Electric wiring kit for towbars / 13-pin / 12 Volt / ISO 11446 · 6/20 8 9 10 11 12 X Option 1...
Transcript of Electric wiring kit for towbars / 13-pin / 12 Volt / ISO 11446 · 6/20 8 9 10 11 12 X Option 1...
Part No: AU-068-13M
1/20
Audi Q5 01/2017->Audi Q7 06/2015->Audi Q7 E-tron 2015->
Audi Q8 08/2018->VW Touareg III 06/2018->
Electric wiring kit for towbars / 13-pin / 12 Volt / ISO 11446
This electric kit has to be installed by a professional workshop or a suitable qualified person.The installation instructions must have been read and fully understood before the start of any installation. Please contact your wiring kit provider or the hotline shown in the footer should you need assistance!Make sure the vehicle is approved/homologated by the manufacturer to tow a trailer! Also please check that there is a definite compatibility between this vehicle and the electric kit!Following the installation of the electric kit, the fitting instructions should be kept together with the vehicle service document and vehicle handbook. The fitting instructions contain important information relating to the use and function of the towing kit as well as for any diagnostic or activation process, that might have to be repeated in the future (e.g. after the performance of a vehicle software update).All warranty claims will be forfeited if the electric kit or components contained therein are used incorrectly or modified. If a towing socket adaptor has been used to connect to the trailer or bike rack, this must be removed from the trailer socket once the trailer or bike rack has been disconnected.If the trailer or bike rack is not equipped with a rear fog lamp, depending on the towing vehicle type, the correct function of the towing kit cannot be guaranteed. In such cases, a rear fog lamp should be retro fitted.This towing electric kit will not be covered under warranty if any technical or electrical modifications or software updates have been performed by the vehicle manufacturer after the initial commissioning of the kit. That applies especially to modifications or updates which may cause malfunctions in the trailer socket or any other part of the trailer electrical equipment!Depending on the type of trailer module used in this electric kit, diagnostic interrogation with the vehicle’s electrical system may be limited or will not function. The error memory inside the trailer module may not be able to be accessed by vehicle manufacturers diagnostic system.Error logs relating to the trailer electrical equipment, that may be generated in the vehicle manufacturers diagnostic system as a result of a test procedure, may be due to the incorrect installation of the towing electric kit or the false activation of the trailer module.We always recommend whenever possible, the following troubleshooting process: An analysis of the vehicle’s error memory and possibly clearing of all faults before the start of the installation! Try disconnecting the trailer module from the towing harness and re-start the fault clearing process! If in doubt, limit the time for troubleshooting to a max of 0,5 hours and call our Technical Support Team!Please follow our instructions carefully and always test the towing electrics using a true lighting board or a specifically designed bulb tester. If an LED tester is used, ensure it is equipped with correct load resistors or malfunctions will occur! This instruction is subject to changes and we reserve the right to make changes to design, colour etc. All of the data and illustrations may not be an exact representation but the text contained in this instruction must be observed!
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
2/20
5x
3x3x
2x
3x 3x
10x
4-14
M
20 Amp.
20 Amp.1x15
Amp.
15 Amp.2x
1x
R
U
B L1
L3
L4
L2
XA
M1
R1 T
G
2x
Optional
15-41
SUPPLIERS OF TOWBAR WIRING KITS FOR THE UK
*************** -->
Part No: *********
1/**
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Revision: * / **********RC-MIT001-7 /*******
Web: www.rightt
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
3/20
SYMBOL EXPLANATION
TOOLS
Left (58-L) respectivelyRight (58-R) tail light
Stop light (54) / high mounted, third stop light (54)
Turn signal indicator left
Turn signal indicator right
Rear fog light(s)
Reversing light(s)
Trailer / trailer recognition
Permanent current power supply
Ground or Earth (31)
Ground connection battery terminal lug
Permanent power supply / 13pin socket, chamber 9
Charging wire for trailer battery / 13pin socket, chamber 10
+
15+
+
30+
Positive connection battery terminal lug
54 STOP
L
R
Reverse
B+/30
Fuse / fuse capacity 20 Ampère
Cigarette lighter /accessory socket
Loudspeaker / buzzer
Park Distance Control
Switch / source of function
Connect together
Disconnect
Look at / See further information
Look carefully at selected area
Present / Occupied / OK
Not present / Not occupied / Not OK
Acoustic indication
Attention / important advice
20 Amp.
20 Amp.
12V
1
ATTENTION!
ATTENTION! In order to avoid mal-functions and damage to the vehicle’s electrical system the earth terminal must be disconnected from the vehicle’s battery before starting work!
Both the trailer module and the vehicle’s control unit for the electrical system can be damaged during workon the data bus connections if the battery is not disconnected!
Please pay attention to the manufacturer’s instructions when disconnecting and reconnecting the vehicle’s battery!
The vehicle's cooling capacity may have to be increased when retrofitting a trailer coupling!You must observe the manufacturer's instructions!!
!Code
3:3
Note: It may be necessaryto check if this vehicle hasa stored radio code beforedisconnecting the battery!
Co
Co
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
4/20
2
3
4
Q5
Q5
TX
SEAL WITH SILICONE.
2
3
1
1
2
3
4
6
5
1
2
36
5
4
Only if fitted!
Q7, Q8 & Touareg
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
5/20
5
6
7
Q5
TX
2
SEAL WITH SILICONE.
1
3
Q7, Q8 & Touareg
Q7, Q8 & Touareg
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
6/20
8
9
10
11
12
X
Option 1 Option 2
SOCKET CONNECTION
1-8 STOPReverse 10 9
21W21W 21W 42W 3x21W 42W 21W 180W 180W
DIN/ISO 11446
Pmax
YellowColour Blue White Green Brown Red Black Pink Orange Grey White/Black - White/
Red
1/L 2 3/31 4/R 5/58-R 6/54 7/58-L 8 9 10 11 12 13
+
15++
30+L R
X
X
Option 1
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
7/20
13
16
14
1 2 3Option 2
1 2 3Option 2
15
MM1M
M
1 2 3
4
R1
R
1 2 3 4
R R
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
8/20
17
18
M
R
2
1
3
Q5
2
1
M
R
Q7, Q8 & Touareg
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
9/20
19
21
Q5
10 mm1
2
G
25 49
+42 49
22 24
Prepared Trailer Connector
Vehicles with trailer preparation
Vehicles without trailer preparation
Black10 pin
Black/Violet6 pin
Black10 pin
Black/Violet6 pin
20
10 mm1
2
G
Q7, Q8 & Touareg
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
10/20
22
23
A
21 3
1
2
3
4
Black10 pin
Black/Violet6 pin
Q7 E-TronQ5
Q7 & Q8
Touareg
Q5 Q7 & Q8
Touareg
Q7 E-Tron
Fusebox B (2)Red
Fusebox HWhite
Fusebox ERed Fusebox B
Red
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
11/20
26
24
25
AB
21 3
1
1
2
2
3
Black10 pin
Black/Violet6 pin
15 Amp.
15 Amp.
15 Amp.
15 Amp.
20 Amp.
20 Amp. Pos. 5
Pos. 8
Pos. 9
B+/301
2
3
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
12/20
29
27
28
UNLOCK1
3
2
Connector 32 pole Blue
Connector 32 pole Blue Connector 32 pole Blue
1 2
16
1
Pos. 2Orange/Green or GreenCAN
H
Pos. 1Orange/BrownCAN
L Can-busDatawire
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
13/20
30
32
31
Connector 32 pole Blue
2
1
3
LOCK
Connector 32 pole Blue
16
1
LOCK Orange/BrownPos. 1
Orange/GreenPos. 2
1
2
3 L1
Pos. 1Orange/Brown
Pos. 2Orange/Green
4
Pos. 2Orange/Green or GreenCAN
H
Pos. 1Orange/BrownCAN
L
L2
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
16
1
Pos. 12Black/Red or BlackSTOP
Pos. 17Black or Black/Purple
+15
Connector 32 pole Black Connector 32 pole Black
1 2
14/20
33
35
UNLOCK1
32
Connector 32 pole Black
34
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
15/20
36
38
37
2
1
3
LOCK
Connector 32 pole Black
Connector 32 pole Black
16
1
LOCK
1
2
34
5
L4
Blue/RedPos. 3
BlackPos. 2
L3
Pos. 3Black/Red or BlackSTOP
Pos. 2Black or Black/Purple
+15
Pos. 12Blue/Red
Pos. 17Black
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
16/20
12
3
39
4
U
Pos. 9Pos. 8Pos. 5
Orange
Red/Blue
Red/Yellow
Q7 E-TronQ5
Q7 & Q8
Touareg
Q5 Q7 & Q8 Q7 E-Tron
Fusebox B (2)Red
Fusebox ERed
Fusebox ERed
Fusebox BRed
Fusebox B (2)Red
Touareg
Fusebox HWhite
Fusebox HWhite
Fusebox BRed
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
17/20
40
41
2
1
4
3
15 Amp.
15 Amp.
15 Amp.
15 Amp.
20 Amp.
20 Amp.Pos. 5
Pos. 8
Pos. 9
Fusebox ERed
Fusebox BRed
Fusebox HWhite
Q7 E-TronQ5
Q7 & Q8
Touareg
Q5 Q7 & Q8 Q7 E-Tron
Fusebox BRed
Fusebox ERed
Fusebox ERed
Fusebox BRed
Fusebox BRed
Touareg
Fusebox HWhite
Fusebox HWhite
Fusebox BRed
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
18/20
42
! Code3:3
Set up trailer operation
43
! VolkswagenSeatAudi
VolkswagenSeatAudi
Diagnosis Services or diagnostic methods (local / offline):
Please note:
Always use the latest diagnostic version!The vehicle to be coded must be supported by the diagnostic service provider and already be implemented in the diagnostics version!Please contact your diagnostic service provider in case of any question.
- ODIS - Hella Gutmann- VCDS- Autologic- Bosch / KTS- SP Diagnostic- SUN- Jifeline- Autocom- etc. pp.
CODING WITH ODISPlease note:
The procedure described below for encoding andenabling the trailer mode only serves for a generalorientation and can vary greatly depending on themodel (motorisation / equipment). If necessary less orfurther control units will have to be adapted.
After connecting to ODIS, the “69 trailer function”controller has to be set to encoded in the targetinstallation list.
The following may be necessary in the further courseof work:
EZE_09 (electronic central electric controller): Diagnosis (possible login code: 31347) Networking plan Controller self-diagnosis Encode Trailer connection device ›installed or: hitch_ecu ›installed
Alternative encoding EZE_09 as follows (MY 2017 >>): Self diagnose control unit Access authorization ›31347 Adjustment Integration Trailer control unit > installed
ZKS_46 (Central module convenience system) trailer monitoring ›put on active trailer control unit ›installed
SWA_3C (Lane Change Assist) ECU for draw bar ›with ECU for draw bar
SW2_CF (Lane Change Assist2) ECU for draw bar ›with ECU for draw bar
SCH_17 (Dash panel insert) Trailer ›yes
RFK_6C (reverse camera system) equipment_ahk ›installed
STF_74 (chassis control system) Trailer ›installed
EPH_76 (PDC controller) Trailer ›trailer device can be removed manually
DIS_13 (controller distance control (possible login code: 20103) Control module for towing sens ›installed
Alternative encoding DIS_13 as follows: Self diagnose control unit Access authorization ›20103 Encoding Binary encoding Byte 3 Binary ›xxxx1xxx or Hex ›+8
FFF_A5 (front sensor system controller) AAG ›coded
HDE_6D (boot lid electronics controller) Trailer ›installed
Important note on encoding and activating intrailer modeThe aforementioned settings are carried out in thevehicle's electrical system and saved locally. Duringgeneral updates for the vehicle software (for example,within the scope of service or repair work), the settings may be overwritten and deleted under certain circumstances. In this case, the trailer mode activationhas to be updated again locally after the update.Diagnostic information relating to the trailer mode thatmay appear during variance comparisons with thedata saved in the manufacturer's works, may form thebasis of the local activation.
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
19/20
44
46
45
Optional
L 54 STOPR
Reverse+
30++
15+
L R
MENUOK
P 500 miles6666 miles
Driving Aids
6:00 AM 36 F
C H0
1
23 4
56
7
8
RPMx1000
1/210
20
40
6080
100
120
140
160
20
40
60
80100
120 140160
180
200
220
240
260km/h
LED
!
L R
Trailer Simulator for 7- and13-pin Sockets
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
20/20
47
49
48
Adapter socket
Optional
13-pin 7-pin
SUPPLIERS OF TOWBAR WIRING KITS FOR THE UK
*************** -->
Part No: *********
1/**
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Revision: * / **********RC-MIT001-7 /*******
Web: www.rightt
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www
Revision: 2 / 25.01.2019AU-068-13M
Righ tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www.rightRigh tdUnit 503 Queensway Business ParkTELFORD TF1 7UL UK
SALETE
Web: www