1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems:...
-
Upload
nickolas-gallagher -
Category
Documents
-
view
218 -
download
1
Transcript of 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems:...
![Page 1: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/1.jpg)
1
Turf and Ornamental Pest ControlTurf and Ornamental Pest Control
![Page 2: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/2.jpg)
2
Application Equipment:
• Two basic types of application systems: Liquid (sprayers) Granular
![Page 3: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/3.jpg)
3
Misapplication:
• Without proper attention, you may end up with a ……
Misapplication
![Page 4: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/4.jpg)
4
Calibrating Homeowner Equipment
![Page 5: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/5.jpg)
5
Types of ApplicationTypes of Application
• Foliage sprays (shrubs, trees)• Area coverage (soils or lawns)• Spot sprays• LAWN
Fertilization Weed control Insect/Fungi control
• HORT Fertilization Insect/Disease control Dormant oil treatments
![Page 6: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/6.jpg)
6
Area Coverage (soils or lawns)Area Coverage (soils or lawns)
• Application should provide even wetting of entire surface with no areas of intense concentration
• Often recommend to cut application rate in half and cover area twice. at opposite angles - not always good since
application rate and speed not proportional in same direction alternating rows per
application
![Page 7: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/7.jpg)
7
Foliage Sprays (shrubs, trees)Foliage Sprays (shrubs, trees)
• Most recommendations advise spraying the foliage with diluted chemical to the point of runoff – glistening of the leaves
• Difficult to do uniformly
![Page 8: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/8.jpg)
8
EquipmentEquipment
• Hose-end sprayers• Compressed air sprayers• Knapsack sprayers• Trombone sprayer/ bucket (stirrup)
sprayer• Fogger• Spray bottle
![Page 9: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/9.jpg)
9
Application Equipment
Manual Sprayers Compressed air Knapsack
Spray Management Valve
CF Valve
Easy Spray Valve
![Page 10: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/10.jpg)
10
Compressed Air SprayersCompressed Air Sprayers
• Pesticides already mixed to their proper spraying dilution
• Tank pressurized with compressed air or carbon dioxide
![Page 11: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/11.jpg)
11
Notes:Notes:
• Shake occasionally to keep materials in solution/suspension/emulsion.
• Each sprayer comes with a nozzle that can be adjusted to provide fine spray, coarse spray, and solid stream.
![Page 12: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/12.jpg)
12
Pressure Control:Pressure Control:
• Fill tank 2/3 full with spray material so considerable air space if left for initial expansion.
• Repressurize tank frequently.• If pressure gage is used, repressurize
when pressure drops about 10 psi from initial reading.
• Use a ‘spray management valve’.
![Page 13: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/13.jpg)
13
Calibration Procedure (trees and shrubs)Calibration Procedure (trees and shrubs)
• Add a known amount of water to the sprayer.
• Spray the water as uniformly as possible to the point of runoff.
• Measure the amount of water left in the sprayer and subtract it from the amount added to the sprayer in the beginning
![Page 14: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/14.jpg)
14
Calibration Procedure (lawns and soils)Calibration Procedure (lawns and soils)
• Measure and mark off an area of 1000 sq ft.
• Add a measured amount of water to spray tank, spray area, and then measure the amount of water remaining in the tank.
• The difference between the amount in the tank before and after spraying is the amount used.
![Page 15: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/15.jpg)
15
Alternative Calibration Procedure
Steps: Mark off a calibration course of 1000 sq. ft. Accurately measure the time required to spray
the calibration course using a proper technique. Remember only record the amount of time the gun is actually spraying.
Measure the flow rate from the gun. Using the time recorded in step 2, spray into a calibrated container for that same length of time.
Amount in the container represents the application rate per 1000 sq. ft.
![Page 16: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/16.jpg)
16
Example:It took 50 seconds for an applicator to spray
the 1000 sq. ft. calibration course. The amount of spray collected from the gun in the 50 seconds was 1.4 gallons.
The application rate for this example is:
1.4 gallons per 1000 sq. ft.or
61 gallons per acre (43.56 x 1.4)
Alternative Calibration Procedure
![Page 17: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/17.jpg)
17
Spot SprayersSpot Sprayers
• Fence rows.• Weeds in beds or turf.• Calibrate sprayer same as in Area
Coverage, but estimate area of spots to be covered when figuring amount of water and chemical to add to spray tank.
• Spray to point of run off.
![Page 18: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/18.jpg)
18
Hose-end SprayersHose-end Sprayers
• Simple and inexpensive• Use water pressure from garden hose
to distribute the spray.• Chemical added to jar as concentrate.
![Page 19: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/19.jpg)
19
Siphon ActionSiphon Action
• Draws the solution in the jar and mixes it at a predetermined rate with the water spraying out of the nozzle.
![Page 20: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/20.jpg)
20
Marks on Jar:Marks on Jar:
• Gallon scale on jar indicates total amount of water and pesticide solution in the jar applied.
• Ounces give amount actually in jar while gallons give amount supposed to be sprayed out once mixed with water from hose.
• ie: Jar filled to 10 gal mark (25 oz of solution). When
jar is empty, 25 oz has been applied with 10 gallons of water.
![Page 21: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/21.jpg)
21
Calibration:Calibration:
• Measure and mark off an area of 1000 sq ft.• Fill jar with water to a measured level.• Spray marked area uniformly and then check
the amount left in the jar.• Add to the jar the chemical needed to spray
the number of sq ft in your yard or garden area. Then add enough water to the jar to bring the level up to the gallonage mark required to cover the sq ft to be treated.
![Page 22: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/22.jpg)
22
Notes:Notes:
• To obtain uniform application cut rate in half and spray area twice; overlapping motion as you walk.
• Always use uniform walking speed during application.
![Page 23: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/23.jpg)
23
MEASURE SPEED
Speed(MPH)Distance(ft) x 60
Time(seconds) x 88
(1 MPH = 88 Feet traveled in 60 seconds)
Measure the ground speed in an area similar to the conditions of the area to be sprayed!
![Page 24: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/24.jpg)
24
Sprayer AccuracySprayer Accuracy
• Water pressure affects accuracy of sprayer.
• Designed to operate at 40 psi (typical water pressure found in most areas).
• Hose length not to exceed 50 ft and min. dia. of 5/8 inch.
![Page 25: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/25.jpg)
25
Example Calibration Problem
• Your yard is 3500 ft2, and you want to apply a pesticide at the rate of 3 oz/1000 ft2 (according to label).
• In calibration you added water to the 6 gallon mark on the jar. After spraying an area of 1000 ft2, equivalent of 4 gal. is left in the jar.
• How much water and chemical should you put in the jar?
![Page 26: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/26.jpg)
26
Example of CalibrationExample of Calibration
• Area covered = 1000 ft2
• 6 gal. - 4 gal. = 2 gal.• Yard is 3500 ft2
• From label: 3 oz/1000 ft2
• (3500 x 3)/1000 = 10.5 oz
• The jar is filled to:• ( 3500/1000) x 2 = 7
gal.
50 ft50 ft
20 ft20 ft 3500 ft3500 ft22
![Page 27: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/27.jpg)
27
Trombone Sprayer/ Bucket (stirrup) SprayerTrombone Sprayer/ Bucket (stirrup) Sprayer
• Inexpensive, durable, telescoping, plunger-action pumps that provide continuous spray.
• Can reach tops of 25 to 30 foot trees.• Must carry bucket with you.• Bucket sprayer involves a foot support for
the bucket
![Page 28: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/28.jpg)
28
FoggerFogger
• Used in small areas to control insects• Oil based insecticide is used along
with a lit propane tank to volatilize the spray and produce smoke or fog.
• Allow fog to dissipate before reentry to area.
• Very likely to drift so extreme care must be taken.
![Page 29: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/29.jpg)
29
Spray BottleSpray Bottle
• House plants, small flower beds and gardens, small shrubs
• Spray to point of runoff• Simply add proper amount of
water and pesticide according to label
![Page 30: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/30.jpg)
30
Measurement of small land area
• Apply proper amounts of pesticide
• the area must be accurately determined
![Page 31: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/31.jpg)
31
Field measurement methods
• Division of the area into simple figures.
• Offsets from straight lines.
• Maples-Turf technique.
• Coordinates.
![Page 32: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/32.jpg)
32
Example
• Calculate a irregular shaped turf
127’
32’
![Page 33: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/33.jpg)
33
Circle, Rectangle, Triangle
• a1d2/4=706 ft2 or (r2)
• a2 = 20 x 50 = 1000 ft2
• s = (32+20+40)/2 = 46• a3 = [s(s-32)(s-40)(s-20)]1/2
= 317 ft2
• Area = a1+a2+a3 = 2023 ft2
20’40’
d=30’
50’
a1
a2
a3
32’
![Page 34: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/34.jpg)
34
Trapezoid area
a
b
h
Area = h * (a+b)/2
(a+b)/2
![Page 35: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/35.jpg)
35
Offsets from straight lines
• Trapezoidal rule: divide the figure
into an even nummer, n, of strips.
A dh h
h h hnn
01 2 12
d d d
hn
![Page 36: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/36.jpg)
36
Calibrating granular spreaders:
• Improves weed, insect, and disease control.• Lowers incidences of using wrong amounts.• Minimizes potential problems to the
environment.
![Page 37: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/37.jpg)
37
Calibration includes:
• Calculating the amount of product needed.• Mixing properly and safely.• Adjusting the equipment to deliver the
desired rate uniformly.• Determining effective swath/overlap.• Checking accuracy during operation.• Detecting and correcting errors.
![Page 38: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/38.jpg)
38
Importance of calibration:
• All spreaders should be calibrated with the operator and the product being used.
• Many product suppliers furnish recommended settings and swath width.
• Equipment manufacturers also make setting recommendations.
![Page 39: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/39.jpg)
39
Types of application devices:
• Centrifugal, rotary, or broadcast• Drop• Pendulum• Pneumatic
![Page 40: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/40.jpg)
40
Factors influencing granular rates:
• Size of metering orifice.• Speed of the agitator or rotor.• Travel speed• Roughness of the application area.• Topography of the application area.• Flowability of the granules.• Quality of the granules/mix.• Temperature and humidity.• Wind
![Page 41: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/41.jpg)
41
Checking distribution pattern:
• Open area – bounce and scatter.• Preferred method – use collection
containers on a line perpendicular to the direction of travel.
• Enough boxes to cover 1½ times the anticipated swath width.
• Make several passes over the boxes – in the same direction.
• Empty contents from containers into a tube or bottle.
![Page 42: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/42.jpg)
42
Pan Test
![Page 43: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/43.jpg)
43
Pattern distributions:
Primary collection
![Page 44: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/44.jpg)
44
Determing the swath width using the tube method:
• Compare the tubes.
• Determine the tube that is ½ the amount of the center tube.
• These two tubes determine the boundaries
![Page 45: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/45.jpg)
45
Effective swath width:
![Page 46: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/46.jpg)
46
Final pattern:
![Page 47: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/47.jpg)
47
Pattern distributions:
Swath To Wide
Side Wind
![Page 48: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/48.jpg)
48
Header strips and swath overlap:
• Recommended application method: First pass at ½ rate using calibrated swath width Second path on centerline of previous pass
![Page 49: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/49.jpg)
49
Improved granular application techniques will include:
• Selecting the right equipment.• Keeping the equipment in good working
condition.• Calibrating the application equipment to:
Prevent streaking of pesticides. Avoid a reduction in control with pesticides. Apply proper amount of product.
• Selecting good quality product.• Avoiding losses in $$$$.
![Page 50: 1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems: Liquid (sprayers) Granular.](https://reader035.fdocuments.us/reader035/viewer/2022062716/56649dce5503460f94ac1d39/html5/thumbnails/50.jpg)
50
Thank You!