gsfc annual report 09-10
Transcript of gsfc annual report 09-10
-
8/7/2019 gsfc annual report 09-10
1/68
-
8/7/2019 gsfc annual report 09-10
2/68
-
8/7/2019 gsfc annual report 09-10
3/6848th ANNUAL REPORT 2009-10 1
BOARD OF DIRECTORS(As on 31-07-2010)
SHRI A. K. JOTI Chairman
SHRI D. C. ANJARIA
PROF. VASANT P. GANDHI
SHRI AJAY N. SHAH
SHRI VIJAI KAPOOR
SHRI P. N. ROY CHOWDHURY
SHRI M. M. SRIVASTAVA
SHRI D. J. PANDIAN
SHRI H. V. PATEL Managing Director
EXECUTIVE DIRECTORSHRI H. P. PANDYA
GENERAL MANAGER (FINANCE)
SHRI B. M. BHORANIA
COMPANY SECRETARY & DY. GENERAL MANAGER
(LEGAL & INDUSTRIAL RELATIONS)
CS V. V. VACHHRAJANI
BANKERS
Bank of Baroda
Central Bank of India
Bank of IndiaDena Bank
Indian Bank
Vijaya Bank
Yes Bank Ltd.
State Bank of India
Indian Overseas Bank
Axis Bank Ltd.
ICICI Bank Ltd.
Punjab National Bank
LEGAL ADVISORS AND ADVOCATES
M/s. Nanavati Associates, Advocates, Ahmedabad
Jaideep B. Verma, Advocate, Vadodara
STATUTORY AUDITORS
M/s. S. C. Bapna & Associates, Vadodara (for 2009-10)
M/s. Prakash Chandra Jain & Co., Vadodara (for 2010-11)
BRANCH AUDITORS
(Polymers & Fibre Units)
M/s. Khedkar Shah & Soni, Vadodara
COST AUDITORS
M/s. Diwanji & Associates, Vadodara
GUJARAT STATE FERTILIZERS & CHEMICALS LIMITED
48th ANNUAL GENERAL MEETING
Date : 24th September, 2010
Day : Friday
Time : 4.30 p.m.
Place : Cultural Centre AuditoriumFertilizernagar TownshipP. O. Fertilizernagar - 391 750District Vadodara
CONTENTS Page No.
Notice .................................................................... 03
Directors Report ................................................... 07
Management Discussion and Analysis Report .. 16
Corporate Governance Report ............................ 22
Financial Highlights .............................................. 32
Auditors Report .................................................... 33
Balance Sheet ...................................................... 36
Profit & Loss Account .......................................... 37
Cash Flow Statement ........................................... 38
Schedules forming part of Accounts ................... 39
REGISTRARS & SHARE TRANSFER AGENTS
M/s. MCS LimitedNeelam Apartments, 1st Floor
88, Sampatrao Colony
Behind Standard Chartered Bank
Productivity Road, Vadodara - 390 007
REGISTERED OFFICE
P. O. Fertilizernagar - 391 750
District Vadodara, Gujarat, India
Phone : (0265) 2242451/651/751
Website : www.gsfclimited.com
-
8/7/2019 gsfc annual report 09-10
4/682 48th ANNUAL REPORT 2009-10
1. The Register of Members and the Share Transfer
Books of the Company shall remain closed fromSaturday, the 11th September, 2010 to Friday, the24th September, 2010 (both days inclusive) for the
purpose of ascertaining the entitlement for
payment of dividend.
2. Dividend, upon its declaration at the meeting, will
be paid on Equity Shares of the Company on or
after 5th October, 2010, to those members whose
names shall appear on the Register of Members
of the Company on the Book Closure date.
3. To make the payment of dividend through ECS or
to print Bank particulars of the members on the
dividend warrants, members are requested tofurnish their Bank particulars viz. Name of Bank
with its branch and address, Bank A/c. No., 9 Digit
MICR Code appearing on the MICR cheque issued
by the Bank etc. Please also send a copy of the
MICR Cheque together with Bank particulars to
the Company latest by 11th September, 2010.
The shareholders who hold shares in electronic
form are requested to furnish their Bank particulars
as aforesaid to their Depository Participant (DP)
by the stipulated date.
4. Members are requested to quote Folio Number or
DP ID and Client ID No. (in case of shares held in
demat forms) in all correspondence and also tobring with them the Attendance Card which may
be submitted at the entrance gate duly signed.
5. Members who are registered under two or more
Ledger Folios are requested to write to the
Registrars and Share Transfer Agents of the
Company for consolidation, giving particulars of
such Folios alongwith the relevant Share
Certificates.
6. Those members, who have not yet submitted theirold share certificates of Rs.100/- face value for
exchange of new equity shares of Rs.10/- each,are requested to send the said share certificates to
the Registrars & Share Transfer Agents of the
Company.
FOR MEMBERS ATTENTION
VERY IMPORTANT
Members are requested to show their Photo Identity Card at the entry point alongwith originaAnnual Report for the Financial Year 2009-10 containing the Attendance Slip duly signed by selfthe proxy, failing which the entry to the Annual General Meeting shall be denied.
No bags or belonging shall be permitted to be carried inside the venue of Annual General Meeting
The Members may kindly note that this is being done for security reasons.
7. Shareholders of erstwhile Gujarat Nylons Lt
(GNL) who have yet not surrendered their GNequity share certificate/s are advised to surrend
the same immediately to the Registrars & Sha
Transfer Agents of the Company so as to enab
to issue GSFC shares in exchange thereof at t
earliest.
8. Members holding shares in the Dematerialis
Form are requested to intimate changes, if any,
respect of their Bank details, Mandate instruction
Nomination, Power of Attorney, Change
Address, Change of Name etc. to their Deposito
Participant (DP).9. The Companys Equity Shares are listed on t
following Stock Exchanges :
1. Bombay Stock Exchange Limited
Phiroze Jeejeebhoy Tower
25th Floor, Dalal Street, Fort
Mumbai 400 001
2. National Stock Exchange of India Ltd.
Exchange Plaza, 5th Floor
Plot No.C/1, G Block
Bandra Kurla Complex
Bandra (East)
MUMBAI 400 051
The Company has paid annual Listing fees to ea
of the above Stock Exchanges for the financ
year 2010-11.
10. Members are requested to send their querie
if any, at least seven days in advance of th
meeting so that the information can be mad
available at the meeting.
11. As a measure of economy, the Company do
not distribute the copies of Annual Report
the Meeting. Members, therefore, are request
to bring their copies with them.
-
8/7/2019 gsfc annual report 09-10
5/6848th ANNUAL REPORT 2009-10 3
NOTICE is hereby given that the Forty-eighth Annual General Meetingof the Members of the Company
will be held at Cultural Centre Auditorium situated at the Registered Office of the Company atP. O. Fertilizernagar - 391750, Dist. Vadodara at 4.30 p.m. on Friday, the 24 th September, 2010to transact the following business :
Ordinary Business
1. To receive, consider and adopt the Audited Accounts, Balance Sheet as at 31 st March, 2010,Profit & Loss Account for the year ended on that date and the Directors' report and Auditors' reportthereon.
2. To declare Dividend on Equity Shares.
3. To appoint a Director in place of Shri Vijai Kapoor, who retires by rotation and being eligible offershimself for re-appointment.
4. To appoint a Director in place of Shri D. J. Pandian, who retires by rotation and being eligible offers
himself for re-appointment.5. To pass the following resolution, with or without modification, as an Ordinary Resolution :
RESOLVED that the Board of Directors of the Company be and are hereby authorized to fix theremuneration plusthe traveling and other out of pocket expenses, that is to be paid to the StatutoryAuditors and Branch Auditors appointed by the Comptroller and Auditor General of India for auditof accounts of the Company for the Financial Year 2010-11 at the Head Quarters for Baroda Unitand the Sikka Unit and also for audit of accounts of the Polymers Unit and the Fibre Unit of theCompany for the Financial Year 2010-11, as may be deemed fit and proper by the Board of Directorsin its absolute discretion.
Special Business
6. To consider and if thought fit, to pass the following resolution, with or without modification, as anOrdinary Resolution :
RESOLVED that Shri M. M. Srivastava who was appointed as an Additional Director of the Companyunder Section 260 and other applicable provisions, if any, of the Companies Act, 1956, read withthe relevant Article/s of the Articles of Association of the Company and who holds such officeupto the date of this Annual General Meeting and who is eligible for re-appointment and in respectof whom the Company has received a notice in writing alongwith a deposit of Rs.500/- (RupeesFive hundred only) from a member under Section 257 of the Companies Act, 1956 proposing hiscandidature for the office of Director, be and is hereby appointed as a Director of the Companyand shall be liable to retire by rotation."
By Order of the Board
Sd/-
CS V. V. VachhrajaniPlace : Fertilizernagar Company Secretary &Date : 31st July, 2010 Dy.Gen.Mgr.(Legal & Industrial Relations)
NOTICE
-
8/7/2019 gsfc annual report 09-10
6/684 48th ANNUAL REPORT 2009-10
NOTES
1. A MEMBER ENTITLED TO ATTEND AND VOTE AT THE MEETING IS ENTITLED TO APPOINT A PROX
TO ATTEND AND VOTE INSTEAD OF HIMSELF AND THE PROXY NEED NOT BE A MEMBER.Please bring your copy of Annual Report a nd attendance card at the meet ing. Persons other than membeor proxy will not be allowed to attend the meeting.
2. As the Company continue to attract the provisions of Section 619-B read with the provision of Section 619(2)the Companies Act, 1956, the Comptroller & Auditor General of India has appointed M/s. Prakash Chandra Ja& Co., Chartered Accountants, Vadodara and M/s. Khedkar Shah & Soni, Chartered Accountants, Vadodarespectively as Statutory & Branch Auditors of the Company for the Financial Year 2010-11.
3. Explanatory Statement pursuant to Section 173(2) of the Companies Act, 1956 in respect of Special Busineis annexed hereto.
The particulars of qualification, experience and other directorship etc. of Shri Vijai Kapoor, Shri D. J. Pand iaShri M. M. Srivastava and Shri A. K. Joti is given in the annexure to this notice.
4. As required under the Rule 4A of the Companies Unpaid Dividend (Transfer to General Revenue Account of CentGovernment) Rules, 1978, the Company hereby inform to its Members that all unpaid/ unclaimed dividends declared and upto the Financial Year ended 31st March, 1994 have been transferred to the General Revenue Account of tCentral Government. Members who have not encashed the dividend warrants for the said period are requested to cla
the amount from the Registrar of Companies (Gujarat), Housing Board Building, Opp. Roopal Park Society, Ankur ChRasta, Naranpura, Ahmedabad - 380 013.
Consequent upon amendment to Section 205-A of the Companies Act, 1956 and introduction of Section 205-C by tCompanies (Amendment) Act, 1999, the amount of dividend for the subsequent years remaining unpaid or unclaimed a period of seven years from the date of transfer to Unpaid Dividend Account of the Company shall be transferred to tInvestors' Education and Protection Fund set up by the Government of India and no payments shall be made, in respeof any such claims, by the Fund. Accordingly, the unclaimed dividends for the financial year ended 31-03-1995 31-03-1999 has been transferred to the said fund.
Details of dividend to be transferred to Investors' Education & Protection Fund (IEPF) :Dividend No. Financial year Date of Declaration Due for transfer to IEPF on
31 2004-05 23-09-2005 23-10-201232 2005-06 22-09-2006 22-10-201333 2006-07 21-09-2007 21-10-201434 2007-08 26-09-2008 26-10-201535 2008-09 25-09-2009 25-10-2016
Members who have not yet encashed their dividend warrant(s) for the financial year ended 31-03-20to 31-03-2009, are requested to lodge their claims to the Compan y, without any delay.
5. Relevancy of questions and the order of speakers at the meeting shall be decided by the Chairman.
ANNEXURE TO NOTICE
EXPLANATORY STATEMENT PURSUANT TO SECTION 173 OF THE COMPANIES ACT, 1956
In conformity with the provisions of Section 173 of the Companies Act, 1956, the following Explanatory Statement sets o
all the material facts relating to the Special Business mentioned in the accompanying Notice and should be taken
forming part of the Notice.
Item No. 6
Pursuant to the recommendation of the Govt. of Gujarat, the Board of Directors have, effective from 29-10-2009, appointShri M. M. Srivastava, IAS as an Additional Director and who shall hold of fice upto the date of t his Annual General Meetiof the Company.
As required under Section 257, notice has been received by the Company signifying the intention to propose his candidatufor the office of Director of the Company together with requisite amount of deposit prescribed.
Shri M. M. Srivastava, besides being a member of the Indian Administrative Service is having vast experience in the fieof Management, Corporate Finance & Accounts and Administration, etc. He is an Additional Chief Secretary, FinanDepartment, Govt. of Gujarat and he is also a Director of other companies. Your Directors, therefore, recommends tpassing of the resolution at Item No. 6. The resume of Shri M. M. Srivastava forms part of this annual report.
None of the Directors except Shri M. M. Srivastava, is in any way concerned or interested in the resolution.
By Order of the Boa
S
CS V. V. Vachhraja
Place : Fertilizernagar Company Secretary
Date : 31st July, 2010 Dy.Gen.Mgr.(Legal & Industrial Relation
-
8/7/2019 gsfc annual report 09-10
7/6848th ANNUAL REPORT 2009-10 5
DETAILS OF DIRECTORS APPOINTED / SEEKING APPOINTMENT / RE-APPOINTMENT AT THE
ANNUAL GENERAL MEETING (IN PURSUANCE OF CLAUSE 49 OF THE LISTING AGREEMENT)
ANNEXURE
Name of theDirector
Date of Birth
Date of Appointmentas a Director of
GSFC
Qualification
Expertise
No. of Shares held inthe Company
Name of other
Companies in which
directorship is held
Committee positionfor Audit and
Investors Grievance
Committees
Shri D. J. Pandian, IAS
11-05-1955
21-01-2010
B.A., M.B.A., IAS
He is a Senior IAS Officer having vast experience inPolicy Making, Public Administration, Management
of Corporate Finance & Strategic Planning.During his career, he held various key positions atthe State Government and Central Governmentlevels. He has also worked with World Bank inWashington. Presently, he is holding the key positionof Principal Secretary (Energy & PetrochemicalsDepartment), Govt. of Gujarat. He has successivelymanaged GSPC group companies for the last 8years as its Managing Director.
500 (Jointly with GSIL)
1. Gujarat Urja Vikas Nigam Limited
2. Gujarat State Electricity Corporation Ltd.
3. Gujarat Energy Transmission Corporation Ltd.
4. GSPC Pipavav Power Co. Ltd.5. Gujarat Industries Power Company Ltd.
6. Gujarat State Energy Generation Ltd.
7. Gujarat Power Corporation Ltd.
8. GSPC Gas Co. Ltd.
9. Gujarat State Petroleum Corporation Ltd.
10. Gujarat Alkalies and Chemicals Ltd.
11. Gujarat Narmada Valley Fertilizers Co. Ltd.
12. Gujarat State Petronet Ltd.
13. Mahaguj Collieries Ltd.
Name of the Company Position inAudit Comm.
1. Gujarat Alkalies and Member
Chemicals Limited
Name of the Company Position inInvestorsGrievanceCommittee
1. Gujarat State Fertilizers & ChairmanChemicals Limited
2. Gujarat Alkalies andChemicals Limited Chairman
Shri Vijai Kapoor, IAS (Retired)
13-09-1938
15-07-2006
M.A. (Mathematics), IAS (Retd.)
Served in Indian Administrative Service and haslater served as Lieutenant Governor of Delhi for
6 years. He has had rich administrativeexperience in different walks of Administration andCorporate Affairs.
500 (Jointly with GSIL)
1. Febindia Overseas Private Ltd.
2. Corporate Consultants, New Delhi
Name of the Company Position inAudit Comm.
___ ___
Name of the Company Position inInvestorsGrievanceCommittee
___ ___
-
8/7/2019 gsfc annual report 09-10
8/686 48th ANNUAL REPORT 2009-10
DETAILS OF DIRECTORS APPOINTED / SEEKING APPOINTMENT / RE-APPOINTMENT AT THE
ANNUAL GENERAL MEETING (IN PURSUANCE OF CLAUSE 49 OF THE LISTING AGREEMENT)
ANNEXURE
Name of theDirector
Date of Birth
Date of Appointment
as a Director of
GSFC
Qualification
Expertise
No. of Shares held in
the Company
Name of other
Companies in which
directorship is held
Committee position
for Audit andInvestors Grievance
Committees
Shri A. K. Joti, IAS
23-01-1953
19-02-2010
B.Sc., M.Sc., IAS
He is a Senior IAS Officer having vast experience iPolicy Making, Public Administration, Managemenof Corporate Finance & Strategic Planning.
During his career, he held various key positions athe State Government and Central Governmenlevels. Presently, he is the Chief Secretary to thGovt. of Gujarat.
___
1. Gujarat Alkalies and Chemicals Ltd.
2. Gujarat Narmada Valley Fertilizers Co. Ltd
3. Gujarat State Petroleum Corporation Ltd.
4. Gujarat State Petronet Ltd.5. Sardar Sarovar Narmada Nigam Ltd.
Name of the Company Position inAudit Comm.
___ ___
Name of the Company Position inInvestorsGrievanceCommittee
___ ___
Shri M. M. Srivastava, IAS
23-07-1952
29-10-2009
M.Sc., M.B.A., IAS
He is a senior IAS Officer having vast experiencein the field of Management, Corporate Finance &Accounts and Administration etc. He held many
important positions in the State/Central Government.At present he is an Additional Chief Secretary to theGovernment of Gujarat, Finance Department.
500 (Jointly with GSIL)
1. Gujarat State Financial Services Limited
2. GSFS Caps Limited
3. Gujarat State Investments Ltd.
4. Gujarat Narmada Valley Fertilizers Co. Ltd.5. Gujarat International Finance Tech City Co. Ltd.
6. Gujarat State Petroleum Corporation Ltd.
7. Sardar Sarovar Narmada Nigam Ltd.
8. Gujarat Alkalies and Chemicals Ltd.
Name of the Company Position inAudit Comm.
1. Gujarat State Fertilizers & Member
Chemicals Ltd.2. Gujarat State Investments Ltd. Member
3. Gujarat International Finance Member
Tech City Company Ltd.
4. Sardar Sarovar Narmada MemberNigam Ltd.
Name of the Company Position inInvestorsGrievanceCommittee
___ ___
-
8/7/2019 gsfc annual report 09-10
9/6848th ANNUAL REPORT 2009-10 7
DIRECTORS REPORT
To
The Members,Your Directors are happy to present the 48 th Annual Report and Audited Accounts of the Company for the year ended31st March, 2010.
A. FINANCIAL RESULTS (Rs. in Crores)
Particulars 2009-10 2008-09
1. Gross Sales 4129.17 6019.19
Less : Excise Duty Recovered 109.98 138.39
Net Sales 4019.19 5880.80
2. Other Income 113.01 71.29
3. Total Revenue 4132.20 5952.09
4. Less : Operating Expenses 3569.51 5030.70
5. Operating Profit 562.69 921.39
6. Less : Interest 30.62 39.177. Gross Profit 532.07 882.22
8. Less : Depreciation 140.93 143.04
9. Prior Period Adjustment 2.02 (0.77)
10. Profit before taxes 389.12 739.95
11. Taxation
- Current Tax 156.46 330.37
- Deferred Tax (net) (21.93) (91.37)
- FBT 1.50
- Wealth Tax 0.12 0.12
- Excess provision for taxation written back (0.03)
12. Profit after taxes 254.47 499.36
13. Balance brought forward from last year 47.75 47.35
14. Amount available for appropriations 302.22 546.71
15. Out of which, your Directors have proposed appropriation and
transfer as under :
a) Proposed Dividend on Equity shares 35.86 35.86
b) Tax on Proposed Dividend 5.96 6.09
c) General Reserve 170.00 457.00
16. Leaving a balance in the Profit & Loss Account 90.40 47.76
B. OPERATIONAL PERFORMANCE
Your Company has achieved new heights on the operational front. During the Financial Year (FY) 2009-10,your Company has achieved the ever highest Fertilizer production of 18.13 Lacs MTs surpassing the previousrecord production of 17.78 Lacs MTs. The production of major Industrial Products like Caprolactam and
Ammonia have also touched the ever highest level of 81,151 MTs and 5.06 Lacs MTs respectively during theyear surpassing the previous record production of 79,716 MTs and 4.71 Lacs MTs respectively. The productionat the Polymers Unit is also higher as compared to the previous year. The higher producti on of Fertilizers and
Industrial Products was due to better capacity utilization of plants, improved maintenance practices andadequate availability of raw materials and intermediates. The Fertilizer sales for the FY 2009-10 was 17.98 LacsMTs as compared to 13.82 Lacs MTs during the FY 2008-09 thus registering 30% growth. Despite deficientrainfall in the home market of Gujarat and in the primary market of Maharashtra, Rajasthan and Madhya
Pradesh, your Company has achieved ever highest sales volume of fertilizers thus surpassing the previoussales record of 16.59 lacs MTs. Your Directors are pleased to inform that inspite of global meltdown, yourCompany has been able to achieve higher sales volume of its major industrial products due to its aggressive
marketing strategy.
-
8/7/2019 gsfc annual report 09-10
10/688 48th ANNUAL REPORT 2009-10
In Fiscal Terms, the Net Sales was Rs. 4019.19 Crores as compared to Rs. 5880.80 Crores during the previous ye
This was mainly due to lower prices of Phosphatic Fertilizers like DAP and APS. Similarly, the input prices of Phosphafertilizers were also lower which helped in maintaining 14% EBIDTA margin as against 15.67% during the previo
year.
The Interest cost has gone down by 22% to Rs. 30.62 Crores in FY 2009-10 as compared to Rs. 39.17 Crores f
FY 2008-09. The Profit Before Tax for the FY 2009-10 was Rs. 389.12 Crores as compared to Rs. 739.95 Crores f
the FY 2008-09. The Profit After Tax was Rs. 254.47 Crores for the FY 2009-10 as compared to Rs. 499.36 Crores f
FY 2008-09.
C. DIVIDEND
Your Directors are happy to recommend a Dividend of Rs. 4.50 per Equity Share (Previous Year Rs. 4.
per share) on 7,96,95,506 Equity Shares of Rs. 10/- each for the financial year ended 31st March, 2010. The n
outgo on account of Dividend shall be Rs. 4181.94 Lacs including Corporate Dividend Tax. The Dividend shall
paid to those members, whose name shall appear on the Register of Members of the Company on the Book Closu
Date i.e. on 11 th September, 2010.
D. CURRENT PERFORMANCE
It is heartening to report that during the First Quarter of FY 2010-11, your Company has achieved highest ever Pro
Before Tax (PBT) of Rs.160 Crores and Net Profit of Rs.109 Crores in the First Quarter of any financial year. (Previo
highest Profit Before Tax Rs.105 Crores and Net Profit Rs.71 Crores in First Quarter of F. Y. 2008-09). The EBIDT
for the Q1 of FY 2010-11 is Rs.198 Crores as compared to Rs.82 Crores in Q-1 of the FY 2009-10 which is higher
116 Crores(140%).
The sales price realization of major industrial products like Caprolactam and Nylon-6 increased in line w
international prices. This, coupled with encouraging Nutrient Based Subsidy (NBS) policy for Potassic & Phospha
fertilizers introduced by Deptt. of Fertilizers w.e.f. 01-04-10 helped in economic price realization in fertilizers als
However, the Net Sales of your Company during the first quarter of FY 2010-11 stood at Rs.1067 Crores whic
is lower by Rs.76 Crores as compared to the Net Sales of Rs.1143 Crores during 1st Quarter of FY 2009-10 main
due to lower production on account of annual turn-around of the plants and consequently lower sales volume.
With the tapping of the cheaper source of working capital finance, the interest cost during the quarter stood
Rs.4 Crores as compared to Rs.9 Crores during corresponding quarter of the previous financial year.
E. LISTING OF SHARES & DEPOSITORIES
The Equity Shares of your Company are listed on the Bombay Stock Exchange Limited (BSE) and National Sto
Exchange of India Ltd. (NSE). As approved by the shareholders, an application for voluntary delisting of Equ
Shares from Calcutta Stock Exchange Association Ltd., Kolkatta, was made, however, the approval for delisting
still awaited.
Your Directors wish to state that the Equity Shares of your Company are compulsorily traded in dematerialized fo
w.e.f. 26/06/2000. Presently, 58.15% of shares are held in electronic/dematerialised form.
F. REPORT ON CORPORATE GOVERNANCE AND MANAGEMENT DISCUSSION AND ANALYSIS REPORT T
SHAREHOLDERS
Your Company has complied with all the mandatory requirements of Corporate Governance norms as mandated
Clause 49 of the Listing Agreement with Stock Exchanges. A separate report on Corporate Governance togethwith the Certificate of M/s. S. Samdani & Associates, Company Secretaries, Vadodara forms part of this Annu
Report. The Management Discussion and Analysis report also forms part of this Annual Report.
G. FIXED DEPOSITS
Your Directors wish to report that there are 787 fixed deposits aggregating Rs.111.72 Lacs which have remain
unclaimed by Depositors, as on 31 st March, 2010. Letters reminding them to exercise their option to seek repayme
have been sent. Upto and including the date of this report, 451 deposits amounting to Rs. 69.72 Lacs have be
repaid.
During the year, the Company has transferred a sum of Rs. 9.18 Lacs being the unclaimed deposits and intere
amount thereon to the Investors Education and Protection Fund as required in terms of Section 205C of t
Companies Act, 1956.
DIRECTORS REPORT (Contd.)
-
8/7/2019 gsfc annual report 09-10
11/6848th ANNUAL REPORT 2009-10 9
H. INSURANCE
All the properties and insurable interests of the Company, including buildings, plant & machinery and stocks havebeen adequately insured. Also, as required under the Public Liability Insurance Act, 1991, your Company has taken
all the necessary insurance cover.
I. PROJECTS UNDER CLEAN DEVELOPMENT MECHANISM (CDM)
Your Company has taken up various projects for reducing emission and energy saving. These projects have also
been put up for validation and registration under the Clean Development Mechanism. This will help your Company
to earn carbon credit under Clean Development Mechanism.
Your Directors are happy to inform that a project on fossil fuel change-over and Wind Mill Power Project of 10 MW
have already got registered under CDM.
J. EXPANSION & DIVERSIFICATION
Your Company has taken up conversion of Ammonia-I Plant for production of Methanol based on technology
from M/s. Haldor Topsoe, Denmark. M/s. Project & Development India Ltd. has been appointed as consultants
for carrying out detailed engineering work for the project. The work relating to the basic design is completedand the detailed engineering and procurement activities for critical and long term delivery items have been taken
up. The project is slated to be commissio ned in the first quarter of financial year 2011-12. Your Company has
also taken up Project of modernisation of Cyclohexanone unit situated at Vadodara.
Your Company has participated in a strategic joint venture Tunisian Indian Fertil izers (TIFERT) in Tunisia with
a view to ensure consistent supply of Phosphoric Acid for optimized running of its DAP Plant at Sikka. This
project is progressing satisfactorily. The financial closure for the project has been achieved in April, 2009 and
the project is expected to go into main stream during the first quarter of Financial Year 2011-12. Further your
Company has commissioned 1500 MTPY Urea Phosphate Fertilizer project, which will help in meeting the
demand of Water Soluble Fertilizer for micro irrigation system.
Your Company has been conscious for the development of green technology and with a view to translate this
into reality, it has commissioned its first 10 MW Wind Mill Power Project at Kutch in March 2008 and added
another 12 MW Wind Mill Power Project at Kutch in January 2009. These projects are working satisfactorily
and are meeting the Companys captive power requirements as well. Encouraged by the performance of these
Wind Mill Power Projects, keeping in mind the additional requirement of power for future and the incentives
available from the Government in this regard, your Company is implementing its third Wind Mill Power Project
of 18 MW Capacity in the Porbandar District in Gujarat.
Your Directors are pleased to inform that your Companys ambitious plan for setting up larger capacity plants
at Dahej replicating its existing Baroda Unit is gaining momentum.
K. INFORMATION REGARDING CONSERVATION OF ENERGY, TECHNOLOGY ABSORPTION, FOREIGN
EXCHANGE EARNING AND OUTGO AND PARTICULARS OF EMPLOYEES ETC.
Information as required under Section 217(1)(e) of the Companies Act, 1956, read with Rule (2) of the Companies
(Disclosure of Particulars in the Report of Board of Directors) Rules, 1988 is given in Annexure "A" forming part
of this report. The Company did not have any employee falling within the purview of Section 217(2A) of the
Companies Act, 1956 and hence Particulars of Employees are not included.
L. DIRECTORS
Chairman :
Upon attaining superannuation, Shri D. Rajagopalan, IAS, retired from the services of Govt. of Gujarat on
31-12-2009 and in his place Shri A. K. Joti, IAS, Chief Secretary to the Govt. of Gujarat has been appointed
as Govt. Director and Chairman of the Company w.e.f. 19-02-2010. Your Directors place on record their
deep sense of appreciation for the dynamic leadership, valuable contribution and the vision provided by
Shri D. Rajagopalan, IAS towards the growth of the Company during his tenure as Chairman.
Change in Directors :
Shri M. M. Srivastava, IAS, Additional Chief Secretary, Finance Department, Govt. of Gujarat, has been
appointed as an Additional Director of the Company w.e.f. 29-10-2009. The Resolution for his appointment
as Rotational Director is placed for your approval.
DIRECTORS REPORT (Contd.)
-
8/7/2019 gsfc annual report 09-10
12/6810 48th ANNUAL REPORT 2009-10
Shri D. J. Pandian, IAS, Principal Secretary, Energy & Petrochemicals Dept., Govt. of Gujarat has been appoint
by the Govt. of Gujarat w.e.f. 21-01-2010, as Rotational Director in the vacancy caused due to transfer Shri S. Jagadeesan, IAS as Managing Director, Sardar Sarovar Narmada Nigam Ltd.
Pursuant to the provisions of Sections 255 & 256 of the Companies Act, 1956, Shri Vijai Kapoor anShri D. J. Pandian, IAS shall be liable to retire by rotation at the ensuing Annual General Meeting and being eligib
have offered themselves for re-appointment.
Your Directors place on record the valuable contributions made by Shri S. Jagadeesan, IAS during his tenure Director of the Company.
The appropriate resolutions for re-appointment of Directors are placed for the approval of shareholders.
Your Directors also take this opportuni ty to welcome the new Directors on the Board of your Company.
M. DIRECTORS RESPONSIBILITY STATEMENT
As required under Section 217 (2AA) of the Companies Act, 1956, the Directors hereby confirm that:
i) In the preparation of the Annual Accounts, the applicable Accounting Standards have been followed and th
no material departures have been made from the same;ii) The appropriate accounting policies have been selected and applied consistently and judgments and estimat
have been made that are reasonable and prudent, so as to give a true and fair view of the state of affa
of the Company as at 31st March, 2010 and of the profit of the Company for the period fro1st April, 2009 to 31st March, 2010;
iii) Proper and sufficient care has been taken for the maintenance of adequate accounting records in accordan
with the provisions of the Companies Act, 1956 for safeguarding the assets of the Company and for preventiand detecting fraud and other irregularities; and
iv) The Annual Accounts have been prepared on a Going Concern basis.
N. AUDITORS
The provisions of Section 619B of the Companies Act, 1956 continue to apply to your Company. The Comptrol
& Auditor General of India (CAG) has appointed M/s. S. C. Bapna & Associates, Chartered Accountants, Vadodafor the Financial Year 2009-10 and M/s. Prakash Chandra Jain & Co., Chartered Accountants, Vadodara, for th
Financial Year 2010-11 for carrying out audit of accounts of the Company at its Corporate Office, Sikka Unit anBaroda Fertilizernagar Plants. M/s Khedkar Shah & Soni, Chartered Accountants, Vadodara have been appoint
as Branch Auditors for the audit of accounts of the Companys Polymers Unit and Fibre Unit for the Financial Ye2009-10 and 2010-11. Your Directors recommend the approval of Resolution for fixation of remuneration to thStatutory Auditors and Branch Auditors for the F.Y. 2010-11.
Pursuant to the directive from the Dept. of Company Affairs regarding appointment of Cost Auditor, M/s DiwanjAssociates, Cost Accountants, Vadodara have been appointed as the Cost Auditor for the Financial Ye2010-11. The approval of the Central Government for the said appointment has been received.
Your Company has also appointed M/s. Haribhakti & Co., Chartered Accountants, Mumbai as Internal Auditors fcarrying out the Internal Audit for its Baroda Unit and Sikka Unit. M/s. K. N. Mehta & Co., Chartered AccountanVadodara and M/s. Parikh, Mehta & Associates, Chartered Accountants, Vadodara have been appointed as Intern
Auditors for the Companys Fibre Unit and Polymers Unit respectively.
O. AUDITORS REPORT
With regard to observations of Statutory Auditors contained in their Report, the Company has provided clarificatioin Schedule 22 Notes on Accounts.
P. ENVIRONMENTAL PROTECTION
Your Directors wish to reiterate that GSFCs business strategies consciously factor in the conservation a
prevention of the environment as its supreme goal. There is zero effluent discharge system for the proceeffluent emanating from the Fertilizer Group of Plants. Your Company has in place two full fledged EfflueTreatment Plants (ETP) and the treated effluents, conforming to Pollution Control Board norms, are discharginto sea through the channel of M/s. Effluent Channel Project Ltd. Your Company is also going for revampi
of its Effluent Treatment Plants to increase their treatment capacity. Further the treated sewage arising frothe Companys township is used as manure for the gardening and maintenance of green sports pavilion anmassive tree plantation. Your Company has latest computerized ambient air monitoring station at the centof the Complex which monitors the ambient air quality on continuous basis.
DIRECTORS REPORT (Contd.)
-
8/7/2019 gsfc annual report 09-10
13/6848th ANNUAL REPORT 2009-10 11
DIRECTORS REPORT (Contd.)
Your Directors are happy to inform that your Company has been conferred with ICC Aditya Birla Award for
Best Responsible Care Committed Company for the year 2008, 1
st
prize in Fertilizer Sector in National EnergyConservation Awards 2009 from Ministry of Power GOI.
Your Directors are pleased to inform that your Company has won the Gold Trophy of SCOPE Meritorious Awardfor Environmental Excellence & Sustainable Development for the year 2008-09.
As a part of Environment Management System, our conscious efforts are on towards waste minimization,
recycling and conservation of natural resources to the maximum possible extent for the protection of environment.
Apart from controlling pollution, your Company maintains 261 Acres of Green Belt Area within GSFC premises
and this constitutes more than one third of its total land area. These green belts are the natural abode of vari etyof birds like peacocks, ducks etc. In the year 2009, your Company has planted aroun d one Lac Banyan, Pipaland Neem trees as a part of its forestation drive. Your Companys encapsulated chalk heap which has beenconverted into a beautiful garden admeasuring about 14 Hectares is being well maintained.
Q. HUMAN RESOURCES
The strength of your Company lies in its team of competent and motivated personnel. This has made possible
for your Company to make significant strides in all areas of its functioning. The Employees have from timeto time taken up the challenge to improve upon the performance of its plants through efficiency, productivityand economy. Your Directors are happy to place on record their sincere appreciation for the unstinted effortsand contribution put in by the employees of the Company.
The Company has also continued its endeavor to impart appropriate and relevant training to its employees at
various levels with a view to equip them to take up the challenges that are ahead and to enhance theirperformance in the overall interest of the Company.
The industrial relations remained cordial during the year.
R. ACKNOWLEDGEMENTS
Your Directors place on record their appreciation for the overwhelming co-operation and assistance received from
the Government of Gujarat, Government of India, Bank of Baroda and other Banks and agencies. Your Directorsalso wish to express their gratitude to the investors for their continued support and faith reposed in the Company.
For and on behalf of the Board
Sd/-
Place : Fertilizernagar A. K. JotiDate : 31st July, 2010 Chairman
-
8/7/2019 gsfc annual report 09-10
14/6812 48th ANNUAL REPORT 2009-10
ANNEXURE TO THE DIRECTORS REPORT
A) CONSERVATION OF ENERGY
Measures taken at Baroda Unit :
1) Installation of small capacity make up water pump at Co-Generation III Plant.
Due to low load operation requirement, make up waterpump was operating at low capacity. Small capacity, low
head pump installed in place of high capacity, high headpump to reduce power consumption. It resulted into annualpower saving of 1.60 Lacs units (Rs. 6.03 Lacs).
2) Power saving by stopping continuous operation of highcapacity Caustic pump (P-1046) in Caprolactam-II Plant.
A high capacity caustic pump common for continuous and
occasional consumers is provided which runs on continuousbasis. Small capacity pump for continuous supply toconsumers, installed. It resulted into stoppage of highercapacity pump except for occasional running. It resulted intoannual power saving of 0.48 Lac units (Rs. 1.81 Lacs).
3) Changing of CT fan blade from Aluminium to FRP-Hollow
blades at Ammonia storage Plant.
Existing Aluminium blades replaced by hollow FRP blades toreduce power consumption. It resulted into annual power
saving of 0.32 Lac units (Rs. 1.21 Lacs).
Above mentioned measures resulted into aggregate annual savingat a rate of 2.40 Lacs units (Rs. 9.05 Lacs).
Measures taken at Sikka Unit :
1) Direct supply of Ammonia from Rail/Road tanker to plantin place of Ammonia storage tank.
Instead of unloading Rail/Road tankers of Ammonia intostorage tank, consumption of bulk quantity of NH3 fromRail/Road tankersstarted into DAP Plant directly. It resulted intoannual power saving of 14.33 Lacs units (Rs. 60.34 Lacs).
2) Separation of instrument air and process air header.
Modification resulted into lower air loses due to reduction of
load on air dryer. This enabled to reduce runninghours of aircompressor.It resulted into annual power saving of1.37 Lacs units (Rs. 5.77 Lacs).
3) Energy saving by using Energy efficient lighting sources.
Replacing35 nos. of 160 W MLL lamps by 125 W HPMVlamps resulted into saving of 0.0448 Lac units per annum.
Replacing 116 nos. 50 W tube lights by 32 W CFL lampsresulted into saving of 0.0754 Lac units per annum.
Above mentioned measures resulted into aggregate annualsaving of 0.12 Lac units (Rs. 0.54 Lac).
4) Energy saving by using Natural sunlight.
Replacement of opaque asbestos sheet at certain interval atBagging floor shed by transparent FRP sheet and creatingopenings in building for ventilation has improved illuminationat Bagging floor in Bagging Plant resulting into switching offthe 12 Numbers of 125 HPMV light points during day time.It resulted into annual power saving of 0.027 Lac units
(Rs. 0.11 Lac).
Above mentioned measures resulted into aggregate annual savingat a rate of 15.85 Lacs units (Rs. 66.76 Lacs).
Measures taken at Fiber Unit :
1) Stoppage of one cooling water circulation pump fcooling tower.
Optimization of process parameters done in NFY productiarea which had resulted into reduction in load of refrigeratisystem and in turn allows the stoppage of one cooling wa
circulation pump. It resulted into annual power saving6.9 Lacs units (Rs. 27.32 Lacs).
2) Air supply blower motor replacement in Draw twistiair-conditioning area.
In Draw twisting air-conditioning plant, 130 KW motor of supply blower replaced by spare 75 KW motor. It resultinto annual power saving of 0.91 Lac units (Rs. 3.6 Lacs
3) Primary pump replacement in Brine Refrigeration Syste
Existing low efficiency primary pump in Brine RefrigeratiSystem replaced by energy efficient pump. It resulted iannual power saving of 0.75 Lac units (Rs. 2.97 Lacs).
4) Quench air supply blower pulley replacement for SpinniLine Nos. 1, 4 & 5.
Pulleys of Motors of Quench air supply blowers of SpinniLine Nos. 1,4 & 5 are replaced by smaller diameter i.e. fro200 mm dia. to 190 mm dia. and from 290 mm dia to 260 mdia, respectively. It resulted into annual power saving 0.75 Lac units (Rs. 2.97 Lacs).
5) Stoppage of supply blower in conditioning area.
Conditioning Hall A.C. requirement was fulfilled with supof blower of Draw Twisting area. Due to this, supply blow
for conditioning hall area was stopped. It resulted into annupower saving of 0.34 Lac units (Rs. 1.35 Lacs).
6) Quench air supply fan motor replacement in SpinniLine No. 1.
Existing 55 KW motor for quench air supply fan of SpinniLine No. 1 replaced by 30 KW motor. It resulted into annpower saving of 0.30 Lac unit (Rs. 1.19 Lacs).
7) Stoppage of pressure balancing blower in NFY productiarea.
Pressure balancing blower for conditioning air of SpinnLine Nos. 2 & 3 stopped with optimization of different
pressure. It resulted into annual power saving of 0.28 Lunits (Rs. 1.11 Lacs).
8) Boiler feed water pump replacement.
Existing low efficiency boiler feed water pump for steam boiNo. 1 replaced by high efficiency pump to reduce powconsumption. It resulted into annual power saving 0.18 Lac units (Rs. 0.71 Lac).
9) Nitrogen Circulation Blower motor replacement.
In Chips drying system of Polymerization unit, existi18.5 KW motor for Nitrogen Circulation Blower replaced
15 KW motor. It resulted into annual power saving 0.16 Lac units (Rs. 0.63 Lacs).
10) Soft water pump replacement.
Existing low efficiency pump for soft water supply replacby energy efficient pump. It resulted into annual power savof 0.065 Lac units (Rs. 0.26 Lac).
Annexure A
PARTICULARS REQUIRED UNDER THE COMPANIES (DISCLOSURES OF PARTICULARS IN THE REPORT OF DIRECTORS) RULES,1988
-
8/7/2019 gsfc annual report 09-10
15/6848th ANNUAL REPORT 2009-10 13
11) Replacement of potable water pump.
High efficiency pump installed in potable water supply system.It resulted into annual power saving of 0.065 Lac units(Rs. 0.26 Lac).
Above mentioned measures resulted into aggregate annual savingat a rate of 10.70 Lacs units (Rs. 42.37 Lacs).
Measures under consideration at Baroda Unit :
1) Utilization of LP Steam of Ammonia-IV Plant in Co-Gen-IIIPlant Deaerator.
Presently 14 Bar steam is utilized in Co-Gen-III PlantDeaerator after reducing pressure. LPS at Ammonia-IV Plantis in excess and is being vented. About 6~7 MT/Hr of steamcan be utilized in Co-Gen-III Deaerator and to that extent NGconsumption for generation of 14 Bar steam can be reduced.This will also reduce steam venting at Ammonia-IV Plant.The anticipated NG saving is 41.6 Lacs SM3 /Year
(Rs. 328.6 Lacs).2) MP steam generation from HP condensate blow down at
Ammonia-IV Plant.
Blow down of HP condensate is being carried out in LP flashdrum. As LPS is in excess, it is vented. It is proposed togenerate first MPS (37 Bar) and then LPS by flashing HPcondensate blow down. It will reduce NG consumption forequivalent steam generation at boiler. This will also reducesteam venting at Ammonia-IV Plant. The anticipatedNG saving is 10 Lacs SM3 /Year (Rs. 75.8 Lacs).
3) Use of H2
from PSA as fuel in reformer.
It is proposed to use pure H 2 as fuel in reformer whichotherwise being flared during no availability of pure NG andReformer is in running condition. This will reduce NGconsumption in Reformer accordingly. The anticipated NGsaving is 1.14 Lacs SM3 for each incident (Rs. 8.97 Lacs).
4) Utilization of Hydrogen bearing off gases ofCaprolactam-I Plant in boiler.
The off gases of Benzene hydrogenation section of Capro-IAnone Plant contains about 18% H 2. Provisions for usingthese off gases as fuel in new boiler (~55 MT/Hr capacity)being erected is made. System is under installation andanticipated annual NG fuel saving is 4.37 Lacs SM3(Rs. 34.5 Lacs).
5) Installation of VAHP-2 in CEP-HAS Plant.
While considering sizing of stand by VAHP unit, highercapacity unit is proposed to take load of ANONE AHU having162 TR capacity operating on electric power. This will reducepower for running A.C. unit making use of excess low pressuresteam. The anticipated power saving is 6.80 Lacs units /Year(Rs. 25.6 Lacs).
6) Installation of VAHP in Nylon-6 Plant.
It is considered to install VAHP Unit in Nylon-6 Plant usingavailable steam from Ammonia-IV Plant which is in excess.Anticipated annual power saving is 14.13 Lacs unitsequivalent to Rs. 53.27 Lacs.
Measures under consideration at Sikka Unit :
1) Use of small capacity, spare air compressor.
Khosla make small capacity air compressor lying spare atBagging Plant is shifted and being installed at Utility servicesplant for use in place of higher capacity air compressor duringless compressed air requirement. The anticipated annualpower saving is 0.46 Lac units (Rs.1.92 Lacs).
Measures under consideration at Fiber Unit :
1) Installation of Variable speed drive screw compressorfor Air.
It is planned to install screw compressor equipped with variable
speed drive mechanism. The annual saving in power is
estimated at 15.0 Lacs units (Rs. 59.4 Lacs).
2) Replacement of existing, inefficient Refrigeration
compressors with efficient compressors.
It is planned to replace existing chillers by energy efficient
screw type refrigeration compressors for Chilled water as well
as Air Compressor unit. The annual saving in power is
estimated at 11.0 Lacs units (Rs. 43.56 Lacs).
3) Installation of variable frequency drive system on AHU
blowers.
Optimization of air handling units to reduce air flow and cooling
load with installation of variable frequency drive mechanismfor various blowers. The annual saving of power is estimated
at 2.1 Lacs units (Rs. 8.3 Lacs).
Measures under consideration at Polymers Unit :
1) Increasing impeller size of chilled water pump and stopping
operation of second pump.
At Polymers Unit, two chilled water pumps are running to
cater chilled water requirement of the Unit. It is considered to
increase impeller size of one pump and stop operation of
second pump. Anticipated annual power saving is 0.56 Lac
Units equivalent to Rs. 2.51 Lacs.
B) CONSERVATION OF RAW MATERIALS AND CHEMICALS
Measures taken at Baroda Unit :
1) Diverting CW blow down to Fire water tank.
CW blow down was diverted to Fire water reservoir. It resultedinto reduction of Raw water makeup to Fire water reservoir by
400 M3/day, equivalent to Rs.17.7 Lacs/Yr.
2) Recovery of COD bearing effluent generated in
Ammonia-IV Plant.
COD bearing streams from CO2 removal section in Ammonia-
IV Plant were getting drained. Scheme commissioned to
divert above mentioned streams back to process in place of
fresh DMW make up. It resulted into saving of DMW by
2400 M3/Yr, equivalent to Rs.1.52 Lacs/Yr.
Measures taken at Sikka Unit :
1) Installation of scrubber storage transfer system.
Installation of scrubber liquor storage, transfer system at
DD-1 unit of Bagging Plant for storage of scrubber liquor
generated in bagging Plant during DAP Plant shut downcondition & consuming the scrubber liquor during DAP Plant
running. In addition to environment improvement, this resulted
to material saving of 4.23 MT P2O
5+1.72 MT NH3 annually
equivalent to Rs.1.75 Lacs. @ Rs. 34081/MT P2O
5and
Rs. 17599/MT NH3.
Measures under consideration at Sikka Unit :
1) Recovery of waste water by using at cooler and tail gas
scrubber.
Recovering waste water and using it in cooler and tail gas
scrubber in Train A of DAP Plant. This will reduce fresh water
make up annual requirement in the plant by 49500 M3.
Estimated saving is Rs. 2.23 Lacs/ Yr.
ANNEXURE TO THE DIRECTORS REPORT (Contd.)
-
8/7/2019 gsfc annual report 09-10
16/6814 48th ANNUAL REPORT 2009-10
ANNEXURE TO THE DIRECTORS REPORT (Contd.)
FORM-A
Form for disclosure of particulars with respect to
Conservation of Energy : 2009-10
A. POWER AND FUEL CONSUMPTION
PARTICULARS 2009-10 2008-09
1. ELECTRICITY
(A) PURCHASE
UNIT : MWH 446118 392605
AMOUNT Rs. in Lacs 16277.14 19248.75
Rate Rs. / KWH 3.65 4.90
(B) Own GenerationUnit : MWH 140989 162029
KWH Per Ltr. of
Fuel/Gas 2.45 2.92
Cost Rs./KWH 3.72 3.28
2. LSHS
QUANTITY MTs 6916 5412
Amount Rs. in Lacs 1627.40 1779.33
Average Rate Rs./MT 23530.11 32877.49
3. NATURAL GAS
Quantity in 000 SM3 551946 145039
Amount Rs. in Lacs 42858.97 11680.71
Average Rate 1000/SM3 7765.07 8053.50
TOTAL ENERGY CONSUMPTION AND ENERGYCONSUMPTION PER UNIT OF PRODUCTION
C) TECHNOLOGY ABSORPTION
EFFORTS MADE IN TECHNOLOGY ABSORPTIONAs per enclosed FORM B
D) FOREIGN EXCHANGE USED AND EARNED : 2009-1
Foreign Exchange Outgo :
(i) C.I.F. VALUE OF IMPORTS Rs. Lac
(a) Raw Materials 134938.3
(b) Stores & Spares 2253.7
(c ) Capital Goods 0.0
TOTAL (i) 137192.1
(ii) EXPENDITURE IN FOREIGN CURRENCY
(a) Interest 369.5
(b) Technical Asstt./Know How 69.7
(c) Others 7579.4
TOTAL (ii) 8018.7
TOTAL (i) + (ii) 145210.8
Foreign Exchange Earned :
FOB VALUE OF EXPORT OF Rs. Lac
Caprolactam 4604.8
MEK Oxime 2420.6
Nylon 6 28.0
Ammonium Sulphate 1272.3
Nylon 6 Chips 7.3
TOTAL 8333.2
B. CONSUMPTION PER UNIT OF PRODUCTION
Sr. Product Power Steam Natural Gas
No.
2009-10 2008-09 2009-10 2008-09 2009-10 2008-09
KWH KWH MTs MTs SM3 SM3
1 Ammonia 329 390 0.972* 0.779* 856 8462 Sulphuric Acid 34 36 0.803* 0.828* 0.092 0.2653 Phosphoric Acid 273 236 0.744 1.100 0.628 0.4604 Urea 185 195 1.544 1.627 - -5 DAP 0 75 0.000 0.028 5 56 ASP 37 36 0.002 0.003 5 57 Melamine 1765 1749 6.789 6.320 328 3168 Caprolactam (Old) 2328 2424 11.829 11.374 101 929 Caprolactam (Exp.) 1315 1397 6.838 7.869 38 3310 Nylon 6 988 997 1.939 1.957 - -11 ACH 519 612 0.924 1.012 77 11512 Monomer 699 813 2.936 3.220 - -13 MAA 442 569 4.139 4.470 - -14 AS 27 33 0.240 0.291 - -15 Sheets 1651 1594 7.500 8.265 - -16 Pellets 605 569 1.080 1.197 - -17 DAP (Sikka Unit) 50 53 0.015 0.017 - -18 NPK(12:32:16)(Sikka Unit) 0 56 0.000 0.023 - -19 NPK(10:26:26)(Sikka Unit) 0 0 0.000 0.000 - 20 Nylon Chips 721 690 - - - -21 Nylon Filament Yarn 4597 4623 - - - -
* Indicate Export from Plants
-
8/7/2019 gsfc annual report 09-10
17/6848th ANNUAL REPORT 2009-10 15
ANNEXURE TO THE DIRECTORS REPORT (Contd.)
FORM-B
Form for disclosure of particulars with respect to Technology Absorption : 2009-10RESEARCH & DEVELOPMENT (R & D)
(1) SPECIFIC AREAS, IN WHICH R&D IS CARRIED OUT :
The areas are Polymers & Fibers, Environment Control &Waste Management, Value added Product(s)/ Derivativesfrom existing corporate products, specialized agri-inputsfor improving quality and yield of agricultural outputalongwith conservation of water, support to plant andMarketing for problem solving, Quality & Process Efficiencyimprovement and assurance, Customization of Products,Corrosion & Material Evaluation, Failure investigation ofComponents of Plant Equipment & Machinery, Consultancyand Analytical Service to Plants and Outside Agencies.
(2) BENEFITS DERIVED :
(A) Development of New Products :
1. 1500 MTPY capacity plant for R&D developed watersoluble fertil izer- Urea Phosphate has beencommissioned and put under regular production and153.08 MTs Urea Phosphate fertilizers was producedand sold.
2. Generation of Bench scale & Pilot scale process datafor setting up commercial scale HX Crystal project.
3. Around 156-MTs of 19-19-19, one of the most popularwater-soluble fertilizers has been manufactured basedon in-house process know-how and released in themarket under 'SARDAR NUTRISOL' brand.
4. 56,850-Packets of GOG approved ChelatedMicronutrient have been produced based on in-houseprocess know-how and released in the market under'SARDAR Micro Mix : G-4' brand.
5. Development of Nylon-6 f ibers as secondaryreinforcement for reinforced concrete. Commerciallot quantity prepared for market seeding purpose.
6. Development, Customization & Commercialization ofFlame Retardant Nylon-6 having various levels ofFR Rating.
7. Development & commercialization of high impact gradeof Nylon-6.
8. Development of new colour formulation for Nylon-6.
(B) Customization & Market support Services, PlantSupport Activities :
1. Plant support services rendered by R&D improvedoperational efficiency of various plants.
2. Testing of initial performance of various catalysts usedby the plant provided valuable support to plants in
selection and approval of those catalysts.3. The analytical and microbiology group of R&D is
providing critical support to R&D Projects, pilot plantproduction activities, monitoring of cooling towers of11 plants, non-routine analysis of plant samples,carrying out experimental work required for troubleshooting in plants and testing of catalyst properties.R&D also develops suitable analytical / microbiologicalmethods to cater to the above requirements.
4. On-line corrosion monitoring and Microbial monitoringof cooing tower water at various plants by R&Dresulted in efficient running of plants and cost effectivecooling water treatment.
5. Monitoring of Cooling Towers for Biocide Efficacy.
6. Supporting marketing for the entering new marketsegments, developing new customized polymerproducts through compounding route for satisfyingcustomers
(3) FUTURE PLAN OF ACTION :
1. Installations of 1200 MTs per year capacity HydroxylAmine Sulphate Crystal Plant after completion ofrequired formalities and detail engineering.
2. Trouble shooting and stabilization of the production ofUrea Phosphates.
3. To develop new Nylon-6 and acrylic based value addedproducts having synergy with companys existing lineand business and associate with marketing forapplication and technical support and with processplants for commercialization of the developedtechnologies, quality improvement and assurance forpolymer products of the company.
4. To continue to extend support services to the processplants for process trouble shooting, product qualityupgradation and improving process efficiency etc..
5. Commercialization of Nylon-6 fiber as secondaryreinforcement for Reinforced concrete as well asdeveloping value added Nylon-6 fiber for specialtyapplications.
6. To provide catalyst testing service to plants to evaluateinitial performance of various catalysts before beingloaded into the plants.
7. To introduce more FCO approved grades of water-soluble fertilizers under 'SARDAR NUTRISOL' Brandfor drip and foliar/soil applications subject toMarketings approval.
(4) EXPENDITURE ON RESEACH & DEVELOPMENT :
Rs in Lacs
(a) Capital 34.64
(b) Recurring 1288.25
(c) Total 1322.89
(d) Total R & D Expenditure as a
percentage of Net Sales 0.33%
TECHNOLOGY ABSORPTION, ADOPTION AND
INNOVATIONIn house development of process technology for an efficientmicro irrigation system compatible fertilizer named UreaPhosphate (nutrient content 17-44-00) was accomplished. Thetechnology has been commercialized with installation of a semicommercial 1500 MT/Year capacity plant based on in housedesigning and engineering.
GSFC becomes the first company to manufacture UreaPhosphate and get the approval as FCO approved fertilizers inIndia.
Information regarding technology imported during the last fiveyears : NIL
-
8/7/2019 gsfc annual report 09-10
18/6816 48th ANNUAL REPORT 2009-10
MANAGEMENT DISCUSSION AND ANALYSIS REPORT
CAUTIONARY STATEMENT
Some of the statements made in this Management Discussion & Analysis Report regarding the economic and financconditions and the results of operations of the Company, the Companys objectives, expectations and predictions m
be futuristic within the meaning of applicable laws/regulations. These statements are based on assumptions a
expectations of events that may or may not materialize in the future.
The Company does not guarantee that the assumptions and expectations are accurate and/or will materialize. T
Company does not assume responsibility to publicly amend, modify or revise the statements made therein nor does
assume any liability for them. Actual performance may vary substantially from that expressed in the foregoing statemen
The investors are, therefore, cautioned and are requested to take considered decisions with respect to these matte
1 MACRO ECONOMIC OVERVIEW
The Financial Year (FY) 2009-10 commenced on a difficult note since there was significant slow down in the econom
growth rates especially in the second half of the previous Financial Year (FY) 2008-09. This was a fall out of the financ
crisis that started in the industrialized countries and spread to the economies across the world and the Indian econom
also experienced a slow down. Indias f iscal deficit shot up to the alarming level of 6.8% during the FY 2009-10. The
was also a severe drought during 2009-10 which resulted in a negative impact on the growth. The continued recessiin the developed world, for the major part of FY 2009-10 meant a sluggish export performance which mellowed t
financial flows into the economy. However, gradually, the economy posted some recovery in terms of overall growth a
also certain basic fundamentals.
As per the GDP estimates for 2009-10 released by Central Statistical Organization, the growth rate of Gross Domes
Product (GDP) at factor cost at constant prices was found to be 7.2% in 2009-10 as compared to 6.7% in 2008-0
The growth in Industrial & Service sectors was 8.2% and 8.7% respectively as compared to 3.9% and 9.8% in 2008-0
The reversal came despite a negative growth rate of (-) 0.2% in the agricultural output as compared to positive 1.6%
2008-09. The overall growth rate in the industrial production index showed a significant recovery to 10.4% during t
year 2009-10 compared to 2.8% during the previous year. Core infrastructure supportive sectors grew at 5.5%
2009-10 as compared to 3.0% in 2008-09.
Other sectors also showed significant recovery. The annual growth rate of the mining sector, manufacturing sector a
electricity sector dur ing FY 2009-10 was 9.70%, 10.90% and 6.00% respectively as against 2.60%, 2.80% and 2.80
during the corresponding period of the previous year.
The agriculture sector experienced a major set back due to severe drought during kharif season of 2009. The droug
as well as floods in some parts of southern India affected the kharif production, especially the rice productio
The monsoon played the truant and the country received only 689 mm of rainfall upto September 2009 as compared
the normal rainfall of 892 mm. The overall rainfall deficit was 23% and was the worst in last 37 years. There was seve
drought in almost 44% of countrys 626 districts. Out of 36 meteorological sub-divisions, rainfall was deficient/ scanty
23 sub-divisions, normal in 10 and excess in only 3 sub-divisions. The food bowl region of North India also receiv
deficient rainfall. This seriously affected the agricultural production. The food-grain production declined fro
234.47 million tons in 2008-09 to 218.19 million tons in 2009-10. Production of wheat in the Rabi season is also expect
to be lower by about 3% to 5% due to lower output from Northern states.
The pro-active policies initiated by the Government in providing substantial fiscal stimulus to counter the negative effe
of the global slow down paid dividends and though almost the entire world was in the grip of a recession, the Indi
economy was a silver lining of positive growth.
The Gujarat state, where all the production units of the Company are located, has shown outstanding economic grow
during the last five years with an average annual growth rate of 12.70% in gross state domestic product, surpassing t
growth targets of the Planning Commission. The per capita income of Gujarat is Rs. 45,773 as compared to the nation
average of Rs. 33,283. The state continues to retain the tag of the most industry friendly state of the count
As per Assocham report, Gujarat is at the top in new investments for the calendar year 2009 with investment plans wo
Rs. 2.45 Lacs Crores.
Thrust on Agriculture :
The agriculture sector is crucial for Indias economy and development and a very important driver of macro econom
performance. It is a critical element of the national growth strategy. In line with the process of economic developme
the share of the agricultural sector in the GDP has witnessed decline over the years, but even today approximately 52
of the total Indian population depends on the agriculture for livelihood. The Eleventh Five Year Plan lays great
emphasis on the reversal of decline in agricultural growth rates and has identified the areas whereby 4% annual grow
-
8/7/2019 gsfc annual report 09-10
19/6848th ANNUAL REPORT 2009-10 17
MANAGEMENT DISCUSSION AND ANALYSIS REPORT (Contd.)
could be achieved. Thrust on increasing area under irrigation, favorable terms of trade to farmers, better and cheaper
access to credit, more investment in agriculture, use of latest technology including the use of new and specialtyfertilizers for application based on soil report would certainly help in giving momentum to the agricultural growth.
Gujarat is the primary market of the Company for selling fertilizers. The programs, including Krushi Mahotsava,
implemented by the State Government have helped immensely in improving agriculture and agricultural productiv ityand this has enabled the Company to sell 9.00 Lacs tons of fertil izers in Gujarat, which is 51% of i ts national fertilizersales of 17.78 Lacs tons. In the recent years, the State has emerged to be the fastest growing state in the field of
agriculture, with an annual growth rate of 11.20%. The performance of Gujarat in the agricultural sector noted to be thebest in the Country. The state has emerged as a major producer of cash crops such as cotton as well as other crops.
Despite adverse economic and rainfall scenario, GSFC was able to sell 17.78 Lacs tons of fertilizers, which is the ever
highest sales, thus, surpassing even the record sales of 16.48 Lacs tons of FY 2006-07. Out of the total sales of7.60 Lacs tons of DAP, GSFC sold 4.77 Lacs tons in Gujarat. GSFC, thus, had the highest market share of 63% inGujarat for DAP, followed by IFFCO (25%) and Indian Potash (5%). In case of Ammonium Phosphate Sulphate (APS)
also, GSFC has the highest market share of 57%, followed by GNFC at 43%.
2 OPPORTUNITIES & THREATS
2.1 Nutrient Based Subsidy Policy :
During the year, in a major move, the Government of India announced the implementation of a Nutrient Based Subsidy(NBS) policy (w.e.f. 01.04.2010) for Phosphatic and Potassic fertilizers. Until March 2009-10, subsidy on
P & K products was being paid on the basis of Import Parity Price (IPP) on month to month basis.
Under the new regime of NBS, subsidy which would be paid will be determined on the basis of the quantity of thenutrients. The following subsidy levels were announced :- Nitrogen Rs.23.227/Kg, Phosphorus Rs.26.276/Kg, PotashRs.24.487/Kg and Sulphur Rs.1.784/Kg. These rates would remain in force for the entire financial year. The selling price
of various fertilizers could be determined by the companies/suppliers based on market forces. Thus, under the newNBS regime, there would be a fixed subsidy for products covered under the NBS policy and MRP wouldbe floating. Urea continued under the retention price scheme, however, its MRP was raised by 10%, i.e. fromRs. 4,830 per MT to Rs. 5,310 per MT (w.e.f. 01.04.2010).
This policy was introduced by the Government of India with a view to encourage balanced use of nutrients andconsequently improve agricultural productivity in the country. The policy also sought to bring a check on the level of
fertilizer subsidies which had risen to high levels due to raw material costs in the yester years. Additional subsidy wasalso announced on Boron fortified fertilizers (Rs.300 per Ton) and Zinc fortified fertilizers (Rs. 500 per Ton).
Simultaneously, the imports of major complex fertilizers was opened and placed under Open General License (OGL).
However, import of urea remained canalized. Ammonium Sulphate produced indigenously has been covered undersubsidy fold, whereas no subsidy is payable on the imported Ammonium Sulphate.
Freight subsidy on decontrolled fertilizers under NBS for rail movement would be paid as per actual claim. The freight
for primary road movement would be subject to lower of the actual claim or equivalent rail freight subject to maximumdistance of 500 kms.
Manufacturers of customized & mixture fertilizers would get the subsidized fertilizers as an input to manufacture such
fertilizers. However, no subsidy will be paid on sales of customized & mixture fertilizers.
2.2 Impact of Nutrient Based Subsidy (NBS) :
Effectively, under the new policy, the Government of India has declared subsidy of Rs. 16,268 per ton which is based
on the imported price of DAP inclusive of Freight (i.e.CFR) of USD 500 per ton. If in the international market, price ofimported DAP goes below USD 500 per tone, the imports may increase as this will be profitable to the importers. Thiswill add to the competitionfor indigenous suppliers whose cost of production is based on price of imported PhosphoricAcid (PA) and Ammonia.
The inclusion of import of complex fertil izers such as APS under the open general license may result in increase of theirimports. The increased availability of complex fertilizers may enhance the sales of these grades in the country.
With this policy change, GSFCs APS (20-20-0-13) will now face competition from imports. It is estimated that23.00 Lacs Tons of NPK might be imported in the coming 12 months in the country. Area specific as well as soil specificgrades may be imported by the importers. On the positive side, this may improve the soil health and may lead to
balanced use of fertilizers.
Ammonium Sulphate (AS) has been covered under the NBS subsidy fold. The subsidy announced for AS isRs. 5,195 per ton. Before announcement of NBS, the MRP fixed by Government of India was high (Rs. 10,350/ MT)
-
8/7/2019 gsfc annual report 09-10
20/6818 48th ANNUAL REPORT 2009-10
MANAGEMENT DISCUSSION AND ANALYSIS REPORT (Contd.)
RAW MATERIAL & FERTILISE
2008
901
1707
404
5
0100200300400500600700800900
1000110012001300
14001500160017001800
DAP (C & F) PA (C & F)
Price
USDperMT
and had affected its off take in a big way. GSFC has opted out of the subsidy scheme and hence the freight subsidy
not available to GSFC. Now, the primary railway freight on Ammonium Sulphate is admissible.Since the subsidy is also given on secondary nutrients like Sulphur and Micro nutrients such as Zinc, Boron etc, nefertilizer grades fortified with Zinc & Boron will be developed by the fertilizer companies under the NBS regime.
The price of Phosphatic and Potassic fertil izers has gone up during the year in the range of 6% to 8%. Since Governmeof India has raised the MRP of Urea by 10%, there will not be much resistance from farmers to absorb this price riseP & K fertilizers and hence their demand in the market may continue to grow at the present pace.
Since the mixture/customized fertilizer manufacturers will get subsidized raw material, their production will get a booespecially in state like Maharashtra, where mixture of fertilizers are used in large quantities.
2.3 Raw Material Price Behavior :
The international prices of finished fertilizers & raw materials witnessed an unprecedented rise as well as fall during tFY 2008-09. As per the Fertilizer Market Bulletin, the CFR prices of Phosphoric Acid (PA) which was USD 1789 per tin April 2008 went up to USD 2310 per ton in August 08. However, since September 2008, the prices started to declisharply and touched the level of USD 760 per ton. This trend slowed down during FY 2009-10. Average CFR prices
Phosphoric Acid declined from USD 1707 per ton in 2008-09 to USD 580 per ton in 2009-10.Sulphur prices also experienced a steep rise during 2008-09. Average prices of Sulphur, touched a peak of USD 409 pton in 2008-09. However, subsequently it declined to USD 95 per ton, while average Rock Phosphate prices declinfrom USD 350 per ton in FY 2008-09 to USD 115 per ton during FY 2009-10.
Average price of Ammonia in 2008-09 was USD 458 per ton. It declined in 2009-10 and reached the level of USD 303 pton, i.e. a decline of 34%. The decline in prices was less as compared to other raw materials.
Average CFR prices of DAP declined from USD 901 per ton to USD 404 per ton in FY 2009-10. Since the subsidy to tDAP manufacturers was paid on Import Parity, the subsidy inflow to GSFC declined in FY 2009-10 as comparedFY 2008-09. Regular supplies of PA and Rock Phosphate to manufacturers at reasonable prices as comparedFY 2008-09 gave a boost to production of DAP in the country including your Company. Production of DAP in the counincreased to 42.40 Lacs tons in FY 2009-10 as against 29.90 Lacs tons in FY 2008-09. As a result, the imports declinfrom 61.90 Lacs tons in 2008-09 to 57.70 Lacs tons in FY 2009-10.
Average Prices of Raw materials and Finished Products
(USD / MT)Product 2008-09 2009-10 % Increase/Decrease
DAP (C & F) 901 404 -55PA (C & F) 1707 580 -66
Rock Phosphate. (C & F) 350 115 -67Sulphur (C & F) 409 95 -76Ammonia (C & F) 458 303 -34
Source: FMB Various Issues
-
8/7/2019 gsfc annual report 09-10
21/6848th ANNUAL REPORT 2009-10 19
MANAGEMENT DISCUSSION AND ANALYSIS REPORT (Contd.)
2.4 Industrial Products :
The year as a whole witnessed consistent growth in demand for Industrial Products as the market was favorable. Theimprovement witnessed in the second half of the FY 2008-09 continued and the demand remained strong as compared
to the previous year. This has helped in increase of both sales volume and realization of all the industrial products,
especially Caprolactam, which accounts approx. 49% of total Industr ial products sales. The demand across all the end
use segments such as automobile, textile, infrastructure, housing and consumer durables, showed an encouraging
trend, enabling better market penetration. The Industrial Products net sales turnover for the FY 2009-10 has increased
by Rs.75.11 Crores, i.e. registering an increase of 6.33% over FY 2008-09. During the year under review, the rupee
remained fairly stable , thus no major impact on this account was observed.
3 BUSINESS SEGMENT UPDATE
Product-wise performance in terms of production and sales for last ten years is tabulated below:
PARTICULARS Unit 2009-10 2008-09 2007-08 2006-07 2005-06 2004-05 2003-04 2002-03 2001-02 2000-01
PRODUCTION
FERTILIZERS MT 1812570 1469470 1594703 1778070 1528265 1392018 1275764 1146668 1360661 1292283
CAPROLACTAM MT 81151 70913 79716 79666 78120 77150 68489 60004 59546 65051
NYLON-6 MT 8715 8783 8683 9145 7975 8691 7264 5424 5487 6698
MELAMINE MT 13735 13655 14741 15335 15323 14823 15237 6643 11521 10527
ARGON 000NM3 3464 3183 3129 2912 3105 2245 3029 2756 2785 2218
MONOMER MT 4597 3469 4156 4449 4053 4739 4472 3586 2665 4012
ACRYLIC SHEETS MT 687 552 642 664 574 398 498 469 358 745
ACRYLIC PELLETS MT 1937 1887 2023 2082 1936 1813 2159 2114 2010 2119
NYLON FILAMENT YARN MT 4433 4498 4705 5169 5779 6069 5159 5311 4084 5850
NYLON CHIPS MT 4652 5097 5950 4084 4546 3816 3553 2283 2073 3025
SALES
FERTILIZERS* MT 1797894 1382463 1602782 1659381 1405491 1373289 1325562 1221559 1330856 1183105
CAPROLACTAM* MT 62650 53859 59710 63419 60660 57910 52528 46991 47707 60504
NYLON-6 MT 9189 8496 9138 9806 8285 9017 6613 6307 5777 5254
MELAMINE MT 13695 14115 14804 15563 16717 15373 13417 10619 10062 17462
ARGON 000NM3 3464 3184 3138 2911 3111 2251 3033 2759 2817 2179
MONOMER* MT 2282 1374 1706 2090 1762 2976 1610 1309 828 1315
ACRYLIC SHEETS MT 696 584 598 692 590 460 588 600 555 503
ACRYLIC PELLETS MT 1883 1916 2038 2178 1890 2012 1938 2149 2361 1909
NYLONE FILAMENT YARN MT 4081 4740 4391 4788 5619 5493 4948 5251 3964 5404
NYLON CHIPS MT 4596 5500 5737 4095 4312 4133 3324 2351 2048 2642
*excluding captive consumption
3.1 Turnover :
In the Year 2009-10, turnover of the Company (including trading activities) was Rs. 4019.19 Crores as against
Rs. 5880.80 Crores in 2008-09. The reduction in turnover, despite increase in the volume was mainly due to lower pricesof Phosphatic fertilizers, i.e. DAP and APS. The sale of fertilizers was Rs. 2740.45 Crores. For industrial products, theCompany registered net sales of Rs.1149.46 Crores as compared to Rs. 1057.10 Crores in the previous year.
-
8/7/2019 gsfc annual report 09-10
22/6820 48th ANNUAL REPORT 2009-10
MANAGEMENT DISCUSSION AND ANALYSIS REPORT (Contd.)
The following table depicts the proportion of Fertilizer products segment and Industrial Products Segment in the net sal
of the Company during the last two years:-2009-10 2008-09
Rs. Crores % Rs. Crores %
Fertilizers segment 2869.73 71.40 4823.70 82.02
Industrial Products Segment 1149.46 28.60 1057.10 17.98
Total 4019.19 100.00 5880.80 100.00
3.2 Exports :
MEK-Oxime and Caprolactam are the main export products of your Company. During the F.Y. 2009-10, the exportCaprolactam was to the tune of 4896 MTs as against 4955 MTs in F.Y. 2008-09. MEK-Oxime has been exported to abo40 countries and the export quantity was 2337 MTs in 2009-10 compared to 2695 MTs in 2008-09. The decreasemainly attributed to the slump demand particularly from European Union.
4 OUTLOOK FOR 2010-11
Under the NBS policy, subsidy is fixed on a per kg of nutrient basis for the whole year covering Phosphatic and Potassfertilizers. The sale price is allowed to be free but these fertilizers are on OGL for imports. Thus, the MRP of theproducts is expected to change according to the raw material prices as well as the finished product prices in tinternational market. There is, however, an informal pressure from the Government on the industry to keep the fertilizprices to the farmers under control. The NBS policy may increase the volatility in the profit margins of the FertilizCompanies. The cost efficient players will be better placed to combat the impact of this volatility. Industry has welcomthis policy. However, the real impl ications would be known only over a period of time.
GSFC has got a good product mix but considering the NBS policy opportunity of encouraging the use of NP/NPfertilizers, your Company needs to have the facilities to produce DAP and NP/NPK grades at Sikka. This is beiconsidered by your Company.
The subsidy on micro-nutrient fortified fertilizers encourages, fertilizer manufacturers to undertake the productionsuch fertilizers. Your Company is also examining the possibilities to manufacture such special ferti lizers.
Given the great emphasis on agriculture in the Union Budget 2010-11, with measures such as easy access to credit, extemphasis on irrigation and micro irrigation, rural infrastructure and soil testing, there may be significant growth opportunitie
Farmers of Gujarat generally prefer indigenous fertilizers to imported fertilizers. Besides the demand for NP/NPproducts, demand of DAP is likely to continue at the present level or grow. Considering your Companys presencethese potential markets and its significant brand preference, there may not be much difficulty in selling DAThe inclusion of Ammonium Sulphate in the subsidy fold will significantly help your Company to increase its sales volumYour Company has well established market for APS and since subsidy is given on the Sulphur content, the policy whave a favorable impact on the Company.
5 RISK MANAGEMENT
Your Company is exposed to various types of risks associated with the fertilizers and chemicals businesThis includes the fluctuation in the input prices and changes in pricing policy by the Govt. of India. Volatility in fuel pricalso has impact on the profitability of the Company. The availability of natural gas continues to be of prime importance production of fertilizers.
While the prices of the raw materials of viz. Ammonia, Sulphur and Phosphoric Acid are rising in the international markthe price of DAP has started softening. With fixed subsidy and floating MRP, markets may experience frequent changin the price of domestic Phosphatic fertilizers. In the current scenario, good and widely distributed rainfall, smooth acomparatively cheaper availability of raw materials and the timely reimbursement of subsidy by the Govt. of India woube of prime importance for the Company to sustain its operations profitably.
Given this scenario, the Company is focusing on efficiency improvement, higher production levels, efficiencies in ramaterial procurement, reduction in marketing and distribution costs, production of various complex grades and propproduct/segment market strategies to maximize the sales and achieve better contribution from its product basket.
6 DISCUSSION ON FINANCIAL PERFORMANCE
During the year 2009-10, your Company generated Rs.553 Crores cash from its operations before accounting fchanges in the working capital and realized Rs.393 Crores through sales of fertilizer bonds issued by the GovernmeThe Company has financed new capital expenditure of Rs.153 Crores and invested Rs.236 Crores in other Companie
-
8/7/2019 gsfc annual report 09-10
23/6848th ANNUAL REPORT 2009-10 21
MANAGEMENT DISCUSSION AND ANALYSIS REPORT (Contd.)
At the end of Financial Year 2008-09, the Company has net borrowings of Rs.688 Crores and has parked surplus fund
amounting to Rs.558 Crores.The Company was able to reduce the average cost of borrowing from 7.25% during last year (FY 2008-09) to 4.81%during the year under report (FY 2009-10), through judicious mix of different sources of short term borrowings.
The Company continued to maintain a healthy credit rating of PR1+ for short term borrowings and Care AA for long termborrowings from CARE and F1+ for short term borrowing and AA with stable outlook from FITCH.
The earning per share of the Company is Rs. 31.93 in 2009-10 as compared to Rs. 62.66 in 2008-09. The Debt EquityRatio at the end of FY 2009-10 was 0.32:1 as compared to 0.17:1 at end of FY 2008-09. The book value per share as onMarch 31, 2010 was Rs. 269 as compared to Rs. 242 on March 31, 2009.
7 PROMOTIONAL ACTIVITIES
Your Company is a leader in banana tissue culture plants in the State of Gujarat since the year 1995. It is also producingand marketing different types of Bio-fertilizers since the year 1984 and Biotech products since 2006. Your Companyalso produces and markets certified seeds of notified hybrids and varieties having disease and pest resistance whichhave been developed in-house.
With a view to improve soil health, your Company analyzes a large number of soil and water samples and provides
recommendations for balanced use of NPK along with micro nutrients, use of soil amendments and judicious use of waterfor maintaining the health of soil.
Sardar Agri-net cell of your Company has equipped farmers of Gujarat with excellent knowledge base on new technologiesfor various crops for improving cultivation and productivity. It does dissemination of information throughout the year.Your Company has organized three regular and one re-orientation Farm Youth Training Programs during the year topromote high-tech agri-concepts amongst the farmers, who are now decision makers.
Publication of KRISHI JIVAN, a unique monthly magazine having one of the highest circulation, fosters disseminatingknowledge to farmers on various activities of agriculture and acts as a link for transfer of technology from lab to land.
8 SAFETY, HEALTH AND ENVIRONMENT
Your Company has won the prestigious International Safety Award 2009 for the 3rd Consecutive Yearfrom theworlds renowned advisory body- British Safety Council, U.K. This award is conferred for taking significant leaps in thefield of Health & Safety.
Your Company continues to give special attention and priority to the Safety & Health of its employees. GSFC BarodaUnit has achieved 443 Reportable Accident Free Days between the period from 13/09/2008 and 30/11/2009, thus
surpassing its own previous record of 288 days accident free operations. This is the best performance ever since theCompanys inception. GSFC is not complacent with this achievement and targets to break even this record.
Your Company was conferred the prestigious ICC Aditya Birla Award for Best Responsible Care Committed Companyfor the year 2008 at Mumbai on 4 th December, 2009. GSFC is the first fertilizer Company to receive this award.
Your Company has taken initiative for BS EN 16001:2009 Energy Management System Certification. This system willput your Company on the path of improvement in the field of energy efficiency and to reduce Green House Gases(GHGs) emission through systematic management of energy.
Your Company is periodically imparting training to young villagers from surrounding villages on the hazards and riskassociated with the chemicals that are being handled by it. Every year around 150 villagers are trained on various topicsincluding emergency preparedness and safety procedures followed by GSFC and the role of vil lagers during emergencies.
Your Company is also conscious about the environment and the ecological balance and is promoting horticulturalactivities. It has taken the initiative to make GSFC more green by planting a large number of trees such as Banyan,Pipal, and Neem, thus also supporting the initiative of Govt. of Gujarat in this direction.
For encouraging the urban population to increase greenery and maintaining the ecological balance, your Company has
sponsored Fruit, Flower & Vegetable shows in association with Baroda Agri Horti Committee and also sponsored FlowerShows in association with Society for Clean Environment (SOCLEEN). It has participated in the competitions and wonaccolades and appreciation.
9 HUMAN RESOURCES
Regarding this, the shareholders are requested to refer to point no. Q on page no. 11 of the Directors report which formsthe part of this Annual Report.
For and on behalf of the Board
Sd/-
Place : Fertilizernagar A. K. JotiDate : 31st July, 2010 Chairman
-
8/7/2019 gsfc annual report 09-10
24/6822 48th ANNUAL REPORT 2009-10
(PURSUANT TO CLAUSE 49 OF THE LISTING AGREEMENT)
1 THE PHILOSOPHYGood Governance is all about commitment to values and ethical business conduct. It is also about managing an organizatioits corporate and other structures, its culture, policies and the manner in which it deals with various stakeholders. Propeaccurate and timely disclosure of information regarding the affairs of the company, its financial position, performancownership and governance is an indispensable part of the philosophy of Corporate Governance.
Our Perspective for Good Governance :
The Companys Corporate Governance philosophy rests on the following canons :
1 Follow laws of the land, not only in letter, but also in spirit.
2 Candid and truthful disclosure of information.
3 Understanding distinction between personal conveniences and Companys resources and properties.
4 Management is not the Owner, it is the Trustee to its stakeholders.
The Companys Corporate Governance Policy emanates from the very basics of the Shareholders own institution (Companwhich they own, no matter what number of shares they hold. The apex think tank of the Company viz. the Board of Directobelieves that there should be proper admixture of responsibility and accountability of the Board vis--vis its vital ingredienlike Consumers, Investors, Employees and Regulators.
The Company firmly believes and proclaims that the shareholders are the very cause of and the ultimate beneficiaries of business and are the epicenter to its all round growth.
Our Endeavor :
The Board of Directors of the Company are proud to assert that much before the formal code on Corporate Governance, its present form, was thought of, GSFC was following it in its literal sense.
The enhancement of Shareholders value was, is and shall continue to remain GSFCs top-most priority.
The Company is managed and contro