8/13/2019 Brochure WasherTrainFlocculants MM NA

1/2

8/13/2019 Brochure WasherTrainFlocculants MM NA

2/2

Product Benefts

Our polymers are manufactured to achieve very high

molecular weights. A range of products with various anionic

charges has been tailored to ensure that the optimum

selection can be made for all stages of the washer train.

The resulting benets provide advantages over most of

the commonly used products in the industry, including:

Low dosage requirements to maximize cost effectiveness

Negligible effect on underow rheology and improved

mud pumpability

Less blockage in the strainers

Product Makedown and Application

Kemiras Superoc washer occulants are supplied as

easy-to-handle emulsions, resulting in short hydration

time and small makedown systems. Initial dilution or

breaking is recommended at 0.5-2.0% with nal dilution

strength of 0.1% to 0.01%. Products have been specically

formulated to break well in a wide range of process

streams including washer overow and lake water. Final

dilute solutions need minimal aging prior to use.

Kemira makes this information available as an accommodation to its customers and it is intended to be solely a guide in customers evaluation of the products. You must test our products to determine if they

suitable for your intended uses and applications, as well as from the health, safety and environmental standpoint. You must also instruct your employees, agents, contractors, customers or any third party whic

may be exposed to the products about all applicable precautions. All information and technical assistance is given without warranty or guarantee and is subject to change without notice. You assume full liabili

and responsibility for compliance with all information and precautions, and with all laws, statutes, ordinances and regulations of any governmental authority applicable to the processing, transportation, delivery,

unloading, discharge, storage, handling, sale and use of each product. Nothing herein shall be construed as a recommendation to use any product in conflict with patents covering any material or its use.

Superoc is a registered trademark of Kemira Oyj or its subsidiaries.

Storage and Handling

While concentrated emulsions should not be stored in mild

steel, brass or rubber tanks, dilute emulsion is compatible

with a wide range of storage materials. Please contact

your technical sales representative for further details or

assistance with feed and storage system compatibility.

Industry standard for

washer applications

Anionic Charge Application

Superoc4895 High First washer

Superoc4894 High First washer

Superoc4896 Medium Last washer

Superoc4893 Intermediate Available as needed for optimization

Superoc4892 Intermediate Available as needed for optimization

Superoc4891 Intermediate Available as needed for optimization

Superoc4890 Intermediate Available as needed for optimization

Kemira SuperocWasher Flocculant Typical Products

Kemira

P.O. Box 330

FI-00101 Helsinki

Finland

Tel + 358 10 86 11

www.kemira.com

1000 Parkwood Circle

Suite 500

Atlanta, Georgia 30339

USA

Tel. +800 347 1542