CALM Buoys (Telemetry and AtoN systems)
-
Upload
ivan-r-vargas-bscee -
Category
Documents
-
view
84 -
download
0
Transcript of CALM Buoys (Telemetry and AtoN systems)
Typical Aids to Navigation Equipment for CALM Buoys
© 2016 PMAPI All Rights Reserved www.automaticpower.com
CALM: Cantenary Anchor Leg Mooring Buoy Used for: Crude Oil
and Oil sub-products Transfer Usually connected
between: FPSOs- Tankers Onshore stations
– Tankers
CALM Buoy General Info
© 2016 PMAPI All Rights Reserved www.automaticpower.com
NavAids: Lanterns, FSs and FDs Telemetry Systems (radio based) GSM Monitoring and Control Sensors: pressure, weather, sea conditions
etc. Controls: Oil Valve control, NavAids Power Back-Up: Solar, Wind and Hybrid Base station (onshore) monitor& control units Portable monitoring and/or repeating units Load Pins and Hawser Life Monitoring
software
PMAPI Solutions
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Typical System Components
© 2016 PMAPI All Rights Reserved www.automaticpower.com
NavAids Turntable Controller Hull Controller Oil and Nitrogen pressure sensors Solenoids Control for product valves ON/OFF Radios + Antennas Portable unit and Base station with
HMIs/SCADA Power Backup: Mainly Solar Optional not frequent: Weather and sea
condition monitoring stations Load Pins and Hawser Life Monitoring
software
Typical System Components
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Typical On-Site Arrangement
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Typical Aids to Navigation Equipment for CALM Buoys
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Typical Aids to Navigation Equipment for CALM Buoys (System Package)
© 2016 PMAPI All Rights Reserved www.automaticpower.com
FA-250-LED Zone 1 Lantern Fog Horn, Zone 1
Zone 1 Battery Boxes (Isolators, etc.)
Zone 1 Solar Panels
Zone 1 Fog Detector
Radar Reflector
Optional Aids to Navigation Equipment for CALM Buoys
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Optional Aids to Navigation Equipment for CALM Buoys
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Weather Report System AIS-Atonis (dynamic position reporting signal
using AIS technology) Zone 1 Radar Beacon – Phalcon 2000EX
Explosion-Proof Enclosures
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Upgrade of AtoN Package & Telemetry System for existing CALM Buoys
© 2016 PMAPI All Rights Reserved www.automaticpower.com
PMAPI is an Engineering company that can be your technological partner for modernizing/upgrading existing CALM buoys from different manufacturers
A basic navigation system (typically consisting of EX Solar Panels, battery systems, fog horn & 5NM yellow lantern) can be updated to a more modern system incorporating: A telemetry system for remote monitoring &
command from the control station Upgrade of the solar system to include a Radar
beacon (RACON), Fog detector, Meteorological system, AIS (Atonis) and other complementary systems
Hazardous Area LED Illumination Alternatives
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Hazardous Area Illumination Fixture is engineered to perform multiple lighting functions on offshore production platforms and drilling rigs to allow better general illumination on different working areas with low power consumption and high reliability
Optional Equipment to Improve Safety of Operations
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Winker lights for hoses and pipes Hazardous Area LED illumination alternatives CCTV on board the buoy AIS technology to prevent unauthorized
vessel traffic Weather Met/Hydro (Doppler and Current
data) sensor with AIS transmission
FA-249 Gimbaled 15 NM
© 2016 PMAPI All Rights Reserved www.automaticpower.com
LED Gimbaled Lantern is the technological solution to the problem posed by the movement of large navigation buoy, CALM buoy, floating production systems (FPSO) and tension leg platforms.
This Gimbaled Lantern maintains its optic in a vertical position for inclinations of +/‐ 9° (18° total). This assures the full light intensity is continually available in the most severe sea conditions
Telemetry: Main System Components
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Master Telemetry Unit (MTU) Remote Telemetry Unit (RTU)
Tanker Portable Unit (TPU)
Telemetry CALM Buoy System
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Master Telemetry Unit
© 2016 PMAPI All Rights Reserved www.automaticpower.com
MTU is typically presented in a 19” rack fitted with a highly specialized industrial PC, printer, programmable logic controller, set of high performance radio modems and supplementary electronic circuitry. In most cases this is in a remote location connected to the buoy via RF link or fiber optic cable, depending on the local topology and geography.
Includes all the control, alarming, trending and data logging features. All designs are tailored to customer specifications.
Master Telemetry Unit
© 2016 PMAPI All Rights Reserved www.automaticpower.com
HMI Screenshots display live information received over UHF radio link Low battery indications Alarm screen Status of the aids to navigation Trends for battery, load, and pressure
Remote Telemetry Unit
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Telemetry, data transmission from buoys to onshore station, including hawser sensor, open/close valves, emergency shut-down, etc. All controls based on PLC technology;
independent controllers for turntable and hull
Remote Telemetry Unit
© 2016 PMAPI All Rights Reserved www.automaticpower.com
HMI/SCADA series of PLCs in the remote telemetry unit Acquire and process this raw data and map it
wirelessly Uses the serial or Ethernet connections and
protocols via UHF for display on HMI/SCADA computer terminals
Important parameters are updated every few
seconds with system-critical information Sub-second responses in ideal conditions and not
exceeding two seconds Less consequential data is updated less frequently
or polled, improving the efficiency of the communications
Tanker Portable Unit
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Telemetry, control, and data transmission from the tanker for emergency control of the hawser sensor, open/close valves, emergency shut-down, etc. Provides a means of monitoring the
offloading vessel and functions as a radio repeater in case of radio communication disruptions
Example System Drawings
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Example System Drawings
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Service Options
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Start up and commissioning services Additional requirements for documentation Your logo and title blocks on our
documents Specific drawing types
Training for you or your customers on the
functionality and use of our systems in our Houston facility or on location
PMAPI Headquarters – Houston, TX
© 2016 PMAPI All Rights Reserved www.automaticpower.com
PMAPI Headquarters – Houston, TX
© 2016 PMAPI All Rights Reserved www.automaticpower.com
LIEX Fog Signals In Sound Deadening Chamber
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Production Assembly Area
© 2016 PMAPI All Rights Reserved www.automaticpower.com
LED & PCB Assembly & Soldering Stations
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Open Warehousing
© 2016 PMAPI All Rights Reserved www.automaticpower.com
NOMAN NavAids Control Test Panel
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Helideck Lights & Zone 1 Windsock
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Lantern Test
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Self-Contained Single Lift Skids
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Global Coverage
© 2016 PMAPI All Rights Reserved www.automaticpower.com
• U.S. AND INTERNATIONAL OFFICE LOCATIONS: Houston, TX
Gray, LA Novato, CA
UK Singapore
• WORLDWIDE REPRESENTATIVES
Muchas Gracias por su Atencion Thank you for your Attention
© 2016 PMAPI All Rights Reserved www.automaticpower.com
Ivan Vargas, B.Sc.E.E. Vice President of Business Developments 10810 W Little York Rd Suite 130 Houston, TX 77041 +1-713-228-5208 - Main +1-713-419-7152 - Cell skype - ivanrvargas email - [email protected] Visit our website - http://www.automaticpower.com