Introduction to Stimulation

Post on 18-Nov-2014

1.403 views 15 download

Transcript of Introduction to Stimulation

1

Introduction to Reservoir Stimulation

Kellyville Training Center

2

Well Stimulation

Stimulation is a chemical or mechanical method of increasing flow capacity to a well.

Dowell Schlumberger is mainly concerned with three methods of stimulation:

1. Wellbore Clean-up : “ Fluids not injected into formation”• a. Chemical Treatment• b. Perf Wash

2. Matrix Treatment : “ Injection below frac pressure”• a. Matrix Acidizing• b. Chemical Treatment

3. Fracturing “ Injection above frac pressure”• a. Acid Frac• b. Propped Frac

3

Stimulation Techniques

Restores Flow Capacity:• Wellbore Clean-up• Matrix Treatment

These procedures are performed below fracture pressure.

Create New Flow Capacity:• Hydraulic Fracturing (Acid and Sand)

These procedures are performed above fracture pressure.

4

Areas Where Reduction in Flow Capacity May Occur

1. Wellbore:• Scale Damage• Sand Fill• Plugged Perforations• Paraffin Plugging• Asphalt Deposits• Etc.

2. Critical Matrix:• Drilling Mud Damage• Cement Damage• Completion Fluids• Production• Native Clays/Fines

5

WELLBORE

Primary Purpose :

Restore flow capacity by removing restrictive damage to fluid flow in the wellbore.

Methods :• Mechanical• Chemical Treatment• Acidizing Treatment

6

Critical Matrix What is It?

• The area of formation that is 3' to 5' from the wellbore. Why is it critical?

r % Pressure Drop (Drainage Radius) P (psi) P/ft (Pe - P) (Pe - Pwf) * 100

(Pe) 2,000 ft 5,000 0.07 psi/ft 01,000 ft 4,934 2.5100 ft 4,719 10.850 ft 4,654 1.3 psi/ft 13.320 ft 4,568 16.610 ft 4,503 6.5 psi/ft 19.05 ft 4,439 21.53 ft 4,391 23.32 ft 4,000 850 psi/ft 24.81 ft 3,150 27.3

(Pwf) 0 ft 2,000 1,150 psi/f 100

7

Major Goals of Matrix Treatment

1. Restore Natural Permeability• By Treating the Critical Matrix

2. Minor Stimulation

3. Leave Zone Barrier Intact

8

Matrix Acidizing 1. Sandstone:

• Major Effects: Dissolves/Disperses Damage Restores Permeability

• Minor Effects: Minor Stimulation

2. Limestone:• Major Effects:

Enlarge Flow Channels/Fractures Disperse Damage by Dissolving Surrounding Rock Creation of Highly Conductive Wormholes

9

Applications For Matrix Treatment

High Permeability Formation with Damage.

Unproppable Formations.

Treating Limitations.

Thick Zones.

To Supplement Fracturing.

10

Low Permeability Reservoir Increase well productivity by creating a highly conductive path

compared to the reservoir permeability.

The fracture will extend through the damaged near wellbore area. The fracture size is limited to two criteria :

• Drainage Radius• Cost

Fracturing is : Pumping fluid into the formation above fracture pressure.

Damage

XL

XL = Fracture half length

11

Darcy’s Equation

Oil Well : Oil Well : Gas Well : Gas Well :

q = kh (Pe - Pwf)

141.2 µ (In rerw + S)

q = kh (Pe2 - Pwf2)

1424 µzT (In rerw + S)

12

Skin (s) The total Skin (ST) is the combination of mechanical and pseudo-skins. It

is the total skin value that is obtained directly from a well-test analysis.

Mechanical Skin:• Mathematically defined as an infinitely thin zone that creates a steady-

state pressure drop at the sand face.• S > 0 Damaged Formation• S = 0 Neither damaged nor stimulated• S < 0 Stimulated formation

Pseudo Skin:• Includes situations such as fractures, partial penetration, turbulence,

and fissures. The Mechanical Skin is the only type that can be removed by stimulation.

13

Skin Example Pseudo Skin:

• Producing at high rates --> turbulence• Collapsed tubing, perforations• Partial penetration / Partial perforation• Low Perforation Density (Shots/ft)• Etc.

Formation Damage:• Scales• Organic/Mixed Deposits• Silts & Clays• Emulsions• Water Block• Wettability Change

14

Example An oil well produces 57 B/D under the following reservoir and producing

conditions:

k = 10 md

h = 50 ft

ßo = 1.23 res bbl/stb

µo = 0.6 cp

Pr = 2,000 psi

Pwf = 500 psi

rw = .33 ft

re = 1,320 ft

What is the Skin Factor?

Is there potential for Stimulation?

15

INTRODUCTION TO MATRIX TREATMENT

16

Formation Damage

Damage Definition :

• Partial or complete plugging of the near wellbore area which reduces the original permeability of the formation.

• Damage is quantified by the skin factor ( S ).

17

Types of Formation Damage Emulsions

Wettability Change

Water Block

Scale Formation

Organic Deposits

Mixed Deposits

Silt & Clay

Bacterial Slime

18

Areas of Damage

Scales

Organic deposits

Silicates, Aluminosilicates

Emulsion

Water block

Wettability change

Tubing Gravel Pack Perforations Formation

19

Emulsions Definition:

• Formed by invasion of filtrates into oil zones or mixing of oil-based filtrates with formation brines.

• Any two immiscible fluids

Keys to Diagnosis:• Sharp decline in production• Water breakthrough• Production of solids• Fluid samples• Injection of inhibitors

Treatment:• Surfactants • Mutual solvents

20

Wettability Change Definition:

• Oil wetting of rock from hydrocarbon deposits or adsorption of an oleophilic (attracts oil) surfactant from treating fluid.

Keys to Diagnosis: (Normally difficult to diagnose)• Rapid production decline• Casing leak• Water breakthrough• Water coning• Decrease or disappearance of gas

Treatment:• Mutual solvent followed by water-wetting surfactant.

21

Water Block Definition:

• Caused by an increase in water saturation near the wellbore which decreases the relative permeability to hydrocarbons.

Keys to Diagnosis: • Rapid oil or gas production decline• Casing leak• Water breakthrough• Water out• Abnormally high water cut through lower perforations

Treatment:• Mutual solvents or surfactants

22

Scale Formation Definition:

• Scales are precipitated mineral deposits. Scale deposition occurs during production because of lower temperatures and pressures encountered in or near the wellbore.

Keys to Diagnosis: • Sharp drop in production• Visible scale on rods/tubing• Water breakthrough

Treatment:• Carbonate (Most Common)

HCl, Aqueous Acetic• Sulfate

EDTA NARS

• Chloride 1 - 3% HCl

IronIron» HCl with various iron control agentsHCl with various iron control agents

SilicaSilica» Mud AcidMud Acid

23

Keys to Diagnosis of a SampleFloats in H2O 2

Soluble in H O2

Soluble in HCl

No

Soluble in hot HCl

No

No

Iron Oxide

Magnetic

Magnetite FeCo

Soluble in U42

Soluble in hot HCl/HF

3

No

No

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

No

Organic

NaCl (probably)

Odor of rotten eggs

Silica Base (sand/clay)

SrSO (slow) BaSO (very slow)

CO Evolves

FeCO

Fe (CO ) CaCO

MgCO Ca(SO ) slowly soluble (also soluble in U42)

FeS (possible)

3

2 3 3

3

3

4 2

2

4

4

24

Scales : Inorganic Mineral Deposits

Types of Scale

Usual Occurrence

Treating Fluids Comments

Carbonates CaCO3 HCl Very Common

Sulfates

CaSO •2H O (gypsum)

BaSO /SrSO

EDTA

EDTA

Common

Rare

Chlorides NaCl H O/HCl Gas Wells

IronFe S

Fe O

HCl + EDTA

HCl + Sequestering Agent

CO /H S Possible Produced

Silica SiO HF Very Fine

Hydroxides Mg/Ca(OH) HCl

4

4 4

3

2

2

2

2

22

2

25

Organic Deposits Definition:

• Organic deposits are precipitated heavy hydrocarbons (parrafins or asphaltenes). They are typically located in the tubing, perforations and/or the formation.

• The formation of these deposits are usually associated with a change in temperature or pressure in or near the wellbore during production.

Keys to Diagnosis: • Sharp decline in production• Visual parrafin on rods and pump• Operator is "hot oiling"

Treatment:• Aromatic Solvents (Xylene, Toluene)• Mutual Solvents

26

Keys to Diagnosis of Actual Organic Deposit

Floats in water Yes Organic Deposit

1. Burns evenly with clean flame Yes Paraffin/wax

No

Black sooty flame Yes Asphaltene

2. Soluble in pentane Yes Paraffin

No

Asphaltene

3. Soluble in Toluene/Xylene Yes Paraffin/ Asphaltene

27

Silts & Clays Definition:

• Damage from silts and clays includes the invasion of the reservoir permeability by drilling mud and the swelling and/or migration of reservoir fines.

• Keys to Diagnosis: • Sharp drop in production• Lost circulation during drilling• Production tests• ARC tests

Treatment:• HCl: Carbonate Reservoirs• HF Systems: Sandstone• Quaternary Amine Polymers (L55)• Cationic Surfactant (M38B)• Fusion (Clay Acid)

28

Bacterial Slime

Definition:• Anaerobic bacteria grows downhole without oxygen up

to 150°F. Bacteria may chemically reduce sulfate in a reservoir to H2S.

Treatment:• M91 (Bleach+Caustic soda)

29

Sources of Formation Damage Drilling

Cementing

Perforating

Completion and Workover

Gravel Packing

Production

Stimulation

Injection Operations

30

31

Successful Matrix Treatment

REQUIREMENTS :

• Enough Treating Fluid Volume

• Correct Reactive Chemicals

• Low Injection Pressure

• Total Zone Coverage

32

INTRODUCTION TO FRACTURING

33

Applications For Hydraulic Fracturing

If wells natural permeability is low ( Ke < 10 md )

Natural production is below economic potential

Skin By-Pass “ HyperSTIM “ or higher permeability and soft formations.

The injected fluid is pumped at a rate above the fracture pressure of the reservoir to create cracks or fractures within the rock itself.

34

Hydraulic Fracturing Treatment

Primary Purpose :• To increase the effective wellbore area by creating a

fracture of length XL whose conductivity is greater than that of the formation.

Dimensionless Conductivity ( Fcd ) = Kf Wf / Ke Xf

Two Methods :• Sand Frac• Acid Frac

35

Propped Frac & Acid Frac

1/2"open fractureduring job

fracture tends to closeonce the pressure has been

released

sand used to prop thefrac open

acid etched frac walls

36

Propped Fracture Optimization

Optimize the reservoir deliverability by balancing fracture characteristics and reservoir properties

Analyze the effect of production systems :• Perform => Nodal Analysis

Determine the pumping parameters :• DataFRAC

Tailor the fracturing fluid and proppant to the reservoir Determine treatment size (Fluid & proppant amount)

• Calculate XLand FCD

Calculate the benefit of the treatment => $• FracNPV

37

Acid Fracture

Bottom hole pressure above fracturing pressure

Acid reacts with the formation

Fracture is etched

Formation must retain integrity without fracture collapse

38

Hydraulic Fracturing Accomplishes:

Creates Deep Penetrating Fractures to :

Improve productivity Interconnect formation permeability Improve ultimate recovery Aid in secondary recovery Increase ease of injectivity

• A hydraulic Fracture has to be cost effective to the customer.

39

Fracture Penetration is influenced by: FORMATION CHARACTERISTICS :

• Type • Hardness• Permeability• Zone Height “ Presence of Barriers “• Drainage Radius

FRAC FLUID CHARACTERISTICS :• Base Fluid• Viscosity• Volume• Pump Rate• Fluid Loss

41

Orientation Of The Fracture

The fracture will extend perpendicular to the axis of the least stress.

• X - Y - Z Coordinate :Overburden Pressure

Least Principal Stress

Favored Fracture Direction

(i.e. Vertical Fracture)

42

Vertical Or Horizontal Fracture

Rule-Of-thumb :• Frac Gradient < 0.8 psi / ft --------> Vertical Fracture• Frac Gradient > 1.0 psi / ft --------> Horizontal Fracture

Vertical fracture plane is perpendicular to earth’s surface due to overburden stress being too great to overcome

Horizontal fracture with a pancake likegeometry. Usually associated withshallow wells of less than 3,000 ft. depth

43

Fracture Propagation Models

KGD

• XL < h

PKN

• XL > h

Radial

• XL = h/2

44

Rock Mechanical Behavior Young’s Modulus :

• E =

Poisson’s Ratio : L1 - L2 / L1

d1 - d2 / d1D1

D2

45

Rock Mechanical Behavior

Young’s Modulus :• E =

Poisson’s Ratio : L1 - L2 / L1

d1 - d2 / d1

46

Fracture Width

W = ( Q L) 1/4 PKN E

W = ( QL2)1/4 KGD EH

= Viscosity of fluid

• Q = Injection Rate • H = Gross Height

• L = Xf

• E = Young’s Modulus

47

Net Present Value FracNPV BENEFITS :

• Design lowest cost job• Realize full production rate potential• Forecast post treatment decline• Study impact of treatment variables

APPLICATION :

• Select optimum XL, W & proppant type

• Aid in determining whether or not to fracture a new well• Determine size of production equipment• Evaluation of the fracture treatment based on well performance

48

FracNPV

52

0 100 200 300 400 500

Hydraulic Half-Length - ft

-100000

0

100000

200000

300000

400000

500000

600000

Ne

t Pre

se

nt V

alu

e -

$(U

S)

YF120LG

ClearFRAC (3

Production time 1 year

Fluid Type

FracCADE*

*Mark of Schlumberger

Net Present Value

Well XXXX1235.5//1249.508-26-1997

Design

58

Conclusion Three Types of Stimulation :

• Wellbore Clean-up• Matrix Treatment• Hydraulic Fracturing

Well Candidate Selection :• What is it ?• How does Dowell Schlumberger use it ?• What are some of the tools associated with it ?

NPV• What is it ?• How can it be used to design a treatment ?• How does the output benefit our customers and us ?