Post on 26-Jan-2021
B2007 M1
Dev
iceN
et™Med
ia
DeviceNet™ Physical Media Connectivity
Part Number Keys M4
Cordsets M10
Receptacles M39
FieldWireables M46
• Cables that meet the requirements of the ODVA• PLTC rated cable• Available in thin, mid, and thick styles• 7/8 and M12 connectors• Rated up to 9 Amps and 600 Volts• IP67/IP69K rated
Features
https://www.valinonline.com/catalog/manufacturers/turck/connectivity
M2 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™ SystemDescriptionDeviceNet is a low-cost communications protocol that eliminates hard wiring and connects industrial devices such as limitswitches, photoelectric sensors, valve manifolds, motor starters, process sensors, bar code readers, variable frequency drives,panel displays and operator interfaces to a network. DeviceNet's direct connection provides improved communicationbetween devices, as well as important device-level diagnostics not easily accessible or available through hard-wired I/Ointerfaces.
DeviceNet is based on the Controller Area Network (CAN) broadcast-oriented communication architecture. CAN uses a busarbitration method, CSMA/BA, that assures the highest priority message always gets use of the bus in the event of a datacollision. The DeviceNet protocol further defines message priorities such that I/O messages are given top priority andconfiguration messages have lower priority.
A DeviceNet network supports up to 64 nodes and virtually an unlimited amount of I/O. The bus uses a trunkline/droplinetopology, where bus power and communication are supplied on a single cable. Bus power is 24 VDC and supplies current tooperate the nodes and (typically) power input devices. Some TURCK stations require an additional 24 VDC auxiliary power tosupply current for outputs.
DeviceNet allows peer-to-peer data exchange (where a DeviceNet node can initiate communication with other nodes orpeers), and a master/slave configuration in which the master node initiates all communication and all other nodes, or slaves,respond to the master node’s requests.
Typical System Configuration
A typical DeviceNet system consists of the following parts:
• A - Controller• B - Power Supply
• C - DeviceNet Cable• D - DeviceNet I/O Modules (or Slaves)
• E - Terminating Resistors
DeviceNet stations require a network master (also called a scanner) to interface the stations to the host controller.TURCK DeviceNet stations are designed to be fully compatible with DeviceNet equipment from other manufacturers.
C
A
B
C
D
C
C D
E
D
D
E
D
RSMCBC5 5711-1M
RSM 57-TR2
RSC CBC5 572-1M
RKM 46-1M
JBBS-57-SM01
FDNP-S0404G-TT
RKM RKC 5711-1M
BL67 I/O System
Power Supply
PLC
RSM2RKM 57
BL20 I/O System
FDN20-4S-4XSG-E
FDNQ-S0400-T
RSM RSM 5711-2M
B2007 M3
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
Cordsets
TURCK offers a complete line of molded DeviceNet cordsets to facilitate network installation, resulting in a faster start-up andfewer wiring errors. The bus and drop cables are specially designed foil-shielded, high-flex cables with very low inductanceand capacitance to minimize propagation delay time. DeviceNet cables consist of a shielded and twisted data pair, as well asa shielded and twisted power pair for the 24 VDC bus power, with an additional outer shield. The 24 VDC power pair providesbus power to the station’s communication electronics and (typically) to input circuits.
The data lines for CAN-High and CAN-Low differential signals conform to the CAN standard, and support network dataexchange at the maximum transmission speed of 500 kbps.
In most cases, bus cable connections are made using 5-pin minifast ® (7/8-16 UN) or eurofast ® (M12) connectors. A variety ofstations are also available that support terminal-block type connections. Stations with output circuits for DC actuatorsnormally require 24 VDC auxiliary power fed through a separate connection from the communication bus.
TURCK cordsets for the DeviceNet system are available in standard lengths. Contact your local sales representative to ordercustom lengths.
Diagnostics
TURCK stations provide increased diagnostics when used with standard proximity or photoelectric sensors and discreteactuators. TURCK stations also serve as a buffer between I/O devices and the DeviceNet bus by detecting short-circuitswithout disrupting DeviceNet communication.
For deluxe style stations, each I/O point on the station provides state and status data. State data represents the real worldvalue of the I/O device; for example, when the sensor is on or the actuator is off. Status data indicates short-circuits in the I/Odevice or in the wiring between the device and the station. Some models also use status data to indicate open circuits.
State and status data are transferred to the DeviceNet scanner where it is available for fault handling in the control program.Additionally, each input and output has a multicolored LED to indicate its state and status and pinpoint I/O problems quickly;for example the module status LED indicates the internal health of the station, and the network status LED indicates thestation’s communication on the DeviceNet network.
Addressing
The valid range of DeviceNet node addresses is 0 to 63. The station’s default node address is 63. Each node’s address must beinitially set, usually via rotary dials or switches on the node. The address can also be set with a DeviceNet configuration tool.
Changes to the address settings take effect when the station power is cycled. Care must be taken to prevent the same addressfrom being assigned to more than one node in a system. If the same address is set on multiple nodes, one node will takecontrol of the address and the others will go into “Critical Link Failure” state, indicated by the network status LED (solid red).
M4 B2007
DeviceNet™ Physical Media Connectivity
W K M 57x - *M
K = Female Connector, Female ThreadsS = Male Connector, Male Threads
Gender
R = StraightW = Right Angle
7/8-16UN (minifast)
Consult factory for other lengths.
Length in Meters (*)
(Blank) = NylonM = Nickel Plated BrassV = Stainless Steel
Coupling Nut Material
minifast Receptacle Part Number Key
minifast® Cordset Part Number Key
R K F V 57x - *M /NPT
Consult factory for other lengths.
Length in Meters (*)
57 = DeviceNet™
Protocol
57 = DeviceNet™
Protocol
K = Female Connector, Female ThreadsS = Male Connector, Male Threads
Gender
Designator for Receptacle
(Blank) = Front MountP = Back Panel Mount
Mounting Style
(Blank) = Anodized AluminumK = NylonV = Stainless Steel
Material
7/8-16UN (minifast)
(Blank) = Leads or PCB PinsL = Solder Cup
Connection Type
(Blank) = 1/2-14 NPSM Threads/NPT = 1/2-14 NPT Threads/14.5 = 1/2-14 NPT Full Length Threads/14.75 = 3/4-14 NPT Full Length Threads/M20 = M20 Threads
Connection Thread
Part Number Keys are to assist in IDENTIFICATION ONLY. Consult factory for catalog items not identified.
B2007 M5
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
Part Number Keys are to assist in IDENTIFICATION ONLY. Consult factory for catalog items not identified.
R S C W V 57x - *M
K = Female Connector, Female ThreadsS = Male Connector, Male Threads
Gender
C = Large Plug BodyG = Robust Large Plug BodyS = Shielded to Coupling NutT = Small Plug Body
Plug Body
R = StraightW = Right Angle
M12x1 (eurofast)
Consult factory for other lengths.
Length in Meters (*)
(Blank) = Standard KeyD = D-coding KeyW = Reverse Key
Keying Options
eurofast Receptacle Part Number Key
57 = DeviceNet™
Cable Type (x)
eurofast® Cordset Part Number Key
F S F V 57x - *M
K = Female Connector, Female ThreadsS = Male Connector, Male Threads
Gender
(Blank) = Front MountF = StandardFD = Standard Back Panel MountS = Shielded to Receptacle HousingSDE = Shielded Back Panel Mount, Large Body
Housing Style
M12x1 (eurofast)
Consult factory for other lengths.
Length in Meters (*)
(Blank) = Nickel Plated BrassV = Stainless Steel
Coupling Nut Material
57 = DeviceNet™
Cable Type (x)
(Blank) = Nickel Plated BrassK = NylonU = PVDFV = Stainless Steel
Coupling Nut Material
(Blank) = Standard KeyD = D-coding KeyW = Reverse Key
Keying Options
M6 B2007
DeviceNet™ Physical Media Connectivity
picofast® Part Number Key
P S G E 5 M 57x - *M
Consult factory for other lengths.
Length in Meters (*)
Part Number Keys are to assist in IDENTIFICATION ONLY. Consult factory for catalog items not identified.
(Blank) = Nickel Plated BrassV = Stainless Steel
Coupling Nut (Threaded coupling nut only)
G =StraightW = Right Angle
Configuration
57 = DeviceNet™
Cable Type (x)
Number of Pins
M8x1 (picofast)
K = Female ConnectorS = Male Connector
Gender
M F K S 5 F 57x - *
M = straightWM = right angle (PCB pins)
M8 picofast Receptacle
(blank) = snap lockS = threadedSH = threaded and mounting bracketSHL = threaded and long mounting bracket
Connection Type
Number of Wires
K = female connectorS = male connector
Gender
Designator for Receptacle
PCB = PCB pins
PCBF = PCB pins
Connection Type / Length in Meters
M8 picofast ® Receptacle Part Number Key
Part Number Keys are to assist in IDENTIFICATION ONLY. Consult factory for catalog items not identified.
(Blank) = Snap lock (No Locking Sleeve)M = M8x1 Threaded Coupling NutZ = Snap lock (locking sleeve)
LockingMethod
(blank) = front mount (rear thread and locknut)F = rear mount (front thread and locknut)
Mounting Style
57 = DeviceNet™
Cable Type (x)
B2007 M7
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
• Cable that Meets the Requirements of ODVA Thin or Type 1Cable
• Commonly Used as Drop Cable to aMaximum Length of 6Meters (20 Feet) or Trunk Cable in Networks Up to aMaximum Length of 100Meters (328 Feet)
DeviceNet™, Thin Cable Specifications
Type Approvals
Power Pair Data Pair Outer Jacket ShieldsBulk Cable
Part Number /Weight/300M
AWGColor Code
DCR (/1000feet)Insulation
AWGColor Code
DCR (/1000feet)
Insulation
Material ColorNominal O.D.
TypeDrain Wire
572AWM 246475°C 300 Volts
NEC PLTCCEC AWM-I/II A/B FT4
RoHS
2/22 AWGBK/RD
18.1 OhmsPVC
2/22 AWGBU/WH
18.1 OhmsPE
PVC Light Grey7.2 mm (.285
in)
Foil22 AWG
RB50603-*M44 lbs.
577AWM 246475°C 300 Volts
NEC PLTCCEC AWM-I/II A/B FT4
RoHS
2/22 AWGBK/RD
16.9 OhmsPVC
2/22 AWGBU/WH
16.9 OhmsPE
PVC Light Grey8.4 mm (.330
in)
Foil/Braid22 AWG
RB50629-*M65 lbs.
flexlife-10 ®
578AWM 246475°C 300 Volts
NEC PLTC/CL2CEC CMGRoHS
2/22 AWGBK/RD
18.1 OhmsPVC
2/22 AWGBU/WH
18.1 OhmsPE
PVC Light Grey7.8 mm (.310
in)
Foil/Braid22 AWG
RB50651-*M51 lbs.
5715AWM 209580°C 300 Volts
NEC AWMCEC AWM-I/II A/B FT1
RoHS
2/22 AWGBK/RD
16.5 OhmsPVC
2/22 AWGBU/WH
16.5 OhmsPE
PVC Light Grey6.0 mm (.235
in)
Foil (DataOnly)
22 AWG
RB50764-*M26 lbs.
5725AWM 2108075°C 300 Volts
NEC AWMRoHS
2/22 AWGBK/RD
16.5 OhmsPE
2/24 AWGBU/WH
27.7 OhmsPE
TPU Violet7.1 mm (.280
in)
Foil/Braid22 AWG
RB50994-*M50 lbs.
Halogen-Free ††
5732AWM 2062680°C 600 Volts
NEC AWMCEC AWM-I/II A/B FT4
RoHS
2/22 AWGBK/RD
16.5 OhmsPVC
2/22 AWGBU/WH
16.5 OhmsPE
TPE CharcoalGrey
8.5 mm(.335 in)
Foil/Braid22 AWG
RB51296-*M68 lbs.
Flexlife®
weldlife™
* Indicates length in meters.Standard spool lengths are 30, 75, 100, 150, 200, 225, 300. Consult factory for other lengths.
†† Zero Halogen: to DIN VDE 0472 part 815 + IEC 60754-1
Data Rate Maximum Trunk LengthDrop Length
Maximum Cumulative
125 Kbaud 100 meters (328 feet)
6 meters (20 feet)
156 meters (512 feet)
250 Kbaud 100 meters (328 feet) 78 meters (feet)
500 Kbaud 100 meters (328 feet) 39 meters (feet)
BlueWhiteBlackRed
Jacket
Overall Foil Shield
Power
Braid Shield
Foil Shield
DrainWire
Data
M8 B2007
DeviceNet™ Physical Media Connectivity
• Cable That Meets the Requirements of ODVAMidor Type III Cable
• Provides More Flexibility When Used as a TrunkCable Up to aMaximum Length of 300Meters (984Feet)
DeviceNet™, Mid Cable Specifications
Type Approvals
Power Pair Data Pair Outer Jacket ShieldsBulk Cable
Part Number /Weight/300M
FigureAWGColorCode
DCR (/1000feet)
Insulation
AWGColor Code
DCR (/1000feet)
Insulation
Material ColorNominal O.D.
TypeDrainWire
5711AWM 246480°C 300 Volts
NEC PLTCCEC AWM-I/II A/B FT4RoHS
2/16 AWGBK/RD
4.1 OhmsPVC
2/20 AWGBU/WH
11.2 OhmsPE
PVC Light Grey8.4 mm (.330in)
Foil/Braid20 AWG
RB50721-*M65 lbs.
A
5722AWM 246475°C 300 Volts
NEC PLTCCEC AWM-I/II A/B FT4RoHS
2/17 AWGBK/RD
5.2 OhmsSR-PVC
2/20 AWGBU/WH
10.4 OhmsPE
PVC Light Grey8.9 mm (.350in)
Foil/Braid20 AWG
RB50876-*M71 lbs.flexlife-10 ®
A
5723AWM 2023380°C 300 Volts
NEC AWMCEC AWM-I/II A/B FT1RoHS
2/17 AWGBK/RD
5.2 OhmsPVC
2/20 AWGBU/WH
10.4 OhmsPE
TPU Light Grey8.4 mm (.330in)
Foil/Braid20 AWG
RB50877-*M60 lbs.flexlife-10
A
5721A75°C 300 Volts
NEC PLTC/CMCEC CMG HL ABCDRoHS
2/18 AWGBK/RD
6.7 OhmsPVC
2/20 AWGBU/WH
10.4 OhmsPE
PVC Light Grey14.9 mm (.585in)AluminumArmor
Foil/Armor20 AWG
RB50859-*M101 lbs.armorfast
®
B
5731AWM 2062680°C 300 Volts
NEC AWMCEC AWM-I/II A/B FT1RoHS
2/16 AWGBK/RD
4.1 OhmsPVC
2/20 AWGBU/WH
10.4 OhmsPE
TPE CharcoalGrey9.6 mm(.254 in)
Foil/Spiral20 AWG
RB51235-*M95 lbs.flexlife
†
weldlife™
A
5737AWM 2023380°C 300 Volts
NEC AWMCEC AWM-I/II A/B FT1
2/17 AWGBK/RD
5.8 OhmsPVC
2/20 AWGBU/WH
11.2 OhmsPE
TPU Grey8.4 mm (.331)
Foil22 AWG
RB51903-*M60 lbs.C-Track
A
* Indicates length in meters.Standard spool lengths are 30, 75, 100, 150, 200, 225, 300. Consult factory for other lengths.
Data Rate Maximum Trunk Length
125 Kbaud 300 meters (984 feet)
250 Kbaud 250 meters (820 feet)
500 Kbaud 100 meters (328 feet)
Figure ABlueWhiteBlackRed
Figure BBlueWhiteBlackRed
AluminumArmor
Foil Shield
Braid Shield
Jacket
Power
DrainWire
Data
Jacket
DrainWire
Power
Data
Foil Shield
Overall Foil Shield
Inner Jacket
B2007 M9
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, Thick Cable Specifications
Type Approvals
Power Pair Data Pair Outer Jacket ShieldsBulk Cable
Part Number /Weight/300M
AWGColorCode
DCR (/1000feet)Insulation
AWGColorCode
DCR (/1000feet)Insulation
Material ColorNominal O.D.
TypeDrain Wire
575AWM 2023380°C 300 Volts
NEC AWMCEC AWM-I/II A/B FT1RoHS
2/15 AWGBK/RD
3.3 OhmsPVC
2/18 AWGBU/WH
6.5 OhmsPE
TPU Light Grey10.4 mm (.409in)
Foil/Braid18 AWG
RB50633-*M94 lbs.
579AWM 257075°C 300 Volts
NEC PLTC/CL2CEC CMGRoHS
2/15 AWGBK/RD
3.2 OhmsPVC
2/18 AWGBU/WH
6.5 OhmsPE
PVC Light Grey11.2 mm (.441in)
Foil/Braid18 AWG
RB50652-*M122 lbs.
572075°C 600 Volts
NEC TCRoHS
2/16 AWGBK/RD
4.9 OhmsPVC
2/18 AWGBU/WH
6.9 OhmsPE
PVC Light Grey13.3 mm (.524in)
Foil/Braid16 AWG
RB50793-*M168 lbs.
5726AWM 2108070°C 300 Volts
NEC AWMRoHS
2/15 AWGBK/RD
3.2 OhmsPE
2/18 AWGBU/WH
6.9 OhmsPE
TPU Violet11.2 mm (.449in)
Foil/Braid18 AWG
RB51038-*M150 lbs.Halogen-Free††
572775°C 600 Volts
NEC PLTCCEC AWM-I/II A/B FT4RoHS
2/15 AWGBK/RD
3.44 OhmsPVC
2/18 AWGBU/WH
7.06 OhmsPE
PVC Light Grey12.5 mm(.492 in)
Foil/Spiral18 AWG
RB51106-*M157 lbsflexlife ® †
5730AWM 2062680°C 600 Volts
NEC AWMCEC AWM-I/II A/B FT1RoHS
2/15 AWGBK/RD
3.44 OhmsPVC
2/18 AWGBU/WH
7.06 OhmsPE
TPE Grey10.5 mm (.413in)
Foil/Braid18 AWG
RB51231-*M110 lbs.flexlife †
weldlife™†
* Indicates length in meters.Standard spool lengths are 30, 75, 100, 150, 200, 225, 300. Consult factory for other lengths.
†† Zero Halogen: to DIN VDE 0472 part 815 + IEC 60754-1
Data Rate MaximumTrunk LengthMaximum Trunk Length
(5720)
125 Kbaud 500 meters (1640 feet) 420 meters (1378 feet)
250 Kbaud 250 meters (820 feet) 200 meters (656 feet)
BlueWhiteBlackRed
Foil Shield
Overall Foil Shield
JacketDrainWire
Power
Data
• Cable That Meets the Requirements of ODVAThick or Type II Cable
• It Provides theMost Power to a NetworkWhenUsed as a Trunk Cable Up to aMaximum StandardCable Length of 500Meters (1640 Feet)
M10 B2007
DeviceNet™ Physical Media Connectivity
minifast®
eurofast® (Thin/Mid Only)
Pin (Male) Socket (Female) Pin (Male)
RSM WSM RKM WKM RSC
Bare
RSM 57x-*M WSM 57x-*M RKM 57x-*M WKM 57x-*M RSC 57x-*M
min
ifa
st
Pin(M
ale)
RSM
RSM RSM 57x-*M RSM WSM 57x-*M RSM RKM 57x-*M RSM WKM 57x-*M RSM RSC 57x-*M
WSM
WSM WSM 57x-*M WSM RKM 57x-*M WSM WKM 57x-*M WSM RSC 57x-*M
Socket
(Fem
ale)
RKM
RKM RKM 57x-*M RKM WKM 57x-*M RKM RSC 57x-*M
WKM
WKM WKM 57x-*M WKM RSC 57x-*M
See pages M16 - M17 for dimensional drawings.* Indicates length in meters.x Indicates cable type.
Standard cable lengths are 1, 2, 4, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.For stainless steel coupling nuts change part number RSM … to RSV, WSM … to WSV.
1 2 743
1
2
3
4
DeviceNet™, Cable/Cordset SelectionMatrix
minifast Pinouts eurofast
1. Bare (Shield Drain Wire)2. Red (+ Voltage)3. Black (- Voltage)4. White (CAN_H)5. Blue (CAN_L)
Female FemaleMaleMale
B2007 M11
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
eurofast® (Thin/Mid Only) minifast ® Bulkhead eurofast Bulkhead (Thin Only)
Pin (Male) Socket (Female) Application Pin (Male) Socket (Female) Pin (Male) Socket (Female)
WSC RKC WKC RSFP RKFP FSFD FKFD
WSC 57x-*M RKC 57x-*M WKC 57x-*M RSFP 57x-*M RKFP 57x-*M FSFD 57x-*M FKFD 57x-*M
RSM WSC 57x-*M RSM RKC 57x-*M RSM WKC 57x-*M RSM RSFP 57x-*M RSM RKFP 57x-*M RSM FSFD 57x-*M RSM FKFD 57x-*M
WSM WSC 57x-*M WSM RKC 57x-*M WSM WKC 57x-*M WSM RSFP 57x-*M WSM RKFP 57x-*M WSM FSFD 57x-*M WSM FKFD 57x-*M
RKM WSC 57x-*M RKM RKC 57x-*M RKM WKC 57x-*M RKM RSFP 57x-*M RKM RKFP 57x-*M RKM FSFD 57x-*M RKM FKFD 57x-*M
WKM WSC 57x-*M WKM RKC 57x-*M WKM WKC 57x-*M WKM RSFP 57x-*M WKM RKFP 57x-*M WKM FSFD 57x-*M WKM FKFD 57x-*M
8 9 10 5 6 13 14
DeviceNet™, Cable/Cordset SelectionMatrix
M12 B2007
DeviceNet™ Physical Media Connectivity
eurofast® (Thin/Mid Only)
Pin (Male) Socket (Female)
RSC RSA WSC RKC WKC RKA
Bare
RSC 57x-*M RSA 57x*-M WSC 57x*-M RKC 57x-*M WKC 57x-*M RKA 57x-*M
eu
ro
fas
t(Thin/Mid
Only)
Pin(M
ale)
RSC
RSC RSC 57x-*M RSC WSC 57x-*M RSC RKC 57x-*M RSC WKC 57x-*M
RSA
RSA RSA 57x-*M
WSC
WSC WSC 57x-*M WSC RKC 57x-*M WSC WKC 57x-*M
Socket
(Fem
ale) RKC
RKC RKC 57x-*M RKC WKC 57x-*M
WKC
WKC WKC 57x-*M
RKA
RKA RKA 57x-*M
See pages M16 - M17 for dimensional drawings.* Indicates length in meters.x Indicates cable type.
Standard cable lengths are 1, 2, 4, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.For stainless steel coupling nuts change part number RSM … to RSV, WSM … to WSV.
7
8
9
10
DeviceNet™, Cable/Cordset SelectionMatrix
Pinouts eurofast
1. Bare (Shield Drain Wire)2. Red (+ Voltage)3. Black (- Voltage)4. White (CAN_H)5. Blue (CAN_L)
FemaleMale
128 9 10
7
11
11
12
B2007 M13
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
minifast® Bulkhead eurofast Bulkhead (Thin Only)
Pin (Male) Socket (Female) Pin (Male) Socket (Female)
RSFP RKFP FSFD FKFD
RSFP 57x-*M RKFP 57x-*M FSFD 57x-*M FKFD 57x-*M
RSC RSFP 57x-*M RSC RKFP 57x-*M RSC FSFD 57x-*M RSC FKFD 57x-*M
WSC RSFP 57x-*M WSC RKFP 57x-*M WSC FSFD 57x-*M WSC FKFD 57x-*M
RKC RSFP 57x-*M RKC RKFP 57x-*M RKC FSFD 57x-*M RKC FKFD 57x-*M
WKC RSFP 57x-*M WKC RKFP 57x-*M WKC FSFD 57x-*M WKC FKFD 57x-*M
5 6 13 14
DeviceNet™, Cable/Cordset SelectionMatrix
M14 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, Open Connector Cordset SelectionMatrix
minifast®
eurofast®
Pin (Male) Socket (Female) Pin (Male)
RSM WSM RKM WKM RSC
CBC5
CBC5 57x-*M RSM CBC5 57x-*M WSM CBC5 57x-*M RKM CBC5 57x-*M WKM CBC5 57x-*M RSC CBC5 57x-*M
BK52C
BK52C 57x-*M RSM BK52C 57x-*M WSM BK52C 57x-*M RKM BK52C 57x-*M WKM BK52C 57x-*M RSC BK52C 57x-*M
Thin, Mid and Thick Cable Thin Cable Only
See pages M16 - M17 for dimensional drawings.* Indicates length in meters.x Indicates cable type.
Standard cable lengths are 1, 2, 4, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.For stainless steel coupling nut: Change part number (RSM … to RSV, RSC … to RSCV).
16
15
1 2 743
minifast Pinouts eurofast
1. Bare (Shield Drain Wire)2. Red (+ Voltage)3. Black (- Voltage)4. White (CAN_H)5. Blue (CAN_L)
Female FemaleMaleMale
B2007 M15
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, Open Connector Cordset SelectionMatrix
eurofast®
minifast® Bulkhead eurofast Bulkhead
Pin (Male) Socket (Female) Pin (Male) Socket (Female) Pin (Male) Socket (Female)
WSC RKC WKC RSFP RKFP FSFD FKFD
WSC CBC5 57x-*M RKC CBC5 57x-*M WKC CBC5 57x-*M RSFP CBC5 57x-*M RKFP CBC5 57x-*M FSFD CBC5 57x-*M FKFD CBC5 57x-*M
WSC BK52C 57x-*M RKC BK52C 57x-*M WKC BK52C 57x-*M RSFP BK52C 57x-*M RKFP BK52C 57x-*M FSFD BK52C 57x-*M FKFD BK52C 57x-*M
Thin and Mid Cable Only Thin, Mid and Thick Cable Thin Cable Only
See pages M16 - M17 for dimensional drawings.* Indicates length in meters.x Indicates cable type.
Standard cable lengths are 1, 2, 4, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
8 9 10 5 6 13 14
CBC5 Pinouts BK52C
1 = Black (- Voltage)2 = Blue (CAN_L)3 = Bare (Shield Drain)4 = White (CAN_H)5 = Red (+ Voltage)
16
BK52C .. PageM10
15
CBC5 .. PageM10
12345
Overmold: TPUContact Carrier: PA (Nylon)Protection: NEMA 1, and IEC IP 20Rated Voltage: 250 VRated Current: 12 AAmbient Temperature: -40° to +75°C (-22° to +167°F)
Specifications
M16 B2007
DeviceNet™ Physical Media Connectivity
3
RKM .. Pages M6 - M11
4
WKM .. Pages M6 - M11
6
RKFP .. Pages M6 - M11
DeviceNet™, minifast ® Cordset and Receptacle Connector Dimensions
1
RSM .. Pages M6 - M11
2
WSM .. Pages M6 - M11
5
RSFP .. Pages M6 - M11
Overmold: TPUCoupling Nut: Nickel Plated CuZn or Stainless SteelContact Carrier: TPUContacts: Gold Plated CuZnProtection: NEMA 1, 3, 4, 6P and IEC IP 67Rated Voltage: 300 VRated Current: 9 AAmbient Temperature: -40° to +75°C (-22° to +167°F)
Specifications
FSFD .. Pages M6 - M11 FKFD ..
B2007 M17
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
12
RKA .. Pages M6 - M11
8
WSC .. Pages M6 - M11
13
DeviceNet™, eurofast ® Cordset and Receptacle Connector Dimensions
9
RKC .. Pages M6 - M11
10
WKC .. Pages M6 - M11
14
Pages M6 - M11
Overmold: TPUCoupling Nut: Nickel Plated CuZn or Stainless SteelContact Carrier: TPU or POM (Nylon)Contacts: Gold Plated CuZnProtection: NEMA 1, 3, 4, 6P and IEC IP 68Rated Voltage: 250 VRated Current: 4 AAmbient Temperature: -40° to +75°C (-22° to +167°F)
Specifications
7
RSC .. Pages M6 - M11
11
RSA .. Pages M6 - M11
M18 B2007
DeviceNet™ Physical Media Connectivity
Type Approvals
Power Pair Data Pair Outer Jacket ShieldsBulk Cable
Part Number /Weight/300M
AWGColor Code
DCR (/1000feet)
Insulation
AWGColor Code
DCR (/1000feet)
Insulation
Material ColorNominal O.D.
TypeDrain Wire
571375°C 300 Volts
NEC CL2CEC AWM-I/II A/B FT4
2/16 AWGBK/RD
4.1PE
2/16 AWGBU/WH
4.1PE
PVC Light GreyFlat Profile††
NoneRB50787-*M116 lbs.
* Indicates length in meters.†† Flat cable profile is 19.3 mm (0.760 in) x 5.3 mm (0.210 in).
RedWhiteBlueBlack
DeviceNet™, Flat Cable Specifications
• Cable that Meets the Requirements of ODVA FlatCable
• Uses Insulation Displacement Connectors asDevice Taps
Flat Cable Profile
Data Rate Maximum Trunk Length
125 Kbaud 420 meters (1378 feet)
250 Kbaud 200 meters (656 feet)
500 Kbaud 100 meters (328 feet)
Jacket
B2007 M19
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, Flat Cable Connectors
Female
Female
Female
• Provides a minifast ® or eurofast ® DropConnector from Flat Cable
Housing: POM (Nylon)Coupling Nut: Nickel Plated CuZn or Stainless SteelContact Carrier: NylonContacts: Gold Plated CuZnProtection: NEMA 1, 3, 4, 6P and IEC IP 68Rated Voltage: 250 VRated Current: 4 A (eurofast), 9 A (minifast)Ambient Temperature: -40° to +75°C (-22° to +167°F)
Specifications
Housing Part Number Application Pinouts
RKF 57-IDCFlat cable connector, tofemale (7/8-16UN) minifastdrop
RKF 40-IDC(7/8-16UN) minifast,auxiliary power connector
FK 57-IDCFlat cable connector tofemale (M12x1) eurofastdrop
FK 57-IDC ET
Includes connector, end termination, and splice kit
RKF 57-IDC ET
RKF 40-IDC ET
M20 B2007
DeviceNet™ Physical Media Connectivity
Type Approvals
Power Pair Data Pair Outer Jacket ShieldsBulk Cable
Part Number /Weight/300M
AWGColorCode
DCR (/1000feet)
Insulation
AWGColorCode
DCR (/1000feet)
Insulation
Material ColorNominal O.D.
TypeDrain Wire
5724AWM 246480°C 300 Volts
NEC AWMCEC AWM-I/II A/B FT1RoHS
2/24AWGBK/RD
24.9PVC
2/24AWGBU/WH
24.9PE
PVC Light Grey5.7 mm (.224in)
Foil (DataOnly)24 AWG
RB51045-*M27 lbs.
5715AWM 246480°C 300 Volts
NEC AWMCEC AWM-I/II A/B FT1RoHS
2/22AWGBK/RD
16.5PVC
2/22AWGBU/WH
16.5PE
PVC Light Grey6.0 mm (.235in)
Foil (DataOnly)22 AWG
RB50764-*M26 lbs.
* Indicates length in meters.Standard cable lengths are 1, 2, 4, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
DeviceNet™, Pico Cable Specifications
Data Rate Maximum Trunk Length
125 Kbaud 35 meters (115 feet)
250 Kbaud 35 meters (115 feet)
500 Kbaud 35 meters (115 feet)
DeviceNet - Pico Cable 5724
Data Rate Maximum Trunk Length
125 Kbaud 100 meters (984 feet)
250 Kbaud 100 meters (820 feet)
500 Kbaud 100 meters (328 feet)
DeviceNet - Thin Cable 5715
BlueWhiteBlackRed
• Cable that Meets the Electrical Requirements ofODVA Thin Cable
• Pico Cable has 24 AWG Conductors WhichMay beUsed with picofast ® Connectors
Foil Shield
Overall Foil Shield
Power
Data
Jacket
B2007 M21
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
10
DeviceNet™, Cable/Cordsets SelectionMatrix - Threaded
picofast Pinouts eurofast
1. Bare (Shield Drain Wire)2. Red (+ Voltage)3. Black (- Voltage)4. White (CAN_H)5. Blue (CAN_L)
FemaleMale Male Female
4
picofast (M8) eurofast (M12)
Socket (Female) Pin (Male) Pin (Male) Pin (Male) Socket(Female)Socket
(Female)
PKG 5M PKW 5M PSG 5M PSW 5M RST WST RKT WKT
Bare
PKG 5M-57x PKW 5M-57x PSG 5M-57x PSW 5M-57x RST 57x* WST 57x RKT 57x-* WKT 57x-*
Socket
(Fem
ale)
PKG 5M
PKG 5M PKG 5M-57x PKG 5M PKW 5M-57x PKG 5M PSG 5M-57x PKG 5M PSW 5M-57x PKG 5M RST 57x*M PKG 5M WST 57x*M PKG 5M RKT 57x*M PKG 5M WKT 57x*M
PKW 5M
PKW 5M PKW 5M-57x PKW 5M PSG 5M-57x PKW 5M PSW 5M-57x PKW 5M RST 57x*M PKW 5M WST 57x*M PKW 5M RKT 57x*M PKW 5M WKT 57x*M
Pin(M
ale)
PSG 5M
PSG 5M PSG 5M-57x PSG 5M PSW 5M-57x PSG 5M RST 57x*M PSG 5M WST 57x*M PSG 5M RKT 57x*M PSG 5M WKT 57x*M
PSW 5M
PSW 5M PSW 5M-57x PSW 5M RST 57x*M PSW 5M WST 57x*M PSW 5M RKT 57x*M PSW 5M WKT 57x*M
See pages M23 - M24 for dimensional drawings.* Indicates length in meters.x Indicates cable type. See page B125 for available cable types.
Standard cable lengths are 1, 2, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.For stainless steel coupling nuts change part number PSG 5M … to PSGV 5M, PSW 5M … to PSWV 5M.
3
1
4
3
2 87 9
2
1
M22 B2007
DeviceNet™ Physical Media Connectivity
10
DeviceNet™, Cable/Cordsets SelectionMatrix - Snap Lock
picofast Pinouts eurofast
1. Bare (Shield Drain Wire)2. Red (+ Voltage)3. Black (- Voltage)4. White (CAN_H)5. Blue (CAN_L)
FemaleMale Male Female
picofast® eurofast ®
Socket (Female) Pin (Male) Pin (Male) Pin (Male) Socket (Female) Socket (Female)
PKG 5Z PSG 5 RST WST RKT WKT
Bare
PKG 5Z 57x-*M PSG 5 57x-*M RST 57x-* WST 57x-* RKT 57x-* WKT 57x-*
pic
ofa
st®(572
4Ca
bleOnly)
Socket
(Fem
ale)
PKG 5Z
PKG 5Z PKGZ 5Z 57x-*M PKG 5Z PSG 57x-*M PKG 5Z RST 57x-*M PKG 5Z WST 57x-*M PKG 5Z RKT 57x-*M PKG 5Z WKT 57x-*M
Pin(M
ale)
PSG 5
PSG 5 PSG 5 57x-*M PSG 5 RST 57x-*M PSG 5 WST 57x-*M PSG 5 RKT 57x-*M PSG 5 WKT 57x-*M
See pages M23 - M24 for dimensional drawings.* Indicates length in meters.x Indicates cable type. See page M20 for available cable types.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
6 5
5
6
87 9
PSG 5 .. Pages M22 PKG 5Z ..
B2007 M23
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
4
PKW 5M .. Pages M21 - M22
3
PKG 5M .. Pages M21 - M22
DeviceNet™, picofast ® Cable/Cordsets Connector Dimensions
2
PSW 5M .. Pages M21 - M22
1
PSG 5M .. Pages M21 - M22
Overmold: TPUCoupling Nut: Nickel Plated CuZn or Stainless Steel (thread), Nylon (snap lock)Contact Carrier: TPU or POM (Nylon)Contacts: Gold Plated CuZnProtection: NEMA 1, 3, 4, 6P and IEC IP 67Rated Voltage: 30 VRated Current: 3 AAmbient Temperature: -40° to +75°C (-22° to +167°F)
Specifications
5 6
Pages M22
M24 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, eurofast ® Cable/Cordsets Connector Dimensions
9
RKT .. Pages M21 - M22
10
WKT .. Pages M21 - M22
7
RST .. Pages M21 - M22
8
WST .. Pages M21 - M22
Overmold: TPUCoupling Nut: Nickel Plated CuZn or Stainless SteelContact Carrier: TPUContacts: Gold Plated CuZnProtection: NEMA 1, 3, 4, 6P and IEC IP 68Rated Voltage: 250 VRated Current: 4 AAmbient Temperature: -40° to +75°C (-22° to +167°F)
Specifications
B2007 M25
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
• Terminating Resistors Stabilize andMinimizeReflections on the Bus Line
• A Terminating Resistor is Required at theBeginning and End of theMain Bus Line
DeviceNet™, Terminating Resistors
Housing Style Part Number Specs Pinouts
RSM 57-TR2Nickel plated brass or stainless steel, 300 V (7.6 V max. on pinswith resistor) , -40° to +80°C, IP 67, 120 Ohms, 1/2 Winternal resistance
RKM 57-TR2Nickel plated brass or stainless steel, 300 V (7.6 V max. on pinswith resistor), -40° to +80°C, IP 67, 120 Ohms, 1/2 W internalresistance,
RSM 57-TR2/VM
Nickel plated brass or stainless steel, 24 V (7.6 V max. on pinswith resistor), -40° to +80°C, IP 67, 120 Ohms, 1/2 W internalresistance, voltage monitoring
Led indication:Red - reverse polarityGreen-okay
RSE 57-TR2Nickel plated CuZn or stainless steel, 250 V(7.6 V max. on pinswith resistor), 4 A, -40° to +80°C, IP 68, 120 Ohms, 1/2 Winternal resistance
RKE 57-TR2Nickel plated CuZn or stainless steel, 250 V (7.6 V max. on pinswith resistor), 4 A, -40° to +80°C, IP 68, 120 Ohms, 1/2 Winternal resistance
RSE 57-TR2/VM
Nickel plated CuZn or stainless steel, 10-30 VDC, -40° to +80°C,IP 68, 120 Ohms, 1/2 W internal resistance, voltage monitoring
Led indication:Red - reverse polarityGreen-okay
Male
Female
Male
Male
Female
Male
M26 B2007
DeviceNet™ Physical Media Connectivity
• Terminating Resistors Stabilize andMinimizeReflections on the Bus Line
• A Terminating Resistor is Required at theBeginning and End of theMain Bus Line
DeviceNet™, Terminating Resistors
Housing Style Part Number Features Pinouts
PSGM 5M 57-TR
Nickel plated brass or stainless steel, 125 V(7.6 V max onresistor), 2 A, -40° to +105°C, IP 67, male picofast connector,120 Ohms, 1/2 W internal resistance
PKGM 5M 57-TR
Female
Male
B2007 M27
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, Receptacles
Housing Style Part Number Features Pinouts
RSF RKF 57/22Straight male/female feed through, nickelplated CuZn or stainless steel, 300 V, 9 A,-40° to +75°C, IP 67
FKM FS 57/M12Straight male/female feed through, nickelplated CuZn or stainless steel, 150 V, 4 A,-40° to +75°C, IP 67
Standard housing material is nickel plated brass. "RSF RKF.."; "RSFV RKFV.." indicates stainless steel housing.
• Receptacles Provide Transition fromMale toFemale Connectors
• Available for Bulkhead and Feed ThroughApplications
Female
Male Female
Male
Panel CutoutFKM FS 57/M12
Panel CutoutRSF RKF 57/22
M28 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, eurofast ® Drop Junctions
Housing Part Number Application Wiring Diagrams
VB2-FKM/FKM/FSM 57Ready for eurofast drop and trunkcordsets
Maximum six meter drop
VB2-RKC 57x-*M-FKM FSM Ready for eurofast trunk line,maximum six meter drop
VB2-FKM/RKC RSC 57x-*M/*M Ready for eurofast drop cordsets,maximum six meter branch
* Indicates length in meters.x Indicates cable type.
• Creates a Drop or Branch from theMain BusLine
• Cable Drop Lengths Available Up to aMaximum of 6Meters
B2007 M29
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
VB2-FKM/FKM/FSM 57 VB2-RKC 57x-*M-FKM FSM
VB2-FKM/RKC RSC 57x-*M/*M
Mounting: Mounting hole accepts #8 screw.
eurofast®
Pinouts
Male Female
Overmold: TPUCoupling Nut: Nickel Plated CuZn or Stainless SteelContact Carrier: TPU or POM (Nylon)Contacts: Gold Plated CuZnProtection: NEMA 1, 3, 4, 6P and IEC IP 68Rated Voltage: 250 VRated Current: 4 AAmbient Temperature: -40° to +75°C (-22° to +167°F)
Specifications
M30 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, Bus Drop and Diagnostic Tees
minifast
Pinouts
Male Female
Housing Style Part Number Features Wiring Diagrams
RSM-2RKM 57 TPU, 300 V, 9 A, -40° to +75°C, maximum sixmeter branch, Standard keyway
RSM 2RKM 57-KF TPU, 300 V, 9 A, -40° to +75°C, maximum sixmeter branch, keyway facing female
RSM 2RKM 57-KM TPU, 300 V, 9 A, -40° to +75°C, maximum sixmeter branch, keyway facing male
• Creates a Drop or Branch from theMain BusLine
• (7/8-16UN) minifast ® Connectors on Bus andDrop Lines
• Available in Three Keyway Options
B2007 M31
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
Housing Style Part Number Features Wiring Diagrams
SH-RKM/RSM/RKM 57/VMTPU (Polyurethane), 30 V, 9 A, -40° to+105°C, maximum sixmeter branch
RSM RSM 57-0/VMTPU (Polyurethane), 30 V, 9 A, -40° to+105°C, maximum sixmeter branch
RSM RKM 57-0/VMTPU (Polyurethane), 30 V, 9 A, -40° to+105°C, maximum sixmeter branch
RKM RKM 57-0/VM TPU (Polyurethane), 30 V, 9 A, -40° to+105°C
TURCK
DeviceNet
Reset
LO OK HIAC
TURCK
DeviceNet
Reset
LO OK HIAC
DeviceNet™, Bus Drop and Diagnostic Tee
• Creates a Drop or Branch from theMainBus Line
• (7/8-16UN) minifast ® Connectors on Busand Drop Lines
• Available in Three Keyway Options• Different Genders Available• LED Status Indicator
TURCK
DeviceNet
Reset
LO OK HIAC
TURCK
DeviceNet
Reset
LO OK HIAC
minifast
Pinouts
Male Female
M32 B2007
DeviceNet™ Physical Media Connectivity
Housing Style Part Number Features Wiring Diagrams
MT-RKM/RSM/RKM 57/DNET/VM
TPU (Polyurethane), 30 V, 9 A, -40° to+105°C
MT-RSM/2RKM 57/DNET/VM
TURCK
DeviceNet
Reset
LO OK HIAC
DeviceNet™, Bus Drop and Diagnostic Tee
• Creates a Drop or Branch from theMain BusLine
• (7/8-16UN) minifast ® Connectors on Bus andDrop Lines
• Available in Three Keyway Options• Different Genders Available• LED Status Indicator
TURCK
DeviceNet
Reset
LO OK HIAC
B2007 M33
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
Housing Style Part Number Features Wiring Diagrams
MT-RSM/2RKM 57/DNET
TPU (Polyurethane), 30 V, 9 A, -40° to+105°C
SH-RKM/RSM/RKM 57
SH-RSM-2RKM 57
RSM RSM 57-0
RKM RKM 57-0
TURCKTURCK
DeviceNet
DeviceNet™, Bus Drop and Diagnostic Tee
• Creates a Drop or Branch from theMain BusLine
• (7/8-16UN) minifast ® Connectors on Bus andDrop Lines
• Available in Three Keyway Options• Different Genders Available
TURCK
DeviceNet
TURCK
DeviceNet
TURCK
DeviceNet
TURCK
DeviceNet
M34 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, Power and Diagnostic Tees
minifast
Pinouts
Male Female
Housing Style Part Number Features Wiring Diagrams
RSM RKM 57 WSM 40 PSTTPU, 300 V, 9 A, -40° to +75°C, bus powertee provides segment power, includesreverse current protection
RSM 2RKM 57 DGT
TPU, 300 V, 9 A, -40° to +75°C, busdiagnostic tee provides easy connectionfor diagnostic tools, tap protected withcover when not in use(not shown)
• Provide a Drop to Insert Power or DiagnosticEquipment
• (7/8-16UN) minifast ® Connectors on Bus andDrop Lines
• Reverse Current Protection on Power Tap
B2007 M35
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, Bus Tees
Housing Style Part Number Features Wiring Diagrams
RSM FKM RKM 57 TPU, 250 V, 4 A, -40° to +75°C, minifast® to
eurofast bus power and data drop
RSM RKC 57x-*MRKM 57
TPU, 250 V, 4 A, -40° to +75°C, minifast toeurofast cordset, bus power and data drop
minifast eurofast
Pinouts
FemaleMale Female
• Creates a Drop or Branch from theMain BusLine
• Cable Drop Can Be Up to aMaximum of 6Meters
• eurofast ® Drop Connector or ExtensionCordset
M36 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, eurofast ® Bus Tees
Housing Style Part Number Features Wiring Diagram
RSC 2RKC 57 TPU, 250 V, 4 A, -40° to +75°C, eurofast trunkand drop
RSC 2RKC 57/KSTPU, 250 V, 4 A, -40° to +75°C, eurofast trunkand drop, keyway aligns tee in-line on (M8x1)piconet
® boxes
RSC RKC 572-*M/RKC 57 TPU, 32 V, 4 A (pins 2,3) 1 A (all others), -40° to+80°C
eurofast
Pinouts
Male Female
• Creates a Drop or Branch from theMain BusLine
• Cable Drop Can Be Up to aMaximum of 6Meters
• eurofast Drop Connector
B2007 M37
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
Housing Style Part Number Features
RSM RSM 57TPU, 300 V, 9 A, -40° to +80°C,changes female cordset tomale cordset
RKM RKM 57
TPU, 300 V, 9 A, -40° to +80°C,Changes male cordset tofemale cordset
changes straight male orfemale cordset to right anglecordset
WSM RKM 57TPU, 300 V, 9 A, -40° to +80°C,right angle male to femaleconnector
DeviceNet™, Gender Changers and Elbow Connectors
minifast
Pinouts
Male Female
• Allows Quick and Easy Changes fromMale toFemale Connectors
• Available in Straight and Right Angle Styleswith minifast ® Connectors
M38 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, Gender Changers and Elbow Connectors
Housing Style Part Number Features Wiring Diagrams
RSM 57-FK 4.5Nickel plated CuZn or stainless steel, 250 V, 4 A,-40° to +75°C, female eurofast to male minifastadapter
RSC RKC 57
Nickel plated CuZn, 250 V, 4 A, -40° to +105°C,male eurofast to female eurofast adapter
RSC WKC 57
minifast eurofast eurofast
Pinouts
Male Male
• Allows Quick and Easy Changes fromMale toFemale and minifast ® to eurofast ®Connectors
Female
B2007 M39
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
Housing Style Female Part Number Male Part Number Features Pinouts
RKF 57-*M/14.5 RSF 57-*M/14.5
Nickel plated CuZnor stainless steel,300 V, 9 A, -40° to+105°C, 1/2-14NPTfull length threads
1. GY2. RD3. BK4. WH5. BU
RKF 57-*M/14.75 RSF 57-*M/14.75
Nickel plated CuZnor stainless steel,300 V, 9 A, -40° to+105°C, 3/4-14NPTfull length threads
RKF 57-*M/M20 RSF 57-*M/M20
Nickel plated CuZnor stainless steel,300 V, 9 A, -40° to+105°C, M20x1.5threads
* Length in meters.Standard cable length is 0.5 meters. Consult factory for other lengths.Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.For locknuts to be included, add "W/LN" to the end of the part number.
DeviceNet™, (7/8-16UN) minifast ® Male Receptacles
Male
• Provides Quick Connection to Field Devices orEnclosures
• Available for 1/2-14NPT, 1/2-14NPSM,3/4-14NPT andM20 Threads
RSF 57../14.5
RSF 57../14.75
RKF 57../14.5
RKF 57../14.75
RSF 57../M20
RKF 57../M20
Female
M40 B2007
DeviceNet™ Physical Media Connectivity
Housing Style Female Part Number Male Part Number Features Pinouts
RKF 57-*M RSF 57-*M
Nickel plated CuZnor stainless steel,300 V, 9 A, -40° to+105°C,1/2-14NPSM threads
1. GY2. RD3. BK4. WH5. BU
RKF 57-*M/NPT RSF 57-*M/NPT
Nickel plated CuZnor stainless steel,300 V, 9 A, -40° to+105°C, 1/2-14NPTmodified lengththreads
* Length in meters.Standard cable length is 0.5 meters. Consult factory for other lengths.Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.For locknuts to be included, add "W/LN" to the end of the part number.
DeviceNet™, (7/8-16UN) minifast ® Male Receptacles
Female
• Provides Quick Connection to Field Devices orEnclosures
• Available for 1/2-14NPT, 1/2-14NPSM,3/4-14NPT andM20 Threads
RSF 57..
RKF 57..
RSF 57../NPT
RKF 57../NPT
Male
B2007 M41
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, (M12x1) eurofast ® Male Receptacles
Housing Style Female Part Number Male Part Number Features Pinout
FK 57-*M/14.5 FS 57-*M/14.5
Nickel platedCuZn orstainless steel,250 V, 4 A, -40°to +105°C,1/2-14NPT fulllength threads
1. GY2. RD3. BK4. WH5. BU
FK 57-*M/14.75 FS 57-*M/14.75
Nickel platedCuZn orstainless steel,250 V, 4 A, -40°to +105°C,3/4-14NPT fulllength threads
FK 57-*M/M20 FS 57-*M/M20
Nickel platedCuZn orstainless steel,250 V, 4 A, -40°to +105°C,M20x1.5threads
* Length in meters.Standard cable length is 0.5 meters. Consult factory for other lengths.Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
Female
• Provides Quick Connection to Field Devices• Available for 1/2-14NPT, 1/2-14NPSM,
3/4-14NPT andM20 Threads
FS 57../14.5
FK 57../14.5
FS 57../14.75
FK 57../14.75
FS 57../M20
FK 57.../M20
Male
M42 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, (M12x1) eurofast ® Male Receptacles
Housing Style Female Part Number Male Part Number Features Pinout
FK 57-*M FS 57-*M
Nickel platedCuZn orstainless steel,250 V, 4 A, -40°to +105°C, PG 9threads
1. GY2. RD3. BK4. WH5. BU
FK 57-*M/NPT FS 57-*M/NPT
Nickel platedCuZn orstainless steel,250 V, 4 A, -40°to +105°C,1/2-14NPTmodified lengththreads
* Length in meters.Standard cable length is 0.5 meters. Consult factory for other lengths.Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
Male
• Provides Quick Connection to Field Devices• Available for 1/2-14NPT, 1/2-14NPSM,
3/4-14NPT andM20 Threads
FS 57..
FK 57…
FS 57.../NPT
FK 57.../NPT
Female
B2007 M43
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, minifast ® PCB and Solder Cup Receptacles
Housing Style Female Part Number Male Part Number Features Pinouts
RKF 57-PCB RSF 57-PCB
Nickel platedCuZn or stainlesssteel, 300 V, 9 A,-40° to +105°C,minifast PCB pins
1. BARE2. RD3. BK4. WH5. BU
RKF 57 RSF 57
Nickel platedCuZn or stainlesssteel, 300 V, 9 A,-40° to +105°C,minifast soldercups
Standard housing material is nickel plated brass "RSFV .."; "RKFV .." indicates 316 stainless steel.
Female
Male
• Provides (7/8-16UN) minifast Connection toField Devices
Panel CutoutFK… FS
Board Layout (reference only)FK… FS
RSF 57 PCB
RKF 57 PCB
RSF 57
RKF 57
M44 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, eurofast ® PCB and Solder Cup Receptacles
Housing Style Female Part Number Male Part Number Features Pinouts
FK 57-PCB KIT FS 57-PCB KIT
Nickel plated CuZn orstainless steel, 250 V, 4A, -40° to +105°C, maleeurofast withmounting kit
1. BARE2. RD3. BK4. WH5. BU
FK 57-PCB FS 57-PCB
Nickel plated CuZn orstainless steel, 250 V, 4A, -40° to +105°C, maleeurofast
Standard housing material is nickel plated brass "FSV .."; "FKV .." indicates 316 stainless steel.
Male
Female
• Provides (M12x1) eurofast Connection toField Devices
Board Layout (reference only)FK… FS
FK 57 PCB KIT
FS 57 PCB KIT
FS 57 PCB
FS 57 PCB
B2007 M45
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, eurofast ® PCB Pins and Solder Cup Receptacles
Housing Style Female Part Number Male Part Number Features Pinouts
FKFD 57-PCB FSFD 57-PCB
Nickel plated CuZn orstainless steel, 250 V, 4A, -40° to +105°C, maleeurofast PCB pins
1. BARE2. RD3. BK4. WH5. BU
FKFDL 57 FSFDL 57
Nickel plated CuZn orstainless steel, 250 V, 4A, -40° to +105°C, maleeurofast solder cups
WFS 57-PCB
Nickel plated CuZn orstainless steel, 250 V, 4A, -40° to +105°C, maleeurofast right anglePCB pins
Standard housing material is nickel plated brass "FKFD .."; "FKFDV .." indicates 316 stainless steel.
Female
Male
Panel CutoutFKFD… FSFD
Board Layout (reference only)FKFD… FSFD
Panel CutoutWFS
Board Layout (reference only)WFS
• Provides (M12x1) eurofast Connection toField Devices
FSFD 57 PCB
FKFD 57 PCB
FSFDL 57
FKFDL 57
WFS 57 PCB
M46 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, minifast ® FieldWireable Connectors
Housing Style Female Part Number Male Part Number Features Pinouts
B 4151-0/9/DNET BS 4151-0/9/DNET
Glass filled nylon, PG 9 cable gland,accepts 6-8 mm cable diameter,screw terminals, 85°C, 250 V, 9 A,mates with all 5-pin cordsets andreceptacles
B 4251-0/9/DNET BS 4251-0/9/DNET
Glass filled nylon, PG 9 cable gland,accepts 6-8 mm cable diameter,screw terminals, 85°C, 250 V, 9 A,mates with all 5-pin cordsets andreceptacles
B 4151-0/13.5/DNET BS 4151-0/13.5/DNET
Glass filled nylon, PG 13.5 cablegland, accepts 10-12 mm cablediameter, screw terminals85°C, 250 V, 9 A, mates with all5-pin cordsets and receptacles
B 4151-0/16/DNET BS 4151-0/16/DNET
Glass filled nylon, PG 16 cablegland, accepts 12-14 mm cablediameter, screw terminals85°C, 250 V, 9 A, mates with all5-pin cordsets and receptacles
Female
Male
BS 4251..
• Allows for Quick Connection when Pre-MoldedCables not Available
• Available for Male and Female Connectors• Color CodedWire Connections for DeviceNet
BS 4151..
B 4151..
B 4251..
B2007 M47
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, eurofast ® FieldWireable Connectors
Housing Style Female Part Number Male Part Number Features Pinouts
B 8151-0/PG9/DNET BS 8151-0/PG9/DNET
PBT, Black, PG 9 cablegland, accepts 4-8 mmcable diameter, screwterminals, 85°C, 125 V, 4 A,mates with 5-pin cordsetsand receptacles
B 8251-0/PG9/DNET BS 8251-0/PG9/DNET
PBT, Black, PG 9 cablegland, accepts 4-8 mmcable diameter, screwterminals, 85°C, 125 V, 4 A,mates with 5-pin cordsetsand receptacles
Male
Female
• Allows for Quick Connection when Pre-MoldedCables not Available
• Available for Male and Female Connectors inStraight or Right-Angle Configurations
• Color CodedWire Connections for DeviceNet
B 81…
B 82…
BS 81…
BS 82…
M48 B2007
DeviceNet™ Physical Media Connectivity
DeviceNet™, eurofast ® Daisy Chain Configurations
eurofast
Pinouts
Male Female
Part Number Features
WSC 2VBWK WKC 5724-1.5M-0.2M-0.2MTPU, 250 V, 4 A, -40° to +75°C, available in custom configurations including length, number of drops and endconnector styles
Consult factory for other designs.
• Multi-drop Harnesses Designed for OEMApplications
• Provides Cost Effective Solution vs. SingleTees and Drops
B2007 M49
DeviceNet™ Physical Media Connectivity
Dev
iceN
et™Med
ia
DeviceNet™, eurofast ® Daisy Chain Configurations
Part Number Features
RSC 8VBRK RKC 5724-DCLTPU, 250 V, 4 A, -40° to +75°C, available in custom configurations including length, number of drops and endconnector styles
Consult factory for other designs.
eurofast
Pinouts
Male Female
• Multi-drop Harnesses Designed for OEMApplications
• Provides Cost Effective Solution vs. SingleTees and Drops
Button3: