APRIL 2019 TECHNICAL news BULLETIN AVAILABLE · 2019. 3. 22. · BULLETIN APRIL 2019 NOW AVAILABLE...
Transcript of APRIL 2019 TECHNICAL news BULLETIN AVAILABLE · 2019. 3. 22. · BULLETIN APRIL 2019 NOW AVAILABLE...
THE TRULY INDEPENDENT LEADER IN ENGINE MANAGEMENT AND
MECHATRONIC PRODUCTSim-group.com.au
TECHNICALBULLETIN
APRIL 2019
NOWAVAILABLE
FOLD
FOLD
newsTECHNICALBULLETIN
LEXUS: GS300 / 430 – AUTOMATIC TRANSMISSION SHIFTING ISSUES
Injectronics are seeing an increasing number of Lexus GS300 and GS430 Engine Control Units being sent in with transmission shifting issues. The Lexus GS300 and GS430 are equipped with either the A650E 5-Speed or A960E 6-Speed transmission made by Toyota for their Lexus division. There are several areas where the A650E 5-Speed and A960E 6-Speed may exhibit problems.
Technicians are advised to run a scan check on the vehicles ECM (Engine Control Module). The problem may be an issue with the vehicle’s computer. IM Group technicians have performed an extensive investigation into the cause of these faults and have now developed a reliable remanufacturing process to repair these units, a cost effective alternative to OE replacements. Injectronics offer a repair of the customers own unit for the above listed faults. This option also guarantees that no programming is required upon refitting of the unit.
Common Faults Include:• Automatic transmission related fault codes including P0761 (shift solenoid C)• Transmission not shifting into 5th and 6th gear• Harsh downshift from 2nd to 1st gear when slowing down to a stop
Genuine / OEM Part Numbers:• 89661-30A50• 89661-30A51• 89661-30A52
Possible Causes Include:• Low transmission fluid level• Dirty transmission fluid• Shift solenoid C valve harness or connectors• Engine Control Module (ECM)
For more information please visit the Injectronics web page at www.injectronics.com.au *Repair service
The Heater Integrated Module (HIM), also known as the HVAC is an electronic control module attached to the left side of the HVAC main unit. The HIM consists of a number of small electric motors, electrical connectors, circuit board and a blower motor control heat sink.
This is where Injectronics can help, offering a prompt test and repair service for these units.
These units are fitted to all of the following vehicles:
• Ford Falcon BA – BF series 2002-2011
• Ford Falcon FG series 2008-2016
• Ford Territory 2004-2016
Injectronics have seen these units displaying numerous faults including:
• Blower fan inoperative
• Unable to adjust temperature
• Blower fan staying on
• Unable to adjust fan speed
• Unable to regulate temperature between zones
Electronic & Mechatronic Components
injectronics.com.au
news
FOLD
FOLD
THE TRULY INDEPENDENT LEADER IN ENGINE MANAGEMENT AND MECHATRONIC PRODUCTS
THE TRULY INDEPENDENT LEADER IN ENGINE MANAGEMENT AND MECHATRONIC PRODUCTS
JUST A SAMPLE OF OUR CONTINUALLY INCREASING
RANGE OF GENUINE OEM AND AFTERMARKET AUTOMOTIVE ELECTRONIC COMPONENTS.
JUST A SAMPLE OF OUR CONTINUALLY INCREASING RANGE OF GENUINE OEM AND AFTERMARKET AUTOMOTIVE ELECTRONIC COMPONENTS.
INSIDE RIGHTINSIDE LEFT
Nissan Micra, Navara, Patrol
KF297Complete Remote
Subaru Impreza, Liberty, Outback
KF388Complete Remote
KF430Remote Shell & Buttons
Mitsubishi Challenger, Lancer, Outlander, Pajero, Triton
Mercedes Benz Vito
GE550Fuel Pump Module
Toyota Landcruiser Prado (Single Tank)
GE558Fuel Pump Module
Toyota Landcruiser Prado (Twin Tank)
GE560Fuel Pump Module
GE562Fuel Pump Module
Audi / Skoda / Volkswagen Volkswagen Caddy 2K
GE564Fuel Pump Module
GE565Fuel Pump Module
Volvo S60, S80, V70, XC70, XC90 Ford Territory / Land Rover Discovery / Range Rover Sport
RPS105Fuel Rail Pressure Sensor
Holden Captiva
RPS115Fuel Rail Pressure Sensor
Isuzu D Max TFS, TFR
ECMDMAXREPElectronic Control Module
Ford Mondeo MA, MB, MC
GE548Fuel Pump Module
Mercedes Benz Vito
GE549Fuel Pump Module
Mazda CX7, CX9, 3, 6, RX8 (RHS) Holden VX, VY, VZ, VTMazda CX7, CX9, 3, 6, RX8 (LHS)
742-802Window Motor
742-801Window Motor
917-033Knock Sensor Loom
Chrysler / Jeep / Holden Colorado
EV152EGR Valve
Holden Colorado RG Diesel
EV153 EGR Valve
SC588Cam Sensor
Holden Colorado RG Diesel
Ford Falcon FG
BCMFGFREPBody Control Module
Mazda 2 DE
ECMAZ2REPElectronic Control Module
VS255Vac Solenoid Valve
Mitsubishi Pajero QA
Toyota Avensis, Corolla, Landcruiser, Rav4, Tarago
KF425Complete Remote
*Repair service *Repair service *Repair service
news
FOLD
FOLD
THE TRULY INDEPENDENT LEADER IN ENGINE MANAGEMENT AND MECHATRONIC PRODUCTS
THE TRULY INDEPENDENT LEADER IN ENGINE MANAGEMENT AND MECHATRONIC PRODUCTS
JUST A SAMPLE OF OUR CONTINUALLY INCREASING
RANGE OF GENUINE OEM AND AFTERMARKET AUTOMOTIVE ELECTRONIC COMPONENTS.
JUST A SAMPLE OF OUR CONTINUALLY INCREASING RANGE OF GENUINE OEM AND AFTERMARKET AUTOMOTIVE ELECTRONIC COMPONENTS.
INSIDE RIGHTINSIDE LEFT
Nissan Micra, Navara, Patrol
KF297Complete Remote
Subaru Impreza, Liberty, Outback
KF388Complete Remote
KF430Remote Shell & Buttons
Mitsubishi Challenger, Lancer, Outlander, Pajero, Triton
Mercedes Benz Vito
GE550Fuel Pump Module
Toyota Landcruiser Prado (Single Tank)
GE558Fuel Pump Module
Toyota Landcruiser Prado (Twin Tank)
GE560Fuel Pump Module
GE562Fuel Pump Module
Audi / Skoda / Volkswagen Volkswagen Caddy 2K
GE564Fuel Pump Module
GE565Fuel Pump Module
Volvo S60, S80, V70, XC70, XC90 Ford Territory / Land Rover Discovery / Range Rover Sport
RPS105Fuel Rail Pressure Sensor
Holden Captiva
RPS115Fuel Rail Pressure Sensor
Isuzu D Max TFS, TFR
ECMDMAXREPElectronic Control Module
Ford Mondeo MA, MB, MC
GE548Fuel Pump Module
Mercedes Benz Vito
GE549Fuel Pump Module
Mazda CX7, CX9, 3, 6, RX8 (RHS) Holden VX, VY, VZ, VTMazda CX7, CX9, 3, 6, RX8 (LHS)
742-802Window Motor
742-801Window Motor
917-033Knock Sensor Loom
Chrysler / Jeep / Holden Colorado
EV152EGR Valve
Holden Colorado RG Diesel
EV153 EGR Valve
SC588Cam Sensor
Holden Colorado RG Diesel
Ford Falcon FG
BCMFGFREPBody Control Module
Mazda 2 DE
ECMAZ2REPElectronic Control Module
VS255Vac Solenoid Valve
Mitsubishi Pajero QA
Toyota Avensis, Corolla, Landcruiser, Rav4, Tarago
KF425Complete Remote
*Repair service *Repair service *Repair service
THE TRULY INDEPENDENT LEADER IN ENGINE MANAGEMENT AND
MECHATRONIC PRODUCTSim-group.com.au
TECHNICALBULLETIN
APRIL 2019
NOWAVAILABLE
FOLD
FOLD
newsTECHNICALBULLETIN
LEXUS: GS300 / 430 – AUTOMATIC TRANSMISSION SHIFTING ISSUES
Injectronics are seeing an increasing number of Lexus GS300 and GS430 Engine Control Units being sent in with transmission shifting issues. The Lexus GS300 and GS430 are equipped with either the A650E 5-Speed or A960E 6-Speed transmission made by Toyota for their Lexus division. There are several areas where the A650E 5-Speed and A960E 6-Speed may exhibit problems.
Technicians are advised to run a scan check on the vehicles ECM (Engine Control Module). The problem may be an issue with the vehicle’s computer. IM Group technicians have performed an extensive investigation into the cause of these faults and have now developed a reliable remanufacturing process to repair these units, a cost effective alternative to OE replacements. Injectronics offer a repair of the customers own unit for the above listed faults. This option also guarantees that no programming is required upon refitting of the unit.
Common Faults Include:• Automatic transmission related fault codes including P0761 (shift solenoid C)• Transmission not shifting into 5th and 6th gear• Harsh downshift from 2nd to 1st gear when slowing down to a stop
Genuine / OEM Part Numbers:• 89661-30A50• 89661-30A51• 89661-30A52
Possible Causes Include:• Low transmission fluid level• Dirty transmission fluid• Shift solenoid C valve harness or connectors• Engine Control Module (ECM)
For more information please visit the Injectronics web page at www.injectronics.com.au *Repair service
The Heater Integrated Module (HIM), also known as the HVAC is an electronic control module attached to the left side of the HVAC main unit. The HIM consists of a number of small electric motors, electrical connectors, circuit board and a blower motor control heat sink.
This is where Injectronics can help, offering a prompt test and repair service for these units.
These units are fitted to all of the following vehicles:
• Ford Falcon BA – BF series 2002-2011
• Ford Falcon FG series 2008-2016
• Ford Territory 2004-2016
Injectronics have seen these units displaying numerous faults including:
• Blower fan inoperative
• Unable to adjust temperature
• Blower fan staying on
• Unable to adjust fan speed
• Unable to regulate temperature between zones
Electronic & Mechatronic Components
injectronics.com.au