HARMAN/CARDON TV ht32_ht40_ht46

45
TFT Display Backlight TFT-Signal 1 - 5 24V 2 -10 GND 11 n.c. 12 BL on/off (BLTC) 13 Vdim (BRT2) 14 PWM dim IR-Receiver X1 CN2 1,2 GND 3,4 30V Audio Power in K9 K8 L R CN2: 1 LI01 2 LI02 3 LVDSOD0- 5 LVDSOD0+ 4 LVDSED0- 6 LVDSED0+ 7/8 GND 9 LVDSED1- 12 LVDSED1+ 13/14 GND 15 LVDSOD2- 17 LVDSOD2+ 16 LVDSED2- 18 LVDSED2+ 19/20 GND 21 LVDSOCK- 23 LVDSOCK+ 22 LVDSECK- 24 LVDSECK+ 28 LVDSOD3- 25/26 GND 27 LVDSOD3- 29 LVDSOD3+ 28 LVDSED3- 30 LVDSED3+ 31/32 GND 33 LVDSOD4- 35 LVDSOD4+ 34 LVDSED4- 36 LVDSED4+ 37 LO1-5V 38 LIO4 39 LIO3 40 SDA 42 SCL 41/43/45 +5VPNL 47/49 +5VPNL 44/46/48/50 GND K22 K22 1/2 +24V/12VS 3 +5V PD/SD 4/6/8 GND 5/7 +5V 9 +12VA 10 PSSTDBY 11 PSDPMS 12 K K 1 2 3 4 5 6 7 K25 K25 1/7 GND 11 GND 12/18 GND 3 LED red 4 LEDgreen 2/5/6 n.c. 8/10 n.c. 9 BLON 13 S5 14 S4 15 S3 16 S2 17 S1 19 +5VST 20 IRRCVR K12 K12 Signal processing DC power line/ control backlight cable - IR-control cable - 20pol X1 1-2 = n.c. 3 = LED AMBER 4 = LED BLUE 5-12 = n.c. 13 = NC 14 = NC 15 = NC 16 = NC 17 = NC 18 = GND 19 = 5V 20 = IR-RCVR PIP- Tuner f2 f1 RF-loop cable 2 GND 1 Signal 2-3 GND 1 Signal K5 K5 1/2 NC 3/6/12 GND 4/5 NC 7/8 +5VSW 9 NC 10 NC 11 NC 1 1 1 1 1 1 Power Supply LVDS - cable Power Input Power Switch 1a 2a 1 2 AC power line Power backlight cable CN2 1/2 +12V 3/4/8/ 10/13 GND 5/6 +5V 7 +5VStby 9 Bright 11 BL on/off 12 Relay CN3 1/2/3/4/5 +24V 3/4/8/ 6/7/8/9/10 GND 11 nc 12 BL on/off 13 GND 14 Bright CNI1 Harman/kardon HT 32" 40" 46" European liaison office: 2, route de Tours, 72500 Château du Loir, France tel: +33 (0)2 43 38 43 00 fax: +33 (0)2 43 44 93 83 www.harman.com Harman Consumer Group International is a trading style of JBL, Incorporated, 8500 Balboa Boulevard, Northridge, CA 91329, USA. . CN1 CN4 CN3 CN2 C1 C2 C2 C3 C4 C5 C6 C7

description

SERVICE REPAIR MANUAL FOR HARMAN/CARDON TV.

Transcript of HARMAN/CARDON TV ht32_ht40_ht46

Page 1: HARMAN/CARDON TV ht32_ht40_ht46

TFT Display

Backlight

TFT-Signal

1 - 5 24V 2 -10 GND11 n.c.12 BL on/off (BLTC)13 Vdim (BRT2)14 PWM dim

IR-Receiver

X1

CN

2

1,2 GND3,4 30V

AudioPower in

K9 K8 LR

CN2:1 LI012 LI023 LVDSOD0-5 LVDSOD0+4 LVDSED0-6 LVDSED0+7/8 GND9 LVDSED1-12 LVDSED1+13/14 GND15 LVDSOD2-17 LVDSOD2+16 LVDSED2-18 LVDSED2+19/20 GND21 LVDSOCK-23 LVDSOCK+22 LVDSECK-24 LVDSECK+

28 LVDSOD3-25/26 GND27 LVDSOD3-29 LVDSOD3+28 LVDSED3-30 LVDSED3+31/32 GND33 LVDSOD4-35 LVDSOD4+34 LVDSED4-36 LVDSED4+37 LO1-5V38 LIO439 LIO340 SDA42 SCL41/43/45 +5VPNL47/49 +5VPNL44/46/48/50 GND

K22

K221/2 +24V/12VS3 +5V PD/SD4/6/8 GND5/7 +5V9 +12VA10 PSSTDBY11 PSDPMS12

K

K1234567

K25

K251/7 GND11 GND12/18 GND3 LED red4 LEDgreen2/5/6 n.c.8/10 n.c.9 BLON13 S514 S415 S316 S217 S119 +5VST20 IRRCVR

K12

K12

Signal processing

DC power line/control backlightcable -

IR-controlcable - 20pol

X11-2 = n.c.3 = LED AMBER4 = LED BLUE5-12 = n.c.13 = NC14 = NC15 = NC16 = NC17 = NC18 = GND19 = 5V20 = IR-RCVR

PIP-Tuner

f2f1

RF-loop cable

2 G

ND

1 Si

gnal

2-3

GN

D1

Sign

al

K5

K51/2 NC3/6/12 GND4/5 NC7/8 +5VSW9 NC10 NC11 NC

1 1

1111

Power Supply

LVD

S -

cabl

e

Power Input

Power Switch

1a2a

1 2

AC power line

Power backlightcable

CN21/2 +12V3/4/8/10/13 GND5/6 +5V7 +5VStby9 Bright11 BL on/off12 Relay

CN31/2/3/4/5 +24V3/4/8/6/7/8/9/10 GND11 nc12 BL on/off13 GND14 Bright

CNI1

Harman/kardon HT 32" 40" 46"

European liaison office: 2, route de Tours, 72500 Château du Loir, Francetel: +33 (0)2 43 38 43 00 fax: +33 (0)2 43 44 93 83 www.harman.com

Harman Consumer Group International is a trading style of JBL, Incorporated, 8500 Balboa Boulevard, Northridge, CA 91329, USA.

.

CN1

CN4

CN3

CN2

C1

C2C2

C3

C4C5

C6

C7

Page 2: HARMAN/CARDON TV ht32_ht40_ht46

TFT Display

Backlight 1 Backlight 2

TFT-Signal

1 - 5 24V 2 -10 GND11 n.c.12 BL on/off (BLTC)13 Vdim (BRT2)14 PWM dim

IR-Receiver

X1

CN

2

1,2 GND3,4 30V

AudioPower in

K9 K8 LR

CN2:1 LI012 LI023 LVDSOD0-5 LVDSOD0+4 LVDSED0-6 LVDSED0+7/8 GND9 LVDSED1-12 LVDSED1+13/14 GND15 LVDSOD2-17 LVDSOD2+16 LVDSED2-18 LVDSED2+19/20 GND21 LVDSOCK-23 LVDSOCK+22 LVDSECK-24 LVDSECK+

28 LVDSOD3-25/26 GND27 LVDSOD3-29 LVDSOD3+28 LVDSED3-30 LVDSED3+31/32 GND33 LVDSOD4-35 LVDSOD4+34 LVDSED4-36 LVDSED4+37 LO1-5V38 LIO439 LIO340 SDA42 SCL41/43/45 +5VPNL47/49 +5VPNL44/46/48/50 GND

K22

K221/2 +24V/12VS3 +5V PD/SD4/6/8 GND5/7 +5V9 +12VA10 PSSTDBY11 PSDPMS12

K23

K231 ACPWDK2 LOWVON3 5VST4 GND5 HIGVDN6 FPVRR7 N.C.

K25

K251/7 GND11 GND12/18 GND3 LED red4 LEDgreen2/5/6 n.c.8/10 n.c.9 BLON13 S514 S415 S316 S217 S119 +5VST20 IRRCVR

K12

K12

Signal processing

DC power line/control backlightcable - 13pol

IR-controlcable - 20pol

X11-2 = n.c.3 = LED red4 = LED green5-12 = n.c.13 = Taste S514 = Taste S415 = Taste S316 = Taste S217 = Taste S118 = GND19 = 5V20 = IR-RCVR

PIP-Tuner

f2f1

HF-cable

2 G

ND

1 Si

gnal

2-3

GN

D1

Sign

al

K5

K51/2 BCKPWM3/6/12 GND4/5 BCKLGHT7/8 +5VSW9 PNLIO3/GND10 PNLIO4/GND11 NC

1 - 5 24V 2 -10 GND11 n.c.12 BL on/off (BLTC)13 Vdim (BRT2)14 PWM dim

Power Supply

LVD

S -

cabl

e

Power Input

Power Switch

1a2a

1 2

AC power line

Power cable

Line Filter

Protectiveearth cord

CN1

CN

4

CN

3

CN

5

CN

2

CN

6

Power backlightcable

CN21/2 +12V3/4/8/10/13 GND5/6 +5V7 +5VStby9 Bright11 BL on/off12 Relay

CN3+41/2/3/4/5 +24V3/4/8/6/7/8/9/10 GND11 nc12 BL on/off13 GND14 Bright

CNI1

J12J12

Protectiveearth cord

CN61 A+5V2 nc3 A+12V4/ 5 GND

Option: Fan

harman/kardon HT 32" 40" 46"

European liaison office: 2, route de Tours, 72500 Château du Loir, Francetel: +33 (0)2 43 38 43 00 fax: +33 (0)2 43 44 93 83 www.harman.com

Harman Consumer Group International is a trading style of JBL, Incorporated, 8500 Balboa Boulevard, Northridge, CA 91329, USA.

JLudwigs
Text Box
C3
JLudwigs
Text Box
C2
JLudwigs
Text Box
C4
JLudwigs
Text Box
C1
JLudwigs
Text Box
C5
JLudwigs
Text Box
C7
Page 3: HARMAN/CARDON TV ht32_ht40_ht46

Harman/kardon HT 32" 40" 46"

European liaison office: 2, route de Tours, 72500 Château du Loir, Francetel: +33 (0)2 43 38 43 00 fax: +33 (0)2 43 44 93 83 www.harman.com

Harman Consumer Group International is a trading style of JBL, Incorporated, 8500 Balboa Boulevard, Northridge, CA 91329, USA.

9*

5

10

10f

8

710h

10g

10h

9**assembled in one part

9*

1

11see part list for Break down of the separateparts included on the stand

2

4

9a

12

Page 4: HARMAN/CARDON TV ht32_ht40_ht46

Spare Parts Lists V1.1Harman Kardon HT 46"

ElectricalPos Part Number Description

1 2097-4600-2005 TFT-LCD MODULE 46" 1366x768 12 2198-0073-0005 SMPS HT32v2 HT40 HT46 14 4042-6350-0100 LP-Signal Processing / input / analog tuner 15 4042-6996-0200 LP-IR-Sensor, 2xLED, bl+amber front board HT 32 / 40 / 46 1

C1 2218-1000-0090X1 LVDS-cabel Samsung -W2-L01 (16:9) (CN2 AV5 / CNT1) 1

C2 TBAPower backlight cable (CN3/CN0001)

1DC power cable backlight (K5 p6.7.8 / CN0001)C3 TBA AV5 supply cable (CN2/K22) 1C4 TBA AV5 supply cable (CN4/K12) 1C5 TBA Remote cable (CN4/LED Bd) 1C6 TBA IR control cable (K25/X1) 1C7 TBA Antenna cable (RF/PIP) 1

MechanicalPos Part Number Description

7 4042-3584-0001 Wall Mount Left 18 4042-3585-0001 Wall Mount Right 19 TBA Front Frame 46" Harman Kardon complete. 1

9a TBA Label Harman/Kardon 110 6046-R004-G210 Rear Cover HT 46" Harman Kardon 1

10a TBA Label - Input 110b TBA Label - safety / rating / sn (without SN) HT46 110c TBA Label - Caution HT46 110d TBA Screw black 1310e TBA Screw silver 2610f TBA Screw cover top edge HT46 110g TBA Screw cover bottom edge HT46 110h TBA Screw cover side edge HT46 2

11 6040-V163-F510 Table Stand mounted Harman Kardon HT40 HT46 111a TBA Stand Base Plate HT40/46 111b TBA Alu profile Black HT40/46 211c TBA Bracket Left 111d TBA Bracket Right 111e TBA Clear Rubber Feet's 611f TBA Headless screw (bracket/Alu profile) 211g TBA Screw (Plate/Alu profile) 211h TBA Screw (Bracket/Rear panel) 8

12 NA Main chassis HT 40" Harman Kardon 112a TBA Label Input HT40 112b TBA Tuner shield , cobber tape 212c TBA shield soft pad small 112d TBA Shield soft pad large 112e TBA Shield Clips (hdmi/main chassis) 1

PackingPos Part Number Description13 2279-0001-0269 Brown Box 114 2279-0001-T102 Beauty Carton HT 46 side 115 2279-0001-T108 Beauty Carton HT 46 top 116 2279-0002-0232 End Pack EPS left down 117 2279-0002-0233 End Pack EPS right down 118 2279-0002-0234 End Pack EPS left up 119 2279-0002-0235 End Pack EPS right up 120 2218-0503-0150 RF Cable 1

Page 5: HARMAN/CARDON TV ht32_ht40_ht46

Spare Parts Lists V1.1Harman Kardon HT 40"

ElectricalPos Part Number Description

1 2097-4000-2007 TFT-LCD MODULE 40" 1366x768 12 2198-0073-0005 SMPS HT32v2 HT40 HT46 1

4 4042-6350-0100 LP-Signal Processing / input / analog tuner 15 4042-6996-0200 LP-IR-Sensor, 2xLED, bl+amber front board HT 32 / 40 1

C1 2218-1000-0090X1 LVDS-cabel Samsung -W2-L01 (16:9) (CN2 AV5 / CNT1) 1

C2 TBAPower backlight cable (CN3/CN0001)

1DC power cable backlight (K5 p6.7.8 / CN0001)C3 TBA AV5 supply cable (CN2/K22) 1C4 TBA AV5 supply cable (CN4/K12) 1C5 TBA Remote cable (CN4/LED Bd) 1C6 TBA IR control cable (K25/X1) 1C7 TBA Antenna cable (RF/PIP) 1

MechanicalPos Part Number Description

7 4042-3584-0001 Wall Mount Left 18 4042-3585-0001 Wall Mount Right 19 TBA Front Frame 40" Harman Kardon complete. 1

9a TBA Label Harman/Kardon 110 6040-R013-G210 Rear Cover HT 40" Harman Kardon 1

10a TBA Label - Input 110b TBA Label - safety / rating / sn (without SN) HT40 110c TBA Label - Caution HT40 110d TBA Screw black 1310e TBA Screw silver 2610f TBA Screw cover top edge HT40 110g TBA Screw cover bottom edge HT40 110h TBA Screw cover side edge HT40 2

11 6040-V163-F510 Table Stand mounted 40" Harman Kardon HT40 111a TBA Stand Base Plate HT40 111b TBA Alu profile Black HT40 211c TBA Bracket Left 111d TBA Bracket Right 111e TBA Clear Rubber Feet's 611f TBA Headless screw (bracket/Alu profile) 211g TBA Screw (Plate/Alu profile) 211h TBA Screw (Bracket/Rear panel) 8

12 NA Main chassis HT 40" Harman Kardon 112a TBA Label Input HT40 112b TBA Tuner shield , cobber tape 212c TBA shield soft pad small 112d TBA Shield soft pad large 112e TBA Shield Clips (hdmi/main chassis) 1

PackingPos Part Number Description13 2279-0001-T101 Beauty Carton HT 40 A 114 2279-0001-T107 Beauty Carton HT 40 B 115 2279-0002-0232 End Pack EPS left down 116 2279-0002-0233 End Pack EPS right down 117 2279-0002-0234 End Pack EPS left up 118 2279-0002-0235 End Pack EPS right up 119 2218-0503-0150 RF Cable 1

Page 6: HARMAN/CARDON TV ht32_ht40_ht46

Spare Parts Lists V1.2

ElectricalPos Part Number Description

1 2097-3200-2003 TFT-LCD MODULE HT 32" 1366 x 768 16030-6521-0000 SMPS HT32 (HT32-SN<CG002-03069) 12198-0073-0005 SMPS HT32 (HT32-SN>CG002-03070) 1

4 4042-6350-0100 LP-Signal Processing / input / analog tuner 15 4042-6996-0200 LP-IR-Sensor, 2xLED, bl+amber front board HT 32 / 40 1

C1 2218-1000-0090X1 LVDS-cabel Samsung -W2-L01 (16:9) (CN2 AV5 / CNT1) 1Power backlight cable (CN3/CN0001)DC power cable backlight (K5 p6.7.8 / CN0001)

C3 TBA AV5 supply cable (CN2/K22) 1C4 TBA AV5 supply cable (CN4/K12) 1C5 TBA Remote cable (CN4/LED Bd) 1C6 TBA IR control cable (K25/X1) 1C7 TBA Antenna cable (RF/PIP) 1

MechanicalPos Part Number Description

7 4042-3584-0001 Wall Mount Left 18 4042-3585-0001 Wall Mount Right 19 R2142 Front Frame 32" Harman Kardon complete. 1

9a TBA Label Harman/Kardon 110 6032-R012-G210 Rear Cover HT 32" Harman Kardon 1

10a TBA Label - Input 110b TBA Label - safety / rating / sn (without SN) HT32 110c TBA Label - Caution HT32 110d TBA Screw black 1310e TBA Screw silver 2610f 6032-3095-F510 Screw cover top edge HT32 110g 6032-3096-F510 Screw cover bottom edge HT32 110h 6032-3097-F510 Screw cover side edge HT32 2

11 6032-V051-F510 Table Stand mounted 32" Harman Kardon HT32 111a TBA Stand Base Plate HT32 111b TBA Alu profile Black HT32 211c TBA Bracket Left 111d TBA Bracket Right 111e TBA Clear Rubber Feet's 611f TBA Headless screw (bracket/Alu profile) 211g TBA Screw (Plate/Alu profile) 211h TBA Screw (Bracket/Rear panel) 8

12 NA Main chassis HT 32" Harman Kardon 112a TBA Label Input HT32 112b TBA Tuner shield , cobber tape 212c TBA shield soft pad small 112d TBA Shield soft pad large 112e TBA Shield Clips (hdmi/main chassis) 1

PackingPos Part Number Description13 2279-0001-T089 Beauty Carton HT 32 /230 114 2279-0002-0176 End Pack EPS RG 30g/dmü 415 2218-0503-0150 RF Cable 1

Harman Kardon HT 32"

TBA 1

2

C2

Page 7: HARMAN/CARDON TV ht32_ht40_ht46

±2 (with wall mounting)

200

±296,3

±1

98,3

49,7 ±2

540 ±2

140,

1±2

625,

6±3

284,2 ±2600 ±1

±1839

±152

589

,5±2

harman/kardon HT 32" 40" 46"

European liaison office: 2, route de Tours, 72500 Château du Loir, Francetel: +33 (0)2 43 38 43 00 fax: +33 (0)2 43 44 93 83 www.harman.com

Harman Consumer Group International is a trading style ofJBL, Incorporated, 8500 Balboa Boulevard, Northridge, CA 91329, USA.

10c 10a

10b

Page 8: HARMAN/CARDON TV ht32_ht40_ht46

±1280

±2103,8

±2 (with wall mounting)104,2

102,2 ±2

726,

80±3

284,20 ±2600 ±1

±11031

±162

6,20

89,5

0±2

540 ±2

140,

2±2

harman/kardon HT 32" 40" 46"

European liaison office: 2, route de Tours, 72500 Château du Loir, Francetel: +33 (0)2 43 38 43 00 fax: +33 (0)2 43 44 93 83 www.harman.com

Harman Consumer Group International is a trading style of JBL, Incorporated, 8500 Balboa Boulevard, Northridge, CA 91329, USA.

JLudwigs
Text Box
10c
JLudwigs
Text Box
10a
JLudwigs
Text Box
10b
Page 9: HARMAN/CARDON TV ht32_ht40_ht46

540 ±2

139,

8±2

01802,

8±3

284,20 ±2600 ±1

±11162

±170

2,20

89,5

0±2 ±1280

±294,8

±2 (with wall mounting)113,2111,2 ±2

harman/kardon HT 32" 40" 46"

European liaison office: 2, route de Tours, 72500 Château du Loir, Francetel: +33 (0)2 43 38 43 00 fax: +33 (0)2 43 44 93 83 www.harman.com

Harman Consumer Group International is a trading style of JBL, Incorporated, 8500 Balboa Boulevard, Northridge, CA 91329, USA.

Dimensions HT 46"

10c 10a

10b

Page 10: HARMAN/CARDON TV ht32_ht40_ht46

150

±15792

800

1802

,20

1200

±15

1169 ±15

harman/kardon HT 32" 40" 46"

European liaison office: 2, route de Tours, 72500 Château du Loir, Francetel: +33 (0)2 43 38 43 00 fax: +33 (0)2 43 44 93 83 www.harman.com

Harman Consumer Group International is a trading style of JBL, Incorporated, 8500 Balboa Boulevard, Northridge, CA 91329, USA.

Page 11: HARMAN/CARDON TV ht32_ht40_ht46

150

±15780

800

20

1200

±10

±15

1610

±15977

20±1

0

Page 12: HARMAN/CARDON TV ht32_ht40_ht46

1954

,20

1200

±15

1300 ±15

150

±15792

800

Page 13: HARMAN/CARDON TV ht32_ht40_ht46

AV5 Main board

Special Features

- High End picture performance- Manifold Inputs- Usage of state-of-the-art Video-Processing-ICs- Digital Audio In- and Output (SPDIF/PCM)- HDMI-input (1080i max.)- DVI with HDCP- Video text, Level 1.5, memory 5000 pages min.- 2 EURO AV SCART-connectors- 5H- and 3D-comb filter

Page 14: HARMAN/CARDON TV ht32_ht40_ht46

AV5 blockdiagram

GraphicsEngine

PW318C

Flash1MByte

DDR 32MByte

Audio/ Video Matrix-Block

(1x TEA6422,1x TEA6415,1x TEA6425,2x FMS6403)

16:9 Flat Panel

Sound DSPMSP 44x0K

HDMI Rx SiI 9011

3x Audio Line In

Front- AV (inkl YC)

YUV (1080i)

PIP Tuner

2x SCART In (1x RGB, 1x YC)

RS232 ControlHDMI InDVI-I In

.

1x SPDIF, ,..

2x 10 Bit Dual LVDS

Video Decoder, ADC, DVI-RxPW3300B1

Video Decoder VPX 3228F

SDRAM1MByte

YC & CVBS

SPDIF In

SPDIF Rx CS8416

JLudwigs
Rectangle
Page 15: HARMAN/CARDON TV ht32_ht40_ht46

AV5-connectors

AV2

AV1V

UYCVBS

S-VideoHDMI

DVI

PC-Audio-IN

Audio-Out

RS232

RF-InPIP-In RF-Out

Spe

aker

R/L

Dig

/ Su

b-O

ut

Line

Out

R/L

Double-Tuner

SPD

IF-In

YU

V /

CVB

S

S-V

ideo

R/ L

Audio-In

K25

K5

288mm

130mm

K11 K6 K15 K13 K1 K21 K7 K19

CN2

K22

K18

K12

JLudwigs
Oval
JLudwigs
Oval
JLudwigs
Oval
JLudwigs
Text Box
to power supply
JLudwigs
Text Box
to tuner pcb
JLudwigs
Text Box
HT32 to backlight pcb HT40/46 to power supply
JLudwigs
Text Box
to Panel
JLudwigs
Text Box
to front LED/IR
JLudwigs
Text Box
to power supply (HT32 only)
Page 16: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 5/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

Introduction

1.1. Intention of the Design Requirements The intention of this document is determination of the technical parameters, the electrical interfaces and the mechanical size for the Electronic.

1.2. Abbreviations DVI Digital Visual Interface HDCP High-bandwidth Digital Content Protection HDMI High Definition Multimedia Interface SDTV Standard-Definition Television EDTV Enhanced-Definition Television HDTV High-Definition Television NTSC National Television Standards Committee USB Universal Serial Bus SPDIF Sony/Philips Digital Interface FBAS Farb Bild Austast Synchronisation (english CVBS) CVBS Composite Video Burst Sync (german FBAS) DVB Digital Video Broadcast RoHS Restriction for the use of Hazardous Substances t.b.d. To Be Defined

2. Description of the Electronic

2.1. Functional Description The Electronic is the interface between analogue/digital video-sources with different standards In addition the audio input signals are processed. Is supplied by an external SMPS. The firmware-update is done by a serial port.

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 17: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 6/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

2.2. Technical Data Supply voltages and supply current:

.

..

Rating No.

Item Symbol Term/ Condition Min. Typ. Max.

Unit

Voltage +5V PD +4.75 +5.0 +5.25 V Stability 0.1 – 1A ±5.0 % Ripple + Noise 100 mVpp Current (RMS) 0.025 0.040 0.055 A Current instant tbd A

1 Stand-By-Voltage (at K22-3)

Current inrush tbd A Voltage +5V +4.75 +5.0 +5.25 V Stability ±5.0 % Ripple + Noise 100 mVpp Current (RMS) No TFT-Load 1.25 1.30 A

EXTRA-Load for TFT-Logic TFT-Load up to 2.5A is acceptable (-> in total 3.8A)

Current instant tbd A

2 Logic-Supply-Voltage (at K22-5 and K22-7)

Current inrush tbd A Voltage +12V +11.40 +12.0 +12.6 V Stability 0.1 – 1A ±5.0 % Ripple + Noise 150 mVpp Current (RMS) 0.74 0.75 0.76 A Current instant tbd A

3 Tuner-Supply-Voltage (at K22-9) with Dual- Tuner-Module

Current inrush tbd A Voltage +V-audio +11.40 +12.0 +12.6 V Stability ±5.0 % Ripple + Noise 0.01 – 1A 150 mVpp Current (RMS)* 0.01 1.2 A Current instant tbd A

4 Audio-Supply-Voltage (at K22-1 and K22-2) +12V- audio supply

Current inrush tbd A

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 18: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 7/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

2.3. Special Features

- High End picture performance - Versatile Inputs - Use of latest video-processing-ICs - DVB capable (optional connector) - digital audio-input and output (SPDIF) - integrated audio delay line (up to 200ms per channel) to support lip-sync (optional) - Digital audio amplifier (95% efficiency) - HDMI-input (max. 1080i) - DVI with HDCP - Teletext, Level 1.5, min 5000 pages program memory - 2 EURO AV SCART-connectors - 5H- and 3D-comb-filter Additional Highlights: - YUV-Input :

o High Performance HDTV input (high quality motion adaptive deinterlacing) up to 1080i o input for progressive analog video signals (EIA770.2) o input resolution up to 1080i

- High performance PIP and multiple windows engine o movable and scalable video/RGB window on RGB/Video or two separate non-

overlapping windows with independently scaled images - High performance scaling engine:

o independent programmable input scalers for each input port providing advanced scaler with adaptive algorithm for intelligent scaling, multiregion, non-linear scaling

o world class image scaler for video and VGA signals - High performance de-interlacer:

o high performance motion adaptive de-interlacing (up to 1080i) o high performance film mode treatment o high performance low angle treatment for moving objects (incl. HDTV 1080i)

- High performance noise reduction: o high performance noise reduction engine o spatial and temporal motion adaptive noise reduction o world class noise reduction

- Option slot for digital video sources: o option slot is prepared for special add-on board for IEEE1394 (Fire Wire), DV (digital

camcorder), SDI, DVB-T, etc. - High performance audio processing

o SPDIF input and output o Delay line to ensure proper lip sync (optional) o Virtual Dolby Digital processing (optional)

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 19: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 9/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.3. K22, Power supply Type : B12B-EH-A from JST, No. 2170-0047-1121

Pin arrangement Pin Signal I/O Description

1

2

3

4

5

6

7

8

9

10

11

12

+12V/+24V

+12V/+24V

+5V-StdBy

GND

+5V

GND

+5V

GND

+12V

PSTDBY

PSDPMS

PSVRR

In

In

In

In

In

In

Out

Out

In

Audio-Supply: +12V/+24V (+/-10%, max. 1A)

Audio-Supply: +12V/+24V (+/-10%, max. 1A)

+5VSTBY (+/- 5%), present all the time (max. 1A)

+5V (+/- 5%) applied by PSU in normal mode (max. 2A)

(same as no. 5, routed in parallel)

+12V (+/- 5%) applied by PSU in normal mode (max. 0.6A)

0V -> PSU supplies +5V/+12V; 3.3V -> PSU stops +5V/+12V

(0V/3.3V) Not used, for future purposes

0V -> PSU is working properly, 3.3V -> PSU problem (diagnostic signal provided by the PSU)

3.4. K12, Audio-supply Type : B4B-EH-A from JST, No. 2170-0047-1041

Pin arrangement Pin Signal I/O Description

1

2

3

4

GND

GND

+12V/+24V

+12V/+24V

In

In

Audio-Supply: +12V/+24V (+/-10%, max. 1A)

Audio-Supply: +12V/+24V (+/-10%, max. 1A)

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 20: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 10/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.5. K5, Backlight-supply Type : B12B-PH-SM3-TB from JST, No. 2170-0122-1120

Pin arrangement Pin Signal I/O Description

1

2

3

4

5

6

7

8

9

10

11

12

BCKPWM

BCKPWM

GND

BCKLGHT

BCKLGHT

GND

BO1_5V

BO1_5V

PNLIO3

PNLIO4

N.C.

GND

Out

Out

Out

Out

Out

Out

Out

Out

Backlight PWM-Signal (5V level, alternatively

3.3V)

(same as no. 1, routed in parallel)

BL Analog-Signal (5V level, alternatively 3.3V)

(same as no. 4, routed in parallel)

BL On/Off-Signal (5V level, alternatively 3.3V)

(same as no. 7, routed in parallel)

General I/Os, 3.3V, 10mA

General I/Os, 3.3V, 10mA

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 21: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 11/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.7. K25, Keyboard-connector Type: 20pin, double row, shrouded pin header, male, pitch 2.54, No. 2170-0043-1200

Pin arrangement Pin Signal I/O Description

1

20

2

19

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

GND NC

Red LED Green LED

N.C. N.C. GND N.C.

ALC + N.C. GND GND T5 T4 T3 T2 T1

GND +5VST

IRR

Out Out

In

In In In In In

Out In

+5V, 10mA, high active +5V, 10mA, high active

analog Input, 0V..+5V

key5, low active, +5VST key4, low active, +5VST key3, low active, +5VST key2, low active, +5VST key1, low active, +5VST

50mA for keyboard

IR-input (from TSOP 1238, 5V level)

3.8. K1, RS232-interface, serial interface for firmware-update, Type: 9pin, double row, D-Sub, male, No. 2170-0218-2091

Pin arrangement Pin Signal I/O Description

Front view

1 2 3 4 5 6 7 8 9

N.C. Rx Tx

N.C. GND N.C. N.C. N.C. N.C.

In Out

Receive Data (+/-12V) Transmit Data (+/-12V)

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 22: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 12/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.9. K21, YC-connector, Type: Mini-Din-socket MD-146D-4P with GND-clips, No. 2175-0129-3040

Pin arrangement Pin Signal I/O Description

Front view

1

2

3

4

Ground

Ground

Y

C

In

In

Luminance

Chrominance

3.10. K13, DVI-connector Type: DVI-socket, Molex-reference-No. 74320-1004, No. 2172-0213-0290

Pin arrangement Pin Signal I/O Description

Front view

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

C1 C2 C3 C4 C5

DT2- DT2+

TX2/4-SHLD N.C. N.C.

DDC-CLK DDC-Data

AVS DT1- DT1+

TX1/3-SHLD N.C. N.C. +5V

Ground (for +5V) HP Detect

DT0- DT0+

TX0/5-SHLD N.C. N.C.

TXC-SHLD CLK+ CLK-

ARED AGRN ABLU AHS

Analog RGB Ground

In In

In I/O In In In

In

Out In In

In In

In In In In

TMDS Data2- TMDS Data2+

TMDS Data2 Shield

I2C-Clock, +5V level I2C-Data, +5V level Analog Vertical Sync

TMDS Data1- TMDS Data1+

TMDS Data1 Shield

+5V Power*

Hot Plug Detect TMDS Data0- TMDS Data0+

TMDS Data0 Shield

TMDS Clock Shield TMDS Clock + TMDS Clock –

Analog Red

Analog Green Analog Blue

Analog Horizontal Sync

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 23: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 14/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.12. K19-A, (lower SCART-socket: AV1, RGB & CVBS) Type : 2202-21ST(A) from POWERNET, No. 2172-0302-6200

Pin arrangement Pin Signal Pin Signal

AV1

1 2 3 4 5 6 7 8 9 10 11

Audio-out, right Audio-in, right Audio-out, left

GND GND

Audio-in, left Blue video in

Widescreen-s. (CVBS) GND

SCLSC5V-AV2 Green video in

12 13 14 15 16 17 18 19 20 21

SDASC5V-AV2

GND GND

Red video in RGB-status-signal (FB)

GND GND

CVBS2 output, RGB-Sync CVBS2 input, RGB-Sync

Shielding / GND

Pin 8/14 : Widescreen-Signaling / corresponding GND +6V : input signal is 16:9-format +12V : input signal is 4:3 letterbox-format Pin 16/18 : RGB-status-signal / corresponding GND High : input signal is RGB Low : input signal is CVBS

3.13. K19-B, (upper SCART-socket.: AV2, YC & CVBS) Type : 2202-21ST(A) von POWERNET, No. 2172-0302-6200

Pin arrangement Pin Signal Pin Signal

AV2

1 2 3 4 5 6 7 8 9 10 11

Audio1-out, right Audio1-in, right Audio1-out, left

Audio-GND GND

Audio1-in, left N.C.

Widescreen-s. (CVBS) GND

SCLSC5V-AV1 N.C.

12 13 14 15 16 17 18 19 20 21

SDASC5V-AV1

GND GND

Y/C : C-in N.C: GND GND

CVBS1-out (Y/C) CVBS1-, Y1 – in (Y/C)

Shielding / GND

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 24: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 15/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.14. K7, YUV-, SPDIF-, audio- input-connector, Type: RCA-Jack, RS853A8-V-01 . 2175-0130-0080

Pin arrangement Pin Signal I/O Description

Front view

A-pin

A-shield B-pin

B-shield A1-pin

A1-shieldB1-pin

B1-shieldC-pin

C-shield D-pin

D-shield C1-pin

C1-shieldD1-pin

D1-shield

Y/C-aud.-R

GND YUV/CVBS-aud.-R

GND Y/C-Aud.-L

GND YUV/CVBS-Aud.-L

GND SPDIF-In

GND V-In GND

CVBS / Y-In GND U-In GND

In

In

In

In

In

In

In

In

Red

Red

White

White

Orange

Red

Green

Blue

3.15. K11, audio-out-connector Type: RCA-Jack, RS621-V-01 No. 2175-0131-0060

Pin arrangement Pin Signal I/O Description

Front view

A-pin

A-shield B-pin

B-shield C-pin

C-shield A1-pin

A1-shield B1-pin

B1-shield C1-pin

C1-shield

Speaker-Out-R

GND SPDIF-OUT

GND Line-Out-R

GND Speaker-Out-L

GND Subwoofer-Line-Out

GND Line-Out-L

GND

Out

Out

Out

Out

Out

Out

Red

Red

Red

White

White

White

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 25: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 17/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.18. K15, HDMI-connector Type: 19pin, double row, Molex-reference-No. 500254-1927,No. 2171-0576-2190

Pin arrangement Pin Signal I/O Description

Front view

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

R1X2+ GND

R1X2- R1X1+ GND

R1X1- R1X0+ GND

R1X0- R1XC+ GND

R1XC- NC NC

DSCL DSDA GND

HDMIHOT HOTPLUG

In

In In

In In

In In

In

In I/O

In

Out

Data

Data Data

Data Data

Data

Data-Clock

Data-Clock

I2C-Data, +5V level I2C-Clock, +5V level

+5V Power

Hot Plug Detect Signal

Note:

No additional audio line-input for HDMI

3.19. K18, Tuner-connector Type: 36pin socket terminal, double row, RM2,54, BL2-36Z, No. 2171-0044-1360

Pin arrangement Pin Signal I/O Description

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

GND +5V GND +5V GND +5V GND N.C. GND N.C. GND +9V GND +9V GND +12V GND SSIF2 GND

Out

Out

Out

Out

Out

Out

In

+5V (+/-5%)

+5V (+/-5%)

+5V (+/-5%)

+9V (+/-5%)

+9V (+/-5%)

+12V (+/-5%)

Digital Sound IF2

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 26: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 18/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

1

3

5

2

4

6

32

34

36

31

33

35

20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

CVBST2 GND

SW22K5V GND

TUNMONOGND

SCL5V GND

SCL5V GND

SDA5V GND

TUNMONOGND

CVBST1 GND SSIF1

In

Out

In

Out

Out

In

In

In

In

CVBS Tuner 2

I2C-Clock, 5V level

I2C-Clock, 5V level

I2C-Data, 5V level

CVBS Tuner 1

Digital Sound IF1

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 27: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 19/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.22. CN2, LVDS-output Type: DF20G-50DP-1 from Hirose, No. 2170-0611-2500

Pin arrangement Pin Signal I/O Description

1 2 3 4 5 6 7 8 9

10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

FPPAR FPCTRL RxO0- RxE0- RxO0+ RxE0+ GND GND

RxO1- RxE1- RxO1+ RxE1+ GND GND

RxO2- RxE2- RxO2+ RxE2+ GND GND

RxOC- RxEC- RxOC+ RxEC+ GND GND

RxO3- RxE3- RxO3+ RxE3+ GND GND

RxO4- RxE4- RxO4+ RxE4+

LO1_5V LIO4 LIO3 SDA

+5VPNL SCL

+5VPNL +12VPNL +5VPNL

+12VPNL +5VPNL

+12VPNL +5VPNL

+12VPNL

Out Out Out Out Out Out

Out Out Out Out

Out Out Out Out

Out Out Out Out

Out Out Out Out Out

Out Out Out Out Out I/O I/O Out Out Out Out Out Out Out Out Out Out Out

digital I/O with +3.3V level, out max. 10mA digital I/O with +3.3V level, out max. 10mA

Data Data Data Data

Data Data Data Data

Data Data Data Data

Data-Clock Data-Clock Data-Clock Data-Clock

Data Data Data Data

Data Data Data Data

digital output with TTL +5V level digital I/O with +3.3V level, out max. 10mA digital I/O with +3.3V level, out max. 10mA

I2C-Data, +3.3V level +5V (+/-5%, all +5V pins max. 2A)

I2C-Clock, +3.3V level +5V

+12V (+/-5%, all +12V pins max. 1.5A) +5V

+12V +5V

+12V +5V

+12V

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 28: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 22/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

1

3

5

2

4

6

76

78

80

75

77

79

33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80

GND GND

PORT1Y7 PORT1Y6 PORT1Y5 PORT1Y4 PORT1Y3 PORT1Y2 PORT1Y1 PORT1Y0

GND GND

DVBIO1 DVBIO3 DVBIO2 IN0CLK

GND GND

IN0BE9 IN0BE8 IN0BE7 IN0BE6 IN0BE5 IN0BE4 IN0BE3 IN0BE2 IN0GE9 IN0GE8 IN0GE7 IN0GE6 IN0GE5 IN0GE4 IN0GE3 IN0GE2 IN0RE9 IN0RE8 IN0RE7 IN0RE6 IN0RE5 IN0RE4 IN0RE3 IN0RE2

GND GND

IN0HS IN0VS IN0VBI IN1VBI

ITU-656IN7 ITU-656IN6 ITU-656IN5 ITU-656IN4 ITU-656IN3 ITU-656IN2 ITU-656IN1 ITU-656IN0

GPIO +3.3V ; 10mA GPIO +3.3V ; 10mA GPIO +3.3V ; 10mA

Data0 Clock

Data0 Blue Bit9 Data0 Blue Bit8 Data0 Blue Bit7 Data0 Blue Bit6 Data0 Blue Bit5 Data0 Blue Bit4 Data0 Blue Bit3 Data0 Blue Bit2

Data0 Green Bit9 Data0 Green Bit8 Data0 Green Bit7 Data0 Green Bit6 Data0 Green Bit5 Data0 Green Bit4 Data0 Green Bit3 Data0 Green Bit2 Data0 Red Bit9 Data0 Red Bit8 Data0 Red Bit7 Data0 Red Bit6 Data0 Red Bit5 Data0 Red Bit4 Data0 Red Bit3 Data0 Red Bit2

Horizontal Sync0 Vertical Sync0

Vertical Blanking Interval 0 Vertical Blanking Interval 1

Note: It is also possible to mount on K17 only a 50pin connector (Pin1-Pin50) e.g. for use with

DVB-module

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 29: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 23/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

3.25. CN---, IEC-antenna-connector on separate Tuner-module

Pin arrangement Pin Signal

Front view

Pin shield

RF-In GND

3.26. CN---, IEC-antenna-connector

Pin arrangement Pin Signal IN OUT

Front view

pin shield

pin

shield

RF-In GND

RF-Out GND

sepa

rate

Tun

er-m

odul

e

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 30: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 25/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

4.2. Possible in- and output-signals

Interface Connector / Nr. Input Output Tuner IEC s. separate Tuner-module AV1 / AV2 SCART CVBS,

RGB (FB) or YC AUDIO

CVBS, AUDIO

YUV / CVBS 3x RCA

Component YCrCb (SDTV, EDTV, HDTV)

---

S-Video 4pin Mini Din YC DVI / VGA DVI-I-socket RGB at 75 Ohm, H / V TTL

TMDS DVI 1.0

HDMI HDMI plug digital video/audio Front socket 2x RCA

Mini DIN RCA

AUDIO YC CVBS

Headphone

Audio in (analogue)

2x2 RCA l/r 3.5mm stereo jack

Audio from YC Audio from YUV / CVBS Audio from PC

Audio in (digital) 1x RCA SPDIF Audio out (analogue)

2x RCA l/r 1x RCA Subwoofer

AUDIO-Line-out

Audio out (digital)

1x RCA SPDIF

Service plug 9pin DSUB, male 1 x RS232, Rx 1 x RS232, Tx

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 31: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 26/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

4.2.1 PC analog input

- RGB-input

• Signal level: 0 - 700mV, tolerance ± 10% • Polarity: positive • Impedance: 75 Ohm • Video Bandwidth ≤ 110 MHz • Rise/Fall time: ≤ 3.7 ns • Jitter: ≤ 1.1 ns • Syncronization H/V separate sync: TTL

H/V composite sync: TTL Sync on green

The video interface must be capable to display video content with high change rate (e.g. pixel patch pattern one pixel on, one pixel off) without distortion of the image. The display quality must be maintained over the specified temperature range.

- TTL-inputs (Sync-Signals) The Monitor has to operate up to the following specified TTL-input signals:

• Level: L = 0V – 0.8V H = 2.0V - 5V

• Polarity: positive or negative

< 200 ns

< 50 ns

0.8V

2.0V 2.0V

0.8V

< 0.7V

< 0.7V0V

< 200 ns

< 50 ns

H- Sync. and V - Sync. signals at the monitor input

• High logic level: ≥ 2.0 V • Low logic level: ≤ 0.8 V

• Rise time: 0.8 V - 2.0 V: < 50 ns • Fall time: 2.0 V - 0.8 V: < 50 ns

• Pos. overshoot: < 0.7 V • Neg. overshoot: < - 0.7 V

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 32: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 27/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

Characteristics of the monitor input circuit

• Threshold voltage: 1.2 V - 1.5 V typ.

• High level noise margin: 0.5 V typ., 0.3 V min.

• Low level noise margin: 0.4 V typ., 0.2 V min.

• Impedance: ≥ 2.2 kΩ

- Noise immunity: The inputs shall have a hysteresis of 0.4 V min., (0.8 V typ). Without hysteresis the following condition has to be met: If there is a second transition of a sync. signal through the threshold region within 100 ns after a trigger event, it may not cause any malfunction of the monitor.

- DDC-Signals on DVI connector:

• DDC Serial Data: Pin 7, I2C-BUS • DDC Serial Clock: Pin 6, I2C-BUS

4.2.2 Digital input HDMI and DVI-I

• Signal format: Panel Link TM TMDS (Transmission Minimized Differential Signalling)

• R/G/B color depth: 8 bit • Dot clock rate: 110 MHz max. (Single Link) • Signals: 1 channel TMDS - TMDS data: TX0+/-, TX1+/-, TX2+/- - TMDS clock: TXC+/- - not used: TX3+/-, TX4+/-, TX5+/- • DDC: SDA, SCK : I2C-BUS

The HDMI and DVI-D input is equipped with HDCP

- Video Blanking

The video will be blanked for a period of 1 s to 2 s during change of modes or if undefined signals are applied. No switching effects are visible!

- DDC Signals on DVI connector see above - DDC Signals on HDMI connector:

• DDC Serial Data: Pin 16, I2C-BUS • DDC Serial Clock: Pin 15, I2C-BUS

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 33: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 28/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

The monitor has installed 4.7 kΩ pull-up on the SCL-line and a 4.7KΩ pullup resistor on the SDA and SCL line. The DDC EEPROM’s are connected to monitor Vcc and to DDC +5V as well, that the system can read the DDC Information also when the Monitor is powered off. The graphic controller board should provide pull-up resistors of ≥ 1.5 kΩ and ≤ 2.2 kΩ to a +5V reference or a 3 mA current source for the SCL and SDA open drain signals.

• High logic input level: ≥ 2.8 V (3.0 V) • Low logic input level : ≤ 0.8 V (1.5 V) • Low logic output level : ≤ 0.4 V

4.2.3 RF-input Minimum input level: 50 dBµV @ 75 Ohm Video standards PAL 4.43 50Hz B/G, D/K, I, L, L1

PAL 4.43 60Hz B/G, I NTSC 3.58 60Hz M not for tuner-module NTSC 4.4 60Hz B/G not for tuner-module SECAM 50Hz B/G, D/K, L, L1

HDTV: 480i, 480p, 576p, 720p, 1080i (1080p optional)

Signals CVBS Y / C RGB with additional sync (fast blank possible) YUV / YCrCb (component)

Audio standards FM-mono B/G, D/K, I, M, N FM-stereo B/G, D/K, I FM-bilingual B/G, D/K, I NICAM-stereo B/G, D/K, I, L NICAM-bilingual B/G, D/K, I, L AM-Mono L SPDIF input Cinch

Options Virtual Dolby® 4.2.4 Video-input

Specification Item Conditions Min Typ Max Unit Y 75 Ohm 1000 mVp-p Component Input level Pb 75 Ohm 700 mVp-p Pr 75 Ohm 700 mVp-p R 75 Ohm 600 700 800 mVp-p Input level G 75 Ohm 600 700 800 mVp-p SCART B 75 Ohm 600 700 800 mVp-p Comp. 75 Ohm 1000 mVp-p output level Comp. 75 Ohm 1000 mVp-p S-Video in Input level Y 75 Ohm 1000 mVp-p C 75 Ohm 300 mVp-p Composite Input level 75 Ohm 1000 mVp-p

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 34: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 29/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

Corresponding Audio-input and output:

4.2.5 S/PDIF

- S/PDIF IN (Coax) Signal level: 5V TTL (max. 48KHz), Impedance: 75Ohm (typical) Connector Type: RCA (orange)

- S/PDIF Out (Coax) Signal level: 5V TTL (48KHz), Impedance: 75Ohm (typical) Connector Type: RCA (red) 4.2.6 SCART-Input

Impedance Pin Signal Signal level Min Typ Max 1 Audio R out 0.5 Vrms 1) 10kOhm load2 Audio R in 0.5 Vrms (>= 0.2 Vrms) 1) 15 kOhm 3 Audio L out 0.5 Vrms 1) 10kOhm load4 GND Audio 5 GND blue 6 Audio L in 0.5 Vrms (>= 0.2 Vrms) 1) 15 kOhm 7 Blue video 0.7 V (+/- 0.1V) 2) 75 Ohm 8 Switch signal in TV mode: 0 .. 2 V

AV Wide: 4.5 .. 7 V AV 4:3: 9.5 .. 12 V

10 kOhm load

9 GND green 10 N/C 11 Green video 0.7 V (+/- 0.1V) 2) 75 Ohm 12 N/C 13 GND red 14 GND fast switch 15 Red video/ C

Video 0.7 V (+/- 0.1V) / 0.3V (+/- 0.1V) 2)

75 Ohm

16 Fast switch CVBS: 0 .. 0.4 V RGB: 1.0 .. 3 V

75 Ohm

17 GND video out 18 GND video in 19 Video out 3) 1.0 Vss +/- 3dB 75 Ohm 20 Video in 1.0 Vss +/- 3 dB / 75 Ohm

Audio in Input level 10 kOhm load 0.5 Vrms Line output (variable) 10KOhm load 0.5 Vrms Audio out SCART output 10KOhm load 500 mVrms Sub woofer output 10KOhm load 250 mVrms

Output level THD 10% 5+5, PDP 7 +7

W

Distortion [1W, 1kHz] TV 1 % Speaker Other source 0,5 % output S/N ratio TV TBD dB Other source TBD dB TV stereo separation -30dBm, 1kHz TBD dB TV L,R balance TBD dB

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 35: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 30/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

4.3. Timing Overview 4.3.1 Preset Timing Chart

B

A

F

G H I

(Video)

(Sync.)

Item Description: A Total time B Active display area F Blanking time G Front porch H Sync-width I Back porch

4.3.2 Timing Restrictions Based on the following conditions the monitor is full-scan capable, the adjustment ranges for picture-size and -position are within specification.

Item Horizontal Vertical Frequency 1/A 31 kHz - 70 kHz 50 Hz - 90 Hz Blanking period F 2.430 µs min. 525 µs min. Front porch period G 0.188 µs min. 11 µs min. Sync. Period H 0.987 µs - 4.0 µs 32 µs - 332 us Back porch period I 0.730 µs min. 427 µs min. Blank/Total F/A 29 % max. 26 % max. Backporch - Frontporch x 100

2 x Total

(I -G) x 100

2 x A

1 – 6.6 1 - 6.6

Detectable mode frequency separation

± 2.0 kHz min. ± 1.5 Hz min.

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 36: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 31/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

4.3.3 Factory Presetted and Predefined Timings

Remark No Resolution V-Freq

[Hz] H-Freq [kHz]

Pixel Rate [MHz]

HS-pol

VS-pol

1 640x480 59.94 31.47 25.175 N N VESA 2 72.81 37.86 31.500 N N VESA 3 75.00 37.50 31.500 N N VESA 4 800x600 56.25 35.156 36.000 P P VESA 5 60.32 37.879 40.000 P P VESA 6 72.2 48.077 50.000 P P VESA 7 75.0 46.875 49.500 P P VESA 8 1024x768 60.0 48.363 65.000 N N VESA 9 70.1 56.476 75.000 N N VESA 10 75.0 60.023 78.750 P P VESA 11 1280x720p 50 37.500 74.250 P P PC mode w/o overscan 12 50 37.500 74.250 P P HDTV: Component, DVI 13 60 45.150 74.250 P P PC mode w/o overscan 14 60 45.150 74.250 P P HDTV: Component, DVI 15 1280x1024 60.0 64.000 108.000 P P VESA 16 1360x768 60.0 47.700 85.500 P P VESA, no scaling 17 720x400 70.0 31.460 28.320 N P DOS 18 720x 480i 60.0 All inputs (not DVI-A) 19 720x 576i 50.0 All inputs (not DVI-A) 20 720x480p 60 31.469 27.000 HDTV: Component, DVI, HDMI 21 720x576p 50 31.250 27.000 HDTV: Component, DVI; HDMI 22 1920x1080i 50 33.780 74.250 HDTV: Component, DVI, HDMI 23 60 33.780 74.250 HDTV: Component, DVI, HDMI

PC Modes details for LCD panel resolution

No Resolution Fv Hz

Fh kHz

Fpix MHz **)

HS VS H.tot px

H.fp px

HS.pw px

V.tot lines

V.fp lines

VS.pw lines

1360x768 50 39.76 71.25 P P 1792 64 112 795 3 6 1360x768 60 47.71 85,50 P P 1792 64 112 795 3 6

**) Fpix +/- 0.5%

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 37: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 32/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

4.3.4 Digital Control Operation

Signals used for mode detection:

• Nominal horizontal frequency • Nominal vertical frequency • Horizontal Sync. Pulse Polarity • Vertical Sync. Pulse Polarity • Amount of total lines

The tolerance for detecting the horizontal frequency is between ± 2% from the horizontal center frequency. The tolerance for detecting the vertical frequency is between ± 2% from the vertical center frequency. PICTURE STABILITY: Picture position, size and image lock has to be stable even during warm up, this means phase shift ≤ 2ns PROTECTION CIRCUIT: Missing or improper sync pulses will not damage the monitor. Additionally, under these conditions, the monitor shall not cause damage to the driving source.

4.4. Audio Electrical Performance LOUDSPEAKER

Rated input 7W (2 speakers in parallel) Max. input 10W (2 speakers in parallel) Impedance 8 Ohm ± 15% (PDP), 2 Ohm ± 15% (TFT) Resonant frequency 100 Hz ± 20% Frequency range 150 Hz – 20 kHz +/- 3 dB

AMPLIFIER

Max. Output 7W (PDP), 5W (TFT) per channel Frequency range 100 Hz – 15 kHz

SUB WOOFER : The sub woofer output is a "line" output and volume control works together with the built in speaker.

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 38: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 34/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

4.5.2 On Screen Display (OSD)

Item Options PICTURE DISPLAY SOUND VOLUME BALANCE EQIUALIZER MODUS VOLUME LINE OUT MAX STARUP VOLUME AVC SPDIF INPUT USER EQUALIZER

SETUP @ selected input: TUNER SCART1,2

CVBS YC YUV HDMI PC(DVI) PC(RGB)

TUNER INPUTS INPUTS PC OSD OSD OSD OSD OSD INFO INFO INFO INFO INFO

SETUP\TUNER AUTO SEARCH MANUAL SEARCH EDIT STATION LIST SETUP\SCART1 TV SCART OFF/ON RGB IN SCART/UNUSED/ALWAYS FILM MODE ON/OFF FORMAT DETECTION VOLTAGE/SOFTWARE 16:9 FORMAT LETTERBOX / ANAMORPH SETUP\SCART2 TV SCART ON/OFF YC IN UNUSED/ALWAYS FILM MODE ON/OFF FORMAT DETECTION VOLTAGE/SOFTWARE 16:9 FORMAT LETTERBOX / ANAMORPH SETUP\CVBS FILM MODE ON/OFF SETUP\YC FILM MODE ON/OFF SETUP\YUV FILM MODE ON/OFF SETUP\HDMI FILM MODE ON/OFF (SETUP\PC DVI) (NO SETUP SELECTIONS)

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 39: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 35/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

SETUP\PC RGB (VGA) H FREQ V FREQ AUTO SETUP H TOTAL V POS V SIZE H POS H SIZE

PHASE SETUP\TUNER\AUTO SEARCH

COUNTRY UK, France, Germany, Italy, Spain, Austria, Switzerland, Belgium, Netherlands, Luxembourg, Denmark, Sweden, Finland, Norway, Eire, Turkey

SEARCH FROM ALL CHANNELS / NEW CHANNELS START SEARCH SETUP\TUNER\MANUAL SEARCH

PROGRAMME PROGRAMME NUMBER FROM 0 TO 99 TYPE CHANNEL / SPECIAL CHANNEL CHANNEL ENTER A CHANNEL NUMBER or FREQUENCY 5 DIGIT FREQUENCY

NAME TV STANDARD FOR PAL: B/G D/K I

FOR SECAM: B/G D/K L COLOUR STANDARD PAL/SECAM DECODER

SETUP\EDIT STATION LIST YELLOW BUTTON: SELECT THE CHANNEL TO BE SHIFTED

GREEN BUTTON: SELECT A CHANNEL TO BE DELETED RED BUTTON: CLOSE EDIT MENU

SETUP\OSD TIME OUT OFF 5 10 15 20 25 or 30 sec. TRANSPARANCY 1 - 10 SHOW LOGO ON/OFF

RESET TO FACTORY ´ DEFAULTS

LANGUAGE English, Francáis, Deutsch, Italiano, Espanol, Portugues, Nederlands, Svenska, Noersk, Suomi, Dansk, Polski

TTX SETUP WEST EAST RUSSIAN ARABIC

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 40: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 36/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

After switching on the TV the first time the language and the country has to be selected. After that the automatic station search starts. Lanuguage settings for OSD: English, Francáis, Deutsch, Italiano, Espanol, Portugues, Nederlands, Svenska, Noersk, Suomi, Dansk, Polski Selection of the country for the TV channel sorting sequence: UK, France, Germany, Italy, Spain, Austria, Switzerland, Belgium, Netherlands, Luxembourg, Denmark, Sweden, Finland, Norway, Eire, Turkey. OSD menu PICTURE SETTINGS PICTURE SETTINGS FOR AV SOURCES (TV,CVBS;YC;YUV;SCART1,SCART2,HDMI):

Item Options PICTURE

CONTRAST X BRIGHTNESS X SHARPNESS X COLOUR X TINT FOR NTSC ONLY COLOUR

BALANCE Cool, Normal, Warm

PICTURE ADJUST Normal. Light, Dark FILTER Normal, Soft, Intensive (CVBS and YC only) NOISE RED. DNC (Dynamic Noise Control , not for HDMI) PHOTO CD On, Off (Not for TV or HDMI ; enhances Photo CDs )

PICTURE SETTINGS FOR pc SOURCES (dvi ; rgb=vga):

Item Options PICTURE

CONTRAST X BRIGHTNESS X SHARPNESS X COLOUR X TINT FOR NTSC ONLY COLOUR

BALANCE Cool, Normal, Warm

PICTURE ADJUST Normal. Light, Dark FILTER Normal, Soft, Intensive (CVBS and YC only) NOISE RED. DNC (Dynamic Noise Control , not for HDMI)

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 41: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 37/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

4.5.3 Picture formats (Display)

PICTURE FORMATS FOR AV SOURCES (TV,CVBS;YC;YUV;SCART1,SCART2,HDMI):

Item Options DISPLAY

ZOOM AUTO ZOOM FILL ALL NORMAL 16:9 16:9 TOP 14:9 14:9 TOP PANORAMA

LAYOUT PIP FREEZE PICTURE OFF/ON OVERSCAN ON/OFF SCREEN SAVER ON/OFF

PICTURE FORMATS FOR PC SOURCES (DVI , RGB=VGA):

Item Options DISPLAY

ZOOM FILL ALL NORMAL ONE TO ONE LAYOUT PIP FREEZE PICTURE OFF/ONX

4.5.4 PIP Matrix-Table

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 42: HARMAN/CARDON TV ht32_ht40_ht46

Design Requirements

AV5-Electronic

CONRAC Number

4042-6350-9601

Rev. 1.12

Status: 04.05.2006

Page 38/39

Copyright © CONRAC GmbH. All rights reserved. For internal use only

Nur für internen Gebrauch. Alle Rechte vorbehalten Pflichtenheft AV5, REV 1.12

4042-6350-9601

5. Qualification

5.1. Ambient conditions

Operating-temperature : lower = 5°C (+32°F) warranted performance -20°C (-4°F) no major problem or permanent fault

upper = +35°C (+95°F) warranted performance

storage-temperature : -20°C … +70°C (-4°F … +158°F)

relative humidity : < 80%

maximum air pressure: = 708 hPa (corresponding height 2000m)

5.2. EMI-standards

Criteria EMI/EMC: EN55013

EN55022-B D

ESD: EN61000-4-2 contact discharge 4kV EN61000-4-2 air discharge 8kV

B

Radiated RF (80-1000MHz): EN61000-4-3 (20V/m 80% modulation level from 80 – 1000MHz)

A

Conducted disturbances induced by RF fields:

EN61000-4-6 (10Veff, AM 80%, 1kHz from 150kHz – 80MHz)

A

Radiated RF: ENV50204:1995 900MHz, 20V/m, pulse 50%

A

5.3. El. safety

• EN60065/09.93 + A11 (latest revision) • EN60950:2000 • Designed to meet UL1950 3rd edition or higher

5.4. Vibration and shock MECHANICAL STRESS

Shock: 20G, 11ms, half sine (x/y direction) 15G, 11ms, half sine (z direction) Vibration: 1.2G, 10 – 55Hz, sinus Sweep: 1 minute/octave Amplitude: 0.35mmp-p (x-direction) 0.35mmp-p (y direction) 0.175mmp-p (z-direction) Time : 30 minutes Standard: Conform to EN60605

DL HT32 - HT40 - HT46

Harman Consumer Group International

Page 43: HARMAN/CARDON TV ht32_ht40_ht46

Power Supply

Page 44: HARMAN/CARDON TV ht32_ht40_ht46

Power Supply

JLudwigs
Rectangle
JLudwigs
Rectangle
Page 45: HARMAN/CARDON TV ht32_ht40_ht46

Power Supply