Post on 02-Jun-2018
8/10/2019 Hyundai 130w-3 Electrical
1/49
4 - 1
SECTION 4 ELECTRICAL SYSTEM
GROUP 1 COMPONENT LOCATION
1
2
3
45
78910
11
12
13
14
15
16
18
19
20
21
22
23
24
25
17
26
P
27
2829
6
1 Horn switch
2 RH multifunction switch
3 Cluster
4 Starting switch
5 Cigar lighter
6 Aircon switch
7 Cold start switch(Option)
8 Breaker switch(Option)
9 Beacon switch(Option)
10 Quick coupling switch
11 Service meter
12 Arm half switch
13 Work light switch
14 Outrigger & dozer selector switch
15 Main light switch
16 Cassette & radio
17 Warning indicator
18 Aircon heater switch
19 Dozer & outrigger lever
20 Power boost switch
21 Resistor
22 Emergency engine
starting connector
23 CPU controller
24 Prolix switch
25 Fuse box
26 LH multifunction switch
27 RAM lock switch
28 Parking braker switch
29 Hazard switch
1. LOCATION 1
8/10/2019 Hyundai 130w-3 Electrical
2/49
2. LOCATION 2
4 -2
1
3
4
5
5
4
7
9
8
10
11
7
2
14
17
15
6
13
12
16
1 Fuel filter pump
2 Battery
3 Work light
4 Front compination lamp
5 Head lamp
6 Master switch
7 Rear combination lamp
8 Temperature sendor
9 Engine speed sensor
10 Number plate lamp
11 Engine oil pressure switch
12 Heater valve
13 Heater adapter
14 Alternator
15 Start relay
16 Battery relay
17 Connector plate
8/10/2019 Hyundai 130w-3 Electrical
3/49
4 -3
GROUP 2 ELECTRICAL CIRCUIT
8/10/2019 Hyundai 130w-3 Electrical
4/49
4 -4
8/10/2019 Hyundai 130w-3 Electrical
5/49
1. POWER CIRCUIT
The negative terminal of battery is grounded to the machine chassis through master switch.
When the start switch is in the OFF position, the current flows from the positive battery terminal as
shown below.
OPERATING FLOWBattery Battery relay Fusible link CN-60(1)
Fuse box(No.11) I/conn CN-1(8) Start switch CS-2(1)
Fuse box(No.12) I/conn CN-2(17) I/conn CN-6(4) Room lamp CL-1(2)
Cassette radio CN-27(7)
Fuse box(No.13) CPU controller CN-53(3)
Fuse box(No.14) I/conn CN-2(3) Flasher unit CR-11(2)
I/conn : Intermediate connector
CHECK POINT
4 -5
Engine Start switch Check point Voltage
OFF OFF
- GND(Battery 1EA)
- GND(Battery 2EA)
- GND(Battery 2EA)
- GND(Fusible link)
10~12.5V
20~25V
20~25V
20~25V
GND : Ground
1)
2)
8/10/2019 Hyundai 130w-3 Electrical
6/49
POWER CIRCUIT
4 -6
FUSE BOX
BATTERY RELAY
MASTER SW
CASSETTE RADIO
START KEY SW
3
4
21
_ + _ +
ROOM LAMP
CPU CONTROLLER
CN-6
CL-1
CN-27
CS-2
CN-60 C
R-1
CN-53
CN-36
CN-1
CN-2
FLASHER UNIT
CR-11
8/10/2019 Hyundai 130w-3 Electrical
7/49
2. STARTING CIRCUIT
OPERATING FLOW
Battery(+) terminal Battery relay(M8, B+ terminal) Fusible link CN-60(1)
Fuse box(No.11) I/conn CN-1(8) Start switch CS-2(1)
When start key switch is in ON positionStart switch ON CS-2(2) I/conn CN-1(7) Battery relay M4 terminal
Battery relay operating(All power is supplied with the electric component)
Start switch ON CS-2(3) I/conn CN-1(6) Fuse box(No.4) I/conn CN-3(5)
Fuel cut-off CN-79(1)
When start key switch is in START position
Start switch START CS-2(5) I/conn CN-1(5) Start safety relay CR-5(2) (4)
I/conn CN-5(2) Start relay CR-23(1)
CHECK POINT
4 -7
(1)
(2)
Engine Start switch Check point Voltage
OPERATING START
- GND(Battery)
- GND(Start key)
- GND(Battery relay M4)
- GND(Start B+)
- GND(Start M)
- GND(Start relay)
- GND(Battery relay M8)
20~25V
GND : Ground
2)
1)
8/10/2019 Hyundai 130w-3 Electrical
8/49
STARTING CIRCUIT
4 -8
MASTER SW BATTRY
CPU CONTROLLER
FUEL CUT OFF
1
7
3
_ + _ +
CN-51
CN-79
CN-60
DO-1
CR-1
FUSE BOXCN-36
CN-3
START KEY SW
STARTER
START RY
ALTERNATOR
5
CR-23
CN-45
M
CN-74
4
CN-5
CN-7
CN-8
6
START SAFETY RY
CR-5
CN
-1
CN-2
MULTI-FUCTION SW
CS-13
DO-3
DO-2
CS-2
2
8/10/2019 Hyundai 130w-3 Electrical
9/49
3. CHARGING CIRCUIT
When the starter is activated and the engine is started, the operator releases the key switch to the ON
position.
Charging current generated by operating alternator flows into the battery through the Battery
relay(CR-1).
The current also flows from alternator to each electrical component and controller through the fuse
box.
OPERATING FLOW
Warning flow
Alternator "I" terminal I/conn CN-5(4) CPU Alternator power level CN-50(5)
Cluster charging warning lamp
Charging flow
Alternator B+ terminal Battery relay(M8) Battery(+) terminal
CHECK POINT
4 -9
2)
(1)
(2)
Engine Start switch Check point Voltage
RUN ON
- GND(Battery voltage)
- GND(Battery relay)
- GND(Alternator B terminal)
- GND(Alternator I terminal)
20~30V
GND : Ground
1)
8/10/2019 Hyundai 130w-3 Electrical
10/49
CHARGING CIRCUIT
4-10
CPU CONTROLLER
STARTER
START RY
ALTERNATOR
CLUSTER
43
CN-9
CN-56
CR-23
CN-51
CN-45
CN-74
MASTER SW B
ATTRY
1
2_ + _ +
CN-60 C
R-1
DO-3
M
FUSE BOXCN-36
CN-5
CN-50
5
CN-1
8/10/2019 Hyundai 130w-3 Electrical
11/49
4-11
4. HEAD LIGHT AND CLEARANCE LAMP CIRCUIT
OPERATING FLOW
Fuse box(No.6) I/conn CN-1(4) Main light switch CS-21(4)
l/conn CS-12(1) RH multifunction switch(lG)
passing function operating by RH multifunction
up and down.
Main light switch ON : 1st step
Main light switch ON CS-21(5) Switch indicator lamp ON CS-21(9)
I/conn CN-2(12)
Cluster illumination lamp ON CN-52(4)
Fuse box(No.19) LH clearance lamp ON
Rear : CL-15(1), Front : CL24(1)
Fuse box(No.20) RH clearance lamp ON
Rear : CL-16(1), Front : CL25(1)Number plate lamp ON CL-21(2)
Main light switch ON : 2nd step
Main light switch ON CS-21(2) I/conn CS-12(2) or
RH multifunction switch : Lo
I/conn CS-12(4) Head light low beam ON CL-3(1), CL-4(1)
RH multifunction switch :Hi
I/conn CS-12(6) Head light low beam ON CL-3(2), CL-4(2)
CHECK POINT
(1)
(2)
Engine Start switch Check point Voltage
STOP ON
- GND(Fuse box)
- GND(Switch power input)
- GND(Switch power output)
- GND(Switch power output)
- GND(Switch power input)
- GND(Head lamp)
- GND(Clearance lamp)
- GND(Numberplate lamp)
20~25V
GND : Ground
2)
1)
8/10/2019 Hyundai 130w-3 Electrical
12/49
4-12
HEAD LIGHT AND CLEARANCE LAMP CIRCUIT
4
MAIN LIGHT SW
FUSE BOXCN-36
CN-1
MULTI-FUNCTION SW
CN-2
HEAD LAMP
CL-3
HEAD LAMP
CL-4
FRONT COMBI RH
REAR COMBI RH
REAR COMBI LH
CL-25
CL-16
CL-15
FRONT COMBI LH
CL-24
NUMBERPLATE LAMP
CL-21
CS-21
CS-12
1
2
3 5
6
7
8
CLUSTER
CN-52
7
8/10/2019 Hyundai 130w-3 Electrical
13/49
4-13
5. WORK LAMP CIRCUIT
OPERATING FLOW
Fuse box(No.9) I/conn CN-1(23) Work light switch CS-36(5)
Work light switch CS-36(6)
When work light switch ON
Work light switch ON CS-36(1), (2) I/conn CN-1(24) Cluster work lamp ON CN-52(8)
I/conn CN-10(2)
Work light ON CL-5(2), CL-6(2)
Switch indicator lamp ON CS-36(9)
CHECK POINT
Engine Start switch Check point Voltage
STOP ON
- GND(Fuse box)
- GND(Switch power output)
- GND(Switch power input)
- GND(Cluster work lamp)
- GND(Work lamp)
20~25V
GND : Ground
2)
1)
8/10/2019 Hyundai 130w-3 Electrical
14/49
4-14
WORK LAMP CIRCUIT
FUSE BOXCN-36
CN-1
WORK LAMP SWITCH
CN-10 CL-6
CL-5
WORK LAMP
CLUSTER WORK LAMP
CS-36
CN
-52
1
3
2
4
5
5
8/10/2019 Hyundai 130w-3 Electrical
15/49
4-15
6. BEACON LAMP CIRCUIT
OPERATING FLOW
Fuse box(No.8) I/conn CN-1(30) Beacon lamp switch CS-23(2)
When Lamp switch ON
Beacon lamp switch ON CS-23(6) Switch indicator lamp ON CS-23(9)I/conn CN-6(6) I/conn CN-14(3)
Beacon lamp ON CL-7
CHECK POINT
Engine Start switch Check point Voltage
STOP ON
- GND(Fuse box)
- GND(Switch power input)
- GND(Switch power output) 20~25V
GND : Ground
2)
1)
8/10/2019 Hyundai 130w-3 Electrical
16/49
4-16
BEACON LAMP CIRCUIT
BEACON LAMP
CN-14
CL-7
CN-6
FUSE BOXCN-36CN-1BEACON LAMP SW
CS-23
132
44
8/10/2019 Hyundai 130w-3 Electrical
17/49
4-17
7. WIPER AND WASHER CIRCUIT
OPERATING FLOW
Fuse box CN-36(No.10) Inter wiper relay CR-6(4)
Wiper relay CR-4(2), (4)
Washer tank CN-22(2)I/conn CN-2(14) I/conn CN-6(2) I/conn CN-13(3)
Wiper motor CN-21(3)
Washer switch ON
Washer switch ON CS-11(2) (1) I/conn CN-2(8)
Inter wiper relay CR-6(1) (3) I/conn CN-2(5)
Wiper switch CN-11(7) (5),(6) I/conn CN-2(9)
Wiper relay CR-4(6) (1) I/conn CN-2(13)
I/conn CN-6(1) I/conn CN-13(1) I/conn CN-21(1)
Wiper motor operatingWasher tank CN-22(2) (1) Washer operating
Wiper switch ON : INT Position
Wiper switch ON CS-11(2) (4) I/conn CN-2(2) Inter wiper relay CR-6(6) (4),
CR-6(4) (3) ON/OFF I/conn CN-2(5) Wiper switch CS-11(7) (5)
I/conn CN-2(9) Wiper relay CR-4(6) (1) I/conn CN-2(13)
I/conn CN-6(1) I/conn CN-13(1) I/conn CN-21(1)
Wiper motor intermittently operating
Wiper switch ON : Low and Hi Position
Wiper switch ON CS-11(2) (5) or (6) I/conn CN-2(9) Wiper relay CR-4(6) (1)I/conn CN-2(13) Wiper switch CN-6(1) I/conn CN-13(1)
I/conn CN-21(1) Wiper motor operating
Auto-parking(When switch OFF)
Wiper motor CN-21(1) OFF Fuse box CN-36(No.10) I/conn CN-2(14)
I/conn CN-6(2) I/conn CN-13(3) Wiper motor CN-21(3) (4)
Wiper motor stop
CHECK POINT
1)
2)
(1)
(2)
(3)
(4)
Engine Start switch Check point Voltage
STOP ON
- GND(Fuse box)
- GND(INT wiper relay)
- GND(INT wiper RY washer output)
- GND(INT wiper RY INT power output)
- GND(INT wiper RY power input)
- GND(INT power RY INT output)
- GND(Relay power input)
- GND(Relay coil)
- GND(Relay output)
- GND(Wiper power input)
- GND(Wiper motor)
20~25V
GND : Ground
8/10/2019 Hyundai 130w-3 Electrical
18/49
4-18
WIPER AND WASHER CIRCUIT
CN-2
MULTI-FUNCTION SW
CS-11
WASHER TANK
WIPER RELAY
INTER WIPER RELAY
WIPER MOTOR
CN-21 CN-13
CN-6
FUSE BOXCN-36
CR-6
CR-4
CN-22
1
4
5
10
10
3
29
6
7
8
1011
8/10/2019 Hyundai 130w-3 Electrical
19/49
4-19
CONTROLLER CIRCUIT
CPU CONTROLLER
CN-53
CN-52
CN-51
CN-50
FUSE BOXCN-36
CN-47
CN-76
CN-3
CD-17
TACHO SENSOR
DC MOTOR
CS-7
CN-75
RESISTOR
PROLIX SW
EPPR VALVE
8/10/2019 Hyundai 130w-3 Electrical
20/49
4-20
BREAKER SW
PEDAL
CS-26
CS-27
SAFETY SW
CS-4
ARM HALF SW
CS-50
CS-25
DZR/OUTRIGGER SELECT SW
CS-29
POWER MAX
CS-67
QUICK COUPLING SW
MULTI-FUNCTION SW
CS-13
CN-1
CN-2
SAFETY SOL REV SOL FWD SOL
ARM HALF
SOLENOID
DOZER
O/RIGGER
SOL
CN-68
CN-123
CN-122
CN-89
CN-72
CN-36
FUSE BOX
CN-53
POWER MAX
CN-88
TRAVEL
CN-70
CN-15
ELECTRIC CIRCUIT FOR HYDRAULIC
8/10/2019 Hyundai 130w-3 Electrical
21/49
4-21
h
HOUR METER
CPU CONTROLLER
CN-1
CN-2
CN-48
CLUSTER
CN-9 CN-56CN-36
FUSE BOX
CN-53
CN-51
CN-50
WATER LEVEL
CD-16
MONITORING CIRCUIT
8/10/2019 Hyundai 130w-3 Electrical
22/49
4-22
CN-2
CPU CONTROL
CN-1
CN
-36
FUSE BOX
CN-53
CN-51
HAZARD SW
PARKING SW
RAMLOCK SW
CS-18
CS-17
CS-41
CS-15
MULTI-FUCTION SW
CS-12
WARNING INDICATOR
CN-64
CN-63
RAM LOCK PARKING
WORKING BRAKE
CD-38
CN-69
CN-71
INDICATOR CIRCUIT
8/10/2019 Hyundai 130w-3 Electrical
23/49
4-23
GROUP 3 ELECTRICAL COMPONENT SPECIFICATION
Part name Symbol Specifications Check
Battery
Battery relay
Fusible link
Start key
Pressure switch
(Auto idle, T/M,
Brake)
12V 100Ah
(2EA)
Rated load : 24V100A(Continuity)
1000A(30sec)
24V 60A
B-BR : 24V 1A
B-ACC : 24V 10A
B-ST : 24V 40A
10kg/cm2
(N.C TYPE)
Check specific gravity
1.280 over : Over charged
1.280 ~ 1.250 : Normal
1.250 below : Recharging
Check coil resistance(M4 to M4)
Normal : About 50
Check contact
Normal :
Check disconnection
Normal : About 0
(For terminal 1-ring term,
terminal 2-ring term)
Check contact
OFF : (For each terminal)
ON : 0(For terminal 1-3, 1-2)
START : 0(For terminal 1-5)
Check contact
Normal : 0.1
CR-1
CN-60
123456
1
65 32 4C ST ACC BR H
HO
B
O,
CS-2
CD-6CD-7
Pa
CD-3CD-5
8/10/2019 Hyundai 130w-3 Electrical
24/49
4-24
Pressure switch(For stop lamp)
Pressure switch(For engine oil)
Coolanttemperature
sensor
Coolant levelsensor
Fuel sender
Tacho sensor
4~6kg/cm
2
(N. O TYPE)
0.5kg/cm2
(N. C TYPE)
24V 0.5A
Check contact
Normal
Check resistance
Normal : 0
Check resistance
50C : 800
80C : 310
100C: 180
Check contact
High level :
Low level : 0
Check resistanceFull : 1005/ 6 : 2004/ 6 : 3003/ 6 : 400
2/ 6 : 5001/ 6 : 600Empty warning : 700
Check resistance
Normal : 300(For terminal 1-2)
CD-4
Pa
CD-18
Pa
1
2
CD-8
C
CD-16
CD-2
CD-17
Part name Symbol Specifications Check
8/10/2019 Hyundai 130w-3 Electrical
25/49
4-25
Relay
Accel actuator
Solenoid valve
EPPR valve
Resistor
Speaker
24V 20A
24V 1A
700mA
50
20W
Check resistance
Normal : About 200
(For terminal 1-3)
(For terminal 2-4)
Check resistance
Normal : 1~2(For terminal 5-6)
0.8~1.2k
(For terminal 1-3)
Check resistance
Normal : 15~25
(For terminal 1-2)
Check resistance
Normal : 15~25
(For terminal 1-2)
Check resistance
Normal : 45~55
Check resistance
Normal : 3~5
CR-5CR-2
AC RY2AC RY1
1
2
3
4
5
6
P+
SIG
P-
NC
M+
M-
2
1 3
5 6M
CN-76
CN-68CN-66 CN-88
CN-89
CN-123CN-72 CN-122
CN-75
CN-47
Part name Symbol Specifications Check
CN-23(LH)CN-24(RH)
CR-2 CR-5
8/10/2019 Hyundai 130w-3 Electrical
26/49
4-26
Switch(Locking type)
Prolix switch
Switch(Locking type)
Switch(Non-locking type)
Work lamp,
Room lamp,
Numberplate
lamp
Beacon lamp
24V 8A
24V 15A
24V 8A
24V 8A
24V 70W(H3 Type)24V 10W
(Room lamp)
24V 70W
(H1 Type)
Check contact
Normal
ON : 0(For terminal 1-5, 2-6)
(For terminal 5-7, 6-8)
OFF : (For terminal 1-5, 2-6)
0(For terminal 5-7, 6-8)
Check contact
Normal : 0(For terminal 1-5, 2-6)
Emergency
ON : 0(For terminal 1-2, 4-5)
(For terminal 2-3, 5-6)
OFF :(For terminal 1-2, 4-5)
0(For terminal 2-3, 5-6)
Check contact
ON : 0(For terminal 1-5, 2-4)
OFF :(For terminal 1-5, 2-4)
Check resistance
Normal : 1.0
ON : 0(For terminal 1-5, 2-6)
(For terminal 5-7, 6-8)
OFF :(For terminal 1-5, 2-6)
0(For terminal 5-7, 6-8)
Check disconnection
Normal : A few
Check disconnection
Normal : A few
CS-18 CS-23 CS-25CS-27 CS-36 CS-41
CS-7
CS-21
CS-22
CL-1 CL-5CL-6 CL-21
Part name Symbol Specifications Check
CL-7
CS-17,CS-18,CS-23,CS-25,CS-27,CS-36,CS-41,CS-50,CS-54,CS-67
8/10/2019 Hyundai 130w-3 Electrical
27/49
4-27
Fuel filler pump
Hour meter
Horn
Safety switch
Receiver dryer
Cassette radio
24V 10A35/min
16~32V
DC 22~28V2A
24V 15A
24V 2.5A
24V 2A
Check operation
Supply power(24V) to
terminal 1 pin
Connect ring terminal with
ground and turn the operation
switch ON.
Check operation
Supply power(24V) to
terminal No.2 and connect
terminal No.1 to ground.
Check operation
Supply power(24V) to each
terminal and connect ground.
Check contactNormal : 0(For terminal 1-2)
(For terminal 1-3)
Operating : (For terminal 1-2)
0(For terminal 1-3)
Check contact
Normal :
Check resistance
Power on
15W+15W, 4+4
(For terminal 1-6, 4-8)
20~25V
(For terminal 7-GND, 2-GND)
CN-61
CN-48
CN-20 CN-25
CS-4
Pa
CN-29
CN-27
Part name Symbol Specifications Check
8/10/2019 Hyundai 130w-3 Electrical
28/49
4-28
Washer pump
Wiper motor
Relay
Intermittent
wiper relay
Cigar lighter
Ether
24V 3.8A
24V 2A
24~32V 16A
20~30V 5A
24V 5A 1.4W
24V 15A
Check contact
Normal : 10.7(For terminal 1-2)
Check disconnection
Normal : 10.5(For terminal 1-2)
Washer spray
: 0.2(For terminal 1-4)
Wiper operating
: 24V(For terminal 1-4)
: 0V(For terminal 2-GND)
Check resistance
Normal : About 200
(For terminal 2-6)
: 0(For terminal 1-3)
: (For terminal 1-4)
Check contact
Normal : 0(For terminal 1-3)
Check coil resistance
Normal : About 1M
Check contact
Normal : Operating time : 5~15sec
Check contact
Normal : 1.1
CN-22
M
CN-21
CR-4 CR-16 CR-17CR-34 CR-36
CR-6
CL-2
Part name Symbol Specifications Check
CN-78
8/10/2019 Hyundai 130w-3 Electrical
29/49
4-29
Hydraulic
temperature
Alternator
Starter
Back buzzer
Fuel cut-off
Aircon
compressor
-
24V 55A
DELCO REMY28MT 24V
24V 0.5A
24V 25W
24V 79W
Check resistance
50C : 800
80C : 310100C : 180
120C : 100
Check contact
Normal : 0(For terminal B+-)
Normal : 24~27.5V
Check contact
Normal : 0.1
Check contact
Normal : 5.2
Check resistance
Normal : 15~25
Check contact
Normal : 13.4
1
2C
CD-1
CN-74
CN-45
CN-65
3
2
1
E
S
I
CN-28
Part name Symbol Specifications Check
CN-79
8/10/2019 Hyundai 130w-3 Electrical
30/49
4-30
Start relay
Blower
Aircon resistor
Mode actuator&
Temp actuator
Intake actuator
Thermostat
24V 300A
24V 9A
24~28V
9~16V300mA max
22V~30V
-
Check contact
Normal : 0.94(For terminal 1-2)
-
Check contact
Normal : 0.9(For terminal 2-4)
: 3.3(For terminal 1-3)
: 5.4(For terminal 1-4)
: 5.7(For terminal 1-2)
-
Check resistance
Normal : 2.0(For terminal 1-2)
Working temperature of contact
Point : AC ON 4.5C
AC OFF 1.5C
Differential of temperatuer 3C
Rated input volt : 24V
CR-23
M
Part name Symbol Specifications Check
8/10/2019 Hyundai 130w-3 Electrical
31/49
4-31
Door switch
Horn switch
Solenoid valve
Flasher unit
Head lamp
Rear combilamp
24V 2W
24V 6A
24V 6A
24V 85C/M
24V 75/70W
24V P27W224V P21/10W
Check resistance
Normal : About 5M
Check contact
Normal : 15M
Check resistance
Normal : 28.9M(For terminal 1-2)
-
Check resistance
Normal : 1.0(For terminal 1-3,2-3)
1.5(For terminal 1-2)
-
Part name Symbol Specifications Check
CS-1
CS-5
CN-67 CN-69
CN-70 CN-71
CR-11
CL-3 CL-4
CL-15 CL-16
TA
TU
NC
EH
BU
ST
1
2
3
4
5
6
8/10/2019 Hyundai 130w-3 Electrical
32/49
4-32
Front combilamp
Pedal switch
Power maxswitch
Blower switch
Diode
24V 21W24V 10W
24V 15A
24V 6A
-
600V, 3A
Check resistance
Normal : 2.1(For terminal 2-3)4.8(For terminal 1-2)
Check resistance
Normal ON : 0(For terminal)
Check contact
Normal : 15M
Check resistance
Low : 0(For terminal 1-4)
ML : 0(For terminal 1-5)
MH : 0(For terminal 1-3)
MI : 0(For terminal 1-6)
COM : 0(For terminal 1-2)
-
Part name Symbol Specifications Check
CL-24 CL-25
CS-26
CS-29
CS-17
CN-140
8/10/2019 Hyundai 130w-3 Electrical
33/49
1. CONNECTOR DESTINATION
4-33
GROUP 4 CONNECTORS
Connector
number Type
No. of
pin Destination
Female Male
Destination
CN-1
CN-2
CN-3
CN-4
CN-5
CN-6
CN-7
CN-9
CN-10CN-14
CN-15
CN-18
CN-19
CN-20
CN-21
CN-22
CN-23
CN-24
CN-25
CN-27
CN-28
CN-29
CN-30
CN-33
CN-36
CN-45
CN-47
CN-48
CN-50
CN-51
CN-52
CN-53
CN-56
CN-60
CN-61
CN-63
CN-64CN-65
DEUTSEH
DEUTSCH
KET
KET
DEUTSCH
KET
KET
KET
KETCN
KET
AMP J TYPE
AMP J TYPE
MOLEX
CN
KET
AMP
AMP
MOLEX
PA
PACKARD
KET
AMP
AMP J TYPE
SWP
RING-TERM
AMP
KET
T&B
T&B
T&B
T&B
ML
KET
AMP
AMP
AMPAMP
31
31
8
6
6
8
1
6
24
2
3
3
2
4
2
1
1
2
9
2
2
13
3
20
-
2
2
24
18
10
18
16
2
1
7
71
I/conn(Frame harness-main harness)
I/conn(Frame harness-main harness)
I/conn(Frame harness-engine RR)
I/conn(Frame harness-pump PX)
I/conn(Frame harness-engine FR)
I/conn(Cab harness-main harness)
I/conn(Frame harness-main harness)
I/conn(Cabin harness-main harness)
I/conn(Boom harness-frame harness)I/conn(Cabin harness-beacon harness)
Quick coupling
Pump 1 pressure switch
Pump 2 pressure switch
Horn
Wiper motor
Washer tank
Speaker(LH)
Speaker(RH)
Horn
Cassette & radio
Compressor
Receiver dryer
Aircon controller
Pump 3 pressure switch
Fuse box
Start motor B+
Resistor
Hour meter
CPU & controller
CPU & controller
CPU & controller
CPU & controller
Cluster
Fusible link
Fuel filter pump
Warning indicator
Warning indicatorBack buzzer
HD36-24-31SN
HD36-24-31SN
S814-008001
S814-006001
DT06-6S-E003
S814-008001
MG610278
S814-006001
MG640188-4S810-004202
S814-002001
S816-103002
S816-103002
35215-0200
S810-004202
MG640605
S822-014000
S822-014000
35215-0020
S811-009003
0297 3407
ST730135-2
S811-013002
S816-103002
21L7-00250
S820-410000
S810-002202
ST730135-2
102251-24
102241-18
102200-10
102241-18
DT04-4P-E003
-
S822-015000
S811-014000
S811-007002S822-014000
HD34-24-31PN
HD34-24-31PN
S814-108001
S814-106001
DT04-6P-E003
S814-108001
S814-101001
S814-106001
MG610574-
S814-102001
S816-003002
S816-003002
-
-
-
S822-114000
S822-114000
-
-
-
-
-
S816-003002
-
-
-
-
-
-
-
-
-
S813-130201
-
S811-114000
S811-107002-
8/10/2019 Hyundai 130w-3 Electrical
34/49
4-34
Connectornumber
Type No. of
pin Destination
Female Male
Destination
CN-66
CN-68
CN-69CN-70
CN-70
CN-72
CN-74L
CN-74B
CN-75
CN-76
CN-78
CN-79CN-88
CN-89
CN-91
CN-92
CN-122
CN-123
CN-140
CN-141
RelayCR-1
CR-2
CR-4
CR-5
CR-6
CR-11
CR-23
CR-30
SwitchCS-1
CS-2
CS-4
CS-5
CS-7
CS-11
CS-12
CS-13
CS-15CS-17
KET
KET
AMPAMP
AMP
AMP
RING-TERM
RING-TERM
AMP
DEUTSCH
AMP
PACKARDKET
KET
AMP
KET
KET
KET
KET
AMP J TYPE
RING-TERM
AMP
AMP
AMP
AMP
CN
KET
AMP
KET
KET
AMP
AMP
KET
KET
KET
KET
KETSWF
2
2
22
2
2
-
-
2
6
1
12
2
8
12
2
2
2
3
-
4
6
4
6
3
2
4
1
6
3
1
6
8
8
12
1210
Breaker solenoid
Safety solenoid
Ramlock solenoidTravel solenoid
Parking solenoid
Dozer/Outrigger solenoid
Alternator "B+" terminal
Alternator "B+" terminal
EPPR valve
DC motor
Ether
Fuel cut-off solenoidPower max
Arm half flow solenoid
AC EVA assembly
AC EVA assembly
Forward solenoid
Reverse solenoid
Quick coupling
Pump 2 pressure switch
Battery relay
Horn relay
Wiper relay
Start safety relay
Intermittent wiper relay
Flasher unit
Start relay
Back up relay
Door switch
Start key switch
Safety switch
Horn switch
Prolix switch
Multifunction switch(Wiper side)
Multifunction switch(RH lever side)
Multifunction switch(LH lever side)
Multifunction switchWorking, traveling, parking switch
S814-002001
S814-002001
S822-015000S822-015000
S822-05000
S816-002001
S820-104000
S820-406000
S816-002002
DT06-6S-E003
S822-014000
S818-020311S814-002001
S814-002001
S810-008202
S814-012001
S814-002001
S814-002001
S814-002001
S816-103002
S820-104000
S810-004202
S810-006202
S810-004202
S810-006202
S810-003702
-
S810-004202
S822-004202
S814-006001
S810-003202
S822-014000
S814-006001
S814-008001
S814-008001
S814-012001
S814-012001593757
S814-102001
S814-102001
S822-115000S822-115000
-
S816-102001
-
-
-
-
-
-S814-102001
S814-102001
-
-
S814-102001
S814-102001
-
S816-103002
-
-
-
-
-
-
S814-102001
-
-
-
-
-
S814-106001
S814-108001
S814-108001
S814-112001
S814-112001-
8/10/2019 Hyundai 130w-3 Electrical
35/49
4-35
Connectornumber
Type No. of
pin Destination
Female Male
Destination
CS-18
CS-21
CS-22CS-23
CS-25
CS-26
CS-27
CS-29
CS-36
CS-41
CS-50
CS-54
CS-58
CS-67
Light
CL-1
CL-2
CL-3
CL-4
CL-5
CL-6
CL-7
CL-15
CL-16
CL-21
CL-24
CL-25
CD-1
CD-2
CD-3CD-4
CD-5
CD-6
CD-7
CD-8
CD-16
CD-17
CD-18
CD-38
SWF
SWF
SWFSWF
SWF
AMP
SWF
AMP
SWF
SWF
SWF
SWF
AMP
SWF
KET
AMP
HMC
HMC
KET
KET
-
KET
KET
KET
KET
KET
AMP
KET
KETKET
KET
KET
KET
KET
KET
PACKARD
RING-TERM
KET
10
10
1010
10
1
10
1
10
10
10
10
6
10
2
1
3
3
2
2
1
6
6
2
3
3
2
2
11
2
2
2
2
2
2
1
1
Ramlock switch
Main light switch
Cold start switchBeacon switch
Dozer/Outrigger switch
Pedal switch
Breaker switch
Power max switch
Work lamp switch
Hazard switch
Arm half control switch
Aircon switch
Blower switch
Quick coupling switch
Room lamp
Cigar lighter
Head lamp
Head lamp
Work lamp
Work lamp
Beacon lamp
Rear combination lamp(RH)
Rear combination lamp(LH)
Numberplate lamp
Front combination lamp(LH)
Front combination lamp(RH)
Hydraulic oil temp sender
Fuel sender
Brake fail pressure switchStop lamp pressure switch
Transmission oil pressure switch
Auto idle pressure switch
Auto idle pressure switch
Water temp sender
Water level sensor
Speed sensor
Engine oil pressure switch
Working brake pressure switch
573757
593757
593757593757
593757
S822-014000
593757
S822-014000
593757
593757
593757
593757
S810-006202
593757
MG 610392
S822-014000
S810-003702
S810-003702
S814-002000
S814-002000
S822-014000
S814-006001
S814-006001
S814-002001
S814-003001
S814-003001
85202-1
S814-002001
ST730135-2ST 730135-2
MG 640795
MG 640795
MG 640795
85202-1
MG 610320
-
-
ST730135-2
-
-
--
-
S822-114000
-
S822-114000
-
-
-
-
-
-
-
S822-114000
-
-
S814-102000
S814-102000
S822-114000
S814-106001
S814-106001
S814-102001
S814-103001
S814-103001
-
-
--
-
-
-
-
-
S818-120221
S820-104000
-
Sensor, sender
8/10/2019 Hyundai 130w-3 Electrical
36/49
4-36
No. ofpin
Receptacle connector(Female) Plug connector(Male)
1
1
S813-030100
1
S813-130100
2
1 2
S813-030200
1 2
S813-130200
2. CONNECTION TABLE FOR CONNECTORS
58-L TYPE CONNECTOR1)
8/10/2019 Hyundai 130w-3 Electrical
37/49
4-37
No. ofpin
Receptacle connector(Female) Plug connector(Male)
20 1
11
10
20
S817-020105
MULTILOCK TYPE CONNECTOR2)
8/10/2019 Hyundai 130w-3 Electrical
38/49
4-38
No. ofpin Receptacle connector(Female) Plug connector(Male)
5
2 5
1 3
S811-005002
1 3
2 5
S811-105002
3 7
1 4
S811-007002
1 4
3 7
S811-107002
1 5
4 9
3S811-109002
5 11
1 6
S811-011002
1 6
5 11
S811-111002
7
9
11
PA TYPE CONNECTOR3)
4 9
1 5
S811-009002
8/10/2019 Hyundai 130w-3 Electrical
39/49
4-39
No. ofpin
Receptacle connector(Female) Plug connector(Male)
13
6 13
1 7
S811-013002
17
21
1 7
6 13
S811-113002
8 17
1 9
S811-017002
1 9
8 17
S811-117002
10 21
1 11
S811-021002
1 11
10 21
S811-121002
8/10/2019 Hyundai 130w-3 Electrical
40/49
4-40
No. ofpin
Receptacle connector(Female) Plug connector(Male)
1
2
3
4
1 1
2
1
1
2
2
1 3
1 3
2
2 4
1 3
1 3
2 4
S813-060100 S813-160100
S813-060200 S813-160200
S813-060300 S813-160300
S813-060400 S813-160400
58-X TYPE CONNECTOR4)
8/10/2019 Hyundai 130w-3 Electrical
41/49
4-41
No. ofpin
Receptacle connector(Female) Plug connector(Male)
2
3
4
8
1
2 2
1
2
3 1
3 1
2
3 1
4 2
4 2
3 1
6 3 1
8 5 2
8 5 2
6 3 1
S816-002001 S816-102001
S816-003001 S816-103001
S816-004001 S816-104001
S816-008001 S816-108001
J TYPE CONNECTOR5)
8/10/2019 Hyundai 130w-3 Electrical
42/49
4-42
No. ofpin
Receptacle connector(Female) Plug connector(Male)
1
1
S814-001000
2
3
4
1
S814-101000
2
1
1
2
S814-002000 S814-102000
3
2 1
1
2 3
S814-003000 S814-103000
2 4
1 3
1 3
2 4
S814-004000 S814-104000
SWP TYPE CONNECTOR6)
8/10/2019 Hyundai 130w-3 Electrical
43/49
4-43
No. ofpin Receptacle connector(Female) Plug connector(Male)
6
8
12
14
3 6
1 4
1 4
3 6
S814-006000 S814-106000
4 8
1 5
1 5
4 8
S814-008000 S814-108000
4 12
1 9
1 9
4 12
S814-012000 S814-112000
3 14
1 11
1 11
3 14
S814-014000 S814-114000
8/10/2019 Hyundai 130w-3 Electrical
44/49
4-44
No. ofpin
Receptacle connector(Female) Plug connector(Male)
1
1
S810-001202
2
3
4
1
S810-101202
2
1
S810-002202
2
1
S810-102202
3
1 2
S810-003202
2
1 3
S810-103202
2 4
1 3
S810-004202
1
32
4
S810-104202
CN TYPE CONNECTOR7)
8/10/2019 Hyundai 130w-3 Electrical
45/49
4-45
No. ofpin
Receptacle connector(Female) Plug connector(Male)
6
3 6
1 4S810-006202
8
1 4
3 6S810-106202
1 5
4 8
S810-108202
4 8
1 5
S810-008202
8/10/2019 Hyundai 130w-3 Electrical
46/49
4-46
No. ofpin
Receptacle connector(Female) Plug connector(Male)
2
1
2
S812-002001
3
4
6
2
1
S812-102001
1 3
2
S812-003001
1 2
3
S812-103001
2 4
1 3
S812-004001
1 3
2 4
S812-104001
3 6
1 4
S812-006001
1 4
3 6
S812-106001
BS TYPE CONNECTOR8)
8/10/2019 Hyundai 130w-3 Electrical
47/49
4-47
No. ofpin
Receptacle connector(Female) Plug connector(Male)
10
5 10
1 6
S815-010000
12
16
18
6 12
1 7
S815-012000
8 16
1 9
S815-016000
9 18
1 10
S815-018000
LC TYPE CONNECTOR9)
8/10/2019 Hyundai 130w-3 Electrical
48/49
4-48
No. ofpin
Receptacle connector(Female) Plug connector(Male)
24
12 24
1 13S815-024000
8/10/2019 Hyundai 130w-3 Electrical
49/49
No. ofpin
Receptacle connector(Female) Plug connector(Male)
2
1 2
S810-002402
1 2
S810-102402
375 FASTEN TYPE CONNECTOR10)