1 LeuchTek GmbH Hamburg, Germany .
-
Upload
patience-booth -
Category
Documents
-
view
227 -
download
5
Transcript of 1 LeuchTek GmbH Hamburg, Germany .
1
LeuchTek GmbHHamburg, Germanywww.LeuchTek.de
2
Benefits of supplemental lighting Higher yield, more vigorous leading to a lower risk of
disease and aiding the process of biological control Full year-round production is possible Fruit tends to be more consistent in terms of quality and
taste. Less disease and fungi problemsEnergy is used more
effectively and overall use/kg of product will be lower. Increase CO2 and irrigation cycles Stronger and quicker root development
3
More light, more growth
Max
115000lux (1400micromol/m2.s)
Light Level
The general lighting saturation level can be as high as 115000lux, which from a practical point of view, cannot be achieved. Thus normally always more light, more growth.
But more lighting increases the cost
Reasonable payback would appear to be possible for an installation producing 6,000 to 15,000 lux.
4
Typical Applications
Propagation.Seeding, Plant raising, Eggplant,(Aubergine), Cucumber, Sweet pepper,Tomato
Bedding Plants. Ageratum, Antirrhinum,snapdragon, Begonia, Dianthus,carnation, Gazania, Impatiens, Pelargonium, geranium, Petunia
Potted Plants. Kalanchoe,Chrysanthemum, orchids
Cut Flowers. Alstromeria,Roses,Gerbera
5
Influece of supplemental lighting
Following slides show some research/practical results in terms of supplemental lighting in greenhouse. Most of
them are extracted from academic papers.
6
Tomato
Tomatoes cultivated in the Netherlands, lit with 10,000 lux can produce 92 kg/m2 annually, and with 15,000 lux it is possible to produce 104 kg/m2.
When production is unlit the harvest Is about 59kg/m2.
-- Harry Stijger
7
Rose With supplementary lighting the production was 24% higher than the
control.. the development of axillary buds was promoted, the number of flowers with inferior quality was less. There was no
influence of supplementary lighting on the total number of flowers. C.
Vonk Noordegraaf, SUPPLEMENTARY LIGHTING AT THE ROSE CV 'SONIA'
An increase in the lighting period (LP) enhanced the number of
flowering shoots by 12% and fresh weight per shoot by 5%. MORTENSEN L. M. „Influence of air humidity and lighting period on growth, vase life and water relations of 14 rose cultivars“
8
Scaevola
Influence of CO2 + HPS lighting combo
9
Additional practical Information
18 to 20 hour/day ( day length + supplemental ) lighting time can be very helpful
For a rough calculation, each 10m2 /600W can reach 6000lux. (Distance 2-3m)
Each 1000lux lighting can increase the temperature of greenhouse 0.7degree
1 Micromol (umol)=7.62 FC(foot candle)=81.9lux
10
Lamp and application
Kelvin Color Temperature
Incandescent lamp has low efficiency, high temperature, short bulb life time
Fluorescent lamp has good efficiency, suitable for seeding, leaf lettuce, spinach
HPS lamp has very high efficiency, used in less color critical applications such as parking lots, street lights and horticultural lighting.
The orange/red spectrum helps to produce larger harvests of higher quality fruits or flowers.
MH lamp has high efficiency, close nature sunlight thus suitable for stadium, malls. Crops has nature look but not high yield.
Note: High Pressure Sodium (HPS) lamp and Metal Halide (MH) lamp all belong to High Intensity Discharge (HID) lamps. It needs a driver, i.e. ballast.
11
Magnetic vs. Electronic ballast
Type
Magnetic Ballast Electronic Ballast
Power 400W 600W 400W 600W
Operating Current (A) 7.5 9 2.3 2.95
Total Power Consumed (VA)
10121364 420 623
PF 0.43 0.47 0.99 0.99
Waste Power Saved 56% 58%
Bulb Lifetime 1
1 2 2
Energy-saving up 58%
Prolong Bulb life time
We focus on the electronic ballast only!
12
LeuchTek GmbH LeuchTek GmbH
& Products& Products
13
LeuchTek, your partner in greenhouse lighting
LeuchTek is a dynamic player in agricultural supplemental lighting
Especially LeuchTek offers HPS electronic ballast
Located in Hamburg, service for European market
14
Products for Greenhouse
PLG602,402 series (600w, 400w) PLG601,401 series (600w, 400w)
PLG603,403 series (600w, 400w)
PLG1200,800 series (1200w, 800w)
Available 230V 50Hz / 120V 60Hz
PLG2-3 reflector
PLG2-4 reflector
15
Our Strength
Convenient and robust connection box
The only product which is certified by TUV-GS, UL, FCC
RoHS compliance tested and passed
Second prize winner of Hortifair 2003
4 international patents
Best quality/price rate; state-of-art design
16
If you need quotations or rough designs, please contact us
LeuchTek GmbHHans-Henny-Jahnn-Weg 1722085 Hamburg, GermanyTel: +49 40 23495747Email: [email protected]