a330 Etops Parts List
-
Upload
zulfikar-ali -
Category
Documents
-
view
635 -
download
53
Transcript of a330 Etops Parts List
A330 ETOPS PARTS LIST
This issue of ETOPS PARTS LIST corresponds to A330 CMP Document Revision 23 dated 17 November 2011 (Applicable to all A330 models)
- CMP Data Reference: “LR2/EASA : AMC 20-6/CMP” - Reference: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011
i.1
1. Purpose:
To identify parts whose usage is restricted on ETOPS aircraft and to further categorize them into those authorized and not authorized on an aircraft dispatched for ETOPS operation.
2. Contents:
The parts list corresponds to Airbus A330 ETOPS Configuration, Maintenance and Procedures Document (CMP), CMP Data Reference: “LR2/EASA : AMC 20-6/CMP”, and a revision number, for A330 aircraft. The list relates the CMP item name, its associated modification number and service bulletin (SB) number, Airbus and/or vendor, to a parts listing which may or may not be used on an aircraft flying ETOPS. It also traces the history of each part group, through use of pre- and post-modification numbers. The part's list reference number, issue date and corresponding CMP reference are marked on each page. 3. Method used to create the parts list:
The parts list is created after the referenced CMP is issued. The modification number and/or service bulletin number is used as the starting point to identify the old and the new part numbers. Once identified, a part number search is performed using Airbus parts data base, the service bulletin and the modification dossier, to establish the part's family tree. The parts are then classified NOT APPROVED FOR ETOPS or MINIMUM STANDARD APPROVED FOR ETOPS. Those parts NOT APPROVED are all those which are the pre-modification standard or earlier. The parts APPROVED are all those which are the post modification standard or more advanced. An item which is the direct responsibility of a vendor (noted VIPC) or the engine manufacturer may not be listed or if it is listed, may not have a complete family tree due to the unavailability of the information at Airbus. Only part numbers of major components are identified. Support items for this component, i.e. brackets, washers, nuts, etc., are not listed. If an entire configuration was changed a major component in the system change is identified. If no major component exists, no part numbers are identified and the user must assure that the correct page in the IPC (noted by the major modification number) is used. Furthermore revised items in the parts list are written in red.
4. Cautions (list short falls):
The family trees identified are as complete as possible and may give part numbers, especially in the not approved listing, which are obsolete. On the other hand, the list may not state all of the approved ETOPS parts due to an evolution in the product's standard. It is up to each user to customize this list to its operation by using its customized IPC. This list also does not contain compatibility requirements. For instance, if a certain computer invalidates the usage of another computer, the second computer is not listed. It is up to the individual user to make this liaison using IPC codes. Part numbers authorized via accomplishment of a service bulletin, but not available as a spare, may not appear on this list. As long as it can be shown that the component is post-modification standard, the part is authorized; vice-versa, a pre-modification standard is not approved. This list does not identify all amendment numbers or other similar markings which differentiates the application of lower level SBs. This information is identified if it is available and if it is needed to differentiate between an ETOPS and non-ETOPS configuration. If no note is mentioned and a second level of identifications exists, all parts within the parent numerical value are effected. This list does not track changes to higher assembly part numbers.
i.2
5. Liability Statement:
This list is created by Airbus to provide an aide in controlling ETOPS configurations. It may not be full proof! Prior to adopting this list in an ETOPS operation, each company should verify this information against its customized IPC. Any corrections and/or comments to improve the contents of this list should be provided to Airbus' ETOPS department. 6. Users Guide By Column: 6.1 Column 1 - AI Mod No.: *Component/configuration name: states the name of the component or configuration effected;
name close to or identical to that in the CMP
* mod numbers: modification numbers that are called out in the CMP * CMP Eff: : states which aircraft models have this item in their CMP. Note that this item may not
be in a CMP, but may be basic to the aircraft, by default validating the usage of parts in the approved for ETOPS column.
* or: choice of one of the modifications * and: both modifications must be embodied * ------- AND : the modification(s) above and below dotted lines must be incorporated ------- * ------- OR : the modification(s) above or below dotted lines must be incorporated ------- * ( xxxxx ) : extra information to define scope of modification effectivity * Note - "**The configuration(s) prior to this standard is (are) not flagged ("Not approved for
ETOPS ") in the IPC.**":Signals that an entire configuration and not a component was effected and that once the IPC contains ETOPS notes the modification numbers will not be identified as ETOPS or non-ETOPS.
6.2 Column 2 - AI or vendor SB: * Mod xxxxx: relates to the modification number to the service bulletin number * A330-xx-xxxx: Airbus Service Bulletin number. Same SB number appears in the CMP. * vendor name and SB number: listed when available * or: choice of one of the modifications * and: both modifications must be embodied
i.3
* ------- AND : the modification(s) above and below dotted lines must be incorporated ------- * ------- OR : the modification(s) above or below dotted lines must be incorporated ------- * ( xxxxx ) : extra information to define scope of modification effectivity * (... non-priority, no later than DD MM YY): states that all SBs and or modifications listed above this message
must be incorporated on ETOPS aircraft by the day (DD) month (MM) year (YY) given. Until that time, the aircraft can fly ETOPS without this item being embodied. If more than one note like this appears, all text above the first set of parentheses is concerned and all text after the first set of parentheses and above the second set of parentheses is governed by the note in the second parentheses.
* ------- Superseded by : mods/SBs above the top dotted line are superseded by the ------- mods/SBs below the bottom dotted line 6.3 Column 3 - P/Ns NOT ETOPS Approved: * Lists all part numbers of that referenced component/equipment which are not allowed
to be used on aircraft flying ETOPS. * Pre-mod xxxxx / Pre-SB xx-xxxx: provides a reference to part numbers which were
introduced prior to the ETOPS mod or SB, Mod xxxxx / SB xx-xxxx.
.Part numbers listed directly underneath this heading: The part numbers listed directly
underneath this pre-mod or pre-SB heading are the part numbers which have been invalidated for use on ETOPS aircraft due to the fact that Mod xxxxx becomes the minimum configuration standard.
Caution : Higher assemblies part numbers are not listed. * (mod xxxxx): appears after a part number listed underneath the heading "more advanced
standards" and identifies the modification number which introduces this part. * Equipment / component name: this is the equipment or component which is effected. If
more than one component's name is listed underneath a modification number or SB number, then all components are effected by this mod or SB. If the modification number or SB number is situated underneath the component or equipment name, then the mod or SB only effects this immediate equipment.
i.4
* Phrase "If the a/c in question has This phrase appears when an entire configuration has mod xxxxx, then IPC pages not been changed and there is no individual equipment or reflecting this mod are not component effected. The only identification feature is authorized for use.": the design feature itself which is controlled by a modification
standard. * (after DD MM YY): Signals the date which all of the part numbers (entire column) above this date
are not allowed to be used on ETOPS aircraft. Until that time, these part numbers can be installed on ETOPS aircraft. If more than one note like this appears, all text above the first set of parentheses is concerned and all text after the first set of parentheses and above the second set of parentheses is governed by the note in the second parentheses. If this note does not appear in a column, that means the item is priority for ETOPS and all part numbers in the column cannot be mounted on an aircraft flying an ETOPS route.
* -------: separates equipment or modification part numbers * (VIPC): indicates that this part number is found in the vendor IPC and is not a part sold by
Airbus. The part's family tree may be incomplete due to limited information available. The respective vendor should be contacted in case of questions.
* See (Engine manufacturer's name) IPC: indicates that the referenced engine manufacturer is
responsible for this part and that it is found in its documentation. The part's family tree should be obtained from the engine manufacturer, if not given.
* ------- OR : the part number(s) above the dotted line apply to one configuration and ------- the part number(s) below the dotted line apply to another configuration. The
configuration is mentioned in bold at the top each part number group. 6.4 Column 4 - MINIMUM STANDARD P/N ETOPS APPROVED: * Lists the part number of that referenced component/equipment which is the minimum
standard allowed to be used on aircraft flying ETOPS. More advanced standards and the allowed interchangeability are listed in the IPC.
* Mod xxxxx / SB xx-xxxx: relates to the modification number or to the service bulletin number
which caused the part number to be changed. .Part numbers listed directly underneath this heading: The part number(s) listed directly
underneath this mod number or SB number is (are) the part number(s) introduced by the mentioned change.
Caution, : Higher assembly part numbers are not listed. * more advanced standards: part numbers introduced after the minimum ETOPS standard and
allowed for used on ETOPS aircraft are found in the IPC; hence the note consult the IPC.
i.5
* Phrase "P/Ns shown on IPC pages reflecting mod xxxxx standard": This phrase appears when an entire configuration has been
changed and there is no individual equipment or component effected. The only identification feature is the design feature itself which is controlled by a modification standard.
* Equipment / component name: this is the equipment or component which is effected. If more than
one component's name is listed underneath a modification number or SB number, then all components are effected by this mod or SB. If the modification number or SB number is situated underneath the component or equipment name, then the mod or SB only effects this immediate equipment.
* -------: separates equipment or modification part numbers * (VIPC): indicates that this part number is found in the vendor IPC and is not a part sold by
Airbus. The part's family tree may be incomplete due to limited information available. The respective vendor should be contacted in case of questions.
* See (Engine manufacturer's name) IPC: indicates that the referenced engine manufacturer is responsible for this part and that it is found in its documentation. The part's family tree should be obtained from the engine manufacturer, if not given.
* ------- OR : the part number(s) above the dotted line apply to one configuration and ------- the part number(s) below the dotted line apply to another configuration. The
configuration is mentioned in bold at the top each part number group.
i.6
LIST OF APPROVED ETOPS AIRCRAFT MODELS (EASA)
Series Engine A330 Model
A330-300
GE
A330-301
A330-302
A330-303
PW
A330-321
A330-322
A330-323
RR
A330-341
A330-342
A330-343
A330-200
GE
A330-201
A330-202
A330-203
PW A330-223
RR A330-243
A330-200F PW A330-223F
RR A330-243F
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
21.1
ATA 21
AI Mod No. AI or Vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Pack Controller CMP Eff:-301,-321,-322, -341,-342
CMP Item: 21-1-0000-001
42309
Mod 42309: none
Pre-mod 42309: 977A0000-03 977A0000-02 977A0000-01
Mod 42309: 977A0000-04 more advanced stds: 977A0000-05 Consult IPC
Packs and Temperature Sensors CMP Eff: -301,-321,-322, - 341,-342 CMP Item: 21-1-0000-002
42628 and 42629
Mod 42628: A330-21-3010 / Liebherr SBs 956A-21-01 Mod 42629 : A330-21-3010/ Liebherr SB 9105A-21-1
Pre-mod 42628: 956A0000-02 956A0000-01 Pre-mod 42629 : 9105A0001-01
Mod 42628: 956A0000-03 more advanced stds: Consult IPC Mod 42629 : 9105A0005-01 more advanced standards : Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
22.1
ATA 22
AI Mod No. AI or Vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
FMGEC FM CMP Eff: -301 CMP Item: 22-1-0000-001 42792 _____ AND 43724 CMP Item: 22-1-0000-003
Standard L-5 Mod 42792: A330-22-3002/ Sextant Avionique SB B490BAM-22-001 _____ AND Standard L-6 B3 Mod 43724: A330-22-3011
Pre-mod 42792: B490BAM0103 _____ Pre-mod 43724: B490BAM0105
Mod 43724: B490BAM0106 more advanced stds: B490BAM0307 (Mod 45328)
FMGEC FM CMP Eff: -321, -322
CMP Item: 22-1-0000-002 42931 _____ AND 44661 CMP Item: 22-1-0000-003
Standard L-5 Mod 42931: none _____ AND Standard L-6 C3 Mod 44661: A330-22-3009
Pre-mod 42931: B490CAM0101 B490DAM0101 _____ Pre-mod 44661: B490CAM0102 B490CAM0103
Mod 44661: B490CAM0104 more advanced stds: B490CAM0305 (Mod 45239)
FMGEC FM CMP Eff : -341,-342 CMP Item: 22-1-0000-002 41815 _____ AND 44662 CMP Item: 22-1-0000-003
Standard L-5 Mod 41815: None _____ AND Standard L-6 D3 Mod 44662: A330-22-3010
Pre-mod 41815: N/A _____ Pre-mod 44662: B490DAM0101 B490DAM0102
Mod 44662: B490DAM0104 more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
22.2
ATA 22
AI Mod No. AI or Vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
FMGEC FM CMP Eff: -201,-202,-203, -301,-302,-303, -223,-321,-322,-323, -243,-341,-342,-343, CMP Item: 22-1-0000-004
55351
_____ OR
55352
_____ OR
57545
THALES Standard T2CD8 Mod 55351: A330-22-3072 A330-22-3050 A330-22-3084
_____ OR Standard T2B8 Mod 55352: A330-22-3073 A330-22-3074
OR HONEYWELL Standard TBD* Mod 57545: N/A * FMS Standard not yet available
Pre-mod 55351: N/A
Pre-mod 55352: N/A
Pre-mod 57545: N/A
Mandatory for ETOPS beyond 180 min. Post-Mod 55351: C13039CA01
Post-Mod 55352: C13039BA01 C13039CA01 C13164GA01
Post-Mod 57545: TBD*
* FMS Standard not yet available
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
23.1
ATA 23
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
SATCOM CMP Eff: - CMP Item: 23-1-0000-001 45451 _____ OR
45452 _____ OR 48447
Mod 45451: None
_____ OR Mod 45452: A330-23-3050 _____ OR Mod 48447: A330-23-3099
Mandatory for ETOPS beyond 180 min. P/Ns shown on IPC pages reflecting mod 45451 standard. P/Ns shown on IPC pages reflecting mod 45452 standard. P/Ns shown on IPC pages reflecting mod 48447 standard.
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
24.1
ATA 24
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Additional Services on CSMG Power CMP Eff: -301,-321,-322, -341,-342 CMP Item: 24-1-0000-001 41462 and 42783 ** The configuration(s) prior to this standard is (are) not flagged ("Not approved for ETOPS") in the IPC.**
Mod 41462: SB A330-24-3018 and Mod 42783: SB A330-24-3004
Configuration pre-mods 41462 and 42783 are prohibited. Use of IPCs not showing this configuration is prohibited.
P/Ns shown on IPC pages reflecting mod 41462 standard. P/Ns shown on IPC pages reflecting mod 42783 standard.
Electrical Feeder Gauge in Engine Pylons CMP Eff: -301 CMP Item: 24-1-0000-002 40121
Mod 40121: none
Configuration pre-mods 40121 are prohibited. Use of IPCs not showing this configuration is prohibited.
P/Ns shown on IPC pages reflecting mod 40121 standard.
Electrical Feeder Gauge in Engine Pylons CMP Eff: -321,-322 CMP Item: 24-1-0000-002 40209
Mod 40209: none
Configuration pre-mods 40209 are prohibited. Use of IPCs not showing this configuration is prohibited.
P/Ns shown on IPC pages reflecting mod 40209 standard.
Electrical Feeder Gauge in Engine Pylons CMP Eff: -341,-342 CMP Item: 24-1-0000-002 40210
Mod 40210: none
Configuration pre-mods 40210 are prohibited. Use of IPCs not showing this configuration is prohibited.
P/Ns shown on IPC pages reflecting mod 40210 standard.
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
24.2
ATA 24
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
APU Gen CMP Eff: -301,-321,-322, -341,-342 CMP Item: 24-1-0000-003 42952
Mod 42952: A330-24-3005/ Sundstrand Aerospace SB 90EGS07AG-24-1
Pre-mod 42952: 5909129 5909012 5908508
Mod 42952: 5910139 more advanced stds: Consult IPC
GCU of CSM/G CMP Eff: -301,-321,-322, -341,-342 CMP Item: 24-1-0000-004 42957
Mod 42957: A330-24-3006/ Vickers SB 920395-24-01
Pre-mod 42957: 920395
Mod 42957: 928005 more advanced stds: Consult IPC
IDG CMP Eff: -301 CMP Item: 24-1-0000-005 43286
Mod 43286: A330-24-3008/ Sundstrand SB 115EGS01I-24-1
Pre-mod 43286: 752168
Mod 43286: 752168A more advanced stds: Consult IPC
IDG CMP Eff: -321, -322 CMP Item: 24-1-0000-005 43285
Mod 43285: A330-24-3008/ Sundstrand SB 115EGS01I-24-1
Pre-mod 43285: 755017
Mod 43285: 755017A more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
26.1
ATA 26
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
155 min Cargo Fire Extinguishing System (Bottles)-Walter Kiddie CMP Eff: -301, -302, -303, -321,-322 -323, -341,-342,-343, -201, -202, -203, -223, -243 BASIC !! Configuration acceptable for ETOPS operations not exceeding 140 min diversion time !!
Mod BASIC: none
Pre-mod BASIC: not applicable
Mod BASIC: Bottle 1: 472931-2 (2140 cu. inch bottle) Bottle 2: 472930-2 (800 cu. inch bottle) 472930-1 (800 cu. inch bottle) (minimum standard P/N for bottle 2, ETOPS approved for diversion time up to 140 mins)
more advanced stds: Consult IPC
260 min Cargo Fire Extinguishing System (Bottles)-Walter Kiddie CMP Eff: -301, -302, -303, -321,-322, -323, -341, -342, -343 -201, -202, -203, -223, -243 -223F, -243F
40314 or 45435 (for A330-200) * Option to 40487* !! Modification mandatory if operating ETOPS up to and beyond 180 min ; Configuration acceptable for ETOPS operations not exceeding 245 min diversion time !!
Mod 40314 or Mod 45435 (for A330-200) none
Pre-mod 40314: Or Pre-mod 45435 (for A330-200): Bottle 1: none Bottle 2 : 472930-2 (800 cu. inch bottle) 472930-1 (800 cu. inch bottle) (NOT ETOPS approved for diversion time > 140 mins)
Mod 40314: or Mod 45435 (for A330-200) Bottle 1: 472931-2 (2140 cu. inch bottle) Bottle 2: 472625-1 (1600 cu. inch bottle) more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
26.2
ATA 26
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Cargo Fire Extinguisher Discharge Flexible Hose Assembly CMP Eff: -301,-321,-322 -341,-342 CMP Item: 26-1-0000-001 42451
Mod 42451: A330-26-3002
Pre-mod 42451: F2627007000400 F2627007000200
Mod 42451: F2627007200200 F2627007200000 more advanced stds: Consult IPC
SDCU (Smoke Detection Control Unit) CMP Eff: -301,-321,-322 -341,-342 CMP Item: 26-1-0000-002 42148
Mod 42148: A330-26-3003/ Sextant Avionique SB RAI 2810-26-001
Pre-mod 42148: RAI2810M0202 RAI2810M0101
Mod 42148: RAI2810M0303 more advanced stds: Consult IPC
260 min HTL Fire Extinguishing System (Bottles) CMP Eff: -301, -302, -303, -321,-322, -323, -341,-342, -343, -201, -202, -203,-223,-243, -223F, -243F
40487 (and 45435 for A330-200 only) 200093 (A330-200F only) * Option to 40314* !! Modification mandatory if operating ETOPS up to and beyond 180 min ; Configuration acceptable for ETOPS operations not exceeding 245 min diversion time !!
Mod 40487 (and Mod 45435 for A330-200 only): or Mod 200093 (and Mod 45435 for A330-200F only): none
Pre-mod 40487: (and Pre-mod 45435 for A330-200 only): or Pre-mod 200093: (and Pre-mod 45435 for A330-200F only): none; new standard
Mod 40487 (and Mod 45435 for A330-200 only):
Bottle 1: 34900008-1 (2170 cu. inch bottle)
Bottle 2: 35200003-1 (1600 cu. inch bottle)
more advanced stds: Consult IPC Mod 200093 (and Mod 45435 for A330-200F only):
Bottle 1: 34900008-2 (2170 cu. inch bottle)
Bottle 2: 35200003-2 (1600 cu. inch bottle)
more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
27.1
ATA 27
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
PTLU/RTLU (Pedal, Rudder Travel Limitation Unit) CMP Eff: -301,-321,-322, -341,-342 CMP Item: 27-1-0000-001 42707
Mod 42707: A330-27-3010/ Sarma SB 341400-27-001
Pre-mod 42707: 341400M01 341400M00
Mod 42707: 341400M02 more advanced stds: Consult IPC
FCSC2 (Provide second electrical power supply) CMP Eff: -301,-321,-322, -341,-342 CMP Item: 27-1-0000-002 44047 **The configuration(s) prior to this standard is (are) not flagged ("Not approved for ETOPS") in the IPC.**
Mod 44047: A330-27-3039
If the a/c in question has mod 44047, then IPC pages not reflecting this mod are not authorized for use.
P/Ns shown on IPC pages reflecting mod 44047 standard.
FCSC M10 Standard CMP Eff: -301,-321,-322, -341,-342 CMP Item: 27-1-0000-003 44441
Mod 44441: A330-27-3041
Pre-mod 44441: B492AAM0405 B492AAM0406 B492AAM0407 B492AAM0304
Mod 44441: B492AAM0408 more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
28.1
ATA 28
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Fuel Air Separator and Drain Valve CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-001 42890
Mod 42890: A330-28-3014
Drain Valve : Pre-mod 42890: none - new part introduced via mod 42890 Air Separator : Pre-mod 42890: F2827001100600 F2827001100000
Drain Valve : Mod 42890: 4127360 more advanced stds: Consult IPC Air Separator : Mod 42890: F2827001101000 more advanced stds: Consult IPC
Fuel Air Separator Drainage and Access Hatch CMP Eff: -301,-321,-322, -341,-342
CMP Item: 28-1-0000-002 42921 or 43169 **The configuration(s) prior to this standard is (are) not flagged ("Not approved for ETOPS") in the IPC.**
Mod 42921 Or Mod 43169 A330-53-3016
Access Hatch: If the a/c in question has mod 42921 or 43169, then IPC pages not reflecting this mod are not authorized for use.
Access Hatch: P/Ns shown on IPC pages reflecting mod 42921 or 43169 standards.
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
28.2
ATA 28
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Fuel Tank Transfer Valves Electrical Wiring to CSM/G Power CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-003 42636 **The configuration(s) prior to this standard is (are) not flagged ("Not approved for ETOPS") in the IPC.**
Mod 42636: A330-28-3011
If the a/c in question has mod 42636, then IPC pages not reflecting this mod are not authorized for use.
P/Ns shown on IPC pages reflecting mod 42636 standard.
Inner Wing Tank Refuel Pipe Restrictor CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-004 41871
Mod 41871: none
If the a/c in question has mod 41871, then IPC pages not reflecting this mod are not authorized for use.
P/Ns shown on IPC pages reflecting mod 41871 standard.
Collector Cell Water Scavenge System CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-005 42708 **The configuration(s) prior to this standard is (are) not flagged ("Not approved for ETOPS") in the IPC.**
Mod 42708: A330-28-3009
If the a/c in question has mod 42708, then IPC pages not reflecting this mod are not authorized for use.
P/Ns shown on IPC pages reflecting mod 42708 standard.
Wing Inner Tank Wiring CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-006 42014
Mod 42014: A330-28-3003
Wiring: Pre-mod 42014: If the a/c in question has mod 42014, then IPC pages not reflecting this mod are not authorized for use.
Wiring: Mod 42014: P/Ns shown on IPC pages reflecting mod 42014 standard.
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
28.3
ATA 28
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Wing Inner Tank FQI Harnesses CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-007 41282 and 42243 Note: Mod 42243 supersedes Mod 41282.
Mods 42243: A330-28-3003
Harnesses: Pre-mod 42243: 103QT: 50150-0312 (Mod 42158) 50150-0212 (Mod 41282) 50150-0112 104QT: 50150-0309 (Mod 41282) 50150-0209 50150-0109 118QT: 50150-0313 (Mod 42158) 50150-0213 (Mod 41282) 50150-0113 119QT: 50150-0214 (Mod 41282) 50150-0114 50150-0111
Harnesses: Mod 42243: 103QT: 50150-0412 104QT: 50150-0409 118QT: 50150-0413 119QT: 50150-0314 more advanced stds (all harnesses): Consult IPC
Wing Inner Tank Probes CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-006
42242
Probes: Mod 42242: A330-28-3003
Probes: Pre-mod 42242: 120QT: 20130-0118 121QT: none 122QT: none 123QT: none 124QT: none
Probes: Mod 42242: 120QT: 20130-0218 121QT: 20130-0111 122QT: 20130-0113 123QT: 20130-0112 124QT: 20130-0113 more advanced stds (all probes): Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
28.4
ATA 28
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Fuel Temperature Sensor and Densitometer Relocation CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-08 42278 and 42787
Mods 42278 and 42787: A330-28-3003
Sensor and Densitometer Relocation: Pre-mod 42278: If the a/c in question has mod 42278, then IPC pages not reflecting this mod are not authorized for use. ------- Harness: Pre-mod 42787: 50150-0506 50150-0406 50150-0306 50150-0206 50150-0106
Sensor and Densitometer Relocation: Mod 42278: P/Ns shown on IPC pages reflecting mod 42278 standard. ------- Harness: Mod 42787: 50150-0606 more advanced stds: Consult IPC
FCMC (Fuel Control and Monitoring Computer) CMP Eff: -301,-321,-322, -341,-342
44575 CMP Item: 28-1-0000-016 (compliance with CMP item 28-1-0000-020 i.e. incorporation of FCMC STD-9) (MOD 47930) supersedes the requirement of CMP item 28-1-0000-016)
Stage 7.1 Mod 44575: A330-28-3037
Pre-mod 44575: B494AAM0611 B494AAM0610 B494AAM0609 B494AAM0608 B494AAM0507 B494AAM0506 B494AAM0405 B494AAM0404 B494AAM0303 B494AAM0202 B494AAM0101
Mod 44575: B494AAM0612 (see CMP item 28-1-0000-20)
more advanced stds:B494AAM0613
(see CMP item 28-1-0000-20)
Mod 47930 B494AAM0614 B494AAM0615
further advanced standards:
Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
28.5
ATA 28
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Outer Tank Inlet Valve CMP Eff : -301,-321,-322 , -341,-342 CMP Item: 28-1-0000-011
43035 or 43122
Mod 43035 : A330-28-3016 or Mod 43122 : A330-28-3017
Pre-mods 43035 and 43122 : B97H38-602 B97H38-601
Mod 43035 : B97H63-602
Mod 43122 : B97H38-603 more advanced stds : Consult IPC
Fuel System Fault Indication CMP Eff: -301,-321,-322, -341,-342 CMP Item: 28-1-0000-013 43227 ** The configuration(s) prior to this standard is (are) not flagged ("Not Approved for ETOPS") in the IPC**
Mod 43227: A330-33-3005
Pre-mod 43227: If the a/c in question has mod 43227, then IPC pages not reflecting this mod are not authorized for use.
Mod 43227: P/Ns shown on IPC pages reflecting mod 43227 standard more advanced stds: Consult IPC
Larger Mesh-Aft Fuel Pump Grills CMP Eff : -301,-321,-322, -341,-342 CMP Item: 28-1-0000-012 43115 and 43117
Mods 43115 and 43117: A330-28-3020
Pre-mods 43115 and 43117 : If the a/c in question has mod 43115 and mod 43117, then IPC pages not reflecting these mods are not authorized for use
Mods 43115 and 43117 : P/Ns shown on IPC pages reflecting mod 43115 and mod 43117 standard more advanced stds: Consult IPC
Automatic Pre-Flight Check of APU Aft Pump CMP Eff : -301,-321,-322, -341,-342 CMP Item: 28-1-0000-014 43689
Mod 43689: A330-28-3026
Pre-mod 43689: If the a/c in question has mod 43689, then IPC pages not reflecting this mod is not authorized for use
Mod 43689: P/Ns shown on IPC pages reflecting mod 43689 standard more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
28.6
ATA 28
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Modified APU fuel Pump electrical supply CMP Eff : -301,-321,-322, -341,-342 CMP Item: 28-1-0000-015 44603
Mod 44603: A330-28-3041
If the a/c in question has mod 44603, then IPC pages not reflecting this mod are not authorized for use.
P/Ns shown on IPC pages reflecting mod 44603 standard.
New APU Aft Pump CMP Eff : -301,-321,-322, -341,-342 CMP Item: 28-1-0000-017 44725
Mod 44725: A330-28-3040
Pre-mods 44725 : P93A19-202
Mod 44725 : P93A19-203 more advanced stds : Consult IPC
Add latching device and time delay circuit in fuel trim transfer system. CMP Eff : -301,-321,-322, -341,-342 CMP Item: 28-1-0000-018 45049
Mod 45049: A330-28-3048
If the a/c in question has mod 45049, then IPC pages not reflecting this mod is not authorized for use
P/Ns shown on IPC pages reflecting mod 45049 standard more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
28.7
ATA 28
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Modified wiring of trim tank transfer system CMP Eff : -201, -202,-203,-223,-243
CMP Item: 28-1-0000-019
46825
---- OR ----
FCMC (Fuel Control and Monitoring Computer)
CMP Eff : -201, -202,-203,-223,-243
CMP Item: 28-1-0000-19 (refer also to CMP item 28-1-0000-020)
47930
Note: compliance with CMP item 28-1-0000-20 entails compliance with CMP item 28-1-0000-19
Mod 46825: A330-28-3062
---- OR ----
Mod 47930: A330-28-3067 / Sextant SB B494AAM-28-015
Pre-mod 46825: none
Pre-mod 47930:
B494AAM0613 B494AAM0612 B494AAM0611 B494AAM0610 B494AAM0609 B494AAM0608 B494AAM0507
B494AAM0506 B494AAM0405 B494AAM0404 B494AAM0303 B494AAM0202 B494AAM0101
Mod 46825:
Relay time delay: E0217XXU006A
Relay 4-pole: E0671D28A0
Mod 47930: B494AAM0614 B494AAM0615 more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
28.8
ATA 28
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
“Fuel FU/FOB discrepancy” crew alert
CMP Eff : All
CMP Item : 28-1-0000-020 49800 _____ AND
FWC (Flight Warning Computer)
47420
or
49193
(incorporation of FWC std K5 or above supersedes the requirement of CMP item 31-1-0000-001)
_____ AND
FCMC (Fuel Control and Monitoring Computer) Std 14
47930
(incorporation of FCMC std –14 supersedes the requirements of CMP items 28-1-0000-010, 28-1-0000-016 and 28-1-0000-19)
Mod 49800: A330-28-3080 _____ AND
FWC: Mod 47420: A330-31-3042 / Aerospatiale SB LA2E0-31-016 or Mod 49193 _____ AND
FCMC: Mod 47930: A330-28-3067 / SEXTANT SB B494AAM-28-015
Pre-mod 49800: no dedicated P/N information neither for FCMC without FU/FOB discrepancy alert, nor for FCMC P/N with PIN programming for alert de-activation (Mod 49801)
FWC: Pre-mod 47420: LA2E0060AK40000 LA2E0060A3K0000 LA2E0060AK30000 LA2E006091K0000 LA2E00609K10000 LA2E00609920000 LA2E00609910000 LA2E00609620000 LA2E00609610000 LA2E00609330000 LA2E00607320000 LA2E00607310000
FCMC: Pre-mod 47930: B494AAM0613 B494AAM0612 B494AAM0611 B494AAM0610 B494AAM0609 B494AAM0608 B494AAM0507 B494AAM0506 B494AAM0405 B494AAM0404 B494AAM0303 B494AAM0202 B494AAM0101
Mod 49800: no dedicated P/N information: FCMC P/N is not changed by PIN programming for activation of FU/FOB discrepancy alert
FWC: Mod 47420: LA2E0060BK50000 more advanced stds: LA2E0060BK60000 LA2E20101K70000 standard K8: P/N’s LA2E20101K800000 & LA2E0060BK800000 further advanced standards: Consult IPC
FCMC: Mod 47930: B494AAM0614 B494AAM0615 more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
29.1
ATA 29
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Wire Locked Plugs on Manifolds CMP Eff: -301,-321,-322, -341,-342,-202 CMP Item: 29-1-0000-001 42036 ** The part numbers herewith are not flagged in the IPC due to their use in more than one location on the a/c.**
Mod 42036: A330-29-3003 Note: SB applicable only for A330 MSNs 030 and 037. All other A330's have MSN 42036 as part of their basic delivery configuration.
Pre-mod 42036: AN814-10D AN814-10 AN814-12D AN814-12 AN814-16D AN814-16 AN814-6 **Consult SB for effected areas. **
Mod 42036: AN814-10DL AN814-10L AN814-12DL AN814-12L AN814-16DL AN814-16L AN814-6L AN814-8L **Consult SB for effected areas. **
EDP CMP Eff: -301,-321, -322,-202,-203 CMP Item: 29-1-0000-003
43458
Mod 43458: A330-29-3009
Pre-mod 43458: 848354 848194 518547
Mod 43458: 971844 More advanced Stds: 972630 (Mod 44176) Consult IPC for further stds
Modified Hose in Yellow Hydraulic Circuit CMP Eff: -301,-321, -322, -341, -342,-202,-203 CMP Item: 29-1-0000-004
43696
Mod 43696: A330-29-3013
Pre-mod 43696: F0003160007900
Mod 43696: F0003160010700 more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
29.2
ATA 29
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Installation of damper to reduce hydraulic engine hose pressure pulse. CMP Eff: -321, -322, -323, -223 CMP Item: 72-1-0204-007
43547
Mod 43547: A330-29-3071/ SB PW4G-100-A72-125
Pre-mod 43547: 58T498 58T501 50J803-01 50J831-01
Post-mod 43547: 51U954 51U742 51U760 51U739 51U740 52U138 51J142-01 51U955-01
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
30.1
ATA 30
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Modified Circuitry: Wing Anti-Icing Operation CMP Eff: -301,-321,-322, -341,-342 CMP Item: 30-1-0000-001 42288 **The configuration(s) prior to this standard is (are) not flagged ("Not approved for ETOPS") in the IPC.**
Mod 42288: A330-30-3003
If the a/c in question has mod 42288, then IPC pages not reflecting this mod are not authorized for use.
P/Ns shown on IPC pages reflecting mod 42288 standard.
Wing Anti-ice Valve CMP Eff: -301,-321,-322, -341,-342
CMP Item: 30-1-0000-002 42531
Mod 42531: Grimes SB 38E 93-30-01
Pre-mod 42531: 38E93-4 38E93-3 38E93-1 HYMATIC Valves (cannot be fitted on A330 at all): HC1750 HC1751 HC1752 HC1756 HC1758 HC1755 HC1757 SAS911-002A SAS912-002A
Mod 42531: 38E93-5 more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
31.1
ATA 31
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
FWC (Flight Warning Computer) CMP Eff: -301,-202,-203 CMP Item: 31-1-0000-001
42673
(compliance with CMP item 28-1-0000-020 i.e. incorporation of FWC std K5 or above (CMP Eff: all) supersedes the requirement of CMP item 31-1-0000-001)
Mod 42673: A330-31-3005/ Aerospatiale SB LA2E0-31-003
Pre-mod 42673: LA2E00607310000 Mod 42673: LA2E00607320000 (M3.2 std) (see CMP item 28-1-0000-20) more advanced stds: LA2E00609330000 LA2E00609K10000 LA2E006091K0000 LA2E0060AK30000 LA2E0060A3K0000 LA2E0060AK40000 (see CMP item 28-1-0000-20)
std K5 or above LA2E0060BK50000 LA2E0060BK60000 LA2E20101K70000 standard K8: P/N’s LA2E20101K800000 & LA2E0060BK800000 further advanced stds: Consult IPC
FWC (Flight Warning Computer) CMP Eff: -321,-322 CMP Item: 31-1-0000-002
42880
(compliance with CMP item 28-1-0000-020 i.e. incorporation of FWC std K5 or above (CMP Eff: all) supersedes the requirement of CMP item 31-1-0000-002)
Mod 42880: none
Pre-mod 42880: not applicable Mod 42880: LA2E00609610000 (N3.0 std) (see CMP item 28-1-0000-20) more advanced stds: LA2E00609620000 LA2E00609K10000 LA2E006091K0000 LA2E0060AK30000 LA2E0060A3K0000 LA2E0060AK40000 (see CMP item 28-1-0000-20)
std K5 or
aboveLA2E0060BK50000 LA2E0060BK60000 LA2E20101K70000 standard K8: P/N’s LA2E20101K800000 & LA2E0060BK800000 further advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
31.2
ATA 31
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
FWC (Flight Warning Computer) CMP Eff: -341,-342 CMP Item: 31-1-0000-003
43578
(compliance with CMP item 28-1-0000-020 i.e. incorporation of FWC std K5 or above (CMP Eff: all) supersedes the requirement of CMP item 31-1-0000-003)
Mod 43578: none
Pre-mod 43578: Not applicable Mod 43578: LA2E00609920000 (see CMP item 28-1-0000-20) more advanced stds: LA2E00609K10000 LA2E006091K0000 LA2E0060AK30000 LA2E0060A3K0000 LA2E0060AK40000 (see CMP item 28-1-0000-20)
std K5 or above LA2E0060BK50000 LA2E0060BK60000 LA2E20101K70000 standard K8: P/N’s LA2E20101K800000 & LA2E0060BK800000 further advanced stds: Consult IPC
Push button (P/B) Dimming Electrical Configuration CMP Eff: -301,-321,-322, -341,-342,-202,-203 CMP Item: 31-1-0000-004 42664 **The configuration(s) prior to this standard is (are) not flagged ("Not approved for ETOPS") in the IPC.**
Mod 42664: none
If the a/c in question has mod 42664, then IPC pages not reflecting this mod are not authorized for use.
P/Ns shown on IPC pages reflecting mod 42664 standard.
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
34.1
ATA 34
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
ADM (Air Data Module) Thermal Insulation CMP Eff: Honeywell & Litton ADIRU -301,-321,-322 CMP Item: 34-1-0000-001 42885
Mod 42885: A330-34-3008
If the a/c in question has mod 42885, then IPC pages not reflecting this mod are not authorized for use.
P/Ns shown on IPC pages reflecting mod 42885 standard.
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
36.1
ATA 36
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Fan Air Valve (FAV) CMP Eff: -301,-321,-322, -341,-342 CMP Item: 36-1-0000-001 42570
Mod 42570: A330-36-3002 / ABG Semca SB 6733-36-01
Pre-mod 42570: 6733A020000 6733A010000
Mod 42570: 6733A030000 more advanced stds: Consult IPC
BMC (Bleed Monitoring Computer) CMP Eff: -301,-321,-322, -341,-342 CMP Item: 36-1-0000-002
42943
Mod 42943: A330-36-3003 / Intertechnique SB 706-36-157
Pre-mod 42943: 785-840-1 785-840
Mod 42943: 785-840-2 more advanced stds: 785-840-3 (Mod 43468)
Consult IPC
APU Check Valve CMP Eff : -301,-321,-322, -341,-342 CMP Item: 36-1-0000-003
43190
Mod 43190: A330-36-3006
Pre-mod 43190: 4063-18202-1 4063-18202
Mod 43190: 4063-18202-2 more advanced stds: Consult IPC
High Pressure Valve (HPV) CMP Eff : -301 CMP Item: 36-1-0000-004
43197
Mod 43197: A330-36-3007/ ABG Semca SB 6763-36-01
Pre-mod 43197: 6763C040000 6763C020000 6763A010000
Mod 43197 : 6763C050000 more advanced stds: Consult IPC
High Pressure Valve (HPV) CMP Eff : -321,-322,-341,-342 CMP Item: 36-1-0000-004
43198
Mod 43198: none
Pre-mod 43198: 6763D040000 6763D020000
Mod 43198: 6763D050000 more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
36.2
ATA 36
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Pressure Transducer
CMP Eff : All Applicability: - ETOPS beyond 180 min: to be incorporated no later than 31/12/2013 - ETOPS up to 180 min: recommended CMP Item: 36-1-0000-005
202028
Mod 202028: none
Pre-mod 202028: ZRA380-00 (not approved only for ETOPS beyond 180 min after 31/12/2013)
Mod 202028: ZRA691-00 ZRA380-00 (until 31/12/2013 for ETOPS beyond 180 min only)
more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
49.1
ATA 49
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
APU GTCP 331-350-C CMP Eff: All CMP item: 49-1-2003-001 Dash 3: 42406 ---- OR ---- Dash 4: 43440
Mod 42406: Allied Signal SBs GTCP 331-49-6842 and 3881000-49-6844 ---- OR ---- Mod 43440: Allied Signal SB GTCP 331-49-7073
Pre-mod 42406: 3800454-2 3800454-1
Pre-mod 43440: 3800454-3
Pre-mod 47312: 3800454-4
Pre-mod 50179: 3800454-5
APU standards: 3800454-4A (see CMP item 49-1-2003-17)
3800454-6 (see CMP item 49-1-2003-17)
Further advanced stds: Consult IPC
ECB Aircraft Wiring, Lightning Protection CMP Eff: All CMP item: 49-1-2003-004 42186 or 42272 **The configuration(s) prior to this standard is (are) not flagged ("Not approved for ETOPS") in the IPC.**
Mod 42186 or Mod 42272: none
If the a/c in question has mod 42186 or 42272, then IPC pages not reflecting this mod are not authorized for use. (Modification in the aircraft type definition.)
P/Ns shown on IPC pages reflecting mod 42186 or 42272 standard.
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
49.2
ATA 49
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
FCU/Lube Pump Assembly CMP Eff: All
CMP item: 49-1-2003-014
43730
or
Wiring Harness (De-Oil Solenoid connector)
None
SB 49-4012 SB 49-3008 ---- OR ---- GTCP 331-49-7094
Pre-SBs 49-7092, 49-7093, 49-7094
FCU: 3883240-5 3883240-3 Lube Pump Assy: 3881000-5 3881000-4 3881000-2 3881000-1 De-Oil Connector: 3888297-1
SBs 49-7092, 49-7093, 49-7094:
FCU: 3883240-6
Lube Pump Assy: 3881000-6
De-Oil Connector: 3888297-2 more advanced stds: Consult IPC
Fuel Nozzles CMP Eff: All CMP item: 49-1-2003-009 None
None : Allied Signal SB GTCP 331-49-7085
Pre-SB 49-7085: Fuel Nozzles : 3883264-1 3883264-3
SB 49-7085: Fuel Nozzle: 3883839-2 Fuel Nozzle Assy : 3883890-1 more advanced stds: Consult IPC
Cooling Fan CMP Eff: All
CMP item: 49-1-2003-010
None
None : Allied Signal SB GTCP 331-49-7120 or GTCP 331-49-7121
Pre-SB 49-7120 or 49-7121 : 3614163-2 3614163-4 3614163-1
SB 49-7120 or 49-7121 : 3614163-5 more advanced stds: Consult IPC
Gearbox Assembly/ Starter Clutch CMP Eff: All CMP item: 49-1-2003-011
None
None : Allied Signal SB 3805028-49-7109 or GTCP 331-49-7108
Pre-SB 49-7109 or 49-7108: 3805028-1 (VIPC) 3805028-3 (VIPC) 3805028-4 (VIPC)
SB 49-7109 or 49-7108: 3805028-5 (VIPC) more advanced stds: Consult VIPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
49.3
ATA 49
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
IGV Actuator CMP Eff: All CMP item: 49-1-2003-012
None
None : Allied Signal SB 3804007-49-6977
Pre-SB 49-6977: A64982-2
SB 49-6977: A64982-3 more advanced stds: Consult IPC
Load Compressor (L/C) Module CMP Eff : All Load Compressor with improved IGV (Vespel Bushing): CMP item: 49-1-2003-016
(priority, to be incorporated prior to ETOPS)
Mod: none
Load Compressor Dash 11: 46768 CMP item: 49-12003-016
Mod: none Allied Signal SB 3804007-49-7123 or GTCP 331-49-7127
Mod 46768: Allied Signal
SB GTCP 3804007-49-7429 or Allied Signal SB GTCP 331-49-7430
Pre-SB 49-7123 or 49-7127: 3804007-4 3804007-5 3804007-6 3804007-7 Post-SB 49-7123 or 49-7127: 3804007-8
Pre-mod 46768: 3804007-10 3804007-9 3804007-8
Mod 46768: 3804007-11
more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
49.4
ATA 49
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
ECB CMP Eff: All Dash-9 or VECB dash –010100 CMP item: 49-1-2003-013
(priority, to be incorporated prior to ETOPS)
43765 or 45332
Dash-10 or VECB dash –210101 CMP item: 49-1-2003-016
46255 or 47454
(Mod 46255 or Mod 47454 supersedes Mod 43765 and Mod 45332)
Dash-11 or VECB dash-210102 CMP item: 49-1-2003-018
50295 or 50245
(Mod 50295 or Mod 50245 supersedes Mod 46255 and Mod 47454)
Mod 43765: GTCP SB 331-49-7087 Rev. 1 or Mod 45332: A330-49-3018/GTCP SB 331-49-7368 Mod 46255: A330-49-3019 / GTCP SB 331-49-7420 or Allied Signal BGT SB 304486-49-7423 or Mod 47454: A330-49-3021 / GTCP SB 331-49-7549 or Allied Signal BGT SB 3888394-49-7548 Mod 50295: A330-49-3023 / Honeywell SB 304486-49-7705 or Honeywell SB GTCP331-49-7706 or Mod 50245: A330-49-3024 / Honeywell SB 304486-49-7701 or Honeywell SB GTCP331-49-7702
Pre-mod 43765: 304486-8 304486-7 304486-6 304486-9 Mod 45332: 3888394-010100 Pre-mod 46255: 304486-9 Pre-mod 47454: 3888394-010100 Pre-mod 50295: 304486-10 Pre-mod 50245: 3888394-210101
Mod 50295: 304486-11
Mod 50245: 3888394-210102 more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
Ref: AI/EA-O 418/0174/94 Iss 16 Issue date: 17 November 2011 This issue corresponds to LR2/EASA: AMC 20-6/CMP Rev 23
49.5
ATA 49
AI Mod No. AI or vendor SB P/Ns NOT ETOPS Approved
MINIMUM STANDARD P/N
ETOPS APPROVED
Surge Control Valve (SCV) CMP Eff: All
CMP item: 49-1-2003-016
45953
Mod 45953: GTCP SB 331-49-7369 or Allied Signal Aerospace SB 3290476-49-7018
Pre-mod 45953: 3290476-3
Mod 45953: 3290476-5 3290476-4
more advanced stds: Consult IPC
APU GTCP 331-350-C with modified Bumper Quill Shaft
CMP Eff: All
CMP item: 49-1-2003-017
50179
Note: compliance with CMP item 49-1-2003-017 entails compliance with CMP item 49-1-2003-017
Mod 50179: SB A330-49-3022 / HONEYWELL SB GTCP331-49-7704 or HONEYWELL SB GTCP331-49-7738
Pre-mod 50179: 3800454-5 3800454-4
Mod 50179: 3800454-6 3800454-4A more advanced stds: Consult IPC
A330 ETOPS PARTS LIST
AIRBUS
1 Rond Point Maurice Bellonte 31707 Blagnac Cedex
FRANCE Telephone (+33) 5 61 93 33 33
© Airbus
All Rights Reserved
Printed in France