FDA 10055

8/10/2019 FDA 10055

1/5

DALIC, B.P. 90139, 35501 VITRE CEDEX, FRANCE [email protected] 16.02.2009Code: 10055, document code: FDS10055 1/5

SAFETY DATA SHEET

1 - IDENTIFICATION OF THE PREPARATION AND OF THE COMPANY

IDENTIFICATION OF THE PREPARATION

ANODISATION SULFURIQUE S2 (code 10055)

orS2 SULPHURIC ANODISING

USE OF THE PREPARATIONThis solution is used for anodising aluminium parts locally, using the selective brush plating process or the Dalistick tool.These electrolysis processes (brush or DALISTICK) can be applied locally, i.e. without immersion of the part, just where itis necessary. Thus, only small quantities of solutions are stored or used.With the DALISTICK, the solution circulates in a closed loop without flowing on the area to be treated.

COMPANY IDENTIFICATIONDALIC - ZI de Plagu - 41, rue des Eaux - B.P. 90139 - 35501 VITRE CEDEX, FRANCEManufacturer and Seller, tel.: (33) 2.99.75.36.99, fax: (33) 2.99.74.49.31.

For information: [email protected], tel.: (33) 2.99.75.53.88.

RELEVANT OFFICIAL ADVISORY BODY (France): INRS / Orfila, tel. (33) 1.45.42.59.59.________________________________________________________________________________________________

2 HAZARDS IDENTIFICATION

CHEMICAL NATUREAqueous solution of acids containing notably more than 15% sulphuric acid.

PRODUCT CLASSIFICATION ACCORDING TO 1999/45/EC and 67/548/ECSymbol:C, risks phrases: R35

MAIN HAZARDSAdverse physicochemical effects- Fire or explosion: this product is not classified as flammable or explosive. However, it can be a secondary source of fireor explosion, for example following its action on metals (hydrogen that forms is flammable and exploding in some

concentrations with air).Adverse effects on healthAcidic and CORROSIVE preparation that can cause serious burns following a short contact (less than 3 minutes). Skindamages in its whole depth and disabling after-effects of eyes are possible if decontamination with water is not quicklyachieved.Effects on the environmentIs not classified as dangerous for the environment providing that the recommendations of the section 13 relative todisposal as well as the national or local provisions are followed.

Refer also to the paragraphs 11, 12, 13 and 15.________________________________________________________________________________________________

3 - COMPOSITION / INFORMATION ON INGREDIENTS

COMPONENTS OR IMPURITIES CONTRIBUTING TO THE HAZARDS (according to 1999/45/EC and 67/548/EC)Substances present in concentrations higher than the minimal level of danger: YES.

Regulated substance

H2SO4 (19th

adaptation)Sulphuric Acid

EC index N: 016-020-00-8CAS N: 7664-93-9

EINECS N: 231-639-5

Classification of thepure substance

C R35

S phrases (1/2)- 26-30-45

Classification of thesubstance according toits concentration (in %)

15% C R355-15% Xi R 36/38

Concentration range inthe preparation

15%

Substances present in concentrations lower than the minimal level of danger (if 1%): NO.Substances with the R33 phrase (if 1%) or the R64 phrase (if 1%) or sensitising substances (if 0.1%): NO.OTHER SUBSTANCES WITH WORKPLACE EXPOSURE LIMITS: NO.________________________________________________________________________________________________

8/10/2019 FDA 10055

2/5


4 - FIRST AID MEASURES

CONTACT WITH SKINTake off contaminated clothing and shoes. Wash immediately with plenty of water for 10 to 15 minutes. Dont hesitate totake a shower. In all cases, dont try to neutralize with bases and dont apply any cream. If an irritation appears or if thecontamination is large or in case of prolonged contact, seek medical advice.

CONTACT WITH EYESRinse immediately with plenty of water for approximately 15 minutes. Always call an ophthalmologist.

INHALATIONTheoretically, not applicable. Under abnormal conditions of use causing considerable inhalation, remove the casualtyfrom the contaminated area, let him take a rest in a well-ventilated room and seek medical advice. A delayed pulmonaryoedema may appear. A clinical, biological and radiological supervision and a treatment may be necessary in that case.

INGESTIONDont try to induce vomiting. Do not give anything to drink. Transfer quickly into hospital. Complications may appear later.

PROTECTION OF THE FIRST-AIDERSWear gloves and according to the situation: glasses, clothes and protective shoes, a mask.________________________________________________________________________________________________

5 - FIRE-FIGHTING MEASURES

SUITABLE EXTINGUISHING MEDIADry ice, powders.

EXTINGUISHING MEDIA WHICH SHALL NOT BE USEDWater.

SPECIFIC HAZARDSPrevent any material from entering drains or waterways or soil.

Dangerous thermal decomposition products: in particular, vapours of sulphur oxides and oxygen. Hydrogen evolution ispossible.

PROTECTION OF THE FIRE-FIGHTERSBecause of the substances produced during thermal decomposition, use approved self-contained breathing equipmentand protective clothing in case of intervention.________________________________________________________________________________________________

6 - ACCIDENTAL RELEASE MEASURES

PERSONAL PRECAUTIONSAvoid contact with skin and eyes: wear gloves, glasses, overalls and safety boots. In case of contact, dispose of allcontaminated clothing and shoes and wash thoroughly in water.

ENVIRONMENTAL PRECAUTIONSDo not allow the product to be thrown away. Recover as much as possible for processing within the firm or by anapproved centre.

METHODS FOR CLEANING UPWith water to remove all non-recoverableproduct. Before throwing rinsing water, check the pH is between 5.5 and 8.5.________________________________________________________________________________________________

7 - HANDLING AND STORAGE

HANDLINGUse as supplied. Close containers (in PE) tightly after use with the original cap. Do not re-use containers with anotherproduct.

STORAGEStore in a room on a spill-retaining vat away from alkaline or reducing products, metals and flammable compounds. Keepin original containers only, between 5 and 30C if possible away from direct sun-light. The maximum recommended shelflife is three years from the date of manufacture under normal conditions of storage.________________________________________________________________________________________________

8 - EXPOSURE CONTROLS / PERSONAL PROTECTION

EXPOSURE CONTROLSTECHNICAL MEASURESNo drinking, eating or smoking on the workplace.Maintain the premises and the workplace in a perfect state of cleanliness and clean them frequently.

As the product is used at ambient or cold temperature during a short time, the values below are generally not reached.They depend on the treatment time, the surface area treated and on the quality of the workshop air extraction.

8/10/2019 FDA 10055

3/5


EXPOSURE LIMIT VALUES IN AIR

Sulphuric acid

France: decisions of 26 October2007, of 30 June 2004, INRS fileND 2098

Average value (8h) = 1 mg/m3

Limit value (15 min) = 3 mg/m3

(INRS file ND 2098)

Directives 2006/15/EC,2000/39/EC and 91/322/EC

Not applicable

PERSONAL PROTECTIONProvide a shower, a powerful tap and sink unit and an eye basin near the workplace.- Respiratory protection: during brush electrolysis, provide as far as possible an inhaling of the sprays / vapours where

they are created and extraction out of the premises. Or work in a ventilated room and wear if necessary a filteringFFP3 mask (EN 149:2001 standard) or a E2P3 cartridge (EN 405:2002 standard).

During electrolysis with the DALISTICK tool, these measures are not necessary, work taking place in a closed loop.

- Hand protection: wear imperatively gloves (in nitrile, neoprene or PVC).- Eye protection: wear imperatively glasses with lateral protections or a facial screen. Do not wear contact lenses.- Skin protection: wear overalls and safety boots.________________________________________________________________________________________________

9 - PHYSICAL AND CHEMICAL PROPERTIES

- Appearance: colourless liquid.- Odour: odourless.- pH:

8/10/2019 FDA 10055

4/5


12 - ECOLOGICAL INFORMATION

There are no ecological data on the preparation.Prevent any material from entering drains or waterways or earth .In general, a pH lower than 5 is fatal.

ECOTOXICITYBibliographic data concerning sulphuric acid at 94-98 %:FISH-LC50 (24h) = 82 mg / L, DAPHNIA-EC50 (24h) = 29 mg / L.MOBILITYSulphuric acid is very mobile in soils and dissolves quickly in water.

PERSISTENCE AND DEGRADABILITY-

BIOACCUMULATIONSulphuric acid has a weak bioaccumulative potential.

OTHER ADVERSE EFFECTSNo other information.

According to the applicable EC directives, it is not appropriate to apply theN symbol DANGEROUS FOR THE

ENVIRONMENTto this preparation.________________________________________________________________________________________________

13 - DISPOSAL CONSIDERATIONS

This product and water used for rinsing must not be thrown away notably because of their acidity and their content inmetals after use. They must be processed within the firm or destroyed by an approved organization.Contaminated packaging if not re-used with the same product is also special waste to be sent to an approvedorganization for recycling or disposal.

Classification according to the commission directive 2000/532/EC of 3 May 2000 and its modifications (in particular2001/118/EC, OJ L47). Use the mandatory documents to follow-up the waste products.

06 03 13* or11 01 05*

Solid salts and solutions containing heavy metalsPickling acids

11 01 11* Aqueous rinsing liquids containing dangerous substances

15 01 10* Packaging containing residues of or contaminated by dangerous substances

As the volume of rinsing water is small, it can be added to the waste solutions.

NOTE: in addition to the community provisions, it can be specific legislative and administrative, national or localprovisions on this topic.________________________________________________________________________________________________

14 - TRANSPORT INFORMATION

A.D.R. (road transport)Sulfuric acid with 51 % or less acid, UN N2796, class 8, classification code: C1, packaging group II, hazard label model8, restricted quantities LQ22, hazard code 80, material identification n 2796.

I.M.D.G. (sea transport)Sulfuric acid with not more than 51 % acid, UN N 2796, class 8, subsidiary risk label: not applicable, packaging group II,restricted quantities: 1 L, stowing and separation: category B, safety sheets F-A, S-B.

I.A.T.A. (air transport)

Sulphuric acid with 51 % or less acid, UN N 2796, class 8, subsidiary risk: not applicable, risk label: CORROSIVE,packaging group II, Passenger and cargo aircraft: packaging instructions 809, maximum quantity per package: 1 L,Cargo aircraft only: packaging instructions 813, maximum quantity per package: 30 L, instruction IDC: 8L.________________________________________________________________________________________________

15 - REGULATORY INFORMATION

This safety data sheet has been established in accordance with the Corrigendum to Regulation (EC) n 1907/2006 of theEuropean Parliament and of the Council of December 18, 2006, OJ L136, 29.05.2007.The preparation labelling has been established in compliance with the directive 67/548/EC (until the 29

th adaptation:

directive 2004/73/EC of April 29, 2004) and the directive 1999/45/EC reviewed in last in January 23, 2006 by thedirective 2006/8/EC.

EC LABELLING: CORROSIVEAqueous preparation containing in particular sulphuric acid (> 15 %).

R35: causes severe bums.S26: in case of contact with eyes, rinse immediately with plenty of water and seek medical advice.S28: after contact with skin, wash immediately with plenty of water.S36/37/39: wear suitable protective clothing, gloves and eye / face protection.S45: in case of accident or if you feel unwell, seek medical advice immediately (show the label where possible).

8/10/2019 FDA 10055

5/5


HEALTH SURVEILLANCECouncil Directive 98/24/EC of 7 April 1998 on the protection of the health and safety of workers from the risks related tochemical agents at workAn appropriate health surveillance of workers must be carried out according to the risk.For each worker who undergoes this health surveillance, individual health and exposure records are to be made and keptup-to-date.

Other paragraphs in the French version of this safety data sheet summarize French rules regarding: administrative declarations and rules,

environment laws regarding rinsing water treatment.

The situation of the company has to be examined in relation to the specific legislative and administrative, national or localprovisions on these topics.Additional information is provided in paragraphs 8, 11, 12, 13 and 14.________________________________________________________________________________________________

16 - OTHER INFORMATION

RESTRICTION OF USEFor industrial use only.We remain available to bring you the advice or training you may need.

R PHRASES OF THE PURE COMPONENTS LISTED IN SECTION 3

R35: causes severe burns.R PHRASES OF THE PREPARATION ACCORDING TO THE SECTIONS 2 AND 15R35: causes severe burns.

BIBLIOGRAPHIC REFERENCESEuropean directives, INRS files, safety data sheets of the components established by their manufacturers or distributors,information of European Office of the chemical substances (ECB).

MODIFICATIONSUpdating in relation to the corrigendum to regulation (EC) n 1907/2006 published in May 29, 2007 and French decisionsof October 26, 2007.Revised paragraphs: n1, 2, 3, 14, 15, 16.

OTHER INFORMATIONThis sheet is provided to complement, not replace, the user instructions.Information contained herein is bona fide and based on current knowledge relating to the product on the date ofpublication. Furthermore, the attention of the user is drawn to the risks which may be incurred when the product is usedfor purposes other than those for which it is designed.Information provided herein relates to this product only; it cannot take account of every situation which may arise at everywork place. This safety data sheet therefore represents only a part of the information required for establishing a safetyprogramme.Under no circumstances does this sheet dispense the user from the need to know and to apply all of the regulationsgoverning its activity, which are not all necessarily quoted herein in an exhaustive manner.________________________________________________________________________________________________

FDA 10055

Documents

Transcript of FDA 10055