PRODUCT NAME KANSAI Economy Enamel Project Pack

Product Code A315 Line

DESCRIPTION Kansai Economy Enamel Project Pack is a high quality solvent-based enamel with gloss finish, suitable for use on all type of interior and exterior wood and metal surfaces. Kansai Economy Enamel Project Pack gives superior coverage and

PACK SIZE 3.64 and 14.56 litres

COLOR RANGE See appropriate shade card

FILM PROPERTIES

Chemical Resistance Resistant to mild chemical fume attack but where there is heavy attack, e.g. actual contact with chemicals, special paint system are recommended.

Heat Resistance Generally resistant to heat up to 90OC, but some discoloration of light colours may

occur at temperatures above 80OC.

Water Resistance Resistant to the levels of atmospheric humidity present in normal interior and exterior environments and will with stand repeated washing. Not suitable for use on immersed surfaces.

COMPOSITION (NOMINAL)

Pigment: Lightfast Non Lead Pigments Binder: Alkyd. Solvent: White spirit

VOLUME SOLIDS White 40% (nominal), other colours may vary

DRYING TIMES Single coat at standard film thickness

Touch Dry 2-3 hours

Re-Coat 16 hours

FILM THICKNESS Wet: 50-55 micrometers

Dry: 20-25 micrometers

PRACTICAL COVERAGE A guide to the practical coverage which can be achieved under normal conditions is 13-15m2 /litre /coat.

APPLICATION Brush, Roller Spray

THINNING

Brush Add up to 0.6 parts of white spirit to 4 parts of paints (15-20%)

Roller Add up to 0.4 0.5 parts of white spirit to 4 parts of paints (10-12%)

Conventional spray Add up to 1 part of white spirit to 3 parts of paint (30-40%)

SPRAY RECOMENDATIONS

Conventional Spray Satisfactory through most equipment

CLEANING UP Clean all equipment with white spirit immediately after use.

KANSAI ECONOMY ENAMEL

DECORATIVE PAINTS

E

Japans No.1

SURFACE PREPARATION

New Paint

New surfaces must be clean, dry and free from all defective or poorly adhering material. Such as dirt grease wax etc. Remove any rust or scaling from the surface with a suitable sandpaper. Apply a coat of Kansai Red Oxide Primer or Zinc Phosphate Primer. Let the surface dry overnight. Scuff (wet or dry as the conditions allow) the surface, dust off and clean residual powder with petrol or turpentine dampened cloth.

Repaint for sound surface If the surface is sound and intact, gently scuff the surface with a fine water proof sandpaper, dust off and clean the residual powder with petrol or turpentine dampened cloth.

Repaint For Powdery, Dusty Surface, Cracks and Other Surface Defects

Remove any loosely adhering material with the help of a scraper, suitable sandpaper or wire brush. Apply a coat of Kansai Red Oxide Primer or Zinc Phosphate Primer. Let the surface dry over night. Scuff the surface dust off and petrol wipe.

Galvanized and Aluminum Surface New galvanized surface should be cleaned and degreased. Then pre-treat the surface with an appropriate pretreatment primer to ensure good adhesion. A coat of Kansai Red Oxide Primer with further improve the adhesion.

Finishing Apply 2 or more subsequent coats of Kansai Economy Enamel. Stir thoroughly before use.

SYSTEM INFORMATION

FLASH POINT 320C

SAFETY, HEALTH AND ENVIORNEMENT INFORMATION

The product contains white spirit. Ensure adequate ventilation and lighting.

The product is flammable, keep away from source of ignition.

Keep windows and doors opened at all times. Dont use in confined spaces

Keep container tightly closed and out of the reach of children

When applying paint it is advisable to wear eye protection

In case of contact with eyes rinse immediately with water and seek medical assistance

To remove splashes of paint from skin use water and soap or a recognized cleaner

Avoid contact with skin, it may cause sensitization. Repeated exposure may cause skin dryness or cracking

If inhalation causes physical discomfort, move to fresh air

It is harmful if swallowed. In case of ingestion, seek immediate medical advice

In the event of spillage, contain and collect spillage using sand and soil

Dont empty into drains or water courses

Dont use empty container for food storage

Product safety data sheet is available on request

Protect the product from extreme of temperatures

Contains no added lead or mercury

KANSAI ECONOMY ENAMEL

Wood Primer (1 Coat)

Finish (2 or more coats)

Kansai Economy Enamel Metal Kansai Red Oxide Primer

Masonry Kansai Wall Primer

Appropriate wood primer

DECORATIVE PAINTS

E

Japans No.1