6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B....
Transcript of 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B....
![Page 1: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/1.jpg)
1
6V Mini Cooper S
Customer Service Guide
MMXII © Copyright Goodbaby Group (gbinternational)
![Page 2: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/2.jpg)
2
Customer Service Guide
Contents
I) Check Battery …………………………............................................. 3
II) Check Wiring Condition ……………………………..………………………. 5
III) Check Foot Pedal ………………………………………………………….….. 8
IV) Gearbox Replacement …………………………………………..…………… 10
V) Headlights Replacement .…………………………..…….……..….………. 14
VI) Schematic diagram ……………..…………….…..….………..……………. 16
VII) Exploded View …………………………..…....….……….……..…….…… 17
![Page 3: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/3.jpg)
3
Customer Service Guide
I) Check Battery
Operation: Use a Flat head screwdriver, unlock and remove the seat. Locate the battery harness, unplug the connector then use a volt-meter to check battery condition at battery side.
Step (1) Unlock these two plastic knobs
Step (2)
Unplug the battery harness (RED) after seat removed
![Page 4: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/4.jpg)
4
Customer Service Guide
I) Check Battery
Step (3)
Reading Judgment: 6.0 V ~ 6.5 V – Good condition
5.6 V ~ 5.9 V – Proceed to Recharge
5.5 V – Battery to be recharged if after the stipulated recharging time, voltage has not increased, the Battery needs replacement
Below 5.5 V – Battery needs replacement
![Page 5: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/5.jpg)
5
Customer Service Guide
II) Check Wiring Connection
Operation: There are totally two positions of connections should be checked.
A. Motor/Gearbox : Follow above (Point I) to remove the seat, locate the Gearbox harness underneath.
Check the harness of Gearbox which is in white color
![Page 6: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/6.jpg)
6
Customer Service Guide
II) Check Wiring Connection
B. Functional Switches : Access all the functional switches which are located at the bottom side of Shifter per below procedures.
Step (1)
Main function switches are located at underside of Shifter
Step (2)
Turn over the vehicle, unscrew these two screws to remove
the wirings cover
![Page 7: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/7.jpg)
7
Customer Service Guide
II) Check Wiring Connection
Check the terminal connections of Shifter
Front Rear
Step (3)
Step (4)
Red
Power switch
(leave the empty blade at the front)
Reverse above procedures to re-assemble back the vehicle
Single Black
Single Blue
Single Red
Red & Blue
Double Black
Double Red
Black
![Page 8: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/8.jpg)
8
Customer Service Guide
III) Check Foot Pedal
Operation: Follow below procedures to check the Foot Pedal connection.
Step (1)
Turn over the vehicle and pull out the Foot Pedal cover by screwdriver from right side
Blue (front)
White (middle)
Step (2)
Red (rear)
![Page 9: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/9.jpg)
9
Customer Service Guide
III) Check Foot Pedal
Step (3)
Slide in the Foot Pedal into Chassis from right side
①
② Snap back in place
![Page 10: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/10.jpg)
10
Customer Service Guide
IV) Gearbox Replacement
Operation: Follow below steps to take apart the gearbox completely for replacing.
Use a flat head screwdriver to remove the hub cap
(Rear left wheel only)
Step (1)
Step (2)
Use the same screwdriver to remove
the snap-pin from axle as showed
![Page 11: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/11.jpg)
11
Customer Service Guide
IV) Gearbox Replacement
Step (3)
Slide the rim and rear wheel out from axle
Follow above (Point IIB) to access the Motor harness underneath
the seat, then unplug it before removing the gearbox
Step (4)
![Page 12: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/12.jpg)
12
Customer Service Guide
IV) Gearbox Replacement
Step (5)
Unplug the Headlights connector plugs located at middle of bottom side
Unscrew the two wiring clips to release the harness completely
Step (6)
![Page 13: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/13.jpg)
13
Customer Service Guide
IV) Gearbox Replacement
Step (7)
Slide the gearbox out from axle
Step (8)
Advance design for easy to replace the
whole gearbox by simple steps now
Reverse above procedures to re-assemble back the vehicle
![Page 14: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/14.jpg)
14
Customer Service Guide
V) Headlights Replacement
Operation: Follow below procedures to remove and replace the Headlights assembly.
Step (1)
Pull the Headlight out from both sides of brackets
Unplug the Headlight connectors at middle of bottom side
Step (2)
![Page 15: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/15.jpg)
15
Customer Service Guide
V) Headlights Replacement
Step (3)
Unscrews two wiring clips to remove the Headlights Assembly
![Page 16: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/16.jpg)
16
Customer Service Guide
VI) Wirings Schematic
![Page 17: 6V Mini Cooper S Customer Service Guide · 2017. 12. 7. · II) Check Wiring Connection B. Functional Switches : Access all the functional switches which are located at the bottom](https://reader035.fdocuments.us/reader035/viewer/2022071510/612f14a91ecc515869433770/html5/thumbnails/17.jpg)
17
Customer Service Guide
VII) Exploded View