Celano

Model: 53109000-99Owner's Manual

Portable Gas Grill

1

1. Never operate this appliance unattended.

Failure to follow these instructions could resultin fire or explosion, which could cause property

damage, personal injury or death.

! DANGER

4. If a fire should occur, keep away from the appliance and immediately call your fire dept.

3. Never operate this appliance within 25 feet (7.5 m) of any flammable liquid.

2. Do not store spare LP cylinders within 10 feet (3.05 m) of this appliance.

1. Shut off gas to the appliance.If you smell gas:

Failure to follow these instructions could resultin fire or explosion, which could cause property

damage, personal injury or death.

Read and Follow all warnings and instructionsbefore assembling and using the appliance.

This Instruction Manual contains important information necessary for the proper assembly and

safe use of the appliance.

! DANGER

4. If odor continues, immediately call your gas supplier or your fire department.

3. Open Lid.2. Extinguish any open flame.

5. Never put grill in travel or storage mode immediately after use. Allow unit to cool to the touch.

2

When using propane grills, basic safety precautions should alwaysbe followed to reduce the risk of fire and injury to persons, including the following:

1. Read and follow all instructions before using the grill. 2. Do not touch hot surfaces. Use handles or knobs and oven mitts or potholders. 3. Keep children and pets away from the grill at all times. 4. This grill is not for use by children. 5. Do not leave this grill unattended while in use. 6. Do not move the grill while in use. Allow to cool before moving, putting on or taking off parts, and before cleaning and storing. 7. To disconnect, turn Temperature Control Knob to LOCK/OFF. 8. Do not operate any grill after the grill malfunctions, or has been dropped or damaged in any manner. Contact Consumer services for return authorization, examination, repair or adjustment. 9. The use of accessory attachments not recommended by the grill manufacturer may cause injuries.10. This grill is for outdoor use only. NEVER operate grill in enclosed areas, as this could lead to gas accumulating from a leak, causing an explosion or a carbon monoxide buildup which could result in injury death. DO NOT USE in garages, sheds or any enclosed area.11. Do not use grill for other than intended use.12. Extreme caution must be used when moving a grill containing hot oil or other hot liquids. Allow liquid to cool before removing. Do not remove Cooking Grid and Flame Tamer from Grill Body until Grill is cool.13. Do not attempt to dislodge food or clean the grill when it is hot.14. Fuel, such as charcoal briquettes, are not to be used with this grill.

WARNING: A risk of fire or explosion exists in all grills. Readthis manual before use. Failure to follow all instructions mayresult in serious personal injury, property damage, or death.

READ AND SAVE THESE INSTRUCTIONSImportant Safeguards

3

1. All users of this grill must read and understand this Owner's Manual before operating this grill. 2. When using this grill, provide adequate air space above and on all sides for air circulation. 3. IMPORTANT: Minimum clearance or 12 inches around all sides of the grill should always be maintained and the appliance shall not be located under overhead unprotected combustible construction. 4. If this grill begins to malfunction during use, immediately turn the Temperature Control Knob to LOCK/OFF. Do not use or attempt to repair. 5. The use of alcohol, prescription or non-prescription drugs may impair the consumer's ability to properly assemble or safely operate the grill. 6. In the event of rain while cooking with oil/grease, cover the cooking grid immediately and turn off the grill burner and gas supply. Do not attempt to move the grill or cooking grid. 7. When cooking, the grill must be on a level and stable surface in an area clear of combustible materials. 8. Make sure the Temperature Control Knob is in the LOCK/OFF position when placing the cooking grid into position. 9. The grill is not intended for and should never be used as a heater.10. Keep grill area clear and free from combustible materials, gasoline and other flammable liquids.

FOR OUTDOOR USE ONLY

THIS GRILL IS NOT FOR COMMERCIAL USE

KEEP THIS MANUAL FOR FUTURE REFERENCE

Additional Important SafeguardsCAUTION: This grill generates heat and escaping steamduring use. Proper precautions must be taken to prevent therisk of burns, fires or other damage to person or property. Use of protective oven mitts or gloves are recommended.

4

Additional Important Safeguards Cont. 11. Do not obstruct the flow of combustion and ventilation air. 12. Always open the lid before lighting your grill. 13. Do not attempt to disconnect the gas fitting while the unit is in operation. 14. Do not wear clothing with loose flowing sleeves while lighting or using the grill. 15. Use barbecue utensils with long, heat-resistant handles. 16. The grill should never face directly into the wind. 17. Do not operate the grill in a high-traffic area. 18. After use, allow the grill to cool completely before cleaning. 19. We recommend storing grill indoors or, if unable to store indoors, always cover grill with protective cover. Always keep out of the reach of children. 20. IMPORTANT: Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened. 21. The grill unit should not be any closer than 12 inches to the RV or any other structure other than the frame, from any one side of the grill. 22. Grill shall be installed on the opposite side from the fuel distribution or dispensing system of the RV. 23. Installation shall preclude the possibility of appliance operation or gas flow when the appliance is in its storage position.

5

Frame and Grill Setup

2. Hang frame on bracket and unfold grill support. (See Figures Below)

1. Unfold Frame and secure hinges into locked position (See Figures Below)

Pull hinge out to Lock

Before First Use1. This grill is assembled as a complete unit, please follow all instructions for setup and use.2. Remove the grill and any packaging materials from the shipping carton.3. Place the grill on a flat, level surface.4. Unfold grill legs.

6

Frame and Grill Setup Cont.

5. Attach Gas line to male plug of grill unit. Pull back on socket, slide socket over male plug and lock into place.

4. Set grill onto support frame and lock intoplace. (See Figures Below)

3. Unfold grill legs and secure into locked position (See Figures Below)

Lock grill legsinto Tabs

Pull Back

Secure Socket onto male plug

6

7

Do not use this appliance under extended awnings. Failureto comply could result in a fire or property damage.

! DANGER

Grill installation must conform with local codes, or inthe absence of local codes, with the National Fuel GasCode, ANSI Z223.I/NFPA 54, Storage and Handling ofLiquefied Petroleum Gases, ANSI/NFPA 58 or CSA B149.I,Natural Gas and Propane Installation Code.

Use grill only with LP (propane) gas. Use grill only with the regulator/valve assembly supplied.

Do not operate the grill if there is a gas leak present.

Do not enlarge orifice or burner ports when cleaning theburner.

If you smell gas, turn Temperature Control Knob to LOCK/OFFto shut off gas to the grill. Extinguish any open flame and open lid. If odor continues, immediately call your gas supplier oryour local fire department.

Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other grill.

If the grill is not in use, the Temperature Control Knob must be turned to LOCK/OFF to shut off.

Do not store a spare LP-gas cylinder under or near this appliance. If the instructions are not followed exactly, a fire causing death or serious injury can occur.

8

How to Use the Celano Propane Grill

WARNING: If burner does not light within 5 seconds,turn Temperature Control Knob to the LOCK/OFFposition, wait 5 minutes and repeat the lighting procedures.

Lighting Instructions:

3. Visually check burner flames.

1. Open lid before lighting.2. Secure a paper match to the Match Holder, light the match and place through the Flame Viewing Hole (on the left side) to the nearest burner ports. (See Fig. 1 and Fig. 2)

Fig. 2

Fig. 1

LOW

HIGH

9

CAUTION: Do not leave any cooking utensils on theCooking Grid surface while it is still hot.

Grilling Instructions:1. Unfold legs into position. Open lid prior to lighting grill.2. Secure unit to outside bracket.3. Connect Female quick-connect socket to male connection of valve assembly.3. Light burner and turn temperature Control Knob from HIGH to LOW. Check the flame through the flame viewing hole to make sure the burner is lit. (See Fig. 3)4. To Preheat: Close the Grill Lid and preheat on high about 8 minutes during the first use, you may notice a slight odor caused by the curing of the paint and parts.

IMPORTANT: Do not close the Lid for more than 8 minutes unless there is food on the grill.

5. After 8 minute preheat period, carefully open the lid and place food onto the Cooking Grid. Cook until done, turning food at least once halfway through cooking time for most foods. Adjust flame with Temperature Control Knob as needed.

6. When finished cooking, turn Temperature Control Knob to the LOCK/OFF position.7. Allow the grill to cool before disassembling and cleaning.

10

Safety Precautions: Test for leaks outdoors in well ventilated areas.

Testing for Leaks:

1. Mix a couple of tablespoons of liquid detergent with an equal amount of water. Use mild soap and water. DO NOT USE HOUSEHOLD CLEANING AGENTS.2. Be sure that the Temperature Control Knob is in the LOCK/OFF position.3. Use a clean paint brush to brush soapy solution onto connection between grill and gas supply, and watch for bubbles.4. If bubbles form or if a bubble grows, there is a leak. Retighten connection and repeat step (2) and (3).

Test all gas connections for leaks before using your grill.Test for leaks every time you connect the gas supply.Do not smoke while checking for leaks.

Do not use an open flame to check for gas leaks. Be surethere are no sparks or open flames in the area while you check for gas leaks. This can result in a fire or explosion which can cause serious bodily injury or death, anddamage to property.

Note: If you cannot stop a leak, remove the gas line and checkfor damage, dirt and debris at the connection and socket of gas supply. Remove any obstruction that may be found and repeat leak test.

11

Cleaning and CareAll the cleaning and maintenance should be done when grill is cooland with fuel supply turned off at the LP cylinder. DO NOT clean anypart of grill in a self-cleaning oven.

Cleaning: Burning-off the grill after every use about 15 minutes willkeep excessive food residue from building up.

CAUTION: Grill surfaces are hot during use. Allow CookingGrid, and Grill Body to cool completely before handling andcleaning.

1. Turn the Temperature Control Knob to the LOCK/OFF position and allow the grill to cool before disassembling and cleaning.2. Remove the Cooking Grid and Flame Tamer. 3. Wash the Cooking Grid and Flame Tamer with warm, soapy water and a plastic scouring pad. Rinse and dry thoroughly. Do not use steel wool, coarse scouring pads or harsh abrasive cleaners. If necessary, use a nylon bristle brush to loosen hardened food particles.4. Wash exterior parts with soft sponge and warm clean water. Non-abrasive cleaners may also be used.5. Use a damp cloth to clean the inside of the lid and Grill Body.6. If disassembly is required for cleaning, be sure that burner is in line with the orifice and back in its correct position. Make sure all parts are assembled and back to their original location.

12

Warranty Information

Maintenance and Care

C-Land Manufacturing, Inc. warrants, the Celano grill for a periodof (1) year from the date of the original purchase, this grill to be free from defects in material and workmanship under normal conditionsof normal use.

1. Remove Cooking Gird and Flame Tamer.2. Wash parts with warm soapy water.3. Dry with a paper towel4. Visually check burner flames.5. Check and clean burner/venturi tubes for insects and insect nest. A clogged tube can lead to a fire beneath the appliance.

Clean and inspect hose before each use. If there is evidence of abrasion, wear cuts or leaks, the hose must be replaced prior togrill being put back into operation. The replacement hose assembly shall be that specified by the RV manufacturer.

Use hose assembly supplied with the grill. Check burnerperiodically to make sure the flame is consistent and uniform around the entire burner. You can view the flame through theviewing hole on the left side. If the flame is not burning properlycleaning may be required.

Replacement parts can be obtained by contacting C-land Mfg.at 352.624.9667.

Manufactured by: C-Land Manufacturing2409 SE 26th ST

Ocala, Florida 34479