“A STUDY OF PERFORMANCE AND GROWTH OF SARAS DAIRY”
-
Upload
dipankar07 -
Category
Documents
-
view
145 -
download
4
description
Transcript of “A STUDY OF PERFORMANCE AND GROWTH OF SARAS DAIRY”
Management Thesis - I
A REPORT ON
“A STUDY OF PERFORMANCE AND GROWTH OF SARAS DAIRY”
BY
SMITA CHOUDHARY
SARAS DAIRY, ALWAR
ALWAR ZILA DUGDH UTPADAK SAHAKARI SANGH LTD., ALWAR
ISO 9001-2000 AND HACCP CERTIFIED
JAIPUR ROAD, ALWAR PH. 0144 -2702644, 2701010
Page 1 of 51
Management Thesis - I
A REPORT ON
“A STUDY OF PERFORMANCE AND GROWTH OF SARAS DAIRY”
BY
SMITA CHOUDHARY
MBA (III SEMESTER)
Submitted on 07th July 2007
A report submitted in partial fulfillment of the requirements of
PGPROGRAM (Class of 2007)
ICFAI National College,
Copies marked list: Mr. Sandeep Kumar Kautish (Faculty Guide)
Mr. Amit Bhattacharya (Company Guide)
Page 2 of 51
Management Thesis - I
TABLE OF CONTENTS
Acknowledgement.....................................................4
Preface........................................................................5
Declaration.................................................................6
Company Profile........................................................7
Product portfolio............................................8
From the Managing Director’s Desk.........................10
Who’s who of marketing department........................11
Introduction................................................................12
Objectives......................................................13
Limitations ....................................................14
List of Tables and Illustrations..................................16
Abbreviations.............................................................17
Summary....................................................................18
Body of thesis............................................................20
Main tasks and targets....................................20
Method of survey...........................................22
Conclusions....................................................24
Survey results.....................................26
Observation about Saras products......32
Observation about Saras dairy...........33
Recommendations..........................................34
Appendix....................................................................36
References..................................................................44
Glossary.....................................................................45
Page 3 of 51
Management Thesis - I
ACKNOWLEDGEMENT
I express my heartfelt thanks to Mr. J.R. Dhaka, Managing Director, AZDUSS Ltd. for his
direction, help and motivation.
I express my sincere thanks to Mr. Sandeep Kumar Kautish (Faculty Guide), Mr. Amit
Bhattacharya (Company Guide, Plant Manager, Saras Dairy, Alwar [AZDUSS Ltd., Alwar]),
Mr. L.C. Balai (Deputy Manager, Marketing) and Mr. Anil Kumar Mathur (Deputy Manager,
Administration) for their support and cooperation. They provided me their valuable help and
guidance during the training period.
I shall be highly indebted to the staff of the marketing department of Saras Dairy (AZDUSS
Ltd., Alwar) for the moral support they extended to me during the SIP training.
I also thank the booth/parlour owners and the respondents whom I surveyed for giving me
their valuable time and fruitful suggestions.
Page 4 of 51
Management Thesis - I
PREFACE
Marketing is one of the most important functions in business. It is the discipline required to understand customers' needs and the benefits they seek.
No study can be termed complete if there is no practical experience. Hence need for training has become a real necessity. The training aims to prepare students through a process of practical experience. Practical exposure no doubt has contributed a significant amount of knowledge to me along with real life experience and was an ideal combination of academic knowledge and practical experience.
Marketing activities can be regarded as lifeblood of all business concerns. In order to enhance the performance of marketing department and overall success of a business concern, study of consumer behavior and their satisfaction, sales and distribution channels, advertisement and competitive advantages is necessary. The performance of a company is very much important for an organization.
Saras Dairy, Alwar is in fact a very ideal location to gain practical experience. I am sure the experience gained in short duration, will go a long way in all my future endeavors.
Page 5 of 51
Management Thesis - I
DECLARATION
I hereby declare that this project work entitled “A study of performance and growth of
Saras Dairy, Alwar” is my original work, carried out under the guidance of my Faculty
Guide Mr. Sandeep Kumar Kautish and my Company Guide Mr. Amit Bhattacharya.
The facts and figures produced in this report are based on my own experience and study. This
report neither full nor in part has ever been submitted for award of any other degree.
Smita Choudhary
6ND11765
ICFAI National College
Alwar
Page 6 of 51
Management Thesis - I
COMPANY PROFILE
Alwar Zila Dugdh Utpadak Sahakari Sangh Ltd., Alwar (AZDUSS Ltd., Alwar) is a cooperative organization registered under Cooperative Act with Registrar of Cooperative, Government of Rajasthan. AZDUSS Ltd., Alwar was established in the year 1972 keeping in mind the interests of the cattle rearers to implement dairy development activities in the Alwar district, under Operation Flood Program. The task of milk collection started from 22nd August 1973. The main objective of the organization is to eliminate the role of intermediaries and give cattle rearers good value for the milk and prevent them from exploitation. The other objectives of the organization are:
1) To help in financial development of the villages and cattle rearers.2) To help in the social and financial development of the rural milk producers.3) To increase the milk producing capacity of the cattle.4) To make available pure, healthy and high quality milk and milk products to the
customers.
AZDUSS receives direction and assistance from Central Government, State Government, RCDF Ltd. Jaipur and National Dairy Development Board, Anand from time to time. Presently the dairy plant has a capacity to process 1.50 lakh litre milk, prepare 10 M.T. milk powder and 9.0 M.T. ghee per day. Besides these the plant also prepares chhach, lassi, dahi, shrikhand, paneer and other milk products. The plant also has a capacity to pack 2.50 lakh litre milk per day.
The Alwar plant of Saras (AZDUSS Ltd., Alwar) has been certified under internationally accepted quality and food safety management systems in accordance with ISO 9001-2000 with HACCP. The organization also helps in improvement of animal breed, providing animal health services, insurance of animals, women dairy project and providing vermicompost manure to the cattle rearers. The organization also provides cattle feed which is purchased from Nadbai and marketed in Alwar.
Page 7 of 51
Management Thesis - I
Product Portfolio
Saras Dairy, Alwar (AZDUSS Ltd., Alwar) prepares and markets the following products:
1) Milk (Available in ½ and 1 litre packs)
a. Full cream Milk (Red) Gold It contains FAT- 6% and SNF- 9%
b. Toned Milk (Blue) Taaza It contains FAT-3% and SNF- 8.5%
c. Double toned Milk (Yellow) Smart It contains FAT-1.5% and SNF-9%
d. Skim Milk (Purple) Lite It contains FAT-0.5% and SNF-8.5%
Page 8 of 51
Management Thesis - I
2) Chhach
a. Plain 500ml
b. Namkeen 250ml
3) Lassi 250ml
4) Ghee ½ litre , 1 litre and 15 litre tin
5) Paneer 200 gm and 1 KG
6) Shrikhand 100 gm Cup
7) Dahi 200 gm Cup
8) Butter (Purchased from Jaipur Dairy, marketed in Alwar) 100 gm and 500
gm
9) Flavored milk (Purchased from Jaipur Dairy, marketed in Alwar) 200 ml Bottle
Page 9 of 51
Management Thesis - I
From the Managing Director’s Desk:
The Managing Director of AZDUSS Ltd., Alwar is Mr. J.R. Dhaka. His future plans and strategies for the betterment of the organization are:
Page 10 of 51
“To provide better milk procurement price along
with technical input service to member producers. To
procure maximum milk, provide safe and good
quality milk and milk products at competitive price
to consumers. Thrust will be for better financial
health of milk union”
Management Thesis - I
Page 11 of 51
Management Thesis - I
Who’s who of Marketing Department
Hierarchy of Marketing Department
Page 12 of 51
Mr. J.R. Dhaka, M.D.
Mr. Amit Bhattacharya, Plant Manager
Mr. Lal Chand Balai, Dy. Manager
Mr. Mahesh Sharma, Asstt. Manager
Sales Supervisor
Sales Inspector
Root Supervisors
Skilled Workers
Computer Operators
Fourth Class
Management Thesis - I
INTRODUCTION
I joined Saras Dairy, Alwar (AZDUSS Ltd., Alwar) as an intern on 19th March 2007. I am working in the Marketing Department of Saras. My main task was to conduct booth, parlour and customer surveys.
American Marketing Association (AMA) defines marketing as the process of planning and executing the conception, pricing, promotion and distribution of ideas, goods and services to create exchanges that satisfy individual and organizational goals. Marketing deals with products. Product can be in the form of goods, services or ideas. Marketing is not just selling. According to Peter Drucker, “The aim of marketing is to make selling superfluous.”
Marketing department is one the most important department in every organization. The marketing activities of the organization include providing support to the milk unions within and outside the state. The marketing department conducts various surveys to know the needs and expectations of the customers.I was assigned the task to survey parlours, booths and customers of Alwar city.In Alwar city there are 10 Saras parlours and 315 booths that are currently working.
On the basis of my observation till date I expand the name SARAS as follows:
S – Smart
A – Association
R – Responsible for
A – Authentic
S – Services
I define SARAS as a Smart Association Responsible for Authentic Services.
Page 13 of 51
Management Thesis - I
OBJECTIVES
The objectives of the Executive Training at Saras Dairy (AZDUSS Ltd., Alwar) are:
1) To identify the working of the organization.
2) To conduct an exhaustive analysis of the marketing department.
3) To increase the sales of the products that are prepared and marketed by the
organization.
4) To conduct an extensive study of the market place and the customer’s needs.
5) To understand the core business of the company, organization chart, key personnel in
the company, manufacturing units, marketing channels, financial policies, etc.
6) To do a comprehensive analysis of the company and prepare the SWOT (Strengths,
Weaknesses, Opportunities and Threats) analysis report for the company.
7) To build a good rapport with the company’s staff.
8) To understand the organizational structure and the top management team including
the Chairman, Managing Director and the Officers.
9) To do a practical and live observation of the work place.
10) To understand the attitudes and behavior of the customers.
11) To analyze the sale of Saras milk in Alwar district and find out the factors which are
affecting its sale.
Page 14 of 51
Management Thesis - I
LIMITATIONS
Any research in any field topic gives some new results, discovering new areas etc. but there are always some limitations thereof.
The limitations that I came across during the course of my training at Saras (AZDUSS Ltd., Alwar) are:
1) Response Bias: Sometimes the respondents consciously or unconsciously
misrepresent the truth, and then it amounts to response bias.
2) Non response errors: Sometimes respondents do not give a response or give partial
response. It is called non response error. The reason may be lack of knowledge or
unwillingness to answer.
3) Fluctuations in weather conditions: During the survey I came across unfavorable
weather conditions like scorching heat and dust storm.
4) Scarcity of time : There is limited time available each day and lot of tasks have to
completed in a day like preparing reports, conducting surveys, spend time at the office
to gain knowledge, etc.
5) Different tastes and preferences : The study was conducted in the urban areas and it
cannot be applied to the rural areas because the tastes and preferences of people of
rural and urban areas differ vastly.
6) Inaccurate information : The answers given by the respondents are not always
correct and may be misleading.
7) Time consuming : It is very time consuming to go door to door in order to conduct a
survey of various homes and find their views and study their buying behavior.
8) Small sample size: The sample size is small and it may not actually represent the
whole population.
Page 15 of 51
Management Thesis - I
Page 16 of 51
Management Thesis - I
9) Difficult to convince people : Sometimes it becomes very difficult to convince people
as many of them are not at all aware of Saras products and some are very stubborn. It
becomes slightly difficult to convince such people but it is a challenging task and a
good learning experience. 10) Limited information : Being a trainee, it became difficult to obtain some confidential
information about the organization. This sometimes became a hurdle during the
training.
11) Non availability of person: In some cases the person is not present at home.
12) Dependence on respondents’ views: The data collected is totally dependent on
respondents’ views, which could be bias in nature.
13) Difficult to recall: It is not possible and economically viable to revisit a person who
was not present at home.
14) Lack of educated and cooperative respondents: Personal interviews are successful
only when the respondents are educated.
The limitations that Saras Dairy comes across are:
1) Low availability of raw milk in summers.
2) Dependence on milk producers.
3) Dependence on monsoons.
4) Milk can be produced not manufactured.
5) Increasing competition in dairy industry.
Page 17 of 51
Management Thesis - I
Page 18 of 51
Management Thesis - I
LIST OF TABLES AND ILLUSTRATIONS
Figure1...................................People’s opinion about dahi
Figure2...................................People’s opinion about paneer
Figure3...................................People’s opinion about ghee
Figure4...................................People’s opinion about lassi
Figure5...................................Survey result of 214 booths/parlours
Figure6...................................Responses of 250 people who visited the plant
Figure7...................................Survey result of 500 people
Figure8...................................Golden advice for Saras
Table1....................................Summary of targets and tasks
Table2....................................Reasons for which people are not using Saras products
Table3....................................Registered DCS
Table4....................................Milk Procurement
Table5....................................Liquid Milk Sale
Table6....................................Turn Over
Table7....................................My observation of Saras products
Table8....................................My observation of Saras dairy
Page 19 of 51
Management Thesis - I
ABBREVIATIONS
1. AZDUSS.......................Alwar Zila Dugdh Utpadak Sahakari Sangh Ltd., Alwar
2. DCS...............................District Cooperative Societies
3. FGS...............................Finished Goods Supply
4. FMP...............................Fresh Milk Products
5. HACCP.........................Hazard Analysis Critical Control Points
6. ISO................................International Standard Organization
7. OJT................................On Job Training
8. SIPSummer Internship Program
9. SKM..............................Skimmed Milk Powder
10. WMP.............................Whole Milk Powder
Page 20 of 51
Management Thesis - I
SUMMARY
In this section I present the summary of targets achieved by me and the tasks performed by me during the SIP training in a tabular form. The supporting documents and the detailed information are present in the appendix section at the end of the report. This Summary contains details of tasks done by me from 19th March 2007 to 6th July 2007.
Table 1
S.No. Targets/Tasks Purpose Achievements Date
1. To conduct Survey of 500 people
To know their opinion about Saras products
Interviewed 500 people
19th March 2007 to 04th July 2007
2. To organize plant visit for 250 people
To make them aware of Saras products and quality
Organized plant visit for 250 people
19th March 2007 to 30th June 2007
3. To survey 9 parlours and 210 booths
To know their problems and solve them
Surveyed 9 parlours and 205 booths
08th April 2007 to 18th June 2007
4. To interview people of the marketing department
To know their satisfaction level.
Interviewed every person of the marketing department.
23rd April 2007 to 27th April 2007
5. To take demand from various stations
To give the demand sheet to the FGS department
Took demand from 100 stations
13th May 2007 to 04th July 2007
6. Completed initial report, synopsis interim report, management thesis and final report.
As part of the ICFAI curriculum.
My Initial Report was declared the best in my batch
Initial Report 31st March 2007Synopsis 07th April 2007Interim Report 12th May 2007Management Thesis 05th July 2007Final report 06th July 2007
7. Collected secondary data from various departments
To get complete knowledge about Saras
Collected very significant data from the MIS and accounts department
Got information about milk procurementLiquid milk sale, turn over
8. Interviewed the Managing Director
To gain an insight on the future
Understood the organization’s
22/04/2007
Page 21 of 51
Management Thesis - Iof the organization plans and
strategiesfuture plans and strategies
9. Participated in milk testing camp organized monthly
To inform people about the quality of milk used by them
Learnt how to test the milk sample for purity and to know its nutritional value
20/03/07 to 25/03/07
10. I was given the responsibility to guide 36 MBA Students.
To reduce their work-load.
It improved my communication skills and enhanced my knowledge.
15/05/07 to04/07/07
Note:- I got an Appreciation Letter from my SIP Company (Alwar Zila Dugdh Utpadak Sahakari Sangh Ltd.) for good performance. Copy of Appreciation Letter is enclosed at the end of the report.
Page 22 of 51
Management Thesis - I
BODY OF THESIS
Saras (AZDUSS Ltd., Alwar) is a very large and reputed organization and it gives me immense pleasure and satisfaction to be associated with such a reputed organization.The organization maintains state of the art quality and hygiene standards.
MAIN TASKS AND TARGETS
1) To conduct a comparative study of the growth of Saras (AZDUSS Ltd., Alwar) for
three consecutive years.
2) To conduct survey of Saras parlours and booths to know their problems and sort them
out. To get feedback from Saras parlours and booths.
3) To get feedback from customers and find their problems, satisfaction level, take their
suggestions and help AZDUSS Ltd., Alwar to implement those suggestions.
4) To take responses from people who do not use Saras products and find the answer to
the question, “Why they are not using Saras products”.
5) To judge the satisfaction level of the employees of AZDUSS Ltd., Alwar.
6) To do entries of daily supply in the supply register.
Page 23 of 51
Management Thesis - I
7) To take demand of various Saras products from parlour/booth owners and distributors
through phone or personal contact in the prescribed proforma. To make maximum
people aware of Saras.
8) To organize free testing camps to test the purity of milk.
9) To increase the sale of Saras products.
10) To implement human resource management techniques to increase the satisfaction
level of the employees of AZDUSS Ltd., Alwar.
11) To interview 500 homes in four months to know their views and opinions about Saras
products.
12) To organize plant visit for 250 people in four months to show them the plant and tell
them the processes that the Saras milk undergoes and how different Saras products are
prepared. The purpose of organizing such visits is to tell the people about the many
advantages that Saras offers them like
a. Hygienic plant
b. High nutritional value of its products
c. Good storage facilities
d. Cleanliness of the plant and storage area
13) I was given the responsibility to guide 36 MBA students (working as interns in Saras
Dairy, Alwar) and assign them their tasks and duties on a weekly basis.
Page 24 of 51
Management Thesis - I
METHOD OF SURVEY
Survey Research
Research is the search for, and retrieval of, existing, discovery or creation of new information or knowledge for a specific purpose. Research has many categories, from medical research to literary research. Marketing research is a form of business research.
A survey research is defined as the method of collecting information by asking a set of pre formulated questions in a predetermined sequence in a structured questionnaire to a sample of individuals drawn so as to be representative of a defined population.
Some of the common methods of conducting surveys are:
Personal Interviews: Personal interviews are characterized by the presence of four entities i.e. the researcher, the interviewer, the interviewee and the interview environment.
Telephonic Interviews: Telephonic interviews are judged as one of the best cost-effective alternatives to face-to-face interviews and mail surveys.
Self-administered Interviews: Self administered interview is an interview in which the questionnaire is filled out without the intervention of an interviewer.
Mail Surveys: Mail survey is a survey where questionnaire is sent to the qualified respondents by e-mail.
Method of survey research used by me: Personal Interview (Door to Door Interview)
Page 25 of 51
Management Thesis - I
Reasons for Choosing Personal Interview:
I chose the personal interview method for survey research due to the following reasons:
1) Feedback Opportunities: In face to face interview, doubts of the interviewee can be clarified. Also the respondent can be assured confidentiality.
2) Probing: The interviewer in a personal interview can explore the respondent for complex answers. The detailed information so obtained is very useful to the researcher.
3) Length of Interview: The length of interview is better in personal interviews. In a personal interview, chances of the respondents answering all the questions are greater as compared to other non-personal survey methods. Personal interviews lead to improvement in the quality of responses.
Questionnaire Design
A questionnaire is a set of questions to be asked from respondents in an interview, with appropriate instructions indicating which questions are to be asked, and in what order. Questionnaires are used in various fields of research like survey research and experimental design.
Questionnaire design is a vital issue in interviewing. A properly designed questionnaire can tap the necessary information from the respondent. Therefore, researchers always design a tactful set of questions to probe and prompt the interviewee to give useful answers. Questionnaires fall under various categories, such as structured, unstructured, disguised and undisguised.
The questionnaire consists of two types of questions:
Open Ended Questions
Close Ended Questions
Page 26 of 51
Management Thesis - I
CONCLUSIONS
The following pie charts show the opinion about various Saras products.
Figure 1 Figure 2
People's opinion about Dahi
36%
18%
18%
15%
13%
Like very much
like somew hat
neutral
dislike somew hat
dislike very much
People's opinion about Paneer
51%
29%
10%
5%5%
Like very much
like somew hat
neutral
dislike somew hat
dislike very much
Figure 3 Figure 4
People's opinion about Ghee
62%13%
12%
10%3%
Like very much
like somew hat
neutral
dislike somew hat
dislike very much
People's opinion about Lassi
44%
24%
8%
14%
10%
Like very much
like somew hat
neutral
dislike somew hat
dislike very much
Note: The graph only shows the opinion of the people I surveyed and not of the general
public.
Page 27 of 51
Management Thesis - I
During the training my major work was to conduct booth/parlour surveys and customer surveys. My efforts have benefited the company (AZDUSS Ltd., Alwar) in the following ways:
1) I surveyed Saras parlours and booths and tried to find out the problems faced by the booth/parlour owners.
2) The problems faced by the booth/parlour owners were:a. They did not get timely supply of products from Saras dairy.b. They did not receive cover stands and straws to serve the customers better.
3) I conveyed these problems to the Managing Director of AZDUSS Ltd., Alwar.
4) He immediately took action after receiving my feedback.
5) This has resulted in timely supply of material to the booth and parlours and cover stands and straws were also provided to them.
6) After these actions were taken, customers started getting better facilities and this enhanced the goodwill of the company (AZDUSS Ltd., Alwar).
7) I also interviewed the staff of the marketing department to judge their satisfaction level. It proved very beneficial to the head of the organization, the Managing Director, as he came to know the satisfaction level of the employees of his organization and the action he needs to take to keep his staff completely satisfied so that they can work well for the betterment of the organization and remain loyal towards the organization.
Page 28 of 51
Management Thesis - I
Page 29 of 51
Management Thesis - I
Survey Results
During the course of SIP training I conducted survey of 9 Saras parlours, 205 booths. The results of the survey are presented graphically as follows:
Figure 5
Page 30 of 51
Survey result of 214 Booths/ Parlours
10248%
6329%
3516%
126%
21%
Highly satisfied
Very much satisfied
Fairly satisfied
Unsatisfied
Highly unsatisfied
Management Thesis - I
I organized plant visit for 250 people during the four months of my SIP training. I explained them the working of Saras plant. I also told them how Saras products are better than the products supplied by local vendors and the advantages of using Saras products. Each and every person gave his/her response and I graphically present their responses using pie chart as follows:
Figure 6
Page 31 of 51
Responses of 250 people who visited the plant
11948%
6124%
2912%
239%
114%
73%
Highly convinced
Very much convinced
Fairly convinced
Unconvinced
Highly unconvinced
Can’t say
Management Thesis - I
I surveyed 500 people. The people I interviewed were randomly selected from various colonies of Alwar. Every person has a different opinion, some say Saras products are excellent, some say they are good, some feel they are poor and some find them average. I present the result of the survey graphically using pie chart as follows:
Figure 7
Page 32 of 51
Survey result of 500 people
28958%
9820%
6613%
214%
122%
143%
Excellent
Very good
Good
Poor
Very poor
Can’t say
Management Thesis - I
Reasons of those people who are not using Saras products
During the course of my training I surveyed some people who for some or the other reason are not using Saras products or are unable to use Saras products. The reasons they gave are presented below in a tabular form.
S.No. Factor % of the people surveyed
1 Absence of home delivery 23.6
2 Unknown about Saras products 10.2
3 Products are expensive 8.4
4 Priority to buffalo’s milk 10.8
5 Possess bad smell 5.8
6 Non availability of booth in the vicinity 6.6
7 Use Saras milk in case of emergency only 5.8
8 Faith in long association with the milkman 9.2
9 Not able to pay in cash 8.2
10 Consumers own cows and buffalos 4.8
11 No price consistency 6.6
TOTAL 100
Table 2
Page 33 of 51
Management Thesis - I
As my project title is “A study of performance and growth of Saras dairy”, therefore I did a comparative analysis of many factors related to performance and growth of the organization like number of registered societies, milk procurement, liquid milk sale and turnover from 2001-02 to 2006-07. I represent the statistical figures in a tabular form below:
ALWAR ZILA DUGDH UTPADAK SAHAKARI SANGH LTD., ALWAR
REGISTERED DCS
Table 3
Year No. of registered cooperative societies
2001-02 497
2002-03 532
2003-04 609
2004-05 681
2005-06 742
2006-07 795
ALWAR ZILA DUGDH UTPADAK SAHAKARI SANGH LTD., ALWAR
MILK PROCUREMENT
Table 4
Year Milk procurement000’ kg
2001-02 59.59
2002-03 62.97
2003-04 66.22
2004-05 70.28
2005-06 76.93
2006-07 82.66
Page 34 of 51
Management Thesis - IALWAR ZILA DUGDH UTPADAK SAHAKARI SANGH LTD., ALWAR
LIQUID MILK SALE
Table 5
Year Liquid milk sale000’ lit per day
2002-03 18.6
2003-04 29.56
2004-05 35.81
2005-06 67.03
2006-07 132.69
ALWAR ZILA DUGDH UTPADAK SAHAKARI SANGH LTD., ALWAR
TURN OVER
Table 6
Year Turn over (Crore)
2001-02 53.6
2002-03 59.57
2003-04 93.77
2004-05 96.33
2005-06 95.8
2006-07 99.15
Page 35 of 51
Management Thesis - I
My observation about various Saras products with respect to people’s liking
Product
Product Excellent Very Good
Good Poor Very Poor
FCM (Gold) √
Toned Milk (Taza) √
Double toned milk (Smart)
√
Skimmed milk (Lite) √
Ghee √
Dahi √
Paneer √
Lassi √
Chhach (Plain) √
Chhach (Namkeen) √
Shrikhand (Plain) √
Shrikhand (Kesar Pista) √
Flavored Milk √
Table 7
My Observation of Saras Dairy (AZDUSS Ltd., Alwar)
Page 36 of 51
Management Thesis - I
Now I have completed four months as an intern in Saras Dairy (AZDUSS Ltd., Alwar) and during these four months as a trainee I carefully observed various aspects of the organization. Here, I am presenting my observations and findings using the Constant Sum Scale. I have divided a total of 100 points into various attributes that I observed. The maximum marks that can be allotted to a factor are 10.
The various attributes that I observed and the points I allocated to each observation are presented below in tabular format.
S.No. Characteristic of Saras Dairy Number of Points
1 Variety of milk provided by Saras Dairy 9
2 Prices are affordable 6
3 Round the clock availability 0
4 Quality and hygiene 10
5 Enough range of FMP 8
6 Staff is cooperative 9
7 Follow the ISO 9001-2000 norms 10
8 Give weightage to suggestions (Suggestions are always welcome)
8
9 Customer awareness camps and plant visits 7
10 Employee satisfaction 8
11 Market reputation 9
12 Advertisement and publicity 4
13 New product development 5
14 Channels of marketing 7
Total 100
Table 8
Page 37 of 51
Management Thesis - I
RECOMMENDATIONS
On careful observation of the Saras dairy during the training period, I have the following suggestions for Saras dairy, which on proper implementation may provide a big boost to it.
1) Home delivery facility should be provided.
2) Increase in advertisement and publicity.
3) Motivation program for booth and parlour owners.
4) All information regarding Saras dairy and its products should be available on internet.
5) The policy that an organization must follow in order to run successfully is…..
Figure 8
Page 38 of 51
Rule #1The customer is always right!
Rule #2If the customer is ever wrong, reread Rule #1
Golden Advice for Saras
Management Thesis - I
6) Marketing department should be well furnished and attractive.
7) There should be consistency in price.
8) Alwar dairy should give milk producers competitive prices and facilities.
9) Glow sign boards should be provided to booth and parlour owners.
10) New products should be launched like ice-cream.
11) An organization like Saras should have a reception and a receptionist.
12) To popularize ‘Shrikhand’ free samples may be distributed at some public places.
13) Inspection and frequent check of booths and parlours.
14) Good coordination between marketing department and booths & parlour owners.
15) Departments should be interconnected through computer network.
16) Employee identification card should be provided to employees of Saras.
17) New technology should be adopted from national and international company’s experts
in the field.
Page 39 of 51
Management Thesis - I
APPENDIX
I prepared many questionnaires to perform the survey task assigned to me. These questionnaires were first shown to the officials of the Saras dairy and after their acceptance and consent they were implemented to do the assigned task. The various questionnaires prepared by me to conduct surveys and interviews are enclosed in this section.
Alwar Zila Dugdh Utpadak Sahakari Sangh Ltd., Alwar
Date:_________
Questionnaire for Customers1) Name : ___________________________________2) Husband’s Name: ____________________________________3) Address : ___________________________________
___________________________________ ___________________________________
4) Profession : ___________________________________5) Age : ___________________________________6) Are you aware about Saras? Yes No
7) Number of family members : _______________ Adults __________ Children _________
8) Do you use Saras Products : Yes No9) If yes which products do you use?
Milk : Full Cream Toned Double Toned Skimmed
Butter Dahi Ghee Paneer s Shrikhand
Chhach : Plain Namkeen Lassi : Sweet
10) Are you satisfied with quality of Saras products? Yes No
11) Do you think that Saras products can be improved further? Yes No
12) Do you have any suggestions for further improvement of Saras products?__________________________________________________________________
13) Which is your nearest Saras booth? _____________________________________
14) Is number of booths sufficient in your locality? Yes No
15) Are all products available at the booth? Yes No
Page 40 of 51
Management Thesis - I16) Do you think Saras should start the system of home delivery? Yes No
17) Do you want Saras to introduce any new product? Yes No
If yes, which types of products?____________________________________________________________
18) Are you satisfied with the price of Saras Products? Yes No
If not why and what should be the right price? _______________________________________________________________
19) Any Suggestions __________________________________________________________________
Page 41 of 51
Management Thesis - I
Alwar Zila Dugdh Utpadak Sahakari Sangh Ltd., Alwar
Questionnaire to Obtain Feedback from the Booth/Parlours
1) Name of the Booth/parlour: _________________________________2) Address : __________________________________
__________________________________ __________________________________
3) Products available with the booth/parlourMilk : Full Cream Toned Double Toned Skimmed
Butter Dahi Ghee Paneer Shrikhand
Chhach : Plain Namkeen Milk Cake
Lassi : Sweet
4) Do you get timely supply from Saras? Yes No5) Do you get proper storage facilities to store the products? Yes No6) Average daily sales of the products?
Milk : _____________________________Dahi : _____________________________Ghee : _____________________________Chhach : _____________________________Lassi : _____________________________Paneer : _____________________________
7) What measures do you take to improve sales? _____________________________________________________________________
8) Does management of Saras help you to improve sales? Yes No
9) What support do you expect from the management of Saras to boost sales? _____________________________________________________________________
10) What source do you use to convey your demand to the plant? _____________________________________________________________________
11) Does Saras give you any credit facility and what are the payment terms and conditions? _____________________________________________________________________
12) What are the timings of your booth/parlour? _____________________________________________________________________
13) How much manpower is required to run the booth/parlour? ______________________________________________________________________
14) Are you satisfied with the profit margins you get? Yes No
15) Do you have arrangement of home delivery for regular customers?
Page 42 of 51
Management Thesis - I Yes No
16) How do you collect your payment from customers, monthly or cash and carry? _____________________________________________________________________
17) Do you have any alternative source of electricity in case of power failure to keep your products safe? Yes No
18) Do you sell other products (like bread, biscuits, eggs, etc.) along with the Saras products? Yes No
19) Are you able to sell the received products daily or you are left with some unsold products? Yes No
20) What do you do of the unsold products? ______________________________________________________________________
21) How do you handle the excessive demand for any product? ______________________________________________________________________
22) Does the marketing department of Saras help you in fulfilling the excessive demand? ______________________________________________________________________
23) Does the marketing department of Saras ask about your problems? Yes No
24) Does the marketing department of Saras solve your problems? Yes No
25) Any suggestions:________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________
Page 43 of 51
Management Thesis - I
Alwar Zila Dugdh Utpadak Sahakari Sangh Ltd., Alwar
Questionnaire to Obtain Employee Feedback
1) Name : ______________________________________2) Department : ______________________________________3) Designation : _____________________________________ 4) Address : ______________________________________
______________________________________ ______________________________________
5) No. of years in service: ______________________________________6) Timings : ______________________________________7) Job responsibility : ______________________________________8) Satisfaction Level : Extremely Not Satisfied Not Satisfied
Satisfied Very Satisfied Extremely Satisfied
9) Facilities Provided: Medical L.T.A. Loan Facility
Conveyance Allowance Traveling Allowance
House Rent Allowance Welfare Schemes
10) If you get better remuneration and opportunity in some other company will you leave Saras Dairy, Alwar? Yes No
11) How much time do you devote for field work in a day?________________________________________________________________________
12) Are you satisfied with the policies of the company with respect to customer?
Yes No
13) What steps do you take to fulfill the demand for milk when supply is short?________________________________________________________________________
14) What are the means of advertising you use?
Electronic media Print media Banners Hoardings Door to door
marketing
15) Do you set well defined targets for each booth?
Yes No
16) What are the timings of the booths?________________________________________________________________________
17) Do you prepare each product marketed by you at the Alwar plant? Yes No
18) Which products do you purchase from other plants of Saras Dairy?
________________________________________________________________________
19) What do you do with the unsold products left after the date of expiry?________________________________________________________________________
Page 44 of 51
Management Thesis - I20) How do you check the synthetic milk producers operating illegally in the market?________________________________________________________________________
21) How do you prevent duplicacy of your brand?________________________________________________________________________
22) Are you exploring the market outside Rajasthan? If yes, where?________________________________________________________________________
23) Do you get any incentives for meeting the targets?________________________________________________________________________
24) What mechanism do you use to set prices of your products?________________________________________________________________________
25) Do you take feedback from the customers? Yes No
26) Do you organize any camp to solve the problems/grievances of the customers? Yes No
27) Do you work on holidays also or do you adopt rotation system?________________________________________________________________________
28) Do you have any plans to launch new products in the market in the near future? Yes No
29) Do you see any difference between your product and the product coming from the milk producers? Yes No
Page 45 of 51
Management Thesis - I
Alwar Zila Dugdh Utpadak Sahakari Sangh Ltd., Alwar
Questionnaire for the Managing Director of the Organization
1) Name : ____________________________________2) Address : ____________________________________
____________________________________ ____________________________________
3) Phone No. : ____________________________________4) Timings : ____________________________________5) No. of years in AZDUSS Ltd., Alwar as MD ______________________________________________________________________
6) Place of work before coming to Alwar ______________________________________________________________________
7) Are you satisfied with the working of Alwar Dairy plant?
Highly Satisfied Considerably Satisfied Reasonably Satisfied
Unsatisfied Highly Unsatisfied
8) Number of staff members
Permanent Contract
9) Do you inspect the plant regularly?
Yes No
10) What is the time interval between two inspections? _____________________________________________________________________
11) What do you observe while inspecting the plant and the office? _____________________________________________________________________
12) What is the cooperation level of your employees?
Non Cooperative Cooperative Extremely Cooperative
13) What are your future plans and strategies? _____________________________________________________________________
14) What are the promotional activities you conduct to promote your products? _____________________________________________________________________
15) Do you organize events or seminars for your customers to make them aware about your products? Yes No
16) Do you conduct staff meeting for smooth working and better coordination?
Yes No
17) Does your staff work over time? If yes, do you pay extra money for that?_____________________________________________________________________
Page 46 of 51
Management Thesis - I18) Does any conflict arise between your staff members? If yes, what do you do to resolve the conflict? ____________________________________________________________________
19) Do you reserve the power to provide monetary benefit or incentive to your staff for
good performance?
Yes No
20) Do you provide training to your staff?
Yes No
21) Do you take feedback from employees?
Yes No
22) How do you keep record of your data?
Electronically Manually Both
23) Do you organize any camps or meetings where Saras parlour and booth owners are involved and their problems can be heard and solved? Yes No
24) What measures do you take to ensure smooth functioning of the organization? _____________________________________________________________________
25) Do you provide any additional benefit/incentive to booth/parlour owners? Yes No
If yes, what are the conditions that need to be fulfilled by the parlour/booth owners? ___________________________________________________________________
26) Who is responsible for setting prices of Saras products? ____________________________________________________________________
27) Are you aware of the fact that Reliance is entering the dairy industry?
Yes No
28) Have you planned any strategy to counter competition from Reliance?
Yes No
Page 47 of 51
Management Thesis - I
REFERENCES
The definitions and data used in this report are compiled from the following sources:
1) Annual publication of Saras Dairy, Alwar
2) Business Research Methodology by C.R. Kothari.
3) Business Research Methods published by ICFAI University Press.
4) Dairy map of Rajasthan from the website www.mapsofindia.com
5) Definition of marketing by American Marketing Association
6) Definition of marketing by Peter Drucker
7) MIS department of Saras dairy (AZDUSS Ltd., Alwar).
8) Principles of Marketing by Philip Kotler and Gary Armstrong.
9) Principles of Marketing published by ICFAI University Press.
Page 48 of 51
Management Thesis - I
Page 49 of 51
Management Thesis - I
GLOSSARY
The definitions of the terms used in this report are:
1) HACCP: HACCP stands for Hazard Analysis and Critical Control Points. HACCP is an industry-wide effort approved by the scientific community as well as regulatory and industry practitioners. This effort is designed to focus specifically on food safety, including food safety in retail establishments. HACCP, or the Hazard Analysis Critical Control Point system, is a process control system that identifies where hazards might occur in the food production process and puts into place stringent actions to take to prevent the hazards from occurring. By strictly monitoring and controlling each step of the process, there is less chance for hazards to occur. HACCP is important because it prioritizes and controls potential hazards in food production. By controlling major food risks, such as microbiological, chemical and physical contaminants, the industry can better assure consumers that its products are as safe as good science and technology allows. By reducing food borne hazards, public health protection is strengthened.
2) ISO : ISO is the International Standard Organization. It is essentially a federation of national standards bodies from around 150 different countries. Within ISO there are constantly new standards and upgrades being worked upon. Established in 1947, ISO is a non-government organization, with a mission broadly to promote the development of standardization with the objective of facilitating international trade. ISO standards are prefixed with 'ISO'. ISO contribute to making life simpler, and to increase the reliability and effectiveness of the goods and services we use.
3) PASTEURIZATION : Pasteurization is the process of heating liquids for the purpose of destroying viruses and harmful organisms such as bacteria, protozoa, molds, and yeasts. The process was named after its inventor, French scientist Louis Pasteur. The first pasteurization test was completed by Pasteur and Claude Bernard on April 20, 1862. The food is heated enough to destroy the most heat-resistant pathogenic or disease-causing microorganism known to be associated with that food. In this process a large quantity of milk is held in a heated vat at 63 °C (145 °F) for 30 minutes, followed by quick cooling to about 4 °C (39 °F).
Page 50 of 51
Management Thesis - I
Page 51 of 51