FORDSON TRACTOR

REPLACEMENT PARTS

CATALOGUE

Updated February 2016

Distributed by

DISCOUNT TRACTOR PARTS

Ph 0800 872 272

PO Box 70059 Ranui, West Auckland. 0655 E mail sales@discounttractorparts.co.nz

Yester Years Tractor Parts Specialist All prices listed are plus GST and subject to change

Some parts indent only

COOLING SYSTEM

Water Pump $112.00 Water Pump Kit $70.20 Pump pulley Narrow V $80.00 Thermostat $13.20 Radiator Cap large $18.50 Radiator cap Std long $15.00 Fan Belt narrow $12.00 Radiator inboard fixings $580 Radiator outboard fixings $618 Radiator drain tap $55.00 Fan Blades $12.50ea Radiator hoses Top rad. Hose $17.50 Bottom rad hose $28.60 Filler hose $14.50 Complete rad. hose kit $52.00

FRONT HUB

Seal $17.31 Hub $135.86 Hub Nut $10.50 Brg & Seal Kit $105 Inner wheel brg $68.80 Outer wheel brg $55.00 Wheel Nut $2.00

WHEEL RIMS

Wheel Rims Rim suit 6.00x 16 tyre $88.00 Rim suit 7.50x 16 tyre $108.00

Prices plus GST @ subject to change

Page 1

Front Axle Parts King pin LHS $168.00 King pin RHS $168.00 Felt seal $2.34 Top bush $14.50 Lower bush $14.50 Thrust brg $32.64 Repair kit (per side) $52.50 Steering arm RH $91.98 Steering arm LH $130.63 Bolt $2.50 Nut $0.50

STEERING BOX

Steering Box Parts Steering Wheel $65 Steering Wheel Nut $8.75 ( UNF thread ) Steering Wheel Washer $5.50 Rocker Shaft $155 Rocker Shaft Seal $12 Shaft Assembly 610mm $280 Shaft Assembly 657mm $275 Shaft brgs top & bottom $18.50 ea Roller $14

FRONT AXLE STEERING Drag link repair kit ( socket & cups ) $102.64 ea Drag link ball peg $43.68ea Forked tie rod LH & RH $129.30ea Tie Rod Repair Kit $24 (Contains 1 pin & 1 bush) Steering Box Drag Link $155

CYLINDER HEAD Inlet Valve $13.50 Exhaust Valve $17.70 Valve Spring 7 coil $4.00 Valve Spring 8 coil $4.00 Valve Guide $4.50 Camshaft $325 Injector Washer $1.22 Cam Follower $13.50

EXHAUST Muffler $57.50 Ex Manifold (in line studs) $240.00 Ex Manifold Gasket for above $15 set Ex Manifold (offset studs) $280 Ex Manifold Gasket for above $15 set Elbow $70.50 Flange Gasket $4.70 Page 2 Prices plus gst and subject to change

ENGINE REBUILD KITS. Kit A Kit B Kit C Fordson Major 100mm 1 1/4” gudgeon pin > $838 $920 $1420 Fordson Power Major 100mm 1 3/8”pin > $830 $920 $1420 Fordson Super Major 100mm 1 3/8” pin > $848 $945 $1420 ( liner has 2 x o rings ) Kit A contains :- 4 x cylinder liner kits, big end brgs, gudgeon bushes and pins, gaskets Kit B contains :- all of Kit A plus main brgs, crankshaft seals & thrusts Kit C contains :- all of the above plus a new crankshaft.

ENGINE BLOCK PARTS Liner Kit Major $164 ea Liner Kit Power Major $174 ea Liner Kit Super Major $180 ea Piston 1 1/4” pin $89 each Piston 1 3/8” pin $84 each Piston Ring Set $27.50 per cy Liner single O-ring $76.50 each Liner double O-ring $76.50 each Main bearing set $75 Big end bearing set $50 Crankshaft Thrusts $36 Gudgeon Bush 1 1/4” $17 each Gudgeon Bush 1 3/8” $13.50 each Crankshaft thrust washer set std $36 Crankshaft with 2” timing gear $610 Crankshaft with 2.015” timing gear $556 Crankshaft Gear 2.015 ID $104 Bearings available in std,.010,.020,.030

GASKETS Head Gasket $50 Head Gasket Set Major $81 Bottom O/Haul Set $85 Full engine set $120 Sump Gasket $24.00 Tappet cover gasket $17.50 Timing cover seal $12.00 Rear Main Seal $16.50 set Cylinder liner Seal (Major PM ) $6.50 ea Cylinder liner seal (Super Major) $14pr

FILTERS

Pre Cleaner Bowl Type $55 Pre Cleaner Flat Top $49.50

( 2 1/4” inlet x175mm length) Oil Filter 154mm long $10

Oil Filter 138mm long $11.70 Oil Filter 118mm long $10.50

Fuel Filter 33mm Centre Hole $12.90 Fuel Filter 19mm Centre Hole $15.26

Hydraulic Filter $24.50 Air Cleaner to engine hose $40.00

Filler Hose Support $48

Page 3 Prices plus gst & subject to change

OIL PUMPS & FUEL SYSTEM Oil Pump (with relief valve) $195 Injector washer Fordson $1.25 Lift pump with glass bowl. $ 79 Lift Pump (no bowl ) $69 Lift pump repair Kit (2 types) $23.40 Fuel water trap bowl assembly $32.50 Fuel Tap Alternative Fordson $28.50 Injector Pump Drive Pad $40 Injector Pump Diaphragm $18.50 Injector Pipe set Super Major $75 Injector Pump Coupler assembly $60 Fordson Fuel Tank Cap $17.20

CLUTCH KITS AND PARTS Model Kit Drive Pressure Release Spigot Plate Plate Bearing Bearing Single Plate 11”x10spl $394 $82 $254 $74 $13.50 Single Plate 12”x10spl $460 $79 $340 $74 $13.50 Dual Plate Kit $1400 $79 $100 $13.50 > Double plate non standard conversion Replaces obsolete original pressure plate 12” PTO Plate suits original clutch $187 Single Plate 13”x10spl $350 $325 $72.50 $15 Clutch Pedal Return Spring Non live drive tractors $12 Live drive tractors $12

REAR AXLE

Seal Outer axle $45 Wheel Stud $6.60 Rear Wheel Nut $6.60

Gear Lever Knobs 3/8”UNF Thread $11 5/16” UNF Thread $5

PTO SEALS 89x44.5x19mm $25

89x54x12mm $15.50 63.8x36.8x18.6mm $19.50

Page 4 Prices plus gst and subject to change

BRAKES Disc Linings $62.50 (4 facings) Disc Linings $65.50 (4 facings) Set brake shoes (4 shoes) $295 Drum Brake Linings $72.00 (4 facings) Set of 4 brake shoes $312 Drum brake spring set $51 per side Disc brake dust cover $12 RH Brake Cable $117 LH Brake Cable $117 Brake Activator Spring $1.75 ea Brake Activator Ball $4.50 ea Brake pedal return spring Major $13,20 ea Brake Pedal return Spring SM $13.20 ea

HYDRAULIC SEALS AND GASKETS Hydraulic overhaul o ring kit $48 Kit contains lift cover, cylinder and pump seals Lift piston seal $22 Hydraulic oil filter Major, 100mm long, $35 Sump plug $16.50

REAR LINKAGE Linkage Drawbar Cat 2 $68 Weld on Cat 2 Ball End $24 Levelling Box Non Orig $195 Levelling Box Orig type $420 Yoke & fork orig type $275 Top Link $45

Prices plus gst and subject to change

PANELS Grill set without headlight holes $195 Grill Set with headlight holes $195 Retainer clip takes grill stud $2.00 Footplate Set Major,P Major $312 Footplate Set Super Major $370 Footstep Major, P Major $77.50 Front Cowl (Grill extra) $1012.00 Mudguard early design $994pr Mudguard late design $994 pr Toolbox $95 Bonnet Handle S/Major $65 Major & P Major $65 Latch Assembly $22.50 Bonnet Panel Set $838 Bonnet Rubber/Rivet Set $51 PTO Safety Guard $142

ELECTRICAL Starter Solenoid $35.60 Ignition/light switch $48 Generator 11 amp $155 Regulator bullet terminals $72 Regulator Spade Terminals $72.50 45amp Alternator with pulley & regulator to convert from generator $185 Starter Start lever boot $21.50 Starter Solenoid (barrel type) $45.50 Starter solenoid latter model type $35.60 Wiring Harness Major $205 P/Major S/Major $268 Neutral Safety Switch $33.50 Heavy Duty M50 Lucas TVR Starter motor with attached solenoid $298 (key start)

GAUGES Temp gauge oil & gene light $93.50 Rev Counter Major (C/wise) $68.60 Rev Counter Cable equal size end nuts,1460mm $68.80 Rev counter cable different size end nuts,1250mm $54.00

Page 6 Prices plus gst and subject to change

LIGHTS 1) Headlight (base mount) $48 ea 2) Side Mount Headlights $45ea 3) Side light Guard Mount $94 ea Side Light Lens White $16 ea 4) Mudguard Mount Tail Light $95 ea 5) Red Lens Only $54 6) No Plate Holder $140 Light Socket Rubber $48

SEATS Pan Seat $153 Seat Backrest & Base Cushion Set $125

Manual & Handbooks Fordson Operations Repair Manual $53 (Copy of original Ford Manual) Fordson Major Operator Handbook $55 Full workshop repair manual Includes Fordson & Dexta $89

BADGES Major Nose Cone Emblem $40 Super Major Nose Cone Emblem $247 Ford 8N Chrome $ Red Background $85 Bonnet Badges Major $185 Power Major $196 Ford 8N $42.50 Super Major Side Badge $226

Prices plus gst and subject to change

1 2

3

4

5 6