITCH

2SC3661SWITCH

2SC3661SWITCH

2SC3661SWITCH

2SC3661SWITCH

2SC3661SWITCH

2SA1235TPSWITCH DRIVE

DTC114EKASWITCH DRIVE

DTC114EKABUFFER

DTA114EKASWITCH DRIVE

DTC114EKASWITCH DRIVE

RT1P137P-TP-1SWITCH

DTC114EKASWITCH

2SD596BIAS OSC

1016V

DTC114EKABUFFER

BA09T

TA7809LS

2SC3661MUTE

2SC3661MUTE

6.8k

6.8k

10k

10k

DTA124EKACD MUTE DRIVE

DTA124EKATC MUTE DRIVE

DTA124EKALINE MUTE

DRIVE

2P

BUS1

BUS2BUS3

BUS4BUS5

BUS6

EVER +4V

M G

ND

A+9V

CD M

UTE

TC M

UTE

M+9V

SPEA

NA

OVER

LOAD

DET

ECT

DC D

ETEC

T

TC L

TC R

REC

L

REC

R

DBFB

FB

UNRE

G

M+7

V

LINE

MUT

E

GND

R IN

L IN

67/A7

65/A5

59

58

57

56

527876 7577

70

36

72

7129304

737472

97

91835049

95

66/A665/A537

PROTECTOR CCT

BOARD

BOARD

BOARDPA

BOARDPA

TAPE AHEAD

HEADTAPE B

PANEL

TRANS

BOARDMAIN

(1/3)

(2/3)

MAINBOARD

BOARDMAIN

(1/3) (2/3)

MAINBOARD

DECK A/B SELECTPB/REC EQUALIZER AMP

+9VREGULATOR

+9VREGULATOR

BOARDCDG

(Page38)

(Page38)

(Page37)

(Page37)(Page49)

(Page45)(Page45)

(Page41)

(Page51)

HCD-GNX88

4040HCD-GNX88

7-15. PRINTED WIRING BOARD – PANEL BOARD – • See page 26 for Circuit Boards Location.

Ref. No. Location

D901 B-10D902 B-10D903 D-7D904 D-6D905 B-9D906 C-10D907 C-10D908 D-10D909 D-10D910 D-10D911 B-3D912 C-3D913 D-3D914 E-3D915 B-3D916 E-10D917 E-10D918 F-10D925 F-10D926 F-10D927 B-10D928 C-3D929 E-3D930 F-3

IC902 C-7IC903 B-10IC904 C-4

Q900 A-10Q901 C-8Q902 C-8Q903 B-10Q904 B-10Q905 C-10Q906 C-11Q907 C-11Q908 C-10Q909 E-10Q910 F-10Q914 C-8Q915 D-10Q916 F-10Q917 A-11Q918 B-2Q919 D-3Q920 E-3


IC902

R913

C957

R937

R117

9R1

112

C901

C902

C903

C904

C905

C909

C910

C916

C917

C919

C923

C924

C925 C9

26

C927

C928

C929

C930

C931

C932

C933

C934

C935

C936

C937

C938

C939

C945

C946

C947

C948

C949

C950

C951

C952

C953

C954

C955

C956

C958

C959

C961

C966

C980

C981

C982

C983

Q906

Q907

Q908

Q909

Q915

Q917

Q918

Q919

R900R9

01

R902

R903R904

R905

R906

R907

R912

R918

R919

R920

R922

R939

R940R941

R942

R944

R945

R946

R947

R948

R949

R950

R951

R952

R953

R954

R956

R958

R959

R960

R961

R962R963

R964

R966

R967

R968

R970

R971

R975

R977

R978

R980

R981R982R983

R984R985R986

R987R988R989

R990

R999

R113

5

R1136

R1137

R1141R1142R1143

R1147R1148

R1160

R1161

R1162

R1163

R1164

R1165

R1166

R1167

R1168

R117

5

R1176

R1177

R1178

R1180

R118

6R1

187

R1188

IC904Q901

C972

C973

C977C978

C979

R917

Q902

Q914

D905

JR914

JR91

5

R909

JR91

0

Q903

Q900

Q920

D901

Q904

R1189R1183

Q905JR911

JR912

JR922

JR90

9

JR91

3

R908

C907

JR918

JR91

6JR

917

C906S916

C908

JR92

1

FB901

R910

R932R943R933

R1197

R914

R957

R1198R1199

R911

R916R915

R931

R969

R972

R973

R997

Q910

Q916

R965

R991R992

R993R994R995

R1194

R1196R1195

R974

R996

JW904

FL901

CNS9

02

JW905

NO90

3JW901

JW90

2JW

906

JW90

7JW

908

JW90

9JW

910

JW91

2JW

913

JW91

4JW

915

JW91

6JW

917

JW91

8JW

919

JW92

0JW

921

JW92

2JW

923

JW92

4

JW92

5

JW92

6

JW92

7

JW92

8


JW93

5JW

936

JW93

7JW

938

JW93

9JW

940

JW94

1JW

942

JW94

3JW

944

JW94

5JW

946

JW94

7

JW94

8

JW949

JW950 JW951

JW956

JW957

JW95

9

JW96

1

JW96

2

JW96

3JW

964

JW96

5

JW96

9

JW97

4

JW994

JW995

JW996

JW99

7JW

998

JW99

9

JW11

18

JW11

20

JW11

23

JW1124

JW11

25

JW1131

JW903

JW91

1

JW1128

JW11

10

JW11

12

JW11

13JW1126

JW11

15

JW11

16

JW953

JW11

14

JW96

8

JW11

19JW1129

JW11

33

JW1138

JW1139JW1140JW1141JW1142JW1143

JW11

22

JW11

46

JW11

47

JW11

48

JW11

49

JW11

50

JW1151

JW1152JW1153

JW1154

JW11

55

JW11

56

JW96

6S970

S917

S916

S915

S914

S904

S901

S912

S913

S902

S932

S903

S925

S920

S919

S911

S918

S900

S929

S928

S930

S931

S927

CNS901

D912

D913

D914

X901

C922C920

C944

C900

C942

C941

C960

IC903

JW99

3JW

991

JW99

0JW

989

JW98

8JW

987

JW98

5JW

986

JW98

4JW

983

JW98

2JW

981

JW98

0JW

979

JW97

8 D903

D904

JW96

7

CN90

2

D906

D907

D908

D909

D910

D916

D917

D918

D902

D927D911

D915

JW975

CLP912

JW11

60JW

1161

JW929

JW11

30

JW11

27

JW1137 JW11

36

JW1135

JW1134

JW1132

JW11

62

JW1145

JW955

JW97

6

JW954

JW97

0

JW95

2

JW960

D930

D929

D928

C971

C970

C918

JW97

2

JW97

3JW

900

JW97

1

JW1117

JW95

8JW

977

JW1144

S910

D925

D926

BOARDPANEL

11(11)1-864-912-

CD

CD

TUNER BAND

TUNERBAND

TAPE A/BTAPE A/B

TV

TV

VIDEO/MD

VIDEO/MDAMP MENU

SOUND FLASH

DIRECTIONTUNER MEMORY/MPX

ENTER

TUNING

+>

–

>

t

t

ALBUM

M+

M–

t

t

ALBUM

M+

M–

t

t

x

x

XX

CD SYNC

TUNING

RECPAUSE/START

MP3 BOOSTER

EQ BAND

VOLUME

DISPLAY

SURR SPEAKERMODE

ILLUMINATION

GROOVE12

3

1

8

LJOG

BOARD(Page 42)H

MAINBOARD

(Page 36)

MCD-SWBOARD

(Page 42)

(NOT USE )

1

100

50

51

31 30

80 81

110

1120

E

E E

E

EE

E

E

E

E

E

E

123E

E

E

E

E

E

1 76 64

7065

2 3 4 5 6 7 8 9 10 11

A

1

B

C

D

E

F

G


HCD-GNX88

4141HCD-GNX88

7-16. SCHEMATIC DIAGRAM – PANEL BOARD – • See page 52 for IC Block Diagrams. • See page 52 for Waveforms. • See page 59 for IC Pin Function Description.

D901

R958

R959

R960

R961

R962

R963

R964

R965

R966

R967

R968

S920

S919

S918

S911

S910

S927

S928

S929

S930

S931

S932

NO903

CNS901

C900

C903

R900

C904

R901

C908

C916

R912

R920

R118

7R9

09

R907

R906

R905

C910

R904

R903

C902

C901

C909

R902

C905

R999

R975R978

R977R980

R1188

CNS902R970

S970

C907

R971

S912 S913 S914 S915

R1163 R1164 R1165 R1166 R1160 R1161R1162

C906

R954 R951 R948

C947

R945

C945

C959

C958

C956

C954

C952

C950

C946

C948

C949C953C955

C957C951

R952

R953

R950

R949

R947C966

CLP912

JR915C961

C941

R941R942

R940

CN902

S925

S900

R1167

R1180

C922

C923

S904

S903

S902

S901

D904

D903

C919

C918

C970

C971

R1178

R1177

R1176

R1175

C944

FL901

JW900

R919 R918 R917

R908

R1189

R1183

D927D902

R910

R911

R931

R943

R933

R932

R914

R915

R916

R1197

R1198

R1199

R1194

R1195

R1196 R993

R994

R995R990

R991

R992

R987

R988

R989

R984

R985

R986

R981

R982

R983 R969

D908

D907

D909

D916

R972

R973

D925 D926

R996

D917 D918

R974

D910

D906

R957

R1179

R1112R1141 R1143 R1142

R1148

R1168

R997 R1135

R1136

R1137D930

D914

D929

D913

R1147

D928

D912D915D911

IC904

S916

C960

R946

R956

C942

D905

X901

R118

6

C924

C925

C926

C927

C928

C929

C930

C931

C932

C933

C934

C935

C937

C936

C938

C980

C981

C982

C983

C972

C973

C979

C978

C977

C917

FB901

R922

Q906

Q907

Q904Q905

Q900

Q903

Q902

Q901

Q914

Q917

Q910

Q920Q919Q918

Q916

Q909

Q915

Q908

IC903

JR914

R944

C920C939

R939

JR912

JW905

S917

IC902

1SS355TE-17

470

680

1k

1.5k

1.5k

2.2k

3.3k

4.7k

6.8k

10k

15k

4.750V

0.1

10k

0.1

10k

220p

0.1

100

10k

10k

10k

15k

15k

15k

0.1

100

100

220p

220p

220p

10k

0.1

0

470470

1k1k

1k

6.8k

0.001

1k

1.5k 2.2k 3.3k 4.7k 6.8k 10k6.8k

0.001

10k 5.6k 6.8k

1

33k

1

0.04

7

0.04

7

0.02

2

0.02

2

0.00

47

0.00

47

470p

470p

111

11

1k1k 1k 1k 1k

0.1

00.1

1050V

100100

10k

17P

270

270

1050V

0.01

10EDB40

10EDB40

0.01

4706.3V

4706.3V

4706.3V

1.5k

1k

680

470

1050V

OMT

100k 100k 100k

100

22

100

SLI-325URT31WSEL6164E-LC05

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k

1.8k 680

680

680680

680

680

680

680

680

680

680

680

680

680

680 680

SLI-325URT31W

SEL6414E-LC05

SEL6414E-LC05

SEL6414E-LC05

680

680

SLI-325URT31W SEL6414E-LC05

680

SLI-325URT31W SEL6414E-LC05

680

SLI-325URT31W

SLI-325URT31W

1.8k

1.8k

1.8k1.8k 1.8k 1.8k

1.8k

1.8k

680 680

680

680SLI-325URT31W

SLI-325URT31W

SLI-325URT31W

SLI-325URT31W

1.8k

SLI-325URT31W

SLI-325URT31WSEL6414E-LC05SLI-325URT31W

NJM2760V-TE

1050V

56k

2.7k

1050V

DTZ-TT11-6.8B

4MHz

4.7k

100p

100p

100p

100p

100p

100p

100p

100p

100p

470p

100p

100p

100p

100p

100p

100p

100p

100p

100p

100p

100p

100p

100p

100p

0.1

0

1M

DTC114EKABUFFER

DTC114EKABUFFER

2SB1115A-YQSWITCH

2SB1115A-YQSWITCH

DTA114EKALED DRIVE

DTA114EKALED DRIVE

DTC143TKABUFFER

DTC143TKABUFFER

DTC143TKABUFFER

DTC114EKALED DRIVE

DTC114EKALED DRIVE

DTC114EKALED DRIVE

DTC114EKALED DRIVE

DTC114EKALED DRIVE

DTC114EKALED DRIVE

DTC114EKALED DRIVE

DTC114EKALED DRIVE

DTC114EKALED DRIVE

RPM7240-H8

0

47

4710V 0.001

1k

0

0

MB90M407PF-G-144-BNDE1

24252627282930 1234567891012131516171819202122 14

31323334353637

38394041

43

87888990919293949596979899

100

4948 51 52 53 54 55 56 57

65 66 6768 69 70 71 72

495152535456

776160

48

6061

74 75

64

444546

76

76

858652

54

53

55

79 8077

73

73

74

47

65

66

78

7879 75 57

8788899091929697989910

01234567

891012131415161718192021222425262728293031323334353637383940414344454647

95

8586

94

93

56

58 59

58 59

64

80

72

67

706968

71

I/

TUNER/BAND

SURR SPEAKERMODE

SOUNDFLASH

-

+

-

+

- +

+

-

I/

BOARD

BOARD

(3/3)

MAINBOARD

(NOT USE)

CD-SW

JOG

(Page39)

(Page43)

(Page43)

HCD-GNX88

4242HCD-GNX88

7-17. PRINTED WIRING BOARD – CD-SW, JOG, MIC BOARDS – • See page 26 for Circuit Boards Location.


Ref. No. Location

D919 D-11D920 E-11D921 D-12D922 D-12D923 C-11D924 D-10D1100 F-6D1101 F-6D1102 G-8

Q911 C-11Q912 D-12Q913 E-11

IC1100 G-7IC1101 G-8

C1116

C1118C111

9

C1125

R111

7

R1116

R1124

C112

6

R1115

R112

3

R1121

R1113

R1114

R1122

R111

9

R1120

R111

8

IC1101

D110

2

C1150

Q911

Q912

Q913

R1138

R113

9R1

140

R1144R1145

R1146

R1156S1161

R1157R1158

R1159

R116

9

R117

1

R117

2

R117

3

R117

4

JR904

JR905

R1190

R119

1

JR11

02

R119

2

FB1101 FB1100

JR1108

JR1101

JR1113

JR1114

JR1105

R110

0

R110

2

C1104C1

105

C110

9

C111

0

C111

1

JR11

06

C1142

R1132

R1101 R1103

R1104

R1105R110

6

R1107

R110

8

R110

9

R1110

R1111

R1125R1126

IC1100

JR11

04

D1100D1101

JR1103

C110

0C1101

C110

3C1133

CNS9

03

NO1150

RV1101

EPT1103

C1122

C1120

C112

3

JW1103

JW11

04

JW11

05

CLP1100CLP1101

C1130

JW1109

JW11

07

D919

D920

D921

D922

D923

D924

S115

6

S115

7

S115

8

S115

9

S116

0

EPT1102

J1103

RV1100

C1102

C1113

C1131CN1102

JW1108

JW1101

J1100 J1101

NO1101 C1129

C1121 C1117 C1124

C1106 C1115

C1108

C111

2

C113

9C1

114

C1127 C1128

BOARDJOG

BOARDCD-SW

BOARDMIC

11(11)1-864-913-

11(11)

1-864-915-

11(11)1-864-914-

LPANELBOARD

(Page 40)

MPANELBOARD

(Page 40)

NPA

BOARD(Page 44)

DMAIN

BOARD(Page 36)

19

13

1

3

1

8

1

1

16

4

58

8

9

ECHO LEVELMIC LEVEL

MIC2PHONES

MIC1

VOL 1

VOL 2

VOL 3

VOL 4

VOL 5

VOL 6

1

23

OPERATIONDIAL

E

E

E

DISC 1DISC 2DISC 3Z OPEN/CLOSE EX-CHANGE/DISC SKIP

2 3 4 5 6 7 8 9 10 11 12

A

1

B

C

D

E

F

G

H


HCD-GNX88

4343HCD-GNX88

7-18. SCHEMATIC DIAGRAM – CD-SW, JOG, MIC BOARDS BOARD –

D924D922D920

D919 D921 D923

R1138

R1139

R1140

R1190

R1144

R1145

R1146

R1191

R1157

R1158

R1159R1192

CNS903

R1169R1174R1173R1171 R1172

S1160S1159S1158S1157S1156

C1100 R1101C1102

R1103

C1104 R1104

C1103

C1101

R1102

R1105

C1139

C1105

R1106

IC1100(1/2)

R1107

RV1100

R1108

C1109

IC1100(2/2)

R1109

C1110

C1111

R1125

R1126

R1132

D1100

D1101

C1142

J1103

NO1150

S1161

J1110

J1111

C1108

C1125C1127

C1130

C1126

R1122 R1123

R1124

R1121

C1119

C1118

C1120

D1102 C1123

R1119

R1117

R1118

R1114

R1120

C1122 C1115

R1113

R1115

R1116

C1131 C1112

C1116

C1117

C1121C1124

C1129

C1128

C1133

CN1102

NO1101

RV1101

C1106

FB1100FB1101

JW1101

EPT1102EPT1103

R1156

C1150

Q913 Q912 Q911

IC1101

R1100

C1113

R1110

C1114

R1111

SELS5223C-TP115RED

SELS5223C-TP115RED

SELS5223C-TP115RED

SELS5223C-TP115RED

SELS5223C-TP115RED

SELS5223C-TP115RED

820

820

820

100

820

820

820

100

820

820

820100

8P

4706801k1.5k 1.5k

0.01 1k2.250V

1k

0.001 100k

47p

0.01

10k

1k

150V

470p

47k

NJM4565M

100

50k

10k

47p

NJM4565M

150k

150p

47p

2.2k

2.2k

0

1SS355TE-17

1SS355TE-17

0

3P 2.250V

0.00150.068

0.015

0.0068

15k 15k

47k

15k

0.0015

0.0068

0.068

UDZS-TE-175.1B 0.068

15k

15k

15k

15k

120k

4715V

2.250V

15k

330

330

22010V

1050V

0.0022

150V

4716V1

50V

0.2250V

0.2250V

0.47

3P

4P

50k

2.250V

00

1k

0.001

DTC114EKALED DRIVE

DTC114EKALED DRIVE

DTC114EKALED DRIVE

M65850FP-E1

10k

1050V

100

0.2250V

100k

OPEN/CLOSE

BOARDPANEL

BOARDPANEL

BOARD

(2/3)

MAINBOARD

PA

(Page41)

(Page41)

(Page38)

(Page45)

HCD-GNX88

4444HCD-GNX88

7-19. PRINTED WIRING BOARD – PA BOARD – • See page 26 for Circuit Boards Location.

Ref. No. Location

D609 A-6D611 E-7D612 E-7D620 B-7D624 E-9D646 B-10D654 B-9D655 B-10D656 E-4D658 E-5D660 E-2D661 E-2D665 C-10D670 B-7

IC600 D-8

Q604 B-7Q606 B-6Q610 B-7Q618 B-7Q628 E-9Q629 D-10Q630 E-9Q634 B-6Q640 B-6Q641 B-5Q644 F-1Q647 F-1Q648 E-2Q666 E-1Q668 B-7Q682 A-6


L

R

L

R

C682C681

C691C692

JR603

R694

D611

R611

R610

D612

C601C651

R600

R650

R617R695R696

R624

R674

R630

R631

Q628

Q630

C605

C683

C693

R676

R656

R657

R658

R677

R678

C660

D620

D646

R609 R6

98R6

08R6

93

R606

R692R607

Q634

R604

R605

Q610

R642R662

R640

R635

R641

Q682

R643

R663

R639 R6

38

R697R634Q641

Q640

R683

Q618

D609

R682

Q644

D661

D660R649

Q648

R685

Q647

R645

R644

R673

R623

Q668

D670

D655

D654

R655

R654

R632

R633

Q629

JR600

R620

C654C604

R603 R653R602 R652

R601 R651

R625

R628 R629R660R661

R621

R619

Q604

D665

Q666

R666R667

R648

R671

R669R670

R626R627

R647

D624

D658D656

JW62

6

NO60

1

R691

R681

JW67

7

JW67

6

JW60

1

NO600

JW69

1

JW62

7

JW68

1

JW60

0

JW60

2

JW604JW605JW606

JW608

JW61

4

JW617

JW618JW619JW620

JW62

1JW

622

JW62

3JW

628

JW62

9

JW63

0

JW63

3JW

634

JW63

5

JW63

7

JW638

JW63

9

JW64

0

JW64

1

JW64

2JW

643

JW64

4 JW64

5

JW64

6

JW64

9

JW65

1

JW65

2

JW65

3

JW65

4

JW65

5

JW65

6

JW65

7

JW658

JW659

JW66

0

JW66

1

JW664

JW665

JW668

JW678JW679

JW616

JW607

JW61

3

JW603JW662

JW663

JW63

1

JW688

JW69

2

JW693

JW69

4

JW69

5

JW69

8

JW69

9

JW70

0

RY646

EP69

0

EP660

CN600

CN601 TM600

JWH603

JWH602

C602

C600 C6

50

C652

TH62

9

C617 C6

66R672R622

C609

C618

C619

C610

C635

C634

C636

C608 C655

C648

C649

R636

R637

R616

JWH601

C657

C659

C677

C679

Q606

C667

C637

C616 JWH600

TH63

0

C676

C656

C678

IC600

C658 R6

68

RY665

CN607

R618

R613

R614

R612

R615

TM601

PL600

PL601

PL602

JW667

JW669

JW682JW683

JW65

0

JW67

4JW

675

JW670JW671 JW672

JW673

JW64

7

JW64

8

JW69

6

JW63

2

JW68

0

R646

R665

JW636

JW68

4

JW62

4

JW62

5

JMAIN

BOARD(Page 36)

KMAIN

BOARD(Page 36)N

MICBOARD

(Page 42)

OSURROUND

BOARD(Page 46)

PTRANSBOARD

(Page 50)

BOARDPA

11(11)1-864-930-

11

1

13

3

8

1

5

1 7

FRONT SPEAKER

SURR SPEAKER

E E

E

E

E

E

E

EE

E

E

E

E

E E E

+ –+ –

2 3 4 5 6 7 8 9 10 11 12

A

1

B

C

D

E

F

G


HCD-GNX88

4545HCD-GNX88

7-20. SCHEMATIC DIAGRAM – PA BOARD –

Q606

R607

R692

R606

R693

R608

R698R694

D609

R609

R611

R610

C608

R604

R605

R674R624 R623 R673

R696R695R617

C666

C667C616

C617

R631

R632

R633

TH630TH629

R622R672

C609

C610

C619

R616

C618

C657

C677 R656

R676 R677

R657 C656

C676

NO600

C660

R658

R678

C659

C679

D660 D661

C652

C602

C693 C683

EP690

D655

D654

R655

R654

C655

D646

R644

R645

R685

C648 C649R649

R682R683

R697

R634

R638 R639

C634

C635

R635

R640

R641

C636 R636 R643

C637 R637R642

R662

R663

C651C601

R650R600

C650C600

D624

NO601

CN601CN600

C605

C692

C691

C682

C681

R691 R681

R667

R666

RY665

R647R648

D665

Q648

Q666

Q647

R665

R668R618

R612

C604

R603

R653

C654

R671

R669

R670

D670D620R621

R620R619

Q618

R615

D612

D611R613

R614

D656

D658

C658

C678R661R660

EP660

Q668

Q604

Q610

R651R601

Q634

Q682

Q640

Q641

R646

R628 R630 R626

R629 R627

Q644

Q629Q630 Q628

TM600

TM601

JW677

JW676

JW681

JW691

RY646

IC600

CN607

R652

R602

R625

2SA1207

2.2k

47k

47k

100k

100k

100k68k

1SS355

68k

33k

68k

2250V

10k

10k

22k22k 68k 56k

100k100k100k

0.068

0.0680.068

0.068

100k

100k

56k

101/2W 10

1/2W

22100V

22100V

10100V

11/4W

10100V

0.1100V

0.1100V

220k

220k 220k

220k 3300100V

3300100V

7P

100000p

100k

100k

0.1100V

0.1100V

1SS355 1SS355

10010V

10010V

0.01 0.01

GND PLATE

1SS355

1SS355

47k

47k

1050V

1SS355

2.2k

10k

10k

10010V

1050V 22k

1k4.7k

2.2k

2.2k

100k 100k

10025V

10025V

10k

1k

1k

4.7100V

6802W

150

4.7100V

6802W 150

150

150

0.00220.0022

1k1k

4.750V

4.750V

1SS355

3P

8P13P

0.01

0.068

0.068

0.068

0.068

101/2W

101/2W

10k

4.7k

RELAY

1k22k

1SS355TE

2SC1623-L5L6OVER LOAD

DETECT SWITCH

2SC2412K-T-146-RSPEAKER PROTECT

RELAY DRIVE

2SC1623-L5L6FRONT SPEAKER

RELAY DRIVE

821/2W

0.15W

0.15W

1001/4W

220p

47k

47k

220p

100k

1k

33k

1SS3551SS355100k

33k1k

2SC3722K-EOVERLOAD DET

1001/4W

UDZSTE-1718B

UDZSTE-1718B3.3k

1W

3.3k1W

RBV-2506

D25XB60

330063V

330063V

10k10k

2SC3722K-EOVERLOAD DET

2SC3722K-E

2SC3722K-E

47k47k

DTA124EKA-T146MUTING

CONTROL SWITCH

2SC1623-L5L6MUTING

CONTROL SWITCH

2SC3661HEADPHONE

MUTING

2SC3661HEADPHONE

MUTING

821/2W

22k 100k 56k

5.6k 1k

2SC1623-L5L6FRONT SPEAKER

RELAY DRIVE

2SC1623-L5L6FAN MOTORON SWITCH

2SC1623-L5L6TEMPERATURE

DETECT SWITCH

2SC1623-L5L6TEMPERATURE

DETECT SWITCH

2P

2P

RELAY

STK412-150

5P

2.7k

*2

*2

Q604,606,610STANBY SWITCH

R

L

SURR SPEAKER

R

L

FRONT SPEAKER

POWER AMP

(3/3)

MAINBOARD

(3/3)

MAINBOARD

BOARD

BOARD

BOARDSURROUND

TRANS

MIC

E2,E51E3,AUS

*2 R602,652470390

(Page39)

(Page39)

(Page43)

(Page47)

(Page51)

HCD-GNX88

4646HCD-GNX88

7-21. PRINTED WIRING BOARD – SURROUND BOARD – • See page 26 for Circuit Boards Location.

Ref. No. Location

D800 D-4D810 D-2D811 E-3D812 D-4D850 D-4

IC800 B-4

Q800 D-4Q810 C-1Q812 D-2Q814 D-3Q815 D-3Q850 D-4


C858

C803

C805R8

60

C853

R800

C807R807

R806

R808R8

58

R801

C801

R803

Q810

R851

C851

R850

D811

R802

Q800Q850

R890

R840

D800

D850

R839

D810R8

17R8

12

R814

Q812

D812

R889R843

R861

Q814

Q815

R863

R864

R865

R866

C804

R852

R891

R841C820

NO800

CPL700

CPL701

JW801

JW80

3

JW819

JW820

JW821

JW70

9

JW813

JW828

RY862

C888

C889

CN700

C839

CN800

C800

C806

C850

C802

C825

C826

R827

R828

R804

R892 R842

C838

C843

B705

IC800

R805

JW80

6

R888

R838

JW80

2

NO801

JW80

4

JW81

1

C852

JW826

JW80

7

JW808JW809

JW805

JW810

JW81

4

JW818JW817

JW815

JW816

B706

CLP702

JW81

2

JW822

JW800

R862

11(11)1-864-941-

BOARDSURROUND

OPA

BOARD(Page 44)

EMAIN

BOARD(Page 36)

GMAIN

BOARD(Page 36)

FMAIN

BOARD(Page 36)

13

115

1

5

18

E

E

E

E E

E

2 3 4 5 6 7 8 9 10

A

1

B

C

D

E

F


HCD-GNX88

4747HCD-GNX88

7-22. SCHEMATIC DIAGRAM –SURROUND BOARD –

C853C850

R800

R851

R850

R807

C802

C852

R801

R802

C804

R852

R806

C806

C820C843

R817

R889

R858 R812

R814

D810

R888

D850R891R892

R860

R861

D811

RY862R8

63

R866

D800 C826

R839

R841

R808

R838R842

C825R843

NO800

C800C838

C839

B706

C851B705

C807

C801

C889

C888

R828

R827

CN700CN800

R805

R804

C805

R862

Q810

Q812Q850

Q800

Q814

Q815

IC800

R865

R803

C803

D812

R864

NO801

R840

R890

100p4.750V

1k

47k

1k

47k

10010V

10010V

47k

820

100000p

820

1k

2.250V

1050V4.7

50V

10k

1k

47k 2.2k

10k

1SS1355TE

0.225W

1SS1355TE100k10

1/2W56k

47k

1SS1355TE

12V2.

2k

22k

1SS1355TE 100100V

1k

100k

47k

0.225W

101/2W

100100V

47k

MT

4.750V

0.068

0.068

BRACKET

0.01BRACKET

1

1

0.068

0.068

1001/4W

1001/4W

8P6P

11/4W

11/4W

0.1

1001/2W

2SC3661MUTE

2SC3722K-ESW MUTE2SC3722K-E

OVER LOADDETECT

2SC3722K-EOVER LOAD

DETECT2SC1623-L5L6RELAY DRIVE

2SC1623-L5L6RELAY DRIVE

STK403-120POWER AMP

1k

2.2k

100p

1SS1355TE

22k

5P

22k

22k

(2/3)

MAINBOARD

(2/3)

MAINBOARD

BOARDPA

(2/3)

MAINBOARD

(Page38)

(Page38)

(Page45)

(Page38)

HCD-GNX88

4848HCD-GNX88

7-23. PRINTED WIRING BOARD – CDG BOARD – • See page 26 for Circuit Boards Location.

Ref. No. Location

D1003 B-5D1004 B-5

IC1001 C-5IC1002 B-3IC1003 C-2IC1005 B-6IC1006 D-3

Q1001 D-5Q1002 D-5Q1004 D-6Q1005 C-7Q1006 D-5Q1007 A-3Q1008 B-2Q1009 C-6Q1010 D-3


IC1001

IC1002

IC1005

Q1007

IC1006

R103

4

R103

0

R103

3

Q1005

Q1009

Q1002Q1001 Q1006

Q1004

C1004

C1001

C1018

D100

3

D100

4

C1021

C101

1

FB10

01

C101

4

R1004

L1002

L100

1

C1005

C101

5

C1027R1005R1006

R1031

C100

7

R101

2

R1013

R1029

C1003

R1022

R1023

R1021

R101

7

R101

1 R1018

R1019

R1020

R101

5

R1003

C1022

C1019

C1006

Q1010

R101

6

R103

2

C1002C1

025

Z2

C102

9

EP1001

JW10

02

JW10

03JW1004

JW10

05

JW1006

JW10

07

JW1008

JW10

09

JW10

10

JW10

11

JW10

12

JW10

13JW

1014

JW10

15

JW10

16

JW1017

JW1019JW10

20

JW1018

J1001

CN1003

X1002

Q1008

CN1001

IC1003

C100

8

C1010 C1028

C1012

C1013

C102

3

C102

6

C103

0

C1024

11(11)1-864-878-

BOARDCDG

1

1

1 2

3

5 9 13

14182226

16 15

45 46

3031

160

EE E E

E

E

E

1

6

3

4

E

E

QMAIN

BOARD(Page 36)

RMAIN

BOARD(Page 36)

VIDEO OUT

2 3 4 5 6 7

A

1

B

C

D

E


HCD-GNX88

4949HCD-GNX88

7-24. SCHEMATIC DIAGRAM – CDG BOARD – • See page 52 for IC Block Diagrams. • See page 52 for Waveforms.

C1021

R1020

X1002C1018

C1019

R1017 C1015

C1003

R1016

R1013 C1007

R1029

C1022

R1011

C1023

R1005

C1004C1013

C1025C1024

R1030

C1010

L1001 C1008CN1003

R1034

R1033

R1032

C1027

C1026C1030

C1028

C1002 IC1003

IC1005

IC1002

C1001 C1011

R1003

R1004

R1021

R1022

R1023

L1002

R1019

R1018

IC1006

C1014

R1031

R1015

C1006

C1005

C1012

C1029

EP1001

IC1001

FB1001

Q1007

Q1008

Q1010

Q1001

Q1002

Q1006

Q1004

Q1005

Q1009

D1004

D1003

CN1001

R1012

R1006

J1001

0.001

10k

14.31818MHz22p

22p

10k 0.01

0.01

10k

470 0.01

100

22p

2.2k

150V

2.2k

0.0110010V 0.01

10010V

22k

10010V

01

50V 2P

4.7k

4.7k

10k

220p

4706.3V22

50V

10010V

0.01 TA7805S

SN74AHCT04NSR

MSM514400E-60-TS-K

0.01 0.01

4.7k

2.2k

220

220

220

0

10k

10k

NJM2575F1-TE2

0.01

75

0

0.01

0.01

4735V

0.47

TC9411AFG

0

DTC114EKA-T146+B SWITCH

2SB1116-TP-LK+B SWITCH

DTC114EKA-T146BUFFER



DTA114EKA-T146BUFFER



DTA114EKA-T146BUFFER

1SS355TE-17

1SS355TE-17

13P

4.7k

4.7k

1P

WFCKSCOR

EXCK

CDG/_BGC

CDG-DET

_HALT-CLK

CDG-POWER

VMUTE

EXCK

WFCK

SCOR

MUTE_DATA

_CDG-RST

MUTE_DATA_HALT-CLK

VMUTE

CDG-DET

_CDG-RSTCDG/_BGC

CDG-POWER

VIDEO D/A

DRAM

+5V REG

VIDEO BUFFER

BUFFER(2/3)

(3/3)

MAINBOARD

MAINBOARD

(Page38)

(Page39)

HCD-GNX88

5050HCD-GNX88

7-25. PRINTED WIRING BOARD – TRANS, PRIMARY BOARDS – • See page 26 for Circuit Boards Location.

Ref. No. Location

D1200 E-3D1264 D-8D1292 C-7

Q1200 F-3Q1264 D-8


R126

2R1

263

R126

4

D1264

Q120

0

R120

0R1

201

C120

2

C1201 D1200

JR12

02

JW1210

JW12

04

NO1201

NO1203

CN12

12

C1263

Q1264

C1262

NO1211

CN12

13

CN1202

C1206

RY12

00CN1200

CN1204

L1201

PL12

00

PL12

01PL

1202

PL12

12PL

1213

FH1242

FH1251FH1252

FH1261

FH1262

FH1271FH1272

FH1282

E

FH1281

R129

2

FH1241

F1241

F1251

F1261

F1271

F1281

JW1202JW1201

JW1206JW1207

JW1208JW1209

JW1213

JW12

14

JW12

15

JW1220

JW1221

JW1211

C1292

JW12

16

JW12

30

JW1222

JW1223

PL12

11

D1292

BOARDTRANS

BOARDPRIMARY

11(11)1-864-932-

11(11)1-864-931-

1

2

1

1

1

7

8

PPA

BOARD(Page 44)

IMAIN

BOARD(Page 36)

AC IN

NOT REPLACEABLE: BUILT IN TRANSFORMER

T1200POWER TRANSFORMER

*

*

1

1

2

2

CMAIN

BOARD(Page 36)

POWERSWITCHING

2

E

2 3 4 5 6 7 8 9 10

A

1

B

C

D

E

F

G

H


HCD-GNX88

5151HCD-GNX88

7-26. SCHEMATIC DIAGRAM – TRANS, PRIMARY BOARD –

FH1261 FH1262

FH1271 FH1272

FH1242FH1241

FH1252FH1251

FH1281 FH1282

CN1212

CN1200

NO1201

NO1203

CN1202

RY1200

D1200

JR1202 C1202L120118uH

C1201

C1206

R1201

R1200

R1264

R1263

R1262C1262

C1263

C1292

R1292

JW1292

JW1293

JW1211

T1200

JW1204

F1271

F1261

F1251

F1241

F1281

CN1213

D1264

D1292

Q1200

CN1211 CN1204

Q1264

MT MT

MT MT

MTMT

MTMT

MT MT

7P

3P

2P

2P

2P

RELAY5V

1SS355TE

0 0.10.1

10006.3V

100k

4.7k

1k

8.2k

8.2k10

50V

10050V

10063V

0.68

POWERTRANSFORMER

T8.00AL250V

T8.00AL250V

T8.00AL250V

T8.00AL250V

T3.15AL250V

6P

HZU36BTRF

10EDB40

2SC2412KT-146-RRELAY DRIVE

2P 2P

2SB1565E-33V REG.

BUILT IN TRANSFORMERNOT REPLACEABLE:*

*

BOARDPA

(3/3)

MAINBOARD

BOARDMAIN

(1/3)(Page37)

(Page39)

(Page45)

HCD-GNX88

5252HCD-GNX88

• WAVEFORMS

– MAIN BOARD –– BD84 BOARD – – PANEL BOARD –

2.7 Vp-p

32.768 kHz

2.0 Vp-p

16 MHz

1V/DIV, 10 µsec/DIV

1V/DIV, 50 nsec/DIV

10.5 µsec



67 Vp-p

10.5 µsec

82 Vp-p

1 IC401 qa XC-OUT

2 IC401 qd X-OUT

3 T301 5 TAPE REC only

4 T301 4 TAPE REC only

0.15 Vp-p

0.2V/DIV, 0.2 msec/DIV

0.1V/DIV, 1 msec/DIV

0.9 ±0.4 Vp-p

0.2V/DIV, 0.5 µsec/DIV

0.4 Vp-p

1 IC101 wa TEI

2 IC101 wd FEI

3 IC101 ra RFAC

3.1 Vp-p

4 MHz

1V/DIV, 0.2 µsec/DIV

1 IC902 is X OUT

– DRIVER Board –

IC701, 712 BA6956AN

• IC Block Diagram

– BD84 Board –

IC251 BA5947FM-E2

1 2 3 4 5 6 7 8 9

CONTROL LOGIC

TSD

VREF

OUT2

OUT1

RNF

VM VCC

FIN

GND

RIN

11

12

13

1415

16

17

18

19

20

21

22

23

24

25

26

27

28 1

2

3

4

5

6

7

8

9

10

LEVELSHIFT

FR

R

F

RF

F

19k

6.5k

50k 50k

100k

50k

PIN310k

Vref

50k 50k

PIN26

(ch1, 2)

POWVCC

(ch3, 4)

SW

PreVcc

INTERFACE

INTERFACE

INTERFACE

R

F

50k 50k

POWVCC

MUT

E

Vref

POWVCC

POWVCC

RF

10k

CH1OUTF

CH1OUTR

CH2OUTF

CH2OUTR

POWVCC

CNF4

GND

GND

CH2RIN

CH2FIN

CH1RIN

CH1FIN

SW

OPIN+

OPIN-

CH4OUTR

CH4OUTF

CH3OUTF

CH3OUTR

POWVCC

MUTE

GND

GND

CH3RIN

CH3FIN

CH4IN

CH4CAPA

OUTVREF

DPOUT

TREVCC

D

D

D

D

D

D

D

D

– PANEL Board –

IC904 NJM2760V-TE2

BPF1IN2

DET

IN1 1

IN2 2

BPF2IN1 4

BPF2IN2 5

18

BPF2OUT15

BPF1IN119

BPF2OUT20

BPF DET

BPF3IN1 6

BPF3IN2 7BPF3OUT14BPF DET

BPF4IN1 8

BPF4IN2 9BPF4OUT13BPF DET

GND 10 NC12

BUF1OUT 3

VCC11

RECOUT17

BPF1OUT16

BPF

DET

– CDG Board –

IC1006 NJM2575F1-TE2

2SAVE

3VOUTVIN

1PWR 6 VCC

GND5

LPF

75DRIVER 6dB

CLAMP

4

– CDG BOARD –

14.31818 MHz

2V/DIV, 50 nsec/DIV

5.9 Vp-p

1 IC1001 tl XI1

53

HCD-GNX88

– BD84 Board –

IC301 TC94A34FG-002

33

34

35

36

37

38

39

40

41

42

1

8

43

61 62 63 646059565250

47

46

45

44

48

49

2526272829303132 1718192021222324

9

10

11

2

3

4

5

6

7

5857555351

12

13

14

15

16

54

CS/RAS/ADO2

AD15/CAS/PD12

SDO3/OE

WE

/SD

O1

PIO

7/B

US

3/IO

7

PIO

6/F

I3/B

US

2/IO

7

PIO

5/F

I2/B

US

1/IO

5

PIO

4/F

I1/B

US

0/IO

4

BusSwitch

PO11/BUCK/AD14

PO10/CCE/AD13

PO9/AD12

PO08/AD11

Gen

eral

In/O

utpu

t Por

t

Add

ress

Cal

c.2s

ets

Y-P

oint

erre

gist

erC

-Poi

nter

regi

ster

X-P

oint

erre

gist

er

VDDM

SRMSTB

VDDT

AD10

AD9

ER

AM

2k w

ord

CR

AM

4k w

ord

CR

OM

4k w

ord

YR

AM

4k w

ord

XR

AM

4k w

ord

SR

AM

/D

RA

M I/

F

SR

AM

I/F

1Mbi

tS

RA

MX

-Bus

Y-B

us

PO07/AD7

PO06/AD6

PO05/AD5

AD8

VC0Timing

Generator

PR

AM

Inst

ruct

ion

Dec

oder

Pro

gram

Con

trol

MC

U. I

/F

regi

ster

XO

• X

1 •

X2

Y0

• Y1

• Y2

MX

MY

MZ

MA

C

A0

A1

AX

AY

ALU

A2

A3

DIT

roun

d &

lim

itro

und

& li

mit

Aud

io I/

F

LRCKIA

BCKIA

SDI0

LRCKO

BCKO

SDO0

VSS

VDDT

MIACK

MICK

MIDIO

MILP

MICS

STANBY

RESET

VDDP

AD

4/P

O04

AD

3/P

O03

AD

2/P

O02

AD

1/P

O01

AD

0/P

O00

VS

S

VD

D

CK

O/P

O13

/AD

16

VD

DX

XO

TE

ST

VC

OI

VS

SXXI

MIM

D

VS

SP

PIO

3/IO

3

PIO

2/IO

2

PIO

1/S

DI3

/IO1

PIO

0/S

DI2

/IO0

VS

S

CK

I/CLO

CK

/IRQ

/FIO

VD

D

TX

O

SF

SY

/LR

CK

IB

SB

SY

/BC

KIB

SD

I1/D

ATA

PO

M

Sub

cod

eI/F

CD

P C

ont

I/F

54

HCD-GNX88

7-27. IC Pin Function Descriptions• IC101 CXD3059AR (RF AMP) (BD84 BOARD)

Pin No. Pin Name I/O Description

1 MIRR I/O Not used (Open)

2 DFCT I/O Not used (Open)

3 FOK I/O Not used (Open)

4 VSS — Ground

5 LOCK I/O Not used (Open)

6 MDP O Spindle motor servo control output

7 SSTP I Disk innermost detection signal input

8 IOVSS1 — Ground

9 SFDR O Sled drive signal output

10 SRDR O Sled drive signal output

11 TFDR O Tracking drive signal output

12 TRDR O Tracking drive signal output

13 FFDR O Focus drive signal output

14 FRDR O Focus drive signal output

15 IOVDD1 — Power supply (+3.3V)

16 AVDD0 — Power supply (+3.3V)

17 AVSS0 — Ground

18 NC — Not used (Open)

19 E I E signal input

20 F I F signal input

21 TEI I Tracking error signal input

22 TEO O Tracking error signal output

23 FEI I Focus error signal input

24 FEO O Focus error signal output

25 VC I/O Center voltage output from RF amplifier block

26 A I A signal input

27 B I B signal input

28 C I C signal input

29 D I D signal input



32 RFDCO O RFDC signal output (Not used)

33 PDSENS I Reference voltage pin

34 AC_SUM O RFAC summing amplifier output

35 EG_IN I Equalizer circuit input

36 LD O APC LD drive signal output

37 PD I APC PD signal input


39 RFC I Equalizer cut-off frequency adjustment pin

40 AVSS4 — Ground

41 RFACO O RFAC signal output

42 RFACI I RFAC signal input or EFM signal input


44 BIAS I Asymmetry circuit constant current input

45 ASYI I Asymmetry comparator voltage input

46 ASYO O EFM full-swing output

47 VPCO O Not used (Open)

48 VCTL I Wide-band EFM PLL VCO2 control voltage input

55

HCD-GNX88


49 AVSS3 — Ground

50 CLTV I Multiplier VCO1 control voltage input

51 FILO O Master PLL (slave = digital PLL) filter output

52 FILI I Master PLL filter input

53 PCO O Master PLL charge pump output


55 DDVROUT O DC/DC converter output (+2.5V)

56 DDVRSEN I DC/DC converter output voltage monitor input

57 AVSS5 — Ground

58 DDCR I DC/DC converter reset input


60 BCKI I D/A interface bit clock input

61 PCMDI I D/A interface serial data input

62 LRCKl I D/A interface LR clock input

63 LRCK O D/A interface LR clock output f = Fs

64 VSS — Ground

65 PCMD O D/A interface serial data output

66 BCK O D/A interface bit clock output

67 VDD — Power supply (+2.5V)

68 EMPH O High when the playback disc has emphasis, low it has not

69 EMPHI I High when de-emphasis is ON, low when input OFF


71 DOUT O Digital Out output

72 TEST I Test pin (Connected ground)

73 TEST1 I Test pin (Connected ground)

74 IOVSS2 — Ground


76 XVSS — Ground

77 XTAO O Crystal oscillation circuit output

78 XTAI I Crystal oscillation circuit input

79 XVDD — Power supply (+2.5V)


81 AOUT1 O L-ch analog output

82 VREFL O L-ch reference voltage

83 AVSS1 — Ground

84 AVSS2 — Ground

85 VREFR O R-ch reference voltage

86 AOUT2 O R-ch analog output




90 RMUT O Not used (Open)

91 LMUT O Not used (Open)


93 XTSL I Crystal selection input (Pull down)

94 IOVSS0 — Ground

95 XTACN I Oscillation circuit control (H:Self-oscillation, L:oscillation stop)

96 SQSO O Not used (Open)

97 SQCK I SQSO readout clock input (Connected to +VDD(+3.3v))

98 SBSO O Sub code P to W serial output

56

HCD-GNX88


99 EXCK I SBSO readout clock input

100 XRST I System reset input from M30622MEP

101 SYSM I Mute input (Connected to ground)

102 DATA I Serial data input from M30622MEP

103 VSS — Ground

104 XLAT I Latch input from M30622MEP

105 CLOCK I Serial data transfer clock input from M30622MEP


107 SENS O SENS output to M30622MEP

108 SCLK I SENS serial data readout clock input (Connected to +VDD(+3.3v))

109 ATSK I/O Not used (Open)

110 WFCK O WFCK output

111 XUGF O Not used (Open)

112 XPCK O Not used (Open)

113 GFS O Not used (Open)

114 C2PO O Not used (Open)

115 SCOR O High output when the sub code sync, S0 or S1, is detected


117 C4M O Not used (Open)

118 WDCK O Not used (Open)

119 COUT I/O Not used (Open)


57

HCD-GNX88


1 XRST O Reset signal output to CXD3053AR

2 CD-DATA O Serial data output to CXD3053AR

3 XLAT O Serial data latch signal output to CXD3053AR

4 SIRCS I Remote control signal input

5 MP3 DATA OUT O Serial data output to TC94A34FG

6 MP3 DATA IN I Serial data input from TC94A34FG

7 MP3 CLK O Serial data transfer clock output to TC94A34FG

8 BYTE I Not used (Connected to ground)

9 CNVSS — Ground at test (Pull down)

10 XC-IN I Sub system clock input (32.768KHz)

11 XC-OUT O Sub system clock output (32.768KHz)

12 RESET I System reset input

13 X-OUT O Main system clock output (16MHz)

14 VSS — Ground

15 X-IN I Main system clock input (16MHz)

16 VCC — Power supply (+5V)

17 NMI I Not used (Pull up with resistor)

18 CD-CLK O CD data clock output

19 SCOR I Sub code sync (S0+S1) detection signal input

20 AC-CUT I AC off detection signal input

21 SENS I Internal status detection monitor input from CXD3059AR

22 MP3 RST O Reset signal output to TC94A34FG

23 MP3 CS O Chip select signal output to TC94A34FG

24 MP3 LP O Latch pulse output to TC94A34FG

25 MP3 ACK I Acknowledge signal input from TC94A34FG

26 MP3 REQ I Request signal input to TC94A34FG

27 MP3 STB O Standby mode signal output to TC94A34FG

28 XTCN O Oscillation on/off control signal output to CXD3053AR and TC9411AFG

29 IIC-CLK I/O IIC bus serial clock input/output

30 IIC-DATA I/O IIC bus serial data input/output

31 VMUTE O CDG video signal muting on/off control signal output

32 CD POWER O CDG power on/off control signal output

33 CDG DET I CDG disc detection signal input from TC9411AFG

34 CDG/BGC O CDG/Blue background control signal output to TC9411AFG

35 CDG RST O Reset signal output to TC9411 AFG

36 FAN KICK-OFF O Fan kick off pulse to start up fan rotation signal output

37 CD MUTE O CD muting on/off control signal output

38 OPEN SW I Eject detection signal input

39 TBL-SENS I Disc tray position detection signal input

40 E-3 I Disc tray status detection signal input



43 TM-F O Table motor control signal output

44 TM-R O Table motor control signal output

45 LMF O Table loading motor control signal output

46 LMR O Table loading motor control signal output

47 A-PLAY I Deck A playback detection signal input

48 A-HALF I Deck A cassette detection signal input

49 SW LED1 O LED drive signal output

• IC401 M30622MEP-A02FPUO SYSTEM CONTROL (MAIN Board)

58

HCD-GNX88


50 SW LED2 O LED drive signal output

51 B-PLAY I Deck B playback detection signal input

52 THERMAL VACS I Thermal VACS detection input

53 A-TRIG O Deck A side trigger plunger drive signal output

54 CAPM-CONT O Capstan motor drive signal output

55 B-TRIG O Deck B side trigger plunger drive signal output

56 REC BIAS O Recording bias on/off control signal output

57 TC-RELAY O Recording/playback selection signal output

58 ALC O Automatic limiter control signal output

59 PB-AB O Deck A/B playback selection signal output

60 AMS-IN I Not used

61 UNDER VOLTAGE DET I Not used (Open)

62 VCC — Power supply(+3.3V)

63 OVER VOLTAGE O Not used (Open)

64 VSS — Ground

65 TC MUTE/IO-EXP DATA OUT O Tape playback muting on/off signal output

66 LINE MUTE O Line muting on/off signal output

67 REC MUTE O Recording muting on/off signal output

68 SW RY/IO-EXP CLK O Sub woofer relay drive signal output

69 STBY-RLY O Main power on/off signal output

70 PROT I Speaker protect detection signal input

71 GC-RESET O GC reset signal output

72 STBY-LED/FAN CTRL O POWER indicator LED drive signal output

73 DISPLAY-KEY I DISPLAY key press detection Interrupt signal input

74 POWER-KEY I POWER key press detection Interrupt signal input

75 HP-MUTE O Headphone muting on/off signal output

76 FR RELAY O front speakers relay drive signal output

77 LINK/SURR-RLY O Surround speaker mode control signal output

78 STK-MUTE O Power amplifier and sub woofer amplifier on/off control signal output

79 M61530-DATA O Serial data output to M61530FP

80 M61530-CLK O Serial transfer clock signal output to M61530FP

81 M61529-DATA O Serial data output to M61529FP

82 M61529-CLK O Serial transfer clock signal output to M61529FP

83 SW ON LED O SUB WOOFER ON LED drive signal output

84 ST-CE O PLL chip enable signal output to the tuner unit

85 MC DIN (ST) O PLL serial data output to the tuner unit

86 ST-CLK I PLL serial transfer clock signal output to the tuner unit

87 MC DOUT (ST) I PLL serial data input from the tuner unit

88 TUNED I Tuning detection signal input from the tuner unit

89 A SHUT I Shut off detection signal input from deck A side reel pulse detector

90 B SHUT I Shut off detection signal input from deck A side reel pulse detector

91 SW AD KEY I Sub woofer on/off and surround speaker mode key input

92 MODEL-IN I Model input

93 DEST-IN I Destination input

94 B-HALF I Deck B cassette , forward side recording tab and reverse side recording tab detection signal input

95 SW VOL IN I Subwoofer on/off signal input

96 AVSS — Ground

97 BPF DET I Low frequency signal input from NJM2760 for RANDOM mode

98 VREF I A/D reference voltage input

99 AVCC — Power supply (+3.3V)

100 HP DET I Headphone connection detection signal input

59

HCD-GNX88


1 to 8 G8 to G1 O FLD grid signal output

9, 10 P1,P2 O FLD segment signal output

11 VSS-IO — Ground

12 to 22 P3 to P13 O FLD segment signal output

23 VDD-FIP — Power supply (+3.3V)


42 VSS-IO — Ground


48 VKK — Power supply (-35V)

49 MD0 I MD0 signal at test

50 MD1/VDD-VFT I Not used (pull down)

51 MD2 I Not used (pull down)

52 LED CD/DVD O LED drive signal output

53 LED TUNER O LED drive signal output

54 LED TAPE O LED drive signal output

55 LED VIDEO O LED drive signal output

56 LED STOP,PAUSE O LED drive signal output

57 LED VOLUME 2,3 O LED drive signal output



60 IIC DATA I/O IIC bus serial data input/output

61 IIC CLK I/O IIC bus serial clock input/output

62 AVCC — Power supply (+3.3V)

63 AVSS — Ground

64 to 66 KEY0 to KEY2 I Key input (A/D)

67 ALL BAND I Audio L+R signal input

68 to 71 BPF4 to BPF1 I Spectrum analyzer signal input

72 LED AUX/GAME O LED drive signal output

73 JOG X-ROUND O LED drive signal output (Not used)

74 VOLUME I Volume encoder signal input

75 JOG I JOG dial encoder signal input

76 AMS I AMS dial signal input

77 RESET I Reset input

78 LED AMS+/-,FF/FW O LED drive signal output

79 LED PLAY O LED drive signal output

80 SELECTOR O LED group select signal output

81 VSS-CPU — Ground

82 XOUT O Crystal oscillator output (4MHz)

83 XIN I Crystal oscillator input (4MHz)

84 VCC-CPU — Power supply (+3.3V)

85 to 100 G24 to G9 O FLD grid signal output

• IC902 MB90M407PF-G-144-BNDE1 DISPLAY CONTROL (PANEL Board)

60

HCD-GNX88

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks

SECTION 8EXPLODED VIEWS

8-1. CASE (TOP), REAR PANEL SECTION

NOTE:• -XX, -X mean standardized parts, so they may

have some differences from the original one.• Items marked “*” are not stocked since they

are seldom required for routine service. Somedelay should be anticipated when ordering theseitems.

• The mechanical parts with no reference numberin the exploded views are not supplied.

• Hardware (# mark) list and accessories aregiven in the last of this parts list.

The components identified by mark 0 ordotted line with mark 0 are critical forsafety.Replace only with part number specified.

1

2

3

4

#1

not supplied

#1

#1

#1#1

#1

#1

#1

M891

510

6

7

#2

#1 #2

#1

#1

#1#1

not supplied

8

9

#1

#1

#1

not supplied

#1

3

4

not supplied

not supplied

not supplied

#1

10

lug

1 X-2025-408-1 LOADING PANEL ASSY2 2-342-117-01 CASE (TOP)3 3-363-099-32 SCREW (CASE 3 TP2)4 3-363-099-02 SCREW (CASE 3 TP2)5 1-693-671-11 TUNER (TM-10E)

6 A-1089-525-A PRIMARY BOARD, COMPLETE

07 1-468-737-21 POWER, SWITCHING8 A-1089-768-A CDG PC BOARD ASSY9 1-775-280-11 WIRE (FLAT TYPE) (31 CORE)10 3-970-608-11 SUMITITE (B3), +BVM891 1-763-372-11 FAN, DC

#1 7-685-647-79 SCREW +BVTP 3×10 TYPE2 IT-3#2 7-685-646-01 SCREW +BVTP 3×8 TYPE1

61

HCD-GNX88

8-2. FRONT PANEL SECTION


not supplied

not supplied

notsupplied

not supplied

not supplied

not supplied

not supplied

51

52 53

5455

57

58

59

6058

58

61

62

64

FL901

5858

58

58

58

65

66

6758

68

69

69 58

70

58

58

71

58

51 X-2025-400-1 FRONT PANEL ASSY52 2-342-128-01 ESCUTHEON (LID)53 2-342-108-01 LID (TC)54 2-342-134-01 SPRING (LID)55 2-342-111-01 HOLDER (TC-R)

57 2-342-110-01 HOLDER (TC-L)58 3-087-053-01 +BVTP2.6 (3CR)59 4-224-578-21 KNOB (MIC)60 2-342-104-01 KNOB (AMS)61 4-252-575-01 KNOB VOL

62 X-2025-430-1 KNOB JOG ASSY64 3-970-608-01 SUMITITE (B3), +BV65 1-828-992-11 WIRE (FLAT TYPE) (17 CORE)66 A-1089-476-A PANEL BOARD, COMPLETE67 2-342-136-01 SPRING (R)

68 2-342-135-01 SPRING (L)69 4-224-104-11 DAMPER70 A-1089-466-A MIC BOARD, COMPLETE71 1-797-165-11 DECK, MECHANICALFL901 1-519-794-11 VACUUM FLUORESCENT DISPLAYS

62

HCD-GNX88

8-3. CHASSIS SECTION


The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

#1

not supplied

not supplied

not supplied

not supplied

#1

#1

#1

#1 #1

#1

#1

F1241

T1200

F1251F1261

F1271

F1281

101

101

102

103

104

105

105

106

107

108

109

110

111

112

112112

112

101 4-900-386-01 SCREW102 A-1110-925-A PA BOARD, COMPLETE103 A-1089-507-A TRANS BOARD, COMPLETE104 A-1089-323-A SURROUND PC BOARD ASSY105 3-905-609-31 SCREW (TRANSISTOR)

106 1-828-956-11 WIRE (FLAT TYPE) (9 CORE)107 1-828-972-11 WIRE (FLAT TYPE) (13 CORE)

0108 1-827-226-11 CORD, POWER109 3-703-571-11 BUSHING (S) (4516), CORD110 1-828-973-11 WIRE (FLAT TYPE) (13 CORE)

111 A-1089-303-A MAIN BOARD ASSY112 3-970-608-11 SUMITITE (B3), +BV

0F1241 1-576-655-12 FUSE, GLASS TUBE (DIA. 5) (T8AL/250V)0F1251 1-576-655-12 FUSE, GLASS TUBE (DIA. 5) (T8AL/250V)0F1261 1-576-655-12 FUSE, GLASS TUBE (DIA. 5) (T8AL/250V)

0F1271 1-576-655-12 FUSE, GLASS TUBE (DIA. 5) (T8AL/250V)0F1281 1-533-470-12 FUSE, GLASS TUBE (DIA. 5) (T3.15AL/250V)0T1200 1-443-584-11 POWER TRANSFORMER

#1 7-685-647-79 SCREW +BVTP 3×10 TYPE2 IT-3

63

HCD-GNX88

8-4. CD MECHANISM DECK SECTION-1(CDM74-F1BD84)


152

154

155155

156

156157

157

158

158159

151

156

162

163

164165160

161164

CD mechanism deck section-2151

153

166

M741

151 4-218-253-32 SCREW (M2.6), +BTTP152 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)153 1-687-134-12 MOTOR (TB) BOARD154 4-243-815-01 TABLE (LOADING)155 4-245-571-02 GEAR (STOPPER)

156 4-218-252-61 SCREW (+PTPWH M2.6), FLOATING157 4-245-570-01 GEAR (JOINT)158 4-245-572-01 BUSHING (GEAR)

159 1-687-132-12 SENSOR BOARD160 4-243-820-01 GEAR (TABLE)161 4-243-819-01 GEAR (GENEVA)162 4-243-816-01 TRAY163 4-243-823-01 BELT (TABLE)

164 4-985-672-01 SCREW (+PTPWH M2.6), FLOATING165 4-243-821-01 PULLEY (TABLE)166 3-231-598-01 SHEET (BA)M741 A-4723-963-A MOTOR ASSY, TABLE

64

HCD-GNX88

8-5. CD MECHANISM DECK SECTION-2(CDM74-F1BD84)



201

202

202

202

203

204

205

206

207

208

210

211

212 213

214

215

216217

219231220

205

233

222

223

223

224

224

225

225

226

232

230

218223

223

222229

222

222

205

205205

205

M751

not supplied

RE701

228

201 1-687-135-12 DRIVER BOARD202 4-218-253-52 SCREW (M2.6), +BTTP203 1-687-669-12 SW BOARD204 4-244-034-01 BELT (LOADING)205 4-218-252-52 SCREW (+PTPWH M2.6), FLOATING

206 4-225-844-01 GEAR (LOADING A)207 4-224-613-01 GEAR (SHAFT)208 1-687-133-12 MOTOR (LD) BOARD210 4-244-108-01 GEAR, SWING211 4-224-609-01 GEAR (LOADING C)

212 4-224-608-01 COLLAR, SWING213 3-016-533-01 WASHER (FR), STOPPER214 4-224-611-01 GEAR (LOADING B)215 4-224-606-01 GEAR (RV)216 4-243-818-01 GEAR (U/D)

217 4-243-822-02 LEVER (LIFTER)

218 X-4955-774-2 PULLEY (SM) ASSY, CHUCKING219 4-221-688-01 PULLEY (B), CHUCKING220 X-4955-536-1 HOLDER (213) ASSY222 4-227-549-11 INSULATOR223 4-227-045-11 SPRING (INSULATOR), COIL

224 4-231-151-01 STOPPER (BU)225 4-218-253-42 SCREW (M2.6), +BTTP226 1-827-992-11 WIRE (FLAT TYPE) (16 CORE)228 A-1084-901-A BD84 BOARD, COMPLETE

0229 8-820-244-01 OPTICAL PICK-UP KSM-215DCP/C2NP

230 1-471-035-11 MAGNET ASSY231 4-243-817-22 CHASSIS232 3-087-053-01 +BVTP2.6 (3CR)233 4-985-672-01 SCREW (+PTPWH M2.6), FLOATINGM751 A-4737-553-A MOTOR ASSY, LOADING

RE701 1-477-680-12 ENCODER, ROTARY

65

HCD-GNX88SECTION 9

ELECTRICAL PARTS LIST


NOTE:• Due to standardization, replacements in the

parts list may be different from the partsspecified in the diagrams or the componentsused on the set.

• -XX, -X mean standardized parts, so theymay have some difference from the originalone.

• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated whenordering these items.

• CAPACITORS:uF: µF

• RESISTORSAll resistors are in ohms.METAL: metal-film resistorMETAL OXIDE: Metal Oxide-film resistorF: nonflammable

• COILSuH: µH

• SEMICONDUCTORSIn each case, u: µ, for example:uA...: µA... , uPA... , µPA... ,uPB... , µPB... , uPC... , µPC... ,uPD..., µPD...

The components identified by mark 0or dotted line with mark 0 are criticalfor safety.Replace only with part number specified.

When indicating parts by referencenumber, please include the board.

A-1084-901-A BD84 BOARD, COMPLETE********************

< CAPACITOR >

C10 1-165-989-11 CERAMIC CHIP 10uF 10% 6.3VC11 1-165-989-11 CERAMIC CHIP 10uF 10% 6.3VC14 1-164-360-11 CERAMIC CHIP 0.1uF 16VC15 1-164-360-11 CERAMIC CHIP 0.1uF 16VC16 1-115-156-11 CERAMIC CHIP 1uF 10V

C17 1-126-246-11 ELECT CHIP 220uF 20% 4VC18 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC111 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50VC112 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC113 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50V

C114 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC115 1-164-360-11 CERAMIC CHIP 0.1uF 16VC116 1-128-995-21 ELECT CHIP 100uF 20% 10VC122 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC123 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C124 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC125 1-164-360-11 CERAMIC CHIP 0.1uF 16VC131 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC132 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3VC133 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C134 1-164-360-11 CERAMIC CHIP 0.1uF 16VC141 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC142 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC143 1-164-360-11 CERAMIC CHIP 0.1uF 16VC151 1-128-995-21 ELECT CHIP 100uF 20% 10V

C161 1-164-360-11 CERAMIC CHIP 0.1uF 16VC162 1-164-360-11 CERAMIC CHIP 0.1uF 16VC163 1-164-360-11 CERAMIC CHIP 0.1uF 16VC171 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC172 1-162-920-11 CERAMIC CHIP 27PF 5% 50V

C174 1-164-360-11 CERAMIC CHIP 0.1uF 16VC181 1-164-360-11 CERAMIC CHIP 0.1uF 16VC182 1-164-360-11 CERAMIC CHIP 0.1uF 16VC183 1-124-778-00 ELECT CHIP 22uF 20% 6.3VC184 1-124-778-00 ELECT CHIP 22uF 20% 6.3V

C185 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC186 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC194 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C195 1-164-360-11 CERAMIC CHIP 0.1uF 16VC196 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C201 1-128-995-21 ELECT CHIP 100uF 20% 10VC203 1-128-995-21 ELECT CHIP 100uF 20% 10VC209 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC210 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC211 1-164-230-11 CERAMIC CHIP 220PF 5% 50V

C212 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC213 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC251 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25VC252 1-164-360-11 CERAMIC CHIP 0.1uF 16VC255 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C257 1-164-360-11 CERAMIC CHIP 0.1uF 16VC258 1-164-360-11 CERAMIC CHIP 0.1uF 16VC259 1-164-360-11 CERAMIC CHIP 0.1uF 16VC260 1-128-394-11 ELECT CHIP 220uF 20% 10VC302 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C303 1-164-360-11 CERAMIC CHIP 0.1uF 16VC305 1-126-246-11 ELECT CHIP 220uF 20% 4VC306 1-164-360-11 CERAMIC CHIP 0.1uF 16VC307 1-164-360-11 CERAMIC CHIP 0.1uF 16VC308 1-126-208-21 ELECT CHIP 47uF 20% 4V

C309 1-164-360-11 CERAMIC CHIP 0.1uF 16VC310 1-164-360-11 CERAMIC CHIP 0.1uF 16VC311 1-164-360-11 CERAMIC CHIP 0.1uF 16VC312 1-164-360-11 CERAMIC CHIP 0.1uF 16VC313 1-164-360-11 CERAMIC CHIP 0.1uF 16V

C314 1-126-208-21 ELECT CHIP 47uF 20% 4VC315 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC316 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC317 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC318 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C320 1-216-864-11 SHORT CHIP 0

< CONNECTOR >

CN101 1-770-425-11 CONNECTOR, FFC/FPC 16PCN201 1-784-879-21 CONNECTOR, FFC (LIF (NON-ZIF)) 31P

< FERRITE BEAD >

FB301 1-500-445-21 FERRITE, EMI (SMD) (2012)

BD84

66

HCD-GNX88


< IC >

IC101 8-752-425-12 IC CXD3059ARIC251 6-705-808-01 IC BA5947FM-E2IC301 6-705-365-01 IC TC94A34FG-002IC303 6-705-807-01 IC BH15FB1WG

< TRANSISTOR >

Q10 6-551-120-01 TRANSISTOR 2SA2119K

< RESISTOR >

R10 1-216-791-11 METAL CHIP 3.3 5% 1/10WR11 1-216-864-11 SHORT CHIP 0R12 1-216-845-11 METAL CHIP 100K 5% 1/10WR13 1-218-446-11 METAL CHIP 1 5% 1/10WR111 1-216-821-11 METAL CHIP 1K 5% 1/10W

R112 1-216-835-11 METAL CHIP 15K 5% 1/10WR113 1-216-821-11 METAL CHIP 1K 5% 1/10WR114 1-216-835-11 METAL CHIP 15K 5% 1/10WR121 1-216-835-11 METAL CHIP 15K 5% 1/10WR131 1-216-857-11 METAL CHIP 1M 5% 1/10W

R132 1-216-833-11 METAL CHIP 10K 5% 1/10WR133 1-216-848-11 METAL CHIP 180K 5% 1/10WR141 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR142 1-216-821-11 METAL CHIP 1K 5% 1/10WR143 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R151 1-216-864-11 SHORT CHIP 0R161 1-216-809-11 METAL CHIP 100 5% 1/10WR162 1-216-841-11 METAL CHIP 47K 5% 1/10WR163 1-216-809-11 METAL CHIP 100 5% 1/10WR165 1-216-864-11 SHORT CHIP 0

R171 1-216-817-11 METAL CHIP 470 5% 1/10WR172 1-216-857-11 METAL CHIP 1M 5% 1/10WR173 1-216-295-91 SHORT CHIP 0R181 1-216-809-11 METAL CHIP 100 5% 1/10WR182 1-216-809-11 METAL CHIP 100 5% 1/10W

R191 1-216-864-11 SHORT CHIP 0R201 1-500-445-21 FERRITE, EMI (SMD) (2012)R203 1-216-864-11 SHORT CHIP 0R204 1-500-445-21 FERRITE, EMI (SMD) (2012)R205 1-216-864-11 SHORT CHIP 0

R251 1-216-833-11 METAL CHIP 10K 5% 1/10WR252 1-216-837-11 METAL CHIP 22K 5% 1/10WR253 1-216-833-11 METAL CHIP 10K 5% 1/10WR301 1-216-845-11 METAL CHIP 100K 5% 1/10WR302 1-216-833-11 METAL CHIP 10K 5% 1/10W

R303 1-216-845-11 METAL CHIP 100K 5% 1/10WR305 1-216-845-11 METAL CHIP 100K 5% 1/10WR306 1-216-864-11 SHORT CHIP 0R307 1-216-833-11 METAL CHIP 10K 5% 1/10WR313 1-216-813-11 METAL CHIP 220 5% 1/10W

R351 1-216-809-11 METAL CHIP 100 5% 1/10WR352 1-216-809-11 METAL CHIP 100 5% 1/10WR353 1-216-809-11 METAL CHIP 100 5% 1/10WR354 1-216-809-11 METAL CHIP 100 5% 1/10WR401 1-216-809-11 METAL CHIP 100 5% 1/10W

R402 1-216-809-11 METAL CHIP 100 5% 1/10W

R403 1-216-809-11 METAL CHIP 100 5% 1/10WR404 1-216-809-11 METAL CHIP 100 5% 1/10WR405 1-216-809-11 METAL CHIP 100 5% 1/10WR406 1-216-809-11 METAL CHIP 100 5% 1/10W



< SWITCH >

S101 1-771-853-11 SWITCH, DETECTION (LIMIT)

< VIBRATOR >

X171 1-767-408-21 VIBRATOR, CRYSTAL (16.9MHz)*************************************************************

A-1089-768-A CDG BOARD ASSY***************

< CAPACITOR >

C1001 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1002 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1003 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1004 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1005 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C1006 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1007 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1008 1-126-960-11 ELECT 1uF 20% 50VC1010 1-104-658-91 ELECT 100uF 20% 10VC1011 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C1012 1-126-947-11 ELECT 47uF 20% 35VC1013 1-104-658-91 ELECT 100uF 20% 10VC1014 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1015 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1018 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

C1019 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC1021 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50VC1022 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC1023 1-126-960-11 ELECT 1uF 20% 50VC1024 1-104-658-91 ELECT 100uF 20% 10V

C1025 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1026 1-104-655-91 ELECT 470uF 20% 6.3VC1027 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC1028 1-104-658-91 ELECT 100uF 20% 10VC1029 1-165-647-91 CERAMIC CHIP 0.47uF 10% 6.3V

C1030 1-126-965-91 ELECT 22uF 20% 50V

< CONNECTOR >

CN1001 1-784-774-11 CONNECTOR, FFC 13PCN1003 1-785-314-11 PIN, CONNECTOR (STRAIGHT) 2P

BD84 CDG

67

HCD-GNX88


< DIODE >

D1003 8-719-988-61 DIODE 1SS355TE-17D1004 8-719-988-61 DIODE 1SS355TE-17

< EARTH TERMINAL >

EP1001 1-537-738-21 TERMINAL, GROUND

< FERRITE BEAD >

FB1001 1-216-864-11 SHORT CHIP 0

< IC >

IC1001 6-707-420-01 IC TC9411AFG (BS, K)IC1002 6-704-474-01 IC MSM514400E-60TS-KIC1003 8-759-231-53 IC TA7805SIC1005 8-759-584-98 IC SN74AHCT04NSRIC1006 6-703-378-01 IC NJM2575F1-TE2

< JACK >

J1001 1-774-227-11 JACK, PIN 1P (VIDEO OUT)

< SHORT >

JR1001 1-216-864-11 SHORT CHIP 0

< COIL >

L1001 1-216-296-11 SHORT CHIP 0L1002 1-216-296-11 SHORT CHIP 0

< TRANSISTOR >

Q1001 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1002 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1004 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1005 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1006 8-729-027-23 TRANSISTOR DTA114EKA-T146

Q1007 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1008 8-729-140-04 TRANSISTOR 2SB1116A-LQ1009 8-729-027-23 TRANSISTOR DTA114EKA-T146Q1010 8-729-027-43 TRANSISTOR DTC114EKA-T146

< RESISTOR >

R1003 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1004 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1005 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1006 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1011 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R1012 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1013 1-216-820-11 METAL CHIP 820 5% 1/10WR1015 1-216-864-11 SHORT CHIP 0R1016 1-216-833-11 METAL CHIP 10K 5% 1/10WR1017 1-216-833-11 METAL CHIP 10K 5% 1/10W

R1018 1-216-833-11 METAL CHIP 10K 5% 1/10WR1019 1-216-833-11 METAL CHIP 10K 5% 1/10WR1020 1-216-833-11 METAL CHIP 10K 5% 1/10WR1021 1-216-813-11 METAL CHIP 220 5% 1/10WR1022 1-216-813-11 METAL CHIP 220 5% 1/10W

R1023 1-216-813-11 METAL CHIP 220 5% 1/10W

R1029 1-216-809-11 METAL CHIP 100 5% 1/10WR1030 1-216-837-11 METAL CHIP 22K 5% 1/10WR1031 1-218-285-11 METAL CHIP 75 5% 1/10WR1032 1-216-833-11 METAL CHIP 10K 5% 1/10W

R1033 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1034 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

< VIBRATOR >

X1002 1-795-153-11 VIBRATOR, CRYSTAL (14.31818MHz))*************************************************************

CD-SW BOARD************

< RESISTOR >

R1169 1-216-817-11 METAL CHIP 470 5% 1/10WR1171 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1172 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1173 1-216-821-11 METAL CHIP 1K 5% 1/10WR1174 1-216-819-11 METAL CHIP 680 5% 1/10W

< SWITCH >

S1156 1-762-875-21 SWITCH, KEYBOARD (DISC 1)S1157 1-762-875-21 SWITCH, KEYBOARD (DISC 2)S1158 1-762-875-21 SWITCH, KEYBOARD (DISC 3)S1159 1-762-875-21 SWITCH, KEYBOARD (EX-CHANGE/DISC SKIP)S1160 1-762-875-21 SWITCH, KEYBOARD (Z OPEN/CLOSE)

*************************************************************

1-687-135-12 DRIVER BOARD************

< CAPACITOR >

C715 1-126-933-11 ELECT 100uF 20% 16VC731 1-126-964-11 ELECT 10uF 20% 50VC735 1-164-159-11 CERAMIC 0.1uF 50VC736 1-164-159-11 CERAMIC 0.1uF 50VC737 1-164-159-11 CERAMIC 0.1uF 50V

C741 1-162-306-11 CERAMIC 0.01uF 20% 16VC751 1-162-306-11 CERAMIC 0.01uF 20% 16VC752 1-164-159-11 CERAMIC 0.1uF 50V

< CONNECTOR >

CN701 1-785-338-11 PIN, CONNECTOR (LIGHT ANGLE) 12PCN702 1-784-766-11 CONNECTOR, FFC 5P

* CN703 1-564-720-11 PIN, CONNECTOR (SMALL TYPE) 4PCN704 1-785-328-11 PIN, CONNECTOR (LIGHT ANGRE) 2P

< DIODE >

D701 8-719-947-16 DIODE MTZJ-T-72-5.1AD711 8-719-983-66 DIODE MTZJ-T-72-3.6B

< IC >

IC701 8-759-598-69 IC BA6956ANIC712 8-759-598-69 IC BA6956AN

< TRANSISTOR >

Q731 8-729-029-66 TRANSISTOR DTC114ESA

CDG DRIVERCD-SW

68

HCD-GNX88

Ref. No. Part No. Description Remarks Ref. No. Part No. Description RemarksRef. No. Part No. Description Remarks

MAIN

< RESISTOR >

R701 1-249-413-11 CARBON 470 5% 1/4WR702 1-247-807-31 CARBON 100 5% 1/4WR711 1-247-831-91 CARBON 1K 5% 1/4WR712 1-247-847-91 CARBON 4.7K 5% 1/4WR713 1-247-863-91 CARBON 22K 5% 1/4W

R721 1-247-847-91 CARBON 4.7K 5% 1/4WR722 1-247-847-91 CARBON 4.7K 5% 1/4WR723 1-247-847-91 CARBON 4.7K 5% 1/4WR731 1-247-807-31 CARBON 100 5% 1/4WR732 1-249-429-11 CARBON 10K 5% 1/4W

R733 1-247-831-91 CARBON 1K 5% 1/4WR734 1-249-430-11 CARBON 12K 5% 1/4WR735 1-247-807-31 CARBON 100 5% 1/4WR751 1-247-847-91 CARBON 4.7K 5% 1/4W

*************************************************************

JOG BOARD*********

< CAPACITOR >

C1150 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

< CONNECTOR >

* CNS903 1-562-573-11 SOCKET, CONNECTOR 8P

< DIODE >

D919 8-719-071-44 DIODE SELS5223C-TP15 (VOL 2)D920 8-719-071-44 DIODE SELS5223C-TP15 (VOL 3)D921 8-719-071-44 DIODE SELS5223C-TP15 (VOL 4)D922 8-719-071-44 DIODE SELS5223C-TP15 (VOL 5)D923 8-719-071-44 DIODE SELS5223C-TP15 (VOL 6)

D924 8-719-071-44 DIODE SELS5223C-TP15 (VOL 1)

< SHORT >

JR904 1-216-296-11 SHORT CHIP 0JR905 1-216-864-11 SHORT CHIP 0

< TRANSISTOR >

Q911 8-729-027-43 TRANSISTOR DTC114EKA-T146Q912 8-729-027-43 TRANSISTOR DTC114EKA-T146Q913 8-729-027-43 TRANSISTOR DTC114EKA-T146

< RESISTOR >


R1146 1-216-820-11 METAL CHIP 820 5% 1/10WR1156 1-216-821-11 METAL CHIP 1K 5% 1/10WR1157 1-216-820-11 METAL CHIP 820 5% 1/10WR1158 1-216-820-11 METAL CHIP 820 5% 1/10WR1159 1-216-820-11 METAL CHIP 820 5% 1/10W

R1190 1-216-809-11 METAL CHIP 100 5% 1/10WR1191 1-216-809-11 METAL CHIP 100 5% 1/10WR1192 1-216-809-11 METAL CHIP 100 5% 1/10W

< SWITCH >

S1161 1-479-203-11 ROTARY ENCODER (OPERATION DIAL)*************************************************************

A-1089-303-A MAIN BOARD ASSY***************

7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

< CAPACITOR >

C100 1-104-658-91 ELECT 100uF 20% 10VC102 1-126-964-11 ELECT 10uF 20% 50VC103 1-126-964-11 ELECT 10uF 20% 50VC104 1-126-964-11 ELECT 10uF 20% 50VC105 1-126-964-11 ELECT 10uF 20% 50V

C106 1-136-157-00 FILM 0.022uF 5% 50VC107 1-136-157-00 FILM 0.022uF 5% 50VC108 1-136-159-00 FILM 0.033uF 5% 50VC109 1-126-960-11 ELECT 1uF 20% 50VC110 1-162-974-11 CERAMIC CHIP 0.01uF 50V

C111 1-126-964-11 ELECT 10uF 20% 50VC112 1-136-170-00 FILM 0.27uF 5% 50VC113 1-136-170-00 FILM 0.27uF 5% 50VC114 1-126-791-11 ELECT 10uF 20% 35VC115 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C116 1-126-176-11 ELECT 220uF 20% 10VC121 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC122 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC130 1-126-964-11 ELECT 10uF 20% 50VC131 1-126-959-11 ELECT 0.47uF 20% 50V

C140 1-136-495-11 FILM 0.068uF 5% 50VC149 1-164-156-11 CERAMIC CHIP 0.1uF 25VC150 1-126-964-11 ELECT 10uF 20% 50VC152 1-126-964-11 ELECT 10uF 20% 50VC153 1-126-964-11 ELECT 10uF 20% 50V

C154 1-126-964-11 ELECT 10uF 20% 50VC155 1-126-964-11 ELECT 10uF 20% 50VC156 1-136-157-00 FILM 0.022uF 5% 50VC157 1-136-157-00 FILM 0.022uF 5% 50VC158 1-136-159-00 FILM 0.033uF 5% 50V

C159 1-126-960-11 ELECT 1uF 20% 50VC160 1-162-974-11 CERAMIC CHIP 0.01uF 50VC161 1-126-964-11 ELECT 10uF 20% 50VC162 1-136-170-00 FILM 0.27uF 5% 50VC163 1-136-170-00 FILM 0.27uF 5% 50V

C180 1-126-963-11 ELECT 4.7uF 20% 50VC181 1-126-963-11 ELECT 4.7uF 20% 50VC202 1-126-964-11 ELECT 10uF 20% 50VC203 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC204 1-126-923-91 ELECT 220uF 20% 10V

C205 1-164-156-11 CERAMIC CHIP 0.1uF 25VC206 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC207 1-126-960-11 ELECT 1uF 20% 50VC210 1-164-156-11 CERAMIC CHIP 0.1uF 25VC211 1-104-658-91 ELECT 100uF 20% 10V

C220 1-136-497-81 FILM 0.1uF 5% 50VC221 1-136-497-81 FILM 0.1uF 5% 50VC222 1-104-658-91 ELECT 100uF 20% 10V

JOGDRIVER

69

HCD-GNX88


MAIN

C223 1-104-658-91 ELECT 100uF 20% 10VC230 1-136-497-81 FILM 0.1uF 5% 50V

C231 1-136-497-81 FILM 0.1uF 5% 50VC250 1-126-964-11 ELECT 10uF 20% 50VC251 1-126-964-11 ELECT 10uF 20% 50VC260 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC261 1-162-957-11 CERAMIC CHIP 220PF 5% 50V

C262 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC263 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC264 1-165-647-91 CERAMIC CHIP 0.47uF 10% 6.3VC280 1-126-964-11 ELECT 10uF 20% 50VC281 1-126-964-11 ELECT 10uF 20% 50V

C301 1-136-967-11 FILM 0.012uF 5% 100VC303 1-136-497-81 FILM 0.1uF 5% 50VC304 1-126-964-11 ELECT 10uF 20% 50VC305 1-126-960-11 ELECT 1uF 20% 50VC306 1-126-961-11 ELECT 2.2uF 20% 50V

C307 1-126-964-11 ELECT 10uF 20% 50VC308 1-126-925-91 ELECT 470uF 20% 10VC309 1-126-947-11 ELECT 47uF 20% 35VC310 1-126-964-11 ELECT 10uF 20% 50VC311 1-126-964-11 ELECT 10uF 20% 50V

C312 1-126-964-11 ELECT 10uF 20% 50VC314 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC340 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC341 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC351 1-136-967-11 FILM 0.012uF 5% 100V

C353 1-136-497-81 FILM 0.1uF 5% 50VC354 1-126-157-11 ELECT 10uF 20% 16VC355 1-126-960-11 ELECT 1uF 20% 50VC356 1-126-961-11 ELECT 2.2uF 20% 50VC359 1-126-947-11 ELECT 47uF 20% 35V

C361 1-126-964-11 ELECT 10uF 20% 50VC364 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC370 1-137-150-11 FILM 0.01uF 5% 100VC371 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC372 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C373 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC374 1-126-947-11 ELECT 47uF 20% 35VC375 1-162-963-11 CERAMIC CHIP 680PF 10% 50VC376 1-162-963-11 CERAMIC CHIP 680PF 10% 50VC377 1-162-974-11 CERAMIC CHIP 0.01uF 50V

C378 1-162-928-11 CERAMIC CHIP 120PF 5% 50VC379 1-130-481-00 MYLAR 0.0068uF 5% 50VC380 1-162-928-11 CERAMIC CHIP 120PF 5% 50VC381 1-164-670-11 CERAMIC CHIP 1200PF 5% 16VC382 1-164-670-11 CERAMIC CHIP 1200PF 5% 16V

C383 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC384 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC385 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC386 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC391 1-126-933-11 ELECT 100uF 20% 16V

C405 1-164-156-11 CERAMIC CHIP 0.1uF 25VC410 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC411 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC412 1-164-156-11 CERAMIC CHIP 0.1uF 25VC416 1-104-656-11 ELECT 2200uF 20% 6.3V

C419 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC429 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC430 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC462 1-104-658-91 ELECT 100uF 20% 10VC464 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C497 1-164-156-11 CERAMIC CHIP 0.1uF 25VC498 1-126-964-11 ELECT 10uF 20% 50VC499 1-164-156-11 CERAMIC CHIP 0.1uF 25VC501 1-126-964-11 ELECT 10uF 20% 50VC502 1-136-497-81 FILM 0.1uF 5% 50V

C503 1-136-497-81 FILM 0.1uF 5% 50VC520 1-164-156-11 CERAMIC CHIP 0.1uF 25VC521 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC522 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC523 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C524 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC525 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC534 1-164-156-11 CERAMIC CHIP 0.1uF 25VC535 1-126-928-11 ELECT 3300uF 20% 10VC537 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C538 1-164-156-11 CERAMIC CHIP 0.1uF 25VC539 1-164-156-11 CERAMIC CHIP 0.1uF 25VC540 1-126-960-11 ELECT 1uF 20% 50VC541 1-126-960-11 ELECT 1uF 20% 50VC542 1-126-960-11 ELECT 1uF 20% 50V

C543 1-126-960-11 ELECT 1uF 20% 50VC544 1-126-960-11 ELECT 1uF 20% 50VC545 1-126-960-11 ELECT 1uF 20% 50VC546 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC547 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C550 1-126-933-11 ELECT 100uF 20% 16VC551 1-164-156-11 CERAMIC CHIP 0.1uF 25VC552 1-126-961-11 ELECT 2.2uF 20% 50VC553 1-126-942-61 ELECT 1000uF 20% 25VC560 1-130-483-00 MYLAR 0.01uF 5% 50V

C561 1-130-483-00 MYLAR 0.01uF 5% 50VC562 1-126-933-11 ELECT 100uF 20% 16VC563 1-126-925-91 ELECT 470uF 20% 10VC564 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC565 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V

C566 1-128-548-11 ELECT 4700uF 20% 25VC567 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25VC568 1-126-916-11 ELECT 1000uF 20% 6.3VC580 1-164-156-11 CERAMIC CHIP 0.1uF 25VC581 1-164-156-11 CERAMIC CHIP 0.1uF 25V

< CONNECTOR >

* CN100 1-564-706-11 PIN, CONNECTOR (SMALL TYPE) 4PCN102 1-566-857-11 SOCKET, CONNECTOR 7PCN105 1-564-507-11 PLUG, CONNECTOR 4PCN402 1-785-336-11 PIN, CONNECTOR (LIGHT ANGLE) 10PCN501 1-573-845-11 CONNECTOR, BOARD TO BOARD 13P

* CN502 1-774-876-21 CONNECTOR, BOARD TO BOARD 8P* CN503 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P

CN504 1-565-937-11 SOCKET, CONNECTOR 13PCN505 1-779-299-11 CONNECTOR, FFC (LIF (NON-ZIF)) 31PCN506 1-568-441-11 SOCKET, CONNECTOR 9P

* CN507 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P

70

HCD-GNX88


MAIN

* CN508 1-569-934-11 SOCKET, CONNECTOR 17P* CN509 1-569-930-11 SOCKET, CONNECTOR 13P* CN510 1-568-449-11 HOUSING, CONNECTOR (PC BOARD) 3P

CN513 1-778-226-21 CONNECTOR, BOARD TO BOARD 6P

* CN514 1-774-876-21 CONNECTOR, BOARD TO BOARD 8PCN560 1-785-314-11 PIN, CONNECTOR (STRAIGHT) 2PCN580 1-564-506-11 PLUG, CONNECTOR 3P

< DIODE >

D340 8-719-988-61 DIODE 1SS355TE-17D341 8-719-988-61 DIODE 1SS355TE-17D342 8-719-988-61 DIODE 1SS355TE-17D401 8-719-988-61 DIODE 1SS355TE-17D402 8-719-988-61 DIODE 1SS355TE-17


D550 8-719-988-61 DIODE 1SS355TE-17D560 8-719-028-23 DIODE D3SBA20-4101D561 6-500-522-21 DIODE 10EDB40-TB3D562 6-500-522-21 DIODE 10EDB40-TB3D563 6-500-522-21 DIODE 10EDB40-TB3

D581 8-719-069-56 DIODE UDZSTE-176.2BD583 8-719-978-33 DIODE DTZ-TT11-6.8B

< FERRITE BEAD >

FB150 1-216-864-11 SHORT CHIP 0FB260 1-216-864-11 SHORT CHIP 0FB261 1-216-864-11 SHORT CHIP 0FB262 1-216-864-11 SHORT CHIP 0FB263 1-216-864-11 SHORT CHIP 0

FB506 1-500-283-11 INDUCTOR, FERRITE BEADFB507 1-500-283-11 INDUCTOR, FERRITE BEADFB508 1-500-283-11 INDUCTOR, FERRITE BEADFB509 1-500-283-11 INDUCTOR, FERRITE BEADFB510 1-500-283-11 INDUCTOR, FERRITE BEAD

FB512 1-500-283-11 INDUCTOR, FERRITE BEAD

< IC >

IC101 6-703-650-11 IC M61529FP-D60GIC201 6-703-651-11 IC M61530FP-D60GIC210 8-749-019-25 IC TOTX141 (CD DIGITAL OUT)IC301 6-702-130-01 IC HA12237FIC401 6-805-072-01 IC M30622MEP-A02FPU0

IC402 6-705-809-01 IC BD4929G-TRIC550 6-703-610-01 IC RT8H015C-T112-1IC560 8-759-394-36 IC BA09TIC561 6-703-550-01 IC TA7809LSIC562 6-702-771-01 IC TA78033LS

< JACK >

J101 1-794-981-11 JACK, PIN 4P (TV, VIDEO/MD)

< SHORT >

JR001 1-216-864-11 SHORT CHIP 0

JR002 1-216-296-11 SHORT CHIP 0JR003 1-216-864-11 SHORT CHIP 0JR004 1-216-864-11 SHORT CHIP 0JR005 1-216-864-11 SHORT CHIP 0

JR007 1-216-296-11 SHORT CHIP 0JR009 1-216-864-11 SHORT CHIP 0JR010 1-216-864-11 SHORT CHIP 0JR012 1-216-864-11 SHORT CHIP 0JR014 1-216-864-11 SHORT CHIP 0






< COIL >

L302 1-414-189-31 INDUCTOR 100uHL370 1-410-780-11 INDUCTOR 27mHL371 1-410-780-11 INDUCTOR 27mHL372 1-414-189-31 INDUCTOR 100uH

< TRANSISTOR >

Q101 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q151 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q180 8-729-802-80 TRANSISTOR 2SC3661Q181 8-729-802-80 TRANSISTOR 2SC3661Q250 8-729-802-80 TRANSISTOR 2SC3661

Q251 8-729-802-80 TRANSISTOR 2SC3661Q280 8-729-802-80 TRANSISTOR 2SC3661Q281 8-729-802-80 TRANSISTOR 2SC3661Q340 8-729-903-46 TRANSISTOR 2SB1132-PQ341 8-729-903-46 TRANSISTOR 2SB1132-P

Q342 8-729-903-46 TRANSISTOR 2SB1132-PQ343 8-729-113-13 TRANSISTOR FA1A4M-L33Q344 8-729-113-13 TRANSISTOR FA1A4M-L33Q345 8-729-113-13 TRANSISTOR FA1A4M-L33Q370 8-729-141-75 TRANSISTOR 2SD596DV345

Q371 8-729-802-80 TRANSISTOR 2SC3661

71

HCD-GNX88


MAIN

Q372 8-729-802-80 TRANSISTOR 2SC3661Q373 8-729-802-80 TRANSISTOR 2SC3661Q374 8-729-802-80 TRANSISTOR 2SC3661Q375 8-729-802-80 TRANSISTOR 2SC3661

Q376 8-729-802-80 TRANSISTOR 2SC3661Q377 6-550-580-01 TRANSISTOR 2SA1235TP-1FQ378 6-550-185-01 TRANSISTOR RT1P137P-TP-1Q379 8-729-027-43 TRANSISTOR DTC114EKA-T146Q380 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q381 8-729-027-43 TRANSISTOR DTC114EKA-T146Q382 8-729-027-23 TRANSISTOR DTA114EKA-T146Q383 8-729-027-43 TRANSISTOR DTC114EKA-T146Q501 8-729-901-00 TRANSISTOR DTC124EKQ504 8-729-027-23 TRANSISTOR DTA114EKA-T146

Q505 8-729-901-00 TRANSISTOR DTC124EKQ540 8-729-027-31 TRANSISTOR DTA124EKA-T146Q541 8-729-027-43 TRANSISTOR DTC114EKA-T146Q542 8-729-027-31 TRANSISTOR DTA124EKA-T146Q543 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q544 8-729-027-31 TRANSISTOR DTA124EKA-T146Q545 8-729-027-43 TRANSISTOR DTC114EKA-T146Q560 6-550-185-01 TRANSISTOR RT1P137P-TP-1Q561 8-729-027-43 TRANSISTOR DTC114EKA-T146Q580 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q581 8-729-027-43 TRANSISTOR DTC114EKA-T146Q582 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q583 8-729-027-31 TRANSISTOR DTA124EKA-T146Q584 8-729-027-43 TRANSISTOR DTC114EKA-T146Q585 8-729-026-68 TRANSISTOR 2SD2525 (TP)

< RESISTOR >

R101 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR102 1-216-833-11 METAL CHIP 10K 5% 1/10WR103 1-216-818-11 METAL CHIP 560 5% 1/10WR104 1-216-821-11 METAL CHIP 1K 5% 1/10WR105 1-216-841-11 METAL CHIP 47K 5% 1/10W

R106 1-216-833-11 METAL CHIP 10K 5% 1/10WR107 1-216-813-11 METAL CHIP 220 5% 1/10WR116 1-216-809-11 METAL CHIP 100 5% 1/10WR121 1-216-821-11 METAL CHIP 1K 5% 1/10WR122 1-216-821-11 METAL CHIP 1K 5% 1/10W

R130 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR131 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR132 1-216-857-11 METAL CHIP 1M 5% 1/10WR133 1-216-845-11 METAL CHIP 100K 5% 1/10WR140 1-216-833-11 METAL CHIP 10K 5% 1/10W

R150 1-216-809-11 METAL CHIP 100 5% 1/10WR151 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR152 1-216-833-11 METAL CHIP 10K 5% 1/10WR153 1-216-818-11 METAL CHIP 560 5% 1/10WR154 1-216-821-11 METAL CHIP 1K 5% 1/10W

R155 1-216-841-11 METAL CHIP 47K 5% 1/10WR156 1-216-833-11 METAL CHIP 10K 5% 1/10WR157 1-216-813-11 METAL CHIP 220 5% 1/10WR166 1-216-809-11 METAL CHIP 100 5% 1/10WR180 1-216-833-11 METAL CHIP 10K 5% 1/10W

R181 1-216-833-11 METAL CHIP 10K 5% 1/10WR182 1-216-841-11 METAL CHIP 47K 5% 1/10W

R183 1-216-841-11 METAL CHIP 47K 5% 1/10WR184 1-216-821-11 METAL CHIP 1K 5% 1/10WR185 1-216-821-11 METAL CHIP 1K 5% 1/10W

R186 1-216-833-11 METAL CHIP 10K 5% 1/10WR187 1-216-833-11 METAL CHIP 10K 5% 1/10WR203 1-216-864-11 SHORT CHIP 0R204 1-216-821-11 METAL CHIP 1K 5% 1/10WR205 1-216-821-11 METAL CHIP 1K 5% 1/10W

R220 1-216-845-11 METAL CHIP 100K 5% 1/10WR221 1-216-834-11 METAL CHIP 12K 5% 1/10WR228 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR229 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR250 1-216-821-11 METAL CHIP 1K 5% 1/10W


R256 1-216-839-11 METAL CHIP 33K 5% 1/10WR257 1-216-821-11 METAL CHIP 1K 5% 1/10WR260 1-216-864-11 SHORT CHIP 0R261 1-216-864-11 SHORT CHIP 0R262 1-216-864-11 SHORT CHIP 0

R263 1-216-864-11 SHORT CHIP 0R264 1-216-845-11 METAL CHIP 100K 5% 1/10WR265 1-216-845-11 METAL CHIP 100K 5% 1/10WR266 1-216-845-11 METAL CHIP 100K 5% 1/10WR267 1-216-845-11 METAL CHIP 100K 5% 1/10W



R286 1-216-839-11 METAL CHIP 33K 5% 1/10WR290 1-216-841-11 METAL CHIP 47K 5% 1/10WR291 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR292 1-216-841-11 METAL CHIP 47K 5% 1/10WR293 1-216-841-11 METAL CHIP 47K 5% 1/10W

R294 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR295 1-216-841-11 METAL CHIP 47K 5% 1/10WR296 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR297 1-216-841-11 METAL CHIP 47K 5% 1/10WR301 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R302 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR303 1-216-833-11 METAL CHIP 10K 5% 1/10WR304 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR305 1-216-841-11 METAL CHIP 47K 5% 1/10WR306 1-216-837-11 METAL CHIP 22K 5% 1/10W

R307 1-216-857-11 METAL CHIP 1M 5% 1/10WR308 1-216-809-11 METAL CHIP 100 5% 1/10WR309 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR310 1-216-809-11 METAL CHIP 100 5% 1/10WR311 1-216-864-11 SHORT CHIP 0

72

HCD-GNX88


MAIN

R312 1-216-809-11 METAL CHIP 100 5% 1/10WR319 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR336 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR337 1-216-833-11 METAL CHIP 10K 5% 1/10WR339 1-216-837-11 METAL CHIP 22K 5% 1/10W

R340 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR341 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR342 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR343 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR344 1-216-819-11 METAL CHIP 680 5% 1/10W

R345 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR346 1-216-819-11 METAL CHIP 680 5% 1/10WR347 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR348 1-216-819-11 METAL CHIP 680 5% 1/10WR349 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R351 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR352 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR353 1-216-833-11 METAL CHIP 10K 5% 1/10WR354 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR355 1-216-841-11 METAL CHIP 47K 5% 1/10W

R356 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR357 1-216-833-11 METAL CHIP 10K 5% 1/10WR369 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR370 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR371 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R372 1-216-833-11 METAL CHIP 10K 5% 1/10WR373 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR374 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR375 1-216-833-11 METAL CHIP 10K 5% 1/10WR376 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R377 1-216-805-11 METAL CHIP 47 5% 1/10WR378 1-216-833-11 METAL CHIP 10K 5% 1/10WR379 1-216-797-11 METAL CHIP 10 5% 1/10WR380 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR381 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R382 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR383 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR384 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR385 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR386 1-216-803-11 METAL CHIP 33 5% 1/10W

R387 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR388 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR389 1-216-837-11 METAL CHIP 22K 5% 1/10WR390 1-216-833-11 METAL CHIP 10K 5% 1/10WR391 1-216-833-11 METAL CHIP 10K 5% 1/10W

R392 1-216-833-11 METAL CHIP 10K 5% 1/10WR393 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR394 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR395 1-216-841-11 METAL CHIP 47K 5% 1/10WR396 1-216-833-11 METAL CHIP 10K 5% 1/10W

R397 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR399 1-216-833-11 METAL CHIP 10K 5% 1/10WR400 1-216-809-11 METAL CHIP 100 5% 1/10WR401 1-216-809-11 METAL CHIP 100 5% 1/10WR402 1-216-809-11 METAL CHIP 100 5% 1/10W

R403 1-216-809-11 METAL CHIP 100 5% 1/10WR404 1-216-809-11 METAL CHIP 100 5% 1/10WR405 1-216-809-11 METAL CHIP 100 5% 1/10W

R406 1-216-809-11 METAL CHIP 100 5% 1/10WR407 1-216-809-11 METAL CHIP 100 5% 1/10W

R409 1-216-833-11 METAL CHIP 10K 5% 1/10WR411 1-216-851-11 METAL CHIP 330K 5% 1/10WR412 1-216-845-11 METAL CHIP 100K 5% 1/10WR413 1-216-864-11 SHORT CHIP 0R417 1-216-833-11 METAL CHIP 10K 5% 1/10W

R418 1-216-813-11 METAL CHIP 220 5% 1/10WR419 1-216-809-11 METAL CHIP 100 5% 1/10WR420 1-216-821-11 METAL CHIP 1K 5% 1/10WR421 1-216-809-11 METAL CHIP 100 5% 1/10WR422 1-216-809-11 METAL CHIP 100 5% 1/10W






R449 1-216-809-11 METAL CHIP 100 5% 1/10WR450 1-216-809-11 METAL CHIP 100 5% 1/10WR451 1-216-809-11 METAL CHIP 100 5% 1/10WR452 1-216-809-11 METAL CHIP 100 5% 1/10WR463 1-216-833-11 METAL CHIP 10K 5% 1/10W




73

HCD-GNX88


MIC

R491 1-216-809-11 METAL CHIP 100 5% 1/10WR492 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR493 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR495 1-216-809-11 METAL CHIP 100 5% 1/10WR500 1-216-833-11 METAL CHIP 10K 5% 1/10W

R501 1-216-813-11 METAL CHIP 220 5% 1/10WR502 1-216-821-11 METAL CHIP 1K 5% 1/10WR503 1-216-864-11 SHORT CHIP 0R505 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR510 1-216-821-11 METAL CHIP 1K 5% 1/10W


R532 1-216-864-11 SHORT CHIP 0R538 1-216-833-11 METAL CHIP 10K 5% 1/10WR540 1-216-843-11 METAL CHIP 68K 5% 1/10WR541 1-216-835-11 METAL CHIP 15K 5% 1/10WR542 1-216-853-11 METAL CHIP 470K 5% 1/10W


R548 1-216-853-11 METAL CHIP 470K 5% 1/10WR560 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR562 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR563 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR570 1-216-833-11 METAL CHIP 10K 5% 1/10W


R579 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR580 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR582 1-216-864-11 SHORT CHIP 0R585 1-216-833-11 METAL CHIP 10K 5% 1/10WR586 1-216-833-11 METAL CHIP 10K 5% 1/10W

R591 1-216-835-11 METAL CHIP 15K 5% 1/10WR592 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR593 1-216-821-11 METAL CHIP 1K 5% 1/10W

< TRANSFORMER >

T301 1-433-372-11 TRANSFORMER, BIAS OSCILLATION

< TERMINAL >

TM101 1-780-170-21 TERMINAL BOARD (SPEAKER) (SUBWOOFER OUT)

< VIBRATOR >

X401 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)X402 1-795-482-11 VIBRATOR, CERAMIC (16MHz)

************************************************************

A-1089-466-A MIC BOARD, COMPLETE*******************

< CAPACITOR >

C1100 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1101 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC1102 1-124-257-00 ELECT 2.2uF 20% 50VC1103 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1104 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V

C1105 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC1106 1-124-257-00 ELECT 2.2uF 20% 50VC1108 1-124-257-00 ELECT 2.2uF 20% 50VC1109 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1110 1-164-217-11 CERAMIC CHIP 150PF 5% 50V

C1111 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1112 1-124-261-00 ELECT 10uF 20% 50VC1113 1-124-261-00 ELECT 10uF 20% 50VC1114 1-124-464-11 ELECT 0.22uF 20% 50VC1115 1-124-257-00 ELECT 2.2uF 20% 50V

C1116 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC1117 1-126-160-11 ELECT 1uF 20% 50VC1118 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25VC1119 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC1120 1-136-495-11 FILM 0.068uF 5% 50V

C1121 1-124-589-11 ELECT 47uF 20% 16VC1122 1-124-589-11 ELECT 47uF 20% 16VC1123 1-136-495-11 FILM 0.068uF 5% 50VC1124 1-126-160-11 ELECT 1uF 20% 50VC1125 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V

C1126 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25VC1127 1-136-495-11 FILM 0.068uF 5% 50VC1128 1-124-464-11 ELECT 0.22uF 20% 50VC1129 1-124-464-11 ELECT 0.22uF 20% 50VC1130 1-136-155-00 FILM 0.015uF 5% 50V

C1131 1-126-176-11 ELECT 220uF 20% 10VC1133 1-113-619-11 CERAMIC CHIP 0.47uF 10VC1139 1-126-160-11 ELECT 1uF 20% 50VC1142 1-216-864-11 SHORT CHIP 0

< CONNECTOR >

CN1102 1-785-329-11 PIN, CONNECTOR (LIGHT ANGLE) 3P

< DIODE >

D1100 8-719-988-61 DIODE 1SS355TE-17D1101 8-719-988-61 DIODE 1SS355TE-17D1102 8-719-069-54 DIODE UDZSTE-175.1B

< EARTH TERMINAL >

EPT1102 1-537-738-21 TERMINAL, GROUNDEPT1103 1-537-738-21 TERMINAL, GROUND

< FERRITE BEAD >

FB1100 1-216-864-11 SHORT CHIP 0FB1101 1-216-864-11 SHORT CHIP 0

< IC >

IC1100 8-759-710-97 IC NJM4565M-D

MAIN

74

HCD-GNX88



IC1101 8-759-496-41 IC M65850FP-E1

< JACK >

J1100 1-817-630-11 JACK (LARGE TYPE) (MIC 1)J1101 1-817-630-11 JACK (LARGE TYPE) (MIC 2)J1103 1-794-702-11 JACK, HEADPHONE (PHONES)

< SHORT >


JR1106 1-216-864-11 SHORT CHIP 0JR1108 1-216-864-11 SHORT CHIP 0JR1113 1-216-296-11 SHORT CHIP 0JR1114 1-216-296-11 SHORT CHIP 0

< RESISTOR >


R1105 1-216-821-11 METAL CHIP 1K 5% 1/10WR1106 1-216-841-11 METAL CHIP 47K 5% 1/10WR1107 1-216-809-11 METAL CHIP 100 5% 1/10WR1108 1-216-833-11 METAL CHIP 10K 5% 1/10WR1109 1-216-847-11 METAL CHIP 150K 5% 1/10W

R1110 1-216-809-11 METAL CHIP 100 5% 1/10WR1111 1-216-845-11 METAL CHIP 100K 5% 1/10WR1113 1-216-835-11 METAL CHIP 15K 5% 1/10WR1114 1-216-835-11 METAL CHIP 15K 5% 1/10WR1115 1-216-815-11 METAL CHIP 330 5% 1/10W

R1116 1-216-815-11 METAL CHIP 330 5% 1/10WR1117 1-216-835-11 METAL CHIP 15K 5% 1/10WR1118 1-216-835-11 METAL CHIP 15K 5% 1/10WR1119 1-216-835-11 METAL CHIP 15K 5% 1/10WR1120 1-216-846-11 METAL CHIP 120K 5% 1/10W

R1121 1-216-835-11 METAL CHIP 15K 5% 1/10WR1122 1-216-835-11 METAL CHIP 15K 5% 1/10WR1123 1-216-835-11 METAL CHIP 15K 5% 1/10WR1124 1-216-841-11 METAL CHIP 47K 5% 1/10WR1125 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R1126 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1132 1-216-864-11 SHORT CHIP 0

< VARIABLE RESISTOR >

RV1100 1-227-452-11 RES, VAR, CARBON 50K (MIC LEVEL)RV1101 1-227-452-11 RES, VAR, CARBON 50K (ECHO LEVEL)

************************************************************

1-687-133-12 MOTOR (LD) BOARD****************

************************************************************

1-687-134-12 MOTOR (TB) BOARD****************

< CONNECTOR >

CN742 1-784-727-11 CONNECTOR, FFC 5P*************************************************************

A-1110-925-A PA BOARD, COMPLETE******************

< CAPACITOR >

C600 1-126-963-11 ELECT 4.7uF 20% 50VC601 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC602 1-104-658-91 ELECT 100uF 20% 10VC604 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC605 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C608 1-126-965-91 ELECT 22uF 20% 50VC609 1-128-560-11 ELECT 22uF 20% 100VC610 1-128-560-11 ELECT 22uF 20% 100VC616 1-136-495-11 FILM 0.068uF 5% 50VC617 1-136-495-11 FILM 0.068uF 5% 50V

C618 1-128-582-11 ELECT 10uF 20% 100VC619 1-128-582-11 ELECT 10uF 20% 100VC634 1-104-665-11 ELECT 100uF 20% 25VC635 1-104-665-11 ELECT 100uF 20% 25VC636 1-107-721-11 ELECT 4.7uF 20% 100V

C637 1-107-721-11 ELECT 4.7uF 20% 100VC648 1-104-658-91 ELECT 100uF 20% 10VC649 1-126-964-11 ELECT 10uF 20% 50VC650 1-126-963-11 ELECT 4.7uF 20% 50VC651 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C652 1-104-658-91 ELECT 100uF 20% 10VC654 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC655 1-126-964-11 ELECT 10uF 20% 50VC656 1-127-815-11 ELECT 3300uF 20% 100VC657 1-130-777-00 MYLAR 0.1uF 5% 100V

C658 1-127-812-11 ELECT 3300uF 20% 63VC659 1-130-777-00 MYLAR 0.1uF 5% 100VC660 1-131-992-91 CERAMIC CHIP 100000PF 35VC666 1-136-495-11 FILM 0.068uF 5% 50VC667 1-136-495-11 FILM 0.068uF 5% 50V

C676 1-127-815-11 ELECT 3300uF 20% 100VC677 1-130-777-00 MYLAR 0.1uF 5% 100VC678 1-127-812-11 ELECT 3300uF 20% 63VC679 1-130-777-00 MYLAR 0.1uF 5% 100VC681 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16V

C682 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16VC683 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC691 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16VC692 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16VC693 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

< CONNECTOR >

CN600 1-764-865-41 CONNECTOR, BOARD TO BOARD 13PCN601 1-784-031-41 CONNECTOR, BOARD TO BOARD 8P

* CN607 1-564-508-11 PLUG, CONNECTOR 5P

MIC MOTOR (LD) MOTOR (TB) PA

75

HCD-GNX88



PA

< DIODE >

D609 8-719-988-61 DIODE 1SS355TE-17D611 8-719-083-66 DIODE UDZSTE-1718BD612 8-719-083-66 DIODE UDZSTE-1718BD620 8-719-988-61 DIODE 1SS355TE-17D624 8-719-988-61 DIODE 1SS355TE-17

D646 8-719-988-61 DIODE 1SS355TE-17D654 8-719-988-61 DIODE 1SS355TE-17D655 8-719-988-61 DIODE 1SS355TE-17D656 6-500-249-01 DIODE D15XB20D658 8-719-073-32 DIODE D25XB60

D660 8-719-988-61 DIODE 1SS355TE-17D661 8-719-988-61 DIODE 1SS355TE-17D665 8-719-988-61 DIODE 1SS355TE-17D670 8-719-988-61 DIODE 1SS355TE-17

< EARTH TERMINAL >

EP660 1-537-738-21 TERMINAL, GROUNDEP690 1-537-738-21 TERMINAL, GROUND

< IC >

IC600 8-749-017-06 IC STK412-150

< SHORT >


< TRANSISTOR >

Q604 8-729-924-99 TRANSISTOR 2SC3722K-EQ606 8-729-821-00 TRANSISTOR 2SA1207Q610 8-729-924-99 TRANSISTOR 2SC3722K-EQ618 8-729-924-99 TRANSISTOR 2SC3722K-EQ628 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q629 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q630 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q634 8-729-027-31 TRANSISTOR DTA124EKA-T146Q640 8-729-802-80 TRANSISTOR 2SC3661Q641 8-729-802-80 TRANSISTOR 2SC3661

Q644 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q647 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q648 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q666 8-729-901-81 TRANSISTOR 2SC2412K-T-146-RQ668 8-729-924-99 TRANSISTOR 2SC3722K-E

Q682 8-729-120-28 TRANSISTOR 2SC1623-L5L6

< RESISTOR >


R605 1-216-833-11 METAL CHIP 10K 5% 1/10WR606 1-216-841-11 METAL CHIP 47K 5% 1/10WR607 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR608 1-216-845-11 METAL CHIP 100K 5% 1/10WR609 1-216-843-11 METAL CHIP 68K 5% 1/10W


0R612 1-245-605-51 FUSIBLE 100 5% 1/4WR613 1-215-872-11 METAL OXIDE 3.3K 5% 1WR614 1-215-872-11 METAL OXIDE 3.3K 5% 1W

0R615 1-245-605-51 FUSIBLE 100 5% 1/4W0R616 1-217-637-00 FUSIBLE 1 5% 1/4W

R617 1-216-845-11 METAL CHIP 100K 5% 1/10W0R618 1-234-798-11 ENCAPSULATED COMPONENT

R619 1-216-821-11 METAL CHIP 1K 5% 1/10W

R620 1-216-839-11 METAL CHIP 33K 5% 1/10WR621 1-216-845-11 METAL CHIP 100K 5% 1/10WR622 1-249-625-31 CARBON 10 5% 1/2WR623 1-216-843-11 METAL CHIP 68K 5% 1/10WR624 1-216-837-11 METAL CHIP 22K 5% 1/10W

R625 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR626 1-216-842-11 METAL CHIP 56K 5% 1/10WR627 1-216-821-11 METAL CHIP 1K 5% 1/10WR628 1-216-837-11 METAL CHIP 22K 5% 1/10WR629 1-216-830-11 METAL CHIP 5.6K 5% 1/10W

R630 1-216-845-11 METAL CHIP 100K 5% 1/10WR631 1-216-845-11 METAL CHIP 100K 5% 1/10WR632 1-216-845-11 METAL CHIP 100K 5% 1/10WR633 1-216-842-11 METAL CHIP 56K 5% 1/10WR634 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R635 1-216-833-11 METAL CHIP 10K 5% 1/10WR636 1-215-891-11 METAL OXIDE 680 5% 2WR637 1-215-891-11 METAL OXIDE 680 5% 2WR638 1-216-845-11 METAL CHIP 100K 5% 1/10WR639 1-216-845-11 METAL CHIP 100K 5% 1/10W

R640 1-216-821-11 METAL CHIP 1K 5% 1/10WR641 1-216-821-11 METAL CHIP 1K 5% 1/10WR642 1-216-811-11 METAL CHIP 150 5% 1/10WR643 1-216-811-11 METAL CHIP 150 5% 1/10WR644 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R645 1-216-833-11 METAL CHIP 10K 5% 1/10W0R646 1-260-086-31 CARBON 82 5% 1/2W




R661 1-216-833-11 METAL CHIP 10K 5% 1/10WR662 1-216-811-11 METAL CHIP 150 5% 1/10WR663 1-216-811-11 METAL CHIP 150 5% 1/10W

0R665 1-260-086-31 CARBON 82 5% 1/2WR666 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R667 1-216-833-11 METAL CHIP 10K 5% 1/10W0R668 1-234-798-11 ENCAPSULATED COMPONENT

76

HCD-GNX88



R672 1-249-625-31 CARBON 10 5% 1/2WR673 1-216-842-11 METAL CHIP 56K 5% 1/10WR674 1-216-837-11 METAL CHIP 22K 5% 1/10WR676 1-216-849-11 METAL CHIP 220K 5% 1/10WR677 1-216-849-11 METAL CHIP 220K 5% 1/10W

R678 1-216-845-11 METAL CHIP 100K 5% 1/10WR681 1-249-625-31 CARBON 10 5% 1/2WR682 1-216-821-11 METAL CHIP 1K 5% 1/10WR683 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR685 1-216-833-11 METAL CHIP 10K 5% 1/10W

R691 1-249-625-31 CARBON 10 5% 1/2WR692 1-216-841-11 METAL CHIP 47K 5% 1/10WR693 1-216-845-11 METAL CHIP 100K 5% 1/10WR694 1-216-843-11 METAL CHIP 68K 5% 1/10WR695 1-216-845-11 METAL CHIP 100K 5% 1/10W

R696 1-216-845-11 METAL CHIP 100K 5% 1/10WR697 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR698 1-216-845-11 METAL CHIP 100K 5% 1/10W

< RELAY >

RY646 1-755-500-11 RELAYRY665 1-755-500-11 RELAY

< THERMISTOR >

TH629 1-807-796-11 THERMISTORTH630 1-807-796-11 THERMISTOR

< TERMINAL >

TM600 1-780-001-21 TERMINAL BOARD (SPEAKER)(FRONT SPEAKER)

TM601 1-780-001-21 TERMINAL BOARD (SPEAKER)(SURR SPEAKER)

*************************************************************

A-1089-476-A PANEL BOARD, COMPLETE**********************

< CAPACITOR >

C900 1-126-163-11 ELECT 4.7uF 20% 50VC901 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC902 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC903 1-164-156-11 CERAMIC CHIP 0.1uF 25VC904 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C905 1-164-156-11 CERAMIC CHIP 0.1uF 25VC906 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC907 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC908 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC909 1-164-230-11 CERAMIC CHIP 220PF 5% 50V

C910 1-164-156-11 CERAMIC CHIP 0.1uF 25VC916 1-164-156-11 CERAMIC CHIP 0.1uF 25VC917 1-164-156-11 CERAMIC CHIP 0.1uF 25VC918 1-119-941-91 ELECT 470uF 20% 6.3VC919 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C920 1-124-589-11 ELECT 47uF 20% 16VC922 1-124-261-00 ELECT 10uF 20% 50V

C923 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC924 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC925 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C926 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC927 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC928 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC929 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC930 1-162-927-11 CERAMIC CHIP 100PF 5% 50V


C936 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC937 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC938 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC939 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC941 1-124-261-00 ELECT 10uF 20% 50V

C942 1-124-261-00 ELECT 10uF 20% 50VC944 1-124-261-00 ELECT 10uF 20% 50VC945 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC946 1-164-315-11 CERAMIC CHIP 470PF 5% 50VC947 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V

C948 1-164-315-11 CERAMIC CHIP 470PF 5% 50VC949 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC950 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC951 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC952 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V

C953 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC954 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC955 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3VC956 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC957 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V

C958 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC959 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC960 1-124-261-00 ELECT 10uF 20% 50VC961 1-164-156-11 CERAMIC CHIP 0.1uF 25VC966 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C970 1-119-941-91 ELECT 470uF 20% 6.3VC971 1-119-941-91 ELECT 470uF 20% 6.3VC972 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC973 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC977 1-162-927-11 CERAMIC CHIP 100PF 5% 50V


C983 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

< CONNECTOR >

* CN902 1-569-934-11 SOCKET, CONNECTOR 17PCNS901 1-770-401-11 HOUSING, CONNECTOR (PC BOARD) 8PCNS902 1-819-074-11 BOARD TO BOARD HEADER (8P)

< DIODE >

D901 8-719-988-61 DIODE 1SS355TE-17

PA PANEL

77

HCD-GNX88


PANEL

D902 8-719-038-54 DIODE SEL6414E-LC05 (^/1)D903 6-500-522-21 DIODE 10EDB40-TB3D904 6-500-522-21 DIODE 10EDB40-TB3D905 8-719-978-33 DIODE DTZ-TT11-6.8B

D906 6-500-529-01 DIODE SLI-325URT31W (CD)D907 8-719-038-54 DIODE SEL6414E-LC05 (CD)D908 6-500-529-01 DIODE SLI-325URT31W (TUNER/BAND)D909 8-719-038-54 DIODE SEL6414E-LC05 (TUNER/BAND)D910 6-500-529-01 DIODE SLI-325URT31W (TAPE A/B)

D911 6-500-529-01 DIODE SLI-325URT31W (bB)D912 6-500-529-01 DIODE SLI-325URT31W (x)D913 6-500-529-01 DIODE SLI-325URT31W (TUNING/> +)D914 6-500-529-01 DIODE SLI-325URT31W (ALBUM/M +)D915 8-719-038-54 DIODE SEL6414E-LC05 (bB)

D916 8-719-038-54 DIODE SEL6414E-LC05 (TAPE A/B)D917 6-500-529-01 DIODE SLI-325URT31W (TV)D918 8-719-038-54 DIODE SEL6414E-LC05 (TV)D925 6-500-529-01 DIODE SLI-325URT31W (VIDEO/MD)D926 8-719-038-54 DIODE SEL6414E-LC05 (VIDEO/MD)

D927 6-500-529-01 DIODE SLI-325URT31W (^/1)D928 6-500-529-01 DIODE SLI-325URT31W (X)D929 6-500-529-01 DIODE SLI-325URT31W (TUNING/. –)D930 6-500-529-01 DIODE SLI-325URT31W (ALBUM/m –)

< FERRITE BEAD >

FB901 1-216-864-11 SHORT CHIP 0

< FLUORESCENT INDICATOR >

FL901 1-519-794-11 VACUUM FLUORESCENT DISPLAYS

< IC >

IC902 6-805-078-01 IC MB90M407PF-G-144-BNDE1IC903 6-600-210-01 IC RPM7240-H8IC904 6-705-678-01 IC NJM2760V-TE2

< JUMPER RESISTOR >




< TRANSISTOR >

Q900 8-729-027-23 TRANSISTOR DTA114EKA-T146Q901 8-729-027-56 TRANSISTOR DTC143TKA-T146Q902 8-729-027-56 TRANSISTOR DTC143TKA-T146Q903 8-729-027-23 TRANSISTOR DTA114EKA-T146Q904 8-729-106-60 TRANSISTOR 2SB1115A-YQ

Q905 8-729-106-60 TRANSISTOR 2SB1115A-YQQ906 8-729-027-43 TRANSISTOR DTC114EKA-T146


Q910 8-729-027-43 TRANSISTOR DTC114EKA-T146Q914 8-729-027-56 TRANSISTOR DTC143TKA-T146Q915 8-729-027-43 TRANSISTOR DTC114EKA-T146Q916 8-729-027-43 TRANSISTOR DTC114EKA-T146Q917 8-729-027-43 TRANSISTOR DTC114EKA-T146


< RESISTOR >

R900 1-216-833-11 METAL CHIP 10K 5% 1/10WR901 1-216-833-11 METAL CHIP 10K 5% 1/10WR902 1-216-833-11 METAL CHIP 10K 5% 1/10WR903 1-216-809-11 METAL CHIP 100 5% 1/10WR904 1-216-809-11 METAL CHIP 100 5% 1/10W

R905 1-216-835-11 METAL CHIP 15K 5% 1/10WR906 1-216-835-11 METAL CHIP 15K 5% 1/10WR907 1-216-835-11 METAL CHIP 15K 5% 1/10WR908 1-216-809-11 METAL CHIP 100 5% 1/10WR909 1-216-833-11 METAL CHIP 10K 5% 1/10W

R910 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR911 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR912 1-216-809-11 METAL CHIP 100 5% 1/10WR914 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR915 1-216-824-11 METAL CHIP 1.8K 5% 1/10W

R916 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR917 1-216-845-11 METAL CHIP 100K 5% 1/10WR918 1-216-845-11 METAL CHIP 100K 5% 1/10WR919 1-216-845-11 METAL CHIP 100K 5% 1/10WR920 1-216-833-11 METAL CHIP 10K 5% 1/10W

R922 1-216-857-11 METAL CHIP 1M 5% 1/10WR931 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR932 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR933 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR939 1-216-821-11 METAL CHIP 1K 5% 1/10W

R940 1-216-833-11 METAL CHIP 10K 5% 1/10WR941 1-216-809-11 METAL CHIP 100 5% 1/10WR942 1-216-809-11 METAL CHIP 100 5% 1/10WR943 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR944 1-216-805-11 METAL CHIP 47 5% 1/10W

R945 1-216-839-11 METAL CHIP 33K 5% 1/10WR946 1-216-842-11 METAL CHIP 56K 5% 1/10WR947 1-216-821-11 METAL CHIP 1K 5% 1/10WR948 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR949 1-216-821-11 METAL CHIP 1K 5% 1/10W

R950 1-216-821-11 METAL CHIP 1K 5% 1/10WR951 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR952 1-216-821-11 METAL CHIP 1K 5% 1/10WR953 1-216-821-11 METAL CHIP 1K 5% 1/10WR954 1-216-833-11 METAL CHIP 10K 5% 1/10W

R956 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR957 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR958 1-216-817-11 METAL CHIP 470 5% 1/10WR959 1-216-819-11 METAL CHIP 680 5% 1/10WR960 1-216-821-11 METAL CHIP 1K 5% 1/10W

78

HCD-GNX88


PRIMARYPANEL


R966 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR967 1-216-833-11 METAL CHIP 10K 5% 1/10WR968 1-216-835-11 METAL CHIP 15K 5% 1/10WR969 1-216-819-11 METAL CHIP 680 5% 1/10WR970 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W

R971 1-216-821-11 METAL CHIP 1K 5% 1/10WR972 1-216-819-11 METAL CHIP 680 5% 1/10WR973 1-216-819-11 METAL CHIP 680 5% 1/10WR974 1-216-819-11 METAL CHIP 680 5% 1/10WR975 1-216-817-11 METAL CHIP 470 5% 1/10W

R977 1-216-821-11 METAL CHIP 1K 5% 1/10WR978 1-216-817-11 METAL CHIP 470 5% 1/10WR980 1-216-821-11 METAL CHIP 1K 5% 1/10WR981 1-216-819-11 METAL CHIP 680 5% 1/10WR982 1-216-819-11 METAL CHIP 680 5% 1/10W




R999 1-216-864-11 SHORT CHIP 0R1112 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR1135 1-216-819-11 METAL CHIP 680 5% 1/10WR1136 1-216-819-11 METAL CHIP 680 5% 1/10WR1137 1-216-819-11 METAL CHIP 680 5% 1/10W


R1160 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR1161 1-216-833-11 METAL CHIP 10K 5% 1/10WR1162 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR1163 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1164 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R1165 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1166 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1167 1-216-814-11 METAL CHIP 270 5% 1/10WR1168 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR1175 1-216-817-11 METAL CHIP 470 5% 1/10W

R1176 1-216-819-11 METAL CHIP 680 5% 1/10WR1177 1-216-821-11 METAL CHIP 1K 5% 1/10WR1178 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R1179 1-216-824-11 METAL CHIP 1.8K 5% 1/10WR1180 1-216-814-11 METAL CHIP 270 5% 1/10W

R1183 1-216-809-11 METAL CHIP 100 5% 1/10WR1186 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1187 1-216-833-11 METAL CHIP 10K 5% 1/10WR1188 1-216-821-11 METAL CHIP 1K 5% 1/10WR1189 1-216-801-11 METAL CHIP 22 5% 1/10W


R1199 1-216-824-11 METAL CHIP 1.8K 5% 1/10W

< SWITCH >

S900 1-762-875-21 SWITCH, KEYBOARD (DISPLAY)S901 1-762-875-21 SWITCH, KEYBOARD (MP3 BOOSTER)S902 1-762-875-21 SWITCH, KEYBOARD (EQ BAND)S903 1-762-875-21 SWITCH, KEYBOARD

(DIRECTION/TUNER MEMORY/MPX)S904 1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)

S910 1-762-875-21 SWITCH, KEYBOARD (VIDEO/MD)S911 1-762-875-21 SWITCH, KEYBOARD (TV)S912 1-762-875-21 SWITCH, KEYBOARD (CD SYNC)S913 1-762-875-21 SWITCH, KEYBOARD (bB)S914 1-762-875-21 SWITCH, KEYBOARD (X)

S915 1-762-875-21 SWITCH, KEYBOARD (x)S916 1-479-229-11 ROTARY ENCODER (TUNING)S917 1-771-963-11 SWITCH, ROTARY (ALBUM)S918 1-762-875-21 SWITCH, KEYBOARD (TAPE A/B)S919 1-762-875-21 SWITCH, KEYBOARD (TUNER BAND)

S920 1-762-875-21 SWITCH, KEYBOARD (CD)S925 1-762-875-21 SWITCH, KEYBOARD (^/1)S927 1-762-875-21 SWITCH, KEYBOARD (AMP MENU)S928 1-762-875-21 SWITCH, KEYBOARD (ILLUMINATION)S929 1-762-875-21 SWITCH, KEYBOARD (SURR SPEAKER MODE)

S930 1-762-875-21 SWITCH, KEYBOARD (GROOVE)S931 1-762-875-21 SWITCH, KEYBOARD (SOUND FLASH)S932 1-762-875-21 SWITCH, KEYBOARD (ENTER)S970 1-418-725-51 ENCODER, ROTARY (12 TYPE) (VOLUME)

< VIBRATOR >

X901 1-781-282-51 VIBRATOR, CERAMIC (4MHz)*************************************************************

A-1089-525-A PRIMARY BOARD, COMPLETE************************

< CAPACITOR >

C1201 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1202 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1206 1-126-916-11 ELECT 1000uF 20% 6.3V

< CONNECTOR >

CN1200 1-785-329-11 PIN, CONNECTOR (LIGHT ANGLE) 3PCN1202 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2PCN1204 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P

79

HCD-GNX88



< DIODE >

D1200 8-719-988-61 DIODE 1SS355TE-17

< SHORT >

JR1202 1-216-864-11 SHORT CHIP 0

< COIL >

L1201 1-410-666-31 INDUCTOR 18uH

< TRANSISTOR >

Q1200 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R

< RESISTOR >

R1200 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1201 1-216-845-11 METAL CHIP 100K 5% 1/10W

< RELAY >

0RY1200 1-755-299-11 RELAY*************************************************************

1-687-132-12 SENSOR BOARD*************

< CONNECTOR >

CN731 1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P

< IC >

IC731 6-600-022-01 IC RPI-576*************************************************************

A-1089-323-A SURROUND BOARD, COMPLETE**************************

< CAPACITOR >

C800 1-126-963-11 ELECT 4.7uF 20% 50VC801 1-100-717-91 CERAMIC CHIP 1uF 16VC802 1-104-658-91 ELECT 100uF 20% 10VC803 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC804 1-131-992-91 CERAMIC CHIP 100000PF 35V

C805 1-131-992-91 CERAMIC CHIP 100000PF 35VC806 1-126-961-11 ELECT 2.2uF 20% 50VC807 1-100-717-91 CERAMIC CHIP 1uF 16VC820 1-126-964-11 ELECT 10uF 20% 50VC825 1-128-563-11 ELECT 100uF 20% 100V

C826 1-128-563-11 ELECT 100uF 20% 100VC838 1-136-495-11 FILM 0.068uF 5% 50VC839 1-136-495-11 FILM 0.068uF 5% 50VC843 1-126-963-11 ELECT 4.7uF 20% 50VC850 1-126-963-11 ELECT 4.7uF 20% 50V

C851 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC852 1-104-658-91 ELECT 100uF 20% 10VC853 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC888 1-136-495-11 FILM 0.068uF 5% 50VC889 1-136-495-11 FILM 0.068uF 5% 50V

< CONNECTOR >

CN700 1-784-031-41 CONNECTOR, BOARD TO BOARD 8PCN800 1-778-227-41 CONNECTOR, BOARD TO BOARD 6P

< DIODE >


< IC >

IC800 6-705-853-01 IC STK403-120

< TRANSISTOR >

Q800 8-729-924-99 TRANSISTOR 2SC3722K-EQ810 8-729-802-80 TRANSISTOR 2SC3661Q812 8-729-924-99 TRANSISTOR 2SC3722K-EQ814 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q815 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q850 8-729-924-99 TRANSISTOR 2SC3722K-E

< RESISTOR >

R800 1-216-821-11 METAL CHIP 1K 5% 1/10WR801 1-216-841-11 METAL CHIP 47K 5% 1/10WR802 1-216-820-11 METAL CHIP 820 5% 1/10WR803 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

0R804 1-217-637-00 FUSIBLE 1 5% 1/4W

0R805 1-217-637-00 FUSIBLE 1 5% 1/4WR806 1-216-821-11 METAL CHIP 1K 5% 1/10WR807 1-216-841-11 METAL CHIP 47K 5% 1/10WR808 1-216-841-11 METAL CHIP 47K 5% 1/10WR812 1-216-825-11 METAL CHIP 2.2K 5% 1/10W


0R827 1-245-605-51 FUSIBLE 100 5% 1/4W0R828 1-245-605-51 FUSIBLE 100 5% 1/4W0R838 1-220-893-11 METAL 0.22 10% 5W

R839 1-216-821-11 METAL CHIP 1K 5% 1/10WR840 1-216-837-11 METAL CHIP 22K 5% 1/10WR841 1-216-845-11 METAL CHIP 100K 5% 1/10WR842 1-245-711-31 CARBON 10 5% 1/2WR843 1-216-841-11 METAL CHIP 47K 5% 1/10W


R861 1-216-841-11 METAL CHIP 47K 5% 1/10W0R862 1-260-086-31 CARBON 82 5% 1/2W

R863 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR864 1-216-837-11 METAL CHIP 22K 5% 1/10WR865 1-216-821-11 METAL CHIP 1K 5% 1/10W

R866 1-216-837-11 METAL CHIP 22K 5% 1/10W0R888 1-220-893-11 METAL 0.22 10% 5W


PRIMARY SURROUNDSENSOR

80

HCD-GNX88


R891 1-216-845-11 METAL CHIP 100K 5% 1/10W

R892 1-245-711-31 CARBON 10 5% 1/2W

< RELAY >

RY862 1-755-500-11 RELAY*************************************************************

1-687-669-12 SW BOARD*********

S751 1-786-514-11 SWITCH, LEVER (SLIDE) (LEVEL SW)*************************************************************

A-1089-507-A TRANS BOARD, COMPLETE**********************

< CAPACITOR >

C1262 1-126-964-11 ELECT 10uF 20% 50VC1263 1-126-968-11 ELECT 100uF 20% 50VC1292 1-128-576-11 ELECT 100uF 20% 63V

< CONNECTOR >

* CN1212 1-564-522-11 PLUG, CONNECTOR 7P* CN1213 1-564-521-11 PLUG, CONNECTOR 6P

< DIODE >

D1264 8-719-071-83 DIODE HZU36BTRFD1292 6-500-522-21 DIODE 10EDB40-TB3

< FUSE HOLDER >

FH1241 1-533-217-41 HOLDER, FUSEFH1242 1-533-217-41 HOLDER, FUSEFH1251 1-533-217-41 HOLDER, FUSEFH1252 1-533-217-41 HOLDER, FUSEFH1261 1-533-217-41 HOLDER, FUSE

FH1262 1-533-217-41 HOLDER, FUSEFH1271 1-533-217-41 HOLDER, FUSEFH1272 1-533-217-41 HOLDER, FUSEFH1281 1-533-217-41 HOLDER, FUSEFH1282 1-533-217-41 HOLDER, FUSE

< TRANSISTOR >

Q1264 8-729-024-93 TRANSISTOR 2SB1565E

< RESISTOR >

R1262 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR1263 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR1264 1-216-821-11 METAL CHIP 1K 5% 1/10W

0R1292 1-219-124-11 FUSIBLE 0.68 5% 1/4W************************************************************

MISCELLANEOUS*************

5 1-693-671-11 TUNER (TM-10E)07 1-468-737-21 POWER, SWITCHING

9 1-775-280-11 WIRE (FLAT TYPE) (31 CORE)65 1-828-992-11 WIRE (FLAT TYPE) (17 CORE)71 1-797-165-11 DECK, MECHANICAL

106 1-828-956-11 WIRE (FLAT TYPE) (9 CORE)107 1-828-972-11 WIRE (FLAT TYPE) (13 CORE)

0108 1-827-226-11 CORD, POWER110 1-828-973-11 WIRE (FLAT TYPE) (13 CORE)152 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)

226 1-827-992-11 WIRE (FLAT TYPE) (16 CORE)0229 8-820-244-01 DEVICE, OPTICAL KSM-215DCP/C2NP

230 1-471-035-11 MAGNET ASSY0F1241 1-576-655-12 FUSE, GLASS TUBE (DIA. 5) (T8AL/250V)0F1251 1-576-655-12 FUSE, GLASS TUBE (DIA. 5) (T8AL/250V)

0F1261 1-576-655-12 FUSE, GLASS TUBE (DIA. 5) (T8AL/250V)0F1271 1-576-655-12 FUSE, GLASS TUBE (DIA. 5) (T8AL/250V)0F1281 1-533-470-12 FUSE, GLASS TUBE (DIA. 5) (T3.15AL/250V)

FL901 1-519-794-11 VACUUM FLUORESCENT DISPLAYSM741 A-4723-963-A MOTOR ASSY, TABLE

M751 A-4737-553-A MOTOR ASSY, LOADINGM891 1-763-372-11 FAN, DCRE701 1-477-680-12 ENCODER, ROTARY

0T1200 1-443-584-11 POWER TRANSFORMER


SURROUND SW TRANS

81

HCD-GNX88

MEMO

HCD-GNX88

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper right on the revised page allows you to jump to the next revisedpage.

Ver. Date Description of Revision

1.0 2005.02 New

HCD-GNX88diagramas.diagramasde.com/audio/Sony_HCD-GNX88.pdf · 2012. 5. 1. · Sony Corporation...

Documents

Transcript of HCD-GNX88diagramas.diagramasde.com/audio/Sony_HCD-GNX88.pdf · 2012. 5. 1. · Sony Corporation...