Water Treatment Plant #3 Concentration Utilization at Water Treatment Plant #1.
Haiderpur Water Treatment Plant
-
Upload
akshay-malik -
Category
Documents
-
view
387 -
download
43
description
Transcript of Haiderpur Water Treatment Plant
HAIDERPUR WATER TREATMENT PLANT
ROHINI
Haiderpur Water Treatment plant is the single largest plant in Asia with a capacity of 200 MGD. It is located in Western Delhi on the outer Ring Road near Prashant Vihar, Rohini Sector 15 on the bank of Western Jamuna Canal originating from Tajewala Head Works Haryana. The plant is about 5km from GTKarnal Bypass and 4 km from Madhuban Chowk. It has two independent treatment plants of 100 MGD each.The treatment flow scheme is same for both. A common laboratory has been provided in the waterworks.
Haiderpur Water Treatment plant
Western Jamuna Canal (WJC): - It originates from Tajewala Head Works, upstream Yamuna Nagar and then passes through Karnal, Munak, Panipat, Khubru, Kakroi and Bawana to Haiderpur Water Works.Bhakra Storage: Delhi Jal Board receives water from Bhakra Storage through Bhakra Nangal canal which joins WJC near Karnal and carries fresh water for Delhi Water Supply.
Raw water is drawn from two sources, viz. the Western Jamuna Canal (WJC) and the Bhakra Storage.
Plant Capacity and Supply Area Coverage for Haiderpur Water Treatment Plant is as follows:
Haiderpur Ist 100 MGD:-Capacity: -> 100 MGDCommissioned: -> 1973/79Optimised Production: -> 100 MGDRaw Water: -> 10 pumps of 22 MGD eachPre-chlorination :> 40 kg / hr.Filter House (2 Nos.): each of 50 MGD capacity
Total 40 Nos. rapid sand filters of size 10.3m X 9.5m X 3m(2.5 MGD) each
Clariflocculator at Haiderpur Water Treatment Plant
Clarifloculators (8 Nos.): -> each of 12.5 MGD (51.5 m dia X 4m depth)Backwash Pump :-> 125 HP centrifugal typeAir blower:-> 60 HP
Population served:-> 18 Lakh approx. Area served:-> Pitampura, Shalimar bagh, Saraswati vihar, Paschim vihar, Raja Garden, Jawala Heri ,Ramesh nagar,North West Delhi.
1. Feed Channel From WJC Length: 100 ft Width: 12ft-6inchHeight 7ft
2. Raw Water Pump House
a. Silt-Chamber 145ft x 20 ft
b. Sump 152ft x 20ft
c. Pump House with ANNEXE 80 x 16
d. Raw water pumps 10 Nos.
e. Capacity 110 kw 22MGD each
f. Raw water main 4 Nos.---1100 mm dia Length-100ft
3. Pre-treatment
a. Main inlet sump_ (2 Nos.) 16ft x 16ft
b. Flash mixer------- (8 Nos.) 8ft x 8ft
Detention Period 30 sec
c. Clariflocculators 8 Nos.
Capacity 12.5 MGD
Size 160ft dia SWD 12ft-6inch66ft inner dia SWD 17 ft 7 inch
Detention Period Flocculating Chamber - 20 min.Clarifier - 2.5 hrs.
Surface loading 750 gallons/ sq ft/ day
4. Chemical House
A. Area 500 sq ft
B. Maximum Alum Dose 60 ppm
C. Capacity of Each tank (11 ft x 11ft x 6 ft) 4 hrs. @ 5% solution
D. 12 Nos. Tanks 4500 gallons
5. Alum Godown 600 MT each
6. Filtration Plant
Filter House 2 Nos. (348 x 100 ft)
Number of Filters 25 x 2 (26 x 35 ft each)
Capacity of Filters 2 MGD each
Rate of Back Washing 10 gal / sq ft / min
Rate of Air Sourcing 2 cft/min
Working Area of Each Filter 836 sq ft
Rate of Filteration 100 gal / sq ft / hour
Blower in each Plant 3 Nos. (840 cft / min)
Back Washing Pumps 4 Nos. (2800 gal/ min)
7. Filter Sand Media
Fine Sand 1/32 to 1/16 inc = 24 inch
Coarse Sand 1/16 to 1/8 inc = 6 inch
Gravel 1/8 to 1/4 inc = 4 inch
Gravel 1/4 to 1/2 inc = 2 inch
Fine Gravel 1/2 to 1 inc = 2 inch
Coarse gravel 1 to 2 inch = 2 inch
8. Balancing Reservoir
Capacity 2.4 MG each (5 Nos.)
Volume 200 x 200 x 10 ft
Water Treatment Plants 13
Conventional Surface Water Treatment
Screening
Coagulation
Flocculation
Sedimentation
Filtration
Disinfection
Storage
Distribution
Raw water
AlumPolymers
Cl2
sludge
sludge
sludge
Water Treatment Plants 14
ScreeningRemoves large solids
logsbranchesragsfish
Simple processmay incorporate a mechanized trash removal system
Protects pumps and pipes in Water Treatment Plants
Water Treatment Plants 15
CoagulationSmall particles are not
removed efficiently by sedimentation because they settle too slowly
they may also pass through filters
easier to remove if they are clumped together
Coagulated to form larger particles, but they don't because they have a negative charge
repel each other (like two north poles of a magnet)
In coagulationwe add a chemical such
as alum which produces positive charges to neutralize the negative charges on the particles
particles can stick together forming larger particles more easily removedprocess involves addition of
chemical (e.g. alum) rapid mixing to dissolve the
chemicaldistribute it evenly throughout
water
Water Treatment Plants 16
CoagulantsAluminum Sulfate
Al2(SO4)3
Ferrous Sulfate FeSO4
Ferric Sulfate Fe2(SO4)3
Ferric Chloride FeCl3Lime Ca(OH)2
Aluminum salts are cheaper but iron salts are more effective over wider pH range
Factors for choosing a coagulant?1. Easily available in all
dry and liquid forms2. Economical 3. Effective over wide
range of pH4. Produces less sludges5. Less harmful for
environment6. Fast
Water Treatment Plants 17
Flocculation Now the particles have a neutral charge
can stick together The water flows into a tank
with paddles that provide slow mixing
bring the small particles together to form larger particles called flocs
Mixing is done quite slowly and gently in the flocculation step
If the mixing is too fast, the flocs will break apart into small particles that are difficult to remove by sedimentation or filtration.
Water Treatment Plants 18
Sedimentationwater flows to a tank called a
sedimentation basingravity causes the flocs to settle
to the bottomLarge particles settle more
rapidly than small particles It would take a very long time
for all particles to settle out and that would mean we would need a very large sedimentation basin.
So the clarified water, with most of the particles removed, moves on to the filtration step where the finer particles are removed
Water Treatment Plants 19
Raw water
Coagulation
Aeration
Flocculation
Sedimentation Tank
Water Treatment Plants 20
Filtration The filtration apparatus is a
concrete box which contains sand (which does the filtering), gravel (which keeps the sand from getting out) and underdrain (where the filtered water exits)
After the filter is operated for a while, the sand becomes clogged with particles and must be backwashed
Flow through the filter is reversed and the sand and particles are suspended
The particles are lighter than the sand, so they rise up and are flushed from the system. When backwashing is complete, the sand settles down onto the gravel, flow is reversed and the process begins again
Water Treatment Plants 21
Disinfection With particles removed, it only
remains to provide disinfection, so that no pathogens remain in the water
Protozoan pathogens are large in size and have been removed with other particles
Bacteria and viruses are now destroyed by addition of a disinfectant
Chlorination Enough chlorine is added so that
some remains to go out in the water distribution system, protecting the public once the water leaves the plant
Water Treatment Plants 22
DistributionPumping of the clean
water produced at the treatment plant to the community is called distribution
This can be done directly or by first pumping the water to reservoirs or water storage tanks
Water Treatment Plants 23
Serial No. Water Quality ParameterPHYSICAL PARAMETERS
1 Appearance2 Color3 Odor4 Taste5 Temperature6 Turbidity
CHEMICAL PARAMETERS7 pH8 Alkalinity9 Hardness as CaCO3
10 Electrical Conductivity11 Sulphate12 Calcium13 Magnesium14 Total Dissolved Solids15 Chlorides16 Residual Chlorine17 Nitrate as NO3
-
18 Nitrite as NO2-
BACTERIOLOGICAL PARAMETERS19 Total Coliform Count20 Fecal Coliform Count
TOXIC SUBSTANCES21 Arsenic as As +3/+5
22 Cyanide as CN-