BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use...
Transcript of BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use...
![Page 1: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/1.jpg)
Unit 1:
BELT CONVEYOR
http://www2.hcmuaf.edu.vn/?ur=dangnh 1
![Page 2: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/2.jpg)
Introduction
A belt conveyor is one of the most versatiletypes of bulk handling equipment avaiable.It is suited for handling a variety of bulkmaterials over wide range of capacities.
http://www2.hcmuaf.edu.vn/?ur=dangnh
It provides an economical and practicalmeans for transporting bulk materials overlong distances and over terrains requiring awide range of paths of travel.
2
![Page 3: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/3.jpg)
Introduction
The belt conveyor is esentially an endlessbelt operating between two or more pulleys.The belt and its load are usually supportedon idlers.
http://www2.hcmuaf.edu.vn/?ur=dangnh
Belt conveyors have a high mechaincaleficiency since, in larger installations, allthe load is carried on antifriction bearings.
3
![Page 4: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/4.jpg)
Introduction
Damage to the product being transported isslight since there is little or no relativemotion between the product being carriedand the belt.
The carying capacity is high since relatively
http://www2.hcmuaf.edu.vn/?ur=dangnh
The carying capacity is high since relativelyhigh belt speed are possible.
Materials can be conveyed long distances,but there is a limit to the angle of elevation.
4
![Page 5: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/5.jpg)
Introduction
A properly designed and maintained beltsystem has a long service life, but the initialcost is usually high.
Installation is advisable only when
http://www2.hcmuaf.edu.vn/?ur=dangnh
Installation is advisable only whenamortization of the high initial cost beassured.
5
![Page 6: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/6.jpg)
Typical Materials Handled by Belt Conveyors
Material Characteristics ExampleMaximum size lumps, sized or unsized
Mildly abrasive Coal, earth
Very abrasive, not sharp Bank gravel
Very abrasive, sharp and jagged Stone, ore
Half max. lumps, sized or unsized
Mildly abrasive Coal, earth
http://www2.hcmuaf.edu.vn/?ur=dangnh 6
Mildly abrasive Coal, earth
Very abrasive Slag, coke, ore, stone, cullet
Flakes Wood chips, bark, pulp
Granular, 1/8 – 1/2 in lumps Grain, coal, cottonseed, sand
Fines
Light, fluffy, dry, dusty Soda ash, pulverized coal
Heavy Cement, flue dust
Fragile, where degradation is harmful Coke, coal – Soap chips
![Page 7: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/7.jpg)
Types:
Portable
http://www2.hcmuaf.edu.vn/?ur=dangnh 7
Construction :
Permanent
![Page 8: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/8.jpg)
Types:
Purpose: all purpose and single-purpose.
http://www2.hcmuaf.edu.vn/?ur=dangnh 8
![Page 9: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/9.jpg)
Types:
Conveyable Direction:
http://www2.hcmuaf.edu.vn/?ur=dangnh 9
Horizontal Incline Combination
![Page 10: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/10.jpg)
Construction:
Belt conveyors belong to a class of non-self-
contained equipment. Unlike self-contained units
such as pumps and compressors the effeciency or
effectiveness of a belt conveyor depends on a skillful
http://www2.hcmuaf.edu.vn/?ur=dangnh 10
effectiveness of a belt conveyor depends on a skillful
choice of five essential elements that make up a
particular conveyor, coupled with the unit’s proper
integration into a system.
![Page 11: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/11.jpg)
Construction:
The essential elements of typical belt conveyors are:1. The belt, which forms the moving and supporting
surface on which the conveyed material rides.2. The idlers, which form the supports for the troughed
carrying strand of the belt and the flat return strand.3. The pulleys, which support and direct the belt and
http://www2.hcmuaf.edu.vn/?ur=dangnh 11
3. The pulleys, which support and direct the belt andcontrol its tensions.
4. The drive, which impacts power through one or morepulleys to move belt and its load.
5. The structure, which the supports and maintainsalignment of idlers, pulleys, and drive.
![Page 12: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/12.jpg)
Construction:
http://www2.hcmuaf.edu.vn/?ur=dangnh 12
![Page 13: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/13.jpg)
Typical belt conveyor profiles
http://www2.hcmuaf.edu.vn/?ur=dangnh 13
![Page 14: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/14.jpg)
Main components
http://www2.hcmuaf.edu.vn/?ur=dangnh 14
![Page 15: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/15.jpg)
Idlers
http://www2.hcmuaf.edu.vn/?ur=dangnh 15
![Page 16: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/16.jpg)
Idlers
http://www2.hcmuaf.edu.vn/?ur=dangnh 16
![Page 17: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/17.jpg)
Idlers
Diameter of idler:
– 108mm when B = 400 – 800 mm.
– 159mm when B = 800 – 1600mm.
Bước trên nhánh không tải bằng 2 lần bước trên nhánh tải.
http://www2.hcmuaf.edu.vn/?ur=dangnh 17
bước trên nhánh tải.
Bước được xác định theo bề rộng băng và chủng loại vật liệu.
Trục có xoay hoặc không xoay.
![Page 18: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/18.jpg)
Belts
Practically all belt conveyors for bulk materials userubber-covered conveyor belt, made of a wovencarcass having strength enough to pull and supportthe load and protected from damage by rubbercovers which vary in thickness for differentapplications:
http://www2.hcmuaf.edu.vn/?ur=dangnh
applications:
Conventional Belting: has plies of fabric made of cotton,cotton-nylon, rayon, rayon-nylon, and others. Tensionrating from 140 – 500 pounds per inchs of belt width forcotton-nylon combinations and up to 1500 piw.
18
![Page 19: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/19.jpg)
Belts
Steel Cable belt: made up of spaced steel cablessuspended in rubber and wrapped in a fabric envelope, isused where very high strengths and minimum stretch arerequired. Ratings up to 6000 piw.
Heat Service Belts: Special belts are available for jobs
http://www2.hcmuaf.edu.vn/?ur=dangnh
Heat Service Belts: Special belts are available for jobswhere hot materials must be handled. They must retaintheir physical properties at temperatures up to 250oFand resist abrasion by the conveyed material. The beltsutilize carcasses of nylon, polyester, cotton, nylon, orglass. Covers are usually butyl, chloro-butyl, or EPDM(ethylence-propylence-dipolymer).
19
![Page 20: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/20.jpg)
Belts
Applications for belt conveyors range from a few poundsper minute to thousands of tons per hour, and a greatvariety of materials can be handled.
Actual belt selection is dependent on an analysis of avariery of factors:
Required belt tension requirements
http://www2.hcmuaf.edu.vn/?ur=dangnh
Required belt tension requirements
Length and speed of conveyor
Abrasiveness of material handled
Size of lumps and their tendency to cut or tear the cover
Characteristic of material being handled
Method of loading conveyor
Type of take-up (kéo căng).
20
![Page 21: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/21.jpg)
Belts
http://www2.hcmuaf.edu.vn/?ur=dangnh 21
![Page 22: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/22.jpg)
Conveyor Drives:
All belt conveyor installations involve the properapplication of conveyor drive equipment including speedreduction, electric motors and controls, and safetydevices.
The preferred drive location for a belt conveyor is that
http://www2.hcmuaf.edu.vn/?ur=dangnh 22
The preferred drive location for a belt conveyor is thatwhich results in the least maximum belt tension.
For simple horizontal and inclined conveyors this isusually at the discharge end.
![Page 23: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/23.jpg)
Conveyor Drives:
For decline conveyors the preferred location is usuallyat the load end.
Special conditions and requirements can require thatthe drive be located eslewhere.
http://www2.hcmuaf.edu.vn/?ur=dangnh 23
the drive be located eslewhere.
Often internal drives are utilized on longer conveyorsand inclined boom conveyors for reasons of economy,accessibility, or maintenance.
![Page 24: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/24.jpg)
Conveyor Drives:
Belt conveyor drive equipment normally consists of amotor, speed reducer, drive shaft, and necessarymachinery to transmit power from one item to another;the simplest arrangement using the least number ofcomponents is the best.
http://www2.hcmuaf.edu.vn/?ur=dangnh 24
components is the best.
Often however, special-purpose components must beprovided to modify starting and stopping, provide for ahold-back, or vary belt speed.
![Page 25: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/25.jpg)
Conveyor Drives:
http://www2.hcmuaf.edu.vn/?ur=dangnh 25
![Page 26: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/26.jpg)
Take-ups
http://www2.hcmuaf.edu.vn/?ur=dangnh 26
![Page 27: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/27.jpg)
Take-ups and bend pulleys
http://www2.hcmuaf.edu.vn/?ur=dangnh 27
![Page 28: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/28.jpg)
Bend pulleys
http://www2.hcmuaf.edu.vn/?ur=dangnh 28
![Page 29: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/29.jpg)
Feed chute and Discharge chute
http://www2.hcmuaf.edu.vn/?ur=dangnh 29
![Page 30: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/30.jpg)
Feed chute:
http://www2.hcmuaf.edu.vn/?ur=dangnh 30
![Page 31: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/31.jpg)
Discharge chute
http://www2.hcmuaf.edu.vn/?ur=dangnh 31
![Page 32: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/32.jpg)
Belt cleaner:
http://www2.hcmuaf.edu.vn/?ur=dangnh 32
![Page 33: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/33.jpg)
Belt cleaner:
http://www2.hcmuaf.edu.vn/?ur=dangnh 33
![Page 34: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/34.jpg)
Design:
Cần biết và xác định các thông số sau:
– Đặc tính vật liệu vận chuyển
– Năng suất vận chuyển (T/h hoặc m3/h)
– Sơ đồ đường vận chuyển với các kíchthước cơ bản
http://www2.hcmuaf.edu.vn/?ur=dangnh
thước cơ bản
– Đặc điểm bộ phận nạp và dỡ liệu,
– Điều kiện sử dụng
– Yêu cầu đặc biệt khác,….
34
![Page 35: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/35.jpg)
Design:
Capacity:
Q = 3,6.qv.v; (T/h)
qv = 1000. F. g.g
Power requirement (HP):
.HQNđ
http://www2.hcmuaf.edu.vn/?ur=dangnh
Resistance on fixed bearings:
– W1 = (qvl + qb+ qclc)Lng . (qct + qb)H
– Wkt = (qb + qct0)Lng . qb .H
35
.270Nđ
![Page 36: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/36.jpg)
Design:
Cross sectional area of loaded F
http://www2.hcmuaf.edu.vn/?ur=dangnh 36
![Page 37: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/37.jpg)
Belt conveyors on practical.
http://www2.hcmuaf.edu.vn/?ur=dangnh 37
![Page 38: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/38.jpg)
http://www2.hcmuaf.edu.vn/?ur=dangnh
GO BACK
38
![Page 39: BELT CONVEYOR - hcmuaf.edu.vn · Belts Practically all belt conveyors for bulk materials use rubber-covered conveyor belt, made of a woven carcass having strength enough to pull and](https://reader031.fdocuments.us/reader031/viewer/2022022009/5af3251b7f8b9ad06191a723/html5/thumbnails/39.jpg)
Bài tập
BT01: Đọc Page: 65 – 74 : TL2/ (Paddy posharvest_IRRI) phần Belt Conveyor. Tóm tắt, đặt 2 câu hỏi.
BT02. Đọc bài giảng, đặt 4 câu hỏi kèm trả lời.
http://www2.hcmuaf.edu.vn/?ur=dangnh
trả lời.
39