Harsh ntpc

32
Summer Training At NTPC (DADRI) SUBMITTED BY - SUBMITTED TO - Harsh Kumar Mr. Ajay Kumar ME - 4 th year, Sec.-A ME Deptt. Roll. No. - 1202940074

Transcript of Harsh ntpc

Page 1: Harsh ntpc

Summer Training

At

NTPC (DADRI)

SUBMITTED BY - SUBMITTED TO -

Harsh Kumar Mr. Ajay Kumar

ME - 4th year, Sec.-A ME Deptt.

Roll. No. - 1202940074

Page 2: Harsh ntpc

About NTPC

NTPC is India’s largest energy conglomerate with roots planted way back in 1975 to

accelerate power development in India.

NTPC became a Maharatna company in May 2010, one of the only four companies to be

awarded this status.

NTPC was ranked 431st in the ‘2015, Forbes Global 2000’ ranking of the World’s

biggest companies.

The total installed capacity of the company is 45,548 MW (including JVs) with 18 coal

based and 7 gas based stations. 7 Joint Venture stations are coal based and 8 renewable

energy projects and 1 hydro project.

Although the company has 17.73% of the total national capacity, it contributes 25.91%

of total power generation due to its focus on high efficiency.

Page 3: Harsh ntpc

INSTALLED CAPACITY

S.No. NO. OF PLANTS CAPACITY (MW)

NTPC Owned

Coal 18 34,425

Gas/Liquid Fuel 7 4,017

Hydro 1 800

Renewable energy

projects8 110

Total 34 39,352

Owned By JVs

Coal & Gas 7 6,196

Total 41 45,548

Page 4: Harsh ntpc

NTPC - Dadri

TOTAL CAPACITY OF DADRI POWER PLANT :-

(A) THERMAL (B) GAS

I:- 04X210 MW = 840 MW I:- 04X130.19

II:- 02X490 MW = 980 MW II:- 02X154.51

TOTAL = 1820 MW TOTAL = 817 MW

(C) SOLAR = 05MW

GRAND TOTAL = 2642 MW

Page 5: Harsh ntpc

SOURCES

Coal source

- Piparwara mine , Jharkhand

- Requirement = 13000 MT/day

Water source

- Upper Ganga Canal

Gas source

- HBJ Pipeline (a major gas pipeline of GAIL)

Hazira-Bijaipur-Jagdishpur

Page 6: Harsh ntpc

Layout of a typical coal fired thermal power station

Page 7: Harsh ntpc

Basic Working of Thermal Power Plant

Page 8: Harsh ntpc

Working of a Thermal Power Plant

The coal is brought and crushed to powder. This is feed to boiler for producing heat .

In Boiler the water is converted to steam.

In Superheater the moisture content is removed from the steam and that steam is called super heated

steam.

The superheated steam rotates the shaft of the High Pressure(HP) turbine.

The exhausted steam is sent to Reheater and the steam then rotates the Intermediate Pressure (IP)

turbine.

The steam from the IP Turbine is then feed to Low Pressure(LP) turbine.

The turbine shaft is connected to the Generator, which produces electric power.

The steam expanded in turbine is condensed in a Condenser to be feed into the boiler again.

Page 9: Harsh ntpc

Basic Power Plant Cycle

Page 10: Harsh ntpc

COAL HANDLING PLANT

Raw coal wagon – Coal is brought to the site through a wagon as per the requirement.

Wagon tippler – The coal is unloaded from the wagon and is transported to crusher and for storage place through conveyor.

Junction tower - JTs are used where the conveyor has any angular deviation.

Primary crusher – The raw coal is crushed into fine pieces of 45mm grit. Primary crusher is also called Rotatory breaker since the coal is crushed by rotating plate.

The stone and unwanted coal

are rejected

Page 11: Harsh ntpc

Secondary crusher – The fine pieces of coal is crushed into powder . (25 mm grit).

Junction Tower

Mill Bunker – The 25 mm grit coal is crushed into very fine powder for feeding the boiler . We have a spare bunker for each boiler.

Boiler

Stack & Reclaimer – It is

used to store the powdered

coal for emergency purpose.

Atmospheric air

–Through FD

fan

Page 12: Harsh ntpc

BOILER

A Boiler is a closed vessel in which water is heated to produce steam by utilizing the heat generated by coal combustion.

Boilers are classified into two types based on relative position of water and hot gases :-

Water tube boilers

Fire tube boilers

In Water tube boiler, water flows through tubes

and hot gases of combustion flow over these tubes.

This is high pressure boilers.

Page 13: Harsh ntpc

In Fire tube boiler, the hot products of combustion

passes through tubes surrounded by water . This is low pressure boiler.

In Dadri power plant, Water tube boiler is used.

Saturated steam is generated at a pressure of around 2000-2200 KPa.

It is then heated in Superheater.

Page 14: Harsh ntpc

Auxilliary Components Of a Boiler

Superheater

Economizer

Air-preheater

Reheater

Deaerator

Page 15: Harsh ntpc

Superheater

Superheaters are used to raise the steam temperature above the saturation temperature by absorbing

heat from flue gases to increase plant efficiency.

It removes last traces of moisture and therefore prevents turbine blades from corrosion.

Outlet temperature and pressure of steam coming out from the superheater is 540 °C & 157 kg/cm²

Page 16: Harsh ntpc

Economiser, Air-preheater & Reheater

An Economizer is a heat transfer device used for heating

the feed water with the help of hot flue gases.

It improves the efficiency of the power plant.

Air-preheater is a device which utilizes the waste heat

of the flue gases leaving the Economizer for heating

the air required for combustion.

Reheater is used to increase the temperature of exhaust

steam from HP turbine by utilizing the heat of the hot

flue gases leaving the chimney.

Page 17: Harsh ntpc

Deaerator

A steam generating boiler requires that the boiler feed water should be devoid of air and other

dissolved gases, particularly corrosive ones.

In order to avoid corrosion of the metal, power

station uses a Deaerator, for the removal of air

and other dissolved gases from the boiler

feed water.

A Deaerator has a vertical, domed deaeration section

mounted on top of a horizontal cylindrical vessel

which serves as a deaerated boiler feed water storage

tank.

Page 18: Harsh ntpc

PRIME MOVER(TURBINE)

A steam turbine is a mechanical device that extracts thermal energy from pressurized steam, and

converts it into mechanical energy.

About 86% of all electric generation in the world is by use of steam turbines.

In a thermal power plant generally 3 turbines are used to increase the efficiency.

High Pressure Turbine(HPT): The superheated steam is directly fed to this turbine to rotate it.

Intermediate Pressure Turbine (IPT) : The output from the HPT is reheated in a reheater and used to

rotate IPT.

Low Pressure Turbine (LPT):The Exhausted steam from the IPT is directly fed to rotate the shaft of LPT.

All the turbines are connected to a single shaft which is connected to the generator.

Page 19: Harsh ntpc
Page 20: Harsh ntpc
Page 21: Harsh ntpc

CONDENSER

It condenses the steam at the exhaust of the turbine

with the help of cooling water.

It creates a very low pressure at the exhaust of turbine,

this helps in converting heat energy of the steam into

mechanical energy in the prime mover.

Condensed steam can be used as feed water to the

boiler.

Page 22: Harsh ntpc

COOLING TOWER

Removes heat from the water discharged from the

condenser so that the water can be discharged into the

river or recirculated or reused.

Air can be circulated in the cooling tower through

natural draft and mechanical draft.

Page 23: Harsh ntpc
Page 24: Harsh ntpc

ELECTROSTATIC PRECIPITATOR (ESP)

Top view Side View

It is a device which removes dust or other finely divided particles from flue gases by charging the

particles inductively with an electric field, then attracting them to highly charged collector plates.

Also known as precipitator. The process depends on two steps. In the first step the suspension

passes through an electric discharge (corona discharge) area where ionization of the gas occurs. The

ions produced collide with the suspended particles and confer on them an electric charge. The

charged particles drift toward an electrode of opposite sign and are deposited on the electrode where

their electric charge is neutralized.

It has an efficiency of 99.8 % and it is a very high power consuming device of about 1 kwh for 10

thousand m³ of flue gas.

Page 25: Harsh ntpc

PRIMARY AIR FAN (PAF)

Air to blow the coal from the mill to the boiler, called the

primary air, is supplied by a large fan driven by a variable

speed motor.

When mixed with a stream of air the powdered coal

behaves more like a gas than a solid.

Primary air does two jobs – heating the coal powder and

secondly lifting it into the furnace through pipelines.

Page 26: Harsh ntpc

INDUCED DRAUGHT (ID) FAN

It is draws out hot flue gases from the boiler.

The gas has already passed out from Air-

preheater and Electrostatic precipitator before

it reaches ID fan.

The heat from the flue gases or smoke is used

in the air heaters to heat up the primary and

secondary air.

Page 27: Harsh ntpc

CHIMNEY

The chimney is 275 meters' high and

50,000 tonnes of reinforced concrete

were used to make it.

It consists of flues each of which serve

typically two or three boilers.

It is used to discharge flue gases at high

altitude.

Page 28: Harsh ntpc

ELECTRICAL Equipments

Alternator

An alternator is coupled to a steam turbine and converts mechanical energy of turbine into electrical energy.

It may be Hydrogen or Air cooled.

The necessary excitation is provided by main and pilot exciters directly coupled to the alternator shaft.

Transformer

Main step- transformer : steps up generated voltage transmission of power.

Station transformer : general purpose

Auxilliary transformers : which supply to individual unit auxiliaries.

Control Room and Switch yard

The control room monitors the overall operation of the plant. It is provided with safety relays and switch gears.

Page 29: Harsh ntpc

ASH HANDLING PLANT

The percentage of ash in coal is 5% in good

quality coal & about 40% in poor quality coal.

Power plants generally use poor quality of coal ,

thus amount of ash produced by it is quite large.

A modern 1000MW plant produces about 4800

tons of ash daily.

The stations use some conveyor arrangement to

carry ash to dump sites.

Page 30: Harsh ntpc

COAL ASH CAN BE USED IN

Fly Ash Bricks / Blocks

Cement Concrete

Road construction

Embankment / Back fills / Land development

Use in agriculture

Mine filling

Page 31: Harsh ntpc

REFERENCE

www.ntpc.co.in/index.php?option=com_content&id=312&Itemid.

en.wikipedia.org/wiki/NTPC_Dadri

wikimapia.org › India › Uttar Pradesh › Dadri

articles.economictimes.indiatimes.com › Collections › Solar Plant

www.ndtv.com › Topic

www.business-standard.com/.../no-shortage-of-coal-supply-to-ntpc-sdad.

globalenergyobservatory.org/geoid/4562

ntpc.co.in/index.php?option=com_content&id=28&Itemid=41

Page 32: Harsh ntpc

THANK YOU