ATMOSPHERIC REENTRY TRAJECTORY MODELING AND SIMULATION: APPLICATION TO REUSABLE LAUNCH VEHICLE...

ATMOSPHERIC REENTRY TRAJECTORY MODELING AND SIMULATION: APPLICATION TO REUSABLE

LAUNCH VEHICLE MISSION

(Progress Seminar Presentation - 2)

K. Sivan(Roll No. 01401703)

Department of Aerospace EngineeringIIT Bombay

August 2003

PROBLEM DEFINITION

Change Orientation

RetroFiring

Orbit

Re entry Phase

Change Orientation for Re entry

Terminal Area Energy Management Phase

Approach And Landing Phase

Runway Landing

Return Mission of RLV

Reentry Trajectory Planningand Trajectory Control

• Literature survey on RLV mission configuration, reentry models, trajectory planning algorithms

• Generic RLV Configuration definition

• Reentry trajectory simulator development

• Trajectory planning and trajectory control algorithm development, robustness studiy and performance evaluation

CONFIGURATION SELECTION AND SIMULATOR DESIGN CRITERIA

• Generic RLV configuration definition

- Complete aerodynamic characterization

- Mass properties

- Consistent vehicle characteristics and configuration

• Reentry Trajectory Simulator

* Need to Simulate Reentry Dynamics of RLV - 3 DOF translational dynamics (CM motion in 3-D space)

- 3 DOF angular dynamics (Angular motion about CM)

* Simulator should be

- Realistic (Models response close to the actual ones)

- Generalized (All the phases of RLV/Any RLV/

Any application – 3DOF or 6 DOF)

- Avoid computational difficulties (singularities)

- Provision for future expansion

- Validation of the simulator

GENERIC RLV CONFIGURATION

• Literature configuration

- Configuration available

- Complete characteristics not available in single literature

- Overall information is available in bits and pieces

- Finer details not available (not possible)• RLV study configurations of ISRO

- Finer details can be used for the studies

- Mass properties can be used

- But the total aerodynamic characterization is not ready

Generic RLV configuration

- One of the RLV study configurations of ISRO

- Aerodynamic characteristics of different literature combined to form full set

- Fine details if required can be used from RLV study

configurations

GENERIC RLV CONFIGURATION

REENTRY TRAJECTORY SIMULATOR

• 6 DOF reentry dynamics influenced by external forces & moments

• Emphasis

- Realistic models to simulate forces & moments

- Simulation of vehicle & trajectory dynamics using these

forces & moments

DEFINITION & MODEL REQUIREMENTS OF REENTRY TRAJECTORY SIMULATOR

Definitions - Represent data* Coordinate System Definition - Represent forces & moments

- Represent Dynamics

- Attitude definitions w.r.t ref. frames* Vehicle Attitude Definition - Commands for control

(for trajectory & attitude) - Simulation measurements on vehicle onboard

* Coordinate Transformation - To transfer data between ref. frames

DEFINITION & MODEL REQUIREMENTS OF REENTRY TRAJECTORY SIMULATOR - Contd...

Models - Earth Geometry* Environment Model - Gravitation model (Vehicle operating environment) - Atmosphere model

- Wind model

- Mass properties* Vehicle Model - Propulsion systems model

(Main & RCS)- Aerodynamics model

- Sensors* Vehicle Subsystem Model - Navigation (Systems to command vehicle - Guidance & control algorithm control & trajectory) - Actuators

* Vehicle Dynamics Model - Translational dynamics & kinematics- Attitude dynamics & kinematics

COORDINATE SYSTEMS & ATTITUDE DEFINITIONS

Coordinate Systems

YBR XBR

BRZ

BX

OB

BZ

YB

Body Coordinate System

COORDINATE SYSTEMS & ATTITUDE DEFINITIONS – Contd…

Aerodynamic Wind Frame


Definition of Relative Euler Angles


IG

GW

WB

IB

GBG

W

B

COORDINATE TRANSFORMATIONS

EARTH MODEL

R

RD

p

e

gco

c

D

SR

h

Ir

o

• Oblate Earth with zonal harmonics up to J4 term considered

• Altitude corresponding to oblate Earth

• Gravitational potential in ECI frame

• Gravity acceleration in ECI frame

),,,,,,( 432 JJJZYXfU III

IXI X

UG

I

YI Y

UG

I

ZI Z

UG

ATMOSPHERE MODEL

* General Look up table- pa , r , T, Cs as function of altitude- Flexibility of inputting any atmosphere- Cs and r as optional

* Properties from temperature profile- Assumption : (g/RLz) constant

WIND MODEL

* Input data in G-frame- Zonal- Meridional- Vertical

* Convert into ECI frame

VEHICLE MODEL

(1) Aerodynamic Model

* Allow to build up to any configuration and flight condition* General model – can be used in all phases of RLV mission

Cx = Basic coefficient+ Increment due to control surface deflection ( elevator, aileron, body flap, rudder, speed brake)+ Increment due to dynamic conditions (a-dot, b-dot, p, q, r)+ Increment due to vehicle flexibility+ Increment due to landing gear extension+ Increment due to ground effects

* Forces & moments coefficients expressed in body frame

VEHICLE MODEL– contd….

(2) Propulsion Model

* Rocket motors/engines with atmospheric corrections* General model for n engines* General thrust orientation and location w.r.t body frame* Total forces and moments w.r.t body frame

(3) Mass Properties Model

* Mass update due to - Engine burning- Continuous reduction of inert mass- Jettisonable mass

* CM updated through input data (function of propellant mass)

* Moments & products of inertia updated through input data (function of propellant mass)

* for general configuration 1][],[],[ III

VEHICLE SUBSYSTEM MODEL

(1) Sensors

* Sensor parameters at sensor location* Sensor response – 2nd order dynamics* Sensor output errors

(2) Navigation

* Different navigation output for black out & normal phases

(3) Actuators

* Actuators response – 2nd order dynamics* RCS – on-off characteristics

(4) Guidance & Control Algorithm

* To be included as external block

VEHICLE DYNAMICS

* Translational Dynamics

- Spherical Coordinate System: Singularity at latitude + p/2- Rotating frame: Inertial forces > actual forces

* Rotational Dynamics

- All moments in body frame- Inertia constant in body frame

* Rotational Kinematics

- Angular representation (Euler or a/d angles): Singularity at p/2 for middle rotation

Translational dynamics & kinematics in ECI frame

Rotational dynamics in body frame

Quaternion approach

AtmosphericModel

EarthModel

GravityModel

Aero parametersModel

Flight dynamics& kinematics Mass

properties

AerodynamicsModel

INSSensor

Simulator

GPSSimulator

PropulsionModel

ADSSimulator

Actuatordynamics

RCSSimulator

NavigationPackage

FlightControl Guidance

SIMULATION STRUCTURE

VALIDATION OF THE SIMULATOR TOOL

1. Module level tests

2. Comparison with analytical solutions

3. Comparison with reference trajectory

COMPARISON WITH ANALYTICAL SOLUTION

Initial Conditions Location of Landing Point

Results of the Simulator Analytical Solution

Case-1

h(km) 130.2608205

v(m/s) 5426.6656766

g(deg) 1.5024290

Az(deg) 104.4896320

Latitude(deg) 12.2604888

Longitude(deg) 85.464222

Case-2

h (km) 247.2606513

v (m/s) 4079.9528041

g (deg) 19.7724067

Az (deg) 169.9938794

Latitude (deg) 10.4675403


Case-3

h (km) 162.3515483

v (m/s) 7757.2258785

g (deg) 0.5346059

Az (deg) 105.4645370

Latitude (deg) 8.8041388


Latitude (deg) : 8.8448351

Longitude(deg): 96.743040

Latitude (deg) : -7.1769368


Latitude (deg) : -9.2499092


8.8449329

96.7427399

-7.1765934

82.3525419

-9.2500764

266.9827025

COMPARISON WITH REFERENCE TRAJECTORY OF RLV

* Space Shuttle (not in single literature)

• 3 DOF validation

• Ideal control mode (Aerodynamic angles – command values)

• Sufficient for validating guidance performance evaluation

SIMULATOR RESULTS

Assumption:- Space shuttle aerodynamics- mass properties of space shuttle- Ideal control

-10

-5

0

5

10

0 500 1000 1500 2000

Time (sec)

Com

man

ded

Sid

e S

lip A

ngle

(de

g)

-50

0

50

100

0 500 1000 1500 2000

Time (sec)

Com

man

ded

Ban

k A

ngle

(de

g)

0

10

20

30

40

50

0 500 1000 1500 2000

Time (sec)

Co

mm

an

de

d A

ng

le o

f A

tta

ck (

de

g)

Fig.19 Simulator Results with Reference Trajectory

0

2000

4000

6000

8000

0 500 1000 1500 2000

Time (sec)

Rel

ativ

e V

eloc

ity (

m/s

ec)

0

30

60

90

120

150

0 500 1000 1500 2000

Time (sec)

Alti

tude

(km

)

Fig.20 Simulator Results with Reference Trajectory

SIMULATION STUDIES

* Trajectory planning & trajectory Control through aerodynamic angle modulations

* Study carried out to estimate the effectiveness

- Without command profile

- Perturbing command profile



APPLICATIONS OF THE SIMULATOR

(1) Good test bed for evaluating Navigation, Guidance and Control algorithms of reentry flight

(2) Fully nonlinear 6 DOF simulation and analysis of reentry vehicle

(3) Robust control and guidance analysis of the vehicle

(4) Suitable for model linearization analysis (useful for classical and modern control approaches)

Further Developments• Development of an adaptive trajectory

planning algorithm• Algorithm based on Predictor-Corrector method

– Target : Altitude, Latitude, Longitude at TAEM interface.

– Control variable: , and time of Bank reversal

– Constraints: Dynamic pressure, Normal load, Heat flux,

Equilibrium glide

Proposed Method• Propagate trajectory to TAEM through numerical

integration• The target errors are used to correct the control

variables• The process is repeated until the errors are less

than acceptableAdvantages• Equations of motion are explicitly modeled• State vectors available at every instant -

constraints are activated directly• No separate trajectory control law (both

trajectory planning and trajectory control combined)

Disadvantages• Computational load more

– Present day computers can handle– Computational cycle can be increased

• Risk of convergence

PLAN OF ACTION

• Development of trajectory planning Feb, 04• Implementation of the algorithm Mar, 04• Robustness study May,

04• MC analysis for performance Evaluation June, 04

THANK YOU

ATMOSPHERIC REENTRY TRAJECTORY MODELING AND SIMULATION: APPLICATION TO REUSABLE LAUNCH VEHICLE...

Documents

Transcript of ATMOSPHERIC REENTRY TRAJECTORY MODELING AND SIMULATION: APPLICATION TO REUSABLE LAUNCH VEHICLE...