FDA 10033

8/10/2019 FDA 10033

1/6

DALIC , B.P. 90139, 35501 VITRE CEDEX, FRANCE, [email protected] 02.03.2008Codes: 10033, DSF 8010, document code: FDS10033 1/6

SAFETY DATA SHEET1 - IDENTIFICATION OF THE PREPARATION AND OF THE COMPANY

IDENTIFICATION OF THE PREPARATION

PASSIVATEUR N2 or FINISH AC (code 10033)CADMIUM / ZINC PASSIVATING (code: DSF 8010)

USE OF THE PREPARATIONThis solution has been specially formulated to passivate electroplated cadmium or zinc (ZINGAGE N solution).This treatment increases the corrosion resistance thanks to the growth of a layer of chromates at the surface.It is applied at room temperature by soaking the part for 8 to 12 s or locally by damping the metal with a piece of cottonwool for 25 to 30 s, just where it is necessary. The stored and used quantities of solution are therefore small.COMPANY IDENTIFICATIONDALIC - ZI de Plagu - 41, rue des Eaux - B.P. 90139 - 35501 VITRE CEDEX, FRANCEManufacturer and Seller, tel.: (33) 2.99.75.36.99, fax: (33) 2.99.74.49.31.For information: [email protected], tel.: (33) 2.99.75.53.88.

RELEVANT OFFICIAL ADVISORY BODY (France): INRS / Orfila, tel. (33) 1.45.42.59.59. ________________________________________________________________________________________________2 HAZARDS IDENTIFICATION

CHEMICAL NATURE Aqueous acidic preparation containing in particular sodium dichromate.PRODUCT CLASSIFICATION ACCORDING TO 1999/45/EC and 67/548/ECSymbols: T+, N, risks phrases: R 45-46-60-61-22-26-34-42/43-48/23-51/53MAIN HAZARDS

Adverse physicochemical effects- Fire or explosion: this product is not classified as flammable or explosive but it can favour the combustion of othermatters if it is present in large quantities especially in the dehydrated state.

Adverse effects on health According to the available data, this preparation is:

corrosive (may cause burns), allergenic by inhalation and by contact with skin, very toxic by inhalation and toxic by prolonged exposure, harmful if swallowed.

It contains a carcinogenic, mutagenic and toxic for reproduction agent of the 2 nd category (unproved effects on man butthere is sufficient evidence to provide a strong presumption that human exposure to it may result in such effects): ifprotective measures are not taken, the risk of a cancer development can thus be increased as well as the risk ofhereditary genetic changes. Loss of fertility and development retardations of the child may be also possible both beforeand after birth.Effects on the environmentThis preparation is classified as TOXIC to the aquatic environment.Refer also to the paragraphs 11, 13 and 15.

________________________________________________________________________________________________

3 - COMPOSITION / INFORMATION ON INGREDIENTS

COMPONENTS OR IMPURITIES CONTRIBUTING TO THE HAZARDS (according to 1999/45/EC and 67/548/EC)Substances present in concentrations higher than the minimal level of danger: YES

Regulated substancesSulphuric acid (19

th adapt.)EC index N: 016-020-00-8CAS N: 7664-93-9EC N: 231-639-5

Sodium Dichromate (29 th adapt.)EC index N: 024-004-00-7CAS N: 10588-01-9EC N: 234-190-3

Classification of thepure substance

C R35O R8Carc. Cat. 2 R45Muta. Cat. 2 R46Repr. Cat. 2 R60-61T+ R26

T R25-48/23Xn R21C R34

R42/43N R50-53

Symbols C T+, N, O

Classification of thesubstance according to

its concentration (%)

15% C R355-15% Xi R36/38 10-25% T+, N

R45-46-60-61-22-26-34-42/43-48/23-51/53

Weight % in thepreparation < 5%

10-25% expressed in chromate ions(CrO 4

2-)

8/10/2019 FDA 10033

2/6

DALIC , B.P. 90139, 35501 VITRE CEDEX, FRANCE, [email protected] 02.03.2008Codes: 10033, DSF 8010, Safety Data Sheet, document code: FDS10033 2/6

Substances with the R33 phrase (if 1%) or with the R64 phrase (if 1%): NO.OTHER SUBSTANCES WITH WORKPLACE EXPOSURE LIMITS: NOOTHER INFORMATION: contains other EC non-regulated substances, which are also not classified by theirmanufacturers or distributors.

________________________________________________________________________________________________

4 - FIRST AID MEASURES

CONTACT WITH SKINTake off contaminated clothing and shoes. Wash immediately with plenty of water.

CONTACT WITH EYESRinse immediately with plenty of water for approximately 15 minutes. Consult quickly an ophthalmologist in all cases.

INHALATIONTheoretically, not applicable. Under abnormal conditions of use causing considerable inhalation, remove the casualtyfrom the contaminated area, let him take a rest in a well-ventilated room and seek medical advice.

INGESTIONDo not give anything to drink. Do not induce vomiting. Call the medical service to transfer immediately to hospital in orderto observe the evolution of local hepatic and renal troubles. The use of sequestrating products has been recommended.

PROTECTION OF THE FIRST-AIDERS According to the situation, wear gloves, glasses, protective clothes and shoes, a mask ________________________________________________________________________________________________5 - FIRE-FIGHTING MEASURES

SUITABLE EXTINGUISHING MEDIAWater spray.

EXTINGUISHING MEDIA WHICH SHALL NOT BE USEDNo.

SPECIFIC HAZARDSCan react with easily oxidizable/combustible materials.Decomposition begins at about 400C by releasing oxygen.Prevent any material from entering drains or waterways or earth.

PROTECTION OF THE FIRE-FIGHTERSBecause of the substances produced during thermal decomposition, use approved self-contained breathing equipmentand protective clothing in case of intervention.

________________________________________________________________________________________________

6 - ACCIDENTAL RELEASE MEASURES

PERSONAL PRECAUTIONS Avoid contact with eyes, the skin and clothes: wear at least gloves and glasses and if needed a FFP3 mask.Dispose of all contaminated clothing or shoes and wash thoroughly with water.

ENVIRONMENTAL PRECAUTIONSDo not allow the product to be thrown away. Recover as much as possible for processing within the firm or by anapproved centre. Reduce the remaining product for example with sodium bisulphite.

METHODS FOR CLEANING UPRemove with water the non-recoverable product. Collect the recoverable rinsing water for processing within the firm or byan approved centre.

________________________________________________________________________________________________7 - HANDLING AND STORAGE

HANDLINGUse as supplied. Close containers (in PE) tightly after use with the original cap. Do not re-use containers with anotherproduct.

STORAGEStore on a spill-retaining vat, away from organic, flammable, easily oxidizable, combustible or basic materials. Keep in aventilated room in original containers only, between 5 and 30C. The maximum recommended shelf life is THREE yearsfrom the date of manufacture under normal conditions of storage.

________________________________________________________________________________________________

8 - EXPOSURE CONTROLS / PERSONAL PROTECTION

EXPOSURE CONTROLSTECHNICAL MEASURESNo drinking, eating or smoking on the workplace.Maintain the premises and the work stations in perfect state of cleanliness and clean them frequently.Observe a very strict cutaneous hygiene and change clothes after work.

8/10/2019 FDA 10033

3/6


During the treatment that is realized at ambient temperature during a very short time, there are not especially fumes,vapours or sprays and it is mainly necessary to avoid contact with skin and eyes.

EXPOSURE LIMIT VALUES IN AIRSulphuric acid Chromium VI (compounds of, in Cr)

French decisions of 26 October 2007,of 30 June 2004, INRS file ND 2098

Average value (8 h) = 1 mg/m 3 Limit value (15 min) = 3 mg/m 3

(INRS file ND 2098)

Average value (8 h) = 0.05 mg/m 3

(INRS file ND 2098)

Directives 2006/15/EC, 2000/39/ECand 91/322/EC - -

PERSONAL PROTECTIONProvide a shower, a powerful tap and sink unit and an eye basin near the workplace.

- Respiratory protection: provide if possible an inhaling and extraction of the air out of the premises, particularly for thetreatment of large areas. Or work in a ventilated place, and wear if necessary a filtering FFP3 mask (EN 149:2001standard).

- Hand protection: wear imperatively gloves (in latex, nitrile, neoprene or PVC).- Eye protection: wear imperatively glasses or a facial screen. Do not wear contact lenses.- Skin protection: wear overalls and safety shoes.

________________________________________________________________________________________________

9 - PHYSICAL AND CHEMICAL PROPERTIES

- Appearance: orange-coloured liquid.- Odour: odourless.- pH: < 1.- Relative density: 1.13.- Solubility: miscible in water in all proportions.- Boiling point: approximately 100C.- Crystallisation / melting point: - 4C.- Flammability: nil.- Oxidising properties, risk of explosion or fire: risk in case of thermal decomposition or by contact with easily

oxidizable materials.- Other properties: not applicable.

________________________________________________________________________________________________

10 - STABILITY AND REACTIVITY

STABILITYGood at room temperature with water evaporation for only risk.Good in humidity and light.

CONDITIONS TO AVOIDHigh temperatures: sodium dichromate decomposition begins at about 400C, the one of sulphuric acid is practicallycomplete at 450C.

MATERIALS TO AVOIDThe basic products, the reducers and combustible matters, the organic products, oils and greases. Incompatible withhydroxylamine, hydrazine

HAZARDOUS THERMAL DECOMPOSITION PRODUCTSToxic and pungent fumes: emission notably of oxygen, chromium oxides, chromate, sodium oxide and sulfur oxides.

________________________________________________________________________________________________

11 - TOXICOLOGICAL INFORMATION

No data are available regarding the preparation. The evaluation of health hazards has been realised thanks todir ectives 67/548/EC, 1999/45/EC and bi bliograph ical data.

METABOLISMChromium VI derivatives are absorbed by the alimentary tract. Chromium VI is reduced in Chromium III in the intestine.The penetration by pulmonary way is also important. Chromium VI can pass the skin.The accumulation occurs in all organs, in particular in the lungs. Chromium is essentially eliminated via the kidneys (80%of the dose).

An urinary elimination of chromium from 40 to 50 g / L of urine or of 30 g/g of creatinine in a sample collected at theend of day seems to correspond to a middle exposure of 0.05 mg of chromium / m 3 during the day.

SKINMay cause caustic damage in case of contact, necroses and digestive and renal problems. May also cause on somesensitive people recurring ulcerations which can persist several months in case of repeated contacts.

EYE MUCOSAMay cause severe burns in case of contact.

8/10/2019 FDA 10033

4/6


RESPIRATORY SYSTEMVery toxic by inhalation. Danger of serious damage to health by prolonged exposure. May also cause sensitisation byinhalation (asthma, rhinitis).

IN CASE OF INGESTIONHarmful. May cause caustic damage, liver and kidney attacks and cardiovascular problems.

According to studies on animals, this preparation is suspected to cause on man cancer, hereditary genetic changes, lossof fertility and undesirable effects upon the unborn child (agent of the 2nd class).

OCCUPATIONAL DISEASES: tables n10, 10a (in FRANCE). ________________________________________________________________________________________________

12 - ECOLOGICAL INFORMATION

There are no ecological data on the preparation.Prevent any material from entering drains or waterways or earth .In general, a pH lower than 5 is fatal.The toxicity tends to increase with the decrease of water hardness and the increase of temperature.

ECOTOXICITYBibliographic data concerning sodium dichromate:LC50: 96 h, 69 mg Cr /L (trout, salmo gairdneri)EC50 : 24 h, 1.4 mg Cr /L (Daphnia magna)Bibliographic data concerning sulphuric acid (at 94-98 %):FISH-LC50 (24 h) = 82 mg/L, DAPHNIA-EC50 (24 h) = 29 mg/L.

DEGRADABILITY: Chromium VI in water can be reduced in Chromium III by organic matters in water; Chromium III willsettle in the sediments.

BIOACCUMULATIVE POTENTIAL: the bioaccumulation of chromium in soil and on the plants in surface is unlikely.Chromium is found in many organisms living in soft water and accumulates moderately. There is no indication of thebiologic increase of the chromium concentration along the food chain (earth, plant and animal). Sulphuric acid has a lowpotential of bioaccumulation.

According to directive 67/548/EC, the concentration of chromate ions is sufficient to classify this preparation with the Nsymbol Dangerous for the environment and the R51-53 phrase.

________________________________________________________________________________________________

13 - DISPOSAL CONSIDERATIONS This product and water used for rinsing must not be thrown away notably because of their acidity and content inchromium. They must be processed within the firm or destroyed by an approved organization.Contaminated packaging if not re-used with the same product is also special waste to be sent to an approvedorganization for recycling or disposal.Classification according to the commission directive 2000/532/EC of 3 May 2000 and its modifications (in particular2001/118/EC, OJ L47). Use the mandatory documents to follow-up the waste products.

16 09 02* Chromates, for example potassium chromate, potassium or sodium dichromate11 01 11* Aqueous rinsing liquids containing dangerous substances15 01 10* Packaging containing residues of or contaminated by dangerous substances15 02 02* Absorbents, filter materials (including oil filters not otherwise specified), wiping

cloths, protective clothing contaminated by dangerous substances

As the volume of rinsing water is small, it can be added to the waste solutions.NOTE: in addition to the community provisions, it can be specific legislative and administrative, national or localprovisions on this topic.

________________________________________________________________________________________________

14 - TRANSPORT INFORMATION

A.D.R. (road transport) Corrosive liquid, toxic, n.o.s. , class 8, classification code CT1, packaging group III, hazard label model n 8 + 6.1,restricted quantities LQ7, hazard code n 86, material code n 2922.I.M.D.G. (sea transport) Corrosive liquid, toxic, n.o.s. * , UN N 2922, class 8, packaging group III, subsidiary risk label: 6.1, restricted quantities 5L, stowing and separation: category B, away from houses, safety sheets F-A, S-B.I.A.T.A. (air transport) Corrosive liquid, toxic, n.o.s. * , UN N 2922, class 8, subsidiary risk: 6.1, risk label: CORROSIVE + TOXIC, packaginggroup III, Passenger and Cargo aircraft: packaging instructions 818, maximum quantity per package: 5 L, Cargo aircraftonly: packaging instructions 820, maximum quantity per package: 60 L, instruction IDC 8P.

________________________________________________________________________________________________

8/10/2019 FDA 10033

5/6


15 - REGULATORY INFORMATION

This safety data sheet has been established in accordance with the Corrigendum to Regulation (EC) n 1907/2006 of theEuropean Parliament and of the Council of December 18, 2006, OJ L136, 29.05.2007.The preparation labelling has been established in compliance with the directive 67/548/EC (until the 29 th adaptation:directive 2004/73/EC of April 29, 2004) and the directive 1999/45/EC reviewed in last in January 23, 2006 by thedirective 2006/8/EC.

EC LABELLING: VERY TOXIC, DANGEROUS FOR THE ENVIRONMENT Acid aqueous preparation containing more than 10 % of chromate as sodium dichromate.R45-26 : may cause cancer. Also very toxic by inhalation.R46-48/23 : may cause heritable genetic damage. Also toxic: danger of serious damage to health by prolonged exposurethrough inhalation.R22 : harmful if swallowed.R34 : causes burns.R42/43 : may cause sensitization by inhalation and skin contact.R60 : may impair fertility.R61 : may cause harm to the unborn child.R51/53 : toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.S23 : do not breathe gas/fumes/vapour/spray. S26 : in case of contact with eyes, rinse immediately with plenty of water and seek medical advice.S28 : after contact with skin, wash immediately with plenty of water.S36/37/39 : wear suitable protective clothing, gloves and eye / face protection.S45 : in case of accident or if you feel unwell, seek medical advice immediately (show the label where possible).S53 : avoid exposure - obtain special instructions before use.S60 : this material and i ts container must be disposed of as hazardous waste.

HEALTH SURVEILLANCECorrigendum to Directive 2004/37/EC of the European Parliament and of the Council of 29 April 2004 on the protection ofworkers from the risks related to exposure to carcinogens or mutagens at work, (OJ L229, 29.06.2004).

An appropriate health surveillance of the exposed workers must be carried out according to the risk.For each worker who undergoes this health surveillance, individual health and exposure records are to be made and keptup-to-date.

Other paragraphs in the French version of this safety data sheet summarize French rules regarding: occupational diseases, health surveillance, work in another company, restrictions of use, administrative declarations and rules, environment laws regarding rinsing water treatment.

See specific legislative and administrative, national or local provisions on these topics. Additional information is provided in paragraphs 8, 11, 12, 13 and 14. ________________________________________________________________________________________________

16 - OTHER INFORMATION

RESTRICTION OF USEFor industrial use only.We remain available to bring you the advice you may need.

R PHRASES OF THE PURE COMPONENTS LISTED IN SECTION 3R8 : contact with combustible material may cause fire. R21 : harmful in contact with skin.R25 : toxic if swallowed.R26 : very toxic by inhalation.R34 : causes burns. R35 : causes severe burns.R42/43 : may cause sensitization by inhalation and skin contact.R45 : may cause cancer.R46 : may cause heritable genetic damage.R48/23 : toxic: danger of serious damage to health by prolonged exposure through inhalation.R60 : may impair fertility.R61 : may cause harm to the unborn child.R50/53 : very toxic to aquatic organisms may cause long-term adverse effects in the aquatic environment.

R PHRASES OF THE PREPARATION ACCORDING TO THE SECTIONS 2 AND 15R45-26 : may cause cancer. Also very toxic by inhalation.R46-48/23 : may cause heritable genetic damage. Also toxic: danger of serious damage to health by prolonged exposurethrough inhalation.R22 : harmful if swallowed.

8/10/2019 FDA 10033

6/6


R34 : causes burns.R42/43 : may cause sensitization by inhalation and skin contact.R60 : may impair fertility.R61 : may cause harm to the unborn child.R51/53 : toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment.

BIBLIOGRAPHIC REFERENCES

European directives, INRS files, safety data sheets of the components established by their manufacturers or distributors,information of European Office of the chemical substances (ECB).

MODIFICATIONSUpdating in relation to directives 2006/8/EC, 2006/15/EC, corrigendum to regulation (EC) n 1907/2006 published in May29, 2007 and French decisions of October 26, 2007.Revised paragraphs: n2, 3, 8, 14, 15, 16.

OTHER INFORMATIONThis sheet is provided to complement, not replace, the user instructions.Information contained herein is bona fide and based on current knowledge relating to the product on the date ofpublication. Furthermore, the attention of the user is drawn to the risks which may be incurred when the product is usedfor purposes other than those for which it is designed.Information provided herein relates to this product only; it cannot take account of every situation which may arise at everywork place. This safety data sheet therefore represents only a part of the information required for establishing a safetyprogramme.Under no circumstances does this sheet dispense the user from the need to know and to apply all of the regulationsgoverning its activity, which are not all necessarily quoted herein in an exhaustive manner.

________________________________________________________________________________________________

FDA 10033

Documents

Transcript of FDA 10033