Flammable and Combustible Liquids - Clark County...
Transcript of Flammable and Combustible Liquids - Clark County...
![Page 1: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/1.jpg)
Slide 1 (of 23)
Flammable and Combustible Liquids
![Page 2: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/2.jpg)
Slide 2 (of 23)
Introduction
� The two primary hazards associated with flammable and combustible liquids are explosion and fire
� Safe handling and storage of flammable liquids requires the use of approved equipment and practices per OSHA standards
![Page 3: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/3.jpg)
Slide 3 (of 23)
Flash Point
� Flash point means the minimum temperature at which a liquid gives off enough vapor to form an ignition
� In general, the lower the flash point, the greater the hazard
� Flammable liquids have flash points below 100oF, and are more dangerous than combustible liquids, since they may be ignited atroom temperature
� Combustible liquids have flash points at or above 100oF
� Although combustible liquids have higher flash points than flammable liquids, they can pose serious fire and/or explosion hazards when heated
![Page 4: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/4.jpg)
Slide 4 (of 23)
Classes of Flammableand Combustible Liquids
200
140
100
73
OSHA Office of Training and Education 4
Classes of FlammableClasses of Flammable
and Combustible Liquidsand Combustible Liquids
IIIA
II
IC
IA IB
200
140
100
73
Fla
sh P
oin
t (o F
)
100
Boiling Point (oF)
Combustible(FP > 100oF)
Flammable
(FP < 100oF)
![Page 5: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/5.jpg)
Slide 5 (of 23)
Classes of Some Flammable Liquids
CLASS IA
CLASS IB
CLASS IC
Common Name Flash Point (oF)"
Ethyl Ether -49
Gasoline -45
Methyl Ethyl Ketone 21
Toluene 40
Xylene 81-115
Turpentine 95
![Page 6: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/6.jpg)
Slide 6 (of 23)
Program Components
� Control of ignition sources
� Proper storage
� Fire control
� Safe handling
A good plan for safe use of flammable and
combustible liquids contains at least these
components:
![Page 7: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/7.jpg)
Controlling Fires
![Page 8: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/8.jpg)
Slide 7 (of 23)
Sources of Ignition
� Open flames
� Smoking
� Static electricity
� Cutting and welding
� Hot surfaces
� Electrical and mechanical sparks
� Lightning
Must take adequate precautions to prevent ignition of
flammable vapors. Some sources of ignition include:
![Page 9: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/9.jpg)
Slide 8 (of 23)
Static Electricity
Generated when a fluid flows through a pipe or from an opening into a tank
Main hazards are fire and explosion from sparks containing enough energy to ignite flammable vapors
Bonding or grounding of flammable liquid containers is necessary to prevent static electricity from causing a spark
![Page 10: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/10.jpg)
Slide 9 (of 23)
Bonding
� Physically connect two conductive objects together with a bond wire to eliminate a difference in static charge potential between them
� Must provide a bond wire between containers during flammable liquid filling operations, unless a metallic path between them is otherwise present
![Page 11: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/11.jpg)
Slide 10 (of 23)
Grounding
� Eliminates a difference in static charge potential between conductive objects and ground
� Although bonding will eliminate a difference in potential between objects, it will noteliminate a difference in potential between these objects and earth unless one of the objects is connected to earth with a ground wire
![Page 12: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/12.jpg)
Slide 11 (of 23)
Ventilation
Always provide adequate ventilation
to reduce the potential for ignition of
flammable vapors.
![Page 13: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/13.jpg)
Slide 12 (of 23)
Storage Fundamentals
� Identify incompatible chemicals – check the Material
Safety Data Sheet
� Isolate and separate incompatible materials
– Isolate by storing in another area or room
– Degree of isolation depends on quantities, chemical
properties and packaging
– Separate by storing in same area or room, but apart from
each other
![Page 14: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/14.jpg)
![Page 15: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/15.jpg)
Slide 13 (of 23)
Storage of Flammableand Combustible Liquids
� Storage must not limit the use of exits, stairways, or areas normally used for the safe egress of people
� In office occupancies:– Storage prohibited except that
which is required for maintenance and operation of equipment
– Storage must be in:� closed metal containers inside a
storage cabinet, or
� safety cans, or
� an inside storage room
Inside storage room
![Page 16: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/16.jpg)
Slide 14 (of 23)
Safety Cans for Storage and Transfer
� Approved container of not
more than 5 gallons
capacity
� Spring-closing lid and spout
cover
� Safely relieves internal
pressure when exposed to
fire
![Page 17: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/17.jpg)
Slide 15 (of 23)
Flame Arrester Screen
� Prevents fire flashback into can contents
� Double wire-mesh construction
� Large surface area provides rapid dissipation of heat from fire so that vapor temperature inside can remains below ignition point
![Page 18: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/18.jpg)
Slide 16 (of 23)
Storage Cabinets
� Not more than 60 gal of Class I and/or Class II liquids, or not more than 120 gal of Class III liquids permitted in a cabinet
� Must be conspicuously labeled, “Flammable - Keep Fire Away”
� Doors on metal cabinets must have a three-point lock (top, side, and bottom), and the door sill must be raised at least 2 inches above the bottom of the cabinet
![Page 19: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/19.jpg)
Slide 17 (of 23)
Fire Control
� Suitable fire control devices, such as small hose or portable fire extinguishers must be available where flammable or combustible liquids are stored
� Open flames and smoking must not be permitted in these storage areas
� Materials which react with water must not be stored in the same room with flammable or combustible liquids
![Page 20: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/20.jpg)
Slide 18 (of 23)
Transferring Flammable Liquids
1. Through a closed piping system
2. From safety cans
3. By gravity through an approved self-closing safety
faucet
4. By means of a safety pump
Since there is a sizeable risk whenever flammable
liquids are handled, OSHA allows only four
methods for transferring these materials:
![Page 21: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/21.jpg)
Slide 19 (of 23)
Self-Closing Safety Faucet
�Bonding wire between drum
and container
�Grounding wire between
drum and ground
�Safety vent in drum
![Page 22: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/22.jpg)
Slide 20 (of 23)
Safety Pump
� Faster and safer than using a faucet
� Spills less likely
� No separate safety vents in drum required
� Installed directly in drum bung opening
� Some pump hoses have integral bonding wires
![Page 23: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/23.jpg)
Slide 21 (of 23)
Waste and Residue
Waste drum with
disposal funnel
Safety disposal can Oily-waste can
(self-closing lid)B
Combustible waste and residue must be kept to a minimum,
stored in covered metal receptacles and disposed of daily.
![Page 24: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/24.jpg)
HAZARDOUS CHEMICAL DISPOSAL
� Use Proper Chemical
Disposal Methods
� Controlled Waste� Used oil & used antifreeze
� Hazardous Waste� Paint & thinner
� Solvent & cleaners
![Page 25: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/25.jpg)
Slide 22 (of 23)
Safe Handling Fundamentals
� Carefully read the manufacturer’s label on the flammable liquid container before storing or using it
� Practice good housekeeping in flammable liquid storage areas
� Clean up spills immediately, then place the cleanup rags in a covered metal container
� Only use approved metal safety containers or original manufacturer’s container to store flammable liquids
� Keep the containers closed when not in use and store away from exits or passageways
� Use flammable liquids only where there is plenty of ventilation
� Keep flammable liquids away from ignition sources such as open flames, sparks, smoking, cutting, welding, etc.
![Page 26: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/26.jpg)
Slide 23 (of 23)
Summary
� The two primary hazards associated with flammable and combustible liquids are explosion and fire
� Safe handling and storage of flammable liquids requires the use of approved equipment and practices per OSHA standards
� An excellent reference on this topic is National Fire Protection Association Standard No. 30, Flammable and Combustible Liquids Code
![Page 27: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/27.jpg)
Quiz
1. Flammable liquids have a flash point below 100 degrees F?True or False
2. Physically connecting two conductive objects together is called grounding? True or False
3. What’s the best source to identify incompatible chemicals? ___________
4. Flammability on the NFPA label is colored Red? True of False
5. Flammable safety cans:
a. cannot be more than 60 gal.
b. Must have a self-closing lid
c. Must be made of durable plastic
![Page 28: Flammable and Combustible Liquids - Clark County …ccsd.net/resources/risk-and-insurance-services/flam...Slide 2 (of 23) Introduction The two primary hazards associated with flammable](https://reader031.fdocuments.us/reader031/viewer/2022030417/5aa31ba67f8b9ada698dd143/html5/thumbnails/28.jpg)
Quiz
1. Flammable liquids have a flash point below 100 degrees F?TrueTrue or False
2. Physically connecting two conductive objects together is called grounding? True or FalseFalse
3. What’s the best source to identify incompatible chemicals? _MSDSMSDS____
4. Flammability on the NFPA label is colored Red? TrueTrue of False
5. Flammable safety cans:
a. cannot be more than 60 gal.
b. Must have a selfb. Must have a self--closing lidclosing lid
c. Must be made of durable plastic