120313_Wayne Mackey Case Study 1000 Home Challenge
-
Upload
dave-robinson -
Category
Documents
-
view
217 -
download
2
description
Transcript of 120313_Wayne Mackey Case Study 1000 Home Challenge
![Page 1: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/1.jpg)
Mackey Deep Energy Reduction Case Study
Chambersburg, PA
Wayne Mackey
March 13, 2012 1
The 5th home in
North America to
officially meet the
Thousand Home
Challenge!
![Page 2: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/2.jpg)
2
• 33-year-old home
• All-electric
• 5,343 heating degree
day (HDD) climate
• 2,500 ft2 (finished floor area)
• Full basement (1/2 finished)
![Page 3: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/3.jpg)
2007-08 Energy Upgrades
New SEER-18 two-stage heat pump (Sept ‘07)
CFL or LED bulb replacements
New high-performance kitchen appliances (Dec ‘08)
40% energy reduction - enough to counter anticipated rate increases...
3
![Page 4: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/4.jpg)
Then - The Unexpected
Severe hail storm with damage to home + $ insurance settlement
Loss of large tree in south-facing back yard + $ incentives for solar
equals
An opportunity for a much deeper reduction in energy use & CO2!
4
![Page 5: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/5.jpg)
House with
siding
removed; ¼”
Thermo-ply
was original
sheathing –
Significant
gaps at
seams due to
shrinkage.
Home’s energy performance was enhanced by adding
insulation under the new siding & window replacement.
Attic insulation was increased to R-49 (April 2009).
5
![Page 6: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/6.jpg)
Exterior wall
showing
original
Thermo-ply
with new foam
overlapping
seams of
original
sheathing
Original Thermo-ply
New 1” insulation (R-5)
Note: At the time of this upgrade, the product
literature cited a much higher R-value per inch.
6
![Page 7: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/7.jpg)
Richard Sword (green hat)
was a craftsman, not a
contractor. His attention to
detail on the exterior
insulation contributed to
the energy performance of
the Mackeys’ home.
The cost of the one-inch
exterior insulation was
$3,800; the full siding job
cost $17,000.
7
![Page 8: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/8.jpg)
11 existing thermo-pane
windows & 1 door were
replaced with high-performance
(U.18) triple-pane windows. 8
![Page 9: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/9.jpg)
Front of Home as Work Begins
(windows, exterior insulation, siding)
9
Lots of NW facing windows.
Thank goodness for summertime shade!
![Page 10: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/10.jpg)
10
Original door/side lites were built in
3 sections; new insulated door –
one big piece
![Page 11: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/11.jpg)
11 Northeast Side Southwest Side
![Page 12: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/12.jpg)
Front of house in progress. New 1” insulation board over old
Thermo-ply. New windows on first floor; second floor not
replaced yet. Siding removal, new windows, rigid
insulation & new siding carefully staged – one wall at a time. 12
![Page 13: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/13.jpg)
Carefully fitting &
taping rigid
insulation.
Replacing windows &
siding simultaneously
provides opportunity
for proper drainage
plane. (www.buildingscience.com)
13
![Page 14: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/14.jpg)
Beginning of 5.4 KW solar photovoltaic installation (Oct 2009).
Complete & operational on Dec 23, 2009 14
![Page 15: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/15.jpg)
15
October 2009
![Page 16: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/16.jpg)
Josh & Daniel Dec 23, 2009 – PV system
operational & certified! 16
![Page 17: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/17.jpg)
January 2010 – Some snow melted
off the panel
The Mackeys paid to
have the snow cleared off
the PV panels once; They
let the sun melt it off from
then on. 17
355 days/year the
system produces
electricity. It does not
need to be a sunny
day.
![Page 18: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/18.jpg)
March 9, 2008!
1st time in Borough’s history that PV produced enough electricity to power a house for 24 hours.
To date, there have been 10 months when the Mackeys have exported power to grid – producing more than they use.
18
![Page 19: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/19.jpg)
>10% Return on Investment (PV Installation)
Cost of PV
24,000 (after taxes & grants)
Solar Renewable Energy Credit (SREC)
2010 - $2,105
2011 - Banking them
Referral bonus from PV Installer
2010 - $2,000
2011 - $3,000
Produced to Date
13,910 kWh
Value of Electricity
~$1,500
Plus
8,000 miles/year without buying gas
19
![Page 20: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/20.jpg)
(Right) SMA Inverter –
AC/DC inverter - Display
shows daily production,
production to date, & CO2
reduced.
(Left) Box on left transmits signal
to SunPower to provide for
performance info on the web. 20
![Page 21: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/21.jpg)
PV panel on house roof; solar
hot water system installed on
the garage roof in May 2010. 21
5.4 KW PV Array
Solar Hot
Water System
![Page 22: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/22.jpg)
Solar thermal evacuated tube collector
22
![Page 23: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/23.jpg)
23
Trees outside fence will provide
privacy screen, but will not
block solar systems
(Left) Gazebo (&
potting shed) –
enhances outdoor
living
![Page 24: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/24.jpg)
Black box is the motor; also
displays incoming & outgoing
water temperatures.
Solar Thermal System
for Water Heating
Lifetime guarantee on
stainless steel tank!
24
![Page 25: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/25.jpg)
Two Fujitsu ductless heat pumps
(indoor unit above) were
installed July 2011, providing
better control over comfort with
less energy.
25
![Page 26: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/26.jpg)
New Chevy Volt purchased
in Sept 2011. Additional PV
panels added to provide
electricity needed to drive
8,000 miles/year on free
sunshine. 26
![Page 27: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/27.jpg)
eMonitorTM Online results from 30 circuits – both instantaneous & over time!
27
![Page 28: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/28.jpg)
28
![Page 29: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/29.jpg)
Monthly Energy Use Over Time (kWh)
29 -1500
-1000
-500
0
500
1000
1500
2000
2500
3000
3500
4000
May
July
Sep
t
No
v
Jan
Mar
May
July
Sep
t
No
v
Jan
Mar
May
July
Sep
t
No
v
Jan
Mar
May
July
Sep
t
No
v
Jan
Mar
May
July
Sep
t
No
v
Jan
Mar
May
July
Sep
t
No
v
2006 2007 2008 2009 2010 2011
House kWh Use
PV kWh Production
Net kWhUse
Zero!!
New Heat
Pump Insulation
Windows PV
Solar
Thermal
Ductless
Heat Pumps
![Page 30: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/30.jpg)
Beat 1000 Home Threshold by 3,500 kWh!
2,696
9,645
6,488
25,308
0 5,000 10,000 15,000 20,000 25,000 30,000
POST - NET kWh (With PV Credit - 6332kWh)
May 2010 - April 2011
POST - (No PV)May 2010 - April 2011
THC THRESHOLDOption B, Electric Heat
PRE-USE (2007)
Mackey Household Annual Energy Use (kWh) Pre & Post Compared to Threshold Allowance
Over 82% reduction
from 2007 energy use!
30
THC OPTION B assumptions: 5,343 HDD; 2,500 ft2 FFA; 2 occupants;
electric heat; single-family detached
![Page 31: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/31.jpg)
Online Resources
Case Studies
Project Planning Resources
Webcasts Recordings (mini-splits, water heating, dense-pack insulation)
Access to Resources/Links
31
www.ThousandHomeChallenge.org
Register for an upcoming Intro to the 1000 Home Challenge webinar:
March 14, 1-2:30 PM (Eastern) 10-11:30 (Pacific)
http://thousandhomechallenge.com/join-us.
Join the Home Energy Pros THC Group
http://homeenergypros.lbl.gov/
An ACI Initiative The Thousand Home
Challenge
![Page 32: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/32.jpg)
Do Differently?
Buy American
Have energy audit with BPI-certified professional first (e.g., air seal attic prior to insulating)
32
![Page 33: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/33.jpg)
Travis Arnsparger, Climate Control, Fayetteville, PA (www.climatecontrolpa.com)
West Shore Windows and Doors, Mechanicsburg, PA (www.westshorewindows.com)
Advanced Solar Industries (ASI), Lancaster County, PA
Rosenberry Electric, Chambersburg, PA
Bill Mooney, Appalachian Energy of Gettysburg, PA ([email protected])
Wade Martin, Waynesboro, PA (Radon mitigation)
Jon Kautz, Carlisle, Energy Smart Home Improvement, Boiling Springs, PA
J.K. Mechanical, Lancaster County, PA (eMonitor)
PA Code Inspection Services
The Borough of Chambersburg Master Electricians & Plumbing Inspections
Special thanks to the late Richard Sword, a true craftsman
It Takes a Team!
33
![Page 34: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/34.jpg)
Products & Systems Used1
Bryant Evolution Series heat pump – www.bryant.com
Park Avenue Windows – www.parkavenuewindows.com/
SunPower USA (PV) – www.Sunpower-usa.com
Heat Transfer Products, Solar Thermal Hot Water System – www.htproducts.com/solar.html
Fujitsu Ductless Heat Pump – www.fujitsugeneral.com/
Chevy Volt –
www.chevrolet.com/volt-electric-car/
eMonitor™ – www.powerhousedynamics.com/
34
1The inclusion of products & manufacturers on this list
should not be interpreted as an endorsement.
![Page 35: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/35.jpg)
Access to Resources Affordable Comfort, Inc. (ACI) – www.affordablecomfort.org
Better Business Bureau – www.bbb.org
Building Science Corp. – www.buildingscience.com
Consumer Reports – www.ConsumerReports.org
DSIRE (Data Base of State Incentives for Renewable Energy) – www.dsireusa.org
Efficiency First – www.efficiencyfirst.org
Energy Star Most Efficient! www.energystar.gov/index.cfm?c=most_efficient.me_index
EPA Energy Star – www.energystar.gov
Keystone Help – www.keystonehelp.com
NREL (National Renewal Energy Laboratory) – www.nrel.gov
PA Home Energy – www.pahomeenergy.com
Thousand Home Challenge – www.ThousandHomeChallenge.org
Top Ten – www.toptenusa.org/
RMI (Rocky Mountain Institute) – www.rmi.org
35
![Page 36: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/36.jpg)
Bottom Line
Significant drop in CO2 emissions1
2005: 27, 797 lbs. 2011: 3,762 lbs.
Stimulate local economy: paying contractors & supporting local business
Great improvement - house & comfort
Impressive return on my investment
Greater resilience – hedge against uncertainty
36 1www.epa.gov/climatechange/emissions/ind_calculator.html
![Page 37: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/37.jpg)
This project demonstrates that it is possible NOW to significantly reduce our dependence
on nonrenewable energy sources, create millions of green jobs, and protect future
generations from the devastating consequences of global climate change.
I am committed to the goal of achieving this by our nation’s 250th birthday celebration,
July 4, 2028 so we once again serve as a beacon of light and hope
to the rest of the world.
Wayne Mackey 37
![Page 38: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/38.jpg)
Surprises??
Oops – radon! (Fixed)
Missed opportunities – Why didn’t more folks improve homes – energy efficiency & resilience with insurance $
We tend to take energy for granted
Really big reductions possible 38
For information contact:
Wayne Mackey
![Page 39: 120313_Wayne Mackey Case Study 1000 Home Challenge](https://reader030.fdocuments.us/reader030/viewer/2022020322/568c0f4f1a28ab955a93a70a/html5/thumbnails/39.jpg)
REGISTER NOW! – www.acinational.org
39