2014-4800-9U-0001 Rev G Process Line List for ST-PIP

7/26/2019 2014-4800-9U-0001 Rev G Process Line List for ST-PIP

1/33


2/33

Rev:

SU TU TRANG FULL FIELD DEVELOPMENT - PHASE 1

DETAILED ENGINEERING AND PROCUREMENT

ENGINEERING SUPPORT SERVICES

PROCESS LINE LIST FOR ST-PIPDoc. No.: 2014-4800-9U-0001

F

REVISION RECORD SHEET

No. Rev. No Content of Revision Date of Revision

02 D

Issued for Review

- Update operating and design condition for production flowlines,fuel gas system.

- Update operating condition for 1st & 2nd stages gas re-injection

compression system.

- Update insulation thickness and painting system.

- Update line connection; add new lines, delete lines based on latest

P&ID and 3D model.

03-06-15

03 E

Issued for Approval

- Update test pressure, test medium, NDT requirement and stress

category.

- Delete all lines within fuel gas package.

- Update design temperature for MBF-2606/2616 systems.

- Update design pressure for LP fuel gas.

- Update operating pressure of export line.

- Update operating and design temperature, material for cooling

medium outlet line of HBA-2606/2616

Update connection for Compressor Turbine and Seal gas system

21-08-15

01 C Approved for Design (FEED) 26-02-15


3/33

Rev:

NOTES:

1. STRESS CATEGORY: SEE STRESS CRITICAL LINE LIST DOC. NO. 2014-4800-1U-0001.

2. DISCHARGE PRESSURE OF DIESEL FIRE WATER PUMP WILL BE FINALIZED DURING

DETAILED ENGINEERING.3. INSULATION/HEAT TRACING BREAK-UP & LOCATION SHALL BE AS SHOWN ON THE P&IDs.

4. IN GENERAL, TEST PRESSURE IS 1.5 * PROCESS DESIGN PRESSURE EXCEPT FOR LINES

WITH 1 (ONE) OPEN END (OPEN DRAIN AND VENT TO ATMOSPHERIC SERVICES), TEST

PRESSURE IS FOW (FULL OF WATER).

HOLDS:

SU TU TRANG FULL FIELD DEVELOPMENT - PHASE 1

DETAILED ENGINEERING AND PROCUREMENT

ENGINEERING SUPPORT SERVICES

PROCESS LINE LIST FOR ST-PIPDoc. No.: 2014-4800-9U-0001

F

GENERAL NOTES


4/33

PF: PROCESS FLUID

NO. L IN E NU MB ER S IZ E (I nc h) S ER VPIPING

SPEC.SEQ. NO. INSUL. P&ID No. From To FLUID

DENSITY

Kg/m3

OP PRESS.

Barg

OP TEMP

C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST

PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness (mm)

Tracing

Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS

CATEGORYREMARKS REV.

1 8''-PF-E12N-1301-2H1 8 PF E12N 1301 2H1 2014-4828-01-0002-SH2 QAY 2856 18''-PF-E1N-1304- 2H1 Mix 118. 6-142.2 92. 2 80/118 130 -28/130 195 WAT ER HC 38 E lectric 4 100% NOTE 1 Maintain Temp = 55 C G

2 8''-PF-E12N-1302-2H1 8 PF E12N 1302 2H1 2014-4828-01-0002-SH1

2014-4827-01-0004 QAY 2855

MPFM

ZAU-2706 Mix 1 18.6-142.2 92.2 80/118 130 -28/130 195 WATER HC 38 Electric 4 100% NOTE 1 Maintain Temp = 55 C G

3 18''-PF-E1N-1304-2H1 18 PF E1N 1304 2H1 2014-4828-01-0002-SH2 Mix 118.6-142.2 92.2 80/118 130 -28/130 195 WATER HC 38 Electric 2 YES 100% NOTE 1 Maintain Temp = 30 C G

4 16''-PF-E1N-1305-2H1 16 PF E1N 1305 2H1 2014-4828-01-0002-SH2

2014-4825-01-0006

18''-PF-E1N-1304-2H1 Production Separator

MBD-2902

Mix 1 18.6-142.2 92.2 80/118 130 -28/130 195 WATER HC 38 Electric 2 YES 100% NOTE 1 Maintain Temp = 30 C G

5 2''-PF-E12N-1306-2H1 2 P F E 12 N 1 30 6 2 H1 2 01 4- 48 27 -0 1- 00 04 8 '' -P F- E1 2N- 13 02 -2 H1 2 '' -F H- A6N -4 00 2- 2H1 Mix 1 1 8. 6- 14 2. 2 92 .2 8 0/ 11 8 1 30 - 28 /1 30 1 95 WAT ER HC 2 5 E le ct ri c 4 100% NOTE 1 Maintain Temp = 55 C G

6 8''-PF-E12N-1307-2H1 8 PF E12N 1307 2H1 2014-4828-01-0002-SH2

2014-4827-01-0004

From MPFM

ZAU-2706 18''-PF-E1N-1304- 2H1 Mix 118. 6-142.2 92. 2 80/118 130 -28/130 195 WAT ER HC 38 E lectric 4 100% NOTE 1 Maintain Temp = 30 C G

7 8''-PF-E1N-1308-2H1 8 PF E1N 1308 2H1 2014-4825-01-0006

2014-4897-01-0058

From Bridge Piping

(WHP-C / ST-PIP) 1 6''-PF-E1N-1305- 2H1 Mix 118. 6-142.2 92. 2 80/118 130 -28/130 195 WAT ER HC 38 E lectric 2 100% NOTE 1

Maintain Temp = 55 C

FUTURE G

8 6''-PF-E12N-1310-2H1 6 PF E12N 1310 2H1 2014-4828-01-0002-SH2 8''-PF- E12N-1301-2H1 PSV 2956-1 Mix 118. 6-142.2 92. 2 80/118 130 -28/130 195 WAT ER HC 25 E lectric 4 100% NOTE 1 Maintain Temp = 55 C G

9 2''-PF-E12N-1311-2H1 2 P F E 12 N 1 31 1 2 H1 2 01 4- 48 28 -0 1- 00 02 -S H2 8 '' -P F- E1 2N- 13 01 -2 H1 2 '' -F H- A6N -4 06 8- 2H1 Mix 1 18. 6- 14 2. 2 92 .2 8 0/ 11 8 1 30 - 28 /1 30 1 95 WAT ER HC 2 5 E le ct ri c 4 100% NOTE 1 Maintain Temp = 30 C G

10 12''-PF-D1N-1318-2H1 12 PF D1N 1318 2H1 2014-4825-01-0006

2014-4897-01-0058 8 '' -P L- D1 N- 20 00 -2 H1 1 2' '- PF -D 1N -1 31 9- 2H 1 M ix 4 9. 9- 12 2. 7 2 0/ 47 .5 7 1 .4 /1 02 .2 8 6 - 3/ 12 0 1 29 W AT ER H C 3 8 E le ct ri c 2 100% NOTE 1 Maintain Temp = 30 C G

11 12''-PF-D1N-1319-2H1 12 PF D1N 1319 2H1 2014-4897-01-0058 ST-PIP-12''-PF-D1N-1318-

2H1

WHP-C-12''-PF-D1N-1391-

2H1 Mix 49.9-122.7 20/47.5 71.4/102.2 86 -3/120 129 WATER HC 38 Electric 2 100% NOTE 1 Maintain Temp = 30 C G

12 6''-PF-D1N-1320-2H1 6 PF D1N 1320 2H1 2014-4825-01-0006 12''-PF- D1N- 1318- 2H1 PSV 2902-3 Mix 49.9- 122. 7 20/47.5 71.4/102. 2 86 -3/120 129 WAT ER HC 25 E lectric 2 100% NOTE 1 Maintain Temp = 55 C G

13 2''-PF-D1N-1321-2H1 2 P F D 1N 1 32 1 2 H1 2 01 4- 48 25 -0 1- 00 06 1 2' '- PF- D1 N- 131 8- 2H1 2 '' -F H- A1N -4 02 3- 2H1 Mix 4 9. 9- 122 .7 2 0/ 47 .5 - 8 .5 /1 02 .2 8 6 - 28 /1 20 1 29 WAT ER HC 2 5 E le ct ri c 2 100% NOTE 1 Maintain Temp = 55 C G

14 3''-PF-D1N-1322-2H1 3 P F D 1N 1 32 2 2 H1 2 01 4- 48 25 -0 1- 00 06 1 2' '- PF- D1 N- 131 8- 2H1 6 '' -F H- A6N -4 05 7- 2H1 Mix 4 9. 9- 122 .7 2 0/ 47 .5 - 8 .5 /1 02 .2 8 6 - 28 /1 35 1 29 WAT ER HC 2 5 E le ct ri c 2 100% NOTE 1 Maintain Temp = 55 C G

15 6''-PF-D1N-1323-2H1 6 PF D1N 1323 2H1 2014-4825-01-0006 6''-PF-D1N-1320-2H1 PSV 2902-4 Mix 49.9- 122. 7 20/47.5 71.4/102. 2 86 -3/120 129 WAT ER HC 25 E lectric 2 100% NOTE 1 Maintain Temp = 55 C G

16 8''-PF-E1N-1324-2H1 8 PF E1N 1324 2H1 2014-4897-01-0058 WHP-C-8''-PF-E1N-1390-

2H1

ST-PIP-8''-PF-E1N-1308-

2H1 Mix 118.6-142.2 92.2 80/118 130 -28/130 195 WATER HC 38 Electric 2 100% NOTE 1 Maintain Temp = 30 C G

17 6''-PF-E12N-1325-2H1 6 PF E12N 1325 2H1 2014-4828-01-0002-SH1 8''-PF- E12N-1302-2H1 PSV 2955-1 Mix 118. 6-142.2 92. 2 80/118 130 -28/130 195 WAT ER HC 25 E lectric 4 100% NOTE 1 Maintain Temp = 55 C G

18 2''-PF-E1N-1326-2H1 2 PF E1N 1326 2H1 2014-4828-01-0002-SH2 1 8''- PF- E1N-1304-2H1 2''-PF-E12N-1327- 2H1 Mix 1 18. 6-142.2 92. 2 80/118 130 -28/130 195 WAT ER HC 25 E lectric 2 100% NOTE 1 Maintain Temp = 30 C G

19 2''-PF-E12N-1327-2H1 2 PF E12N 1327 2H1 2014-4828-01-0002-SH2 2''-PF-E1N-1326- 2H1 2''-FH-A6N-4071-2H1 Mix 1 18. 6-142.2 92. 2 -7.6/118 130 -46/135 195 WAT ER HC 25 E lectric 4 100% NOTE 1 Maintain Temp = 30 C G

PROCESS LINE LIST FOR ST-PIP

REV. E

Production Manifold

TCT

08-12-1501-10-15

G

TMH

DATE

DOCUMENT NO. 2014-4800-9U-0001

BY

D

TMH

03-06-15 21-08-15

F

TMH

2014-4800-9U-0001 Process Line List for ST-PIP - Rev G Page 4 of 33


5/33

D

TMH

03-06-15

PG: PROCESS GAS

NO. LINE NUMBER SIZE SERVPIPING


DENSITY

Kg/m3

OP PRESS.

Barg

OP TEMP

C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST

PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness

(mm)

Tracing TypePAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


1 10''-PG-E1N-1100-2P1 10 PG E1N 1100 2P1 2014-4825-01-0006

2014-4826-01-0010 12''-PG-E1N-1130-2P1

Gas reinjectioncompressionsuction

cooler (HBA-2606) G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 38 - 2 100% NOTE 1

2 2''-PG-E1N-1101-2P1 2 PG E1N 1101 2P1 2014-4826-01-0010 10''-PG-E1N-1100-2P1 10''-PG-E1N-1100-2P1 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

3 8''-PG-G1N-1102-2P2 8 PG G1N 1102 2P2 2014-4826-01-0010

2014-4826-01-001210''-PG-G1N-1144-2P2 8''-PG-E1N-1104-2P1 G 143.5-168.3 191.7/255.1 119.2/144.1 310 -17/170 465 WATER PP 38 - 2 YES 100% NOTE 1

4 2''-PG-E12N-1103 2 PG E12N 1103 2014-4826-01-0011 2''-PG-E1N-1139 2''-FH-A6N-4010 G 93.1 89.8 -38/50 130 -46/90 195 WATER - - - 14 100% NOTE 1

5 8''-PG-E1N-1104-2P1 8 PG E1N 1104 2 P1 2014-4826-01-0010 8''-PG-G1N-1102-2P2 10''-PG-E1N-1100-2P1 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 38 - 2 100% NOTE 1

6 10''-PG-E1N-1105 10 PG E 1N 1105 2014-4826-01-0010

2014-4826-01-0011

Gas reinjectioncompression

suctioncooler (HBA-2606)

Gas ReinjectionCompressionSuction

Scrubber (MBF-2606) G 9 6.3-110.1 90.1 50 130 -22/90 195 W ATER - - - 1 100% NOTE 1

7 10''-PG-E1N-1107 10 PG E 1N 1107 2014-4826-01-0011

2014-4826-01-0012

Gas ReinjectionCompression

SuctionScrubber (MBF-2606)

1st Stage Gas Reinjection

Compressor G 93.1 89.8 50 130 - 22/90 195 WATER - - - 1 100% NOTE 1

8 6''-PG-G1N-1108-2P2 6 PG G 1N 1108 2P2 2014-4826-01-0012 10''-PG-G1N-1144-2P2 PSV 2606A-4 G 143.5-168.3 191.7/255.1 119.2/144.1 310 -17/170 465 WATER PP 38 - 2 YES 100% NOTE 1

9 10''-PG-L13N-1109-2P1 1 0 P G L 13 N 1 10 9 2 P1 2 01 4- 48 26 -0 1- 00 12 2nd Stage Gas Reinjection

Compressor 10''-PG-L13N-1110-2P1 G 244.1 - 306.2 330/525 9 7.2/111 590 -17/145 885 WATER PP 38 - 2 YES 100% NOTE 1

10 10''-PG-L13N-1110-2P1 1 0 PG L13N 1110 2P1 2014-4828-01-0005

2014-4826-01-001210''-PG-L13N-1109-2P1 10''-PG-L13N-1111-2P1 G 244.1 - 306.2 330/525 97.2/111 590 -17/145 885 WATER PP 38 - 2 YES 100% NOTE 1

11 10''-PG-L13N-1111-2P1 10 PG L13N 1111 2P1 2014-4828-01-0005 G 244.1 - 306.2 330/525 97.2/111 590 -17/145 885 WATER PP 38 - 2 YES 100% NOTE 1

12 8''-PG-L13N-1112-2P1 8 PG L13N 1112 2P1 2014-4826-01-0012

2014-4826-01-001410''-PG-L13N-1109-2P1 FCV 2616-1 G 244.1 - 306.2 330/525 97.2/111 590 -17/145 885 WATER PP 38 - 2 YES 100% NOTE 1

13 2''-PG-L13N-1113-2P1 2 PG L13N 1113 2P1 2014-4826-01-0012

2014-4826-01-0016 10''-PG-L13N-1109-2P1

Compressor Sealgas treatment

system (for 2nd stage) G 2 44.1 - 306.2 330/525 97.2/111 590 -17/145 885 WATER PP 25 - 2 100% NOTE 1

14 10''-PG-L13N-1114-2P1 1 0 PG L13N 1114 2P1 2014-4826-01-0012

2014-4897-01-005810''-PG-L13N-1110-2P1 10''-PG-L13N-1165-2P1 G 244.1 - 306.2 330/525 97.2/111 590 -17/145 885 WATER PP 38 - 2 YES 100% NOTE 1

15 8''-PG-L13N-1115-2P1 8 PG L13N 1115 2P1 2014-4826-01-0012 10''-PG-L13N-1110-2P1 FCV 2606A-1 G 244.1 - 306.2 3 30/525 97.2/111 590 -17/145 885 WATER PP 38 - 2 YES 100% NOTE 1

16 4''-PG-L13N-1116-2P1 4 PG L 13N 1116 2P1 2014-4828-01-0005 10''-PG-L13N-1110-2P1 4''-PG-L6N-1187-2P1 G 244.1 - 306.2 3 30/525 97.2/111 590 -17/145 885 WATER PP 25 - 2 YES 100% NOTE 1

17 6''-PG-L13N-1117-2P1 6 PG L13N 1 117 2P1 2014-4826-01-0012 6''-PG-L13N-1142-2P1 PSV 2606A-3 G 244.1 - 306.2 330/525 97.2/111 590 -17/145 885 WATER PP 25 - 2 YES 100% NOTE 1

18 8''-PG-E1N-1119-2P1 8 PG E1N 1119 2P1 2014-4826-01-0010

2014-4826-01-0012FCV 2606A-1 10''-PG-E1N-1100-2P1 G 77.35-82.19 91.3 70/118 130 -28/130 195 WATER PP 38 - 2 100% NOTE 1

19 8''-PG-G1N-1121-2P2 8 PG G 1N 1121 2P2 2014-4826-01-0014 FCV 2616-1 10''-PG-G1N-1144-2P2 G 143.5-168.3 191.7/255.1 119.2/144.1 360 -17/170 540 WATER PP 38 - 2 YES 100% NOTE 1

20 10''-PG-G1N-1123 10 PG G 1N 1123 2014-4826-01-0014

2014-4826-01-0015


interstage Cooler (HBA-2616) 12''-PG-G1N-1193 G 205.5 - 254.2 190.7/254.1 50 360 -17/90 540 WATER - - - 1 YES 100% NOTE 1

21 10''-PG-G1N-1125 10 PG G 1N 1125 2014-4826-01-0012

2014-4826-01-0015


interstage Scrubber (MBF-2616)

2nd Stage Gas Reinjection

CompressorG 205.2 - 253.9 190.4/253.8 50 360 -17/90 540 WATER - - - 1 YES 100% NOTE 1

22 2''-PG-L13N-1127-2P1 2 PG L13N 1 127 2P1 2014-4828-01-0005 10''-PG-L13N-1111-2P1 2''-PG-L6N-1186-2P1 G 244.1 - 306.2 330/525 9 7.2/111 590 -17/145 885 WATER PP 25 2 100% NOTE 1

23 2''-PG-E1N-1128-2H1 2 PG E1N 1 128 2H1 2014-4825-01-0006 10''-PG-E1N-1100-2P1 PCV 2902-1 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

24 1''-PG-G6N-1129-2H1 1 PG G6N 1 12 9 2 H1 2 01 4-4 82 6-0 1-0 01 6 Compressor sealgas conditioning

system (1st stage)

Compressor sealgas system (1st

stage) G 1 43 .5 -1 68 .3 1 91 .7 /2 55 .1 1 19 .2 /1 44 .1 3 10 - 17 /1 70 4 65 WAT ER H C 2 5 E lec tr ic 4 100% NOTE 1 MaintainTemp = 120 C G

25 1 2' '- PG -E 1N -1 13 0- 2P 1 1 2 P G E 1N 1 13 0 2 P1 2 01 4- 48 25 -0 1- 00 06 ProductionSeparator

MBD-2902 10''-PG-E1N-1100-2P1 G 7 7.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 38 - 2 100% NOTE 1

26 3''-PG-E1N-1131-2P1 3 PG E1N 1131 2P1 2014-4825-01-0006

2014-4857-01-0025 10''-PG-E1N-1100-2P1

Fuelgas Precooler

HAL-5746 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

27 3''-PG-E1N-1132 3 PG E1N 1 132 2014-4826-01-0011

2014-4857-01-0025 10''-PG-E1N-1107

FuelGas Package

(TP 0025-03) G 93.1 89.8 50 130 - 22/90 195 WATER - - - 1 100% NOTE 1

28 8''-PG-D1N-1133-2H1 8 PG D1N 1 133 2H1 2014-4825-01-0006 8''-PG-E1N-1166-2P1 8''-PL-D1N-2000-2H1 G 40.3-42.74 47.5 64.2/103.7 86 -3/120 129 WATER HC 38 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

29 2''-PG-E1N-1134-2P1 2 PG E1N 1134 2 P1 2014-4825-01-0006 4''-PG-E1N-1176-2P1 2''-PG-E12N-1190-2P1 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

30 4''-PG-E1N-1135-2P1 4 PG E1N 1135 2P1 2014-4825-01-0006 4''-PG-E1N-1176-2P1 PSV 2902-1 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

31 4''-PG-E1N-1136-2P1 4 PG E1N 1136 2P1 2014-4825-01-0006 2''-PG-E1N-1134-2P1 PSV 2902-2 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

32 6''-PG-E1N-1137-2P1 6 PG E1N 1137 2 P1 2014-4825-01-0006 10''-PG-E1N-1100-2P1 BDV 2902-3 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

33 6''-PG-E1N-1138-2P1 6 PG E1N 1138 2P1 2014-4825-01-0006 12''-PG-E1N-1130-2P1 PV 2902-1 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

34 2''-PG-E1N-1139 2 PG E1N 1139 2014-4826-01-0011 Gas ReinjectionCompression

suctionScrubber (MBF-2606) 2''-PG-E12N-1103 G 9 6.3-110.1 90.1 50 130 -22/90 195 WATER - - - 1 100% NOTE 1

35 2''-PG-E1N-1140 2 PG E1N 1140 2014-4826-01-0011 2''-PG-E1N-1139 PSV 2606-4 G 96.3-110.1 90.1 50 130 -22/90 195 WATER - - - 1 100% NOTE 1

36 2''-PG-E1N-1141 2 PG E1N 1141 2014-4826-01-0011 2''-PG-E1N-1140 PSV 2606-5 G 96.3-110.1 90.1 50 130 -22/90 195 WATER - - - 1 100% NOTE 1

37 6''-PG-L13N-1142-2P1 6 PG L13N 1142 2P1 2014-4826-01-0012 10''-PG-L13N-1109-2P1 PSV 2606A-1 G 244.1 - 306.2 3 30/525 97.2/111 590 -17/145 885 WATER PP 25 - 2 YES 100% NOTE 1

38 3''-PG-L13N-1143-2P1 3 PG L13N 1143 2P1 2014-4826-01-0012 10''-PG-L13N-1109-2P1 BDV 2606A-8 G 244.1 - 306.2 3 30/525 97.2/111 590 -17/145 885 WATER PP 25 - 2 YES 100% NOTE 1

39 10''-PG-G1N-1144-2P2 10 PG G1N 1144 2P2 2014-4826-01-0012

2014-4826-01-0014

1 st stage Gas Reinjection

Compressor

Gas Reinjectioncompression

interstage cooler (HBA-2616) G 143.5-168.3 191.7/255.1 119.2/144.1 310 -17/170 465 WATER PP 38 - 2 YES 100% NOTE 1

G

TCT

08-12-15

TMH

DATE

E

TMH

21-08-15 01-10-15

INJECTION HEADER


DOCUMENT NO. 2014-4800-9U-0001

REV.

BY

F



6/33

D

TMH

03-06-15

PG: PROCESS GAS

NO. LINE NUMBER SIZE SERVPIPING


DENSITY

Kg/m3

OP PRESS.

Barg

OP TEMP

C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST

PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness

(mm)

Tracing TypePAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


G

TCT

08-12-15

TMH

DATE

E

TMH

21-08-15 01-10-15


DOCUMENT NO. 2014-4800-9U-0001

REV.

BY

F

40 6''-PG-G1N-1145-2P2 6 PG G 1N 1145 2P2 2014-4826-01-0012 6''-PG-G1N-1108-2P2 PSV 2606A-2 G 143.5-168.3 191.7/255.1 119.2/144.1 310 -17/170 465 WATER PP 38 - 2 YES 100% NOTE 1

41 3''-PG-G1N-1146-2P2 3 PG G1N 1 146 2P2 2014-4826-01-0012 6''-PG-G1N-1108-2P2 BDV 2606A-7 G 143.5-168.3 191.7/255.1 119.2/144.1 310 -17/170 465 WATER PP 38 - 2 100% NOTE 1

42 10''-PG-E1N-1155-2P2 10 PG E1N 1155 2P2 2014-4826-01-0012 8''-PG-G1N-1156-2P2 10''-PG-E1N-1107 G 93.1 89.8 50/144 130 -22/170 195 WATER PP 38 - 2 100% NOTE 1

43 8''-PG-G1N-1156-2P2 8 PG G1N 1156 2P2 2014-4826-01-0012 10''-PG-G1N-1144-2P2 10''-PG-E1N-1155-2P2 G 143.5-168.3 191.7/255.1 119.2/144.1 310 -17/170 465 WATER PP 38 - 2 YES 100% NOTE 1

44 8''-PG-L13N-1157-2P1 8 PG L 13N 1157 2P1 2014-4826-01-0012 10''-PG-L13N-1109-2P1 10''-PG-G1N-1158-2P1 G 244.1 - 306.2 3 30-525 97.2/111 590 -17/145 885 WATER PP 38 - 2 YES 100% NOTE 1

45 10''-PG-G1N-1158-2P1 10 PG G 1N 1158 2P1 2014-4826-01-0012 8''-PG-L13N-1157-2P1 10''-PG-G1N-1125 G 205.2 - 253.9 190.4/253.8 50/100 360 -17/145 540 WATER PP 38 - 2 YES 100% NOTE 1

46 2''-PG-G1N-1160 2 PG G1N 1160 2014-4826-01-0015 Gas ReinjectionCompression

interstage Scrubber (MBF-2616) 2 ''-PG-G6N-1177 G 2 05.2 - 253.9 190.4/253.8 50 360 -17/90 540 WATER - - - 1 100% NOTE 1

47 2''-PG-G1N-1161 2 PG G1N 1161 2014-4826-01-0015 2''-PG-G1N-1160 PSV 2616-4 G 2 05.2 - 253.9 190.4/253.8 50 360 -17/90 540 WATER - - - 1 100% NOTE 1

48 2''-PG-G1N-1162 2 PG G1N 1162 2014-4826-01-0015 2''-PG-G1N-1161 PSV 2616-5 G 2 05.2 - 253.9 190.4/253.8 50 360 -17/90 540 WATER - - - 1 100% NOTE 1

49 3''-PG-G6N-1163-2P2 3 PG G6N 1163 2P2 2014-4826-01-0012 BDV 2606A-7 8''-FH-A6N-4014 G 173.10 255.1 -38/144 310 -90/170 465 WATER PP 38 - 4 100% NOTE 1

50 3''-PG-L6N-1164-2P1 3 PG L 6N 1164 2P1 2014-4826-01-0012 BDV 2606A-8 10''-FH-A6N-4013-2P1 G 244.1 - 306.2 330/525 -83.6/111 590 -90/145 885 WATER PP 25 - 4 100% NOTE 1

51 10''-PG-L13N-1165-2P1 1 0 PG L13N 1165 2P 1 2014- 4897- 01- 0058 ST- PIP-10''- PG-L13N-1114-2P1 WHP-C-10"-P G-L13N-1120-2P1 G 244. 1 - 306. 2 3 30/525 97.2/111 590 -17/145 885 WAT ER PP 38 - 2 YES 100% NOT E 1

52 8''-PG-E1N-1166-2P1 8 PG E1N 1166 2 P1 2014-4825-01-0006 12''-PG-E1N-1130-2P1 8''-PG-D1N-1133-2H1 G 77.35-82.19 91.3 80/118 130 -3/130 195 WATER PP 38 - 2 100% NOTE 1

53 2''-PG-G1N-1170-2P2 2 PG G1N 1 170 2P2 2014-4826-01-0012 10''-PG-G1N-1144-2P2 10"-PG-G1N-1144-2P2 G 143.5-168.3 191.7/255.1 119.2/144.1 360 -17/170 540 WATER PP 38 - 2 100% NOTE 1

54 2''-PG-L13N-1171-2P1 2 PG L13N 1 171 2P1 2014-4826-01-0012 10''-PG-L13N-1109-2P1 10''-PG-L13N-1110-2P1 G 244.1 - 306.2 330/525 9 7.2/111 590 -17/145 885 WATER PP 25 - 2 100% NOTE 1

55 4''-PG-E1N-1176-2P1 4 P G E 1N 1 17 6 2 P1 2 01 4- 48 25 -0 1- 00 06 ProductionSeparator

MBD-2902 4''-PG-E1N-1136-2P1 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

56 2''-PG-G6N-1177 2 PG G6N 1177 2014-4826-01-0015 2''-PG-G1N-1160 2''-FH-A6N-4022 G 173.1 247.2 -83.6/50 360 -90/90 540 WATER - - - 14 100% NOTE 1

57 2''-PG-G1N-1178-2P2 2 PG G1N 1178 2P2 2014-4826-01-00122014-4826-01-0016

10''-P G- G1N- 1144- 2P 2 Compr essor Seal gas condition G 143.5-168.3 191. 7/255. 1 119.2/144.1 310 -17/170 465 WAT ER PP 38 - 2 100% NOT E 1

58 2''-PG-G1N-1179-2P2 2 PG G1N 1 179 2P2 2014-4826-01-0012 6''-PG-G1N-1108-2P2 2''-PG-G6N-1181-2P1 G 143.5-168.3 191.7/255.1 119.2/144.1 310 -17/170 465 WATER PP 38 - 2 100% NOTE 1

59 2''-PG-L13N-1180-2P1 2 PG L13N 1 180 2P1 2014-4826-01-0012 10''-PG-L13N-1109-2P1 2''-PG-L6N-1182-2P1 G 244.1 - 306.2 330/525 97.2/111 590 -17/145 885 WATER PP 25 - 2 100% NOTE 1

60 2''-PG-G6N-1181-2P1 2 PG G6N 1181 2P1 2014-4826-01-0012 2''-PG-G1N-1179-2P2 2''-FH-A6N-4058 G 173.1 255.1 -38/82 310 -90/170 465 WATER PP 25 - 4 100% NOTE 1

61 2''-PG-L6N-1182-2P1 2 PG L 6N 1182 2P1 2014-4826-01-0012 2''-PG-L13N-1180-2P1 2''-FH-A6N-4059 G 244.1 - 306.2 330/525 -83.6/111 590 -90/135 885 WATER PP 25 - 4 100% NOTE 1

62 2''-PG-G1N-1183 2 PG G1N 1183 2014-4826-01-0014 10''-PG-G1N-1123 2''-DC-A1N-5050 G 2 05.5 - 254.2 190.7/254.1 50 360 -17/90 540 WATER - - - 1 100% NOTE 1

63 2''-PG-E1N-1184 2 PG E1N 1184 2014-4826-01-0010 10''-PG-E1N-1105 2''-DC-A1N-5049 G 96.3-110.1 90.1 50 130 -22/90 195 WATER - - - 1 100% NOTE 1

64 2''-PG-L12N-1185-2H1 2 PG L12N 1 18 5 2 H1 2 01 4-4 82 6-0 1-0 01 6 Compr. sealgas conditioning

system (2nd stage)

Compressor sealgas system (2nd

stage) G 169.5-199.7 191. 7/255. 1 83.4/100 390 -17/145 585 WAT ER HC 25 Electric 4 100% NOTE 1 MaintainTemp = 106 C G

65 2''-PG-L6N-1186-2P1 2 PG L6N 1 186 2P1 2014-4828-01-0005 2''-PG-L13N-1127-2P1 2''-FH-A6N-4072 G 244.1 - 306.2 330/525 2.6/111 590 -90/145 885 WATER PP 25 - 4 100% NOTE 1

66 4''-PG-L6N-1187-2P1 4 PG L 6N 1187 2P1 2014-4828-01-0005 BDV 2606A-11 6''-FH-A6N-4015-2P1 G 244.1 - 306.2 330/525 -89/111 590 -90/145 885 WATER PP 25 - 4 100% NOTE 1

67 4''-PG-E1N-1188-2P1 4 PG E1N 1188 2 P1 2014-4825-01-0006 6''-PG-E1N-1138-2P1 4''-FH-A1N-4090-2P1 G 77.35-82.19 91.3 80/118 130 -28/130 195 WATER PP 25 - 2 100% NOTE 1

68 12''-PG-E12N-1189-2P1 12 PG E12N 1189 2P1 2014-4825-01-0006 BDV 2902-3 12''-FH-A6N-4003-2P1 G 77.35-82.19 91.3 -20.5/118 130 -46/135 195 WATER PP 38 - 4 100% NOTE 1

69 2''-PG-E12N-1190-2P1 2 PG E12N 1190 2 P1 2014-4825-01-0006 2''-PG-E1N-1134-2P1 2''-FH-A6N-4031 G 1-1.5 91.3 -7.6/118 130 -46/135 195 WATER PP 25 - 4 100% NOTE 1

70 6''-PG-E1N-1191-2P1 6 PG E1N 1191 2 P1 2014-4825-01-0006 8''-PG-E1N-1166-2P1 6''-PG-D1N-1192-2H1 G 77.35-82.19 91.3 80/118 130 -3/130 195 WATER PP 25 - 2 100% NOTE 1

71 6''-PG-D1N-1192-2H1 6 PG D1N 1 192 2H1 2014-4825-01-0006 6''-PG-E1N-1191-2P1 8''-PG-D1N-1133-2H1 G 40.3-42.74 47.5 64.2/103.7 86 -3/120 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G



7/33

D

TMH

03-06-15

FH:HIGH PRESSURE FLARE

NO. LINE NUMBERSIZE

(Inch)SERV

PIPING


DENSITY

Kg/m3

OP PRESS.

BargOP TEMP C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness (mm)

Tracing

Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


1 20''-FH-A1N-4000-2H1 20 FH A1N 4000 2H1 2014-4843-01-0041

2014-4843-01-0043 HP FLARE HEADER 20''-FH-A6N-4080-2H1 G 2.6-5 0.1/2.5 10/65 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

2 10''-FH-A6N-4001-2P1 10 FH A6N 4 001 2 P1 2014-4897-01-0058 10''-FH-A6N-4049-2P1 16''-FH-A6N-4075-2P1 G 1-5 0.1/2.5 -89.7/80 12 -90/135 18 WATER PP 38 - 4 20% NOTE 1

3 2''-FH-A6N-4002-2H1 2 FH A6N 4002 2H1 2014-4828-01-0002-SH2

2014-4827-01-0004 2''-PF-E12N-1306-2H1 2''-FH-A6N-4064-2H1 G 4-7 0.1/2.5 - 20.5/55 12 -90/135 18 WATER HC 25 Electric 14 20% NOTE 1 Maintain Temp = 55 C G

4 12''-FH-A6N-4003-2P1 12 FH A6N 4003 2P1 2014-4825-01-0006

2014-4843-01-0041 12''-PG-E12N-1189-2P1 16''-FH-A6N-4075-2P1 G 1-3 0.1/2.5 -20.5/55 12 -90/135 18 WATER PP 38 - 14 20% NOTE 1 G

5 4''-FH-A1N-4004 4 FH A1N 4 004 2014-4826-01-00102014-4843-01-0041

PSV 2606-1 8''-FH-A1N-4083 L 1007 0.1/2.5 20/30 12 -28/135 18 WATER - - - 1 20% NOTE 1

6 4''-FH-A1N-4005 4 FH A1N 4005 2014-4826-01-0010 PSV 2606-2 4''-FH-A1N-4004 L 1007 0.1/2.5 2 0/30 12 -28/135 18 WATER - - - 1 20% NOTE 1

7 2''-FH-A6N-4006 2 FH A6N 4 006 2014-4828-01-0002-SH2

2014-4843-01-0043 2''-FH-L13N-4030

Flare Scrubber

MBF-4320 G 1 .57/4.32 0.1/2.5 1 9/63 12 -90/135 18 WATER - - - 14 20% NOTE 1 G

8 4''-FH-A1N-4008 4 FH A1N 4 008 2014-4826-01-0011

2014-4843-01-0041 PSV 2606-4 8''-FH-A1N-4083 G 1.1-3.4 0.1/2.5 -3.3/80 12 -28/135 18 WATER - - - 1 20% NOTE 1

9 4''-FH-A1N-4009 4 FH A 1N 4009 2014-4826-01-0011 PSV 2606-5 4''-FH-A1N-4008 G 1.1-3.4 0 .1/2.5 -3.3/80 12 -28/135 18 WATER - - - 1 20% NOTE 1

10 2''-FH-A6N-4010 2 FH A6N 4 010 2014-4826-01-0011

2014-4843-01-0041 2''-PG-E12N-1103 2''-FH-A6N-4022 G 1.1-3.4 0.1/2.5 -38.1/72 12 -90/135 18 WATER - - - 14 20% NOTE 1

11 10''-FH-A1N-4011-2P1 10 FH A1N 4011 2P1 2014-4825-01-0006

2014-4843-01-0041 PV-2902-1 20''-FH-A1N-4000-2H1 G 0.9-2.9 0.1/2.5 30/82 12 -28/135 18 WATER PP 38 - 1 20% NOTE 1 G

12 14''-FH-A1N-4012 14 FH A1N 4012 2014-4826-01-0012

2014-4843-01-0041 PSV 2606A-1 16''-FH-A1N-4084 G 0.89-3.06 0.1/2.5 20/55 12 -28/135 18 WATER - - - 1 20% NOTE 1

13 10''-FH-A6N-4013-2P1 10 FH A6N 4013 2P1 2014-4826-01-0012

2014-4843-01-0041 3''-PG-L6N-1164-2P1 12''-FH-A6N-4088-2P1 G 0.96-1.5 0.1/2.5 -83.6/72 12 -90/135 18 WATER PP 38 - 14 20% NOTE 1 G

14 8''-FH-A6N-4014 8 FH A6N 4 014 2014-4826-01-0012

2014-4843-01-0041 3''-PG-G6N-1163-2P2 12''-FH-A6N-4088-2P1 G 0.96-1.5 0 .1/2.5 3 8.1/72 12 -90/135 18 WATER - - - 14 20% NOTE 1

15 6''-FH-A6N-4015-2P1 6 FH A6N 4015 2P1 2014-4828-01-0005

2014-4843-01-0041 4''-PG-L6N-1187-2P1 12''-FH-A6N-4085-2P1 G 0.96-1.5 0.1/2.5 -89/55 12 -90/135 18 WATER PP 38 - 14 20% NOTE 1 G

16 14''-FH-A1N-4016 14 FH A 1N 4016 2014-4826-01-0012 PSV 2606A-4 14''-FH-A1N-4024 G 0.85-2.95 0.1/2.5 46.8/55 12 -28/135 18 WATER - - - 1 20% NOTE 1

17 4''-FH-A1N-4017 4 FH A1N 4 017 2014-4826-01-0014

2014-4843-01-0041 PSV 2616-1 20''-FH-A1N-4087-2H1 L 1007 0.1/2.5 2 0/30 12 -28/135 18 WATER - - - 1 20% NOTE 1

18 4''-FH-A1N-4018 4 FH A1N 4018 2014-4826-01-0014 PSV 2616-2 4''-FH-A1N-4017 L 1007 0.1/2.5 2 0/30 12 -28/135 18 WATER - - - 1 20% NOTE 1

19 6''-FH-A1N-4020 6 FH A1N 4 020 2014-4826-01-0015

2014-4843-01-0041 PSV-2616-4 8''-FH-A1N-4083 G 0.89-3.06 0.1/2.5 20/55 12 -28/135 18 WATER - - - 1 20% NOTE 1

20 6''-FH-A1N-4021 6 FH A1N 4021 2014-4826-01-0015 PSV-2616-5 6''-FH-A1N-4020 G 0.89-3.06 0.1/2.5 20/55 12 -28/135 18 WATER - - - 1 20% NOTE 1

21 2''-FH-A6N-4022 2 FH A6N 4 022 2014-4826-01-0015

2014-4843-01-0041 2''-PG-G6N-1177 12"-FH-A6N-4003-2P1 G 0.82-2.6 0.1/2.5 -83.6/35 12 -90/135 18 WATER - - - 14 20% NOTE 1 G

22 2''-FH-A1N-4023-2H1 2 FH A1N 4023 2H1 2014-4825-01-0006

2014-4843-01-0041 2''-PF-D1N-1321-2H1 10"-FH-A1N-4011-2P1 G 5.6-20.2 0 .1/2.5 -8.5/55 12 -28/135 18 WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 55 C G

23 14''-FH-A1N-4024 14 FH A1N 4024 2014-4826-01-0012

2014-4843-01-0041 PSV 2606A-2 16''-FH-A1N-4084 G 0.85-2.95 0.1/2.5 46.8/55 12 -28/135 18 WATER - - - 1 20% NOTE 1

24 6''-FH-A1N-4026 6 FH A1N 4 026 2014-4857-01-0028

2014-4843-01-0041

FuelGas Package

(TP 0028-01) 20''-FH-A1N-4087-2H1 G 0.96-1.5 0.1/2.5 1 .5-82 12 -28/135 18 WATER - - - 1 20% NOTE 1

25 2''-FH-L13N-4030 2 FH L13N 4030 2014-4828-01-0002-SH1 CASING VENT HEADER 2''-FH-A6N-4006 G 1.57/4.32 0.1/2.5 19/63 530 -28/135 795 WATER - - - 1 100% NOTE 1

26 2''-FH-A6N-4031 2 FH A6N 4 031 2014-4825-01-0006

2014-4843-01-0041 2''-PG-E12N-1190-2P1 16''-FH-A6N-4075-2P1 G 0.89-2.9 0.1/2.5 -20.5/55 12 -90/135 18 WATER - - - 14 20% NOTE 1 G

27 4''-FH-A1N-4035 4 FH A1N 4035 2014-4857-01-0028 PSV 5726-2 4''-FH-A1N-4036 G 0.85 - 2.7 0.1/2.5 19/62 12 -28/135 18 WATER - - - 1 20% NOTE 1

28 4''-FH-A1N-4036 4 FH A1N 4 036 2014-4857-01-0028

2014-4843-01-0041 PSV 5726-1 20''-FH-A1N-4087-2H1 G 0.85 - 2.7 0.1/2.5 19/62 12 -28/135 18 WATER - - - 1 20% NOTE 1

29 14''-FH-A1N-4039-2H1 14 FH A1N 4039 2H1 2014-4828-01-0002-SH2

2014-4843-01-0041 PSV 2956-1 16''-FH-A1N-4094-2H1 G 2.6-5 0.1/2.5 10/120 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

30 14''-FH-A1N-4040 14 FH A 1N 4040 2014-4826-01-0012 PSV 2606A-3 14''-FH-A1N-4012 G 0.89-3.06 0.1/2.5 20/55 12 -28/135 18 WATER - - - 1 20% NOTE 1

31 2''-FH-A1N-4042 2 FH A1N 4 042 2014-4843-01-0041

2014-4843-01-0043 PSV 4346-1 20''-FH-A1N-4087-2H1 G 0.96-2.61 0.1/2.5 -25/55 12 -28/135 18 WATER - - - 1 20% NOTE 1

32 2''-FH-A1N-4043 2 FH A1N 4 043 2014-4843-01-0043 FIRE IGNITION SYSTEM 2''-FH-A6N-4098 G 0.96-2.61 0.1/2.5 40/64 12 -28/135 18 WATER - - - 1 20% NOTE 1

33 20''-FH-A6N-4044 20 FH A6N 4 044 2014-4843-01-0043 Flare scrubber

MBF-4320 Flare Boom G 0.96-2.61 0.1/2.5 - 45.2/55 12 -90/135 18 WATER - - - 14 & 13 20% NOTE 1

34 12''-FH-A1N-4047-2H1 12 FH A1N 4 047 2H1 2014-4825-01-0006 PSV 2902-3 12''-FH-A1N-4048-2H1 G 5.6-20.2 0.1/2.5 40.98/85.6 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

35 12''-FH-A1N-4048-2H1 12 FH A1N 4048 2H1 2014-4825-01-0006

2014-4843-01-0041 PSV 2902-4 20''-FH-A1N-4000-2H1 G 5.6-20.2 0.1/2.5 40.98/85.6 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

36 10''-FH-A6N-4049-2P1 10 FH A6N 4049 2P1 2014-4897-01-0058 WHP-C-10''-FH-A6N-4233-2P1 ST- PIP-10''-FH-A6N-4001-2P1 G 0.96-20.25 0.1/2.5 -89.7/80 12 -90/135 18 WATER PP 38 - 4 20% NOTE 1

37 3''-FH-A1N-4051 3 FH A1N 4 051 2014-4857-01-0025

2014-4857-01-0028

FuelGas Package

(TP 0025-06) 6''-FH-A1N-4026 G HOLD H OLD HOLD 12 -28/135 18 WATER - - - HOLD 20% NOTE 1

38 10''-FH-A1N-4054-2H1 10 FH A1N 4054 2H1 2014-4825-01-0006

2014-4843-01-0041 PSV 2902-1 20''-FH-A1N-4000-2H1 G 0.89-2.9 0.1/2.5 36.8/81.46 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

39 6''-FH-A1N-4057-2H1 6 FH A1N 4 05 7 2H1 2014-4825-01-0006

2014-4843-01-0041 3''-PF-D1N-1322-2H1 20"-FH-A1N-4000-2H1 G 5.58-20.25 0.1/2.5 -8.5/55 12 -90/135 18 WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

40 2''-FH-A6N-4058 2 FH A6N 4 058 2014-4826-01-0012

2014-4843-01-0041 2''-PG-G6N-1181-2P1 12''-FH-A6N-4088-2P1 G 0.82-2.6 0 .1/2.5 -38.1/55 12 -90/135 18 WATER - - - 14 20% NOTE 1

41 2''-FH-A6N-4059 2 FH A6N 4 059 2014-4826-01-0012

2014-4843-01-0041 2''-PG-L6N-1182-2P1 12''-FH-A6N-4088-2P1 G 0.82-2.6 0 .1/2.5 -83.6/72 12 -90/135 18 WATER - - - 14 20% NOTE 1

G

TCT

08-12-15

BY

DATE

E

TMH

21-08-15


F

TMH

DOCUMENT NO. 2014-4800-9U-0001

01-10-15

REV.



8/33

D

TMH

03-06-15

FH:HIGH PRESSURE FLARE

NO. LINE NUMBERSIZE

(Inch)SERV

PIPING


DENSITY

Kg/m3

OP PRESS.

BargOP TEMP C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness (mm)

Tracing

Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


G

TCT

08-12-15

BY

DATE

E

TMH

21-08-15


F

TMH

DOCUMENT NO. 2014-4800-9U-0001

01-10-15

REV.

42 6''-FH-A1N-4060 6 FH A1N 4 060 2014-4843-01-0041

2014-4849-01-0063 PSV-4906-1A 20''-FH-A1N-4087-2H1 G 1007 0.1/2.5 20/30 12 -28/135 18 WATER - - - 1 20% NOTE 1

43 6''-FH-A1N-4061 6 FH A1N 4061 2014-4849-01-0063 PSV-4906-1B 6''-FH-A1N-4060 G 1007 0.1/2.5 20/30 12 -28/135 18 WATER - - - 1 20% NOTE 1

44 2''-FH-A6N-4064-2H1 2 FH A6N 4064 2H1 2 014-4828-01-0002-SH2 Depressurizing manifold 2''-FH-A6N-4071-2H1 G 116-139.1 0.1/2.5 -45.2/55 12 -90/135 18 WATER HC 25 Electric 14 20% NOTE 1 Maintain Temp = 30 C G

45 2''-FH-A6N-4068-2H1 2 FH A6N 4068 2 H1 2014-4828-01-0002-SH2 2''-PF-E12N-1311-2H1 2''-FH-A6N-4064-2H1 G 1-1.5 0.1/2.5 -20.5/55 12 -90/135 18 WATER HC 25 Electric 14 20% NOTE 1 Maintain Temp = 30 C G

46 2''-FH-A6N-4071-2H1 2 FH A6N 4071 2H1 2014-4828-01-0002-SH22014-4843-01-0043

2''-FH-A6N-4064-2H1 4''-PL-A6N-2070-2H1 G 1-1.5 0.1/2.5 - 20.5/55 12 -90/135 18 WATER HC 25 Electric 14 20% NOTE 1 Maintain Temp = 30 C G

47 2''-FH-A6N-4072 2 FH A6N 4 072 2014-4828-01-0005

2014-4843-01-0041 2''-PG-L6N-1186-2P1 12''-FH-A6N-4085-2P1 G 116-139.1 0.1/2.5 -89/55 12 -90/135 18 WATER - - - 14 20% NOTE 1

48 2''-FH-A6N-4073 2 FH A6N 4 073 2014-4828-01-0005

2014-4843-01-0041 Depressurizing manifold 16''-FH-A6N-4075-2P1 G 1-1.5 0.1/2.5 -89/55 12 -90/135 18 WATER - - - 14 20% NOTE 1

49 16''-FH-A6N-4075-2P1 16 FH A6N 4075 2P1 2014-4843-01-0041

2014-4843-01-0043 G 1-1.5 0.1/2.5 -45.2/55 1 2 - 90/135 18 WATER PP 38 - 14 20% NOTE 1 G

50 10''-FH-A1N-4077-2H1 10 FH A1N 4 077 2H1 2014-4825-01-0006 PSV 2902-2 10''-FH-A1N-4054-2H1 G 0.89-2.9 0.1/2.5 36.8/81.46 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

51 20''-FH-A6N-4080-2H1 2 0 F H A 6N 4 08 0 2 H1 2 01 4- 48 43 -0 1- 00 43 2 0' '- FH -A 1N -4 00 0- 2H 1 Flare Scrubber

MBF-4320 G 1-1.5 0.2/2.5 -45.2/55 12 -90/135 18 WATER HC 38 Electric 14 20% NOTE 1

52 8''-FH-A1N-4083 8 FH A1N 4083 2014-4843-01-0041 HP FLARE SUB-HEADER 20''-FH-A1N-4000-2H1 G 1.1 - 1007 0 .1/2.5 -3.3/80 12 -28/135 18 WATER - - - 1 20% NOTE 1

53 16''-FH-A1N-4084 16 FH A1N 4 084 2014-4843-01-0041 HP FLARE SUB-HEADER 20''-FH-A1N-4087-2H1 G 0.89-3.06 0 .1/2.5 20/55 12 -28/135 18 WATER - - - 1 20% NOTE 1

54 12''-FH-A6N-4085-2P1 12 FH A6N 4085 2P1 2014-4843-01-0041 HP FLARE SUB-HEADER 16''-FH-A6N-4075-2P1 G 0.96-1.5 0.1/2.5 -89/72 12 -90/135 18 WATER PP 38 - 14 20% NOTE 1 G

55 14''-FH-A1N-4086-2H1 14 FH A1N 4086 2H1 2014-4828-01-0002-SH1

2014-4843-01-0041 PSV 2955-1 16''-FH-A1N-4094-2H1 G 2.6-5 0.1/2.5 10/65 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

56 20''-FH-A1N-4087-2H1 20 FH A1N 4087 2H1 2014-4843-01-0041 HP FLARE SUB-HEADER 20''-FH-A1N-4000-2H1 G 2.6-5 0.1/2.5 10/65 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

57 12''-FH-A6N-4088-2P1 12 FH A6N 4088 2P1 2014-4843-01-0041 HP FLARESUB-HEADER 12''-FH-A6N-4085-2P1 G 0.96-1.5 0.1/2.5 -89/72 12 -90/135 18 WATER PP 38 - 14 20% NOTE 1 G

58 4''-FH-A1N-4090-2P1 4 FH A1N 4090 2P1 2014-4825-01-0006 4''-PG-E1N-1188-2P1 10''-FH-A1N-4011-2P1 G 0.9-2.9 0.1/2.5 30/82 12 -28/135 18 WATER PP 38 - 1 20% NOTE 1 G

59 2''-FH-A1N-4091-2H1 2 FH A1N 4091 2H1 2014-4843-01-0043

2014-4844-01-0044

PSV-4305A-1 3''-PL-A1N-2058-2H1 L 650-800 3.4 55/90 12 -28/135 18 WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

60 2''-FH-A1N-4092-2H1 2 FH A1N 4092 2H1 2014-4843-01-0043

2014-4844-01-0044 PSV-4305B-1 3''-PL-A1N-2058-2H1 L 650-800 3.4 55/90 12 -28/135 18 WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

61 3''-FH-A1N-4093 3 FH A1N 4093 2014-4826-01-0016 Compr. SealGas Treatment

System (2nd stage) 4''-FH-A1N-4096 G 1.1-3.4 0 .1/2.5 -3.3/80 12 -28/135 18 WATER - - - 1 20% NOTE 1

62 16''-FH-A1N-4094-2H1 16 FH A1N 4094 2H1 2014-4843-01-0041 14''-FH-A1N-4039-2H1 20''-FH-A1N-4000-2H1 G 2.6-5 0.1/2.5 10/120 12 -28/135 18 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

63 3''-FH-A1N-4095 3 FH A1N 4095 2014-4826-01-0016 Compressor SealGas System

(2nd stage) 4''-FH-A1N-4096 G 1.1-3.4 0 .1/2.5 -3.3/80 12 -28/135 18 WATER - - - 1 20% NOTE 1

64 4''-FH-A1N-4096 4 FH A1N 4 096 2014-4826-01-0016

2014-4843-01-0041 HP FLARE SUB-HEADER 16"-FH-A1N-4084 G 1.1-3.4 0.1/2.5 -3.3/80 12 -28/135 18 WATER - - - 1 20% NOTE 1 G

65 2''-FH-A1N-4097 2 FH A1N 4097 2014-4826-01-0016 Compressor SealGas System

(1st stage) 4''-FH-A1N-4096 G 1.1-3.4 0 .1/2.5 -3.3/80 12 -28/135 18 WATER - - - 1 20% NOTE 1

66 2''-FH-A6N-4098 2 FH A6N 4 098 2014-4843-01-0043 2''-FH-A1N-4043 Flare Tip G 0.96-2.61 0 .1/2.5 40/64 12 -28/100 18 WATER - - - 13 20% NOTE 1 Located on Flare Boom

67 1/2''-FH-A6-4099 1 /2 F H A6 4 09 9 2 01 4- 48 43 -0 1- 00 43 P ro pan e Bo ttl e Rac k Flare Ignition Package

(TP 0043-13) G 0.96-2.61 0.1/2.5 40 17 10/65 25.5 WATER - - - 40 20% NOTE 1 Company Scope

BLOWDOWN HEADER



9/33

D

TMH

03-06-15

PL: PROCESS LIQUID

NO. LINE NUMBER SIZE (Inch) SERVPIPING

SPEC.

SEQ.

NO.INSUL. P&ID No. From To FLUID

DENSITY

Kg/m3

OP PRESS.

BargOP TEMP C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST

PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness (mm)Tracing Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


1 8''-PL-D1N-2000-2H1 8 PL D 1N 2000 2H1 2014-4825-01-0006 LV 2902-1 12''-PF-D1N-1318-2H1 Mix 157.2-375.2 20/47.5 7 6.5/115.1 86 -3/130 129 WATER HC 38 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

2 8''-PL-E1N-2003-2H1 8 P L E1N 2003 2H1 2014-4825-01-0006 ProductionSeparator

MBD-2902 LV 2902-1 L 618.8-623.5 92.2 80/118 130 -28/130 195 WATER HC 38 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

3 4''-PL-A1N-2005-2H1 4 PL A1N 2005 2H1 2014-4843-01-0041

2014-4843-01-0043

HP Flare Condensate Collection

Header 4''-PL-A6N-2070-2H1 L 361.1-800 0.2/2.5 30/120 12 -28/135 18 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 30 C G

4 4''-PL-E1N-2006 4 PL E 1N 2006 2014-4826-01-0011

Gas reinjectioncompression

suctionscrubber (MBF-2606) LV 2606-3 L 528.9 89.8 50 130 -22/90 195 WATER - - - 1 100% NOTE 1

5 4''-PL-D1N-2007 4 PL D1N 2007 2014-4825-01-0006

2014-4826-01-0011LV 2606-3 8''-PG-D1N-1133-2H1 Mix 106.5-279.7 20/47.5 43.4 86 -3/120 129 WATER - - - 1 100% NOTE 1

6 4''-PL-E1N-2008 4 PL E1N 2008 2014-4826-01-0011 4''-PL-E1N-2006 4''-PL-D1N-2009 L 528.9 89.8 50 130 -22/90 195 W ATER - - - 1 100% NOTE 1

7 4''-PL-D1N-2009 4 PL D1N 2009 2014-4826-01-0011 4''-PL-E1N-2008 4''-PL-D1N-2007 Mix 1 06.5-279.7 20/47.5 43.4 86 -3/120 129 WATER - - - 1 100% NOTE 1

8 2''-PL-G1N-2010 2 PL G 1N 2010 2014-4826-01-0015 Gas reinjectioncompression

interstage scrubber (MBF-2616) LV 2616-3 L 997 254 50 360 -17/90 540 WATER - - - 1 100% NOTE 1

9 2''-PL-D1N-2011 2 PL D1N 2011 2014-4825-01-0006

2014-4826-01-0015LV 2616-3 4''-PL-D1N-2007 L 984.9-996.5 20/47.5 43.40 86 -3/120 129 WATER - - - 1 100% NOTE 1

10 2''-PL-G1N-2012 2 PL G1N 2012 2014-4826-01-0015 2''-PL-G1N-2010 2''-PL-D1N-2013 L 997 254 50 360 -17/90 540 WATER - - - 1 100% NOTE 1

11 2''-PL-D1N-2013 2 PL D1N 2013 2014-4826-01-0015 2''-PL-G1N-2012 2''-PL-D1N-2011 L 984.9-996.5 20/47.5 43.40 86 -3/120 129 WATER - - - 1 100% NOTE 1

12 2''-PL-D1N-2016 2 PL D1N 2016 2014-4825-01-0006

2014-4857-01-0025

FuelGas Package

(TP 0025-05)8''-PL-D1N-2000-2H1 L 403.1-658.6 20/47.5 25/47 86 -3/100 129 WATER - - - 1 100% NOTE 1

13 2''-PL-A1N-2027 2 PL A1N 2027 2014-4857-01-0026

2014-4843-01-0041

FuelGas Package

(TP 0026-01) 4''-PL-A1N-2005-2H1 L 612.5-657.6 0.2/2.5 25/47 12 -3/100 18 WATER - - - 1 20% NOTE 1

14 3''-PL-A1N-2036-2H1 3 P L A1N 2036 2H1 2014-4844-01-0042 Closed DrainVessel

MBF-61353''-PL-A1N-2038-2H1 L 650-800 0.1/0.3 55/85 7 -28.2/110 10.5 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

15 3''-PL-A1N-2037-2H1 3 P L A 1N 2 0 37 2 H1 2 01 4- 48 44 -0 1- 00 42 3 '' -P L- A1 N- 20 36 -2 H1 Closed DrainPump A

PBE-6140AL 650-800 0.1/0.3 55/85 7 -28.2/110 10.5 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

16 3''-PL-A1N-2038-2H1 3 P L A 1N 2 0 38 2 H1 2 01 4- 48 44 -0 1- 00 42 3 '' -P L- A1 N- 20 36 -2 H1 Closed DrainPump B

PBE-6140BL 650-800 0.1/0.3 55/85 7 -28.2/110 10.5 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

17 2''-PL-A1N-2039-2H1 2 P L A1N 2039 2H1 2014-4844-01-0042 Closed DrainPump A

PBE-6140A2''-PL-A1N-2044-2H1 L 650-800 3.2 55/85 7 -28.2/110 1 0.5 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

18 2''-PL-A1N-2040-2H1 2 P L A1N 2040 2H1 2014-4844-01-0042 Closed DrainPump B

PBE-6140B2''-PL-A1N-2044-2H1 L 650-800 3.2 55/85 7 -28.2/110 1 0.5 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

19 2''-PL-A1N-2044-2H1 2 PL A1N 2044 2H1 2014-4844-01-00422014-4843-01-0043

2''-PL-A1N-2039-2H1 4''-PL-A1N-2005-2H1 L 650-800 3.2 55/85 12 -28.2/110 18 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 30 C G

20 4''-PL-A1N-2045-2H1 4 PL A1N 2045 2H1 2014-4843-01-0043

2014-4844-01-0044 SDV-4320-1

Flare Booster Pump B

PBE-4315B L 650-800 0.2/2.5 55/90 12 10/135 18 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

21 4''-PL-A1N-2046-2H1 4 P L A 1N 2 0 46 2 H1 2 01 4- 48 44 -0 1- 00 44 4 '' -P L- A1 N- 20 45 -2 H1 Flare Booster Pump A

PBE-4315A L 650-800 0.2/2.5 55/90 12 10/135 18 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

22 3''-PL-A1N-2047-2H1 3 P L A1N 2047 2H1 2014-4844-01-0044 Flare Booster Pump A

PBE-4315A 3''-PL-A1N-2058-2H1 L 650-800 3.4 55/90 12 10/135 18 WATER HC 25 Electric 2 20% NOTE 1

MaintainTemp tillisolation

valve = 55 C

MaintainTemp after

isolationvalve = 30 C

G

23 3''-PL-D1N-2049-2H1 3 P L D1N 2049 2H1 2014-4844-01-0044 Flare Scrubber Pump B

PBE-4305B 3''-PL-D1N-2053-2H1 L 650-800 20/47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

24 3''-PL-A1N-2050-2H1 3 P L A1N 2050 2H1 2014-4844-01-0044 Flare Booster Pump B

PBE-4315B 3''-PL-A1N-2047-2H1 L 650-800 3.4 55/90 12 10/135 18 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

25 3''-PL-D1N-2051-2H1 3 P L D 1N 2 0 51 2 H1 2 01 4- 48 44 -0 1- 00 44 3 '' -P L- A1 N- 20 50 -2 H1 Flare Scrubber Pump B

PBE-4305B L 650-800 3.4 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

26 3''-PL-D1N-2053-2H1 3 P L D1N 2053 2H1 2014-4844-01-0044 Flare Scrubber Pump A

PBE-4305A SDV 4305B-1 L 650-800 20/47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

27 3''-PL-D1N-2054-2H1 3 P L D 1N 2 0 54 2 H1 2 01 4- 48 44 -0 1- 00 44 3 '' -P L- A1 N- 20 47 -2 H1 Flare Scrubber Pump A

PBE-4305A L 650-800 3.4 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

28 3''-PL-D1N-2055-2H1 3 PL D1N 2055 2H1 2014-4825-01-0006

2014-4844-01-0044 3''-PL-D1N-2049-2H1 12''-PF-D1N-1318-2H1 L 650-800 20/47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1

MaintainTemp = 30 C

(After CP-4305-2) G

29 3''-PL-D1N-2056-2H1 3 PL D 1N 2056 2H1 2014-4844-01-0044 3''-PL-D1N-2049-2H1 3''-PL-A1N-2058-2H1 L 650-800 20/47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

30 3''-PL-D1N-2057-2H1 3 PL D 1N 2057 2H1 2014-4844-01-0044 3''-PL-D1N-2053-2H1 3''-PL-A1N-2058-2H1 L 650-800 20/47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

31 3''-PL-A1N-2058-2H1 3 PL A1N 2058 2H1 2014-4844-01-0044 3"-PL-D1N-2057-2H1 4''-PL-A1N-2005-2H1 L 650-800 2.5 55/90 12 -28/135 18 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 30 C

(After isolationvalves) G

32 4''-PL-A6N-2070-2P1 4 P L A 6N 2 07 0 2 P1 2 01 4- 48 43 -0 1- 00 43 4 '' -P L- A1 N- 20 05 -2 H1 Flare Scrubber

MBF-4320L 361.1-800 0 .2/2.5 30/120 12 -90/135 18 WATER PP 25 - 4 20% NOTE 1 G

33 2''-PL-A1N-2071-2H1 2 PL A 1N 2071 2H1 2014-4844-01-0042 2''-PL-A1N-2040-2H1 PSV 6140B-1 L 650-800 3.2 55/85 7 -28.2/110 10.5 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

34 2''-PL-A1N-2072-2H1 2 PL A 1N 2072 2H1 2014-4844-01-0042 2''-PL-A1N-2039-2H1 PSV 6140A-1 L 650-800 3.2 55/85 7 -28.2/110 10.5 WATER HC 25 Electric 2 20% NOTE 1 MaintainTemp = 55 C G

35 4''-PL-A6N-2074-2H1 4 P L A6N 2074 2H1 2014-4843-01-0043 Flare Scrubber

MBF-4320SDV 4320-1 L 650-800 0.2/2.5 -45.2/55 12 -90/135 18 WATER HC 25 Electric 14 20% NOTE 1

36 2''-PL-D1N-2076-2H1 2 P L D1N 2076 2H1 2014-4844-01-0044 Flare scrubber Pump B

PBE-4305BPSV-4305B-1 L 650-800 47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

37 2''-PL-D1N-2077-2H1 2 PL D 1N 2077 2H1 2014-4844-01-0044 2''-PL-D1N-2076-2H1 2''-FH-A1N-4092-2H1 L 650-800 47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

38 2''-PL-D1N-2078-2H1 2 P L D1N 2078 2H1 2014-4844-01-0044 Flare scrubber Pump A

PBE-4305APSV-4305A-1 L 650-800 47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

39 2''-PL-D1N-2079-2H1 2 PL D 1N 2079 2H1 2014-4844-01-0044 2''-PL-D1N-2078-2H1 2''-FH-A1N-4091-2H1 L 650-800 47.5 55/90 86 10/135 129 WATER HC 25 Electric 2 100% NOTE 1 MaintainTemp = 55 C G

40 6''-PL-E1N-2080-2H1 6 PL E1N 2080 2H1 2014-4825-01-0006 8''-PL-E1N-2003-2H1 8''-PL-D1N-2000-2H1 L 618.8-623.5 92.2 80/118 130 -3/130 195 WATER HC 25 Electric 2 100% NOTE 1

REV.

01-10-15


E

TMH

21-08-15

DOCUMENT NO. 2014-4800-9U-0001

TCT

08-12-15

G

BY

DATE

F

TMH



10/33

D

TMH

03-06-15

FG:FUEL GAS

NO. LINE NUMBER SIZE

(Inch)SERV

PIPING


DENSITY

Kg/m3

OP PRESS.

Barg

OP TEMP

C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness (mm)

Tracing

Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


1 3''-FG-E1N-3300-2P1 3 FG E1N 3300 2P1 2014- 4857- 01- 0025 FuelGas Precooler

HAL-5746

FuelGas Package

(TP 0025-01) G 87.1 - 99.3 9 1.0 69.0 130 -3/130 195 WATER PP 25 - 2 100% NOTE 1

2 3''-FG-B1N-3310-2H1 3 FG B1N 3310 2H1 2014-4857-01-0028

2014-4870-01-0057

FuelGas Package

(TP 0028-02) 2''-FG-B1N-3353-2H1 G 24 - 24.4 30 55/77 39.6 -3/100 59.4 WATER HC 25 Electric 2 100% NOTE 1 Maintain Temp = 77 C G

3 3''-FG-B1N-3311-2H1 3 FG B1N 3311 2H1 2014-4826-01-0016

2014-4857-01-0028 3 ''-FG-B1N-3309-2H1 Compressor Turbine Train 1 G 24 - 24.4 30 55/77 39.6 -3/100 59.4 WATER HC 25 Electric 2 100% NOTE 1 Maintain Temp = 77 C G

4 3''-FG-B1N-3314-2H1 3 FG B1N 3314 2H1 2014-4870-01-0057 3''-FG-B1N-3310-2H1 2''-FG-B1N-3352-2H1 G 24 - 24.4 30 55/77 39.6 -3/100 59.4 WATER HC 25 Electric 2 100% NOTE 1 Maintain Temp = 77 C G

5 2''-FG-B1N-3315-2H1 2 F G B 1N 3 31 5 2 H1 2 01 4- 48 70 -0 1- 00 57 2 '' -F G- B1 N- 33 53 -2 H1 Gas Turbine Generator BZZZ-7106B (TP 0057-15)

G 24 - 24.4 30 55/77 39.6 -3/100 59.4 WATER HC 25 Electric 2 100% NOTE 1 Maintain Temp = 77 C G

6 2''-FG-B1N-3316-2H1 2 F G B 1N 3 31 6 2 H1 2 01 4- 48 70 -0 1- 00 57 2 '' -F G- B1 N- 33 52 -2 H1 Gas Turbine Generator A

ZZZ-7106A (TP 0057-06) G 24 - 24.4 30 55/77 39.6 -3/100 59.4 WATER HC 25 Electric 2 100% NOTE 1 Maintain Temp = 77 C G

7 2''-FG-A1N-3317-2H1 2 FG A1N 3317 2H1 2014-4857-01-0028

2014-4843-01-0043 3''-FG-A1N-3336-2H1 PCV 4346-1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 82 C G

8 2''-FG-A1N-3318-2P1 2 FG A1N 3318 2P1 2014-4857-01-0028

2014-4843-01-0041 3' ' -FG-A1N-3336-2H1 1' '-FG-A1N-3332-2P1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G

9 2''-FG-A1N-3319-2P1 2 FG A1N 3319 2P1 2014-4857-01-0028

2014-4844-01-0040 3''-FG-A1N-3336-2H1 1''-FG-A1N-3345-2P1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G

10 2''-FG-A1N-3320 2 FG A1N 3 320 2014-4857-01-0028

2014-4897-01-0058 3''-FG-A1N-3336-2H1 WHP-C G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER - - - 1 20% NOTE 1

11 3''-FG-B1N-3331-2P1 3 FG B1N 3331 2P1 2 01 4- 485 7- 01 -00 28 3 ''- FG -B1 N- 33 10- 2H1 3 '' -F G- A1 N- 33 36- 2H1 G 2 4 - 2 4. 4 3 0 5 5/ 77 3 9. 6 - 3/ 10 0 5 9. 4 WA TE R PP 25 - 2 100% NOTE 1 G

12 1''-FG-A1N-3332-2P1 1 FG A1N 3332 2P1 2014-4843-01-0041 2''-FG-A1N-3318-2P1 1"-FG-A1N-3333/3334/3348-2P1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G

13 1''-FG-A1N-3333-2P1 1 FG A1N 3333 2P1 2014-4843-01-0041 1''-FG-A1N-3332-2P1 20''-FH-A1N-4000-2H1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G

14 1''-FG-A1N-3334-2P1 1 FG A1N 3334 2P1 2014-4843-01-0041 1''-FG-A1N-3332-2P1 16''-FH-A6N-4075-2P1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G

15 4''-FG-A1N-3335-2P1 4 FG A1N 3335 2P1 2014-4857-01-0028 4''-FG-A1N-3344-2P1 PSV 5726-1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1

16 3''-FG-A1N-3336-2H1 3 FG A1N 3 336 2 H1 2014-4857-01-0028 3''-FG-B1N-3331-2H1 2''-FG-A1N-3317-2H1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 82 C G

17 2''-FG-A1N-3339 2 FG A1N 3339 2014-4897-01-0058 ST-PIP-2''-FG-A1N-3320 WHP-C-2"-FG-A1N-3325 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER - - - 1 20% NOTE 1

18 2''-FG-A1N-3342-2H1 2 FG A1N 3342 2H1 2014-4825-01-0006

2014-4857-01-0028PCV 2902-1 3''-FG-A1N-3336-2H1 G 4.45-4.71 4.5 3 8.5/82.6 7 -3/100 10.5 WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 82 C G

19 4''-FG-A1N-3344-2P1 4 FG A1N 3344 2P1 2014-4857-01-0028 3''-FG-A1N-3336-2H1 PSV 5726-2 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1

20 1''-FG-A1N-3345-2P1 1 FG A1N 3345 2P1 2014-4844-01-0040 2''-FG-A1N-3319-2P1 6''-FL-A1N-4200 G 1.2-1.9 0.1/0.3 3 7/38 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G

21 1''-FG-A1N-3348-2P1 1 FG A1N 3348 2P1 2014-4843-01-0041 1''-FG-A1N-3332-2P1 20''-FH-A1N-4087-2H1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G

22 3''-FG-B1N-3349-2P1 3 FG B1N 3349 2P1 2014-4857-01-0028 3''-FG-B1N-3331-2P1 3''-FG-A1N-3350-2P1 G 24 - 24.4 30 55/77 39.6 -3/100 59.4 WATER PP 25 - 2 100% NOTE 1 G

23 3''-FG-A1N-3350-2P1 3 FG A1N 3350 2P1 2014-4857-01-0028 3''-FG-B1N-3349-2P1 3''-FG-A1N-3336-2H1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G

24 1''-FG-A1N-3351-2P1 1 FG A1N 3351 2P1 2014-4844-01-00402014-4843-01-0041

2''-FG-A1N-3319-2P1 12''-FH-A6N-4088-2P1 G 3.81-4.0 4 40/64 7 -3/100 10.5 WATER PP 25 - 2 20% NOTE 1 G



TMH

01-10-15


DOCUMENT NO. 2014-4800-9U-0001

G

TCT

08-12-15

E

TMH

21-08-15

REV.

BY

DATE

F



11/33

D

TMH

03-06-15

DO: OPEN DRAIN

N O. L INE N UM BE R SIZE

(Inch)SERV

PIPING

SPEC.

SEQ.


DENSITY

Kg/m3

OP

PRESS.

Barg

OP TEMP

C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST

PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness

(mm)

Tracing

Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


1 2''-DO-A1-5700 2 DO A1 5 700 2014-4827-01-0004

2014-4862-01-0051

MPFM

ZAU-2706 6''-DO-A8-5754 L 800-1000 ATM AMB 3.5 10/65 5.25 WATER - - - 1 20% NOTE 1

2 4''-DO-A1-5702 4 DO A1 5702 2014-4826-01-0010 Drip pan 4''-DO-A1-5703 L 8 00-1000 ATM AMB 3.5 10/65 5.25 W ATER - - - 1 20% NOTE 1

3 4''-DO-A1-5703 4 DO A1 5 703 2014-4826-01-0010

2014-4862-01-0051 4''-DO-A1-5702 6''-DO-A8-5759 L 8 00-1000 ATM AMB 3.5 10/65 5.25 W ATER - - - 1 20% NOTE 1


5 4''-DO-A1-5705 4 DO A1 5 705 2014-4826-01-00112014-4862-01-0051 4''-DO-A1-5704 6''-DO-A8-5759 L 8 00-1000 ATM AMB 3.5 10/65 5.25 W ATER - - - 1 20% NOTE 1

6 4''-DO-A1-5706 4 DO A1 5706 2014-4826-01-0012 Drip pan 4''-DO-A1-5707 L 8 00-1000 ATM AMB 3.5 10/65 5.25 W ATER - - - 1 20% NOTE 1 G

7 4''-DO-A1-5707 4 DO A1 5 707 2014-4826-01-0012

2014-4862-01-0051 4"DO-A1-5706 8''-DO-A8-5751 L 800-1000 ATM AMB 3.5 10/65 5.25 WATER - - - 1 20% NOTE 1

8 1''-DO-A1-5710 1 DO A1 5710 2014-4870-01-0057 Gas turbine Generator

package B4''-DO-A1-5711 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

9 4''-DO-A1-5711 4 DO A1 5 711 2014-4862-01-0051

2014-4870-01-0057 1''-DO-A1-5710 6''-DO-A8-5759 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1


11 4''-DO-A1-5714 4 DO A1 5 714 2014-4826-01-0014

2014-4862-01-0051 4''-DO-A1-5712 6''-DO-A8-5759 L 8 00-1000 ATM AMB 3.5 10/65 5.25 W ATER - - - 1 20% NOTE 1

12 2''-DO-A1-5717 2 DO A1 5 717 2014-4826-01-0016

2014-4862-01-0051

Compressor turbine

Open Drain Sub-Header8''-DO-A8-5751 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

13 3''-DO-A6N-5719-2H1 3 DO A6N 5 71 9 2H1 20 14-4 84 3-01 -00 43 Flare scrubber

MBF-4320 3''-DO-A6N-5792-2H1 L 650-800 0.2/2.5 -45.2/55 12 -90/135 18 WATER HC 25 Electric 14 20% NOTE 1


MBF-4320 3''-DO-A6N-5792-2H1 L 650-800 0.2/2.5 -45.2/55 12 -90/135 18 WATER HC 25 Electric 14 20% NOTE 1 Maintain Temp = 30 C G

15 3''-DO-A1N-5721-2H1 3 DO A1N 5721 2H1 2014-4843-01-0043

2014-4862-01-0054 3"DO-A1N-5720-2H1 3''-DO-A2-5769-2H1 L 650-800 0 .2/2.5 AMB/55 3.5 10/65 FOW WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

16 4''-DO-A8-5722 4 DO A8 5 722 2014-4843-01-0043

2014-4862-01-0051 Drip pan 4''-DO-A8-5757 L 349.8-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

17 4''-DO-A8-5723 4 DO A8 5 723 2014-4844-01-0044

2014-4862-01-0051 Drip pan 4''-DO-A8-5757 L 349.8-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

18 1''-DO-A1-5724 1 DO A1 5724 2014-4852-01-0003 WHCP

TP 0003-02 4''-DO-A8-5725 L 1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

19 4''-DO-A8-5725 4 DO A8 5 725 2014-4852-01-0003

2014-4862-01-0051 1''-DO-A1-5724 6''-DO-A8-5754 L 1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

20 3''-DO-A1N-5726-2H1 3 DO A1N 5726 2H1 2014-4844-01-0042

2014-4862-01-0054

Closed Drain Vessel

MBF-6135 3''-DO-A2-5769-2H1 L 650-800 0.1/0.3 55/85 7 -28.2/110 FOW W ATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

21 4''-DO-A8-5727 4 DO A8 5 727 2014-4844-01-0042

2014-4862-01-0051

Closed Drain Vessel

MBF-6135 4''-DO-A8-5757 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

22 4''-DO-A8-5728 4 DO A8 5728 2014-4860-01-0050Non Hazardous Open drain

header

(Main deck, MDD-05)

6''-DO-A8-5731 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

23 2''-DO-A8-5729 2 DO A8 5729 2014-4849-01-0063 16''-WC-A8-8163 3''-DO-A8-5730 L 800-1000 ATM AMB 15 10/80 22.5 WATER - - - NONE N/A NOTE 1

24 3''-DO-A8-5730 3 DO A8 5 730 2014-4849-01-0063/

2014-4862-01-0051

Drip Pain/

2''-DO-A8-5729 6''-DO-A8-5731 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

25 6''-DO-A8-5731 6 DO A8 5731 2014-4860-01-0050 Non Hazardous Open drain

header (Main deck) 6''-DO-A8-5736 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

26 4''-DO-A8-5732 4 DO A8 5 732 2014-4862-01-0051 Hazardous Open drain sub-

header (Inter deck) 4''-DO-A8-5737 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

27 3''-DO-A8-5733 3 DO A8 5 733 2014-4862-01-0051Hazardous Open drain

header

(Inter deck, IDD-13)

4''-DO-A8-5732 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

28 4''-DO-A8-5735 4 DO A8 5 735 2014-4860-01-0050

2014-4862-01-0054

Non Hazardous Open drain

header (Cellar deck) 6''-DO-A8-5736 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

29 6''-DO-A8-5736 6 DO A8 5 736

2014-4860-01-0050

2014-4862-01-0054 6''-DO-A8-5731 6''-DO-A2-5767 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

30 4''-DO-A8-5737 4 DO A8 5 737 2014-4862-01-0051 4''-DO-A8-5732 6''-DO-A8-5759 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

31 3''-DO-A8-5738 3 DO A8 5738 2014-4862-01-0051 For Transformers IDD-12 6''-DO-A8-5759 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

32 3''-DO-A8-5740 3 DO A8 5 740 2014-4862-01-0051 IDD-20 4''-DO-A8-5748 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

33 2''-DO-A8-5741 2 DO A8 5741 2014-4849-01-0065 12''-WC-A8-8170 Drip pan L 800-1000 ATM AMB 3.5 10/65 FOW W ATER - - - NONE N/A NOTE 1Till last isolation valve

VB06507:DP = 15 barg; TP

= 15*1.5 = 22.5 barg

34 2''-DO-A8-5742 2 DO A8 5742 2014-4849-01-0065 14''-WS-A8-2311 Drip pan L 800-1000 ATM AMB 3.5 10/65 FOW W ATER - - - NONE N/A NOTE 1Till last isolation valve


= 15*1.5 = 22.5 barg


36 2''-DO-A8-5744 2 DO A8 5 744 2014-4862-01-0051


37 2''-DO-A8-5745 2 DO A8 5745 2014-4849-01-0064 Cooling water trim filter B

MAJ-4930B

Nearest hazardous open drain

funnel L 800-1000 ATM AMB 3.5 10/65 F OW WATER - - - NONE N/A NOTE 1

Till last isolation valve


= 15*1.5 = 22.5 barg

38 2''-DO-A8-5746 2 DO A8 5746 2014-4849-01-0064 Cooling water trim filter A

MAJ-4930A


funnel L 800-1000 ATM AMB 3.5 10/65 F OW WATER - - - NONE N/A NOTE 1

Till last isolation valve


= 15*1.5 = 22.5 barg

DOCUMENT NO. 2014-4800-9U-0001

F

TMH

G

TCT

08-12-1501-10-15

REV.

BY

DATE

E

TMH

21-08-15




12/33

D

TMH

03-06-15

DO: OPEN DRAIN


(Inch)SERV

PIPING

SPEC.

SEQ.


DENSITY

Kg/m3

OP

PRESS.

Barg

OP TEMP

C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST

PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness

(mm)

Tracing

Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


DOCUMENT NO. 2014-4800-9U-0001

F

TMH

G

TCT

08-12-1501-10-15

REV.

BY

DATE

E

TMH

21-08-15


39 2''-DO-A8-5747 2 DO A8 5 747 2014-4862-01-0051

2014-4849-01-0064

Drip pan & hazardous open

drain funnel 6''-DO-A8-5754 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1




43 8''-DO-A8-5751 8 DO A8 5751 2014-4862-01-0051 Hazardous open drain


44 8''-DO-A8-5752 8 DO A8 5 752 2014-4862-01-0051

2014-4862-01-0053 8''-DO-A8-5751

Hazardous Open Drain Tank

ABJ-6201 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

45 4''-DO-A8-5753 4 DO A8 5 753 2014-4862-01-0051 Cellar deck hazardous 6''-DO-A8-5754 L 800-1000 A TM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1


header (Cellar deck) 6''-DO-A8-5755 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

47 6''-DO-A8-5755 6 DO A8 5 755 2014-4862-01-0051


48 3''-DO-A8-5756 3 DO A8 5756 2014-4862-01-0051 Hazardous open drain tank

bunding 4''-DO-A8-5757 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

49 4''-DO-A8-5757 4 DO A8 5 757 2014-4862-01-0051

2014-4862-01-0054

Hazardous open drain

header

-

10''-DO-A2-5768-2H1 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G


header6"-DO-A8-5760 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

51 6''-DO-A8-5760 6 DO A8 5 760 2014-4862-01-0051


52 2''-DO-A1-5761 2 DO A1 5761 2014-4862-01-0053 Hazardous Open Drain

Tank

-

10''-DO-A1-5764 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

53 3''-DO-A1-5762 3 DO A1 5762 2014-4862-01-0053 Hazardous Open Drain

Tank

-


54 3''-DO-A1-5763-2H1 3 DO A1 5763 2 H1 2014-4862-01-0053

2014-4862-01-0054

Hazardous Open Drain

Tank

-

3"-DO-A2-5863-2H1 L 800-1000 ATM A MB 3.5 10/65 FOW WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

55 10''-DO-A1-5764 10 DO A1 5764 2014-4862-01-0053

2014-4862-01-0054

Hazardous Open Drain

Tank

-

10''-DO-A2-5768-2H1 L 800-1000 ATM A MB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

56 6''-DO-A2-5767 6 DO A2 5767 2014-4862-01-0054 Non hazardous open drain

header (MD & ID deck)

Open Drain Caisson

ABH-6202 L 800-1000 ATM AMB 3.5 10/65 5.25 WATER - - - 1 20% NOTE 1

57 10''-DO-A2-5768-2H1 10 DO A2 5 76 8 2H1 20 14-4 86 2-01 -00 54 Hazardous open drain

header

-

Open Drain Caisson

ABH-6202 L 800-1000 ATM AMB 3.5 10/65 5.25 WATER HC 38 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

58 3''-DO-A2-5769-2H1 3 D O A 2 5 76 9 2 H1 2 01 4- 48 62 -0 1- 00 54 3 '' -D O- A1 N- 57 21 -2 H1 Open Drain Caisson

ABH-6202 L 800-1000 ATM AMB 3.5 10/65 5.25 WATER HC 25 Electric 2 20% NOTE 1 Maintain Temp = 30 C G

59 2''-DO-A1-5770 2 DO A1 5770 2014-4826-01-0016 Compressor turbine

(Oil Drain Drip Pan) 2''-DO-A1-5717 L 800-1000 ATM AMB 3.5 10/65 F OW WATER - - - 1 20% NOTE 1

60 1''-DO-A1-5771 1 DO A1 5771 2014-4826-01-0016

Compressor turbine

(Engine Exhaust Collector

& Combustor Drain)


61 1''-DO-A1-5772 1 DO A1 5 77 2 20 14-4 82 6-01 -00 16 Compressor turbine

(Oil Drain from Drip Pan) 2''-DO-A1-5717 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - 1 20% NOTE 1 G


(Engine Air Inlet Duct


funnel L 800-1000 ATM AMB 3.5 10/65 FOW WATER - 1 20% NOTE 1


(Lube Oil Tank Drain) Flexible hose L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

64 4''-DO-A8-5778 4 DO A8 5 778 2014-4862-01-0051 Cellar deck hazardous 6''-DO-A8-5754 L 800-1000 A TM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

65 2''-DO-A1-5780 2 DO A1 5780 2014-4862-01-0051 Chemical Tote Tank MDD-

20 2''-DO-A8-5788 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

66 1''-DO-A1-5783 1 DO A1 5783 2014-4870-01-0057 Gas Turbine Generator

Package A(TP 0057-34) 4''-DO-A1-5787 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1




Package B (TP 0057-44) 4''-DO-A1-5711 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

69 4''-DO-A8-5786 4 DO A8 5 786 2014-4844-01-0042

2014-4862-01-0051

Drip pan - Close drain

pump 4''-DO-A8-5757 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

70 4''-DO-A1-5787 4 DO A1 5 787 2014-4862-01-0051

2014-4870-01-0057 1''-DO-A1-5803 6''-DO-A8-5759 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

71 2''-DO-A8-5788 2 DO A8 5 788 2014-4857-01-0025

2014-4862-01-0051 Drip pan 6''-DO-A8-5759 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1


Package B (TP 0057-45) 4''-DO-A1-5711 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

73 2''-DO-A1-5791 2 DO A1 5 791 2014-4825-01-0006

2014-4862-01-0051 Drip pan 6''-DO-A8-5754 L 8 00-1000 ATM AMB 3.5 10/65 5.25 W ATER - - - 1 20% NOTE 1


MBF-4320 3''-DO-A1N-5721-2H1 L 800-1000 0.2/2.5 -45.2/55 12 -90/135 18 WATER HC 25 Electric 14 20% NOTE 1 Maintain Temp = 30 C G

75 4''-DO-A8-5795 4 DO A8 5 795 2014-4842-01-0032

2014-4862-01-0051

Hypochlorite Generator

Package (TP 0032-04) 6''-DO-A8-5754 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

76 4''-DO-A8-5796 4 DO A8 5 796 2014-4844-01-0044


77 2''-DO-A8-5798 2 DO A8 5 798 2014-4862-01-0051


78 4''-DO-A8-5799 4 DO A8 5 799 2014-4857-01-0028

2014-4862-01-0051

Fuel Gas Skid Drip Pan

(TP 0028-05) 6''-DO-A8-5759 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1





13/33

D

TMH

03-06-15

DO: OPEN DRAIN


(Inch)SERV

PIPING

SPEC.

SEQ.


DENSITY

Kg/m3

OP

PRESS.

Barg

OP TEMP

C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST

PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness

(mm)

Tracing

Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


DOCUMENT NO. 2014-4800-9U-0001

F

TMH

G

TCT

08-12-1501-10-15

REV.

BY

DATE

E

TMH

21-08-15


80 2''-DO-A8-5804 2 DO A8 5 804 2014-4844-01-0040

2014-4862-01-0051 2''-DO-A1-5805 8''-DO-A8-5751 L 800 - 1000 ATM AMB 3.5 10/65 5.25 WATER - - - NONE N/A NOTE 1

81 2''-DO-A1-5805 2 DO A1 5805 2014-4844-01-0040 ST-PIP Crane 2''-DO-A8-5804 L 800 - 1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

82 2''-DO-A1-5806 2 DO A1 5806 2014-4862-01-0051 HVAC System 6''-DO-A8-5759 L 800 - 1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1

83 2''-DO-A8-5808 2 DO A8 5 808 2014-4842-01-0032

2014-4862-01-0051

SafetyShower Station SS-

01 8"-DO-A8-5751 L 1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

84 2''-DO-A8-5809 2 DO A8 5 809 2014-4842-01-0032

2014-4860-01-0050

SafetyShower Station SS-

02 4''-DO-A8-5735 L 1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

85 1.5''-DO-A6-5810 1 1/2 DO A6 5810 2014-4842-01-0032 SafetyShower Station SS-

01 2''-DO-A8-5808 L 1000 ATM AMB 3.5 10/65 5.25 WATER - - - 14 20% NOTE 1

86 1.5''-DO-A6-5811 1 1/2 DO A6 5811 2014-4842-01-0032 SafetyShower Station SS-

02 2''-DO-A8-5809 L 1000 ATM AMB 3.5 10/65 5.25 WATER - - - 14 20% NOTE 1

87 4''-DO-A8-5812 4 DO A 8 5812 2014-4860-01-0050 MDD-18 6"-DO-A8-5731 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

88 4''-DO-A8-5813 4 DO A8 5 813 2014-4862-01-0051 MDD-01 4''-DO-A8-5814 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

89 4''-DO-A8-5814 4 DO A8 5 814 2014-4862-01-0051 MDD-13 8"-DO-A8-5751 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G


91 4''-DO-A8-5816 4 DO A8 5816 2014-4860-01-0050 M DD- 03 6 "- DO -A8 -5 73 1 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G


93 4''-DO-A8-5818 4 DO A8 5818 2014-4860-01-0050 MDD-04 4''-DO-A8-5728 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

94 4''-DO-A8-5819 4 DO A8 5 819 2014-4862-01-0051 Hatch Cover Drain-02 4''-DO-A8-5821 L 800-1000 ATM A MB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

95 4''-DO-A8-5820 4 DO A8 5 820 2014-4862-01-0051 Hatch Cover Drain-03 4''-DO-A8-5821 L 800-1000 ATM A MB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

96 4''-DO-A8-5821 4 DO A8 5 821 2014-4862-01-0051 Hatch Cover Drain-01 8"-DO-A8-5751 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G






102 4''-DO-A8-5827 4 DO A8 5 827 2014-4862-01-0051 MDD-08 4''-DO-A8-5826 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G




106 6''-DO-A8-5832 6 DO A8 5832 2014-4860-01-0050 Non Hazardous Open drain




109 3''-DO-A8-5836 3 DO A8 5836 2014-4862-01-0051 IDD-07 4''-DO-A8-5732 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G









14/33

D

TMH

03-06-15

DO: OPEN DRAIN


(Inch)SERV

PIPING

SPEC.

SEQ.


DENSITY

Kg/m3

OP

PRESS.

Barg

OP TEMP

C

DESIGN

PRESS Barg

DESIGN

TEMP C

TEST

PRESS

Barg

TEST

MEDIUM

Insulation

Type

Insulation

Thickness

(mm)

Tracing

Type

PAINTING

SYSTEM

POST WELD

HEAT

TREATMENT

NDT

Requirement

STRESS


DOCUMENT NO. 2014-4800-9U-0001

F

TMH

G

TCT

08-12-1501-10-15

REV.

BY

DATE

E

TMH

21-08-15









123 2''-DO-A1-5851 2 DO A1 5851 2014-4826-01-0010 Strainer 4"-DO-A1-5703 L 800-1000 ATM AMB 3.5 10/65 F OW WATER - - - 1 20% NOTE 1 G

124 2''-DO-A1-5852 2 DO A1 5852 2014-4826-01-0014 Strainer 4"-DO-A1-5714 L 800-1000 ATM AMB 3.5 10/65 F OW WATER - - - 1 20% NOTE 1 G

125 4''-DO-A8-5853 4 DO A8 5853 2014-4862-01-0051 IDD-21 3"-DO-A8-5733 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G

126 4''-DO-A8-5854 4 DO A8 5854 2014-4862-01-0051 MDD-23 8"-DO-A8-5751 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1 G



129 3/4"-DO-A1-5857 3/4 DO A1 5 857 2014-4870-01-0057 OffSkid Liquid Fuel Filter

System B 4"-DO-A1-5711 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1 G

130 2''-DO-A1-5858 2 DO A1 5858 2014-4826-01-0016Compressor Seal Gas

Treatment System

(2nd Stage)

2"-DO-A1-5717 L 800-1000 ATM AMB 3.5 10/65 F OW WATER - - - 1 20% NOTE 1 G

131 1''-DO-A1-5859 1 DO A1 5859 2014-4826-01-0016Compressor Seal Gas

Treatment System

(1st Stage)

2"-DO-A1-5858 L 800-1000 ATM AMB 3.5 10/65 F OW WATER - - - 1 20% NOTE 1 G

132 1''-DO-A1-5860 1 DO A1 5 860 2014-4826-01-0012 Drip pan 4''-DO-A1-5707 L 800-1000 A TM AMB 3.5 10/65 5.25 WATER - - - 1 20% NOTE 1 Maintain Temp = 30 C G



135 3''-DO-A2-5863 3 DO A2 5863 2014-4862-01-0054 3"-DO-A1-5763-2H1 10"-DO-A2-5768-2H1 L 800-1000 ATM AMB 3.5 10/65 5.25 WATER - - - 1 20% NOTE 1 G

136 3/4"-DO-A1-5864 3/4 DO A1 5 864 2014-4870-01-0057 OffSkid Liquid Fuel Filter

System A 4"-DO-A1-5787 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1 G

137 2''-DO-A8-5877 2 DO A8 5877 2014-4980-05-0001 Firewater Pump Diesel

Enginer PDD-8010A CDD-04 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1

138 2''-DO-A8-5878 2 DO A8 5878 2014-4980-05-0002 Firewater Pump Diesel

Enginer PDD-8010B CDD-07 L 800-1000 ATM AMB 3.5 10/65 FOW WATER - - - NONE N/A NOTE 1


(LPT Drain from Lube Oil2''-DO-A1-5717 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1


(Lube Oil Filter Drain) 2 ''-DO-A1-5717 L 8 00-1000 ATM AMB 3.5 10/65 FOW WATER - - - 1 20% NOTE 1



15/33

D

TMH

03-06-15

DC: CLOSED DRAIN

NO. L INE NUM BE R SIZE

(Inch)SERV

PIPING

SPEC.

SEQ.


DENSITY

Kg/m3

OP PRESS.

Barg

OP TEMP

C

DESIGN

PRESS

Barg

2014-4800-9U-0001 Rev G Process Line List for ST-PIP

Documents

Transcript of 2014-4800-9U-0001 Rev G Process Line List for ST-PIP