Post on 21-Nov-2021
Mr A N Other12 Camping LaneHappyland
CriS Number XXXXXXXXXXXX-CCCCCCCCC
Make of Van BAILEY UNICORN
Model BARCELONA
Year 2014
Service Record 100343
Location of Van As Above
Location Post Code XXXXXXX
Service Required Full Service
Work Complete Kevin Williams Date Completed 05/12/2015Please note all comments and recommendations noted on service schedule
Any gas appliance identified as NOT SAFE TO USE must NOT BE USED until repaired or replaced
CARAVAN SERVICE SCHEDULEAND INSPECTION RECORD
SERVICE SHEETSLAYOUT, SCHEDULE AND WCS LOGO COPYRIGHT OF WCS
It is STRONGLY ADVISED that customers recheck the tightness of wheel nuts before all journeys and again afterthe first 30 miles to prevent possible loss of road wheel
Approved warranty, service agent and installer
cms-northwales@hotmail.co.ukwww.cms-northwales.co.uk
Methven29 Lon PendyffrynLLanddulasNorth WalesLL22 8JQ0149251261207800565449
CARAVAN & MOTORHOME SERVICINGMembership No: 1570
AcoP LPG Gas reg no 43744
Safe Co levels
Gas safety check in accordance with BS5482-1:2005, LPGA's TM83and IGE-UP-1B edition 3 (with amendments 2012) also NCC memorandum No 83 2005
LET BY TEST PASS3030
SAFE TO USE YES
PROPANE OK BUTANE
HOSE AND PIG TAILS
GAS COMPARTMENT
CYLINDER SECURITY
TIGHTNESS TEST 1
N/A
GAS SYSTEMS SAFE TO USE Kevin Williams
1. No securing strap fitted to Gas Bottle. Recommend a new strap is fitted.2. No LPG Sticker on gas compartment. New sticker applied.
F/L = flueless R/S = room sealed V/C = visual check N/C = not checked N/A = not applicable
Please note all comments and recommendations noted on service scheduleAny gas appliance identified as NOT SAFE TO USE must NOT BE USED until repaired or replaced
TIGHTNESS TEST 2
REGULATOR
GAS SAFETY INSPECTION RECORD
APPLIANCE FUNCTION CHECKS
DEFECTS / REMEDIAL ACTION / NOTES
Date
COOKER
FRIDGE
WATERHEATER
FIRE
MAKEMODEL
OPERATINGPRESSURE
FLUETYPE
FLUETERMINATION
FLUECONDITION
FLAMECHECK
SAFETYDEVICE
SAFETO USE
THETFORD FL N /A N/A PASS PASS YES
DOMETIC RS PASS PASS PASS PASS YES
TRUMA RS PASS PASS PASS PASS YES
TRUMA RS PASS PASS PASS PASS YES
YES
Customer present or advised YES
LOCK UP PRESSURE 45 mb
mb
mb
VENTILATION
2014GAS HOSE DATE
OK = Checked, OK no fault found. OK* = Action taken / Advice. X = Defect, Fault found requires Attention /Action
CARBON MONOXIDE BACKGROUND LIVING AREA READING
OPERATING PRESSURE30 MB
PRESSURE LOSS 0 mb
30 MB
30 MB
30 MB
30 MB
05/12/2015
Safe Co levels
OKOKOKX
LPG STICKER XOK
FURNITURE AND FIXINGS
WINDOWS SEALS AND BLINDS
ROOF VENTS / SKY LIGHTS
MAIN DOOR AND FLY SCREEN / BLIND
EXTERIOR LOCKS CHECKED AND OILED OK
TOILET CASSETTE SEAL CHECKED AND LUBRICATED OK
SMOKE ALARM AND Co ALARM CHECK OK*
GRAB HANDLE CONDITION AND SECURITY OKFLOOR CONDITION OKAWNING RAILS, ROOF AND BODYWORK OK
WATER FILTER CHANGE OK*
WATER SYSTEM AND TAPS OK
CHECKED
LIVING / HABITATION / ELECTRICAL / WATER
1. Smoke alarm missing its battery. New battery installed, smoke alarm now working.2. New water filter required. New filter supplied and installed after obtaining agreement with customer.
Comments / Recommendations
Please note all comments and recommendations noted on service schedule
240 VOLT SUPPLY AND RCD TEST240 VOLT APPLIANCES AND SOCKETS
240 VOLT EARTH BONDING
12 VOLT WATER PUMP12 VOLT AND MANUAL TOILET PUMP
12 VOLT LIGHTS
12 VOLT SYSTEMS
BATTERY CONDITIONBATTERY CHARGING RATE
OK
OKOK
OK
OK
OK
OK
OK
OK13.7
(not certified)
(not certified)
OK = Checked, OK no fault found. OK* = Action taken / Advice, see comments box for details.X = Defect, Fault found requires Attention /Action
(not certified)
BATTERY DISCHARGE TEST OK
Volts
AIR CONDITIONING N/A
FIRE EXTINGUISHER AND BLANKET OK
WATER TANK AND FITTINGS N/A
FIXED VENTILATION INCLUDING VERMIN GUARDS
OKOK
OK
OK
OK
8
DAMP INGRESS SURVEY
FRONT CHECKED REAR
AROUND WINDOWSROOF LEVEL
FLOOR LEVELNEARSIDE
OFFSIDE
N
N
N
N
AROUND WINDOWSROOF LEVEL
FLOOR LEVELNEARSIDE
OFFSIDE
N
N
N
N
N
AROUND WINDOWSROOF LEVEL
FLOOR LEVEL
FRONT
REAR
N
N
N
N
N
OFFSIDEAROUND WINDOWSROOF LEVEL
FLOOR LEVEL
FRONT
REAR
N
N
N
N
N
NEARSIDE
AROUND DOOR N
SHOWER AREATOILET AREA
BATHROOM SINKKITCHEN SINK
N
N
N
N
FRONT SKYLIGHT
REAR SKYLIGHTBATHROOM SKYLIGHT
N
N
N
1. No damp found, all readings within Normal range between 1-15%.
Please note all comments and recommendations noted on service schedule
Comments / Recommendations
NKITCHEN SKYLIGHT
AVERAGE BACKGROUND LIVING AREA DAMP READING 8 %
Damp readings N = 1-15% Normal. M = 15 - 20% Monitor. I = 20% and above Water Ingress.30% and above Structural damage may be occurring and deterioration inevitable. Due to construction,
fitted appliances and stored items some areas can only be visually inspected for damp ingress
See damp readings on next page
N
CHECKED
Damp drawings are not to scale and are for illustration purposes onlyDue to construction, appliances and stored items a visual inspection of these areas
might be performed if probing or scanning is not possible due to limited access
CHASSIS INSPECTION
CHASSIS CONDITION OK
CORNER STEADIES GREASED AND CHECKED OK
HAND BRAKE OPERATION GREASED AND CHECKED OK
JOCKEY WHEEL GREASED AND CHECKED OK
COUPLING HEAD GREASED AND CHECKED OK
HUB ASSEMBLY GREASED AND CHECKED
OK
BRAKE ASSEMBLY GREASED AND CHECKED
OK
BRAKE PAD / SHOE CONDITION
OK
OK
BRAKE AWAY CABLE CONDITION
ROAD TYRE CONDITION AND AGE Tyre Date 2013 OK
CHECKED
SPARE TYRE CONDITION
WHEEL NUTS CHECKED AND TORQUED
OK
OK
4mm
1. Ball acting stabiliser friction pads worn passed there limit. New friction pads required. Caravan should not be taken onthe highway until new friction pads are installed. Customer informed.
Work Complete Kevin Williams Date Completed
Comments / Recommendations
It is STRONGLY ADVISED that customers recheck the tightness of wheel nuts before all journeys and again afterthe first 30 miles to prevent possible loss of road wheel
I confirm that all wheel nuts and hub nuts have been TORQUED correctly and rechecked for tightness
7 / 13 PIN PLUG CONNECTOR TO CARROAD LIGHTS AND REFLECTORSCHARGING, FRIDGE AND INTERNAL LIGHTSELECTRONIC STABILITY SYSTEM
OKOKOKOK
OKSUSPENSION AND AXLE CONDITION
05/12/2015
Nut Torque 130nm alloy
Thickness
NOSE WEIGHT CHECK OK
COUPLING HEAD GAITER CHECKED OK
BALL ACTING STABILISER CHECKED X
BRAKE ROD AND CABLES CONDITION OK
657
657
658
Front Rear SpareDepth MMPressure PSI
CHASSIS BOLTS AND FIXINGS OK
Please note all comments and recommendations noted on service schedule
Any gas appliance identified as NOT SAFE TO USE must NOT BE USED until repaired orr e p l a c e d
CARBON MONOXIDE. Do not use any disposable barbecue or portable gas appliances within the caravan,motorhome or awning. As part of a gas safety check, background Carbon Monoxide is monitored and recordedon the service report. The monitoring is performed with all room sealed gas appliances running.
If you suspect a gas appliance has developed a fault immediately turn off appliance, close the appliance isolationvalve and close the gas bottle control valve. Ventilate the caravan / motor home by opening windows, roof lightsa n d d o o r s . D O N O T r e - l i g h t o r u s e s u s p e c t e d f a u l t y a p p l i a n c e .
As soon as possible contact CMS on 01492512612/07800565449 for assistance and advice. Please leave amessage on the answer phone clearly stating your name, contact phone number, location and nature of gase m e r g e n c y .
It is STRONGLY ADVISED that customers recheck the tightness of wheel nuts before all journeys and again aftert h e f i r s t 3 0 m i l e s t o p r e v e n t p o s s i b l e l o s s o f r o a d w h e e l .
Tyre pressures should be checked before all journeys. Tyre pressures can be found in your owners manual.
Whilst every effort has been made by CMS in the service / inspection of your Caravan / Motor home to ensureyou have a trouble free year, the service / inspection is only valid on the day of the service and does not implyany warranty, guarantee, or life expectancy of the caravan / motor home or appliances and fittings. Damp ingressinspection and report is done to the best of my ability, CMS will not be held liable for any omissions ors u b s e q u e n t f i n d i n g s n o t i d e n t i f i e d i n t h e d a m p i n g r e s s r e p o r t .
Caravans and Motorhomes under manufactures warranty. It is not the responsibility of CMS to seek approvelfrom the dealer or manufacturer of your caravan or motorhome before undertaking any service or repairs. CMSwill always advise the customer to satisfy themselves that their warranty will not be effected by any worku n d e r t a k e n b y C M S a n d f o r t h e m t o c o n t a c t t h e i r d e a l e r f o r a d v i c e .
T h e a i m o f C a r av a n & M o t o r h o m e S e r v i c e s i s y o u r t o t a l s a t i s f a c t i o n .
For additional advice and information visit our web site at: www.cms-northwales.co.uk
OK = Checked, OK no fault found. OK* = Action taken / Advice, see comments box for details.X = Defect, Fault found requires Attention /Action
IMPORTANT INFORMATION and ADVICE
SERVICE SHEETSLAYOUT, SCHEDULE AND WCS LOGO COPYRIGHT OF WCS
If you require any further advice or assistance please contact Kevin on01492512612 / 07800565449 (24 hr answer machine)
Damp readings N = 1-15% Normal. M = 15 - 20% Monitor. I = 20% and above Water Ingress.30% and above Structural damage may be occurring and deterioration inevitable
Damp drawings are not to scale and are for illustration purposes onlyDue to construction, appliances and stored items a visual inspection of these areas might be performed
if probing or scanning is not possible due to limited access
Dear
Thank you for choosing CMS for your servicing. If you have any questionsabout the service schedule or report please contact me on 01492512612 and Iwill help with your enquiry.
Your next service will be due on
We will contact you about one month before this date to see if it's convenient.If you would like to be contacted by email please send an email tocms-northwales@hotmail.co.uk and quote your reference number
Thanking you again for your custom. Kevin Williams
CMS can offer a range of services, as well as maintenance and repair, from acomprehensively stocked service vehicle.
Services:Touring Caravan Service and repairsMotor home Habitation Service and repairsPart Services i.e. gas safety checkCaravan Motor movers supplied and fittedSanitation of water systemsAlde central heating systemsShower tray repairs
Approved warranty, service agent and installer
logon to www.approvedworkshops.co.uk and complete the online Customer Satisfaction Survey
I will come to you at home, on site, or in storage
Mr A N Other Reference number 100343
Stockists of: Gas Regulators, Leisure Batteries, Water Pumps, Water Filters,Taps. Etc
01/12/2016
CARAVAN & MOTORHOME SERVICING
www.cms-northwales.co.uk
AcoP LPG Gas reg no 43744