Health Insurance Marketplaces Presented by Cobbs Allen © 2013 Zywave, Inc. All rights reserved.
Fall Protection Standard 29 CFR Part 1910.21-24 © 2006, 2010 Zywave, Inc. All rights reserved.
-
Upload
katherine-cole -
Category
Documents
-
view
219 -
download
0
Transcript of Fall Protection Standard 29 CFR Part 1910.21-24 © 2006, 2010 Zywave, Inc. All rights reserved.
Fall ProtectionStandard 29 CFR Part 1910.21-24
© 2006, 2010 Zywave, Inc. All rights reserved.
Danger of Falls
• Nearly 25 percent of all seriously disabling work injuries
• 300,000 disabling injuries each year in the United States
• Second only to motor vehicle accidents as a cause of death
• Expensive, disruptive, painful and sometimes tragic – whether on or off the job
Today’s Agenda
• Types of falls• Preventing slips• Preventing trips• Falls from ladders
In today’s session, we’ll be discussing:
• Falls from equipment• Falls from loading docks• Falls on stairs• Safety footwear
Types of Falls
Same-Level Falls• High frequency, low
severity• Slips or trips on
walking/working surface
Elevated Falls• Low frequency, high
severity• >60 percent are less than
10 feet
Slips
Usually caused by a slippery surface Two types of slips
– Front foot heel slips, person falls backward– Rear foot slips backward, person falls forward
Prevention through dry walking and working surfaces – Non-skid strips or floor coatings
Prevention through slip-resistant footwear– Cleated, soft rubber soles
Trips, Step and Fall
Trips occur when front foot strikes an object, stopping it.
Causes of trips:– As little as 3/8” rise in a walkway– Difference in height of stairs– Objects in walkways
Step and fall occurs when front foot lands on a surface lower than expected
Fall results from a step forward or down, when inside or outside of foot lands on an object higher than the other side.
Causes of Injury
• Inadequate housekeeping• Inadequate lighting• Carrying objects that
obstruct vision• Walking too fast or running• Distractions, not watching,
sunglasses, failure to use handrails
Slips
Step and fall
Trips
Falls from Ladders
Use only ANSI-approved ladders– Never use metal ladders where they could come into contact with
electricity
Top three rungs/top two steps should never be used for standing
For each 4’ of rise, the base should be 1’ out
Ladder must be absolutely stable Ladder must be thoroughly inspected
before use Use heeled shoes – rung goes just in front
of heel Face ladder while climbing, belt buckle
between rails
Falls from Equipment
Extra riders falling from tractors, equipment or the bed of a truck can lead to death or serious injury
Safest way is no riders If the operation requires riders, they must
have seats or protected work areas Many injuries occur due to slippery metal
steps – keep them dry Grip tightly with both hands before stepping
up
Falls from Loading Docks
Metal dock plates can be slippery, edges of plates can cause trips
Proper housekeeping, following traffic patterns, use of abrasive, skid-resistant surface
Falls on Stairs
Have one hand free at all times to hold on to handrail
Keep steps free of grease and oil
Avoid carrying bulky or heavy objects that obscure your vision or require both hands
Additional Fall Prevention
Use fall protection devices when working at high elevation: ladders, platforms, catwalks
Protection system could be: a protective cage, lifeline, lanyard or safety belt/harness
Change warning signs often and remove when no longer applicable more effective
Safety Footwear
Shoes and boots provide three types of protection:
Slip-resistant soles and heels Crush-resisting toe Ankle support
Always use ANSI-approved work shoes Softer soles are for slippery indoor
conditions In wet environments or around chemicals,
oils, greases or pesticides, wear PVC boots
What should I remember?
Regularly inspect working and walking areas to identify slip, trip and fall hazards
Prioritize housekeeping and clean up spills immediately
Be sure you always have good light and nothing is blocking your view of your path
Follow all precautions when using equipment If you see a hazard, correct it if possible or
inform a supervisor immediately Always wear proper PPE, especially proper
footwear Report any injuries immediately so The Lilly
Company can prevent future incidents