Flownex In Coal Energy
Click here to load reader
-
Upload
santhosh-lingappa -
Category
Documents
-
view
356 -
download
2
Transcript of Flownex In Coal Energy
Flownex® Application in Coal Energy Systems
Bearing Casing
Shaft
Manual Jacking Oil Pump
Jacking Oil Relieve Valve
Jacking Oil Pump
Low Pressure Oil Pump
Filter Unit
Oil Cooler
Oil Heater
Low Pressure Bypass Line
Circulating Cooling Water
L u b r i c a t i o n a n d C o n t r o l F l u i d
S y s t e m s D e a e r a t o r /
F e e d w a t e r T a n k B o i l e r W a t e r
C i r c u i t s S t e a m
C i r c u i t s B o i l e r S t e a m
C i r c u i t s G l a n d S t e a m
S y s t e m
B o i l e r D r a u g h t S y s t e m C o n d e n s e r A s h
R e m o v a l C o o l i n g W a t e r
C i r c u i t s
Slurry Pumps
Ash Hopper
Ash Water Pump
Ash Water
Ground Level
Ash
Water
Main Condenser
Hot Duct
Cold Duct
Condensate Outlet
Steam Inlet
Main Cooling Circuit
BFPTCondenser
Water/Water Coolers
Secondary Cooling Circuit
Generator Consumers
Turbine Consumers
Other Consumers
Demin Water Inlet
Aux. Cooling Water Pumps
Aux. Cooling Water Tank
Auxiliary Cooling Circuit
To Cooling Tower
StrainersPumps
F e e d w a t e r P u m p s
F e e d w a t e r H e a t e r s
Natural convection Drum level tracking
Phase changes
Ash water flow Slurry pipeline planning
Pump capacity Settling velocity
Flow distribution Oil pressure distribution Logic control systems
Steam delivery Pressure distribution Evaluate seal wear
Steam / Air mixture Track condensate levels
Venting capacity
System heat loss Start-up & shutdown scenarios
Complete cycle Turbine trip control
Attemperation control Steam system reaction Operational changes
Accident scenarios Operating conditions
Vent capacity
Flow distribution Damper control
Air leaks
NPSH System integration Pump switch-over
Pump sizing
Heat Transfer degradation Air leaks into system
Condenser (P, T, Level)
Cooling capacity Identify leaks
Water hammer Expansion planning