2902893 Wind-Load-Overview 0820The design wind load pressure rating of a door as expressed in PSF...
Transcript of 2902893 Wind-Load-Overview 0820The design wind load pressure rating of a door as expressed in PSF...
Hurricane Ready™
Hurricane Ready™
Residential Garage Door Wind Load Overview
Raynor StyleView™ Eden Coast by Raynor®
Aspen™ AP138
RockCreeke™
Masterpiece™ & ShowCase™
Aspen™ AP200LV
TradeMark™
Aspen™ AP200
BuildMark™
Hurricane ReadyResidential Garage DoorsDetermine Your Requirements
Step 1:Determine the minimum wind speed (MPH) your door must meet or exceed from the map below, or go to www.atcouncil.org/windspeed. Determine if wind borne debris is applicable. See map below.
Wind Borne DebrisThe wind borne debris region is also known as those areas that require the large missile impact rated door and/or windows. In Florida, being farther south and closer to the shoreline, it is more likely a home or building will be in the wind borne debris region or HVHZ (High Velocity Hurricane Zone - Miami-Dade and Broward counties).
Miami-Dade and Broward Counties require all garage doors meet the large missile impact rating, regardless if the garage door has windows or not.
Insurance companies sometimes give discounts for garage doors and other exterior building products that exceed the local building code, including meeting wind borne debris requirements not mandated. This means that installing a new garage door with the large missile impact rating may reduce your insurance premiums. Please check with your insurance agent for details.
Step 2:Determine if your home is in an Exposure B, Exposure C or Exposure D region.
Exposure BUrban and suburban areas, wooded areas or other terrain with numerous closely spaced obstructions.
Exposure COpen terrain with scattered obstructions, including flat open ground and grasslands. All of Miami-Dade and Broward Counties is Exposure C, unless it meets Exposure D definition.
Exposure DWithin 600 ft. of the ocean front or other large body of water, measuring at least 5,000 ft. across. Contact building code official or DASMA Technical Data Sheet #155t for design pressures.
Step 3:Determine the structural type of your home: one story or two story.
Step 4:Using wind speed (MPH), exposure and structural type, find your required design pressure. See chart on opposite page.
2
Design PressuresThe design wind load pressure rating of a door as expressed in PSF (pounds per square foot). The design pressure of the door must equal or exceed the design pressure for the garage door opening in which a door is to be installed. Design pressure has positive and negative values.
Garage Door Wind Load Guide - Values in PSF
Mean Roof
Height
Door Size
Based on the 2010 and 2014 Florida Building Code & ASCE7-10,Exposure B, 115 - 200 MPH Ultimate Design Wind Speed, MPH (V_ult)
Ultimate Wind Speed g 115 MPH 120 MPH 130 MPH 140 MPH 150 MPH 160 MPH 170 MPH 180 MPH 190 MPH 200 MPH
Less Than 30 Feet
Single9' x7'
12.5-14.2
13.7-15.5
16.1-18.2
18.5-20.9
21.3-24.1
24.3-27.5
27.6-31.2
30.6-34.6
34.2-38.6
38.0-43.0
Double16' x 7'
12.0-13.4
13.1-14.6
15.5-17.2
17.7-19.7
20.4-22.7
23.3-26.0
26.4-29.4
29.3-32.6
32.7-36.5
36.4-40.6
Mean Roof
Height
Door Size
Based on the 2010 and 2014 Florida Building Code & ASCE7-10,Exposure C, 115-200 MPH Ultimate Design Wind Speed, MPH (V_ult)
Ultimate Wind Speed g 115 MPH 120 MPH 130 MPH 140 MPH 150 MPH 160 MPH 170* MPH 175**MPH 180 MPH 190 MPH 200 MPH
15 Feet Single Story
Single 9'x7'
15.2-17.2
16.6-18.8
19.6-22.2
22.4-25.3
25.9-29.2
29.5-33.4
33.5-37.8
35.3-39.9
37.1-42.0
41.5-46.9
46.2-52.2
Double 16' x 7'
14.6-16.2
15.9-17.7
18.8-20.9
21.5-23.9
24.8-27.6
28.3-31.5
32.1-35.7
33.8-37.7
35.5-39.6
39.8-44.3
44.2-49.3
25 Feet Double Story
Single 9'x7'
16.8-19.0
18.4-20.8
21.7-24.5
24.8-28.0
28.6-32.3
32.7-36.9
37.0-41.8
39.0-44.1
41.1-46.4
45.9-51.9
51.1-57.7
Double 16'x7'
16.1-18.0
17.6-19.6
20.8-23.1
23.7-26.5
27.4-30.5
31.3-34.9
35.5-39.5
37.4-41.7
39.3-43.8
44.0-49.0
48.9-54.5
*Broward County is 170 MPH, Exposure C for most residential buildings.**Miami-Dade county is 175 MPH, Exposure C for most residential buildings.The design pressures listed are the minimum required. Recommended wind load levels meet or exceed the required design pressures.MPH=miles per hour PSF= pounds per square foot
Mean Roof
Height
Door Size
Based on the 2010 and 2014 Florida Building Code & ASCE7-10,Exposure D, 115-200 MPH Ultimate Design Wind Speed, MPH (V_ult)
Ultimate Wind Speed g 115 MPH 120 MPH 130 MPH 140 MPH 150 MPH 160 MPH 170 MPH 175 MPH 180 MPH 190 MPH 200 MPH
15 Feet Single Story
Single 9'x7'
18.4-20.8
20.1-22.8
23.8-26.8
27.2-30.7
31.3-35.4
35.8-40.5
40.6-45.9
42.7-48.3
45.0-50.8
50.3-56.9
55.9-63.2
Double 16' x 7'
17.7-19.7
19.3-21.5
22.7-25.4
26.0-29.0
30.0-33.4
34.3-38.2
38.8-43.3
40.9-45.6
43.1-48.0
48.2-53.7
53.6-59.7
25 Feet Double Story
Single 9'x7'
20.1-22.7
21.9-24.7
25.8-29.2
29.5-33.4
34.1-38.5
38.9-44.0
44.1-49.9
46.5-52.5
48.9-55.3
54.7-61.8
60.8-68.7
Double 16'x7'
19.2-21.4
21.0-23.4
24.7-27.6
28.3-31.5
32.6-36.4
37.3-41.6
42.2-47.1
44.5-49.6
46.8-52.2
52.4-58.4
58.2-64.9
3
4
STYLEVIEW WIDE - JULY 2020 UPDATES2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 200+9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
9’ WideIW: P-3319 (41.0/-46.3)
with impact glass
10’ Wide
F: P-2412 (34.0/-38.5) with DSB glass
T: P-2816 (34.0/-38.5) with DSB glass
12’ Wide
14’ WideF: P-2411 (14.2/-15.8)
With DSB glassF: P-2410 (25.5/-28.5)
with DSB glass
F: P-2409 (43.0/-48.0) with DSB glass
T: P-2809 (43.0/-48.0) with DSB glass
IW: P-3327 (43.0/-48.0) with impact glass
IR: P-2909 (43.0/-48.0) with impact glass
16’ Wide
F: P-2420 (27.5/-34.7) with DSB glass
T: P-2817 (27.5/-34.7) with DSB glass
18’ Wide
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Raynor StyleView™
An inspiration in both form and function, Raynor StyleView offers architectural flexibility, maximum visibility and extreme durability in maintenance-free aluminum doors. The Custom Profile, Wide Profile and Narrow Profile models feature a series of unprecedented designs, architectural glass options and 188 ArmorBrite™ powder coat or 7 anodized color finishes to showcase a home's unique flair. From modern styles to classic facades, Raynor StyleView is the choice for achieving a contemporary look or accentuating the design of any residence.
ColorsStandard Anodized Base Colors
Clear
Champagne
Light Bronze
Medium Bronze
Dark Bronze
Extra Dark Bronze
Black
Optional
Choose from over 188 Raynor ArmorBrite™ powder coat colors.The swatches shown on monitors and printed materials may vary from the actual color. For a
true representation of the color, visit your local Raynor Dealer.
"For As Long As You Own Your Home," against defects in material and workmanship.5-year finish warranty
Door Sections*
Hardware: 6 yearsSprings: 3 yearsEnduraCote: "For As Long As You Own Your Home"
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
5
STYLEVIEW WIDE - JULY 2020 UPDATES2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 200+9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
9’ WideIW: P-3319 (41.0/-46.3)
with impact glass
10’ Wide
F: P-2412 (34.0/-38.5) with DSB glass
T: P-2816 (34.0/-38.5) with DSB glass
12’ Wide
14’ WideF: P-2411 (14.2/-15.8)
With DSB glassF: P-2410 (25.5/-28.5)
with DSB glass
F: P-2409 (43.0/-48.0) with DSB glass
T: P-2809 (43.0/-48.0) with DSB glass
IW: P-3327 (43.0/-48.0) with impact glass
IR: P-2909 (43.0/-48.0) with impact glass
16’ Wide
F: P-2420 (27.5/-34.7) with DSB glass
T: P-2817 (27.5/-34.7) with DSB glass
18’ Wide
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Panel OptionsCustom Carriage HouseSwing-Up
Swing-Out
No batten 1 batten 2 batten 3 batten
No batten 1 batten 2 batten
Accordion
1 batten 1 batten
Bi-Fold
No batten no batten 1 batten
1 batten 2 batten 3 batten
Custom Mixed Panel
MillCreek MillCreek Summitreef Summitreef with panels with panels
Ridgelake Bridgeport Shoreland
Ridgelake Bridgeport Shorelandwith panels with panels with panels
Edgewater Baypoint Highcrest
Edgewater Baypoint Highcrestwith panels with panels with panels
Springfield Brookview Riverside
Springfield Brookview Riversidewith panels with panels with panels
Window OptionsCustom Carriage House1 Pane
2 Pane
2 over 2 Pane
2 over 2 Pane
3 Pane
3 over 3 Pane
4 Pane
4 over 4 Pane
Prairie (Simulated Only)
Wide ProfileSingle Car
Single car, 4’0” to 9’2”, 2 panel design
Single car, 9’3” to 12’2”, 3 panel design
Double Car
Double car 12’3” to 20’0”, 4&5 panel designs
6
EDEN COAST BY RAYNOR - JULY 2020 UPDATES2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 200+9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ WIDE
F: P-2381 (34.5/-39.0) No Windows
F: P-2382 (37.1/-41.2) No Windows
9’ WIDE
F: P-2381 (30.7/-34.7) No Windows
F: P-2382 (33.0/-36.6) No Windows
10’ WIDE
F: P-2381 (27.6/-31.2) No Windows
F: P-2382 (29.7/-33.0) No Windows
12’ WIDEF: P-2382
(24.4/-27.2) No Windows
14’ WIDEF: P-2382
(21.0/-23.3) No Windows
16’ WIDEF: P-2382
(18.3/-20.4) No Windows
18’ WIDEF: P-2382
(18.3/-20.4) No Windows
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Eden Coast by Raynor®
Eden Coast by Raynor doors are handcrafted by overlaying steel sections with environmentally-friendly composite material, providing a high-end wood look, without any of the maintenance. No matter the design, all of our overlays are impervious to moisture, mold and mildew because they are built with environmentally friendly composite materials that provide the beauty of naturally strained wood. Underneath our overlays is a sturdy and durable NeuFoam™ insulated steel door base, guarding your garage against hot and cold temperatures.
"For As Long As You Own Your Home," against rust.Certain restrictions apply to corrosive airborne substances.
Door Sections*
18.3
R-value
Hardware: 6 yearsSprings: 3 years
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
7
EDEN COAST BY RAYNOR - JULY 2020 UPDATES2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 200+9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ WIDE
F: P-2381 (34.5/-39.0) No Windows
F: P-2382 (37.1/-41.2) No Windows
9’ WIDE
F: P-2381 (30.7/-34.7) No Windows
F: P-2382 (33.0/-36.6) No Windows
10’ WIDE
F: P-2381 (27.6/-31.2) No Windows
F: P-2382 (29.7/-33.0) No Windows
12’ WIDEF: P-2382
(24.4/-27.2) No Windows
14’ WIDEF: P-2382
(21.0/-23.3) No Windows
16’ WIDEF: P-2382
(18.3/-20.4) No Windows
18’ WIDEF: P-2382
(18.3/-20.4) No Windows
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
ColorsStain Finish Options
Light Cherry
Red Walnut
Dark Cherry
Walnut
Red Mahogany
Mahogany
Dark Cedar
Driftwood
Oak
Natural
Panel OptionsDoor Styles: One and Two Car options AvailableMaximum Door Sizes: 10'0" x 18'2"
Anderson Asheville Birmingham Bridgemill Cambridge Charleston
Hampton Leatherwood Louisville Magnolia Magnolia-Arch Providence
Saratoga St. Augustine Summerhaven Williamsburg Custom
Stain colors shown are for reference only and are not indicative of what the final production color will be. As with all hand stained finishes, slight
variations in color and consistency can occur. Backing and overlays are fin-ished in the same color. Ask your authorized Raynor dealer to see samples
of actual stain options available.
Edges
Round Over Molding (Available at an additional cost.)
RoutedSquare
Backing
FlushV-Groove
For non impact window options please see page 25.
8
RockCreeke™
Designed to provide unsurpassed character in a maintenance-free design, Raynor RockCreeke overlay doors feature an environmentally stable trim board material. With a long-lasting vinyl capstock, this trim board material has an attractive appearance that holds up over time. Best of all, the material technology can utilize "reclaimed" wood fiber and vinyl from post production processes, helping to save natural resources. And, with an R-value of 13, RockCreeke doors have durable 1⅜" polyurethane insulated base door sections for thermal efficiency and maximum structural integrity.
"For As Long As You Own Your Home," against rust.Certain restrictions apply to corrosive airborne substances.
Door Sections*
12.0
R-value
Hardware: 6 yearsSprings: 3 yearsEnduraCote: "For As Long As You Own Your Home"
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
ROCKCREEKE - JULY 2020 UPDATES
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 200+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ WIDE
F: P-2346 (34.5/-39.0) Ranch glass
T: P-2807 (34.5/-39.0) Ranch glass
F: P-2347 (37.1/-41.2) Ranch glass
IR: P-3340 (52.4/-57.0)
9’ WIDE
F: P-2346 (30.7/-34.7) Ranch glass
T: P-2807 (30.7/-34.7) Ranch glass
F: P-2347 (33.0/-36.6) Ranch glass
IR: P-3340 (52.4/-57.0)
10’ WIDE
F: P-2346 (27.6/-31.2) Ranch glass
T: P-2807 (27.6/-31.2) Ranch glass
F: P-2347 (29.7/-33.0) Ranch glass
IR: P-3340 (52.4/-57.0)T: P-2906 (52.4/-57.0)
12’ WIDEF: P-2347 (24.4/-27.2)
Ranch glassIR: P-3340 (32.7/-39.4)
14’ WIDEF: P-2347 (21.0/-23.3)
Ranch glassIR: P-3340 (32.7/-39.4)
16’ WIDE
F: P-2347 (18.3/-20.4) Ranch glass
T: P-2808 (18.3/-20.4) Ranch glass
IR: P-3340 (32.7/-39.4)T: P-2906 (32.7/-39.4)
18’ WIDEIR: P-3340 (25.9/-31.1)T: P-2906 (25.9/-31.1)
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
9
Panel OptionsDoor Styles: Simulated Swing-Out, Bi-fold, and Accordion (12' only)Sizes: Height: up to 10' in 6" increments Widths: 8'0", 9'0", 10'0", 12'0", 16'0", 18'0"(Accordion style doors only available in 12' widths)
Swing-Out Single-Car and Double-Car Panel Configurations
1 car 1 car with windows
1 car withV bucks
1 car with V bucks & windows
1 car withA bucks
1 car with A bucks & windows
1 car withX bucks
1 car with X bucks & windows
Accordion Panel Configurations (Only Available in 12' widths)
12' 12' bi-fold 12' with A bucks
12' with V bucks 12' with X bucks
ColorsStandard Base Colors
White
Almond
Black
Bronze
Brown
Desert Tan
Sandstone
Charcoal
Standard Board Color
White
Optional Board Color
Almond
Black
Bronze
Brown
Desert Tan
Sandstone
Charcoal
The swatches shown on monitors and printed materials may vary from the actual color. For a true representation
of the color, visit your local Raynor Dealer.
Bi-Fold
1 car 1 car with windows
ROCKCREEKE - JULY 2020 UPDATES
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 200+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ WIDE
F: P-2346 (34.5/-39.0) Ranch glass
T: P-2807 (34.5/-39.0) Ranch glass
F: P-2347 (37.1/-41.2) Ranch glass
IR: P-3340 (52.4/-57.0)
9’ WIDE
F: P-2346 (30.7/-34.7) Ranch glass
T: P-2807 (30.7/-34.7) Ranch glass
F: P-2347 (33.0/-36.6) Ranch glass
IR: P-3340 (52.4/-57.0)
10’ WIDE
F: P-2346 (27.6/-31.2) Ranch glass
T: P-2807 (27.6/-31.2) Ranch glass
F: P-2347 (29.7/-33.0) Ranch glass
IR: P-3340 (52.4/-57.0)T: P-2906 (52.4/-57.0)
12’ WIDEF: P-2347 (24.4/-27.2)
Ranch glassIR: P-3340 (32.7/-39.4)
14’ WIDEF: P-2347 (21.0/-23.3)
Ranch glassIR: P-3340 (32.7/-39.4)
16’ WIDE
F: P-2347 (18.3/-20.4) Ranch glass
T: P-2808 (18.3/-20.4) Ranch glass
IR: P-3340 (32.7/-39.4)T: P-2906 (32.7/-39.4)
18’ WIDEIR: P-3340 (25.9/-31.1)T: P-2906 (25.9/-31.1)
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
10
AP200LV - JULY 2020 UPDATES2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 200+9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ Wide
9’ WideF: P-2371
(18.5/-20.9) Ranch glass
F: P-2372 (32.7/-36.5) Ranch glass
F: P-2373 (43.3/-49.0) Ranch glass
10’ Wide
12’ WideF: P-2371
(11.4/-12.9) Ranch glass
F: P-2372 (21.3/-27.5) Ranch glass
F: P-2373 (27.6/-31.2) Ranch glass
14’ Wide
16’ WideF: P-2372 (13.1/-15.5)
Ranch glass
F: P-2373 (15.5/-19.7) Ranch glass
F: P-2374 (32.7/-36.5) Ranch glass
18’ WideF: P-2373 (12.0/-13.9)
Ranch glassF: P-2374 (23.3/-29.4)
Ranch glass
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Aspen™ AP200LVAP200LV LuxeVue door by Raynor® combines all of the aesthetic design options of our Aspen™ AP200 line with a dramatically larger top window section to create a beautiful door, with stunning curb appeal.
"For As Long As You Own Your Home," against rust.Certain restrictions apply to corrosive airborne substances.
Door Sections*
18.0
R-value
Hardware: 6 yearsSprings: 3 yearsEnduraCote: "For As Long As You Own Your Home"
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
LuxeVue™ Standard
11
AP200LV - JULY 2020 UPDATES2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 200+9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ Wide
9’ WideF: P-2371
(18.5/-20.9) Ranch glass
F: P-2372 (32.7/-36.5) Ranch glass
F: P-2373 (43.3/-49.0) Ranch glass
10’ Wide
12’ WideF: P-2371
(11.4/-12.9) Ranch glass
F: P-2372 (21.3/-27.5) Ranch glass
F: P-2373 (27.6/-31.2) Ranch glass
14’ Wide
16’ WideF: P-2372 (13.1/-15.5)
Ranch glass
F: P-2373 (15.5/-19.7) Ranch glass
F: P-2374 (32.7/-36.5) Ranch glass
18’ WideF: P-2373 (12.0/-13.9)
Ranch glassF: P-2374 (23.3/-29.4)
Ranch glass
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
For non impact window options please see page 25.
Panel Options
Raised Colonial Recessed Colonial Grooved
Raised Ranch Recessed Ranch Grooved
Flush Plank
ColorsSolid Color Options
White
Almond
Desert Tan
Sandstone
Bronze
Brown
Charcoal
Black
Distinct Finish Woodtone Options
Painted Woodtone Options
Optional Post Paint FinishRaynor’s ColorWave™ features 1,500 Sherwin-Williams® next generation post paint system for your garage door.
DriftwoodAuburn Mocha
Walnut
The swatches shown on monitors and printed materials may vary from the actual color. For a true representation
of the color, visit your local Raynor Dealer.
12
AP200 - JULY 2020 UPDATES
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 210 210+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ Wide F: P-2339 (20.8/-23.5) Ranch glass
F: P-2340 (48.6/-55.0) Ranch glass
IW: P-3344 (60.0/-65.0) Ranch glass
F: P-2341 (63.1/-70.4) Ranch glass
F: P-2342 (82.5/-90.0) No glass
IR: P-3342 (73.0/-80.0) No Windows
9’ Wide F: P-2339 (18.5/-20.9) Ranch glass
F: P-2340 (43.2/-48.9) Ranch glass
T: P-2800 (43.2/-48.9) Ranch glass
IW: P-3343 (56.1/-62.6) Colonial windows
F: P-2341 (56.1/-62.6) Ranch glass
T: P-2801 (56.1/-62.6) Ranch glass
IW: P-3341 (62.0/-69.0) Colonial windows
F: P-2342 (73.3/-80.0) No glass
IW: P-3344 (60.0/-65.0) Ranch glass
T: P-2900 (60.0/-65.0) Ranch glass
IR: P-3342 (73.0/-80.0) No Windows
IW: P-3345 (60.0/-65.0) Ranch glass
10’ Wide F: P-2339 (15.0/-16.9) Ranch glass
F: P-2340 (35.0/-39.6) Ranch glass
IW: P-3344 (42.8/-47.6) Ranch windows
F: P-2341 (45.4/-50.7) Ranch glass
F: P-2446 (50.0/-55.0) Colonial. / Ranch windowsIW: P-3346 (50.0/-55.0)
Colonial. / Ranch windowsT: P-2901 (50.0/-55.0)
Colonial. / Ranch windows
IR: P-3342 (56.5/-65.5) No Windows
F: P-2342 (72.0/-83.2) No glass
12’ Wide F: P-2340 (24.3/-27.5) Ranch glass
IW: P-3343 (31.6/-35.2) Colonial windows
F: P-2341 (31.6/-35.2) Ranch glass
IW: P-3344 (42.8/-47.6) Ranch windows
IR: P-3342 (56.5/-65.5) No Windows
F: P-2342 (60.0/-69.3) No glass
14’ Wide F: P-2340 (17.9/-20.2) Ranch glass
F: P-2341 (23.2/-25.9) Ranch glass
IW: P-3344 (32.5/-35.9) Ranch Windows
F: P-2342 (51.4/-59.4) No glass
IR: P-3342 (45.0/-52.0) No Windows
16’ Wide F: P-2340 (13.7/-15.5) Ranch glass
F: P-2341 (17.8/-19.8) Ranch glass
F: P-2446 (20.4/-22.7) Colonial / Ranch windows
P-3346 (20.4/-22.7) Col. / Ran. windows
IW: P-3344 (32.5/-35.9) Ranch windows
T: P-2900 (32.5/-35.9) Ranch glass
IW: P-3341 (36.5/-40.6) Colonial windows
F: P-2342 (45.0/-52.0) No glass
T: P-2802 (45.0/-52.0) No glass
IR: P-3342 (45.0/-52.0) No Windows
18’ Wide F: P-2340 (10.8/-12.2)Ranch glass
F: P-2341 (14.0/-15.7) Ranch glass
IW: P-3344 (24.5/-26.9) Ranch windows
F: P-2342 (37.1/-40.7) No glass
IR: P-3342 (33.4/-36.7) No Windows
T: P-2902 (33.4/-36.7) No Windows
20’ Wide F: P-2341 (11.4/-12.7)Ranch glass
IW: P-3341 (23.3/-26.0) Colonial windows
IW: P-3344 (24.5/-26.9) Ranch windows
F: P-2342 (33.4/-36.7) No glass
T: P-2802 (33.4/-36.7) No glass
IR: P-3342 (33.4/-36.7) No Windows
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Aspen™ AP200The Aspen™ model AP200 is a 2" thick, thermally efficient door, featuring Neufoam™ polyurethane insulation that fills 100% of the section's interior. Combine this with all the decorative options available, and you have a best-in-class door that just can't be beat.
"For As Long As You Own Your Home," against rust.Certain restrictions apply to corrosive airborne substances.
Door Sections*
18.0
R-value
Hardware: 6 yearsSprings: 3 yearsEnduraCote: "For As Long As You Own Your Home"
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
13
AP200 - JULY 2020 UPDATES
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 210 210+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ Wide F: P-2339 (20.8/-23.5) Ranch glass
F: P-2340 (48.6/-55.0) Ranch glass
IW: P-3344 (60.0/-65.0) Ranch glass
F: P-2341 (63.1/-70.4) Ranch glass
F: P-2342 (82.5/-90.0) No glass
IR: P-3342 (73.0/-80.0) No Windows
9’ Wide F: P-2339 (18.5/-20.9) Ranch glass
F: P-2340 (43.2/-48.9) Ranch glass
T: P-2800 (43.2/-48.9) Ranch glass
IW: P-3343 (56.1/-62.6) Colonial windows
F: P-2341 (56.1/-62.6) Ranch glass
T: P-2801 (56.1/-62.6) Ranch glass
IW: P-3341 (62.0/-69.0) Colonial windows
F: P-2342 (73.3/-80.0) No glass
IW: P-3344 (60.0/-65.0) Ranch glass
T: P-2900 (60.0/-65.0) Ranch glass
IR: P-3342 (73.0/-80.0) No Windows
IW: P-3345 (60.0/-65.0) Ranch glass
10’ Wide F: P-2339 (15.0/-16.9) Ranch glass
F: P-2340 (35.0/-39.6) Ranch glass
IW: P-3344 (42.8/-47.6) Ranch windows
F: P-2341 (45.4/-50.7) Ranch glass
F: P-2446 (50.0/-55.0) Colonial. / Ranch windowsIW: P-3346 (50.0/-55.0)
Colonial. / Ranch windowsT: P-2901 (50.0/-55.0)
Colonial. / Ranch windows
IR: P-3342 (56.5/-65.5) No Windows
F: P-2342 (72.0/-83.2) No glass
12’ Wide F: P-2340 (24.3/-27.5) Ranch glass
IW: P-3343 (31.6/-35.2) Colonial windows
F: P-2341 (31.6/-35.2) Ranch glass
IW: P-3344 (42.8/-47.6) Ranch windows
IR: P-3342 (56.5/-65.5) No Windows
F: P-2342 (60.0/-69.3) No glass
14’ Wide F: P-2340 (17.9/-20.2) Ranch glass
F: P-2341 (23.2/-25.9) Ranch glass
IW: P-3344 (32.5/-35.9) Ranch Windows
F: P-2342 (51.4/-59.4) No glass
IR: P-3342 (45.0/-52.0) No Windows
16’ Wide F: P-2340 (13.7/-15.5) Ranch glass
F: P-2341 (17.8/-19.8) Ranch glass
F: P-2446 (20.4/-22.7) Colonial / Ranch windows
P-3346 (20.4/-22.7) Col. / Ran. windows
IW: P-3344 (32.5/-35.9) Ranch windows
T: P-2900 (32.5/-35.9) Ranch glass
IW: P-3341 (36.5/-40.6) Colonial windows
F: P-2342 (45.0/-52.0) No glass
T: P-2802 (45.0/-52.0) No glass
IR: P-3342 (45.0/-52.0) No Windows
18’ Wide F: P-2340 (10.8/-12.2)Ranch glass
F: P-2341 (14.0/-15.7) Ranch glass
IW: P-3344 (24.5/-26.9) Ranch windows
F: P-2342 (37.1/-40.7) No glass
IR: P-3342 (33.4/-36.7) No Windows
T: P-2902 (33.4/-36.7) No Windows
20’ Wide F: P-2341 (11.4/-12.7)Ranch glass
IW: P-3341 (23.3/-26.0) Colonial windows
IW: P-3344 (24.5/-26.9) Ranch windows
F: P-2342 (33.4/-36.7) No glass
T: P-2802 (33.4/-36.7) No glass
IR: P-3342 (33.4/-36.7) No Windows
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Panel Options
Raised Colonial Raised Ranch Recessed Ranch Grooved
Recessed Colonial Grooved Mixed Raised Panel Flush
Plank (Beadline)For impact window options please see page 23.
For non impact window options please see page 24.
ColorsSolid Color Options
White
Almond
Desert Tan
Sandstone
Bronze
Brown
Charcoal
Black
Distinct Finish Woodtone Options
Painted Woodtone Options Optional Post Paint Finish
Raynor’s ColorWave™ features 1,500 Sherwin-Williams® next generation post paint system for your garage door.
The swatches shown on monitors and printed materials may vary from the actual color. For a true representation of the color, visit your local Raynor Dealer.
DriftwoodAuburn Mocha
Walnut
14
AP138 - JULY 2020 UPDATES2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 100 110 115 120 130 140 150 160 170 180 190 200 210 210+9’ x 7’ EXP B 9.6/-10.9 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 9.2/-10.3 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ Wide F: P-2339 (12.8/-14.0) Ranch glass
F: P-2340 (31.1/-35.1) Ranch glass
F: P-2341 (55.1/-61.2) Ranch glass
IW: P-3344 (55.0/-62.0) Ranch windows
F: P-2342 (74.5/-82.5) No glass
IR: P-3342 (66.3/-73.0) No windows
9’ Wide F: P-2339 (11.4/-12.4) Ranch glass
P-2339 (12.6/-14.2) Ranch glass (24”)
F: P-2340 (27.6/-31.2) Ranch glass
T: P-2800 (27.6/-31.2) Ranch glass
P-2340 (34.2/-38.6) Ranch glass (24”)
IW: P-3343 (49.0/-54.4) Colonial windows
F: P-2341 (49.0/-54.4) Ranch glass
T: P-2801 (49.0/-54.4) Ranch glass
IW: P-3341 (55.0/-62.0) Colonial windows
IW: P-3344 (55.0/-62.0) Ranch windows
T: P-2900 (55.0/-62.0) Ranch windows
F: P-2342 (66.3/-73.0) No windows
IR: P-3342 (66.3/-73.0) No windows
10’ Wide F: P-2340 (22.4/-25.3) Ranch glass
F: P-2341 (39.7/-44.1) Ranch glass
IW: P-3344 (39.1/-43.5) Ranch windows
IR: P-3342 (51.5/-60.6) No windows
F: P-2446 (50.0/-55.0) Colonial / Ranch windowsIW: P-3346 (50.0/-55.0)
Colonial / Ranch windowsT: P-2901 (50.0/-55.0)
Colonial / Ranch windows
F: P-2342 (59.2/-72.0) No windows
12’ Wide P-2340 (18.5/-20.9) Ranch glass (24”)
F: P-2340 (21.4/-23.7) Ranch glass
P-2341 (21.3/-27.5) Ranch glass (24”)
IW: P-3343 (49.0/-54.4) Colonial windows
F: P-2341 (27.6/-30.6) Ranch glass
IW: P-3344 (39.1/-43.5) Ranch windows
F: P-2342 (49.3/-60.0) No glass
IR: P-3342 (51.5/-60.6) No windows
14’ Wide F: P-2340 (15.7/-17.4) Ranch glass
F: P-2341 (20.3/-22.5) Ranch glass
IW: P-3344 (29.7/-33.1) Ranch windows
F: P-2342 (42.0/-51.4) No glass
F: P-3342 (37.0/-45.0) No windows
16’ Wide P-2340 (9.2/-10.3) Ranch glass (24”)
F: P-2340 (12.0/-13.4) Ranch glass
P-2341 (13.1/-17.2)
Ranch glass (24”)
F: P-2341 (15.5/-17.2) Ranch glass
F: P-2446 (20.4/-22.7) Colonial / Ranch
WindowsIW: P-3346 (20.4/-22.7)
Colonial / Ranch windows
Doors needed with non-impact
glass
IW: P-3341 (29.3/-32.6) Colonial windows
IW: P-3344 (29.7/-33.1) Ranch windows
T: P-2900 (29.7/-33.1) Ranch windows
F: P-2342 (37.0/-45.0) No glass
T: P-2802 (37.0/-45.0) No glass
IR: P-3342 (37.0/-45.0) No windows
18’ Wide F: P-2341 (12.3/-13.6) Ranch glass
IW: P-3344 (22.5/-24.7) Ranch windows
Doors needed with non-impact
glass
F: P-2342 (37.1/-40.7) No glass
IR: P-3342 (33.4/-36.7) No Windows
T: P-2902 (33.4/-36.7) No Windows
20’ Wide F: P-2341 (9.9/-11.0) Ranch glass
IW: P-3341 (20.1/-22.7) Colonial windows
IW: P-3344 (22.5/-24.7) Ranch windows
F: P-2342 (33.4/-36.7) No glass
T: P-2802 (33.4/-36.7) No glass
IR: P-3342 (33.4/-36.7) No Windows
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Aspen™ AP138The Aspen™ model AP138 is a 1⅜" thick, thermally efficient door, featuring Neufoam™ polyurethane insulation that fills 100% of the section's interior. Combine this with all the decorative options available, and you have a best-in-class door. The AP138 is ideal for moderate climates.
"For As Long As You Own Your Home," against rust.Certain restrictions apply to corrosive airborne substances.
Door Sections*
13.0
R-value
Hardware: 6 yearsSprings: 3 yearsEnduraCote: "For As Long As You Own Your Home"
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
15
AP138 - JULY 2020 UPDATES2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 100 110 115 120 130 140 150 160 170 180 190 200 210 210+9’ x 7’ EXP B 9.6/-10.9 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 9.2/-10.3 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
8’ Wide F: P-2339 (12.8/-14.0) Ranch glass
F: P-2340 (31.1/-35.1) Ranch glass
F: P-2341 (55.1/-61.2) Ranch glass
IW: P-3344 (55.0/-62.0) Ranch windows
F: P-2342 (74.5/-82.5) No glass
IR: P-3342 (66.3/-73.0) No windows
9’ Wide F: P-2339 (11.4/-12.4) Ranch glass
P-2339 (12.6/-14.2) Ranch glass (24”)
F: P-2340 (27.6/-31.2) Ranch glass
T: P-2800 (27.6/-31.2) Ranch glass
P-2340 (34.2/-38.6) Ranch glass (24”)
IW: P-3343 (49.0/-54.4) Colonial windows
F: P-2341 (49.0/-54.4) Ranch glass
T: P-2801 (49.0/-54.4) Ranch glass
IW: P-3341 (55.0/-62.0) Colonial windows
IW: P-3344 (55.0/-62.0) Ranch windows
T: P-2900 (55.0/-62.0) Ranch windows
F: P-2342 (66.3/-73.0) No windows
IR: P-3342 (66.3/-73.0) No windows
10’ Wide F: P-2340 (22.4/-25.3) Ranch glass
F: P-2341 (39.7/-44.1) Ranch glass
IW: P-3344 (39.1/-43.5) Ranch windows
IR: P-3342 (51.5/-60.6) No windows
F: P-2446 (50.0/-55.0) Colonial / Ranch windowsIW: P-3346 (50.0/-55.0)
Colonial / Ranch windowsT: P-2901 (50.0/-55.0)
Colonial / Ranch windows
F: P-2342 (59.2/-72.0) No windows
12’ Wide P-2340 (18.5/-20.9) Ranch glass (24”)
F: P-2340 (21.4/-23.7) Ranch glass
P-2341 (21.3/-27.5) Ranch glass (24”)
IW: P-3343 (49.0/-54.4) Colonial windows
F: P-2341 (27.6/-30.6) Ranch glass
IW: P-3344 (39.1/-43.5) Ranch windows
F: P-2342 (49.3/-60.0) No glass
IR: P-3342 (51.5/-60.6) No windows
14’ Wide F: P-2340 (15.7/-17.4) Ranch glass
F: P-2341 (20.3/-22.5) Ranch glass
IW: P-3344 (29.7/-33.1) Ranch windows
F: P-2342 (42.0/-51.4) No glass
F: P-3342 (37.0/-45.0) No windows
16’ Wide P-2340 (9.2/-10.3) Ranch glass (24”)
F: P-2340 (12.0/-13.4) Ranch glass
P-2341 (13.1/-17.2)
Ranch glass (24”)
F: P-2341 (15.5/-17.2) Ranch glass
F: P-2446 (20.4/-22.7) Colonial / Ranch
WindowsIW: P-3346 (20.4/-22.7)
Colonial / Ranch windows
Doors needed with non-impact
glass
IW: P-3341 (29.3/-32.6) Colonial windows
IW: P-3344 (29.7/-33.1) Ranch windows
T: P-2900 (29.7/-33.1) Ranch windows
F: P-2342 (37.0/-45.0) No glass
T: P-2802 (37.0/-45.0) No glass
IR: P-3342 (37.0/-45.0) No windows
18’ Wide F: P-2341 (12.3/-13.6) Ranch glass
IW: P-3344 (22.5/-24.7) Ranch windows
Doors needed with non-impact
glass
F: P-2342 (37.1/-40.7) No glass
IR: P-3342 (33.4/-36.7) No Windows
T: P-2902 (33.4/-36.7) No Windows
20’ Wide F: P-2341 (9.9/-11.0) Ranch glass
IW: P-3341 (20.1/-22.7) Colonial windows
IW: P-3344 (22.5/-24.7) Ranch windows
F: P-2342 (33.4/-36.7) No glass
T: P-2802 (33.4/-36.7) No glass
IR: P-3342 (33.4/-36.7) No Windows
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Panel Options
Raised Colonial Raised Ranch Recessed Ranch Grooved
Recessed Colonial Grooved Mixed Raised Panel Flush
Plank (Beadline)For impact window options please see page 23.
For non impact window options please see page 24.
ColorsSolid Color Options
White
Almond
Desert Tan
Sandstone
Bronze
Brown
Charcoal
Black
Distinct Finish Woodtone Options
Painted Woodtone Options Optional Post Paint Finish
Raynor’s ColorWave™ features 1,500 Sherwin-Williams® next generation post paint system for your garage door.
The swatches shown on monitors and printed materials may vary from the actual color. For a true representation of the color, visit your local Raynor Dealer.
DriftwoodAuburn Mocha
Walnut
16
Showcase/Masterpiece - July 2020 Updates
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size
MPH 110 115 120 130 140 150 160 170 180 190 200 210 210+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
9’ Wide N: P-2312 (12.3/-13.7)
IW: P-3325 (41.6/-47.1) Colonial Glass
D: P-3305 (52.0/-58.0)P-3312 (65.0/-75.0)
N: P-1303 (37.3/-37.3) Colonial/Ranch Glass
10’ WideF: P-1339 (29.0/-32.5)
Ranch GlassD: P-3312 (56.4/-65.1)
12’ Wide D: P-3312 (56.4/-65.1)
16’ Wide N: P-2313 (12.3/-13.7)
F: P-2365 (18.0/-20.0) Ranch Glass
F: P-2365 (26.4/29.4)IR: P-3324 (29.7/-33.1)
D: P-3312 (45.0/-52.0)N: P-1309 (18.7/-18.7) Colonial/Ranch Glass
IW: P-3332 (29.7/-33.1) Colonial glass
18’ WideF: P-2418 (18/-20.0)
Ranch glassIW: P-3332 (23.5/-26.2)
Colonial glass
N: P-3309 (45.3/-51.2) D: P-3314 (43.5/-50.0)
P-3314 (43.5/-50.0)
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Masterpiece™ & ShowCase™
The flagship of the Raynor Traditions Series, Raynor Masterpiece steel garage doors feature 2” thick sections, a continuous thermal break between sections, and expanded polystyrene insulation bonded between two steel skins, for an outstanding 10.25 R-value. Masterpiece features the EnduraCote™ hardware system, while ShowCase uses galvanized hardware. Masterpiece and ShowCase doors are available in post, u-bar, and strut designs.
"For As Long As You Own Your Home," against rust.Certain restrictions apply to corrosive airborne substances.
Door Sections*
10.25
R-value
Masterpiece:"For As Long As You Own Your Home"ShowCase:Hardware: 6-yearsSpring: 3-years
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
17
Showcase/Masterpiece - July 2020 Updates
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size
MPH 110 115 120 130 140 150 160 170 180 190 200 210 210+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
9’ Wide N: P-2312 (12.3/-13.7)
IW: P-3325 (41.6/-47.1) Colonial Glass
D: P-3305 (52.0/-58.0)P-3312 (65.0/-75.0)
N: P-1303 (37.3/-37.3) Colonial/Ranch Glass
10’ WideF: P-1339 (29.0/-32.5)
Ranch GlassD: P-3312 (56.4/-65.1)
12’ Wide D: P-3312 (56.4/-65.1)
16’ Wide N: P-2313 (12.3/-13.7)
F: P-2365 (18.0/-20.0) Ranch Glass
F: P-2365 (26.4/29.4)IR: P-3324 (29.7/-33.1)
D: P-3312 (45.0/-52.0)N: P-1309 (18.7/-18.7) Colonial/Ranch Glass
IW: P-3332 (29.7/-33.1) Colonial glass
18’ WideF: P-2418 (18/-20.0)
Ranch glassIW: P-3332 (23.5/-26.2)
Colonial glass
N: P-3309 (45.3/-51.2) D: P-3314 (43.5/-50.0)
P-3314 (43.5/-50.0)
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Panel Options
Raised Colonial Raised Ranch Beadline
Carriage House (Grooved) Flush For impact window options please see page 23. For non impact window options please see page 25.
ColorsStandard
White
Almond
Bronze
Beige*
Brown*
*Features the Kynar® paint process, which provides
extended UV protection against fading.
Optional
Raynor’s ColorWave™ features 1,500 Sherwin-Williams® next generation post paint system for your garage door.
The swatches shown on monitors and printed materials may vary from the actual color. For a true representation
of the color, visit your local Raynor Dealer.
18
TradeMark - JULY 2020 UPDATES
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 210 210+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
9’ WideN: P-2392 (12.8/14.5) Colonial / Ranch glass
F: P-2300 (18.5/-20.9) Colonial / Ranch glass
F: P-2301 (24.8/-28.0) Colonial / Ranch glassT: P-2803 (24.8/-28.0) Colonial / Ranch glass
F: P-2301 (31.0/-35.1) Colonial glass (3) stilesT: P-2803 (24.8/-28.0) Colonial glass (3) stiles
IW: P-3348 (36.6/-41.1) Ranch glass
IR: P-3321 (41.6/-47.1)IW: P-3322 (41.6/-47.1)
Colonial glassT: P-2903 (41.6/-47.1)
Colonial glass
D: P-3307 (65.0/-75.0)T: P-2907 (65.0/-75.0)
10’ WideN: P-2324 (22.8/-25.8)
Colonial glassN: P-2325 (26.7/-30.2)
Colonial glassD: P-3307 (56.4/-65.1)
12’ WideD: P-3307 (56.4/-65.1)T: P-2907 (56.4/-65.1)
16’ Wide
N: P-2326 (12.3/-13.7) No glass
N: P-2352 (12.0/-13.4) Ranch glass
F: P-2357 (16.0/-17.7) Colonial glass
F: P-2358 (18.0/-22.7) Colonial glass
T: P-2804 (18.4/-22.7) Colonial glass
IW: P-3348 (23.3/-28.0) Ranch glass
F: P-2368 (23.3/-28.0) Colonial / Ranch glassT: P-2806 (23.3/-28.0) Colonial / Ranch glassN: P-2359 (25.6/-28.5)
Colonial glass
IR: P-3321 (29.7/-33.1)IR: P-2416 (30.0/-33.5)N: P-2360 (29.7/-33.1)
Colonial glassIW: P-3331 (29.7/-33.1)
Colonial glassIW: P-2904 (29.7/-33.1)
Colonial glassF: P-2369 (29.7/-33.1)
Colonial glassF: P-2370 (29.7/-33.1)
Colonial glassF: P-2419 (29.3/-32.6)
Colonial glass
IR: P-3318 (39.3/-43.8)D: P-3307 (45.0/-52.0)T: P-2907 (45.0/-52.0)IR: P-3361 (47.3/-47.3)
18’ Wide
N: P-2354 (12.0/-13.4) Colonial / Ranch glassN: P-2367 (12.0/-13.4) Colonial / Ranch glass
N: P-2362 (15.2/-16.9) Colonial glass
F: P-2417 (16.0/-18.0) Colonial glass
IW: P-3349 (17.7/-19.7) Ranch glass
IW: P-3333 (23.5/-26.2) Colonial glass
T: P-2805 (26.4/-29.4) Colonial glass
N: P-2363 (29.7/-36.0) Colonial glass
IR: P-3317 (37.4/-41.7)T: P-2905 (37.4/-41.7)
D: P-3308 (43.5/-50.0)T: P-2908 (43.5/-50.0)
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
TradeMark™
The combination of durable, 24-gauge steel, defined raised panel styling and authentic woodgrain texture gives your home curb appeal with TradeMark steel garage doors. Add charm with colonial or ranch panels, or for a distinctive look on your home, choose the carriage house option. Optional polystyrene insulation can be added to provide additional comfort and help keep your garage quieter. TradeMark doors are available in both post and strut designs.
"For As Long As You Own Your Home," against rust.Certain restrictions apply to corrosive airborne substances.
Door Sections*
6.6 with optional insulation
R-value
Hardware: 6 yearsSprings: 3 years
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
19
TradeMark - JULY 2020 UPDATES
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 210 210+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
9’ WideN: P-2392 (12.8/14.5) Colonial / Ranch glass
F: P-2300 (18.5/-20.9) Colonial / Ranch glass
F: P-2301 (24.8/-28.0) Colonial / Ranch glassT: P-2803 (24.8/-28.0) Colonial / Ranch glass
F: P-2301 (31.0/-35.1) Colonial glass (3) stilesT: P-2803 (24.8/-28.0) Colonial glass (3) stiles
IW: P-3348 (36.6/-41.1) Ranch glass
IR: P-3321 (41.6/-47.1)IW: P-3322 (41.6/-47.1)
Colonial glassT: P-2903 (41.6/-47.1)
Colonial glass
D: P-3307 (65.0/-75.0)T: P-2907 (65.0/-75.0)
10’ WideN: P-2324 (22.8/-25.8)
Colonial glassN: P-2325 (26.7/-30.2)
Colonial glassD: P-3307 (56.4/-65.1)
12’ WideD: P-3307 (56.4/-65.1)T: P-2907 (56.4/-65.1)
16’ Wide
N: P-2326 (12.3/-13.7) No glass
N: P-2352 (12.0/-13.4) Ranch glass
F: P-2357 (16.0/-17.7) Colonial glass
F: P-2358 (18.0/-22.7) Colonial glass
T: P-2804 (18.4/-22.7) Colonial glass
IW: P-3348 (23.3/-28.0) Ranch glass
F: P-2368 (23.3/-28.0) Colonial / Ranch glassT: P-2806 (23.3/-28.0) Colonial / Ranch glassN: P-2359 (25.6/-28.5)
Colonial glass
IR: P-3321 (29.7/-33.1)IR: P-2416 (30.0/-33.5)N: P-2360 (29.7/-33.1)
Colonial glassIW: P-3331 (29.7/-33.1)
Colonial glassIW: P-2904 (29.7/-33.1)
Colonial glassF: P-2369 (29.7/-33.1)
Colonial glassF: P-2370 (29.7/-33.1)
Colonial glassF: P-2419 (29.3/-32.6)
Colonial glass
IR: P-3318 (39.3/-43.8)D: P-3307 (45.0/-52.0)T: P-2907 (45.0/-52.0)IR: P-3361 (47.3/-47.3)
18’ Wide
N: P-2354 (12.0/-13.4) Colonial / Ranch glassN: P-2367 (12.0/-13.4) Colonial / Ranch glass
N: P-2362 (15.2/-16.9) Colonial glass
F: P-2417 (16.0/-18.0) Colonial glass
IW: P-3349 (17.7/-19.7) Ranch glass
IW: P-3333 (23.5/-26.2) Colonial glass
T: P-2805 (26.4/-29.4) Colonial glass
N: P-2363 (29.7/-36.0) Colonial glass
IR: P-3317 (37.4/-41.7)T: P-2905 (37.4/-41.7)
D: P-3308 (43.5/-50.0)T: P-2908 (43.5/-50.0)
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
ColorsStandard
White
Almond
Sandstone
Bronze
Brown
Optional
Raynor’s ColorWave™ features 1,500 Sherwin-Williams® next generation post paint system for your garage door.
Panel Options
Raised Colonial Recessed Colonial Grooved
Raised RanchFor impact window options please see page 23.
For non impact window options please see page 24.
The swatches shown on monitors and printed materials may vary from the actual color. For a true representation
of the color, visit your local Raynor Dealer.
20
BuildMark - JULY 2020 UPDATES
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 210 210+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
9’ WideN: P-2392 (12.8/14.5) Colonial / Ranch glass
F: P-2300 (18.5/-20.9) Colonial / Ranch glass
F: P-2301 (24.8/-28.0) Colonial / Ranch glass T: P-2803 (24.8/-28.0) Colonial / Ranch glass
F: P-2301 (31.0/-35.1) Colonial glass (3) stilesT: P-2803 (24.8/-28.0) Colonial glass (3) stiles
IW: P-3348 (36.6/-41.1) Ranch glass
IR: P-3321 (41.6/-47.1)IW: P-3322 (41.6/-47.1)
Colonial glassT: P-2903 (41.6/-47.1)
Colonial glass
10’ WideN: P-2324 (22.8/-25.8)
Colonial glassN: P-2325 (26.7/-30.2)
Colonial glass
16’ Wide
N: P-2326 (12.3/-13.7) No glass
N: P-2352 (12.0/-13.4) Ranch glass
F: P-2357 (16.0/-17.7) Colonial glass
F: P-2358 (18.0/-22.7) Colonial glass
T: P-2804 (18.4/-22.7) Colonial glass
N: P-2359 (25.6/-28.5) Colonial glass
IW: P-3348 (23.3/-28.0) Ranch glass
F: P-2368 (23.3/-28.0) Colonial / Ranch glassT: P-2806 (23.3/-28.0) Colonial / Ranch glass
IW: P-2419 (29.3/-32.6) Colonial glass
IR: P-3321 (29.7/-33.1)F: P-2416 (30.0/-33.5)N: P-2360 (29.7/-33.1)
Colonial glassIW: P-3331 (29.7/-33.1)
Colonial glassT: P-2904 (29.7/-33.1)
Colonial glassF: P-2369 (29.7/-33.1)
Colonial glassF: P-2370 (29.7/-33.1)
Colonial glass
IR: P-3318 (39.3/-43.8) IR: P-3361 (47.3/-47.3)
18’ Wide
N: P-2354 (12.0/-13.4) Colonial / Ranch glassN: P-2367 (12.0/-13.4) Colonial / Ranch glass
N: P-2362 (15.2/-16.9) Colonial glass
F: P-2417 (16.0/-18.0) Colonial glass
IW: P-3349 (17.7/-19.7) Ranch glass
IW: P-3333 (23.5/-26.2) Colonial glass
T: P-2805 (26.4/-29.4) Colonial glass
N: P-2363 (29.7/-36.0) Colonial glass
IR: P-3317 (37.4/-41.7)T: P-2905 (37.4/-41.7)
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
BuildMark®
This steel garage door design offers a traditional look at an affordable price. Choose from the time-honored ranch and colonial patterns or customize your garage with a carriage house design. Optional polystyrene insulation can be added to provide additional comfort and help keep your garage quieter. BuildMark doors are available in both u-bar and box strut designs.
"For As Long As You Own Your Home," against rust.Certain restrictions apply to corrosive airborne substances.
Door Sections*
6.6 with optional insulation
R-value
Hardware: 6 yearsSprings: 3 years
Hardware/Springs*
*See www.raynor.com/products for complete Limited Warranty details.
21
BuildMark - JULY 2020 UPDATES
2017 FLORIDA BUILDING CODE DESIGN LOADS FOR CATEGORY II OCCUPANCY
Wind speed in Miles Per Hour (MPH) is for reference purposes only: reference the wind speed conversion charts for exact Design Loads or local Authority Having Jurisdiction (AHJ) to insure the door being specified meets the required Design Loads. Wind speeds in the charts are Ultimate Design Wind Speeds for 2017 Florida Building Code (FBC) Exposure B. Doors are rated by Design Loads, not Miles Per Hour. Design pressures may vary between door line. Refer to drawings for exact design load pressures.
Door Size MPH 110 115 120 130 140 150 160 170 180 190 200 210 210+
9’ x 7’ EXP B 11.4/-12.9 12.6/-14.2 13.7/-15.5 16.1/-18.2 18.5/-20.9 21.3/-24.1 24.3/-27.5 27.6/-31.2 30.6/-34.6 34.2/-38.6 38.0/-43.0
16’ X 7’ EXP B 10.9/-12.2 12.0/-13.4 13.1/-14.6 15.5/-17.2 17.7/-19.7 20.4/-22.7 23.3/-26.0 26.4/-29.4 29.3/-32.6 32.7/-36.5 36.4/-40.6
9’ WideN: P-2392 (12.8/14.5) Colonial / Ranch glass
F: P-2300 (18.5/-20.9) Colonial / Ranch glass
F: P-2301 (24.8/-28.0) Colonial / Ranch glass T: P-2803 (24.8/-28.0) Colonial / Ranch glass
F: P-2301 (31.0/-35.1) Colonial glass (3) stilesT: P-2803 (24.8/-28.0) Colonial glass (3) stiles
IW: P-3348 (36.6/-41.1) Ranch glass
IR: P-3321 (41.6/-47.1)IW: P-3322 (41.6/-47.1)
Colonial glassT: P-2903 (41.6/-47.1)
Colonial glass
10’ WideN: P-2324 (22.8/-25.8)
Colonial glassN: P-2325 (26.7/-30.2)
Colonial glass
16’ Wide
N: P-2326 (12.3/-13.7) No glass
N: P-2352 (12.0/-13.4) Ranch glass
F: P-2357 (16.0/-17.7) Colonial glass
F: P-2358 (18.0/-22.7) Colonial glass
T: P-2804 (18.4/-22.7) Colonial glass
N: P-2359 (25.6/-28.5) Colonial glass
IW: P-3348 (23.3/-28.0) Ranch glass
F: P-2368 (23.3/-28.0) Colonial / Ranch glassT: P-2806 (23.3/-28.0) Colonial / Ranch glass
IW: P-2419 (29.3/-32.6) Colonial glass
IR: P-3321 (29.7/-33.1)F: P-2416 (30.0/-33.5)N: P-2360 (29.7/-33.1)
Colonial glassIW: P-3331 (29.7/-33.1)
Colonial glassT: P-2904 (29.7/-33.1)
Colonial glassF: P-2369 (29.7/-33.1)
Colonial glassF: P-2370 (29.7/-33.1)
Colonial glass
IR: P-3318 (39.3/-43.8) IR: P-3361 (47.3/-47.3)
18’ Wide
N: P-2354 (12.0/-13.4) Colonial / Ranch glassN: P-2367 (12.0/-13.4) Colonial / Ranch glass
N: P-2362 (15.2/-16.9) Colonial glass
F: P-2417 (16.0/-18.0) Colonial glass
IW: P-3349 (17.7/-19.7) Ranch glass
IW: P-3333 (23.5/-26.2) Colonial glass
T: P-2805 (26.4/-29.4) Colonial glass
N: P-2363 (29.7/-36.0) Colonial glass
IR: P-3317 (37.4/-41.7)T: P-2905 (37.4/-41.7)
N Tested But Not Certified F Florida Approved IR Impact Rated IW Impact Rated With Windows D Dade Co. Approved T Texas Dept. of Insurance Approved *P-xxxx = Drawing Number
Panel Options
Raised Colonial Recessed Colonial Grooved
Raised Ranch Flush
For impact window options please see page 23. For non impact window options please see page 24.
The swatches shown on monitors and printed materials may vary from the actual color. For a true representation
of the color, visit your local Raynor Dealer.
ColorsStandard
White
Almond
Desert Tan
Sandstone
Brown
Black
Painted Woodtone Options
Optional Post Paint Finish
Raynor’s ColorWave™ features 1,500 Sherwin-Williams® next generation post paint system for your garage door.
Mocha WalnutAuburn
Hurricane Ready™ Reinforcing SystemRaynor provides a wide range of residential garage door models that meet the demands of the most rigorous wind load or impact rating guidelines. Raynor wind load systems meet or exceed the Florida Building Code (FBC) and are tested to ANSI/DASMA 108 & 115. Additionally, Raynor offers several models that meet Miami-Dade product requirements (TAS 201, 202, 203).
Horizontal Trussing
Raynor Hurricane Ready reinforcing systems utilize horizontal trussing, made from high-tensile steel box struts or u-bars, to create a door system built to withstand hurricane force winds.
Single or double end stiles are provided depending on wind load specifications. Both feature Raynor's heavy-duty diamond hinges.
Raynor's box strut design (Patent Pending) features a yellow cap at each end for safety and visibility.
Raynor's high-strength rollers are designed and tested to withstand hurricane force winds.
Vertical Post(s)
Raynor's hurricane post(s) are installed prior to a hurricane and provide strength right where you need it.
The top of the post is anchored to the header with heavy-duty galva-nized hardware.
The middle of the door is strapped to the post to prevent the door from being pulled out of the opening from negative wind forces.
The bottom of the post is pinned to the floor with heavy-duty galva-nized hardware.
22
Impact WindowsRaynor's impact and wind load rated windows are made from tough lightweight polycarbonate material that is durable, UV and scratch resistant, and housed in a colonial sized extruded aluminum frame. Available for BuildMark®, TradeMark™, ShowCase™ and Masterpiece™ doors.
Aspen™ AP138 & AP200
Color OptionsAspen™ Colors
White
Almond
Desert Tan
Sandstone
Bronze
Brown
Slate
Charcoal
Black
*For woodtone doors
Insert OptionsAspen™AP138 & AP200
Clear Colonial Clear Ranch
Snap-In InsertsColonial Ranch
Sherwood Sunburst Ranch
Prairie Prairie Ranch
Cathedral Arched Stockbridge Ranch
Waterton Waterton Ranch
Cascade Cascade Ranch
Stockton Stockton Ranch
Stockbridge Ranch Arched Stockton Ranch
Sunburst 4
Sunburst 5
Sunburst 6
Sunburst 7
Sunburst 8
Sunburst 9
Sunray (4 panel)
Berkshire
Breckenridge
BuildMark™ & TradeMark®
Color OptionsBuildMark® and TradeMark™ Colors
White
Almond
Desert Tan
Sandstone
Bronze
Brown
Black
*For woodtone doors
Insert OptionsBuildMark® and TradeMark™
Clear Colonial Clear Ranch
Snap-In InsertsColonial Ranch
Sherwood Sunburst Ranch
Prairie Prairie Ranch
Cathedral Arched Stockbridge Ranch
Waterton Waterton Ranch
Cascade Cascade Ranch
Stockton Stockton Ranch
Stockbridge Ranch Arched Stockton Ranch
Sunburst 4
Sunburst 5
Sunburst 6
Sunburst 7
Sunburst 8
Sunburst 9
Sunray (4 panel)
Berkshire
Breckenridge
ShowCase™Color Options
White
Almond
Insert Options
ShowCase™
Snap-In Inserts
Cathedral Cascade Stockton
Sunburst 4 Sherwood
Auburn Mocha Walnut
23
24
Non-Impact WindowsAspen™ AP200LVSnap-In Inserts
Arched 4 Pane - Arched
Square 4 Pane - Square
Two Piece Arched 4 Pane - Two Piece Arched
4-Over-4 - Arched Wrought Iron - Arched
4-Over-4 - Square Wrought Iron - Square
4-Over-4 - Two Piece Arched Wrought Iron - Two Piece Arched
Peakview
Mission Vista
Spring Line
Revival Arch
Non-Impact GlassAspen™ AP200LV, AP200, AP138, TradeMark™, BuildMark®
Clear
Obscure
Satin
RockCreeke™
Clear
Rain
Aspen™ AP200, AP138, TradeMark™, BuildMark®
Snap-In Inserts
Clear Colonial Clear Ranch
Sunburst Ranch Sherwood
Prairie Ranch Prairie
Arched Stockbridge Ranch Cathedral
Waterton Ranch Waterton
Cascade Ranch Cascade
Stockton Ranch Stockton
Stockbridge Ranch Arched Stockton Ranch
Sunburst 4 Sunburst 5
Sunburst 6
Sunburst 7
Sunburst 8
Sunburst 9
Sunray (4 panel)
Berkshire
Breckenridge
RockCreeke™ Window OptionsOur beautiful window designs put the perfect finishing touch on your new Raynor RockCreeke garage door.
1 pane 2 over 2 3 pane 3 over 3 3 over 3 arched
1 pan arched 4 pane 4 over 4 4 over 4 arched
25
Masterpiece™ and ShowCase™ Window OptionsArtistic GlassClear Beveled
Clear Diamond Colonial Clear Diamond Ranch Clear Prairie Colonial Clear Prairie Ranch
Frosted Beveled
Frosted Diamond Colonial Frosted Diamond Ranch Frosted Prairie Colonial Frosted Prairie Ranch
Dimensions GlassFrosted and Beveled with Caming
Regency Colonial Antique Ranch Oval/Diamond Frost Ranch Black Caming
Standard Glass & Snap-In InsertsDress up our clear and obscure windows with a variety of snap in inserts.
Plain Ranch Arched Stockton Ranch Plain Colonial Cascade Colonial
Stockton Ranch Prairie Ranch Sherwood Colonial Sunburst Colonial
Cascade Ranch Stockton Colonial Cathedral Colonial
Sunray Ranch Berkshire Ranch
Window designs shown may not be available on all sizes or models.
26
Hardware OptionsDecorative HardwareDecorative handles and straps are optional on Aspen™, Eden Coast by Raynor®, RockCreeke™, Masterpiece™, ShowCase™, TradeMark™, and BuildMark® doors.
Handles
Cast Lift Handle Fleur-de-Lis 6131100
Cast Pull Handle Fleur-de-Lis 6131117
Cast Lift Handle Spear 6131115
Cast Pull Handle Spear 6131116
Cast Pull Handle Colonial 6131113
Stamped Lift Handle Spade 6131101
Stamped Pull Handle Spade 6131102
Low Profile Stamped Bean Handles 2/pack 6130498
Low Profile Stamped HandleFleur-de-Lis 2/pack 6130499
Magnetic Sets
Manor Handle & Strap Kit 4051100 Mission Handles &
Strap Kit 4051101 Colonial Handle & Strap Kit 4051102
Straps
Stamped 16” Hinge Spade (2” High) 6131105
Stamped 16” Hinge Narrow Spade (1⅝” High) 6131111
Cast 16” Hinge Colonial 6131114
Stamped 24” Hinge Spade 6131106
Cast 16” Hinge Spear 6131104
Cast 16” Hinge Assembly Spear 6131103
Stamped 17” Bean Straps 4/pack 6130491
Stamped 17” Fleur-de-Lis Straps 4/pack 6130492
HardwareGalvanized steel hardwareGalvanized hardware comes standard on Aspen™, RockCreeke™, Raynor StyleView™, ShowCase™, TradeMark™ and BuildMark® doors.
EnduraCote™ hardwareThe EnduraCote Hardware System features extended-life black powder coated torsion springs and white powder coated track and hinges. Heavy-duty nylon rollers, with steel ball bearings, also help to provide superior noise reduction.
EnduraCote comes standard on Masterpiece™ doors and is optional on Aspen™, RockCreeke™ and Raynor StyleView™ doors.
27
Garage Door OpenersRaynor offers a full line of residential openers, featuring a variety of horsepower and configuration options. All of our operators feature MyQ™technology, a patented, two-way communication system that allows users to open and close the garage door and manage other household devices from anywhere in the world via a Smart Phone. Ask your authorized Raynor dealer about our residential openers, and select the ideal Raynor opener for your home.
Premium
Deluxe
Standard
Prodigy II® Providing an exceptional solution for garages that don’t allow for a traditional garage door opener. Prodigy II is a space-saving, wall-mounted jackshaft opener. The ultra-quiet 24V DC motor-operated Prodigy II mounts easily on the wall beside the garage door.
Prodigy II® with WiFi® Space saving and heavy lifting, the Raynor Prodigy II with WiFi is the ultimate garage access solution. This opener comes fully equipped with must-have features including built in WiFi for smartphone control, MyQ® Remote LED light, integrated battery backup, and the automatic garage door lock.
General II with WiFi® General II with WiFi® features the quiet reliability of a belt drive opener combined with a battery backup. The General II with WiFi® features MyQ™ technology, a patented, two-way communi-cation system that allows users to open and close the garage door and manage other household devices from anywhere in the world via a Smart Phone. Standard integrated WiFi® provides an all-in-one solution with free apps for Apple and Android.
Sentinel™ Sentinel is built with an integrated HD camera which lets you see who is coming and going in your garage through a live feed or recorded event. Recording begins when motion is detected, even at night thanks to built-in night vision. Want to talk to anyone you see in your garage? This opener is also equipped with 2-way audio for real time communication. Ensure your family and possessions are safe and secure with a reliable garage door opener that’s simple to use, dependable and myQ® connected.
Admiral II with WiFi® Admiral II with WiFi® offers the quiet reliability of a DC belt driven opener, combined with a battery backup. The Admiral II with WiFi® features MyQ™ technology, a patented, two-way communi-cation system that allows users to open and close the garage door and manage other household devices from anywhere in the world via a Smart Phone. Standard integrated WiFi® provides an all-in-one solution with free apps for Apple and Android.
Ultra II with WiFi® Designed to handle even the heaviest doors, the Raynor Ultra II with WiFi® combines a chain drive with a 3/4 horsepower motor. A rugged I-beam rail and chasis support gives added strength and reliable operation. A dual-drive sprocket allows the opener’s speed to be adjusted to optimize door and opener performance. Standard with integrated WiFi provides an all-in-one solution with free apps for Apple and Android.
Aviator II® with WiFi® The Aviator II garage door opener is powered by a 1/2 hp motor with a one-piece solid belt drive rail, for quiet-running performance. Standard integrated WiFi® provides an all-in-one solution with free apps for Apple and Android.
Pilot II® with WiFi® Reliable, effortless operation comes with the Pilot II with WiFi garage door opener, which is powered by a 1/2 hp motor with an industrial-strength chain drive. Standard integrated WiFi® provides an all-in-one solution with free apps for Apple and Android.
Corporal II™ with WiFi® A smooth-running 1/2 hp chain drive opener, the Corporal II with WiFi is dependable and secure. Designed for those who want an excellent combination of value and functionality. Standard integrated WiFi® provides an all-in-one solution with free apps for Apple and Android.
Airman II™ with WiFi® A smooth-running 1/2 hp belt drive opener, the Airman II with WiFi is dependable and secure. Designed for those who want an excellent combination of value and functionality with that everyday dependability of a Raynor opener. Standard integrated WiFi® provides an all-in-one solution with free apps for Apple and Android.
Sergeant II™ with WiFi® Designed for the consumer who values reliability, security and connectivity. The Sergeant II with WiFi has built in technology and is equipped with battery backup to keep homeowners safe and secure while at home or away. This chain drive system offers quiet operation with industrial strength and is built to last. Standard integrated WiFi® provides an all-in-one solution with free apps for Apple and Android.
Capable
Capable
Capable
Exclusively Distributed by:
Professional Installation & ServiceDepend on your Raynor DealerWhen you select Raynor, you’re not just getting a superior garage door - you’re also getting professional garage door installation and service expertise.
Every Raynor garage door is installed by a trained Raynor professional, and that means added benefits for you. First, you won’t have to deal with it yourself. Second, because it’s done right the first time, your door will deliver performance and reliability from the day it’s installed. Your technician will check your door for everything from safety to performance and appearance. Trust your Raynor garage door to someone who knows it better than anyone else, your professional Raynor Dealer.
Follow Us
©2020 Raynor 2902893 10/201-800-4-RAYNOR (472-9667) • www.raynor.com
Hurricane Ready™