COGNIZANCE RESEARCH INDIA PVT. LTD. GT-20...

Pre-Feasibility Report

Submitted by

Prepared by

COGNIZANCE RESEARCH INDIA PVT. LTD.

GT-20, SECTOR-117, NOIDA

Uttar Pradesh QCI-NABET Accredited Organization NO. NABET/EIA/1619/IA 006

BUILDING-STONE (GITTI-BOULDER)

SAND STONE

Gata No. 1mi Khand No.K/2

Village:Kewalpur, Tehsil: Meja

District: Prayagraj, Uttar Pradesh.

Sh. Vijay Bahadur/111142 R/O Village-Panti Meja Khas Tehsil-Meja,

District: Prayagraj, Uttar Pradesh

Project: : Mining of Minor Building Stone

(Gitti- Boulder) Sand stone

Category:

B2 PRE-FEASIBILITY REPORT

Proponent: Sh. Vijay Bahadur

Area: 2.024 Hac

Project Site:

Village: Kewalpur Gata No. 1mi Khand No. K/2.

Tehsil: Meja District: Prayagraj UttarPradesh

Page | 2

Executive Summary

S. No Information Details

1. Project Name Mining of Minor Mineral Building Stone (Gitti-

Boulder) Sand stone

2. Project Proponent Shri Vijay Bahadur/111142

3. Project Coordinates

1mi Khand No. K/2.

Pillar Name N E

A 250 07.827’ 820 16.410’

B 250 07.858’ 820 16 .478’

C 250 07.950’ 820 16.485’

D 250 07.934’ 820 16.416’

4. Toposheet No. 63G12

5. Altitude of the Area

The highest and lowest point in the leasehold is

108.60mRL towards North-East direction and

99.10mRL towards South-West direction

6.

Location Kewalpur / Meja / Prayagraj /UP

Lease Hold Area 2.024 Ha

Village Kewalpur

Tehsil Meja

District Prayagraj

State Uttar Pradesh

7. Topography of Mine lease area Stony Scrub covered with sand stone all around

8. Name of the Mineral Mining Sand stone (Gitty-Stone,Khandas & Boulder)

Mining

9. Mode of Mining Semi Mechanized

10. Capacity of Production 20240 m3 per year (50600 MT)

11. Drilling / Blasting Mild Blasting may be required

12. Man Power Used 24



Category:



Area: 2.024 Hac

Project Site:



Page | 3

13. Land utilization Pattern

sand stone(Gitty-stone,Khandas & Boulder)is

available only and no other use of the lease land is

anticipated

14. Water requirements and source 0.24 KLD, Water in tanks will be procured from

the nearby villages

15. Solid waste Negligible belonging to biodegradable category

1.0 INTRODUCTION OF THE PROJECT / PROJECT BACKGROUND

1.1 Introduction of the Project

Name of Project: Building Stone (Gitti- Boulder) Sand stone

Location of Project: Gata No. 1 mi khand No. K/2,

Village: Kewalpur,

Tehsil: Meja,

District: Prayagraj

State: Uttar Pradesh

Production: 20240 m3 per year (50600 MT)

Total ML Area 2.024 Ha

Name and address of the project proponent: Shri Vijay Bahadur/111142

Village: Panti Meja Khas, Tehsil:Meja,

District: Prayagraj State: Uttar Pradesh

1.2 Brief description of the nature of project

The capacity enhancement project has been proposed by Shri Vijay Bahadur/111142

Singh resident of Panti Meja Khas, District Prayagraj, Uttar Pradesh. The Project is proposed for

mining of minor mineral Sand Stone within 20240 m3 per year (50600 MT) capacity per years



Category:



Area: 2.024 Hac

Project Site:



Page | 4

from the non-forested, non-arable, rugged stony scrub within the mining lease area.

Need of the project and its importance to the country and or the region

Extracted mineral will be used for various infrastructural projects going around the state of Uttar

Pradesh. Abundant resource is available and mining under careful manner from the non-forested and

non-arable stony waste lands is the most preferable and legally valid land use. Such mining projects

boost up the local as well as the economy of state because of rapid and cost effective infrastructural

development.

1.3 Demand supply gap

Sand Stone mining from the stony waste land is the most preferable and legally valid land use.

Current sand stone mining project is particularly for meeting the requirement of regional

infrastructural projects such as roads construction and as building material. The current demand is

45% as high as the current supply.

2.0 Export possibility

No there is no room for export.

Domestic / Export Markets

Domestic demands of sand stone are higher than what is made available today.

Employment Generation (Direct and Indirect) due to project

Semi Mechanized mining will require 24 local heads to be employed.

3.0 Project description

3.1 Type of project including interlinked and interdependent projects, if any

The project involves sand stone extraction and it is not interlinked with any existing project.

3.2 Location of project

The mine lease area can be approached by following NH 76 from Allahabad city (Allahabad to Tikri)

up to Tikri. Following NH 76 turn towards North direction, following National Highway-76

(Chilbila-Rajapur) up to the mine lease. Manda road railway station is about 6.0 kms in South

direction away from project site. The nearest Airport is at Bamrauli Allahabad 63.0 km from the

project site in NW direction.



Category:



Area: 2.024 Hac

Project Site:



Page | 5

3.3 Details of alternate sites considered and the basis of selecting the proposed site, particularly

the environment considerations gone into should be highlighted

No other site is considered for the proposed mining.

3.4 Size or magnitude of operation

Total mineable reserve is 20240 m3 per year (50600 MT) of Building Stone (Gitti- Boulder)

Sand stone. The quantity of geological reserve is 687436 m3 which is much higher than what is

proposed to be extracted.The mine lease (ML) area is 2.024 Ha and lies in B2 category.

3.5 Raw material required along with estimated quantity, likely source, marketing area of final

product(s), mode of transport of raw material and finished product

No raw material is required during the operation.



Category:



Area: 2.024 Hac

Project Site:



Page | 6



Category:



Area: 2.024 Hac

Project Site:



Page | 7

S. No. Purpose Water Requirement (KLD)

1. Dust Suppression 6.0 KLD

2. Irrigation 1.0 KLD

3. Domestic (drinking) 0.24 KLD

Total Water Required 7.24 KLD

Energy Power Source

8 hrs.of working in two shifts, need no temporary shelter however; single temporary shelter has been

proposed here as tents for one or two persons to be used in case of any minor medical problems in the

working hour.

3.7 Quantity of waste to be generated (liquid or solid) and scheme for their management /

disposal

Solid waste generation is expected from the mining procedure. 24 work personals including the works

man and the administrative staff are supposed to produce waste like guthka pouches, smoking litter,

and wrap papers etc. belonging to biodegradable category waste however; Environmental

Management Plan is also proposed to manage the solid waste.

3.7.1 Waste generation and disposal of waste

No significant waste is expected to be generated from the site.

3.7.2 Generation of waste water

There is no waste water generation during the process.

3.6 Availability of water & its source

4.0 Site analysis

The proposed project site located at Gata No: 1mi Khand No. K/2. at Village Kewalpur, Tehsil Meja,

District Prayaraj lies in Survey of India Toposheet No. 63G12 Uttar Pradesh covering an area of

2.024 Hac. The mining lease area belongs to the stony scrub and has no any other use except mining.

No seasonal & perennial drainage exists with in the applied area. General slope of the area is towards

North-East to South-West direction. The highest and lowest point in the leasehold is 108.60mRL

towards North-East direction and 99.10mRL towards South-West direction. The project site is well

Total Water Requirement



Category:



Area: 2.024 Hac

Project Site:



Page | 8

connected with the network of the roads however; few patches require to be repaired.

(iv) Existing land use pattern and distances from forests, CRZ etc.

The existing land area is almost hundred percent waste lands. There is no forest land exist in near

area. The existing land use is given in table given below:

S.

No.

Land Use Pattern Agricultural

Land (Ha)

Forest Land

(Ha)

Waste Land

(Ha)

Grazing

Land (Ha)

1. Land under

excavation

None None 2.024 Ha None

2. Approach road Not Required Not Applicable -- --

3. Dumps Not Required Not Applicable Not

Applicable

--

4. Office, Rest shelter etc. Not Required -- -- --

5. Balance undistributed

land

-- -- 2.024 Ha --

Total 2.024 Ha

(v) Existing infrastructure

a) Roads:

The mine lease area can be approached by following NH 76 from Allahabad city

(Allahabad to Tikri) up to Tikri. Following NH 76 turn towards North direction,

following National Highway-76 (Chilbila-Rajapur) up to the mine lease. Manda road

railway station is about 6.0 kms in South direction away from project site. The nearest

Airport is at Bamrauli Allahabad 63.0 km from the project site in NW direction.

b) Water Supply:

The people of the nearby villages depend upon the wells and the tube well for water. The

average water table level in the region ranges at 23-25 m. below the ground level. River

Tons is the main drainage of the region and flows 10 km from the project site to wards

North. The staff/workers shall use water from the well.

c) Electrification:

The village and its surrounding villages have electricity connection while lease area is not

connected with electricity.

d) Educational – Facilities:

e) Primary school Rajapur 2.0 Km anerial distance N-W direction from project site



Category:



Area: 2.024 Hac

Project Site:



Page | 9

f) Health Service:

Primary Health centre ,Manda 5.0 Km aerial distance NW direction from project site.

g) Postal – Facilities:

The nearest post office is at Meza, 25.0 Kms in West direction.

h) Transport:

The mine lease area can be approached by following NH 76 from Allahabad city

(Allahabad to Tikri) up to Tikri. Following NH 76 turn towards North direction,

following National Highway-76 (Chilbila-Rajapur) up to the mine lease. Manda road

railway station is about 6.0 kms in South direction away from project site. The nearest

Airport is at Bamrauli Allahabad 63.0 km from the project site in NW direction.

(vi) Climate data

a) Temperature:

Sub-tropical climate with varying summer and winter temperature profile from day to night

and ranges between 30°C–42°C, and 2°C–15°C respectively.

b) Rainfall:

District Prayaraj has humid sub-tropical climate with large variations between summer and

winter temperatures. Summers are long, from early April to October, with intervening

monsoon seasons. Cold waves from the Himalayan region cause temperatures to dip across

the city in the winter from December to February. The average annual rainfall is 786 mm.

c) Humidity:

The maximum and minimum humidity in morning is 98% and 44% in the month of August

and May and in the evening 96% and 25% in the month of August and May.

(vii). Social infrastructure Available

a) Educational – Facilities:

Primary school Rajapur 2.0 Km anerial distance N-W direction from project site.

b) Health Service:

Primary Health centre ,Manda 5.0 Km aerial distance NW direction from project site.

c) Postal – Facilities:

The nearest post office is at Meza, 25.0 Kms in West direction.

.



Category:



Area: 2.024 Hac

Project Site:



Page | 10

5.0 Planning Brief

Building Stone (Gitti- Boulder) Sand stone mining will be opencast and Semi-Mechanized. Two

diesel operated excavators (851 L&T) of 1 m3 capacity will be used to extract sand stone. Drillers and

mild blasting is an optional method for losing the stones from the quarry area. Local interested

resident workers (24) will be employed for the execution of the lease. Total mineable reserve is

20240 m3 per year (50600 MT) of Building Stone (Gitti- Boulder) Sand stone. The quantity of

geological reserve is 687436 m3 which is much higher than what is proposed to be extracted.The

mine lease (ML) area is 2.024 Ha and lies in B2 category.

5.1 Blasting

Mild Blasting may be required.

5.2 Greenbelt Development

Green cover will be provided all around the haulage road for which plantation of 100 saplings of

different plant species has been proposed each year to the possible extent.

6.0 Rehabilitation and resettlement (R & R) Plan Not Required

7.0 Project schedule and cost estimates

The environmental clearance is sought for the Capacity Enhancement of the mine of Building Stone

(Gitti- Boulder) Sand stone . The total project Cost is 30,00,000. Once the EC is granted the

mining will be done as per the guidelines.

CER PLAN

Developmental activities Cost in percentage Cost in Rs.

Roads 18 41,760

Green 10 31,200

Education

I. For Upgrading and

expanding School

infrastructure

II. Conducting Training

programmes for skill

17 39,440

10

23,200

5

11,600



Category:



Area: 2.024 Hac

Project Site:



Page | 11

development

Health

Health check-up

15 34,800

Toilets 10 23,200

Sanitation

(Sewage &Water System)

5 11,600

miscellaneous 10 23,200

Total cost of Project 30,00,000 Rs.

Totalcost of CSR 2,40,000Rs(8% of total project cost)

COGNIZANCE RESEARCH INDIA PVT. LTD. GT-20...

Documents

Transcript of COGNIZANCE RESEARCH INDIA PVT. LTD. GT-20...