Presented by: XP EMCO

EMCO High Voltage Corporation

About EMCO High Voltage Corporation For over four decades, EMCO, now a part of XP Power has led the industry in designing and manufacturing high voltage power supplies for original equipment manufacturers, research laboratories and educational institutions worldwide.

©2016 XP EMCO

Mike Doherty Vice President, High Voltage Products

Mission Statement

Our mission is to deliver excellence and remain at the forefront of high voltage technology, while safeguarding our environment.

©2016 XP EMCO

Leading the Industry… • High Performance • Ultra-Miniature • Long Term Reliability • High Volume Manufacturing • Low Power Designs

©2016 XP EMCO

High Voltage Solutions for Demanding Applications

©2016 XP EMCO

Biotechnology

Healthcare

Semiconductor Manufacturing Equipment

Air Filtration

Scientific

Awards

©2016 XP EMCO

• 2 Product of the Year Awards: Electronic Products Magazine

• Product of the Year Runner-up: EE Product News • Innovative New Product of the Year Electrical Engineering:

Elektronik (Germany’s Top Power Supplies) • Most innovative new product: University of California, Davis • Six Editor's Choice Awards: Electronic Products Magazine • Honored for Significant Contributions to

Ice Cube, World's Largest Scientific Instrument • ….plus many more

Ice Cube Neutrino-Telescope • Result: 123 years calculated

Mean Time To Critical Failure (MTTCF) • Result: 5000+ delivered 100% on-time • Result: No failures from systems

integration through actual operation in the ice

• Attest: Key supplier award from Ice Cube program management

©2016 XP EMCO

Ice Cube Neutrino-Telescope • Application: Mission-critical component in

the world’s largest scientific instrument • Application: Powering an eleven stage photo

multiplier tube (PMT) • Severe Environment: Must operate for

20 years at 45°C • 24/7/365 1½ miles down in deep Antarctic ice

at geographic south pole • Precision: <2.4 PPM P-P ripple at 2050 Vout.

©2016 XP EMCO

In the Media: Ice Cube Neutrino-Telescope

©2016 XP EMCO

Expanded Manufacturing Locations California Operations – Sutter Creek, California

©2016 XP EMCO

XP EMCO Design Center California Operations – Sutter Creek, California

©2016 XP EMCO

Expanded Manufacturing Locations Nevada Operations – Minden, Nevada

©2016 XP EMCO

CubeSAT • A CubeSat is a type of miniaturized satellite

for space research that usually has a volume of exactly one liter (10 cm cube), has a mass of no more than 1.33 kilograms,[1] and typically uses commercial off-the-shelf components for its electronics.

• Radio Aurora Explorer - RAX CubeSAT was made by SRI.rch

• SRI, in collaboration with the University of Michigan, designed the RAX mission and spacecraft to investigate the causes of turbulence in the Earth's ionosphere, a portion of the upper atmosphere that is ionized by solar radiation. A second RAX spacecraft has been planned for launch in September 2011 on a Delta-II rocket.

©2016 XP EMCO

“Flex-Chain” Scalable Production Capacity Flex-Chain is a group of certified factories with diverse capabilities that are selected to answer the exact supply chain needs of customers regardless of order lead-time, order quantity, or production run-rate.

©2016 XP EMCO

General features • XP EMCO Oscillator technology is proprietary, quasi-

sinewave, low EMI / RFI, not a switcher. • Transformer built in house or by qualified manufacturing

partner, ferrite pot core. • Fully Encapsulated – can work in vacuum conditions,

suitable for oil immersion. • DC input only – includes battery inputs. • Miniature packaging. • Made in the USA.

©2016 XP EMCO

Selecting a Power Supply • Output Power = Voltage x Current

– Up to 15-Watt for standard products – Up to 50-Watt for custom products

• Regulated vs. Proportional

– Proportional = Unregulated – Regulated models usually have lower ripple – Proportional models are usually lower cost and in a smaller package

©2016 XP EMCO

Proportional products • Features

– Power and control from a single input – Output is load dependent – Spec’s are for Full Load – Smallest size available – Ripple is usually higher than regulated models, less filtering included – Input to Output Isolation – Can be regulated with external circuitry

• Series: Q, A, G, GP, FS, F, E

©2016 XP EMCO

Block diagram

Proportional products • Input is Proportional to Output

[0.7Vin turn-on voltage] • Input to Output is linear, but… • It depends on the output current

or load condition • Load Dependent = Unregulated • Lighter load = steeper slope

©2016 XP EMCO

Regulated products • Features

– Output will change <1% regardless of load condition: “Load Regulation” – Input power separate from low power programming voltage input – Includes feedback circuitry for precision regulation – Non-isolated design – More circuitry and more

filtering = larger than proportional

• Series: C, CA, H, ULP, 4000, DX, USB

©2016 XP EMCO

Block diagram

Regulated products • Output voltage tracks

programming voltage input • Programmable down to zero Vout • DAC => analog voltage

programming input • Voltage monitor output

analog signal => ADC

©2016 XP EMCO

XP EMCO sample product case

©2016 XP EMCO

Proportional — Up to 1.5 Watt • A / AH Series

– 1 Watt / 1.5 Watt – Low profile, 0.25in height – Up to 6KV, 5 / 12 / 24V inputs

• Q Series

– ½ Watt / 1.25 Watt – Smallest board space – Up to 5KV in ½ inch cube – 6KV / 8KV / 10KV in 0.85 inch cube

• G Series, GP Series

– 1.5 Watt / 1 Watt – Legacy Product, Low Cost – Up to 6KV, 12Vin, 1.5 x 1.5 x 0.6in

©2016 XP EMCO

Introducing the NEW Micro-Power P Series • Ultra-Low Noise Magnetic Free Design • 2kV @ 2mW / 1200V @ 2.4mW • Low Profile, Regulated • Programmable

©2016 XP EMCO

CB Series • 1W up to +/-10kV, Regulated • Programming Over-Voltage Protection • Voltage Monitor • Current Monitor • Built-In Thermal Shutdown

©2016 XP EMCO

AG Series — Only 0.128” high! These surface mount devices feature a unique package occupying less than one tenth of a cubic inch of volume, and an extremely low profile of only 0.128 inches (3.25mm) above the host circuit board!

©2016 XP EMCO

Proportional — 3 Watt to 10 Watt • FS Series

– 10 Watt, Next generation, 2010 intro – 1/3 reduction in size, 0.5 inch profile – Advanced internal thermal management – SMART FEATURES

• Over-Temperature Protection • Input Over-Voltage Protection • Automatic Shutdown and Error Code Output

– Up to 6KV, 12 / 15V / 24V inputs

• F Series / E Series – 10 Watt / 3 Watt – Legacy Product, Low Cost – Up to 12KV out, 12V / 15V input – Robust Isolated package

©2016 XP EMCO

Regulated — 1 Watt • C Series

– 1 Watt, Up to 8KV output – Low profile, 0.5in height up to 6KV – 8KV model 0.6 inch height – 12 / 15V input, 0 to +5VDC Vpgm

• CA Series

– 1 Watt, Up to 2KV output – Improved ripple and regulation – Low profile, 0.5in height – Two input options

• 12V input, 0 to +5VDC Vpgm • 5V input, 0 to +2.048V Vpgm

– Voltage monitor output, mirrors Vpgm – Voltage reference outputs, fixed Vout

• Can be used for Vpgm input

©2016 XP EMCO

Regulated — 4 Watt and 15 Watt • H Series

– 15 Watt, Up to 10KV output – Low cost legacy product – 12 / 15V input, 0 to +5VDC – Robust arc and short circuit protection

• ULP Series

– 4 Watt, Up to 5KV output – Battery powered

• Input voltage range is 5.4 to 7.4 volts • Dual Li-Ion ‘AA’ Batteries • 4500 hrs operation at No Load

– Perfect for “green” designs, lightweight – Shutdown pin drops current consumption to less than 5 uA

©2016 XP EMCO

Other • Custom Products

– Thermal Design, high and low temp – Low noise, high quality output – Sequencing and control – Battery input, low power – Packaging, miniature / custom size,

terminations

• Accessories – C and CA Series Mounting Kits – FS Series Evaluation Board – V1G Voltage Divider

• Higher Voltages – DX Series, 1.5 Watt – Proportional type – 4000 Series, 10 Watt – Regulated type

• Application Specific – HC Series – Octo-Channel System – USB Series

©2016 XP EMCO

XP-EMCO Certified Logos

©2016 XP EMCO

XP EMCO Main Office 1 EMCO Court

Sutter Creek, CA 95685 (209) 267.1630

www.xppower.com/Support/Contact-Us

VCN7178A