Air Legislation OBJECTIVE Questions

AIR LEGISLATION

1) Which ICAO annex provides guidance for the airworthiness of aircraft?

A) Annex 6B) Annex 8C) Annex 13

(Level 1, www.icao.int)

2) What is the minimum requirement to be held before an approval/authorisation for maintenance certification may be granted by an Approved Maintenance Organisation?

A) An Aircraft Technician CertificateB) A Type Rating (TR)C) A Licence Without Type Rating (LWTR)

(Level 1, BCAR Section L Issue 13)

3) Prior to grant/extension of LWTR in any category (except Category ‘X’ – Compass Compensation/Adjustment), the minimum period of engineering experience relating to the maintenance of life aircraft

is

A) 6 months B) 24 monthsC) 36 months

(Level 1, AN No. 5)

4) If DCA has a need to circulate information to all concerned with the airworthiness of civil aircraft, they will issue

A) Airworthiness NoticesB) Amendments to Maintenance ManualC) Service News

(Level 1, DCA AN Foreword 3.5)

1

5) The process of restoring an aircraft/aircraft component to a serviceable condition in conformity with an approved standard is termed as

A) OverhaulB) ServicingC) Repair

(Level 1, AN No. 3 para 3.1)

6) Under Airworthiness Notice No. 3, a Licensed Aircraft Maintenance Engineer shall be responsible for the of an aircraft and/or its components.

A) Assembly, functioning, and condition B) Assembly, storage, and conditionC) Replacement, repair, and overhaul


7) Certificate of Release to Service (CRS) for non-destructive inspection using the Field Kit for Colour Contrast Dye Penetrant technique shall be issued by holder of an Aircraft Maintenance Engineer’s Licence in which is appropriately type rated

A) Category ‘A’B) Category ‘X’C) Category ‘R’


8) Which one of the following aircraft category requires the issue of a Certificate of Maintenance Review (CMR) for a maximum period of one year?

A) Transport category aircraft less than 2730 kg MTWAB) Transport category aircraft exceeding 2730 kg MTWAC) Private category aircraft below 2730 kg MTWA

(Level 1, AN No. 12 para 3.3.1)9) Which of the following statements is NOT related to the

Certificate of Airworthiness for Export?

2

A) Raised by the DCAB) Informs the Airworthiness Authority of the country to be

exported the aircraft is airworthy in all aspectsC) Allows the aircraft to be flown its destination

(Level 1, BCAR A3-6)

10) To qualify for the issue, renewal or validation of Certificate of Airworthiness (C of A) or approval of modification, the aircraft shall fly under

A) ‘A’ Condition B) ‘B’ ConditionC) ‘C’ Condition

(Level 1, MCAR Second Schedule, page 2130)

11) If the aircraft were to fly under ‘A’ Condition, prior to flight it shall be issued with a

A) Permit to flyB) Certificate of Fitness for Flight C) Certificate of Release to Service

(Level 1, MCAR Second Schedule, pg 2131)

12) A DCA approved Aircraft Flight Manual is

A) A document in its own rightsB) Part of the Certificate of AirworthinessC) Part of the Operations Manual

(Level 1, AN No. 88 para 3)

13) A Malaysian aircraft , if in relation to such aircraft a Certificate of Airworthiness in either the Transport or in the Aerial Work category is in force, a must be maintained.

A) Certificate of Release for Service

3

B) Technical Log C) Certificate of Fitness for Flight

(Level 1, MCAR Regulation 29)

14) Pursuant to regulation 28, each Certificate of Maintenance Review shall be preserved by the Operator of the aircraft for a period of

A) 4 months after a maintenance review has been carried outB) 2 years after it has been issued C) 2 years after the aircraft has been destroyed


15) In Duplication Inspection of all control systems, the person performing the second inspection may

A) Take account of full extent of the work carried outB) Clean the immediate area of disturbanceC) Inspect part of the of the affected system only

(Level 1, AN No. 51, para 3)

16) If Malaysia is the State of Design, the Airworthiness Directives issued by the DCA are known as

A) MAMISB) CAM ADC) VAM AD

(Level 1, AN No. 4)

17) A Technical Log Book shall be preserved for a minimum period of

A) 6 monthsB) 2 years after the aircraft has been destroyed or

permanently removed from serviceC) 2 years after the log book has been filled

4


18) A list prepared by an operator and approved by the DCA, which provides operations of aircraft, subject to specified conditions, with particular equipment inoperative, is the

A) Configuration Deviation ListB) Defer Defect ListC) Minimum Equipment List

(Level 1, AN No. 87)

19) Which document listed below specifies the signatories for a Maintenance Review?

A) DCA Approval Document for the maintenance schedule concerned

B) Certificate of Airworthiness for Public Transport Category aircraft

C) Operational Specification Level 1, AN No. 89, para 2.2)

20) Which statement below is NOT TRUE relating to a Certificate of Maintenance Review (CMR)?

A) Extensions of the CMR periodicity requirements may always be considered by the DCA upon request from the operators

B) The CMR is required to be issued for a maximum period of four calendar months except for aircraft in Private Category below 2730 kg MTWA

C) A copy must be carried on board of the aircraft to which it relates


21) All work to be carried out on Malaysian registered aircraft shall be in accordance with the requirements of

A) MCARB) BCARC) FAR

(Level 1, AN No. 29, para 2.1)

5

22) Certification responsibilities of type rated engineers/company approval holders/authorization holders can be found in

A) Airworthiness Notice No. 10B) Airworthiness Notice No. 5C) Airworthiness Notice No. 3

(Level 1, AN No. 3)

23) Before DCA can approve a major modification they may require

A) Any Approval CertificateB) A Certificate of Fitness for FlightC) A Certificate of Design

(Level 1, AN No. 78, BCAR A2-5 pg 2)

24) Who determines whether a modification is classified as major or minor?

A) The OperatorB) The DCA C) The Approved Maintenance Organisation


25) The manual that is used by Licensed Aircraft Maintenance Engineers as primary reference for maintaining a complete aircraft in a state of airworthiness is the

A) Overhaul ManualB) Illustrated Parts CatalogueC) Aircraft Maintenance Manual

(Level 1, BCAR A7-4 para 1.11)

6

26) Information regarding the possible design defect, modification, servicing changes or other relevant matters useful in maintaining aircraft and components from the manufacturer is disseminated in

A) Service BulletinsB) Airworthiness DirectivesC) Service Information Letters

(Level 1, AN No. 89 para 2.4.7)

27) The Minister of Transport has directed that the wording “MALAYSIA” with the Malaysian flag be printed on both sides of the fuselage of

A) All aircraft registered in Malaysia and eligible for a Certificate of Airworthiness

B) All aircraft flying in Malaysian airspaceC) All aircraft operated in Malaysia

(Level 1, AN NO. 67)

28) Mandatory Occurrence Report shall be despatched in writing by the quickest available means to the DCA within of the reportable occurrence coming to the knowledge of the person making the report.

A) 24 hoursB) 48 hoursC) 72 hours

(Level 1, MCAR 13th Schedule, para 13, pg 2314)

29) The correct release certification document for new or used parts

intended for aeronautical use shall be

A) Authorised Release Certificate / Airworthiness Approval Tag

B) Certificate of Release to ServiceC) Certificate of Clearance

(Level 1, AN No. 29, Appendix 1, para 2)

7

30) The name and address of registered owner of a large civil aircraft must be inscribed on a fire-proof metal plate and affixed

A) Near the main entrance to the aircraftB) At the tail section of the aircraftC) At the wing root of the aircraft

(Level 1, MCAR 1st Schedule, para 4)

31) Airworthiness flight test is required on all Malaysian registered aircraft

A) For the purpose of issuance or renewal of a Certificate of Airworthiness

B) Two yearly as specified in the approved maintenance schedule

C) Upon completion of any minor modifications

(Level 1, AN No. 45, para 1.2)

32) For Transport and Aerial Work categories aircraft with MTWA exceeding 5700 kg, the re-weighing shall be performed following the initial weighing.

A) Within four yearsB) Within three yearsC) Within two years

(Level 1, BCAR A6-4)

33) All amendments or revisions to any aircraft manuals initiated by the relevant manufacturers shall be accompanied by a

A) Letter of AuthorityB) Service Information LetterC) Letter of Transmittal

34) A JAR-145 maintenance organization must ensure that all aircraft release certifying staff are involved in actual aircraft maintenance experience for

8

A) At least 6 months in any 2 year periodB) At least 12 months in any 3 year periodC) At least 24 months in 3 year period

(Level 1, JAR-145 document, under certifying staff requirements)

35) A Modification Record Book must be kept for each aircraft of

A) Less than less than 2730 kg MTWAB) More than 2730 kg MTWAC) More than 5700 kg MTWA only

(Level 1, BCAR A7-9 para 1.3)

36) The maintenance preventive process, in which known deterioration of an item is limited to an acceptable level by the maintenance action, is termed

A) Hard TimeB) On ConditionC) Condition Monitoring

(Level 1, CAAIP Part 1 para 2)

37) The syllabus and modules that the candidates are tested on when applying for grant of an Malaysian Aircraft Maintenance Engineer’s Licence (AMEL) can be found in

A) BCAR Section AB) BCAR Section BC) BCAR Section L


38) Under new JAA ruling, a JAR 66 Aircraft Maintenance Licence does not confer any certification privileges. Certification privileges are granted by

A) The JAR 145 Authorisation

9

B) The FAR 145 AuthorisationC) The JAR 147 Authorisation

(Level 1, JAR 66 document)

39) The FAA Airworthiness Directives (AD) are published and sent directly to the users as

A) Weekly updatesB) Biweekly updatesC) Monthly updates

(Level 1, www.faa.gov)

40) JAR-OPS 1 prescribes requirements applicable to the operation of any civil aeroplanes for the purpose of commercial transportation with

A) Over 10 tonnes Maximum Take-Off Mass or with a maximum approved passenger seating configuration of 20 or more

B) Over 10 tonnes Maximum Take-Off Mass or with a minimum approved passenger seating configuration of 20 or less

C) Below 10 tonnes Maximum Take-Off Mass or with a maximum approved passenger seating configuration of 20 or more

(Level 1, JAR-OPS document)

41) A Bonded Store shall contain only

A) Those outgoing defective partsB) Those incoming parts that have not conformed to all

requirementsC) Those parts intended for aeronautical use and conform

to all requirements(Level 1, AN No. 29)

42) On receipt, all parts/materials must be placed in

A) The Quarantine StoreB) The Bonded StoreC) The General Store


10

http://www.faa.gov/

43) Malaysia does not issue Type Certificate for imported aircraft. The acceptance of imported aircraft is based on a process of

A) Validation by granting a Malaysian Certificate of ClearanceB) Validation by granting a Certificate of AcceptanceC) Validation by granting a Certificate of Airworthiness

(Level 1, AN No. 1)

44) DCA Airworthiness Notices are printed on either white or pink papers. The colour of paper indicates the type of information contained therein. The pink colour papers shall indicate

A) Notices which contain general information, administrative and technical procedures

B) Notices which include items with mandatory compliance requirements

C) Notices which include items of no significance to airworthiness of aircraft/equipment

(Level 1, AN Foreword para 3.5)

45) Pursuant to Regulation 28, MCAR 1996, an aircraft shall not be issued or renewed with Certificate of Airworthiness unless

A) It is maintained in accordance with the approved maintenance schedule/programme, to which it applies

B) It is maintained in accordance with operational experiences adopted from other air operators

C) It is maintained in accordance with the maintenance schedule/programme that has not been reviewed by the DCA


46) Which of the following JAA publications prescribes the certification procedures for aircraft, and related products and parts?

A) JAR 29B) JAR 25C) JAR 21


11

47) Which one of the following JAA publications prescribes the requirements dealing with the approval of aviation training organizations?

A) JAR 147B) JAR 145C) JAR 66


48) Pursuant to Regulation 24, MCAR 1996, which one of the following documents certifies that the holder is competent to secure that the aircraft operated by him on any flight for the purpose of public transport is operated safely?

A) Air Operator’s CertificateB) Air Operator’s Permit C) Air Service Licence

(Level 1, Regulation 24)

49) In the case of Malaysian aircraft, the equipment to be provided, in addition to any other equipment required by or under Regulation 32, MCAR 1996, shall be that specified in

A) Third Schedule of MCARB) Fourth Schedule of MCARC) Fifth Schedule of MCAR

(Level 1, Regulation 32)

50) Pursuant to Regulation 86, MCAR 1996, how long shall the operator preserve the technical log and its associated records?

A) A date two years after last entry on the technical logB) A date two years after the technical log is filledC) A date two years after the aircraft to which it relates

has been destroyed or permanently removed from use

(Leve 1, Regulation 29 para 5)

12

AIR LEGISLATION WRITTEN QUESTIONS

1. Describe, in your own words, what maintenance actions must be satisfied in order that the validity of a Certificate of Airworthiness (C of A) is maintained.a). C of A is a legal document granted by the airworthiness authority

on the basis that the specified aircraft conform to the requirement of the authority. It is maintained and operated in approved manner as laid down by MCAR reg 27. Flight manual is part of the C of A.

b). It validity is the responsibility of the operator to ensure that: i. the aircraft is maintained as per approved maintenance

schedule. ii. all mandatory modification and inspection have been

carried out.iii. the aircraft equipment must be maintained in a manner

with part approved by the DCA.iv. all CRS-SMI and CMR must be in force and valid.v. aircraft operate within limitation laid down in the Flight

manual.vi. aircraft does no fly other than the intended purpose.vii. all necessary document carried on board 9Ref MCAR 82)viii. tech log defects are rectified or deferred as per

procedures approved by DCA.

13

(Level 1, Regulations 26 & 27)

2. A component is drawn from the Bonded Store. What action would you take prior its fitment to an operational aircraft?

a). Check the component for serviceable label which is signed, stamped and dated.

b). check for correct part number, serial number on components matching with serviceable label and conform to ARC/AAT

c). check that batch number has been issue.d). check for correct packed component sign of corrosion, damage

and contamination. e). check for component life, shelf life and expiry date if applicable. f). ensure component originated from approved stores.


3. List the requirements that must be satisfied before renewal survey of the Certificate of Airworthiness may be considered by the DCA?

a). C of A renewal application form JPA-AP2, together with the appropriate fees must have been received by the DCA 30 days before date of expiry of current C of A.

b). Submission to the Airworthiness Division of the pro-forma detailed in para 4 of this notice at least 14 days before the aircraft is presented for inspection.

c). Mutual agreement with Airworthiness officer concerned as to when the aircraft log books and associated records will be available for inspection.

d). Submission of the required Airworthiness Flight Test Report and associated load sheet at least 14 days before the expected date of aircraft inspection unless otherwise agreed with the Airworthiness officer concerned.

(Level 1, AN No. 2)

14

4. List the documents that must be carried on board the public transport aircraft registered in Malaysia, if the flight is international air navigation?

i). Aircraft radio station license.ii). certificate of airworthiness. (C of A)iii). flight crew license.iv). A copy of load sheet.v). certificate of maintenance review (CMR)vi). Technical logvii). Certificate of registration.viii). Operations manual.ix). A copy of notified procedure.x). Flight manual.

(Level 1, Tenth Schedule)

5. Describe ‘A’ Condition. What is Certificate of Fitness for Flight and who can issue such certificate?

a). ‘A’ condition: Applicable to the aircraft, which C of A has ceased to be in

force by virtue of any of the matter specified in the MCAR, for the purpose of enabling it to:i. proceed to place at which any inspection.ii. Maintenance required for its continuing airworthinessiii. Proceed to a place which any inspection, maintenance

or modification.iv. Carried out functional test or in flight adjustment in

connection with carried out in manner approved by DCA of any overhaul, repair, previously approved modification, inspection or maintenance required for its airworthiness.

v. Qualify for the issue or renewal of C of Avi. The validation thereof of a C of A.

b). Certificate of fitness for flight.i. issue under ‘A’ condition of MCAR 2nd scheduleii. valid for duration stated within but not exceed 7 days from

date of issued.iii. signed by license or approved person by the DCA.

(Level 1, Second Schedule, BCAR A3-8)15

6. Describe Certificate of Maintenance Review (CMR). State the signatory of a CMR and the frequency of its issue in the case of a public transport aircraft.

a). CMR: - provide means of evidence that the aircraft was in compliance

with the requirement of the Maintenance Schedule approved by the DCA.

- all the modification and inspection classified as mandatory had been satisfied.

- a copy of the current CMR must be carried on board the aircraft to which it relates.

b). Signatory: - signed by an authorized person approved by DCA for that

purpose. - LAE with two type rating excluding ‘X’ compasses.

c). issue of CMR: - for public transport CMR is required to be issued for a

maximum period of four calendar months.


16

Air Legislation OBJECTIVE Questions

Documents

Transcript of Air Legislation OBJECTIVE Questions