#1. TECHNICIAN A SAYS THAT USING YOUR BACK IS THE PROPER WAY TO LIFT. TECHNCIAN B SAYS THAT YOU SHOULD ALWAYS LIFT WITH YOUR LEGS. WHO IS RIGHT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#2. TECHNICIAN A SAYS THAT WHEN YOU ARE SOLDERING YOU SHOULD BE VERY CAREFULL, & WEAR SAFETY GLASSES. TECHNICIAN B SAYS THAT SOLDER MELTS AT 400 DEGREES, CONTAINS LEAD & SHOULD NOT BE PLAYED WITH. WHO IS RIGHT? a. A only b. B only

c. BOTH A & B d. NEITHER A nor B

#3. TECHNICIAN A SAYS THAT AS LONG AS YOU HAVE PASSED THE SAFETY TEST YOU CAN USE THE ALIGNMENT RACK (HOIST) WITH OUT PERMISSION. TECHNICIAN B SAYS THAT YOU SHOULD GET THE INSTRUCTORS PERMISSION, HAVE SOMEONE GUIDE YOU ON THE HOIST SO THAT THE VEHICLE IS CENTERED, AND WATCH A DEMONSTRATION OF HOW IT WORKS BEFORE USING THE ALIGNMENT RACK. WHO IS RIGHT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#4. TECHNICIAN A SAYS THAT WHEN USING A LIFT(HOIST) YOU SHOULD ALWAYS HAVE THE INSTRUCTOR DEMONSTRATE ITS OPERATION, PICK THE VEHICLE UP BY THE APPROVED LIFT POINTS & HAVE THE SET UP CHECKED BY THE INSTRUCTOR BEFORE LIFTING THE VEHICLE. TECHNICIAN B SAYS THAT YOU SHOULD GET THE INSTRUCTORS PERMISSION & FOLLOW THE SERVICE MANUAL INSTRUCTIONS WHEN LIFTING A CAR ON A HOIST. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#5. TECHNCIAN A SAYS THAT YOU SHOULD RAISE THE SHOP DOORS ALL THE WAY WHEN YOU OPEN THEM. TECHNICIAN B SAYS THAT AS LONG AS YOU CAN WALK UNDER THE DOOR IT IS HIGH ENOUGH. WHO IS RIGHT? a. A only b. B only

c. BOTH A & B d. NEITHER A nor B

#6. TECHNCIAN A SAYS THAT WHEN YOU ARE WORKING IN THE SHOP YOU ONLY NEED TO FOLLOW SAFETY RULES WHEN YOU ARE DOING SOMETHING DANGEROUS. TECHNCIAN B SAYS THAT YOU SHOULD ALWAYS BE CONCERNED WITH FOLLOWING SAFETY RULES AND THE ACTIONS OF OTHER STUDENT TECHNCIANS IN AND AROUND THE SHOP. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#7. TECHNICIAN A SAYS THAT CHEMICAL BURNS, ELECTRIC SHOCK, AND PHYSICAL INJURIES ARE HAZARDS IN THE SHOP. TECHNICIAN B SAYS THAT FIRES, EXPLOSIONS, AND ASPHYXIATION ARE HAZARDS IN THE AUTO SHOP. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#8. TECHNICIAN A SAYS THAT IF AN ACCIDENT OCCURS YOU ONLY NEED TO NOTIFY YOUR INSTRUCTOR IF YOU ARE BLEEDING. TECHNICIAN B SAYS THAT WHEN EVER AN ACCIDENT OCCURS OR A HAZARD IS PRESENT YOU SHOULD NOTIFY YOUR INSTRUCTOR IMMEDIATELY. WHO IS RIGHT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#9. TECHNICAN A SAYS THAT YOU SHOULD USE COMMON SENSE IN DECIDING WHETHER TO GET A FIRE EXTINGUISHER OR TAKE OTHER ACTIONS IF THERE IS A FIRE. TECHNICIAN B SAYS ALWAYS PUT OUT THE FIRE. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#10. TECHNCIAN A SAYS THAT GASOLINE IS NOT A HAZARD IN THE AUTO SHOP. TECHNICIAN B SAYS THAT GASOLINE IS THE MOST DANGEROUS AND UNDERESTIMATED FLAMABLE IN AN AUTO SHOP AND SHOULD NEVER BE USED FOR CLEANING. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#11. TECHNCIAN A SAYS THAT ASBESTOS IS A FLAMABLE SUBSTANCE IN THE AUTO SHOP. TECHNCIAN B SAYS THAT GASOLINE, PAINTS, AND THINNERS ARE A FLAMABLE HAZARD IN THE AUTO SHOP. WHO IS CORRECT? a. A only b. B only

c. BOTH A & B d. NEITHER A nor B

#12. TECHNCIAN A SAYS THAT ELECTRICAL FIRES ARE NOT A PROBLEM IN THE AUTO SHOP BECAUSE ELECTRICITY DOESN’T BURN. TECHNCIAN B SAYS IF A HOT (POSITIVE) WIRE TOUCHES GROUND IT CAN HEAT UP AND CAUSE A FIRE. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#13. TECHNCIAN A SAYS THAT YOU SHOULD ALWAYS DISCONNECT THE BATTERY BEFORE WORKING ON THE FUEL SYSTEM & SOME ELECTRICAL REPAIRS (ALTERNATOR REPLACEMENT), ETC. TECHNICIAN B SAYS THAT YOU SHOULD KEEP ANY SOURCE OF HEAT AWAY FROM POSSIBLE FUEL LEAKS, SUCH AS DROPLIGHTS, TORCHES, WELDERS, AND OPEN FLAME. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#14. TECHNCIAN A SAYS THAT OILY RAGS CANNOT CATCH FIRE UNLESS THEY ARE SET ON FIRE. TECHNICIAN B SAYS THAT OILY RAGS CAN CATCH FIRE AND SHOULD BE DISCARDED IN THE PROPER CONTAINER. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#15. TECHNICIAN A SAYS THAT HYDROGEN GAS FROM A CARS BATTERY CAN EXPLODE AND THAT SAFETY GLASSES AND EXTRA PRECAUTION SHOULD BE USED TO PREVENT SPARKS. TECHNICIAN B SAYS THAT THERE ARE NO GASSES PRODUCED FROM A CARS BATTERY. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#16. TECHNICIAN A SAYS THAT FUEL TANKS ARE NOT EXPLOSIVE IF THEY ARE EMPTY. TECHNICIAN B SAYS THAT FUEL TANKS ARE ALWAYS A HAZARD & YOU SHOULD BE VERY CAREFUL WHEN WORKING AROUND THEM. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#17. TECHNICIAN A SAYS THAT DUST FROM BRAKE LINNING IS A HARMFUL SUBSTANCE. TECHNICIAN B SAYS THAT DUST FROM A CLUTCH DISC IS A HARMFUL SUBSTANCE. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#18. TECHNICIAN A SAYS THAT YOU SHOULD ALWAYS READ THE DIRECTIONS ON ALL CHEMICAL CONTAINERS BEFORE USING THEM. TECHNICIAN B SAYS THAT YOU SHOULD WEAR PROPER PROTECTIVE CLOTHING. WHO IS RIGHT? a. A only b. B only

c. BOTH A & B d. NEITHER A nor B

#19. TECHNICIAN A SAYS THAT YOU SHOULD FIRST GO TO THE NURSE IF YOU GET CHEMICALS IN YOUR EYES. TECHNICIAN B SAYS THAT YOU SHOULD USE AN EYE FLUSHING STATION FIRST. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#20. TECHNICIAN A SAYS THAT CERTAIN CHEMICALS IN AN AUTO SHOP CAN CAUSE CHEMICAL BURNS TO YOUR SKIN. TECHNICIAN B SAYS THAT YOU SHOULD WEAR PROTECTIVE CLOTHING WHEN WORKING IN THE AUTO SHOP. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#21. TECHNCIAN A SAYS THAT BREATHING OF TOXIC OR POISONOUS SUBSTANCES SUCH AS THE GASSES PRODUCED BY A CAR’S ENGINE CAN CAUSE ASPHYXIATION. TECHNCIAN B SAYS THAT ANY CAR (VEHICLE) THAT IS IN AN INCLOSED AREA NEEDS TO HAVE AN EXHAUST HOSE HOOKED UP TO THE EXHAUST PIPE(S)OF THE CAR. WHO IS RIGHT? a. A only b. B only

c. BOTH A & B d. NEITHER A nor B

#22. TECHNCIAN A SAYS THAT ANY CLOTHES ARE SUITABLE TO WEAR IN THE AUTO SHOP. TECHNICIAN B SAYS THAT YOU SHOULD WEAR THE PROPER CLOTHING AND SAFETY GLASSES AND EQUIPMENT AT ALL TIMES. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#23. TECHNICIAN A SAYS THAT YOU SHOULD ALWAYS MAKE SURE THAT ELECTRIC TOOLS ARE PROPERLY GROUNDED AND SHOULD NEVER BE USED ON A WET FLOOR. TECHNICIAN B SAYS THAT ELECTRIC SHOCK IS A RESULT OF ELECTRIC CURRENT PASSING THROUGH PARTS OF YOUR BODY WHICH CAN CAUSE INJURY OR DEATH. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#24. TECHNICIAN A SAYS AS A STUDENT TECHNICIAN YOU MUST EVALUATE EVERY REPAIR TECHNIQUE & DECIDE WHETHER A PARTICULAR OPERATION IS SAFE & TAKE ACTION AS REQUIRED. TECHNICIAN B SAYS THAT YOU SHOULD NEVER OVEREXERT YOUR BACK BECAUSE ONCE YOU INJURE YOUR BACK IT CAN TAKE MONTHS TO RECOVER. WHO IS RIGHT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#25. TECHNCIAN A SAYS THAT YOU SHOULD NEVER CARRY SHARP TOOLS OR PARTS IN YOUR POCKETS. TECHNICAN B SAYS THAT YOU SHOULD STAY AWAY FROM ANYONE WHO DOES NOT TAKE SHOP WORK SERIOUSLY. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#26. TECHNICIAN A SAYS THAT CARBURETOR CLEANER IS HIGHLY CONCENTRATED & DANGEROUS TO THE SKIN, EYES, & CLOTHING. TECHNICIAN B SAYS THAT YOU SHOULD NEVER SIPHON GASOLINE, OR BREATHE GASOLINE VAPORS BECAUSE IT CAN BE FATAL. WHO IS CORRECT? a. A only b. B only

c. BOTH A & B d. NEITHER A nor B

#27. TECHNCIAN A SAYS THAT IT IS OK TO LAY TOOLS, CREEPERS, & PARTS ON THE FLOOR. TECHNICIAN B SAYS THAT IT IS OK TO USE POWER EQUIPMENT WITH OUT USING SAFETY GLASSES. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#28. TECHNCIAN A SAYS THAT IT IS OK TO WEAR NECKTIES, SHORTS, OPEN TOED SHOES, NECKLACES, & JEWELRY. TECHNICIAN B SAYS THAT THE ONLY THING THAT SHOULD BE WEARING IS A LONG SLEEVE SHIRT, LONG PANTS, & A WATCH. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#29. TECHNICIAN A SAYS THAT YOU SHOULD ALWAYS WORK LIKE A PROFESSIONAL WHEN LEARNING AUTO REPAIR. TECHNICIAN B SAYS THAT YOU SHOULD ALWAYS USE THE RIGHT TOOL FOR THE JOB. WHO IS RIGHT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#30. TECHNCIAN A SAYS THAT YOU SHOULD SUPPORT THE WEIGHT OF THE VEHICLE ON JACK STANDS BEFORE WORKING UNDER IT. TECHNCIAN B SAYS THAT YOU SHOULD USE A PORTABLE CRANE WHEN LIFTING HEAVEY OBJECTS, SUCH AS ENGINES, DIFFERENTIALS, ETC. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#31. TECHNICIAN A SAYS THAT YOU SHOULD ALWAYS LIFT WITH YOUR LEGS & NOT YOUR BACK. TECHNICIAN B SAYS THAT YOU SHOULD GET PERMISSION & FOLLOW ALL SAFETY RULES WHEN USING THE TIRE MACHINE. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#32. TECHNCIAN A SAYS THAT COMPRESSED AIR CAN PENETRATE THE SKIN & MUST BE USED CAUTIOUSLY. TECHNICIAN B SAYS THAT YOU SHOULD NEVER PLAY WITH AN AIR HOSE OR AIR NOZZLE BECAUSE SERIOUS INJURY OR DEATH CAN RESULT. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#33. TECHNCIAN A SAYS THAT YOU SHOULD NEVER STIR UP THE DUST FOUND ON BRAKE AND CLUTCH ASSEMBLIES. TECHNCIAN B SAYS THAT YOU SHOULD ALWAYS KEEP GUARDS OR SHIELDS IN PLACE WHEN USING POWER TOOLS & ALWAYS USE ADEQUATE LIGHTING. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#34. TECHNCIAN A SAYS THAT AS LONG AS THERE IS NO POSTED SPEED LIMIT YOU CAN DRIVE AS FAST AS YOU WANT IN & AROUND THE SHOP AREA. TECHNCIAN B SAYS THAT YOU SHOULD DRIVE SLOWLY IN & AROUND THE SHOP AREA BECAUSE YOU MIGHT CAUSE HARM TO ANOTHER PERSON OR PROPERTY. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#35. TECHNCIAN A SAYS THAT YOU SHOULD NEVER SQUEAL THE TIRES ON YOUR CAR OR ANY CAR IN THE SHOP AREA. TECHNICIAN B SAYS THAT IF THE INSTRUCTOR CATCHES YOU YOU WILL SERVE A ONE HOUR DETENTION & LOOSE YOUR DRIVING PRIVILEGES FOR THE REST OF THE YEAR. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#36. TECHNICIAN A SAYS AS LONG AS YOU DON’T GET HURT WHO CARES ABOUT UNSAFE TOOLS, CONDITIONS, & EQUIPMENT. TECHNCIAN B SAYS THAT YOU SHOULD REPORT ANY UNSAFE TOOLS OR CONDITIONS TO YOUR INSTRUCTOR IMMEDIATELY. WHO IS CORRECT. a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#37. TECHNCIAN A SAYS THAT ENGINE FANS ARE SAFE BECAUSE THE EDGES ARE DULL. TECHNCIAN B SAYS THAT AN ENGINE FAN IS LIKE A SPINNING KNIFE & CAN INFLICT SERIOUS INJURIES. WHO IS RIGHT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#38. TECHNCIAN A SAYS THAT AN ENGINE FAN CAN THROW TOOLS OR PARTS IF THEY ARE DROPPED INTO IT. TECHNICIAN B SAYS THAT ELECTRIC ENGINE COOLING FANS CAN COME ON AT ANY TIME EVEN IF THE ENGINE IS OFF. WHO IS CORRECT. a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#39. TECHNCIAN A SAYS THAT IF A CAR’S WHEELS ARE NOT BLOCKED, THE CAR IS PUT IN PARK, & THE PARK BRAKE SET THE CAR COULD ACCIDENTALLY RUN OVER SOMEONE. TECHNICIAN B SAYS THAT IT IS OK TO SMOKE IN THE AUTO SHOP. WHO IS RIGHT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#40. TECHNCIAN A SAYS THAT A TIRE BALANCER MUST BE USED WITH CAUTION & HAVE THE SHIELD DOWN WHEN RUNNING. TECHNCIAN B SAYS THAT IF YOU DON’T KNOW THE DANGERS OF CERTAIN CHEMICALS YOU SHOULD LOOK AT THE MATERIAL SAFETY DATA SHEET. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#41. TECHNICIAN A SAYS THAT PHYSICAL INJURIES ARE (CUTS, BROKEN BONES, SPRAINED BACKS, ETC). TECHNICIAN B SAYS THAT A MATERIAL SAFETY DATA SHEET (MSDS) HAS A LOT OF IMPORTANT INFORMATION ON IT IN CASE OF AN ACCIDENT INVOLVING A CHEMICAL. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#42. TECHNCIAN A SAYS THAT AN AUTO SHOP CANNOT BE A SAFE PLACE TO WORK. TECHNICIAN B SAYS THAT AN AUTO SHOP CAN BE A VERY SAFE AN ENJOYABLE PLACE TO WORK AS LONG AS BASIC SAFETY RULES ARE FOLLOWED. WHO IS CORRECT? a. A only

b. B only c. BOTH A & B d. NEITHER A nor B

#43. TECHNICIAN A SAYS THAT AS LONG AS YOU KNOW HOW TO USE A HOIST IT IS OK TO USE IT WITHOUT PERMISSION FROM YOUR INSTRUCTOR. TECHNICIAN B SAYS THAT YOU SHOULD ALWAYS ASK THE INSTRUCTOR FOR PERMISSION & HAVE THE INSTRUCTOR CHECK THE SET UP OF THE HOIST UNDER THE VEHICLE BEFORE RAISING IT OFF OF THE FLOOR. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#44. TECHNICIAN A SAYS THAT YOU SHOULD ALWAYS ASK FOR PERMISSION & INSTRUCTIONS WHEN USING POWER TOOLS (DRILL PRESS, AIR CHISELS, IMPACT- WRENCHS, FLOOR JACKS, TIRE CHANGERS & BALANCERS, ETC). TECHNICIAN B SAYS FOR YOUR SAFETY & THE SAFETY OF OTHERS YOU SHOULD ALWAYS FOLLOW YOUR INSTRUCTORS INSTRUCTIONS WHEN USING DANGEROUS EQUIPMENT.WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#45. TECHNICIAN A SAYS THAT WHEN USING AN AIR CHISEL, BE SURE TO HAVE THE TOOL BIT AGAINST THE WORK PIECE BEFORE YOU SQUEEZE THE TRIGGER. TECHNICIAN B SAYS THAT DIE GRINDER WHEELS TURN AT SPEEDS OF UP TO 20,000 RPM, & SHOULD BE CHECKED FOR DAMAGE & SPEED RATING BEFORE USE. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#46. TECHNICIAN A SAYS A FLOOR JACK SHOULD BE USED TO RAISE & LOWER A VEHICLE ONLY. TECHNCIAN B SAYS THAT A JACKED UP VEHICLE SHOULD BE PLACED FIRMLY ON JACK STANDS. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#47. TECHNCIAN A SAYS A FLAMABLE LIQUID FIRE IS CALLED A CLASS B FIRE. TECHNCIAN B SAYS IF A FIRE IS BURNING OUT OF CONTROL LEAVE THE AREA IMMEDIATELY & CALL FOR HELP. WHO IS CORRECT? a. A only b. B only

c. BOTH A & B d. NEITHER A nor B

#48. TECHNICIAN A SAYS THAT THE MOST COMMON CAUSE OF BATTERY EXPLOSION IS WHEN SOMEONE UNHOOKS THE BATTERY CHARGER WITHOUT TURNING IT OFF FIRST. TECHNCIAN B SAYS THAT IF ACID GETS ON THE SKIN OR EYES IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES. WHO IS CORRECT? a. A only b. B only c. BOTH A & B d. NEITHER A nor B

#49. THE MOST COMMON INJURIES IN AN AUTOMOTIVE SHOP INVOLVES THE________________&_______________.

a. LEGS & BACK.

b. HANDS & EYES.

c. FEET & HANDS.

d. BACK & EYES.

#50. WHAT FORM OF GASOLINE IS THE MOST DANGEROUS?

A. VAPOR

b. LIQUID

c. A & B

d. NEITHER A NOR B

#51. THE TEMPERATURE THAT A FLAMABLE LIQUID’S VAPOR WILL IGNITE WHEN BROUGHT INTO CONTACT WITH AN OPEN FLAME IS CALLED THE______________ POINT. a. FLASH b. LIQUID c. SPONTANEOUS d. NEITHER A NOR B

#52. BEFORE AN____________________ FIRE CAN BE EXTINGUISHED THE BATTERY MUST BE DISCONNECTED. a. OIL b. LIQUID c. GASOLINE d. ELECTRICAL

#53. DO NOT ATTEMPT TO PUT OUT A GASOLINE FIRE WITH________________. a. SAND b. DRY CHEMICALS c. CLASS B FIRE EXTIGUISHER d. WATER

#54. THE COLOR OF THE WIRING FOR GROUND ON COMMERCIAL & HOUSEHOLD WIRING IS_____________________. a. BLACK b. RED c. BROWN d. GREEN

#55. ELECTRIC COOLING FANS SHOULD BE __________________ BEFORE WORKING AROUND THEM. a. GROUNDED b. DISCONNECTED c. REMOVED d. TURNED OFF

#56. BEFORE OPENING A RADIATOR (REMOVING THE CAP), TEST FOR PRESSURE BY ___________________ THE TOP RADIATOR HOSE.

a. SQUEEZING b. FEELING c. RUBBING d. REMOVING

#57. MUSHROOMED PUNCHES OR CHISELS SHOULD BE_________________ BEFORE USE. a. PAINTED b. DISCARDED c. REGROUND d.SHARPENED

#58. ALWAYS WEAR________ _________ PROTECTION WHEN USING HAMMERS, CHISELS, PULLERS, BATTERIES, AIR CONDITIONING EQUIPMENT, COMPRESSED AIR, & OTHER HAZARDOUS SITUATIONS. a. EYE OR FACE b. EYE OR HAND c. EYE & HAND d. BACK & HAND

#59. ALWAYS USE A______________ON THE TANG OF A FILE.

a. RAG b. PAIR OF PLIERS c. GLOVES d. HANDLE

#60. DO NOT___________ TO SOMEONE WHO IS OPERATING A MACHINE.

a. TALK b. SIGNAL c. BOTH A & B d. NEITHER A NOR B

#61. A ___________ BIT HAS A TENDENCY TO GRAB THE WORK WHEN IT IS JUST BEGINNING TO BREAK THROUGH THE METAL.

a. SCREW b. IMPACT c. TORX d. DRILL

#62. WHEN____________ THINGS ON THE DRILL PRESS, MAKE SURE THEY ARE CLAMPED TO THE DRILL PRESS TABLE.

a. CUTTING b. GRINDING c. SANDING d. DRILLING

#63. STAND TO THE ____________ WHEN STARTING THE GRINDER.

a. SIDE b. FRONT c. BACK d. NONE OF THESE

#64. POSITION THE TOOL_____________ AS CLOSE TO THE GRINDING WHEEL AS POSSIBLE.

a. STAND b. REST c. BRACE d. NONE OF THESE

#65. A RUBBER-TIPPED________________ WORKS AT FULL SHOP AIR PRESSURE.

a. AIR NOZZEL b. GRINDER c. DRILL d. SPRAY GUN

#66. WHEN USING AN AIR IMPACT WRENCH BE SURE AN USE AN EXTRA THICK SOCKET CALLED AN__________SOCKET. a. CHROME b. WOBBLE c. DEEP d. IMPACT

#67. WHEN AN AIR IMPACT____________ IS USED WITH A WOBBLE SOCKET, THE SOCKET CAN FLY OFF IF THE TOOL IS STARTED WHEN THE SOCKET IS NOT ON THE BOLT HEAD. a. DRILL b. CHISEL c. GRINDER d. WRENCH

#68. BECAUSE THEY CAN DEVELOP FORCE FROM 20 TO 50 TONS ___________ PRESSES CAN CAUSE PARTS TO EXPLODE. a. ARBOR b. SNAP- ON c. MAC d. HYDRAULIC

#69. IF REFRIDGERANT FROM AN AIR CONDITIONING SYSTEM CONTACTS YOUR SKIN OR EYES IT WILL__________ THEM. a. DISCOLOR b. FREEZE c. SCALD d. BURN

#70. WHEN LIFTING A VEHICLE ON A FRAME-CONTACT LIFT (HOIST), PLACE THE LIFT PADS AT THE SPECIFIED LOCATIONS & RAISE THE VEHICLE ABOUT___________ & THEN SHAKE IT TO SEE THAT IT IS FIRMLY IN PLACE. a. 6 INCHES b. 18 INCHES c. 15 INCHES d. 20 INCHES

#71. WHEN MOVING AN ENGINE MOUNTED ON A SHOP CRANE (CHERRY PICKER) BE SURE THE ENGINE IS LOWERED AS FAR AS POSSIBLE TO KEEP THE CENTER OF __________ LOW.

a. WORK AREA b. THE ENGINE c. GRAVITY d. CRANE

#72. BOLTS THAT ATTACH AN ENGINE SLING OR ENGINE STAND ADAPTER TO THE ENGINE BLOCK SHOULD ENTER THE ENGINE BLOCK AT LEAST______________ TURNS. a. 6 b. 8 c. 10 d. 20

#73. WHEN USING A TRANSMISSION__________ ON A CAR THAT IS ON A FRAME-CONTACT LIFT YOU SHOULD BE CAREFUL NOT TO RAISE THE VEHICLE OFF OF THE LIFT PADS AS YOU RAISE THE TRANSMISSION. a. AIR JACK b. FLOOR JACK c. JACK d. SCISSOR JACK

#74. SHUT OFF & UNPLUG THE BATTERY______________ BEFORE UNHOOKING EITHER OF THE CABLES. a. AMP GAUGE b. GAUGE c. SWITCH d. CHARGER

#75. TECHNICIAN A SAYS WHEN A FLOOR CREEPER IS NOT IN USE IT SHOULD BE STOOD VERTICALLY SO IT IS NOT ACCIDENTALLY STEPPED ON. TECHNICIAN B SAYS THE KEYS SHOULD BE OUT OF THE IGNITION ANY TIME A BELT IS BEING INSPECTED, ADJUSTED, OR REPLACED. WHO IS CORRECT? a. ONLY b. ONLY c. BOTH A & B d. NEITHER A NOR B