FORD 172 Point Inspection
4
Original: Owner Copy: Dealer Prior to delivery of this vehicle, the following checks and inspections were performed. Any item(s) that did not pass the 172-point inspection have been replaced or repaired. Dealership Name: Dealership Name: Year/Make/Model: Color: Mileage: Stock Number: VIN: R.O. # 1. VEHICLE HISTORY Passed Repaired Replaced N/A 1. VIN Inspection 2. Service Recalls (OASIS) Performed 3. Vehicle History Report Obtained 4. Scheduled Maintenance Performed 5. Vehicle Emissions Sticker (Applicable States) 3. VEHICLE EXTERIOR Passed Repaired Replaced N/A 3A BODY PANELS AND BUMPERS 23. No Evidence of Flood, Fire, Major or Hail Damage 24. Body Panel Inspection 25. Bumper/Fascia Inspection 3B DOORS, HOOD, DECKLID, TAILGATE 26. Doors, Hood, Decklid/Tailgate and Roof Inspection 27. Doors, Hood, Decklid/Tailgate Alignment 28. Automatic/Manual Release Mechanisms, Hinges, Prop Rod/Gas Struts Operate Properly 29. Power Liſtgate, Power-Sliding Door Operation 3C GRILLE, TRIM AND ROOF RACK 30. Grille, Trim and Roof Rack Inspection 31. Deployable Running Boards 3D GLASS AND OUTSIDE MIRRORS 32. Windshield, Side and Rear-Window Glass Inspection 2. ROAD TEST Passed Repaired Replaced N/A 6. Engine Starts and Idles Properly 7. Remote Start System Operation 8. Engine Accelerates and Cruises Properly/Smoothly 9. Engine Noise Normal (Cold/Hot & High/Low Speeds) 10. Auto/Manual Transmission/Transaxle Operation – Cold and Hot Shiſt Quality 11. Auto/Manual Transmission/Transaxle Noise Normal – Cold and Hot 12. Shiſt Interlock Operates Properly 13. Drive Axle/Transfer Case Operation Noise Normal 14. Clutch Operates Properly 15. Steers Normally (Response, Centering and Free Play) 16. Body and Suspension Squeaks and Rattles 17. Struts/Shocks Operate Properly 18. Brakes/ABS Operate Properly 19. Cruise Control 20. Gauges Operate Properly 21. Driver Select/Memory Profile Systems 22. No Abnormal Wind Noise 3. VEHICLE EXTERIOR continued Passed Repaired Replaced N/A 3D GLASS AND OUTSIDE MIRRORS 33. Wiper Blade Replacement 34. Outside Mirror Inspection 3E EXTERIOR LIGHTS 35. Front-End Exterior Lights 36. Back-End Exterior Lights 37. Side Exterior Lights 38. Hazard Lights 39. Auto On/Off Lighting 40. Trailer Lamp Connector Operation 4. VEHICLE INTERIOR Passed Repaired Replaced N/A 4A AIRBAG AND SAFETY BELTS 41. Airbags 42. Safety Belts 4B AUDIO AND ALARM SYSTEMS 43. Radio, Cassette, CD and Speakers 44. Antenna 45. Alarm/Theſt-Deterrent System 46. Navigation System 4C HEAT/VENT/AC/DEFOG/DEFROST 47. Air Conditioning System 48. Heating System 49. Defog/Defrost 4D INTERIOR AMENITIES 50. Clock 51. Tilt/Telescopic Steering Wheel 52. Steering Column Lock 53. Steering Wheel Controls 54. Horn 55. Warning Chimes 56. Instrument Panel and Warning Lights 57. Wipers 58. Washers 59. Interior Courtesy, Dome and Map Lights 60. Manual Outside Rearview Mirrors, Power Outside Rearview Mirrors and Auto-dimming Rearview Mirror 61. BLIS ® (Blind Spot Information System) 62. Rear View Camera 63. SYNC ® System 64. MyFord Touch ® 65. Active Park Assist FCPO-INSPECT-12 Ford Vehicle Inspection Checklist Page 1 of 4
description
ford car inspection
Transcript of FORD 172 Point Inspection
Original: Owner Copy: DealerPrior to delivery of this vehicle, the following checks and inspections were performed. Any item(s) that did not pass the 172-point inspection have been replaced or repaired.Dealership Name: Dealership Name:Year/Make/Model: Color: Mileage:Stock Number: VIN: R.O. #1. VEHICLE HISTORYPassedRepairedReplacedN/A1. VIN Inspection 2. Service Recalls (OASIS) Performed 3. Vehicle History Report Obtained 4. Scheduled Maintenance Performed 5. Vehicle Emissions Sticker (Applicable States) 3. VEHICLE EXTERIORPassedRepairedReplacedN/A3A BODY PANELS AND BUMPERS 23. No Evidence of Flood, Fire, Major or Hail Damage 24. Body Panel Inspection 25. Bumper/Fascia Inspection 3B DOORS, HOOD, DECKLID, TAILGATE26. Doors, Hood, Decklid/Tailgate and Roof Inspection 27. Doors, Hood, Decklid/Tailgate Alignment 28. Automatic/Manual Release Mechanisms, Hinges, Prop Rod/Gas Struts Operate Properly 29. Power Lifgate, Power-Sliding Door Operation 3C GRILLE, TRIM AND ROOF RACK30. Grille, Trim and Roof Rack Inspection 31. Deployable Running Boards 3D GLASS AND OUTSIDE MIRRORS 32. Windshield, Side and Rear-Window Glass Inspection 2. ROAD TESTPassedRepairedReplacedN/A6. Engine Starts and Idles Properly 7. Remote Start System Operation 8. Engine Accelerates and Cruises Properly/Smoothly 9. Engine Noise Normal (Cold/Hot & High/Low Speeds) 10. Auto/Manual Transmission/Transaxle Operation Cold and Hot Shif Quality 11. Auto/Manual Transmission/Transaxle Noise Normal Cold and Hot 12. Shif Interlock Operates Properly 13. Drive Axle/Transfer Case Operation Noise Normal 14. Clutch Operates Properly 15. Steers Normally (Response, Centering and Free Play) 16. Body and Suspension Squeaks and Rattles 17. Struts/Shocks Operate Properly 18. Brakes/ABS Operate Properly 19. Cruise Control 20. Gauges Operate Properly 21. Driver Select/Memory Prole Systems 22. No Abnormal Wind Noise 3. VEHICLE EXTERIORcontinuedPassedRepairedReplacedN/A3D GLASS AND OUTSIDE MIRRORS 33. Wiper Blade Replacement 34. Outside Mirror Inspection 3E EXTERIOR LIGHTS35. Front-End Exterior Lights 36. Back-End Exterior Lights 37. Side Exterior Lights 38. Hazard Lights 39. Auto On/Of Lighting 40. Trailer Lamp Connector Operation 4. VEHICLE INTERIOR PassedRepairedReplacedN/A4A AIRBAG AND SAFETY BELTS 41. Airbags 42. Safety Belts 4B AUDIO AND ALARM SYSTEMS43. Radio, Cassette, CD and Speakers 44. Antenna 45. Alarm/Thef-Deterrent System 46. Navigation System 4C HEAT/VENT/AC/DEFOG/DEFROST47. Air Conditioning System 48. Heating System 49. Defog/Defrost 4D INTERIOR AMENITIES 50. Clock 51. Tilt/Telescopic Steering Wheel 52. Steering Column Lock 53. Steering Wheel Controls 54. Horn 55. Warning Chimes 56. Instrument Panel and Warning Lights 57. Wipers 58. Washers 59. Interior Courtesy, Dome and Map Lights 60. Manual Outside Rearview Mirrors, Power Outside Rearview Mirrors and Auto-dimming Rearview Mirror 61. BLIS (Blind Spot Information System) 62. Rear View Camera 63. SYNC System 64. MyFord Touch 65. Active Park Assist FCPO-INSPECT-12Ford Vehicle Inspection ChecklistPage 1 of 4Original: Owner Copy: Dealer4. VEHICLE INTERIORcontinuedPassedRepairedReplacedN/A4D INTERIOR AMENITIES 66. Rear Entertainment System 67. Power Outlets and Lighter 68. Ashtrays 69. Glove Box and Center Armrest/Console 70. Sun Visors, Vanity Mirror and Light 71. Adjustable Pedals (if equipped) 4E CARPET, TRIM AND MATS 72. Interior Odor-Free 73. Carpet 74. Floor Mats 75. Door Trim and Door Panels 76. Headliner 4F SEATS77. Seat Upholstery 78. Seat and Head Restraint Adjustment 79. Folding Seats 80. Heated Seats 81. Integrated Child Safety Seats 4G SUNROOF/MOONROOF/CONVERTIBLE TOP 82. Sunroof/Moonroof 83. Convertible Top 4H WINDOWS AND DOOR LOCKS84. Door Handles and Release Mechanisms 85. Remote Entry System and Push-Button Start System 86. Door Locks 87. Child Safety Locks 88. Window Controls 89. Remote Decklid and Fuel Filler Door Release 4I LUGGAGE COMPARTMENT90. Carpet, Trim and Cargo Net 91. Luggage Compartment/Cargo Area Light 92. Vehicle Jack and Tool Kit 93. Spare Tire Size/Type and Sidewall Inspection 94. Spare Tire Tread Depth/Air Pressure Inspection 95. Tire Inator Kit 96. Emergency Trunk-Lid Release 5. VEHICLE DIAGNOSTICSPassedRepairedReplacedN/A5A MODULE SYSTEM TEST 97. Perform Self-Test for all CMDTCs 6. UNDERHOODPassedRepairedReplacedN/A6A FLUIDS 98. Engine Oil/Filter Change and Chassis Lube 99. Coolant 100. Brake Fluid 101. Automatic Transaxle/Transmission Fluid 102. Transfer Case Fluid 103. Drive Axle Fluid 104. Power Steering Fluid 105. Manual Transaxle/Transmission Hydraulic Clutch Fluid 106. Washer Fluid 107. Air Conditioning System Charge 6B ENGINE108. Fluid Leaks 109. Hoses, Lines and Fittings 110. Belts 111. Wiring 112. Oil in Air Cleaner Housing 113. Water, Sludge or Engine Coolant in Oil 114. Oil Pressure 115. Relative Cylinder Compression Test/Power Balance Readings (check if necessary) 116. Timing Belt 117. Engine Mounts 118. Inspect Turbocharger Air Cooler 6C COOLING SYSTEM119. Radiator 120. Pressure-Test Radiator Cap and Radiator 121. Cooling Fans, Clutches and Motors 122. Water Pump 123. Coolant Recovery Tank 124. Cabin Air Filter 6D FUEL SYSTEM125. Fuel Pump Noise Normal 126. Fuel Pump Pressure 127. Fuel Filter 128. Engine Air Filter 6E ELECTRICAL SYSTEM129. Starter Operation 130. Ignition System 131. Battery 132. Alternator Output 133. Diesel Glow Plug System Ford Vehicle Inspection ChecklistPage 2 of 4FCPO-INSPECT-12Original: Owner Copy: Dealer8. UNDERBODYContinuedPassedRepairedReplacedN/A8E BRAKES 163. Calipers and Wheel Cylinders 164. Brake Pads and Shoes 165. Rotors and Drums 166. Brake Lines, Hoses and Fittings 167. Parking Brake 168. Master Cylinder and Booster 8. UNDERBODY PassedRepairedReplacedN/A8A FRAME 138. Frame Damage 139. Fuel Supply System 8B EXHAUST SYSTEM140. Exhaust System Condition 141. Emissions Control Test 8C TRANSMISSION, TRANSAXLE, DIFFERENTIAL AND TRANSFER CASE142. Automatic Transmission/Transaxle 143. Manual Transmission/Transaxle, Diferential and Transfer Case 144. 4x4 Hub Operation 145. Universal Joints, CV Joints and CV Joint Boots 146. Transmission Mounts (not cracked, broken or oil soaked) 147. Diferential/Drive Axle 8D TIRES AND WHEELS148. Tires and Wheels Match and Are Correct Size 149. Tire Tread Depth 150. Normal Tire Wear 151. Tire Pressure 152. Tire PressureMonitoring System 153. Wheels 154. Wheel Covers and Center Caps 155. Rack-and-Pinion, Linkage and Boots 156. Control Arms, Bushings and Ball Joints 157. Tie-Rods and Idler Arm 158. Sway Bars, Links and Bushings 159. Springs 160. Struts and Shocks 161. Wheel Alignment (check if necessary) 162. Power Steering Pump 9. CONVENIENCEPassedRepairedReplacedN/A169. Owners Guide 170. Keys and Remote Controls 171. Universal Transmitter (Garage Door Opener) 172. Full Fuel Level 7. HYBRIDPassedRepairedReplacedN/A134. Hybrid Cooling System 135. Switchable Powertrain Mount 136. Hybrid Entertainment and Information Display 137. 110V Power Outlet Ford Vehicle Inspection ChecklistPage 3 of 4FCPO-INSPECT-12 VINTechnician SignatureDateI certify that all mechanical items have been inspected.Service Manager SignatureDateI certify that all mechanical and appearance standards have been met.Certied Pre-Owned Vehicle ManagerDateI certify that all mechanical and appearance standards have been met.Original: Owner Copy: DealerTechnicians NotesSection/Item _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________ _______________________________________________________________________________________________________________________________Ford Vehicle Inspection ChecklistPage 4 of 4FCPO-INSPECT-12
