Post on 09-Aug-2020
Below is a flowchart describing 40 CFR Part 60, Subpart KKKK. It will likely not be accessible using a screen reader. For the text of the statute/rule, please go to
40 CFR Part 60, Subpart KKKK(1 of 29)
Start
Do you own or operate an affected
source that was constructed, modified or reconstructed after
02/18/2005?
Does your stationary
combustion turbine have a heat input at peak load equal to or
greater than 10.7 gigajoules (10 MMBtu) per
hour?
§60.4300
§60.4305(a)
Yes
No
NoYes
Is thecombustion turbine
at an integrated gasificationcombined cycle electric utility steam
generating unit subject tosubpart Da of this
part?
§60.4310(c)
3
40 CFR Part 60, Subpart KKKK does not apply
End
No
Yes
Yes
Is the affected source a heat recovery unit operating independent of the stationary
combustion turbine?
§60.4320(a)
No
§60.4320(a)
Is the output-based
standard being used?
12
Yes
NOx
No
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(2 of 29)
3
Are you operating an
emergency combustionturbine?
Yes
No
§60.4310(a)
Is your stationarycombustion turbine engaged
in research and development of equipment for both combustion turbine
emission control techniques andcombustion turbine efficiency
improvements?
§60.4310(b)No
4
Yes
Comply with the following:Standard
§60.4310(a)§60.4333(a)§60.4390(a)Reporting
§60.4390(a)
Comply with the following:Standard
§60.4310(b)§60.4333(a)§60.4390(b)Reporting
§60.4390(b)
30
Is theoperation a test
cell/stand?
§60.4310(d)No
40 CFR Part 60, Subpart KKKK does not apply
Yes End
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(3 of 29)
4 NOx
§60.4320(a)
Isthe output < 30
MW?
§60.4320(a)
20
5
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4333(a)Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Yes
Is the output-based
standard being used?
§60.4320(a)
6
Yes
22
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4333(a)Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
No
No
Yes
Are you operating aturbine that operates at < 75 percentof peak load or a turbine operating at
temperatures < 0 °F?
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(4 of 29)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4333(a)Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Is the output-based
standard being used?
§60.4320(a)
Yes
6
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4333(a)Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
21
No
38
20
39
22
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(5 of 29)
Is the turbineheat input at peak load
> 850 MMBtu/h?
Does the turbine fire only gaseous fuels
and > 50% of heat input is from natural gas?
5
Is the turbine heat input at peak load > 50
MMBtu/h?
7
8
No
13
No
Yes
Yes
Yes
No
§60.4320(a)
§60.4320(a)
§60.4320(a)
§60.4320(a)
No
Does the turbine fire only gaseous fuels and> 50% of heat input is from
natural gas?
Is the output-based
standard being used?
§60.4320(a)
Yes
Yes
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
18
17
No
22
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(6 of 29)
§60.4320(a)
§60.4320(a)
Was the turbine constructed after
02/18/2005?
Was the turbine constructed after
02/18/2005?
8
7
No
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Is the output-based
standard being used?
§60.4320(a)
9
No
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
10
Is the output-based
standard being used?
§60.4320(a)
11
No
Yes
No
12
Yes
Yes
Yes
22
22
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
Is the output-based
standard being used?
§60.4320(a)
Yes
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
18
17
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
No
22
20
40 CFR Part 60, Subpart KKKK(7 of 29)
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(8 of 29)
Is the output-based
standard being used?
§60.4320(a)
Yes
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
10
9
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
No
22
20
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
Is the output-based
standard being used?
§60.4320(a)
Yes
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
12
11
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
No
22
20
40 CFR Part 60, Subpart KKKK(9 of 29)
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(10 of 29)
Was the turbine constructed after
02/18/2005?
§60.4320(a)
13
Is the turbineused for electric
generation?
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
15
Does the turbine fire only gaseous fuels and> 50% of heat input is from
natural gas?
§60.4320(a)
Yes
§60.4320(a)
No
Yes
16
No
Is the output-based
standard being used?
§60.4320(a)
Yes
Yes
21
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
No
14
No
20
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(11 of 29)
Is the output-based
standard being used?
§60.4320(a)
Yes
NoComply with the following:
Standard§60.4320(a)-Table 1
§60.4320(a)-(b)§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
16
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4333(a)Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Is the output-based
standard being used?
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
No
Yes
23
§60.4320(a)
14
22
20
20
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(12 of 29)
15
Is the turbineused for electric
generating?
§60.4320(a)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Is the output-based
standard being used?
§60.4320(a)
Yes
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Is the output-based
standard being used?
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Comply with the following:Standard
§60.4320(a)-Table 1§60.4320(a)-(b)
§60.4325§60.4333(a)
Monitoring/Testing[T][G]§60.4400(a)
[T]§60.4400(b), [T](b)(1), [T](b)(4)[T]§60.4400(b)(6)
Yes
No
No
No
Yes
§60.4320(a)
20
20
21
23
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(13 of 29)
20
Are NOxemissions controlledusing water or steam
injection?
§60.4335(a)
Is a CMS used to monitor
fuel consumption and water/steam to fuel
ratio?
Yes
Comply with the following:Standard
§60.4335(a)Monitoring/Testing
§60.4335(a)[G]§60.4355(a)
[T]§60.4400(b)(3)Recordkeeping
§60.4335(a)[G]§60.4355(a)
Reporting§60.4375(a)
§60.4380, [G](a)§60.4395
25
§60.4335(a)
Is heatrecovered from
the turbine?
§60.4350(f)(2)
26Yes
No
Comply with the following:Standard
§60.4335(b)(1)[G]§60.4345
Monitoring/Testing§60.4335(b)(1)[G]§60.4345
§60.4350(a)-(f)[T]§60.4400(b)(5)[T][G]§60.4405Recordkeeping
[G]§60.4345§60.4350(b)Reporting
[G]§60.4345§60.4350(d)§60.4375(a)
§60.4380, [G](b)§60.4395
Yes
No
Is aNOx CEMS
used?
27
No
Yes
No
§60.4335(b),§60.4340(b)
30
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(14 of 29)
21
Are NOxemissions controlledusing water or steam
injection?
§60.4335(a)
Is a CMS used to monitor
fuel consumption and water/steam to fuel
ratio?
Yes
Comply with the following:Standard
§60.4335(a)Monitoring/Testing
§60.4335(a)[G]§60.4355(a)
[T]§60.4400(b)(3)Recordkeeping
§60.4335(a)[G]§60.4355(a)
Reporting§60.4375(a)
§60.4380, [G](a)§60.4395
28
§60.4335(a)
Is heatrecovered from
the turbine?
§60.4350(f)(2)
Yes
No
Comply with the following:Standard
§60.4335(b)(1)[G]§60.4345
Monitoring/Testing§60.4335(b)(1)[G]§60.4345
§60.4350(a)-(f)[T]§60.4400(b)(5)[T][G]§60.4405Recordkeeping
[G]§60.4345§60.4350(b)Reporting
[G]§60.4345§60.4350(d)§60.4375(a)
§60.4380, [G](b)§60.4395
Yes
No
Is aNOx CEMS
used?
No
No
30
26
§60.4335(b),§60.4340(b)
27
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(15 of 29)
22
Are NOxemissions controlledusing water or steam
injection?
§60.4335(a)
Is a CMS used to monitor
fuel consumption and water/steam to fuel
ratio? Yes
Comply with the following:Standard
§60.4335(a)Monitoring/Testing
§60.4335(a)[G]§60.4355(a)
[T]§60.4400(b)(3)Recordkeeping
§60.4335(a)[G]§60.4355(a)
Reporting§60.4375(a)
§60.4380, [G](a)§60.4395
§60.4335(a)
Is heatrecovered from
the turbine?
§60.4350(f)(2)No
Comply with the following:Standard
§60.4335(b)(1)[G]§60.4345
Monitoring/Testing§60.4335(b)(1)[G]§60.4345
§60.4350(a)-(f)[T]§60.4400(b)(5)[T][G]§60.4405Recordkeeping
[G]§60.4345§60.4350(b)Reporting
[G]§60.4345§60.4350(d)§60.4375(a)
§60.4380, [G](b)§60.4395
Yes
No
Is aNOx CEMS
used?
No
Yes
No
Is the turbine for mechanical drive
applications?29Yes
Yes
No
30 26
27
§60.4335(b),§60.4340(b)
§60.4350(f)(3)
28
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(16 of 29)
23
Are NOxemissions controlledusing water or steam
injection?
§60.4335(a)
Is a CMS used to monitor
fuel consumption and water/steam to
fuel ratio?
Yes
Comply with the following:Standard
§60.4335(a)Monitoring/Testing
§60.4335(a)[G]§60.4355(a)
[T]§60.4400(b)(3)Recordkeeping
§60.4335(a)[G]§60.4355(a)
Reporting§60.4375(a)
§60.4380, [G](a)§60.4395
§60.4335(a)
Is heatrecovered from
the turbine?
§60.4350(f)(2)
Yes
No
Comply with the following:Standard
§60.4335(b)(1)[G]§60.4345
Monitoring/Testing§60.4335(b)(1)[G]§60.4345
§60.4350(a)-(f)[T]§60.4400(b)(5)[T][G]§60.4405Recordkeeping
[G]§60.4345§60.4350(b)Reporting
[G]§60.4345§60.4350(d)
§60.4380, [G](b)§60.4395
Yes
No
Is aNOx CEMS
used?§60.4335(b),§60.4340(b)
No
Yes
No
30
26
27
29
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(17 of 29)
Is combined gross energy output
apportioned?
§60.4333(b)(2)
Comply with the following:Standard
§60.4333(b)(1)Monitoring/Testing
§60.4333(b)(1)
Comply with the following:Standard
§60.4333(b)(2)Reporting
§60.4333(b)(2)
Comply with the following:Monitoring/Testing[T]§60.4400(b)(2)
Yes
Is aduct burner
used?
Does the affected unit utilize
a common steam header with one or more combustion
turbines? §60.4333(b)
26
Yes
§60.4400(b)(2)
Yes
No
No
No
30
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(18 of 29)
25
Is the affected unit combined heat
and power?
§60.4335(b)(4)
Comply with the following:Monitoring/Testing[T]§60.4400(b)(2)
Is the affected unit
combined cycle? §60.4350(f)(2)
Does the affected unit utilize a
common steam header with one or more combustion
turbines?
§60.4333(b)
Is combined gross energy output
apportioned?
§60.4333(b)(2)
Comply with the following:Standard
§60.4333(b)(2)Reporting
§60.4333(b)(2)
Comply with the following:Standard
§60.4333(b)(1)Monitoring/Testing
§60.4333(b)(1)
Comply with the following:Monitoring/Testing
§60.4350(g)
Is aduct burner
used?
§60.4400(b)(2)
Yes
Yes
No
No
Comply with the following:Monitoring/Testing
§60.4350(h)
No
No
30
30
30
Yes
YesYes
No
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(19 of 29)
Comply with the following:
Monitoring/Testing[T]§60.4400(b)(2)
Is the affected unit
combined cycle?
§60.4350(f)(2)
Doesthe affected unit utilize
a common steam header with one or more combustion
turbines?
§60.4333(b)
Is combined gross energy output
apportioned?
§60.4333(b)(2)
Comply with the following:Standard
§60.4333(b)(2)Reporting
§60.4333(b)(2)
Comply with the following:Standard
§60.4333(b)(1)Monitoring/Testing
§60.4333(b)(1)
Comply with the following:Monitoring/Testing§60.4350(f)(1), (g)
Is aduct burner
used? §60.4400(b)(2)
28
Comply with the following:Standard
§60.4335(b)(2), (b)(3)Monitoring/Testing§60.4335(b)(2), (b)(3)
Is the affected unit combined heat
and power?
§60.4335(b)(4)
No
Comply with the following:Standard
§60.4335(b)(4)Monitoring/Testing
§60.4335(b)(4)§60.4350(f)(2), (h)
Yes
Yes
Yes
No
No
No
Yes
No
Comply with the following:Monitoring/Testing§60.4350(f)(2), (h)
Yes
30
30
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(20 of 29)
Comply with the following:Monitoring/Testing[T]§60.4400(b)(2)
Is the affected unit
combined cycle?
§60.4350(f)(2)
Doesthe affected unit utilize
a common steam header with one or more combustion
turbines?
§60.4333(b)
Is combined gross energy output
apportioned?
§60.4333(b)(2)
Comply with the following:Standard
§60.4333(b)(2)Reporting
§60.4333(b)(2)
Comply with the following:Standard
§60.4333(b)(1)Monitoring/Testing
§60.4333(b)(1)
Comply with the following:Monitoring/Testing§60.4350(f)(1), (g)
Is aduct burner
used? §60.4400(b)(2)
29
Comply with the following:Standard
§60.4335(b)(2), (b)(3)Monitoring/Testing§60.4335(b)(2), (b)(3)
§60.4350(f)(3)
Is the affected unit combined heat
and power?
§60.4335(b)(4)
Comply with the following:Standard
§60.4335(b)(4)Monitoring/Testing
§60.4335(b)(4)§60.4350(f)(2), (h)
Yes
Yes
Yes
No
No
Yes
No
Comply with the following:Monitoring/Testing§60.4350(f)(2), (h)
Yes
30
30
No
No
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(21 of 29)
Comply with the following:Monitoring/Testing
[T]§60.4340(a)Reporting
§60.4375(b)
Is the unit regulated under
Part 75 and monitoring using methodology under
Appendix E to Part 75?
Comply with the following:Monitoring/Testing§60.4340(b)(2)(i)-(iii)
[G]§60.4355(a)[T]§60.4410
Recordkeeping[G]§60.4355(a)
[T]§60.4410Reporting
§60.4375(a)§60.4380, [G](c)
§60.4395
Comply with the following:Monitoring/Testing§60.4340(b)(2)(iv)
§60.4355(b)[T]§60.4410
Recordkeeping§60.4355(b)[T]§60.4410Reporting
§60.4375(a)§60.4380, [G](c)
§60.4395No
§60.4340(b)(2)(iv)
Yes
Are annualcompliance tests used to show continuous
compliance?
§60.4340(a)
Yes
27
No
30
30
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(22 of 29)
Comply with the following:Monitoring/Testing
[T]§60.4340(a)Reporting
§60.4375(b)
38
NoIs a
NOx CEMSused?
Yes
§60.4335(b),§60.4340(b)
Comply with the following:Standard
§60.4335(b)(1)[G]§60.4345
Monitoring/Testing§60.4335(b)(1)[G]§60.4345
§60.4350(a)-(c), (e)-(f), (h)[T]§60.4400(b)(5)[T][G]§60.4405Recordkeeping
[G]§60.4345§60.4350(b)Reporting
[G]§60.4345§60.4375(a)
§60.4380, [G](b)§60.4395
30
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(23 of 29)
Comply with the following:Monitoring/Testing
[T]§60.4340(a)Reporting
§60.4375(b)
39
NoIs a
NOx CEMSused?
Yes
§60.4335(b),§60.4340(b)
Comply with the following:Standard
§60.4335(b)(1)[G]§60.4345
Monitoring/Testing§60.4335(b)(1)[G]§60.4345
§60.4350(a)-(c), (e)-(f), (h)[T]§60.4400(b)(5)[T][G]§60.4405Recordkeeping
[G]§60.4345§60.4350(b)Reporting
[G]§60.4345§60.4375(a)
§60.4380, [G](b)§60.4395
Is the turbine for mechanical drive
applications?
Yes
NoComply with the following:
Monitoring/Testing§60.4350(f)(2)
Comply with the following:Monitoring/Testing
§60.4350(f)(3)30
§60.4350(f)(3)
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(24 of 29)
30 SO2
§60.4330(b)
Is the turbine located in a noncontinental area or in a
continental area for which the Administrator has determined does not have access to natural gas
and that the removal of sulfur compounds would do more environmental
harm than benefit?
36
Yes
Is the output based standard
being used?
No
Comply with the following:Standard
§60.4330(b)(1)§60.4333(a)[G]§60.4385
Monitoring/Testing§60.4415(a)
Comply with the following:Standard
§60.4330(b)(2)§60.4333(a)
Monitoring/Testing§60.4415(a)
Yes
§60.4330(b)(1)
35
32
No
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(25 of 29)
36
Is the turbine burning
at least 50% biogas on a calendar
basis?
37No
Yes
Comply with the following:Standard
§60.4330(a)(3)§60.4333(a)[G]§60.4385
Monitoring/Testing§60.4415(a)
32
§60.4330(a)(3)
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(26 of 29)
37 SO2
Is the output based standard
being used?
32
§60.4330(a)(2)
Is the fuel demonstrated not to exceed the emission
limitation?§60.4365
Comply with the following:Standard
§60.4330(a)(2)§60.4333(a)
Monitoring/Testing§60.4415(a)
Comply with the following:Standard
§60.4330(a)(1)§60.4333(a)[G]§60.4385
Monitoring/Testing§60.4415(a)
Comply with the following:Monitoring/Testing
§60.4365, (b)Recordkeeping
§60.4365(b)
Comply with the following:Monitoring/Testing
§60.4365, (a)Recordkeeping
§60.4365(a)
Is representative fuel sampling used for
demonstration?
§60.4365(b)
Is sulfur content of the fuel periodically
determined?
§60.4415(a)(1)
31
Yes
NoIs SO diluent gas
2
monitoring used for the performance test?
§60.4415(a)(3)
Comply with the following:Monitoring/Testing
[T]§60.4415(a)(3)
Yes
Comply with the following:Monitoring/Testing
[T]§60.4415(a)(2)
No
End
No
Yes
Comply with the following:Standard
[G]§60.4385
No
Yes
No
35
Yes
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(27 of 29)
31
Is gaseous fuel used?
Is liquid fuel used?
Comply with the following:Monitoring/Testing[T]§60.4415(a)(1)(ii)
Comply with the following:Monitoring/Testing[T]§60.4415(a)(1)(i)
Yes
Yes
End
§60.4415(a)(1)(ii)
§60.4415(a)(1)(i)
§60.4415(a)(1)
Is liquid fuel used?
§60.4415(a)(1)(i)
34
Comply with the following:Monitoring/Testing
[T]§60.4370(a)[T]§60.4415(a)(1)(i)
Is gaseous fuel used?
§60.4415(a)(1)(ii)
Comply with the following:Monitoring/Testing[T]§60.4415(a)(1)(ii)
Is sulfur content of the fuel periodically
determined?
33
No
Yes
No
Yes
End
Comply with the following:Monitoring/Testing
[T]§60.4415(a)(1)Reporting
§60.4375(a)
Comply with the following:Monitoring/Testing
§65.4360[T]§60.4415(a)(1)
Reporting§60.4375(a)
No
No
No
Yes
32
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(28 of 29)
End
Is SO diluent gas 2
monitoring used for the performance test?
§60.4415(a)(3)
Comply with the following:Monitoring/Testing
[T]§60.4415(a)(3)
Yes
Comply with the following:Monitoring/Testing
[T]§60.4415(a)(2)
Is liquid fuel used?
§60.4370(a)
33
No
No
No
Comply with the following:Monitoring/Testing
§60.4370(a)
§60.4370(b)
Yes34Is gaseous fuel used?
Yes
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***
40 CFR Part 60, Subpart KKKK(29 of 29)
Is fuel supplied with
intermediate bulk storage?
§60.4370(b)
Is a custom fuel monitoring schedule used?
§60.4370(c)
End
Comply with the following:Monitoring/Testing
§60.4370(b)Recordkeeping
§60.4370(b)
Is the720-hour fuel
sampling in Appendix D to Part 75
used? §60.4370(c)(2)
Yes
Comply with the following:Monitoring/Testing§60.4370(c), [G](c)(2)
Recordkeeping§60.4370(c)Reporting
§60.4370(c)
Yes
Is themonitoring in §60.4370(c)(1)
used?
End
§60.4370(c)(1)
No
Comply with the following:Monitoring/Testing§60.4370(c), [G](c)(1)
Recordkeeping§60.4370(c)Reporting
§60.4370(c)
Comply with the following:Monitoring/Testing
§60.4370(c)Recordkeeping
§60.4370(c)Reporting
§60.4370(c)
Yes
No
Yes
34
No
08/09/2016 From 40 CFR Part 60, Subpart KKKK, Amended 03/20/2009The flowcharts are for use by sources subject to the Federal Operating Permit Program and are subject to change. ***