3141 785 35130

22
Version 1.0 CEM2000/00/55 3141 785 35130 Car entertainment system CEM2000X/78 Published by LX 1017 Service Audio Subject to modification © Copyright 2010 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. CONTENTS Technical specification ..................................................................1-2 Service measurement setup..........................................................1-3 Service aids .................................................................................1-4 Instructions on CD playability ...............................................2-1.. 2-2 Block diagram ................................................................................ 3-1 Wiring diagram .............................................................................. 4-1 Main board Circuit diagram ..................................................................5-1..5-5 Layout diagram..................................................................5-6..5-7 Panel board Circuit diagram ......................................................................... 6-1 Layout diagram..................................................................6-2..6-3 Servo board Circuit diagram..........................................................................7-1 Layout diagram ..................................................................7-2..7-3 Exploded view diagram ................................................................. 8-1 Revision list ................................................................................... 9-1

description

sevice manual

Transcript of 3141 785 35130

  • Version 1.0

    CEM2000/00/55

    3141 785 35130

    Car entertainment systemCEM2000X/78

    Published by LX 1017 Service Audio Subject to modification

    Copyright 2010 Philips Consumer Electronics B.V. Eindhoven, The NetherlandsAll rights reserved. No part of this publication may be reproduced, stored in a retrievalsystem or transmitted, in any form or by any means, electronic, mechanical, photocopying,or otherwise without the prior permission of Philips.

    CONTENTS

    Technical specification ..................................................................1-2

    Service measurement setup..........................................................1-3Service aids .................................................................................1-4

    Instructions on CD playability ...............................................2-1.. 2-2

    Block diagram ................................................................................3-1Wiring diagram ..............................................................................4-1

    Main board Circuit diagram ..................................................................5-1..5-5 Layout diagram..................................................................5-6..5-7

    Panel board Circuit diagram .........................................................................6-1 Layout diagram..................................................................6-2..6-3

    Servo board Circuit diagram..........................................................................7-1 Layout diagram ..................................................................7-2..7-3

    Exploded view diagram .................................................................8-1Revision list ...................................................................................9-1

  • TECHNICAL SPECIFICATION

    1 - 2

    Radio

    General inforamtion

  • 1-3

    LF Generator e.g. PM5110

    RecorderUse Universal Test Cassette CrO2 SBC419 4822 397 30069

    LEVEL METERe.g. Sennheiser UPM550

    with FF-filter

    S/N and distortion metee.g. Sound Technology ST170

    L

    R

    DUT

    or Universal Test Cassette Fe SBC420 4822 397 30071

    LEVEL METERe.g. Sennheiser UPM550

    with FF-filter

    S/N and distortion metere.g. Sound Technology ST1700B

    L

    R

    DUT

    CDUse Audio Signal Disc(replaces test disc 3)

    SBC429 4822 397 30184

    Bandpass250Hz-15kHz

    e.g. 7122 707 48001LF Voltmeter

    e.g. PM2534DUT

    S/N and distortion meter e.g. Sound Technology ST1700B

    Frame aeriale.g. 7122 707 89001

    Tuner AM (MW,LW)

    To avoid atmospheric interference all AM-measurements have to be carried out in a Faradays cage.Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).

    RF Generator e.g. PM5326

    Ri=

    50:

    Bandpass250Hz-15kHz

    e.g. 7122 707 48001LF Voltmeter

    e.g. PM2534DUT

    RF Generator e.g. PM5326

    S/N and distortion meter e.g. Sound Technology ST1700B

    Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).

    Ri=

    50:

    Tuner FM

    MEASUREMENT SETUP

  • 1-4

    SERVICE AIDS

    GB WARNINGAll ICs and many other semi-conductors aresusceptible to electrostatic discharges (ESD).Careless handling during repair can reduce lifedrastically.When repairing, make sure that you areconnected with the same potential as the massof the set via a wrist wrap with resistance.Keep components and tools also at thispotential.

    ESD

    CLASS 1LASER PRODUCT

    GBSafety regulations require that the set be restored to its originalcondition and that parts which are identical with those specified,be usedSafety components are marked by the symbol ! .

    Lead free

  • Set remains closed!

    N

    Y

    Play a CD for at least 10 minutes

    Y

    playabilityok ?

    Nplayabilityok ?

    add Info for customer"SET OK"

    check playability

    N

    Y

    playabilityok ?

    check playability

    check playability

    return set

    Customer complaint"CD related problem"

    "fast" lens cleaning

    1

    2

    3For flap loaders (= access to CD drive possible)cleaning method 4 is recommended

    INSTRUCTIONS ON CD PLAYABILITY

    2 - 1

    Exchange CDM

    1 - 4 For description - see following pages

  • 1PLAYABILITY CHECK

    For sets which are compatible with CD-RW discsuse CD-RW Printed Audio Disc ....................7104 099 96611

    TR 3 (Fingerprint)TR 8 (600 Black dot) maximum at 01:00

    playback of these two tracks without audible disturbanceplaying time for: Fingerprint 10seconds

    Black dot from 00:50 to 01:10 jump forward/backward (search) within a reasonable time

    For all other sets use CD-DA SBC 444A..................................4822 397 30245

    TR 14 (600 Black dot) maximum at 01:15TR 19 (Fingerprint)TR 10 (1000 wedge)

    playback of all these tracks without audible disturbanceplaying time for: 1000 wedge 10seconds

    Fingerprint 10secondsBlack dot from 01:05 to 01:25

    jump forward/backward (search) within a reasonable time

    2CUSTOMER INFORMATION

    It is proposed to add an addendum sheet to the set whichinforms the customer that the set has been checkedcarefully - but no fault was found.The problem was obviously caused by a scratched, dirty orcopy-protected CD. In case problems remain, the customeris requested to contact the workshop directly. The lens cleaning (method 3) should be mentioned in theaddendum sheet.

    The final wording in national language as well as the printingis under responsibility of the Regional Service Organizations.

    4LIQUID LENS CLEANING

    Because the material of the lens is synthetic and coatedwith a special anti-reflectivity layer, cleaning must be donewith a non-aggressive cleaning fluid. It is advised to useCleaning Solvent

    The actuator is a very precise mechanical component andmay not be damaged in order to guarantee its full function.Clean the lens gently (dont press too hard) with a soft andclean cotton bud moistened with the special lens cleaner.

    The direction of cleaning must be in the way as indicated inthe picture below.

    Before touching the lens it is advised to clean thesurface of the lens by blowing clean air over it.This to avoid that little particles make scratches onthe lens.

    INSTRUCTIONS ON CD PLAYABILITY

    2 - 2

  • SET BLOCK DIAGRAM

    3 - 1 3 - 1

  • S5L8030 8M FLASH

    1117-ADJ

    4x16M SDRAM

    SA5888 MOTOR DRIVOE

    4558

    1117-3.3V

    AMP TDA7388

    LINE OUT

    ANT ISO

    RADIO TDA7703

    4558

    VOL IC 7313

    7809

    20Pin FFC

    MCU

    22Pin Connector TO PANEL

    Wiring diagram

    SERVO Board

    Main Board

    20Pin FFC

    +5V IC

    Reset sw

  • 5 - 15 - 1

    CIRCUIT DIAGRAM - MAIN BOARDMCU PART

  • 5 - 2 5 - 2

    CIRCUIT DIAGRAM - MAIN BOARDPower PART

  • CIRCUIT DIAGRAM - MAIN BOARDRadio PART

    5 - 3 5 - 3

  • CIRCUIT DIAGRAM - MAIN BOARDAudio PART 1

    5 - 4 5 - 4

  • CIRCUIT DIAGRAM - MAIN BOARDAudio PART 2

    5 - 5 5 - 5

  • 5 - 6

    LAYOUT DIAGARM - MAIN BOARDTOP SIDE VIEW

    5 - 6

  • LAYOUT DIAGARM - MAIN BOARDBOTTOM SIDE VIEW

    5 - 7 5 - 7

  • CIRCUIT DIAGARM - PANEL BOARD

    6 - 1 6 - 1

    KEY2

    KEY1

    GND

    +5V

    REMOTE

    SYS_5V

    2COLOR

    BT_LED

    LAMP_VCC

    ENCODER

    CE

    CLK

    DATA

    INH

    GND

    GND

    DO

    CLK

    CE

    OSC

    VSS

    VDD

    INH

    TRACK-UP TRACK-DN

    USB_5V

    USB_DN

    USB_UP

    AUX_R

    AUX_L

    GND

    ,&

    SC75823

    5 .

    &3

    5

    5

    5

    5

    5

    5

    .

    5

    .

    5

    .

    5

    .

    5

    .

    5

    .

    5

    5

    5

    5

    5

    6:)81&7,&1

    6:)2/'(5

    6:),/(

    6:

    '%%6:

    (46(/6:

    6285&(

    6:%$&.

    6:

    781(6((.836:

    781(6((.'1

    6:VOL-

    6:VOL+

    6:

    EJ

    6:

    PRESET-

    6:PRESET +

    6:MENU

    6:DISP

    41&

    41&

    51&

    51&

    5 1&

    5

    1&

    51&

    51&

    5

    1&

    /('5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%

    /('

    5%5

    .

    5

    .

    ,&5(027(

    5

    5

    5

    5

    5

    ='

    9

    ='

    9

    ='

    9

    ='9

    5

    27

    0

    5

    NC

    5

    5

    1&

    5

    39

    0

    5

    1&

    5

    5

    1&

    5

    39

    0

    5

    1&

    5

    39

    0

    5

    1&5

    5

    1&

    &

    /('

    /('

    /('

    /('

    /('

    /('

    /('

    /('

    5

    5

    5

    5

    55

    (1

    (1

    6:

    POWER/ MUTE

    &

    3

    =53=5

    3

    (&X)

    41&

    5

    1&

    5

    1&

    U

    SB

    IN

    86% &

    3

    &

    3

    &

    3

    R9

    75

    R9

    76

    1&

    R9

    55

    39

    0

    R9

    54

    1&

    R9

    56

    39

    0

    R9

    57

    1&

    R9

    69

    R9

    70

    1&

    R9

    71

    39

    0

    R9

    72

    1&

    R9

    67

    R9

    68

    1&

    R9

    73

    R9

    74

    1&

    /&'&(0/&'

    /('

    5%

    R9

    79

    R9

    77

    1&

    4

    41&

    &21

    3,1&21

    $8;

    $8;,1

    5$ .

    (&X)

    &

    5$

    .

    LED17

    5%

    R9

    81

    R9

    80

    NC

    6>@

    6666666666666666

    6

    66

    66

    66

    6

    6666

    66

    66

    6 6 6 6 6 6 6 6 6 66666

    66

    6666666

    S5

    1S

    55

    S5

    4S

    53

    S4

    9S

    50

    %/8(9

    5('9

    5('9

    %/8(9

    32:(5

    32:(5

    %/8(9

    5('9

    6 6 6 6 6 6 6 6 6 66

    66666 66

    666

    6

    66

    66

    666

    6

    6

    6

    666

    666

    6666

    66

    666

    S4

    0666

    666

    666

    86%*1'

    86%9

    86%9

    86%*1'

  • LAYOUT DIAGRAM - PANEL BOARD6 - 2 6 - 2

  • CIRCUIT DIAGRAM - SERVO BOARD

    7 - 1 7 - 1

  • LAYOUT DIAGRAM - SERVO BOARDTOP SIDE VIEW

    7 - 2 7 - 2

  • LAYOUT DIAGRAM - SERVO BOARDBOTTOM SIDE VIEW

    7 - 3 7 - 3

  • EXPLODED VIEW DIAGRAM

    8 - 1 8 - 1

    6501

    6502

    6503

    6504

    6505

    ASS02

    ASS05

    CD01

    PL01

  • 9 - 1

    Revision list

    Version1.0 ( 3141 785 35130)*Initial Release