20H200 - Garden Tractor Spares Ltd · 4089--10 Assemblies include all parts shown in frames....
Transcript of 20H200 - Garden Tractor Spares Ltd · 4089--10 Assemblies include all parts shown in frames....
Not for
Reprod
uctio
n
COPYRIGHT by BRIGGS & STRATTON CORPORATIONAll rights reserved. No part of this material may be reproduced or transmitted,in any form or by any means, electronic or mechanical, including photocopying,recording or by any information storage and retrieval system, without permissionin writing from Briggs & Stratton Corporation.
PRINTED IN U.S.A.
FORM MS4089 REV R 03/15/2013REPLACES FORM MS4089 REV P 10/24/2012
FILE IN SECT. 2 OF SERVICE MANUAL
20H200
Illustrated Parts ListModel Series
20H200TYPE NUMBERS0113 through 0135.
TABLE OF CONTENTS
Air Cleaner 5. . . . . . . . . . . . . . . . . . . . . . . . .
Alternator 9. . . . . . . . . . . . . . . . . . . . . . . . . .
Blower Housing/Shrouds 7. . . . . . . . . . . .
Camshaft 2. . . . . . . . . . . . . . . . . . . . . . . . . .
Carburetor 4. . . . . . . . . . . . . . . . . . . . . . . . .
Controls 8. . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankcase Cover 2. . . . . . . . . . . . . . . . . . .
Crankshaft 2. . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder 2. . . . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder Head 3. . . . . . . . . . . . . . . . . . . . .
Electric Starter 8. . . . . . . . . . . . . . . . . . . . .
Exhaust System 6. . . . . . . . . . . . . . . . . . . .
Flywheel 7. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Supply 9. . . . . . . . . . . . . . . . . . . . . . . .
Gasket Set -- Engine 3. . . . . . . . . . . . . . . .
Gasket Set -- Valve 3. . . . . . . . . . . . . . . . . .
Governor Spring 8. . . . . . . . . . . . . . . . . . . .
Ignition 9. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Kit -- Carburetor Overhaul 4. . . . . . . . . . .
Operator’s Manual 2. . . . . . . . . . . . . . . . . .
Piston/Rings/Connecting Rod 2. . . . . . .
Rewind Starter 7. . . . . . . . . . . . . . . . . . . . .
Valves 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning Label 2. . . . . . . . . . . . . . . . . . . . . .
Not for
Reprod
uctio
n
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--2 Assemblies include all parts shown in frames. 03/15/2013
2
3
55215718
217A
1A
307
306
718A
27
27
30
32
46
741
146
24
742
746
220
22
16
219
29
2526
28
529
170
2117
20
12
522
18
19
NOTE: Ball Bearing is included where needed.
1058 OPERATOR’S MANUAL
1036 EMISSIONS LABEL1319 WARNING LABEL
REQUIRED when replacingparts with warning labelsaffixed.
REQUIRED when replacingparts with warning labelsaffixed.
1319AWARNING LABEL
1330 REPAIR MANUAL
Not for
Reprod
uctio
n
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--3 Assemblies include all parts shown in frames. 03/15/2013
3
358 ENGINE GASKET SET
51
51A
7
1022
868
163
20
12
3
883A 7
1095 VALVE GASKET SET
1022
868
51
51A
35
868
7
383
337
1022
91413
1100 798
1022
36
635
51
51A
34
33 42
192
1029
1023
5
42
883A
45
1026
Not for
Reprod
uctio
n
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--4 Assemblies include all parts shown in frames. 03/15/2013
4
632
121A CARBURETOR OVERHAUL KIT
105A
104A 137A
127A
633B51
51A163
98A
121 CARBURETOR OVERHAUL KIT
105A
104A
127A
633B51
51A 163
98A
137
632A
51
51A122
130A
117127A
51
51A95A
633B
97
98A
125
108A
369
104A
105A
137A
1127A
975A
133A
137A
104A
105A
133A
1127A
975 137
137135
NOTE: This IllustrationRepresentsSeveralCarburetors.Parts Shown May Not Be Included In All Kits.
633B
97A
135A
108A
141
633B
109E
141C
108A
633B
109D
633B
951
118
633B
109D
633B
109E
632A
Not for
Reprod
uctio
n
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--5 Assemblies include all parts shown in frames. 03/15/2013
5
964
161B
53
185163
425
425A
968
161A
536
445
967
161
968C
11C
968A
425
Not for
Reprod
uctio
n
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--6 Assemblies include all parts shown in frames. 03/15/2013
6
613B
300E
883A
613 832B
836B
677A
676C
NOTE: This muffler is intended for replacementpurposes only and is not to be usedfor retrofitting to engines with differentexhaust systems.
883C
832C836C
300C
863C
740
740A
819
355
436C
437
1177
677A
676D
Not for
Reprod
uctio
n
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--7 Assemblies include all parts shown in frames. 03/15/2013
7
7837
305
732
332
455
1070
1005
23
727A
304
695
363
608
65
58
597
689456
459
60
1036 EMISSIONS LABEL
Not for
Reprod
uctio
n
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--8 Assemblies include all parts shown in frames. 03/15/2013
8
211
209
188
222D
270
268
269271
632
505
562
227
278
281
663
1051
801
310
579
802
783
513
510309
1090
503
697
1230
1404
604A
222B
615
616
614
404
564188
222A
410
188668
271A
773
1138
504
222
621
843
564
564A
604
Not for
Reprod
uctio
n
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--9 Assemblies include all parts shown in frames. 03/15/2013
9
364A
799
286
851
334
3331052A
697
240958
601
601
187 187A
601
187C
601
187F
190B
180181 181
1345
1345A
601
187B
813
361A
347B
920
579
577A627A578A
990A
892A
500A
1054
286A
1046
347
DC ONLY
474A
10--16 AMP
474D
NOTE: The proper flywheel part number and/or the alternator magnet size willdetermine the alternator type or output. See repair instruction manualfor additional information.
501
5261119 578
493A
356A
356D
356E
356C
356B
356
774
356J
356L
356K
356H
356G
Not for
Reprod
uctio
n
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--10 Assemblies include all parts shown in frames. 03/15/2013
10
1A 794851 Cylinder Assembly2 698340 Kit--Bushing/Seal
(Magneto Side)3 391086s Seal--Oil
(Magneto Side)5 799859 Head--Cylinder7 694872 Gasket--Cylinder Head
11C 696796 Tube--Breather12 694953 Gasket--Crankcase13 794829 Screw
(Cylinder Head)15 691686 Plug--Oil Drain16 796958 Crankshaft
-- -- -- -- -- -- Note -- -- -- -- -- --796957 CrankshaftUsed on Type No(s).0135.
17 695434 Bearing--Ball17A 691069 Bearing--Ball18 791412 Cover--Crankcase19 698340 Kit--Bushing/Seal
(PTO Side)20 391086s Seal--Oil
(PTO Side)21 281658s Cap--Oil Fill22 794825 Screw
(CrankcaseCover/Sump)
23 794814 FlywheelUsed on Type No(s).0122, 0124, 0126,0128, 0134, 0135.-- -- -- -- -- -- Note -- -- -- -- -- --794812 FlywheelUsed on Type No(s).0113, 0115, 0123,0125, 0127, 0131,0132, 0133.
24 222698s Key--Flywheel25 792117 Piston Assembly
(Standard)-- -- -- -- -- -- Note -- -- -- -- -- --792144 PistonAssembly(.020” Oversize)
26 792026 Ring Set(Standard)-- -- -- -- -- -- Note -- -- -- -- -- --792073 Ring Set(.020” Oversize)
27 690975 Lock--Piston Pin28 696581 Pin--Piston29 694691 Rod--Connecting30 694692 Dipper--Connecting
Rod32 690976 Screw
(Connecting Rod)33 697576 Valve--Exhaust34 792200 Valve--Intake35 694865 Spring--Valve
(Intake)36 694865 Spring--Valve
(Exhaust)37 795715 Guard--Flywheel42 499586 Keeper--Valve45 690977 Tappet--Valve46 795697 Camshaft51 694874 Gasket--Intake
51A 694875 Gasket--Intake53 794830 Stud
(Carburetor)58 795058 Rope--Starter
(Cut To RequiredLength)
60 490652 Grip--Starter Rope65 699228 Screw
(Rewind Starter)78 795026 Screw
(Flywheel Guard)95A 690718 Screw
(Throttle Valve)97 796334 Shaft--Throttle
97A 696387 Shaft--Throttle98A 695408 Kit--Idle Speed104A 694918 Pin--Float Hinge105A 696136 Valve--Float Needle108A 696143 Valve--Choke109D 790149 Shaft--Choke
Used on Type No(s).0113, 0131, 0135.
109E 696735 Shaft--ChokeUsed on Type No(s).0115, 0122, 0123,0124, 0125, 0126,0127, 0128, 0132,0133, 0134.
117 796080 Jet--Main(Standard)(Used After Code Date09020800).-- -- -- -- -- -- Note -- -- -- -- -- --696134 Shaft--Throttle(Standard)(Used Before CodeDate 09020900).796080 Jet--Main(Standard)(Used After Code Date08071700).Used on Type No(s).0113.696134 Jet--Main(Standard)(Used Before CodeDate 08071800).Used on Type No(s).0113.796080 Jet--Main(Standard)Used on Type No(s).0131, 0132, 0133,0134, 0135.
118 796128 Jet--Main(High Altitude)(Used After Code Date09020800).-- -- -- -- -- -- Note -- -- -- -- -- --696135 Shaft--Throttle(High Altitude)(Used Before CodeDate 09020900).796128 Jet--Main(High Altitude)(Used After Code Date08071700).Used on Type No(s).0113.696135 Jet--Main(High Altitude)(Used Before CodeDate 08071800).Used on Type No(s).0113.796128 Jet--Main(High Altitude)Used on Type No(s).0131, 0132, 0133,0134, 0135.
Not for
Reprod
uctio
n
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--11 Assemblies include all parts shown in frames. 03/15/2013
11
121 796137 Kit--CarburetorOverhaul
121A 696146 Kit--CarburetorOverhaul
122 694876 Spacer--Carburetor125 796321 Carburetor
127A 690727 Plug--Welch130A 696139 Valve--Throttle133A 694914 Float--Carburetor135 698780 Tube--Fuel Transfer
135A 696142 Tube--Fuel Transfer137 698781 Gasket--Float Bowl
137A 695426 Gasket--Float Bowl141 696145 Kit--Choke Shaft
141C 699979 Kit--Choke ShaftUsed on Type No(s).0115, 0122, 0123,0124, 0125, 0126,0127, 0128, 0132,0133.
146 798972 Key--Timing(Used After Code Date11022800)-- -- -- -- -- -- Note -- -- -- -- -- --690979 Key--Timing(Used Before CodeDate 11030100)
161 Base--Air Cleaner(Metal)(No Longer Available)(For Replacement,Order Reference 536)
161A 794767 Base--Air Cleaner(Metal)
161B 591217 Base--Air Cleaner(Metal)
163 692277 Gasket--Air Cleaner170 794833 Stud
(Cover--Crankcase)180 795832 Tank--Fuel
(Metal)(Used After Code Date08042000).-- -- -- -- -- -- Note -- -- -- -- -- --794640 Tank--Fuel(Used Before CodeDate 08042100).
181 794641 Cap--Fuel Tank(Metal)
185 794838 Nut(Air Cleaner Base)
187 791766 Line--Fuel(15 Inches Long)(Cut To RequiredLength)
187A 791869 Line--Fuel187B 791834 Line--Fuel187C 791871 Line--Fuel187F 795046 Line--Fuel188 699479 Screw
(Control Bracket)190B 795047 Screw
(Fuel Tank)192 690083 Adjuster--Rocker Arm209 694867 Spring--Governor211 695307 Spring--Governed Idle219 693578 Gear--Governor220 691724 Washer
(Governor Gear)222 795739 Bracket--Control
Used on Type No(s).0135.
222A 794801 Bracket--ControlUsed on Type No(s).0132, 0133.
222B 794804 Bracket--ControlUsed on Type No(s).0115, 0122, 0123,0124, 0125, 0126,0127, 0128.
222D 795991 Bracket--Control(Used After Code Date08042000).Used on Type No(s).0113.-- -- -- -- -- -- Note -- -- -- -- -- --795235 Bracket--Control(Used Before CodeDate 08042100).Used on Type No(s).0113.795991 Bracket--ControlUsed on Type No(s).0131, 0134.
227 694864 Lever--GovernorControl
240 394358s Filter--Fuel268 691025 Casing--Control Wire
(Cut To RequiredLength)
269 691026 Wire--Control(Cut To RequiredLength)
270 691027 Nut(Control Wire Casing)
271 691028 Lever--Control271A 695381 Lever--Control278 798196 Washer
(Governor ControlLever)(Used After Code Date09101800).-- -- -- -- -- -- Note -- -- -- -- -- --792008Washer(Governor ControlLever)(Used Before CodeDate 09101900).
281 697268 Panel--Control286 793696 Module--Oil Sensor
Used on Type No(s).0113, 0115, 0122,0123, 0124, 0125,0126, 0127, 0128,0131, 0134, 0135.
286A 699952 Module--Oil SensorUsed on Type No(s).0132, 0133.
300C 793701 Muffler(This muffler isintended forreplacement purposesonly and is not to beused for retrofitting toengines with differentexhaust systems)
300E 794949 Muffler-- -- -- -- -- -- Note -- -- -- -- -- --795322 MufflerUsed on Type No(s).0134, 0135.
304 591545 Housing--Blower(Used After Code Date12012300)-- -- -- -- -- -- Note -- -- -- -- -- --795699 Housing--Blower(Used Before CodeDate 12012400)
305 699481 Screw(Blower Housing)
306 697240 Shield--Cylinder307 794822 Screw
(Cylinder Shield)309 695479 Motor--Starter310 690323 Screw
(Starter Motor)
Not for
Reprod
uctio
n
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--12 Assemblies include all parts shown in frames. 03/15/2013
12
332 794824 Nut(Flywheel)
333 492341 Armature--Magneto334 699477 Screw
(Magneto Armature)337 792015 Plug--Spark
Used on Type No(s).0113, 0131, 0134.-- -- -- -- -- -- Note -- -- -- -- -- --691043 Plug--SparkUsed on Type No(s).0115, 0122, 0123,0124, 0125, 0126,0127, 0128, 0132,0133.491055s Plug--SparkUsed on Type No(s).0135.
347 697854 Switch--Rocker347B 790949 Switch--Rocker
Used on Type No(s).0131.
355 794842 Washer(Muffler Bracket)
356 695630 Wire--Stop356A 692390 Wire--Stop356B 699340 Wire--Stop356C 695295 Wire--Stop356D 694860 Wire--Stop356E 696328 Wire--Stop356G 697336 Wire--Stop356H 696482 Wire--Stop356J 699994 Wire--Stop356K 697397 Wire--Stop356L 792609 Wire--Stop358 695438 Gasket Set--Engine
361A 691693 Screw(Starting Switch)Used on Type No(s).0131.
363 19203 Puller--Flywheel364A 699947 Terminal--Oil Plug369 695422 Spring--Float Bowl383 19576s Wrench--Spark Plug404 795759 Washer
(Governor Crank)410 695382 Link--Control
425 794836 Screw(Air Cleaner Cover)
425A 794835 Screw(Air Cleaner Cover)
436C 792374 Manifold--Exhaust437 794844 Screw
(Exhaust Manifold)445 491588s Filter--Air Cleaner
Cartridge455 794867 Cup--Flywheel456 692299 Plate--Pawl Friction459 281505s Pawl--Ratchet
474A 695730 Alternator(3 Amps DC)Used on Type No(s).0115, 0123, 0125,0127, 0132, 0133.
474D 695466 Alternator(10 Amp Regulator)
493A 691177 Bracket--Mounting(Regulator)
500A 792613 Washer(Key Switch)Used on Type No(s).0131.
501 845907 Regulator503 691532 Strap--Starter504 695383 Washer Set--Friction505 793515 Nut
(Governor ControlLever)(Used After Code Date09101800).-- -- -- -- -- -- Note -- -- -- -- -- --691251 Nut(Governor ControlLever)(Used Before CodeDate 09101900).
510 693699 Drive--Starter513 692024 Clutch--Drive522 697689 Plug--Dipstick/Fill526 690297 Screw
(Regulator)529 791822 Grommet536 591546 Cleaner--Air552 694674 Bushing--Governor
Crank
562 798197 Bolt(Governor ControlLever)(Used After Code Date09101800).-- -- -- -- -- -- Note -- -- -- -- -- --793216 Bolt(Governor ControlLever)(Used Before CodeDate 09101900).
564 699492 Screw(Control Cover)
564A 699491 Screw(Control Cover)
577A 690795 Cable--Starter578 692306 Wire--Assembly
578A 790948 Wire AssemblyUsed on Type No(s).0131.
579 691029 Nut(Starter Cable)
597 691696 Screw(Pawl Friction Plate)
601 791850 Clamp--Hose604 697326 Cover--Control
Used on Type No(s).0132, 0133.
604A 791752 Cover--ControlUsed on Type No(s).0115, 0122, 0123,0124, 0125, 0126,0127, 0128.
608 798825 Starter--Rewind613 794846 Screw
(Muffler)613B 794844 Screw
(Muffler)614 691620 Pin--Cotter
(Governor Crank)615 694676 Retainer--Governor
Shaft(Governor Gear)(Used Before CodeDate 08021500).
616 795758 Crank--Governor621 692310 Switch--Stop
627A 792608 Bracket--StopswitchUsed on Type No(s).0131.
Not for
Reprod
uctio
n
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
20H200
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.4089--13 Assemblies include all parts shown in frames. 03/15/2013
13
632 695917 Link--Throttle(Used Before CodeDate 09020900).-- -- -- -- -- -- Note -- -- -- -- -- --695917 Link--Throttle(Used Before CodeDate 08071800).Used on Type No(s).0113.
632A 796324 Link--Throttle(Used After Code Date09020800).-- -- -- -- -- -- Note -- -- -- -- -- --796324 Link--Throttle(Used After Code Date08071700).Used on Type No(s).0113.796324 Link--ThrottleUsed on Type No(s).0131, 0132, 0133,0134, 0135.
633B 690998 Seal--Choke/ThrottleShaft
635 691909 Boot--Spark Plug663 699492 Screw
(Control Panel)668 694257 Spacer
(Control Bracket)676C 697816 Deflector--Muffler
Used on Type No(s).0135.
676D 794213 Deflector--Muffler677 794845 Screw
(Deflector--Mounting)689 691855 Spring--Friction695 698807 Screw
(Ring Gear)697 795026 Screw
(Drive Cap)718 690959 Pin--Locating
718A 695178 Pin--Locating(Head)
727A 697465 Cover--Starter Drive732 699200 Screw
(Starter Drive Cover)740 710090 Nut
(Muffler Bracket)
740A 794843 Nut(Muffler Bracket)
741 691288 Gear--Timing742 692564 Retainer--E Ring746 694679 Gear--Idler773 694258 Retainer774 695447 Screw
(Stop Wire)783 693713 Gear--Pinion798 697890 Screw
(Rocker Arm)799 794937 Screw
(Oil Sensor)(Shoulder Screw)-- -- -- -- -- -- Note -- -- -- -- -- --699691 Screw(Oil Sensor)
801 694482 Cap--Drive802 691286 Cap--End813 690635 Clamp819 794832 Screw
(Muffler Bracket)832B 590767 Guard--Muffler832C 792380 Guard--Muffler836 699234 Screw
(Muffler Guard)836C 710023 Screw
(Muffler Guard)843 695588 Sleeve--Lever851 692424 Terminal--Spark Plug
863C 793700 Bracket--Muffler868 690968 Seal--Valve
883A 794818 Gasket--Exhaust883C 710250 Gasket--Exhaust892A 791944 Switch--Key914 794827 Screw
(Rocker Cover)920 691656 Solenoid--Starter951 699961 Lever--Choke958 698180 Valve--Fuel Shut Off
(Plastic)964 799159 Cap--Connector967 491435s Filter--Pre Cleaner968 Cover--Air Cleaner
(No Longer Available)(For Replacement,Order Reference 536)
968A 794784 Cover--Air Cleaner968C 795337 Cover--Air Cleaner975 698783 Bowl--Float
975A 696138 Bowl--Float990A 794696 Key Set1005 794815 Fan--Flywheel1022 690971 Gasket--Rocker Cover1023 697691 Cover--Rocker1026 592673 Rod--Push1029 690972 Arm--Rocker1036 Label--Emissions
(Available From ABriggs & StrattonAuthorized Dealer)
1046 691337 Plug--Blower Housing1051 691265 Ring--Retaining
1052A 794805 Sensor--Oil1054 280275 Tie--Cable1058 279769 Manual--Operator’s1070 794821 Screw
(Flywheel Fan)1090 691293 Retainer--Brush1095 695440 Gasket Set--Valve1100 791959 Pivot--Rocker Arm1119 699772 Screw
(Alternator)1127A 695407 Screw
(Float Bowl)1138 694255 Nut
(Control Bracket)1177 710090 Nut
(Muffler)1230 794840 Stud
(Control Bracket)1319 794467 Label--Warning
1319A 797669 Label--Warning1330 276781 Repair Manual1345 699887 Filter--Filler Neck
1345A 792917 Filter--Filler Neck1404 794838 Nut
(Control Cover)
Not for
Reprod
uctio
n
Not for
Reprod
uctio
n
Not for
Reprod
uctio
n